2001 Ford Expedition Owner Guide 1st Printing
2001 Ford Expedition Manual
2001 Ford Expedition manual content summary:
- 2001 Ford Expedition | Owner Guide 1st Printing - Page 1
Instrumentation Controls and features Seating and safety restraints Starting and driving Starting Driving Roadside emergencies Servicing Maintenance or translation in whole or part is not permitted without written authorization from Ford Motor Company. Ford may change the contents without notice and - 2001 Ford Expedition | Owner Guide 1st Printing - Page 2
Introduction The following warning may be required by California law: CALIFORNIA Proposition 65 Warning WARNING: Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the State of California to cause cancer and birth defects - 2001 Ford Expedition | Owner Guide 1st Printing - Page 3
restraints for more information. Indicates that this Owner Guide contains information on this subject. Please refer to the Index to locate the appropriate section which will provide you more ) of driving, vary speeds frequently. This is recommended to give the moving parts a chance to break in. 3 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 4
at the time of printing. Ford may change the contents without notice and without incurring obligation. EMISSION WARRANTY The New Vehicle Limited Warranty includes Bumper-to-Bumper Coverage, Safety Restraint Coverage, Corrosion Coverage, and 7.3L Power Stroke Diesel Engine Coverage. In addition, your - 2001 Ford Expedition | Owner Guide 1st Printing - Page 5
Your vehicle is not equipped with the Ford Ambulance Preparation Package. Notice to owners of drive your vehicle, please read this Owner's Guide carefully. Your vehicle is not a passenger to operate this vehicle correctly may result in loss of control or an accident. Be sure to read Driving off road - 2001 Ford Expedition | Owner Guide 1st Printing - Page 6
's Guide Fasten Safety Belt Air Bag-Front Air Bag-Side Child Seat Installation Warning Brake System Brake Fluid Non-Petroleum Based Master Lighting Switch Child Seat Child Seat Tether Anchorage Anti-Lock Brake System Traction Control Hazard Warning Flasher Fog Lamps-Front Fuse Compartment - 2001 Ford Expedition | Owner Guide 1st Printing - Page 7
Symbol Engine Oil Engine Coolant Temperature Battery Do Not Open When Hot Avoid Smoking, Flames, or Sparks Explosive Gas Battery Acid Fan Warning Maintain Correct Fluid Level Engine Air Filter Jack MAX MIN Power Steering Fluid Emission System Passenger Compartment Air Filter Check fuel cap 7 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 8
panel dimmer switch (pg. 22) Instrument cluster (pg. 10) Driver air bag (pg. 128) Headlamp control (pg. 21) DOOR AJAR THEFT H 40 60 80 00 20 40 60 km/h RPMX1000 H L H BRAKE CRUISE L F E FUEL DOOR 20 0 MPH SELECT/RESET D 2 P RN D C ON RES SET ACCEL OFF COAST PEDALS Power - 2001 Ford Expedition | Owner Guide 1st Printing - Page 9
PUSH ON CD TAPE EJ TREB BAL FADE RDS MUTE SEEK TUNE SCAN AUTO AM FM REW FF SIDE 1.2 COMP SHUFF 1 2 3 5 6 LO A4WD PANEL A/C OFF PANEL & FLOOR FLOOR FLR & DEF DEF 4H 4L HI MAX A/C COOL WARM 4WD control * (pg. 163) Auxiliary power point (pg. 26) Climate control system (pg - 2001 Ford Expedition | Owner Guide 1st Printing - Page 10
WARNING LIGHTS AND CHIMES DOOR AJAR THEFT H 40 60 80 00 20 40 60 km/h RPMX1000 H L H BRAKE CRUISE 4X4 LOW RANGE L LOW FUEL SERVICE ENGINE SOON 20 0 F E FUEL DOOR MPH SELECT/RESET CK SUSP D 2 P RN D C Low fuel Illuminates as an early reminder of a low fuel condition indicated - 2001 Ford Expedition | Owner Guide 1st Printing - Page 11
your vehicle serviced at the first available opportunity. Under engine misfire conditions, excessive exhaust temperatures could damage the catalytic converter, the fuel system, interior floor coverings or other vehicle components, possibly causing a fire. Air bag readiness Momentarily illuminates - 2001 Ford Expedition | Owner Guide 1st Printing - Page 12
to the ON position ABS to indicate a system check. If the light remains on, continues to flash or fails to illuminate, have the system serviced immediately. With the ABS light on, the anti-lock brake system is disabled and normal braking is still effective unless the brake warning light also remains - 2001 Ford Expedition | Owner Guide 1st Printing - Page 13
remains on, have the system serviced. Refer to SecuriLock passive anti-theft system in the Controls and features chapter. Charging system Illuminates when the ignition is turned to the ON position and the engine is off. The light also illuminates when the battery is not charging properly, requiring - 2001 Ford Expedition | Owner Guide 1st Printing - Page 14
RANGE 4x4 Check air suspension Illuminates momentarily when the CK ignition is turned to the ON position SUSP and the engine is OFF. The light also illuminates when the air suspension switch is turned OFF or the air suspension system requires servicing. For information on the air suspension system - 2001 Ford Expedition | Owner Guide 1st Printing - Page 15
control This light comes on when either the CRUISE COAST/SET or RES/ACCEL controls are pressed. It turns off when the speed control OFF control is pressed, the brake is applied or the ignition is turned to the OFF position. Safety belt warning chime Sounds to remind you to fasten your safety belts - 2001 Ford Expedition | Owner Guide 1st Printing - Page 16
Instrumentation GAUGES DOOR AJAR THEFT H 40 60 80 00 20 40 60 km/h RPMX1000 H L H BRAKE CRUISE 4X4 LOW RANGE L LOW FUEL SERVICE ENGINE SOON 20 0 F E FUEL DOOR MPH SELECT/RESET CK SUSP D 2 P RN D C Fuel gauge Displays approximately how much fuel is in the fuel tank (when the key is in - 2001 Ford Expedition | Owner Guide 1st Printing - Page 17
safely possible, switch off the engine immediately and let the engine cool. Refer to Engine coolant in the Maintenance and care chapter. H C Never remove the coolant reservoir cap while the engine is running or hot. This gauge indicates the temperature of the engine coolant, not the coolant level - 2001 Ford Expedition | Owner Guide 1st Printing - Page 18
the button for three seconds to reset. Tachometer Indicates the engine speed in revolutions per minute. Driving with your tachometer pointer continuously at the top of the scale may damage the engine. D 2 P RN D RPMX1000 Battery voltage gauge This shows the battery voltage when the ignition is in - 2001 Ford Expedition | Owner Guide 1st Printing - Page 19
Add oil if needed (refer to Engine oil in the Maintenance and care chapter). If the oil level is correct, have your vehicle checked at your dealership or by a qualified technician. TRIP COMPUTER (IF EQUIPPED) The trip computer tells you about the condition of your vehicle through a constant monitor - 2001 Ford Expedition | Owner Guide 1st Printing - Page 20
Average fuel economy. The display will indicate the vehicle's average fuel economy in liters/100 km (or miles/gallon) since last reset. • To reset the average fuel economy: 1. Press the MODE control repeatedly until AVG F/ECON is displayed (no other display is resettable). 2. Press the E/M and MODE - 2001 Ford Expedition | Owner Guide 1st Printing - Page 21
