2008 Ducati Monster 696 Owners Manual

2008 Ducati Monster 696 Manual

Get 2008 Ducati Monster 696 PDF manuals and user guides View all 2008 Ducati Monster 696 manuals

2008 Ducati Monster 696 manual content summary:

  • 2008 Ducati Monster 696 | Owners Manual - Page 1
    Use and maintenance manual E 696 1
  • 2008 Ducati Monster 696 | Owners Manual - Page 2
    E 2
  • 2008 Ducati Monster 696 | Owners Manual - Page 3
    the instructions in this manual, especially service for all Ducati owners and enthusiasts for any advice and suggestions you might need. Notes Ducati Motor Holding S.p.A. cannot accept any liability for errors that may have occurred in the preparation of this manual. All information in this manual
  • 2008 Ducati Monster 696 | Owners Manual - Page 4
    Table of contents Front brake lever 50 Rear brake pedal 51 Gearchange pedal 51 Adjusting the position of the gearchange and rear brake pedals 52 Main components and devices 53 E General indications 6 Warranty 6 Symbols 6 Useful road safety information 7 Riding with a full load 8 Identification
  • 2008 Ducati Monster 696 | Owners Manual - Page 5
    Adjusting the throttle cable 70 Charging and maintenance of the battery during winter storage 70 Removal of the battery 71 Refitting the battery 79 Tensioning the drive chain 88 Lubricating the drive chain 89 Replacing bulbs 90 Headlight aim 91 Tyres 93 Checking the engine oil level 95 Cleaning and
  • 2008 Ducati Monster 696 | Owners Manual - Page 6
    , please contact a Ducati Dealer or Authorized Service Centre. You will find the information in the manual useful on trips (which Ducati Motor Holding the warranty is automatically invalidated. Warning Failure to comply with these instructions may put you at risk, and could lead to severe injury
  • 2008 Ducati Monster 696 | Owners Manual - Page 7
    Useful road safety information Warning Read this section before riding your motorcycle. Many accidents are the result of the inexperience of the rider. Always make sure you have your licence with you; you need a valid licence that entitles you to ride a motorcycle. Do not lend your motorcycle to
  • 2008 Ducati Monster 696 | Owners Manual - Page 8
    Riding with a full load Your motorcycle is designed for travelling over long distances with a full load in complete safety. Even weight distribution is critical for maintaining safety standards, and to avoid getting into difficulties when making sudden manoeuvres or riding on bumpy roads. E
  • 2008 Ducati Monster 696 | Owners Manual - Page 9
    Identification data All Ducati motorcycles have two identification numbers, one for the frame (fig. 1) and one for the engine (fig. 2). Frame number Engine number E Notes These numbers indicate the motorcycle model and should be quoted when ordering spare parts. fig. 1 fig. 2 9
  • 2008 Ducati Monster 696 | Owners Manual - Page 10
    Controls 4 1 7 E Warning This section shows the position and function of the controls used to drive the motorcycle. Be sure to read this information carefully before you use the controls. 3 2 6 5 9 Position of the motorcycle controls (fig. 3) 1) 2) 3) 4) 5) 6) 7) 8) 9) Instrument panel. Key-
  • 2008 Ducati Monster 696 | Owners Manual - Page 11
    Instrument panel (fig. 4) 1) LCD (see page 13). 2) Tachometer (rpm). Indicates engine revs per minute. 3) Neutral (N) indicator (green). Illuminates when the gearbox is in neutral. 4) Fuel warning light (yellow). Illuminates when there are approximately 3 litres of fuel left in the tank. 5) Turn
  • 2008 Ducati Monster 696 | Owners Manual - Page 12
    10) 2-position switch A and B. Switch used for displaying and setting instrument panel parameters. It has two positions, A "▲" and B "▼". 11) High beam headlight flasher switch (fig. 5). The high beam headlight flasher switch is also used for the LAP and USB data aquisition functions. 11 A 10 B
  • 2008 Ducati Monster 696 | Owners Manual - Page 13
    LCD - Main functions Warning Any adjustments to the instrument panel must only be carried out when the motorcycle is stationary. Never operate the instrument panel controls while riding the motorcycle. 1) Speedometer. Indicates road speed. 2) Odometer. Shows total distance travelled. 3) Trip meter.
