2008 Ducati Monster S4R Testastretta Owners Manual

2008 Ducati Monster S4R Testastretta Manual

Get 2008 Ducati Monster S4R Testastretta PDF manuals and user guides View all 2008 Ducati Monster S4R Testastretta manuals

2008 Ducati Monster S4R Testastretta manual content summary:

  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 1
    Use and maintenance manual E S4R / S4RS 1
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 2
    E 2
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 3
    motorcycle, Ducati Motor Holding s.p.a wishes you an enjoyable ride. As part of our continuous effort to improve our service, we advise you to strictly follow the indications given in this manual, especially as regards running-in. In this way, you can be sure your Ducati motorcycle will continue to
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 4
    Table of contents Gearchange pedal 24 Adjusting the position of the gearchange pedal 25 Adjusting the position of the rear brake pedal 26 Main components and devices 27 E General indications 6 Warranty 6 Symbols 6 Useful road safety information 7 Riding with a full load 8 Identification data 9
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 5
    67 Brakes 75 Transmission 76 Frame 76 Wheels 77 Tyres 77 Suspension 77 Exhaust system 78 Available colours 78 Electrical system 78 E Routine servicing record 82 For United States of America version Only 83 Reporting of safety defects 83 Safety warnings 83 Noise emission warranty 83 Noise and
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 6
    Ducati Dealer or Authorized Service Centre. The information in this manual will help ensure that your riding experience is trouble-free and enjoyable, the warranty will be automatically invalidated. Warning Failure to comply with these instructions may put you at risk, and lead to severe injury or
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 7
    Useful road safety information Warning Read this section before riding your motorcycle. Many accidents are the result of the inexperience of the rider. Always make sure you have your licence with you; you need a valid licence that entitles you to ride a motorcycle. Do not lend your motorcycle to
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 8
    Riding with a full load Your motorcycle is designed for travelling over long distances with a full load in complete safety. Even weight distribution is critical for maintaining safety standards, and to avoid getting into difficulties when making sudden manoeuvres or riding on bumpy roads. E
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 9
    Identification data All Ducati motorcycles have two identification numbers, one for the frame (fig. 1) and one for the engine (fig. 2). Frame number Engine number E Notes These numbers indicate the motorcycle model, and should be quoted when ordering spare parts. fig. 1 fig. 2 9
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 10
    Controls 4 1 7 E 6 Warning This section shows the position and function of the controls used to drive the motorcycle. Be sure to read this information carefully before you use the controls. 3 5 8 2 Position of the motorcycle controls (fig. 3) 1) 2) 3) 4) 5) 6) 7) 8) 9) Instrument panel.
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 11
    Instrument panel (fig. 4.1 and fig. 4.2) 1) High beam warning light (blue). Illuminates when the high beam headlight is on. 2) Turn signal warning light (green). Flashes when a turn signal is on. 3) Low fuel warning light (yellow). Illuminates when there are approximately 3.5 litres of fuel left in
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 12
    E 7) EOBD light (yellow amber). Comes on when the engine is locked. Switches off after a few seconds (normally 1.8 - 2 sec.). 8) Speedometer (km/h). Indicates road speed. a) LCD (1): - Odometer (km). Shows total distance travelled. - Trip meter (km). Shows distance travelled since last reset. -
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 13
    LCD functions When the key is turned from OFF to ON, the instrument panel runs a check on all instruments (pointers, display, lights) (fig. 5 and fig. 6). LCD unit functions (1) By pressing button (B, fig. 6) with the key turned to ON, you can cycle between display of the trip counter and the
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 14
    it will be displayed for 5 seconds each time the ignition is switched on. When the "MAInt" message id displayed, contact an authorised dealer or service centre. Display backlight Press button (B, fig. 6) within 5 seconds after the ignition key is turned to the ON position to adjust the brightness of
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 15
    Automatic headlight switch-off This function helps reduce battery use by automatically switching off the headlight. The device is triggered in two cases: - in the first case, if you turn the key from OFF to ON and do not start the engine, After 60 seconds the headlight will be deactivated and will