and features HEADLAMP CONTROL Rotate the headlamp control to the first position to turn on the parking lamps. Rotate to the second position to on with a reduced output. To activate: • the ignition must be in the ON position and • the headlamp control is in the OFF or Parking lamps position. 21 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 22
not activate with your tail lamps and generally may not provide adequate lighting during these conditions. Failure to activate your headlamps under these conditions may result in a collision. Foglamp control (if equipped) The headlamp control also operates the foglamps. The foglamps can be turned on - 2001 Ford Expedition | Owner Guide 1st Printing - Page 23
and features AUTOLAMP CONTROL The autolamp system provides light sensitive automatic on-off control of A the exterior lights normally controlled by the headlamp control. The autolamp system also keeps the lights on for approximately 20 seconds after the ignition switch is turned to OFF. • To - 2001 Ford Expedition | Owner Guide 1st Printing - Page 24
rear window defroster. The defroster turns off automatically after 10 minutes or when the ignition is turned to the OFF position. To manually turn off the defroster before 10 minutes have passed, push the control again. 4WD CONTROL (IF EQUIPPED) This control operates the 4WD. Refer to the Driving - 2001 Ford Expedition | Owner Guide 1st Printing - Page 25
Controls and features This system is not designed to prevent contact with small system detects obstacles within approximately 1.8 meters (5.9 ft.) of the rear bumper with a decreased coverage area at the outer corners of the bumper, (refer to the figures for approximate zone coverage areas). As you - 2001 Ford Expedition | Owner Guide 1st Printing - Page 26
only. Do not hang any type of accessory or accessory bracket from the plug. Improper use of the power outlet can cause damage not covered by your warranty. The auxiliary power point is located on the instrument panel. Do not plug optional electrical accessories into the cigarette lighter. Use the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 27
outlets are designed for accessory plugs only. Do not hang any type of accessory or accessory bracket from the plug. Improper use of the power outlet can cause damage not covered by your warranty. A second auxiliary power point is located on the lower rear side of the console. The power point is - 2001 Ford Expedition | Owner Guide 1st Printing - Page 28
Controls and features Premium AM/FM Stereo/Cassette (CD Changer Compatible) BASS SEL VOL PUSH ON CD TAPE EJ TREB FADE BAL RDS MUTE SEEK TUNE SCAN AUTO AM FM REW FF SIDE 1.2 COMP SHUFF 1 2 3 4 5 6 Audiophile AM/FM Stereo/Cassette (CD Changer Compatible) BASS SEL VOL PUSH ON CD - 2001 Ford Expedition | Owner Guide 1st Printing - Page 29
level and the ignition is turned off, the volume will come back on at a "nominal" listening level when the ignition switch is turned back on. Speed sensitive volume (if equipped) With this feature, radio volume automatically changes slightly with vehicle speed to compensate for road and wind noise - 2001 Ford Expedition | Owner Guide 1st Printing - Page 30
and begin radio play. Tune adjust The tune control works in radio or CD mode (if equipped). Tune adjust in radio mode to move to the next • Press TUNE frequency down the band (whether or not a listenable station is located there). Hold the control to move through the frequencies quickly. to move - 2001 Ford Expedition | Owner Guide 1st Printing - Page 31
to continue reversing through the discs. to select the next disc in the CD changer. Hold the control • Press to fast-forward through the remaining discs. Seek function The seek function control works in radio, tape or CD mode (if equipped). Seek function in radio mode to find the next • Press - 2001 Ford Expedition | Owner Guide 1st Printing - Page 32
the tape's first side, direction automatically reverses to the opposite side of the tape.) To stop on a particular selection, press the control again. Scan function in CD mode Press the SCAN control to hear a short sampling of all selections on the CD. (The CD scans in a forward direction, wrapping - 2001 Ford Expedition | Owner Guide 1st Printing - Page 33
To deactivate autoset and return to your audio system's manually set memory stations, press the control again. Bass adjust The bass adjust control allows you to increase or decrease the audio system's bass output. Press the BASS control. Use the SEL control to increase or decrease the amount of bass - 2001 Ford Expedition | Owner Guide 1st Printing - Page 34
forward to stop the rewind or fast forward function. • To begin CD play (if equipped with CD changer), ensure that CD TAPE the CDs are loaded. Press the CD control. The first track of the disc will begin playing. After that, CD play will begin where it stopped last. Do not insert any promotional - 2001 Ford Expedition | Owner Guide 1st Printing - Page 35
will automatically reverse when the end of the tape is reached. • In CD mode, pressing the control for less than three seconds results in slow forward action. Pressing the control for more than three seconds results in fast forward action. Tape direction select Press SIDE 1-2 to play the alternate - 2001 Ford Expedition | Owner Guide 1st Printing - Page 36
. Shuffle feature The shuffle feature operates in CD SHUFF mode and plays all tracks on the current disc in random order. If 6 equipped with the CD changer, the shuffle feature continues to the next disc after all tracks are played. Press the SHUFFLE control to start this feature. Random order play - 2001 Ford Expedition | Owner Guide 1st Printing - Page 37
MINS is DSP RDS displayed. Use the SEL control to manually set the time. to increase • Press hours/minutes. to decrease • Press hours/minutes. SEL Digital signal processing (if equipped) The digital signal processing (DSP) feature allows you to change the DSP RDS signal mode to suit your listening - 2001 Ford Expedition | Owner Guide 1st Printing - Page 38
and features Use the SELECT control to change the equalization to the desired mode. SEL Radio data system transmit station ID and program type as desired. Press the RDS control until RDS ON or RDS OFF appears in the display. Use the SEL control to enable (ON) SEL or disable (OFF) the feature. - 2001 Ford Expedition | Owner Guide 1st Printing - Page 39
selections: • Classic • Country • Info • Jazz • Oldies • R&B • Religious • Rock • Soft • Top 40 Show • With RDS activated, press the RDS control until SHOW is displayed. • Use the SEL control to select TYPE (the display shows the program type), NAME (the display shows the call letters of the station - 2001 Ford Expedition | Owner Guide 1st Printing - Page 40
Controls and features Premium AM/FM Stereo/Single CD Radio BASS SEL VOL PUSH ON CD TREB FADE BAL EJ MUTE SCAN SEEK TUNE AUTO RDS AM FM REW FF COMP SHUFF 1 2 3 4 5 6 Your audio system is equipped with selective lighting, a unique lighting strategy. This lighting feature is - 2001 Ford Expedition | Owner Guide 1st Printing - Page 41