  • 2008 Ducati Monster 696 | Owners Manual - Page 14
    personnel only. If you accidentally access this function, turn the key to OFF and have the motorcycle checked at an authorised Ducati Service Centre. 13) Oil temperature indicator (fig. 6). Important Stop riding if the temperature reaches the maximum value, otherwise the engine might be damaged
  • 2008 Ducati Monster 696 | Owners Manual - Page 15
    LCD - How to set/display parameters At key-on (key turned from OFF to ON) the instrument panel activates all the digits of the LCD for 1 second and switches on the indicator lights in sequence. OFF CHECK 1 E fig. 7 15
  • 2008 Ducati Monster 696 | Owners Manual - Page 16
    It then reverts to "normal" mode and, in place of the motorcycle speed, shows the model and, for 2 seconds, also the version (EU, UK, USA, CND, FRA, JAP). The model is scrolled on the display once only. CHECK 2 E RUN fig. 8 16
  • 2008 Ducati Monster 696 | Owners Manual - Page 17
    At Key-On, the instrument panel always shows the following information (de-activating any previously activated functions): Odometer Speed Engine rpm bargraph Engine oil temperature bargraph. At this point, with switch (1, fig. 9) in position B "▼" it is possible to switch from the odometer display
  • 2008 Ducati Monster 696 | Owners Manual - Page 18
    Total distance travelled indicator (odometer) At Key-On the system automatically enters this function. The reading is saved permanently and cannot be reset under any circumstances. If it exceeds 99999 km (or 99999 miles), the reading "99999" remains displayed permanently. vs. EU E vs. UK vs. USA
  • 2008 Ducati Monster 696 | Owners Manual - Page 19
    "Speed" indicator This function enables display of the motorcycle speed. The dashboard receives actual speed value (expressed in km/h) from the control unit and displays the value increased by 8%. The maximum speed that can be displayed is 299 km/h (186 mph). Over 299 km/h (186 mph) the display will
  • 2008 Ducati Monster 696 | Owners Manual - Page 20
    "TRIP" meter While in this function, if you press switch (1, fig. 9) in position B "▼" for 3 seconds, the reading is reset. If the reading exceeds 999.9, it is reset to zero and the count restarts automatically. vs. EU E vs. UK vs. USA fig. 12 20
  • 2008 Ducati Monster 696 | Owners Manual - Page 21
    "TRIP FUEL" (distance travelled on reserve fuel) indicator When the fuel warning light comes on, the TRIP FUEL meter is activated automatically, regardless of the function displayed. If the fuel level remains in reserve, the reading is saved even after Key-Off. The count stops automatically when the
  • 2008 Ducati Monster 696 | Owners Manual - Page 22
    Air temperature indicator Shows the outside air temperature. Display limits: -39 °C to +124 °C. In the event of a sensor FAULT (-40 °C, +125 °C or disconnected) a series of dashes "- - -" is displayed steadily and the "EOBD engine diagnostics" warning light (8, fig. 4) comes on. vs. EU E vs. UK
  • 2008 Ducati Monster 696 | Owners Manual - Page 23
    Oil temperature indicator This function displays the engine oil temperature. Display indications: - if the temperature is between -40 °C and +80 °C, the display shows "STATUS 2"; - if the temperature is between +81 °C and +110 °C, the display shows "STATUS 3"; - if the temperature is between +111 °C
  • 2008 Ducati Monster 696 | Owners Manual - Page 24
    - if the temperature is between +136 °C and +160 °C, the display shows "STATUS 5"; - if the temperature is between +161 °C and +175 °C, the display shows "STATUS 6"; - if the temperature is between +176 °C and +190 °C, the display shows "STATUS 7"; STATUS 5 E STATUS 6 STATUS 7 fig. 16 24
  • 2008 Ducati Monster 696 | Owners Manual - Page 25
    - if the temperature is between +191 °C and +200 °C, the display shows "STATUS 8"; - if the temperature is ≥ 201 °C the display shows "STATUS 9" with the series of dashes flashing; - in the event of a FAULT with the sensor, the display will flash "STATUS 1". STATUS 8 E STATUS 9 STATUS 1 fig. 17
  • 2008 Ducati Monster 696 | Owners Manual - Page 26
    intervals: after the first 1000 km on the odometer; every 12000 km on the odometer. The service indicator will remain on the display until reset. When the indicator appears, contact your Ducati dealer or Authorized Service Centre. vs. EU KEY-ON (SERV) KEY-ON (SERV) vs. UK vs. USA KEY-ON (SERV
  • 2008 Ducati Monster 696 | Owners Manual - Page 27
    Battery voltage indicator (BATT) To display this function, go into the menu and select the "BATT" page. The battery voltage reading is displayed as follows: if the reading is between 12.1 and 14.9 Volts, it is steadily illuminated on the display; if the reading is between 10.0 and 12.0 Volts or
  • 2008 Ducati Monster 696 | Owners Manual - Page 28
    if the reading is less than or equal to 9.9 Volts, the message "LO" flashes on the display and the "EOBD engine diagnostics" warning light (8, fig. 4) comes on; if the reading is greater than or equal to 16.1 Volts, the message "HI" flashes on the display and the "EOBD engine diagnostics" warning
  • 2008 Ducati Monster 696 | Owners Manual - Page 29
    Adjusting the engine idle speed (rpm) To display the function, access the menu and select the "RPM" page. In addition to the upper rev counter scale, the display also shows engine rpm numerically so that you can adjust the idle speed more precisely. E fig. 21 29