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 16
    to reset and re-program other black keys if necessary. E Keys (fig. 7) The owner receives a set of keys, comprising: - 1 key A (RED) The red key is a service tool and is part of the motorcycle's immobilizer system. It contains the code of the immobilizer system and should not be used for normal
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 17
    Notes The three keys have a small tag (1) attached, which shows their identification number. Warning Keep the keys separate, and store the tag (1) and key A in a safe place. It is also advisable to use only one of the black keys to start the motorcycle. E Code card The keys come with a CODE CARD
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 18
    Procedure to override the immobilizer using the throttle twistgrip 1) Turn the key to ON, fully open the throttle and hold it open. The EOBD warning light (7, fig. 4.1) goes off after the pre-set time of 8 seconds. 2) Release the throttle twistgrip as soon as the EOBD light goes off. 3) The EOBD
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 19
    ON again. If the engine still does not start, try using another black key. If the engine still does not start, contact the DUCATI Service network. 3) If the warning light (6, fig. 4.1) keeps flashing, it means that an error signal from the immobilizer system has been cleared (e.g. with the override
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 20
    Ignition switch and steering lock (fig. 10) This is located in front of the fuel tank and has four positions: A) B) C) D) ON: enables lights and engine operation; OFF: disables lights and engine operation; LOCK: the steering is locked; P: sidelight and steering lock. B O PU SH A FF ON C D P I G
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 21
    Left-hand handlebar switch (fig. 11) 1) Dip switch, two-position light selector switch: position = low beam on; position = high beam on. 2) Button = three-position turn signal: centre position = off; position = left turn; position = right turn. To cancel the turn signals, press the control switch
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 22
    Right-hand handlebar switch (fig. 12) 1) ENGINE STOP switch, with two positions: position (RUN) = run; position (OFF) = stop engine. Warning E This switch is mainly intended for use in emergencies when you need to stop the engine quickly. After stopping the engine, return the switch to the
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 23
    (5). Turn the knob clockwise to move the lever away from twistgrip, or counter clockwise to move it closer. 5 4 E Warning Before using these controls, read the instructions on page 44. fig. 13 23
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 24
    Rear brake pedal (fig. 14) Push down on the pedal (1) with your foot to operate the rear brake. The system is controlled hydraulically. Gearchange pedal (fig. 15) E The gearchange pedal has a central position N, with automatic return, and two directions of movement: down = push down on the pedal
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 25
    Adjusting the position of the gearchange pedal (fig. 16) The gear change pedal position relative to the footrest may be adjusted to suit rider preferences. To adjust the position, proceed as follows: Apply a wrench to the flats (2) to hold the tie-rod (1) and loosen the lock nuts (3) and (4). Notes
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 26
    Adjusting the position of the rear brake pedal (fig. 17) The position of the rear brake pedal in relation to the footrests can be adjusted to suit the preferred riding position. To adjust the position of the rear brake pedal, proceed as follows: Loosen the locknut (5). Turn the pedal travel
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 27
    3) 4) 5) 6) 7) 8) 9) 10) 11) 12) Fuel tank filler cap. Seat lock. Helmet cable pin. Passenger grabhandle. Sidestand. Rearview mirrors. Rear shock absorber adjusters. Front fork adjusters. Tank support strut. Seat cover Fuel tank release lever. Catalytic converter. 5 1 8 12 7 2 3 11 9 fig. 18 27
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 28
    Fuel tank filler cap (fig. 19) Opening Raise the cover (1) and insert the key into the lock. Give the key a 1/4 turn clockwise to unlock. Lift the cap. 14 OPEN 0 E Closing Close the cap with the key inserted and push it into its seat. Turn the key anticlockwise to the initial position and remove
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 29
    Seat and helmet holder lock (fig. 20 and fig. 21) Opening Insert the key in the lock and turn it clockwise to release the seat from the frame. Pull the seat backwards to release it from the front catches. The helmet cable (1) is located at the rear of the compartment under the seat (see page 47).