maximum setting. With the radio on, press and hold the volume control for five seconds, then press: to increase volume compensation to decrease or shut off the • volume compensation • SEL AM/FM select The AM/FM select control works in radio, tape and CD changer modes (if equipped). AM FM 41 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 42
as jamming may occur. Tune adjust The tune control works in radio or CD changer mode (if equipped). Tune adjust in radio mode to move to the next • Press TUNE frequency down the band (whether or not a listenable station is located there). Hold the control to move through the frequencies quickly. to - 2001 Ford Expedition | Owner Guide 1st Printing - Page 43
has been completed, the first track of the current disc will automatically replay. Scan function The scan function works in radio, CD and CD changer mode (if equipped). SCAN Scan function in radio mode Press the SCAN control to hear a brief sampling of all listenable stations on the frequency - 2001 Ford Expedition | Owner Guide 1st Printing - Page 44
on the frequency band, the remaining memory preset controls will all store the last strong station available. To deactivate autoset and return to your audio system's manually set memory stations, press the AUTO control again. Bass adjust The bass adjust control allows you to increase or decrease the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 45
Speaker sound can be adjusted between the front and rear speakers. BAL SEL FADE Rewind The rewind control works in CD REW mode. 1 • In CD mode, pressing the REW control for less than three seconds results in slow rewind. Pressing the control for more than three seconds results in fast rewind. 45 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 46
passages together for a more consistent listening level. Press the COMP control to activate and deactivate compression adjust. COMP 5 Shuffle feature (if equipped) The shuffle feature operates in CD SHUFF changer mode and plays all tracks on the current disc in random order. 6 The shuffle feature - 2001 Ford Expedition | Owner Guide 1st Printing - Page 47
and individually elect to use RDS technology to transmit station ID and program type as desired. Press the RDS control until RDS ON or RDS OFF appear in the display. Use the SEL control to enable (ON) or disable (OFF) the feature. Once activated, you can choose from the following items: Traffic - 2001 Ford Expedition | Owner Guide 1st Printing - Page 48
R&B • Religious • Rock • Soft • Top 40 Show • With RDS activated, press the RDS control until SHOW is displayed. • Use the SEL control to select TYPE, NAME or NONE. SEL SEL RDS Mute mode Press the control to mute the playing media. Press the control again to return to the playing media. MUTE 48 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 49
to manually set the time. to increase • Press hours/minutes. to decrease • Press hours/minutes. Rear seat controls (if equipped) The Personal Audio System, allows front and middle seat passengers to listen to different media sources (radio, cassette or CD) simultaneously. However, the front and - 2001 Ford Expedition | Owner Guide 1st Printing - Page 50
and features To activate the Personal Audio System, press the speaker/headphone control. Press the MODE control to change audio sources (for headphone mode only). Use the SEEK, VOLUME and MEMORY controls to make adjustments to the playing media. - VOLUME + MODE SEEK MEMORY Adjusting the volume - 2001 Ford Expedition | Owner Guide 1st Printing - Page 51
is enabled. For the Personal Audio System to be enabled, the rear seat controls illuminated in the radio display. must be active and Mode select Push the MODE control to toggle between AM, FM1, FM2, tape, CD or CD changer (if equipped). If in the Personal Audio System mode, SHARED illuminates in the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 52
next selection. previous • In CD mode (if equipped), use the SEEK function to access the next - VOLUME + MODE SEEK MEMORY or previous selection. CD changer (if equipped) Your CD changer is located in the center console. Slide the door to access the CD changer magazine. Press to eject the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 53
up. If you pull too hard on the disc holder, the disc holder may come completely out of the magazine. If this happens, reinsert the disc holder back into the magazine. 3. Insert each CD tray, with the disc loaded, all the way into the CD magazine. 4. Insert the CD magazine into the changer. 53 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 54
. Keep the CD changer door closed. Coins and foreign objects will damage the CD player and void your audio system warranty. Do not insert any promotional (odd shaped or sized) discs, or discs with removable labels into the CD player as jamming may occur. Troubleshooting the CD changer (if equipped - 2001 Ford Expedition | Owner Guide 1st Printing - Page 55
Controls and features Cleaning compact discs Inspect all discs for contamination before playing. If necessary, clean discs only with an approved CD cleaner and wipe from the center out to the edge. Do not use circular motion. CD and CD changer care • Handle discs by their edges only. Never touch the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 56
problems. Static can be caused on AM stations by power lines, electric fences, traffic lights and service Refer to the Warranty Guide for audio system warranty information. If service is necessary, see your dealer or a qualified technician. CLIMATE CONTROL SYSTEM Manual heating and air conditioning - 2001 Ford Expedition | Owner Guide 1st Printing - Page 57
FLOOR. However, the air conditioning will only function if the outside temperature is about 6°C (43°F) or higher. Since the air conditioner removes considerable moisture from the air during operation, it is normal if clear water drips on the ground under the air conditioner drain while the system is - 2001 Ford Expedition | Owner Guide 1st Printing - Page 58
to clear ice or fog from the windshield. If the temperature is about 6°C (43°F) or higher, the air conditioner will automatically dehumidify the air to reduce fogging. Operating tips • In humid weather conditions, place the climate control system in DEF before driving. This will reduce fogging on - 2001 Ford Expedition | Owner Guide 1st Printing - Page 59
warm weather conditions, the air conditioner will perform more efficiently in cooling the vehicle if driven for two or three minutes with the windows open. This will force most of the hot, stale air out of the vehicle. Once the vehicle has been "aired out", operate the climate control system as - 2001 Ford Expedition | Owner Guide 1st Printing - Page 60
unless the fan speed thumbwheel is turned or the steering wheel fan speed control is pressed (if equipped). When in AUTOMATIC and weather conditions require heat, air will be sent to the floor. However, if the engine is not warm enough to provide heat, the fan will be at a low speed and the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 61