  • 2008 Ducati Monster 696 | Owners Manual - Page 30
    Display backlighting adjustment To adjust the backlighting, enter the menu and select the "LIGHT SET" page. While in this page, press switch B (▼) for 3 seconds to enable adjustment and display the following pages in sequence: E - page 1 - "LIGHT MAX" setting: This page sets backlighting to
  • 2008 Ducati Monster 696 | Owners Manual - Page 31
    LAP time display function To activate this function, go into the menu and set the "LAP" function to "On" by pressing switch (1, fig. 9) in position B "▼" for 3 seconds. START and STOP the timer by pressing the high beam FLASH button (11, fig. 5) on the left-hand handlebar switch. When the LAP
  • 2008 Ducati Monster 696 | Owners Manual - Page 32
    E When you switch the LAP function off from the menu, the lap in progress will notbe saved. If the LAP function is active and the display is suddenly switched off (Key-Off), the LAP function is switched off automatically (even if the timer was ON, the lap in progress is not saved). If the timer is
  • 2008 Ducati Monster 696 | Owners Manual - Page 33
    LAP Memory display Displays the data saved with the LAP function: lap number and time. To display the saved lap times, enter the menu and select the "LAP MEM" page. From this page, if you press switch (1, fig. 9) in position B "▼" for 3 seconds, the data for the first lap will appear. The display
  • 2008 Ducati Monster 696 | Owners Manual - Page 34
    E DDA data acquistion This function serves to activate the DDA (Ducati Data Analyzer): the DDA must be connected to the motorcycle wiring. To activate the DDA, go into the menu and set the "DDA" to "On" by pressing switch (1, fig. 9) in position B "▼" for 3 seconds. START and STOP the lap separator
  • 2008 Ducati Monster 696 | Owners Manual - Page 35
    Erase DDA This function enables you to delete the data saved on the DDA: the DDA must be connected to the motorcycle wiring. To delete the data, enter the menu and select the "Erase DDA" page. If you press the switch (1, fig. 9) in position B "▼" for 3 seconds and the DDA is not acquiring data, the
  • 2008 Ducati Monster 696 | Owners Manual - Page 36
    E Clock setting function To set the clock, enter the menu and select the "SET" page. From this page, if you press switch (1, fig. 9) in position B "▼" for 3 seconds, you enter clock setting mode. On entering this function, the message "AM" flashes on the display; if you press switch (1, fig. 9) in
  • 2008 Ducati Monster 696 | Owners Manual - Page 37
    . In any case, a more detailed diagnosis can be obtained using the Ducati Diagnostic System. Warning Whenever an error is displayed, always contact an authorized Ducati Service Centre. E Battery voltage LOW - HIGH 37
  • 2008 Ducati Monster 696 | Owners Manual - Page 38
    Error message LAMB FUEL Error Lambda sensor and/or Lambda heater Fuel reserve sensor Horizontal and/or vertical cylinder coil Horizontal and/or vertical cylinder injector Starter contactor Injection relay Pickup sensor Speed sensor (if present) Immobilizer (Key missing or antenna disconnected or
  • 2008 Ducati Monster 696 | Owners Manual - Page 39
    Intelligent headlight switch-off This function helps reduce battery use by automatically switching off the headlight. The device is triggered in 3 cases: - in the first case, if you turn the key from OFF to ON and do not start the engine within 60 seconds, the headlight is turned off and will be
  • 2008 Ducati Monster 696 | Owners Manual - Page 40
    tag (1) attached, which shows their identification number. E Notes Your Ducati dealer may ask you to produce your Code Card in order to carry out certain servicing operations. The black keys (B) are the keys for normal use, and are used to: - start the engine; - open the lock on the fuel tank
  • 2008 Ducati Monster 696 | Owners Manual - Page 41
    Warning Keep the keys separately and use only one of the black keys to start the motorcycle. Code card A CODE CARD (fig. 30) is supplied with the keys. This shows the electronic code (A, fig. 31) that must be used if the engine is locked by the immobilizer and consequently does not start when the
  • 2008 Ducati Monster 696 | Owners Manual - Page 42
    Immobilizer override procedure Should the immobilizer become locked, you can perform the "Immobilizer Override" procedure from the instrument panel by entering the respective function as follows: select the "CODE" page from the menu. Notes E This menu should be active only if there is at least
  • 2008 Ducati Monster 696 | Owners Manual - Page 43
    Entering the code: on entering this function, the first digit on the left starts flashing. Switch (1, fig. 9): each time you press the switch in position B "▼", the number increases cyclically in steps of one digit every second. If you press the switch in position A "▲", you can set the second digit
  • 2008 Ducati Monster 696 | Owners Manual - Page 44
    the engine still does not start, try again with the other black key. If the engine still does not start, contact the DUCATI Service network. Duplicate keys If you need additional keys, contact your DUCATI Service Centre with all the keys you have in your possession and your CODE CARD. The Ducati
  • 2008 Ducati Monster 696 | Owners Manual - Page 45