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 30
    a gear engaged, pull in the clutch lever (in this case the sidestand must be up). E Warning Do not sit on the motorcycle when it is supported on the sidestand. To raise the side stand to the rest position (horizontal position), tilt the motorcycle to the right and, at the same time
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 31
    Shock absorber adjusters (fig. 23, fig. 24, fig. 25 and fig. 26) The rear shock absorber has external adjusters that enable you to adjust your motorcycle suspension to suit the load conditions. The adjuster (1 fig. 23 and fig. 25) located on the lower end of the shock absorber near where it is
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 32
    Warning Use a pin wrench to turn the preload adjusting nut. Take special care when turning the nut, to avoid injuring your hand by striking it violently against other parts of the motorcycle if the wrench suddenly slips off the nut while turning. MS4RS E Warning The shock absorber is filled with
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 33
    Front fork adjusters (MS4R) (fig. 27 and fig. 28) The front forks can be adjusted for both rebound damping and compression damping. The settings are adjusted by way of external adjuster screws: 1) (fig. 27) to adjust rebound damping; 2) (fig. 27) to adjust spring preload; 3) (fig. 28) to adjust
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 34
    The STANDARD positions are as follows, from the fully closed position: compression: 1 turn rebound: 11 clicks Spring preload (A, fig. 27): 11 mm To change the spring preload for each fork leg, turn the adjuster (2) with a 22 mm hex spanner. E Important Adjust both fork legs to same setting. 3 fig
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 35
    Front fork adjusters (MS4RS) (fig. 29 - fig. 30) The front forks can be adjusted for both rebound damping and compression damping. The settings are adjusted by way of external adjuster screws: 1) (fig. 29) to adjust rebound damping; 2) (fig. 29) to adjust spring preload; 3) (fig. 30) to adjust
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 36
    Standard settings: compression: rebound: Spring preload (fig. 29): 12 clicks; 10 clicks. 19 mm. To change the spring preload for each fork leg, turn the adjuster (2) with a 22 mm hex spanner. E Important Adjust both fork legs to same setting. 3 fig. 30 36
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 37
    Adjusting the rear ride height (fig. 31-fig. 32fig. 33) The standard ride height setting is the result of tests carried out in a wide variety of conditions by our technical staff. Modifying the frame geometry is a very critical operation, and can be dangerous if carried out by untrained persons.
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 38
    The maximum distance that the UNIBALL end fitting (A) can be unscrewed from the tie-rod body is 5 threads, or 7.5 mm (B). B E A fig. 33 38
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 39
    Throughout the running-in period, be careful to stick to the recommended maintenance schedule and periodic service intervals indicated in the warranty booklet. Failure to follow these instructions will release Ducati Motor Holding S.p.A. from any liability for any engine damage or shortened engine
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 40
    From 1000 to 2500 km At this point, you can ask for more power from the engine, being careful, however, never to exceed: 7,500 rpm. Keeping to the running-in recommendations will ensure longer engine life and reduce the need for overhauls and re-tuning. 0 1000 Km 1000 2500 Km E fig. 34 40
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 41
    the correct position (page 30). E Warning If there are any faults or malfunctions, do not start the motorcycle and contact your DUCATI Dealer or Authorized Service Centre. 41
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 42
    Starting the engine Warning Before starting the engine, familiarise yourself with the controls you will need to use when riding. Never start or run the engine in enclosed space. Exhaust gases are toxic and may lead to loss of consciousness or even death within a short time. 1) Turn the ignition key
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 43
    2) Check that the stop switch (1, fig. 36) is positioned to (RUN), then press the starter button (2). This model features servo-assisted starting. Press and immediately release the start button (2) to use the servo-assisted engine starting function. When you press button (2) the starter motor runs
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 44
    Moving off 1) Disengage the clutch by squeezing the clutch lever. 2) Push down the gearchange lever firmly with the tip of your foot to engage first gear. 3) Raise the engine revs by turning the throttle twistgrip while gradually releasing the clutch lever. The motorcycle will start moving. 4)
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 45
    Stopping the motorcycle (fig. 37) Reduce speed, change down and release the throttle twistgrip. Change down to engage first gear and then neutral. Apply the brakes and bring the motorcycle to a complete stop. To switch the engine off, simply turn the key to OFF. Do not leave the key in the ON
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 46