MAX A/C and DEF the same time (for one second) to AUTO switch between Fahrenheit and Celsius. The English/Metric (E/M) control on the trip computer and message center (if equipped) will not change temperature display. OFF OUTSIDE TEMP AUTOMATIC MAX A/C VENT PNL • FLR FLOOR FLR • DEF DEF HI LO 61 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 62
LO The air conditioning compressor can operate in all modes except FLOOR and VENT. It will also operate only when required when AUTOMATIC has been selected. However, the air conditioning will only function if the outside temperature is about 6°C (43°F) or higher. Since the air conditioner removes - 2001 Ford Expedition | Owner Guide 1st Printing - Page 63
air through the instrument panel registers. However, the air cannot be cooled below the outside temperature because the air conditioning If the outside air temperature is about 6°C (43°F) or higher, the air conditioner will automatically dehumidify the air to reduce fogging. OFF-Outside air is shut - 2001 Ford Expedition | Owner Guide 1st Printing - Page 64
vehicle is not moving. The readings that you get may not agree with temperatures given on the radio due to differences in vehicle and station locations. Operating tips • In humid weather conditions, place the climate control system in DEF before driving. This will reduce fogging on your windshield - 2001 Ford Expedition | Owner Guide 1st Printing - Page 65
OFF position when the vehicle is parked. This allows the climate control system to be free from contamination of outside pollutants. • If your vehicle has been parked with the windows closed during warm weather conditions, the air conditioner will perform more efficiently in cooling the vehicle if - 2001 Ford Expedition | Owner Guide 1st Printing - Page 66
allow the rear passengers to control the temperature in the rear of the vehicle through a second control panel above the second row, or in the floor console. If your vehicle is equipped with auxiliary A/C controls, they may be located in the floor console, R OO FL L NE PA RM WA F OF AR RE HI - 2001 Ford Expedition | Owner Guide 1st Printing - Page 67
auxiliary A/C-heater control console serves as the main control for the auxiliary climate control system. LO The instrument panel climate controls must be on speed control knob to the desired speed. OFF LO HI Turn the temperature control to the desired temperature. You can get warm or cool air - 2001 Ford Expedition | Owner Guide 1st Printing - Page 68
LOCK, locks the steering wheel, 2 automatic transmission gearshift lever and allows key removal. 1 3. OFF, shuts off the engine and all accessories without locking the steering wheel. 4. ON, all electrical circuits operational. Warning lights illuminated. Key position when driving. 5. START, cranks - 2001 Ford Expedition | Owner Guide 1st Printing - Page 69
are winding, slippery, or unpaved. ON OFF Do not shift the gearshift lever into N (Neutral) with the speed control on. To turn speed control off • Press OFF or • Turn off the vehicle ignition. Once speed control is switched off, the previously programmed set speed will be erased. ON OFF 69 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 70
vary momentarily slower or faster than the set speed. This is normal. Speed control cannot reduce the vehicle speed if it increases above the set speed on a , you may want to shift to the next lower gear or apply the brakes to reduce your vehicle speed. If your vehicle slows down more than 16 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 71
set speed. To set a lower set speed • Press and hold COAST. Release the control when the desired speed is reached or • Press and release COAST to operate the Tap RES SET ACCEL COAST • Depress the brake pedal. When the desired vehicle speed is reached, press SET ACCEL. RES SET ACCEL COAST 71 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 72
and features To disengage speed control • Depress the brake pedal. Disengaging the speed control will not erase the previously programmed set speed. Pressing OFF will erase the previously programmed set speed. ON OFF To return to a previously set speed • - 2001 Ford Expedition | Owner Guide 1st Printing - Page 73
and features Indicator light This light comes on when either the CRUISE SET ACCEL or RES controls are pressed. The vehicle speed must be at or above 48 km/h (30 mph). It turns off when the speed control OFF control is pressed, the brake or clutch is applied, or the ignition is turned to the OFF - 2001 Ford Expedition | Owner Guide 1st Printing - Page 74
wipers. When in this position rotate the control upward for fast intervals and downward for slow wiper/washer controls For rear wiper operation, rotate the rear window wiper and washer control to the washer position. control to either From either position, the control will automatically return to - 2001 Ford Expedition | Owner Guide 1st Printing - Page 75
best fuel economy. The overdrive function allows automatic upshifts and downshifts through all available gears. Deactivating overdrive Press the Transmission Control Switch (TCS) located on the end of OVERDRIVE the gearshift lever. The Transmission Control Indicator Light (TCIL) (the word OFF) will - 2001 Ford Expedition | Owner Guide 1st Printing - Page 76
compartment may be used to secure sunglasses or a similar object. Installing a garage door opener (if equipped) The storage compartment can be converted to accommodate a variety of aftermarket garage door openers: • Place Velcro hook onto back side of aftermarket transmitter opposite of actuator - 2001 Ford Expedition | Owner Guide 1st Printing - Page 77
features One-touch moon roof (if equipped) With trip computer VENT ROOF VENT Without trip computer AUTO ROOF • Press and release the rear portion of the moon roof control to open. • Press and hold (as desired) the front portion of the moon roof control to close. • To halt motion at any point - 2001 Ford Expedition | Owner Guide 1st Printing - Page 78
vehicle in normal conditions. If the compass still appears to be inaccurate, a manual calibration may be temperature display (without trip computer) Outside air temperature The temperature display can be turned off and on by pressing the SELECT control on the overhead console. The temperature - 2001 Ford Expedition | Owner Guide 1st Printing - Page 79
8 9 10 11 15 14 With trip computer 2. Locate the compass module mounted on the center rear view mirror post. 3. Turn ignition to the ON position. 4. Press and hold the RESET button on top of the compass module until the message display in the trip computer shows the current zone setting. 5. Release - 2001 Ford Expedition | Owner Guide 1st Printing - Page 80
voltage lines. For optimum calibration, turn off all electrical accessories (heater/air conditioning, wipers, etc.) and make sure all vehicle doors are shut. 1. Start the vehicle. With trip computer 2. Press and hold the RESET button on the compass module until CAL indicator is displayed in the trip - 2001 Ford Expedition | Owner Guide 1st Printing - Page 81