    Ignition switch and steering lock (fig. 33) This is located in front of the fuel tank and has four positions: A) B) C) D) : enables lights and engine operation; : disables lights and engine operation; : the steering is locked; : sidelight and steering lock. B A Notes To move the key to the latter
  • 2008 Ducati Monster 696 | Owners Manual - Page 46
    Left-hand handlebar switch (fig. 34) 1) Dip switch, two-position light selector switch: position = low beam headlight on; position = high beam headlight on. 2) Switch = three-position turn signal: centre position = off; position = left turn; position = right turn. To cancel the indicator, press the
  • 2008 Ducati Monster 696 | Owners Manual - Page 47
    Clutch lever (fig. 35) When the clutch lever (1) is operated, drive from the engine to the gearbox and the rear wheel is disengaged. Correct use of the clutch lever is very important in all riding situations, especially when moving off. Important Using the clutch properly will prolong the life of
  • 2008 Ducati Monster 696 | Owners Manual - Page 48
    Cold start lever (fig. 36) The cold start lever is used to assist starting from cold and to raise the idle speed after starting. The cold start lever should be used while the engine is cold (1 or max. 2 bars lit of engine oil T). The cold start lever should be adjusted while the engine warms up to
  • 2008 Ducati Monster 696 | Owners Manual - Page 49
    Right-hand handlebar switch (fig. 37) 1) Two-position ENGINE STOP switch: position (RUN) = run; position (OFF) = stop engine. 1 Warning This switch is mainly intended for use in emergencies when you need to stop the engine quickly. After stopping the engine, return the switch to the position to
  • 2008 Ducati Monster 696 | Owners Manual - Page 50
    operate the front brake. The system is hydraulically assisted and you only need to pull the lever gently. Warning Before using these controls, read the instructions on page 62. 50
  • 2008 Ducati Monster 696 | Owners Manual - Page 51
    Rear brake pedal (fig. 39) Push down on the pedal (1) with your foot to operate the rear brake. The system is controlled hydraulically. E 1 fig. 39 Gearchange pedal (fig. 40) The gearchange pedal has a central position N, with automatic return, and two directions of movement: downwards = push down
  • 2008 Ducati Monster 696 | Owners Manual - Page 52
    Adjusting the position of the gearchange and rear brake pedals The position of the gearchange and rear brake pedals in relation to the footrests can be adjusted to suit the requirements of the rider. To adjust the position, proceed as follows: restrain the tie-rod (1) and slacken the locknuts (2)
  • 2008 Ducati Monster 696 | Owners Manual - Page 53
    Main components and devices 2 7 E Position on motorcycle (fig. 43) 1) 2) 3) 4) 5) 6) 7) Fuel tank filler cap. Seat lock. Helmet cable pin. Sidestand. Rearview mirrors. Rear shock absorber adjusters. Catalytic converter. 5 4 6 5 1 3 fig. 43 53
  • 2008 Ducati Monster 696 | Owners Manual - Page 54
    Fuel tank filler cap (fig. 44) Opening Raise the cover (1) and insert the key into the lock. Give the key a 1/4 turn clockwise to unlock. Lift the cap. 1 E Closing Close the cap with the key inserted and push it into its seat. Turn the key anticlockwise to the initial position and remove it.
  • 2008 Ducati Monster 696 | Owners Manual - Page 55
    Seat lock and helmet holder Opening Put the key in the lock and turn it clockwise while pushing downwards in the vicinity of the latch to help release the pin. Pull the seat backwards to release it from the front catches. The helmet cable (1) is located at the rear of the compartment under the seat
  • 2008 Ducati Monster 696 | Owners Manual - Page 56
    a gear engaged, pull in the clutch lever (in this case the sidestand must be up). E Warning Do not sit on the motorcycle when it is supported on the sidestand. To raise the sidestand to rest position (horizontal position), tilt the motorcycle to the right and, at the same time, lift the
  • 2008 Ducati Monster 696 | Owners Manual - Page 57
    Rear shock absorber adjusters The shock absorber has external adjusters that enable you to adapt the rear suspension to suit the load conditions. Adjuster (1), located on the left-hand side at the point at which the top of the shock absorber is fixed to the rear sub-frame, controls rebound damping.
  • 2008 Ducati Monster 696 | Owners Manual - Page 58
    Riding the motorcycle E Running-in precautions Max. rpm (fig. 49) Rpm limits to be observed during the running-in period and in normal use: 1) up to 1000 km; 2) from 1000 to 2500 km. 0÷1.000 km 1.000÷2.500 km Up to 1000 km During the first 1000 km keep an eye on the rev counter. The indicator
  • 2008 Ducati Monster 696 | Owners Manual - Page 59
    the running-in period, be careful to stick to the recommended maintenance schedule and periodic service intervals indicated in the warranty booklet. Failure to follow these instructions releases Ducati Motor Holding S.p.A. from any liability whatsoever for any engine damage or shorter engine
  • 2008 Ducati Monster 696 | Owners Manual - Page 60
    Starting the engine Notes Follow the "High ambient temperature" procedure to start the engine when it is already warm. 2) Move the cold start lever to position (B, fig. 52). 3) Make sure that the stop switch (2, fig. 51) is in the RUN position, then press the starter button (3, fig. 51). Warning