    Parking (fig. 39) Stop and park the motorcycle on the side stand (see page 30). To avoid theft, turn the handlebar fully left and block it by pushing in the ignition key and turning it to the LOCK position. If you park in a garage or other indoor area, make sure that there is proper ventilation and
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 47
    Toolkit and accessories The following accessories are stowed under the seat: use and maintenance manual; helmet fastening cable; toolkit for routine maintenance operations and checks. To access the compartment, you need to remove the seat (page 29) and remove the
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 48
    the consequent loss of control of the motorcycle. Removing the headlight shell Unscrew and remove the two bolts (1) securing the headlight shell to the headlight support. 2 fig. 42 Notes Be careful not to lose the nuts for the bolts (1) located on the inside of the headlight shell. Remove the
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 49
    less than 5 litres. Remove the seat (page 29), release the catch (1, fig. 43). Lift fuel tank and release service rod (2, fig. 44) from beneath the seat; Rest the tank on the support strut. To replace the tank, perform the above operations in the reverse order. 1 E Warning When lowering the fuel
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 50
    Changing the air filter (fig. 45) The air filter must be changed at the intervals indicated in the "Routine maintenance" schedule (see Warranty Card). To access the airbox, lift the fuel tank as described in (page 49). To remove the filter, unhook the tabs (1) securing the cover on both sides of the
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 51
    Checking coolant level (fig. 47) Check the coolant level in the expansion tank on the righthand side of the motorcycle; it must be between the MAX and MIN marks on the tank. If the level is low, top it up. Unscrew the filler cap (1) and add a mixture consisting of water and antifreeze SHELL Advance
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 52
    the control lever and the motorcycle jumps or stops when a gear is engaged, this indicates air in the system. Contact a Ducati Dealer or Authorized Service Centre to have the system inspected and the air bled from the system. Warning Brake and clutch fluid is harmful to paintwork and plastic parts
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 53
    of the friction material on each pad must be at least 1 mm. MIN E Important Have the brake pads replaced at a Ducati Dealer or Authorized Service Centre. 1 mm fig. 49 Adjusting the throttle cable ➤ ➤ In all steering positions, the throttle twistgrip should have about 2 - 4 mm of free travel
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 54
    that the inner cable slides smoothly: if you feel any rubbing or catching, have the cable replaced by a Ducati Dealer or Authorized Service Centre. To prevent problems, periodically lubricate the ends of each control cable with SHELL Advance Grease or Retinax LX2. In the case of the throttle cable
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 55
    Charging the battery (fig. 52) Before charging the battery, it is best to remove it from the motorcycle. First disconnect the black negative terminal (-), then the red positive terminal (+). Release the retaining clamp (1) and remove the battery. - 1 + Warning The battery produces explosive
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 56
    Checking the chain tension (fig. 53) Move the motorcycle slowly until you find the point at which the upper section of the chain is most taut. Place the motorcycle on its sidestand. Push the chain upwards with a finger in correspondence with the centre of the swingarm (see adhesive label). The
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 57
    wattage as specified in the "Electrical System" for that lighting device at page 78. Headlight (fig. 54) To facilitate access to the headlight for servicing, remove the headlight shell as explained in "Removing the headlight shell" (page 48). To access the headlight bulbs, unscrew the lower screw
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 58
    Fit a new bulb (4, fig. 56). Notes Do not touch the transparent part of the bulb with your fingers, this will darken it and cause a loss of brightness. Insert the tabs on the bulb base into the corresponding slots in the bulb housing to ensure the bulb is correctly positioned; hook the end of the
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 59
    Turn signals (fig. 58) Loosen the screw (1) and detach the lens (2) from the turn signal light. The bulb has a bayonet-type base: to remove it, push it in and turn it counter-clockwise. Push in the new bulb and turn it clockwise until it clicks into place. Refit the lens by inserting the tab (A) in
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 60
    Number plate light (fig. 60) To access the bulb in the number plate light (3), pull the bulb holder out from the light, then pull the bulb out of the holder and renew it. E 3 fig. 60 60
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 61
    Headlight aim (fig. 61) To check the headlight aim, place the motorcycle upright with the tyres inflated to the correct pressure and one person sitting astride the motorcycle. The motorcycle should be perfectly vertical, with its longitudinal axis at right angles to a wall or screen at a distance of
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 62