and features Without trip computer 1. Press and hold the SELECT control until CAL appears in the display (approximately eight seconds) and release. 2. Drive the Power quarter rear windows (if equipped) • With out a moon roof VENT VENT MODE E/M RESET • With a moon roof VENT ROOF VENT 81 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 82
and features Press the portion of the VENT control to open the power rear quarter windows. portion of the VENT control to close the power rear Press the quarter windows. Interior Lamps Map lamps With trip computer VENT ROOF VENT Without trip computer AUTO ROOF To turn on the map lamps, press - 2001 Ford Expedition | Owner Guide 1st Printing - Page 83
switch is held up until the courtesy lamps come on. • any of the remote entry controls are pressed and the ignition is OFF. With the ignition key in the ACC or ON position, the rear dome lamp can be turned ON or OFF by sliding the control. AUTOMATIC DIMMING REAR VIEW MIRRORS (IF EQUIPPED) Your - 2001 Ford Expedition | Owner Guide 1st Printing - Page 84
a convenient way to replace up to three hand-held transmitters with a single built-in device. This feature will learn the radio frequency codes of most current transmitters to operate garage doors, entry gates, security systems, entry door locks, and home or office lighting. When programming your - 2001 Ford Expedition | Owner Guide 1st Printing - Page 85
HomeLink button. Do not release the buttons until step 4 has been completed. Some entry gates and garage door openers may require you to replace step 3 with the procedure in the "Canadian Programing" section. 4. The red light will flash slowly and then rapidly. Release both buttons when the red - 2001 Ford Expedition | Owner Guide 1st Printing - Page 86
light flashes rapidly and then turns solid after two seconds. After completing the "Programming" functions, follow these steps to train a garage door opener with the rolling code feature: 1. Locate the training button on the garage door motor head unit. Refer to the garage door opener manual - 2001 Ford Expedition | Owner Guide 1st Printing - Page 87
training). The 2nd or 3rd press from step 3 will activate the door. The HomeLink Universal Transceiver has now been trained to the receiver. Do NOT release until step 4 has been completed. 2. When the indicator light begins to flash slowly (after 20 seconds), position the hand-held transmitter 5- - 2001 Ford Expedition | Owner Guide 1st Printing - Page 88
Controls and features POWER WINDOWS Press and hold the rocker switches to open and close windows. • Press the top portion of fully. Depress again to stop window operation. One touch down can be deactivated during operation by pushing down on the top part of the driver power window control. AUTO 88 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 89
be opened from the outside when the doors are unlocked. The childproof locks are located on rear edge of each rear door and must be set separately for each door. Setting the lock for one door will not automatically set the lock for both doors. Move lock control up to engage the childproof lock. Move - 2001 Ford Expedition | Owner Guide 1st Printing - Page 90
. MIRRORS L R 2. Move the control in the direction you wish to tilt the mirror. MIRRORS L R 3. Return to the center position to lock mirrors in place. 4. Adjust spotter mirrors (if equipped) manually. Heated outside mirrors (if equipped) Both mirrors are heated automatically to remove ice, mist - 2001 Ford Expedition | Owner Guide 1st Printing - Page 91
Controls and features Signal mirrors (if equipped) When the turn signal is mirrors in carefully when driving through a narrow space, like an automatic car wash. CENTER CONSOLE Your vehicle may be equipped with a variety of console features. These include: • Utility compartment • Cupholders • Coin - 2001 Ford Expedition | Owner Guide 1st Printing - Page 92
brake pedal. To remove the floor mat, reverse the installation procedure. LIFTGATE To open the rear window, turn the liftgate handle to the right. To open the liftgate, turn the liftgate handle to the left. • Do not open the liftgate or liftgate glass in a garage or other DOOR the liftgate door and/ - 2001 Ford Expedition | Owner Guide 1st Printing - Page 93
the engine from being started unless a coded key programmed to your vehicle is used. The SecuriLock passive anti-theft system is not compatible with non-Ford aftermarket remote start systems. Use of these systems may result in vehicle starting problems and a loss of security protection. Automatic - 2001 Ford Expedition | Owner Guide 1st Printing - Page 94
the coded key, but can cause a NO-START condition if they are too close to the key during engine start. If a problem occurs, turn ignition OFF and restart the engine with all other objects on the key ring held away from the ignition key. Check to make sure the coded key is an approved Ford coded key - 2001 Ford Expedition | Owner Guide 1st Printing - Page 95
at least one second). This step will program your new key to a coded key. 6. To program additional new unprogrammed key(s), repeat this procedure from step 1. If successful, the new coded key(s) will start the vehicle's engine and the theft indicator will illuminate for three seconds and then go out - 2001 Ford Expedition | Owner Guide 1st Printing - Page 96
. If there is any potential remote keyless entry problem with your vehicle, ensure ALL key fobs (remote entry transmitters) are brought to the dealership, to aid in troubleshooting. Unlocking the doors Press this control to unlock the driver door. The interior lamps and running board lamps (if - 2001 Ford Expedition | Owner Guide 1st Printing - Page 97
. Replacing the battery The remote transmitter is powered by one coin type three-volt lithium battery CR2032 or equivalent. Typical operating range will allow you to be up to 10 meters (33 feet) away from your vehicle. A decrease in operating range can be caused by: • weather conditions • nearby - 2001 Ford Expedition | Owner Guide 1st Printing - Page 98
Controls and features To replace the battery: 1. Twist a thin coin between the two halves of the transmitter near the key ring. DO NOT TAKE THE FRONT PART OF THE TRANSMITTER APART. 2. Place the positive (+) side of new battery in the same orientation. Refer to the diagram inside the transmitter unit - 2001 Ford Expedition | Owner Guide 1st Printing - Page 99
programming has been completed. Illuminated entry The illuminated entry system will turn on the interior lights when the remote transmitter unlock control is pressed. The illuminated entry system will turn off the interior lights if the ignition switch is turned to the ON position, or if the remote - 2001 Ford Expedition | Owner Guide 1st Printing - Page 100