  • 2008 Ducati Monster 696 | Owners Manual - Page 61
    Allow the engine to start on its own, without turning the throttle. 2 Notes If the battery is flat, the system automatically disables operation of the starter motor. 4) Move the starter lever towards the vertical position (A) to obtain an idle speed of 1400 to 1500 rpm. Important Do not rev the
  • 2008 Ducati Monster 696 | Owners Manual - Page 62
    Moving off 1) Disengage the clutch by squeezing the control lever. 2) Push down the gearchange lever firmly with the tip of your foot to engage first gear. 3) Raise the engine revs by turning the throttle twistgrip while gradually releasing the clutch lever. The motorcycle will start moving. 4)
  • 2008 Ducati Monster 696 | Owners Manual - Page 63
    Braking Slow down in time, change down to use the engine brake, then apply both brakes. Pull in the clutch lever before the motorcycle comes to a stop to prevent the engine stalling. Warning Use both the brake lever and the brake pedal for effective braking. Using only one of the brakes will give
  • 2008 Ducati Monster 696 | Owners Manual - Page 64
    Stopping the motorcycle Reduce speed, change down and release the throttle twistgrip. Change down to engage first gear and then neutral. Apply the brakes and bring the motorcycle to a complete stop. To switch the engine off, simply turn the key to position (1, fig. 53). 2 1 Important E Do not
  • 2008 Ducati Monster 696 | Owners Manual - Page 65
    Parking Stop and park the motorcycle on the sidestand (see page 56). To prevent theft, turn the handlebar fully left and turn the ignition key to the position (3, fig. 55). If you park in a garage or other indoor area, make sure that there is proper ventilation and that the motorcycle is not near a
  • 2008 Ducati Monster 696 | Owners Manual - Page 66
    Toolkit and accessories (fig. 56) The underseat compartment contains: use and maintenance manual; helmet fastening cable; toolkit for routine maintenance operations and checks. To access the underseat compartment, remove the seat (page 55). The toolkit Contains: - fuse pliers; - 8/
  • 2008 Ducati Monster 696 | Owners Manual - Page 67
    clutch fluid must be topped up and changed at the intervals specified in the routine maintenance table (see Warranty Booklet) by a Ducati Dealer or Authorized Service Centre. fig. 57 Clutch system If there is too much play at the clutch lever and the motorcycle jumps or stops when a gear is engaged
  • 2008 Ducati Monster 696 | Owners Manual - Page 68
    there is excessive play at the brake lever or pedal even though the brake pads are still in good condition, contact a Ducati Dealer or Authorized Service Centre to have the system inspected and any air expelled from the circuit. Checking the brake pads for wear (fig. 58) Front brake The brake
  • 2008 Ducati Monster 696 | Owners Manual - Page 69
    that the inner cable slides smoothly: if you feel any rubbing or catching, have the cable replaced by a Ducati Dealer or Authorized Service Centre. To prevent problems, periodically lubricate the ends of each control cable with SHELL Advance Grease or Retinax LX2. In the case of the throttle cable
  • 2008 Ducati Monster 696 | Owners Manual - Page 70
    In all steering positions, the throttle twistgrip should have about 2 to 4 mm of free travel, measured at the outer edge of the twistgrip housing. Adjust if necessary, using the adjuster (1, fig. 60) located on the twistgrip. ➤ 1 E Charging and maintenance of the battery during winter storage
  • 2008 Ducati Monster 696 | Owners Manual - Page 71
    Removal of the battery Importante For removal of the battery always contact your Ducati dealer or Authorized Service Centre. 3 1 2 Remove the seat (page 55). Unscrew the screws (1) and (2) securing the upper tank cover (3). Unscrew the screws (4) and (5) and recover the nylon washers (7). E 1
  • 2008 Ducati Monster 696 | Owners Manual - Page 72
    Remove the right-hand tank cover (6) releasing the tabs (A) from the corresponding slots (B) in the rear cover. Repeat the above operations to remove the left-hand tank cover. Remove the front tank cover (3). 6 A E B fig. 63 3 fig. 64 72
  • 2008 Ducati Monster 696 | Owners Manual - Page 73
    Unscrew the three retaining screws (9) and release the cover (8). Withdraw the breather hose (10) from the cover (8). 9 E 8 10 fig. 65 8 10 fig. 66 73
  • 2008 Ducati Monster 696 | Owners Manual - Page 74
    Withdraw the hose (10) upwards, leaving it attached to the tank breather and drain hose unions. 10 E fig. 67 74
  • 2008 Ducati Monster 696 | Owners Manual - Page 75
    Working on the right-hand side of the motorcycle, disconnect the wiring connector (11) of the fuel level sensor from the main wiring harness, unscrew the screw (12) securing the side of the tank to the frame and recover the washer (13). E 11 fig. 68 13 12 fig. 69 75
  • 2008 Ducati Monster 696 | Owners Manual - Page 76
    Unscrew the screw (14) and recover the washer (15). Release the fuel pipes from the retaining clips (C). E 14 15 fig. 70 C fig. 71 76
  • 2008 Ducati Monster 696 | Owners Manual - Page 77
    Detach the lambda sensor cable (D) from the tank flange cover. Attenzione Before removing the flange cover (16), make sure the tank is empty and position a rag to collect any spilt fuel. Hold the fuel tank in a raised position and remove the flange cover (16) by unscrewing the nuts (17). E D fig.