    bumpy roads. Important Do not remove or alter the position of the wheel balancing weights. Notes If tyres need changing, contact a Ducati Dealer or Authorized Service Centre to make sure wheels are removed and refitted correctly. 62
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 63
    Minimum tread depth Measure the tread depth (S, fig. 63) at the point where the tread is most worn. It should not be less than 2 mm, and in any case not less than the legal limit. Important Visually inspect the tyres at regular intervals for cracks and cuts, especially on the side walls, and bulges
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 64
    Checking the engine oil level (fig. 64) Check the engine oil level through the sight glass (1) on the right-hand crankcase cover. When checking oil level, the motorcycle should be upright and the engine cold. The oil level should be between the marks next to the sight glass. Top up oil level with
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 65
    other colour, or if there are dark deposits, renew the spark plug and describe the condition of the old plug to a Ducati dealer or Authorized Service Centre. Also check the central electrode; if it is worn or glazed, renew the spark plug. Check the electrode gap, which must be: 0,6÷0,7 mm. E fig
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 66
    General cleaning To preserve the original shine on metal surfaces and paintwork, wash and clean your motorcycle at regular intervals depending on the type of use and according to the particular road conditions. Use specific products, where possible biodegradable. Avoid aggressive detergents or
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 67
    through the spark plug bores, then crank the engine by hand a few times to form a protective film of oil on the cylinder inner walls; support the motorcycle on the sidestand; disconnect and remove the battery. If the motorcycle has been left unused for more than a month, the battery should be
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 68
    Maintenance E Programmed maintenance plan: operations to be carried out by the dealer km x1000 List of operations with type of intervention (distance or time interval *) Change the engine oil Change the engine oil filter Clean the engine oil pick-up filter Check the engine oil pressure Check and/or
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 69
    km x1000 List of operations with type of intervention (distance or time interval *) Check throttle body synchronisation and idle speed setting (1) Check the brake and clutch fluid levels Change the clutch and brake fluid Check and adjust the brake and clutch control cables Check/lubricate the
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 70
    Check the front sprocket retaining bolts General lubrication and greasing Check and recharge the battery Road test the motorcycle General cleaning • * Service operation to be carried out in accordance with the specified distance or time intervals (km, miles or months), whichever occurs
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 71
    pressure and wear Check the drive chain tension and lubrication Check the brake pads. If necessary, contact your dealer to renew pads * Service operation to be carried out in accordance with the specified distance or time intervals (km, miles or months), whichever occurs first. 1 0,6 6 E 71
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 72
    Technical data 128 Weights Weights Dry weight: 177 kg. Fully laden: 390 kg. 1440 2121 885 790 Warning Failure to observe weight limits could result in poor handling and impair the performance of your motorcycle, and could result in loss of control. 985 1060 1222 355 Overall dimensions (mm) (
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 73
    Fuel, lubricants and other fluids Fuel tank, including a reserve of 3.5 dm3(litres) Lubrication circuit Front/rear brake and clutch circuits Protection for electrical contacts Front fork Cooling system Type Unleaded fuel with at least 95 octane rating SHELL Advance Ultra 4 SHELL Advance Brake DOT 4
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 74
    Engine Longitudinal 90° "L" twin cylinder, four-stroke. Bore (mm): 100. Stroke (mm): 63,5. Total displacement cm3: 998. Compression ratio: 11,4±0,5:1. Max power at crankshaft (95/1/EC): 88.8 kW - 119 HP at 9,250 rpm. Max torque at crankshaft (95/1/EC): 96,9 Nm (9.9 kgm) at 7,500 rpm. Desmodromic
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 75
    speed in any gear should be reached only after the correct running-in period with the motorcycle properly serviced at the recommended intervals. Important Failure to follow these instructions will release Ducati Motor Holding S.p.A. from any liability for any engine damage or shortened engine life
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 76
    information about the special ratios available. Please contact a Ducati Dealer or Authorized Service Centre. E Warning To replace the rear sprocket, contact a Ducati Dealer or Authorized Service Centre. Incorrect replacement of this component could seriously endanger rider and passenger safety
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 77
    Wheels Five Y-spokes, light-alloy rims. Front Dimensions: MT3.50x17". Rear Dimensions: MT5.50x17". Both wheels have removable axles. Suspension Front Upside-down hydraulic forks. The fork is provided with outer adjuster for rebound, compression, and preload (for inner springs of fork legs).