features The battery save feature will turn off the interior lights 45 minutes after the last door is closed, even if the dimmer control is on. Memory seat/mirrors/adjustable pedal feature (if equipped) The memory feature allows automatic positioning of the driver seat, side mirrors and adjustable - 2001 Ford Expedition | Owner Guide 1st Printing - Page 101
) This feature automatically locks all vehicle doors when: • all doors, liftgate and liftgate window are closed • the engine is running • ignition key to ON. 2. Press the power door unlock control three times. 3. Turn the ignition key from ON to OFF. 4. Press the power door unlock control three - 2001 Ford Expedition | Owner Guide 1st Printing - Page 102
gave you. You can use either code to unlock your vehicle. If a second personal code is entered, the module will erase it in favor of the new code. If you wish to erase your personal code, use the following instructions: 1. Enter factory set code. 2. Press 1/2 control within five seconds of step one - 2001 Ford Expedition | Owner Guide 1st Printing - Page 103
, make sure that the anti-theft system (if equipped) is not armed, ignition is off, and all vehicle doors and liftgate window are closed. 1. Enter 5 digit entry code 2. Press and hold 7/8 control 3. Press and release 3/4 control while holding 7/8 control 4. Release 7/8 control. The horn will chirp - 2001 Ford Expedition | Owner Guide 1st Printing - Page 104
these head restraints is to help limit head motion in the event of a rear collision. To properly adjust your head restraints, lift the head restraint so that it is located directly behind your head or as close to that position as possible. Refer to the following to raise and lower the head - 2001 Ford Expedition | Owner Guide 1st Printing - Page 105
Seating and safety restraints Lift handle to move seat forward or backward. Pull lever up to adjust seatback. 60/40 split bench seat (if equipped) • Lift the release bar to move the seat forward or backward. Ensure the seat is relatched into place. • Pull the seatback handle up to recline the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 106
armrest (if equipped) Push the release control to move the armrest up or down. Using the manual lumbar support Turn the lumbar support control toward the front of vehicle to move the lumbar support forward for more direct support. Turn the lumbar support control toward the rear of vehicle to move - 2001 Ford Expedition | Owner Guide 1st Printing - Page 107
Seating and safety restraints Reclining the seatback can reduce the effectiveness of the seat's safety belt in the event of a collision. The control is located on the outboard side of the seat cushion. Press to raise or lower the front portion of the seat cushion. Press to raise or lower - 2001 Ford Expedition | Owner Guide 1st Printing - Page 108
. The memory seat control is located on the driver door. 1 2 • To program position one, move the driver seat to the desired position using the seat controls. Press the SET control. The SET control indicator light will briefly illuminate. While the light is illuminated, press control 1. • To program - 2001 Ford Expedition | Owner Guide 1st Printing - Page 109
them down. Move front passenger seat forward so that the second row seat head rest clears the front seat. 1. Locate handle below the seat cushion near the bottom of the door side cushion that reads "FOLD FLAT OR RECLINE". 2. Lift the handle and push the seatback toward the front of the vehicle. 109 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 110
occupied or empty. If not latched, the seat may cause injury during a sudden stop. 1. Rotate the closeout panel onto the seatback and press the black control (adjacent to the green control) to lock. 2. Locate and lift the handle that reads "FOLD FLAT OR RECLINE". 3. Pull on the seatback while - 2001 Ford Expedition | Owner Guide 1st Printing - Page 111
Locate the lever at the bottom of the seatback that reads "FOLD FLAT OR RECLINE". Pull the lever upwards to recline the seatback. Third row seat The third row seat is equipped with combination lap and shoulder belts in the outboard seating positions and a manual adjust tongue lap belt in the center - 2001 Ford Expedition | Owner Guide 1st Printing - Page 112
, fully latched position before putting the vehicle in motion. 1. Locate and lift seat control "3RD ROW ENTRY" to release seatback and cushion to flip with the liftgate open: 1. Disengage the lap/shoulder belt from the floor by inserting a key or small screwdriver through the hole in the boot - 2001 Ford Expedition | Owner Guide 1st Printing - Page 113
detachable anchor) to stow the loose seat belt. • Pull the seat release lever located on the lower right side of the seatback while pushing the seatback down into the seat cushion. • The seatback will latch into place. 4. Lift the seat release bar located at the center of the seat near the floor to - 2001 Ford Expedition | Owner Guide 1st Printing - Page 114
of the floor tubs. 2. Guide the positioners around each pin and lower the seat. • When the rear of the seat is 10-13 cm (4-5 in) above the rear pins, let the seat drop. This will ensure that the seat will properly latch into the floor. 3. Locate the seat belt anchor tongue in the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 115
into place. 3. To release the rear floor latches of the 3rd row seat, lift the seat release bar located at the center of the seat near the floor to release the floor latches. 4. Lift back of seat up and hold. 5. Lift latch up and out of floor tub to upright position using the strap on - 2001 Ford Expedition | Owner Guide 1st Printing - Page 116
floor latch. To return seat to seating position: 1. Hold seat and pull support bar from floor latch. 2. Rotate support bar up under seat. 3. Rotate floor latch down into floor tub. 4. including the driver, should always properly wear their safety belts, even when an air bag SRS is provided. 116 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 117
under in the back seat and always properly use appropriate child restraints. Combination lap and shoulder belts 1. Insert the belt tongue into the proper buckle (the buckle closest to the direction the tongue is coming from) until you hear a snap and feel it latch. Make sure the tongue is securely - 2001 Ford Expedition | Owner Guide 1st Printing - Page 118
Seating and safety restraints • Rear seats (if equipped) 2. To unfasten, push the release button and remove the tongue from the buckle. • Front seats • Rear seats (if equipped) 118 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 119
belt length adjustment to your movements and locking in response to vehicle movement. For example, if the driver brakes belt system can also be made to lock manually by quickly pulling on the shoulder belt. Automatic locking mode In this mode, the shoulder belt is automatically pre-locked. The belt - 2001 Ford Expedition | Owner Guide 1st Printing - Page 120