  • 2008 Ducati Monster 696 | Owners Manual - Page 78
    Disconnect the quick-release fittings (18) from the flange. Remove the elastic retaining strap (19), remove the caps from the terminals, unscrew the screws (22) on terminal clamps (20) and (21), always starting with the negative terminal, then remove the battery from its seating. 18 E fig. 74 21
  • 2008 Ducati Monster 696 | Owners Manual - Page 79
    Refitting the battery 21 22 Importante To install the battery always contact your Ducati dealer or Authorized Service Centre. Install the battery in the battery support and secure it with the elastic retaining strap (19). 19 E 20 fig. 76 Attenzione Connect the positive lead (20) to the positive
  • 2008 Ducati Monster 696 | Owners Manual - Page 80
    Attenzione If the fuel tank was removed from the motorcycle, refit it by inserting the front pins (E) in corresponding locations in the frame. Importante E To refit the fuel tank always contact your Ducati dealer or Authorized Service Centre. E fig. 77 E fig. 78 80
  • 2008 Ducati Monster 696 | Owners Manual - Page 81
    With the tank raised, reconnect the quick-release fittings (18) to the flange and refit the flange cover (16) tightening the nuts (17) to a torque of 3 Nm ± 0.3%. 18 E fig. 79 16 17 fig. 80 81
  • 2008 Ducati Monster 696 | Owners Manual - Page 82
    Connect the fuel sensor (11) to the main wiring harness. Locate the lambda sensor wire (DE) on the tank flange cover and secure it with a cable tie. E 11 fig. 81 D fig. 82 82
  • 2008 Ducati Monster 696 | Owners Manual - Page 83
    Attach the fuel pipes to the retaining clips (C). Fix the tank to the subframe with the screw (14) and washer (15). Tighten the screw (14) to a torque of 10 Nm ±10%. C E fig. 83 14 15 fig. 84 83
  • 2008 Ducati Monster 696 | Owners Manual - Page 84
    Secure the tank to the frame with the screw (12) and the washer (13). Tighten the screw (12) to a torque of 10 Nm ±10%. Locate the breather/drain hose (10) on the motorcycle and secure it in position by refitting the cover (8). E 13 12 fig. 85 8 84 10 fig. 86
  • 2008 Ducati Monster 696 | Owners Manual - Page 85
    Fit the three screws (9), remembering to fit the longest screw in the lower hole, and tighten to a torque of 10 Nm. Check that the four bushes (F, fig. 88) are installed on the front tank cover (3) with the larger diameter side facing upwards. 9 E 8 10 fig. 87 3 F F fig. 88 85
  • 2008 Ducati Monster 696 | Owners Manual - Page 86
    Locate the front tank cover (3) on the fuel tank. Refit the right-hand tank cover (6), inserting the tabs (A) in the corresponding slots (B) in the rear cover. E 3 fig. 89 6 A B fig. 90 86
  • 2008 Ducati Monster 696 | Owners Manual - Page 87
    Insert the screw (4) complete with the nylon washers (7) and screw (5) in the fuel tank cover (6). Repeat the above operations to refit the left-hand tank cover. Insert the screws (1) and (2) in the front tank cover (3). Tighten the screws (1) to a torque of 0.8 Nm and screwts (2) to a torque of 3
  • 2008 Ducati Monster 696 | Owners Manual - Page 88
    Tensioning the drive chain Turn the rear wheel slowly to find the position at which the chain is at its most taut. With the motorcycle on its sidestand, press with a finger in the centre of the bottom run of the chain and measure the distance between the centres of chain link pins and the aluminium
  • 2008 Ducati Monster 696 | Owners Manual - Page 89
    Lubricating the drive chain The chain fitted on your motorcycle has O-rings to protect its moving parts from dirt, and to hold the lubricant inside. So as not to damage these seals when cleaning the chain, use special solvents and avoid aggressive washing with high-pressure steam cleaners. After
  • 2008 Ducati Monster 696 | Owners Manual - Page 90
    "Electrical system" paragraph on page 110. 2 1 Important E For bulb replacements, contact a Ducati Authorized Service Centre. Turn signals (fig. 95) Loosen the screw (1) and detach the lens (2) from the turn signal support. The bulb has a bayonet-type end fitting: to remove it, push it in and
  • 2008 Ducati Monster 696 | Owners Manual - Page 91
    Headlight aim (fig. 96) To check the headlight aim, place the motorcycle upright with the tyres inflated to the correct pressure and one person sitting astride the motorcycle. The motorcycle should be perfectly vertical, with its longitudinal axis at right angles to a wall or screen at a distance of
  • 2008 Ducati Monster 696 | Owners Manual - Page 92
    To adjust the headlight beam vertically, turn the adjuster screws (1, fig. 97); for horizontal adjustment, turn the adjuster screw (2). 1 E fig. 97 2 fig. 98 92
  • 2008 Ducati Monster 696 | Owners Manual - Page 93
    bumpy roads. Important Do not remove or alter the position of the wheel balancing weights. Notes If tyres need changing, contact a Ducati Dealer or Authorized Service Centre to make sure wheels are removed and refitted correctly. 93
  • 2008 Ducati Monster 696 | Owners Manual - Page 94
    Minimum tread depth Measure the tread depth (S, fig. 99) at the point where the tread is most worn. It should not be less than 2 mm, and in any case not less than the legal limit. S Important E Visually inspect the tyres at regular intervals for cracks and cuts, especially on the side walls, and
  • 2008 Ducati Monster 696 | Owners Manual - Page 95