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 78
    Exhaust system Equipped with catalytic converter in compliance with Euro 3 emission regulations. USA model: not catalyzed. Pearl, code *0040 (PPG); Primer, code 490.019 (PPG) Transparent, code 228.880 (PPG) with red stripe; Red frame with white wheels. Available colours Electrical system The main
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 79
    Fuses The fuse box is located under the fuel tank. To access the fuses, remove the cover (1, fig. 68), which shows the positions and amp ratings of the fuses. The fuse located nearest to the battery protects the electronic regulator. Remove the protective cap (2, fig. 68) to access the fuse. A blown
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 80
    Key to the electrical system / injection system diagram 1) 2) 3) 4) 5) 6) 7) 8) 9) 10) 11) 12) 13) 14) 15) 16) 17) 18) 19) 20) 21) 22) 23) 24) 25) 26) 27) 28) 29) Right-hand handlebar switch Transponder antenna Key switch Fans relay Lights relay Fusebox LH fan RH fan Starter motor Starter contactor
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 81
    COIL) ENGINE ECU INSTRUMENT PANEL Val. 10 A 10 A E 15 A 15 A 20 A 5A 5A 3 4 5 6 7 Notes The electrical system wiring diagram is at the end of this manual. 81
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 82
    Routine servicing record km 1000 Name of Ducati Service Mileage Date E 12000 24000 36000 48000 60000 82
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 83
    it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Ducati North America. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800-424
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 84
    if the motorcycle noise has increased significantly through use. Otherwise, the owner may become subject to penalties under state and local ordinances. Problems that may affect motorcycle emissions If you are aware of any of the following symptoms, have the vehicle inspected and repaired by your
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 85
    Riding safety The points given below are applicable for every day motorcycle use and shoud be carefully observed for safe and effective vehicle operation. A motorcycle does not provide the impact protection of an automobile, so defensive riding in addition to wearing protective apparel is extremely
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 86
    . Do not smoke or allow open flames or sparks when refuelling or servicing the fuel system. Always close the fuel petcock when the engine is prevent flooding of the throttle body. Do not overfill fuel tank (see instructions page 45). Motorcycle exhaust contains poisonous carbon monoxide gas. Do not
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 87
    Label location (fig. B) 1 10 8 2 9 3 4 5 E USA 7 6 87
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 88
    1200 ± 0.12 mm Opening 0.05 ± 0.12 mm VALVE CLEARANCE (in & ex): See Service Manual Closing 0.03 ± 0.12 mm SPARK PLUG: CHAMPION RA4HC SPARK PLUG GAP (mm): 0.5 Ö 0.6 OIL: SAE 20W50 FUEL: Unleaded gasoline INSTRUCTIONS No adjustment No adjustment No adjustment HOT AIR INLET HOLDING Via A.C.Ducati
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 89
    miles), or 5 (five) years from the date of initial retail delivery, whichever first occurs. Important In the event of fuel system malfunction, contact Ducati's authorized Service Centres. E USA CANISTER fig. C 89
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 90
    which adversely affect performance and/or (5) use in competitive racing or related events. B. Inspections, replacement of parts and other services and adjustments required for routine maintenance. C. Any motorcycle on which odometer mileage has been changed so that actual mileage cannot be
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 91
    not liable for these parts. The owner is responsible for the performance of all required maintenance. Such maintenance may be performed at a service establishment or by any individual. The warranty period begins on the date the motorcycle is delivered to an ultimate purchaser. Ducati North America
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 92
    Routine maintenance record Km 1,000 mi 600 7,500 15,000 22,500 30,000 37,500 Ducati Service Name Mileage Date E USA 12,000 24,000 36,000 48,000 60,000 92
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 93
    Stampato 04/2007 Cod. 913.7.134.1A Ducati Motor Holding spa via Cavalieri Ducati, 3 40132 Bologna, Italia www.ducati.com Tel. +39 051 6413111 Fax +39 051 406580
  • 2008 Ducati Monster S4R Testastretta | Owners Manual - Page 94
    1 LIGHTING RY B BBk ON FREE PUSH STARTER BW Bk OFF RUN ENGINE STOP RW RBk 2 LOCK PARK OFF ON 3 W/G 4 B/R 5 O R/Bk R/G O V Bn 6 1 2 7 8 9 R 10 R 14 14 15 Lb WR R GBk GR Y 3 4 5 6 R/Bk Y/R R/Bk W/G R/B 2 1 R/G 2 1 R/G R/Bk R 2 1 B/Bk BK R/O R/G W/B R/Y 11 K A 1 4 3 6 2 5 R/W R O Y
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
1
E
Use and maintenance manual
S4R / S4RS