mode. How to disengage the automatic locking mode Ford recommends that all safety belt assemblies and attaching hardware should be inspected by a qualified technician after any collision. Safety belt assemblies not in use during a collision should also be inspected and replaced if either damage or - 2001 Ford Expedition | Owner Guide 1st Printing - Page 121
vehicle is involved in a collision that results in deployment of front air bags and safety belt pretensioners. Refer to the Safety belt maintenance section in this chapter. Failure to replace the safety belt assembly under the above conditions could result in severe personal injuries in the event of - 2001 Ford Expedition | Owner Guide 1st Printing - Page 122
, not across the waist. • 1st row and 3rd row (if equipped) center seating positions The lap belt does not adjust automatically. Insert the tongue into the correct buckle (the buckle closest to the direction the tongue is coming from). To lengthen the belt, turn the tongue at a right angle to the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 123
is located at the end of the webbing on the label. Also, use the safety belt extension only if the safety belt is too short for you when fully extended. Do not use extensions to change the fit of the shoulder belt across the torso. Safety belt warning light and indicator chime The seat belt warning - 2001 Ford Expedition | Owner Guide 1st Printing - Page 124
safety restraints Conditions of operation If...The driver's safety belt is not buckled before the ignition switch is turned to the ON position...Then...The safety belt warning light illuminates 1-2 minutes and the warning chime sounds 4-8 seconds. The safety belt warning light and warning chime turn - 2001 Ford Expedition | Owner Guide 1st Printing - Page 125
in light trucks. "Traffic is light" Nearly 1 of 2 deaths occur in single-vehicle crashes, many when no other vehicles are around. "Belts wrinkle belts" Children and younger brothers/sisters imitate behavior they see. "I have an air bag" Air bags offer greater protection when used with safety belts - 2001 Ford Expedition | Owner Guide 1st Printing - Page 126
brake is set • the gearshift is in P (Park) (automatic transmission). • the ignition switch is in the OFF position • all vehicle doors are closed • the driver's safety belt or ON) position. (DO NOT START THE ENGINE) 2. Wait until the safety belt warning light turns off. (Approximately 1-2 minutes) • - 2001 Ford Expedition | Owner Guide 1st Printing - Page 127
with the safety belt warning light off, then followed by flashing the safety belt warning light four times per second for three seconds again. 9. After receiving confirmation, the deactivation/activation procedure is complete. Safety belt maintenance Inspect the safety belt systems periodically to - 2001 Ford Expedition | Owner Guide 1st Printing - Page 128
in the Maintenacne and Care section. AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) LOW FUEL F E H 30 20 10 40 40 60 50 80 60 100 70 3 120 H DOOR AJAR BRAKE 000000 80 90 1 2 THEFT 4 VOL - PUSH ON 140 20 160 MPH 5 6 RPMx1000 CHECK ENGINE ABS CHECK SUSP 18 8 0 0 0 km/h 100 IVE RDR - 2001 Ford Expedition | Owner Guide 1st Printing - Page 129
upper body injuries. Air bags DO NOT inflate slowly or gently and the risk of injury from a deploying air bag is greatest close to the trim covering the air bag module. All occupants of the vehicle, including the driver, should always properly wear their safety belts, even when an air bag SRS - 2001 Ford Expedition | Owner Guide 1st Printing - Page 130
torso causing serious injury. Do not attempt to service, repair, or modify the Air Bag Supplemental Restraint System or its fuses. See your Ford or Lincoln Mercury dealer. Modifications to the front end of the vehicle, including frame, bumper, front end body structure and tow hooks may affect the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 131
in this guide. Children must always be properly restrained. Accident statistics suggest that children are safer when properly restrained in the rear seating positions than in the front seating position. Failure to follow these instructions may increase the risk of injury in a collision. Air bags can - 2001 Ford Expedition | Owner Guide 1st Printing - Page 132
from the air bag module as possible while maintaining vehicle control. Several air bag system components get hot after inflation. Do not touch them after inflation. If the air bag has deployed, the air bag will not function again and must be replaced immediately. If the air bag is not replaced, the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 133
the problem and/or light are repaired. If any of these things happen, even intermittently, have the SRS serviced at your dealership or by a qualified technician immediately. Unless serviced, the system may not function properly in the event of a collision. Disposal of air bags and air bag equipped - 2001 Ford Expedition | Owner Guide 1st Printing - Page 134
attempt to service, repair, or modify the air bag supplemental restraint system, its fuses or the seat cover on a seat containing an air bag. See your Ford or Lincoln Mercury dealer. All occupants of the vehicle including the driver should always wear their safety belts even when an air bag SRS is - 2001 Ford Expedition | Owner Guide 1st Printing - Page 135
allow airbag deployment. • The same warning light, electronic control and diagnostic unit as used for the front air bags. • Two crash sensors located under the outboard side of the front seats, attached to the floor. Side air bags, in combination with seat belts, can help reduce the risk of severe - 2001 Ford Expedition | Owner Guide 1st Printing - Page 136
accordance with the vehicle service manual. If the air bag is not replaced, the unrepaired area will increase the risk of injury in a collision. Determining if the system is operational The SRS uses a readiness light in the instrument cluster or a tone to indicate the condition of the system. Refer - 2001 Ford Expedition | Owner Guide 1st Printing - Page 137
sections for directions on how to properly use safety restraints for children. Also see Air Bag Supplemental Restraint System (SRS) in this chapter for special instructions about using air bags. Important child restraint precautions You are required by law to use safety restraints for children - 2001 Ford Expedition | Owner Guide 1st Printing - Page 138
belts on children who have outgrown child safety seats, Ford recommends use of a belt-positioning booster seat that is labelled as conforming to all applicable Federal motor vehicle safety standards. Belt child. Carefully follow all of the manufacturer's instructions with the safety seat you put in - 2001 Ford Expedition | Owner Guide 1st Printing - Page 139
and follow the information presented in the Air Bag Supplemental Restraint System (SRS) section in this chapter. • Use the correct safety belt buckle for that seating position (the buckle closest to the direction the tongue is coming from). • Insert the belt tongue into the proper buckle until you - 2001 Ford Expedition | Owner Guide 1st Printing - Page 140