    To change the engine oil and filters at the intervals specified in the maintenance table in the Warranty Booklet, contact a Ducati dealer or Authorized Service Centre. Oil viscosity SAE 15W-50 The other viscosity values shown in the table can be used if the local average temperature is within the
  • 2008 Ducati Monster 696 | Owners Manual - Page 96
    other colour, or if there are dark deposits, renew the spark plug and describe the condition of the old plug to a Ducati dealer or Authorized Service Centre. Also check the central electrode; if it is worn or glazed, renew the spark plug. Check the electrode gap, which must be 0.7 to 0.8 mm
  • 2008 Ducati Monster 696 | Owners Manual - Page 97
    General cleaning To preserve the original shine on metal surfaces and paintwork, wash and clean your motorcycle at regular intervals depending on the type of use and according to the particular road conditions. Use specific products, where possible biodegradable. Avoid aggressive detergents or
  • 2008 Ducati Monster 696 | Owners Manual - Page 98
    Storing the motorcycle If the motorcycle is to be left unused for a long period, it is advisable to carry out the following operations first: clean the motorcycle; empty the fuel tank by removing the drain plug and gasket; pour a few drops of engine oil into the cylinders through the spark plug
  • 2008 Ducati Monster 696 | Owners Manual - Page 99
    Maintenance E Programmed maintenance plan: operations to be carried out by the dealer km x1000 List of operations with frequency (distance or time interval*) Change the engine oil Change the engine oil filter Clean the engine oil pick-up filter Check the engine oil pressure Check/adjust the valve
  • 2008 Ducati Monster 696 | Owners Manual - Page 100
    km x1000 List of operations with frequency (distance or time interval*) Check throttle body synchronisation and idle speed setting (1) Check the brake and clutch fluid levels miles x1000 Months 1 0.6 6 12 7.5 12 24 15 24 36 22.5 36 48 30 48 60 37.5 60 • E Change the clutch and brake
  • 2008 Ducati Monster 696 | Owners Manual - Page 101
    the motorcycle General cleaning miles x1000 Months 1 0.6 6 12 7.5 12 24 15 24 36 22.5 36 48 30 48 60 37.5 60 • E * Service operation to be carried out in accordance with the specified distance or time intervals (km or months), whichever occurs first. (1) Operation to be
  • 2008 Ducati Monster 696 | Owners Manual - Page 102
    levels Check tyre pressure and wear Check the drive chain tension and lubrication Check the brake pads. If necessary, contact your dealer to renew pads * Service operation to be carried out in accordance with the specified distance or time intervals (km or months), whichever occurs first. 102
  • 2008 Ducati Monster 696 | Owners Manual - Page 103
    Technical data Weights Dry weight in riding order without fuel: 161 kg. Fully laden: 390 kg. Warning Failure to observe weight limits could result in poor handling and impair the performance of your motorcycle, and could result in loss of control. Dimensions (mm) (fig. 102) 784 E 334 1452 2058
  • 2008 Ducati Monster 696 | Owners Manual - Page 104
    Fuel, lubricants and other fluids Fuel tank, including a reserve of 3.5 Sump and filter Front/rear brake and clutch circuits dm3 (litres) Type Unleaded fuel with 95 fuel octane rating (at least) SHELL - Advance Ultra 4 SHELL - Advance Brake DOT 4 SHELL - Advance Contact Cleaner SHELL - Advance Fork
  • 2008 Ducati Monster 696 | Owners Manual - Page 105
    Engine Longitudinal 90º "L" twin cylinder, four-stroke. Bore (mm): 88. Stroke (mm): 57.2. Total displacement cm3: 696. Compression ratio ±0.5:1: 10.7. Max power at crankshaft (95/1/EC) 54.5 kW at 9000 rpm. 62 Nm at 7750 rpm. Timing system Desmodromic with two valves per cylinder, operated by four
  • 2008 Ducati Monster 696 | Owners Manual - Page 106
    after the correct running-in period with the motorcycle properly serviced at the recommended intervals. Fuel system SIEMENS indirect electronic Fuel supply: 95-98 RON. Important E Failure to follow these instructions will release Ducati Motor Holding S.p.A. from any liability for any engine
  • 2008 Ducati Monster 696 | Owners Manual - Page 107
    Brakes Front Type: with drilled steel disc. 2 discs. Disc diameter: 320 mm. Hydraulically operated by a control lever on right handlebar. Braking surface, cm2: 44 per disc. Differential bore brake calipers. Make and type: BREMBO P4.32 K, 4 Piston. Friction material: FERIT I/D 450 FF Master cylinder
  • 2008 Ducati Monster 696 | Owners Manual - Page 108
    information about the special ratios available. Please contact a Ducati Dealer or Authorized Service Centre. E Warning For replacement of the rear sprocket, contact a Ducati Dealer or Authorized Service Centre. Incorrect replacement of this component could seriously endanger rider and passenger
  • 2008 Ducati Monster 696 | Owners Manual - Page 109
    Frame Hybrid trellis frame with chromium-molybdenum coated steel tubes, rear aluminium subframe. Steering angle (on each side): 32°. Steering head angle: 22.8°. Trail mm: 87. Tyres Front Radial tubeless tyre. Size: 120/60-ZR17. Rear Radial tubeless tyre. Size: 160/60-ZR17. E Wheels Light alloy,
  • 2008 Ducati Monster 696 | Owners Manual - Page 110
    Exhaust system Equipped with catalytic converter in compliance with Euro 3 emission regulations. USA model: not catalyzed. Electrical system The main components of the electrical system are: headlight: low beam: H7 (12 V-55 W); main beam: H7 (12 V-55 W); side light: H6 (12 V-6 W). Electrical
  • 2008 Ducati Monster 696 | Owners Manual - Page 111
    Fuses The electrical system components are protected by eight fuses located in the fusebox. Only six of these fuses are connected to the electrical system, the other two are spares. Refer to the table below to identify the circuits protected by the various fuses and their ratings in amps. Key to
  • 2008 Ducati Monster 696 | Owners Manual - Page 112
    A blown fuse can be identified by a broken filament (4, fig. 106). Important To avoid possible short circuits, switch the ignition key to OFF before renewing the fuse. 4 4 E Warning Never use a fuse with a rating other than that specified. Failure to observe this rule may damage the electric
  • 2008 Ducati Monster 696 | Owners Manual - Page 113
    Key to the electrical system/injection system diagram 1) 2) 3) 4) 5) 6) 7) 8) 9) 10) 11) 12) 13) 14) 15) 16) 17) 18) 19) 20) 21) 22) 23) 24) 25) 26) 27) 28) 29) Right-hand handlebar switch Key switch Horizontal cylinder spark plug Vertical cylinder spark plug Starter motor Starter contactor Battery
  • 2008 Ducati Monster 696 | Owners Manual - Page 114
    E Wire colour code B Blue W White V Violet Bk Black Y Yellow R Red Lb Light blue Gr Grey G Green Bn Brown O Orange P Pink Notes The electrical system wiring diagram can be found at the end of this manual. 114
  • 2008 Ducati Monster 696 | Owners Manual - Page 115
    Routine maintenance record km 1000 12000 24000 36000 48000 60000 Name of Ducati Service Mileage Date E 115
  • 2008 Ducati Monster 696 | Owners Manual - Page 116
    E 116
  • 2008 Ducati Monster 696 | Owners Manual - Page 117
    it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Ducati North America. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800-424
  • 2008 Ducati Monster 696 | Owners Manual - Page 118
    if the motorcycle noise has increased significantly through use. Otherwise, the owner may become subject to penalties under state and local ordinances. Problems that may affect motorcycle emissions If you are aware of any of the following symptoms, have the vehicle inspected and repaired by your
  • 2008 Ducati Monster 696 | Owners Manual - Page 119
    Riding safety The points given below are applicable for every day motorcycle use and shoud be carefully observed for safe and effective vehicle operation. A motorcycle does not provide the impact protection of an automobile, so defensive riding in addition to wearing protective apparel is extremely
  • 2008 Ducati Monster 696 | Owners Manual - Page 120
    . Do not smoke or allow open flames or sparks when refuelling or servicing the fuel system. Always close the fuel petcock when the engine is prevent flooding of the throttle body. Do not overfill fuel tank (see instructions page 40). Motorcycle exhaust contains poisonous carbon monoxide gas. Do not
  • 2008 Ducati Monster 696 | Owners Manual - Page 121
    Label location (fig. B) 1 7 8 4 5 (Right Side) E USA 2 (Right Side) 3 6 fig. B 121
  • 2008 Ducati Monster 696 | Owners Manual - Page 122
    1 E USA 2 (Only Canada) 3 4 5 6 7 8 9 122
  • 2008 Ducati Monster 696 | Owners Manual - Page 123
    cap for evaporative emission controlled vehicles; oil filler cap; pressure control valve; fuel/vapor Important In the event of fuel system malfunction, contact Ducati's authorized Service Centres. E USA fig. C 123
  • 2008 Ducati Monster 696 | Owners Manual - Page 124
    which adversely affect performance and/or (5) use in competitive racing or related events. B. Inspections, replacement of parts and other services and adjustments required for routine maintenance. C. Any motorcycle on which odometer mileage has been changed so that actual mileage cannot be
  • 2008 Ducati Monster 696 | Owners Manual - Page 125
    not liable for these parts. The owner is responsible for the performance of all required maintenance. Such maintenance may be performed at a service establishment or by any individual. The warranty period begins on the date the motorcycle is delivered to an ultimate purchaser. Ducati North America
  • 2008 Ducati Monster 696 | Owners Manual - Page 126
    Routine Maintenance Record km 1,000 12,000 24,000 36,000 48,000 60,000 mi 600 7,500 15,000 22,500 30,000 37,500 Ducati Service Name Mileage Date E USA 126
  • 2008 Ducati Monster 696 | Owners Manual - Page 127
    Stampato 06/2008 Cod. 913.7.136.1A Ducati Motor Holding spa via Cavalieri Ducati, 3 40132 Bologna, Italia Tel. +39 051 6413111 Fax +39 051 406580 www.ducati.com
  • 2008 Ducati Monster 696 | Owners Manual - Page 128
    STOP ANT FRIZIONE 30 37 36 Bk V STARTER BW Bk FREE PUSH 1 ENGINE STOP RW RBk OFF RUN 2 MODE TURN O Gr Br L N R OFF PUSH 38 HORN Br BW LO HI DIMMER RB LY OFF PUSH PASSING RB Br 35 FUSES BOX AMP 10 15 15 5 20 5 Wire 109 10/93 110 92 7 10 Wire 54 112 90 115 12 53 R LOCK PARK OFF ON G/Bk G/R
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
  • 99
  • 100
  • 101
  • 102
  • 103
  • 104
  • 105
  • 106
  • 107
  • 108
  • 109
  • 110
  • 111
  • 112
  • 113
  • 114
  • 115
  • 116
  • 117
  • 118
  • 119
  • 120
  • 121
  • 122
  • 123
  • 124
  • 125
  • 126
  • 127
  • 128
1
E
Use and maintenance manual
696