Seating and safety restraints Installing child safety seats in combination lap and shoulder belt seating positions Air bags can kill or injure a child in a child seat. NEVER place a rear-facing child seat in front of an active air bag. If you must use a forward-facing child seat in the front seat, - 2001 Ford Expedition | Owner Guide 1st Printing - Page 141
tongue through the child seat according to the child seat manufacturer's instructions. Be sure the belt webbing is not twisted. 4. Insert the belt tongue into the proper buckle (the buckle closest to the direction the tongue is coming from) for that seating position until you hear a snap and feel - 2001 Ford Expedition | Owner Guide 1st Printing - Page 142
Installing child safety seat in the second row center seating position with an automatic locking retractor 1. Place the child safety seat in the center seating position. 2. In a continuous motion, pull out enough webbing from the retractor to route the tongue through the child seat. 3. While holding - 2001 Ford Expedition | Owner Guide 1st Printing - Page 143
(if equipped) 1. Place the child safety seat in the center seating position. 2. Route the tongue end through the child seat according to the child seat manufacturers instructions. If the tongue will not reach the buckle, lengthen the amount of belt by turning the tongue at a right angle to the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 144
instructions provided with the kit. Tether anchorage hardware kits (part number 613D74) including instructions, may be obtained at no charge from any Ford point. Tether straps are available as an accessory for many older safety seats. Contact the strap anchors located behind the seats as described below. - 2001 Ford Expedition | Owner Guide 1st Printing - Page 145
properly if attached somewhere other than the correct tether anchor. 1. Position the child safety seat on the seat cushion. 2. Route the child safety seat tether strap over the back of the seat. 3. Locate the correct anchor for the selected seating position. (Shown with the seats folded down.) 145 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 146
properly in the event of a collision. 5. Refer to the Installing child safety seats in combination lap and shoulder belt seating positions section of this chapter for further instructions to secure the child safety seat. 6. Tighten the child safety seat tether strap according to the manufacturer - 2001 Ford Expedition | Owner Guide 1st Printing - Page 147
engine. For more information on starting the vehicle, refer to Starting the engine in this chapter. Extended idling at high engine speeds can produce very high temperatures in the engine garage door before you start the engine. See Guarding against exhaust fumes in this chapter for more instructions. - 2001 Ford Expedition | Owner Guide 1st Printing - Page 148
Starting Important safety precautions A computer system controls the engine's idle revolutions per minute (RPM). When the engine starts, the idle RPM runs faster to warm the engine. If the engine idle speed does not slow down automatically, have the vehicle checked. Do not allow the vehicle to idle - 2001 Ford Expedition | Owner Guide 1st Printing - Page 149
vehicle Make sure the corresponding lights illuminate or illuminate briefly. If a light fails to illuminate, have the vehicle serviced. light may not illuminate. • If the driver's safety belt is fastened, the STARTING THE ENGINE NOTE: Whenever you start your vehicle, release the key as soon as the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 150
an engine block heater is strongly recommended if you live in a region where temperatures reach -23°C (-10°F) or below. For best results, plug Have the exhaust and body ventilation systems checked whenever: • the vehicle is raised for service. • the sound of the exhaust system changes. • the vehicle - 2001 Ford Expedition | Owner Guide 1st Printing - Page 151
harm. Important ventilating information If the engine is idling while the vehicle is stopped in an open area for long periods of time, open the windows at least 2.5 cm (one inch). Adjust the heating or air conditioning (if equipped) to bring in fresh air. Improve vehicle ventilation by keeping all - 2001 Ford Expedition | Owner Guide 1st Printing - Page 152
of the vehicle's anti-lock brake system. The ABS performs a self-check after you start the engine and begin to drive away. A brief mechanical noise may be heard during this test. This is normal. If a malfunction is found, the ABS warning light will come on. If the vehicle has continuous vibration or - 2001 Ford Expedition | Owner Guide 1st Printing - Page 153
on or continues to flash, the ABS needs to be serviced. With the ABS light on, the anti-lock brake system is disabled and normal BRAKE braking is still effective unless the ! brake warning light also remains illuminated with parking brake released. (If your brake warning lamp illuminates, have your - 2001 Ford Expedition | Owner Guide 1st Printing - Page 154
is not recommended to stop a moving vehicle. However, if the normal brakes fail, the parking brake can be used to stop your vehicle in an emergency. Since the parking brake applies only the rear brakes, the vehicle's stopping distance will increase greatly and the handling of your vehicle will be - 2001 Ford Expedition | Owner Guide 1st Printing - Page 155
mark on the reservoir). If the power steering system breaks down (or if the engine is turned off), you can steer the vehicle manually, but it takes more effort. If the steering wanders or pulls, the condition could be caused by any of the following: • underinflated tire(s) on any wheel(s) • uneven - 2001 Ford Expedition | Owner Guide 1st Printing - Page 156
or a qualified service technician. AIR SUSPENSION SYSTEM (IF EQUIPPED) The air suspension system is designed to improve ride, handling and general vehicle performance for static, on and off-road driving conditions. • The load leveling feature of the air suspension automatically keeps the vehicle - 2001 Ford Expedition | Owner Guide 1st Printing - Page 157
. If the warning light illuminates again, turn the air suspension switch off and have the vehicle serviced by a dealer or qualified service technician. If the vehicle is loaded beyond the recommended maximum payload, the CK SUSP light may illuminate. To correct this condition, remove or redistribute - 2001 Ford Expedition | Owner Guide 1st Printing - Page 158
engine with one wheel off the ground, such as when changing a tire. PREPARING TO DRIVE YOUR VEHICLE Utility vehicles have a significantly higher rollover rate than other types of vehicles. In a rollover crash, an unbelted person is significantly more likely to die than a person wearing a seat belt - 2001 Ford Expedition | Owner Guide 1st Printing - Page 159
the key and turn it to OFF. Apply the brake pedal and shift to N (Neutral). 3. Start the vehicle. If it is necessary to use the above procedure to move the gearshift lever, it is possible that a fuse has blown or the vehicle's brakelamps are not operating properly. Refer to Fuses and relays in - 2001 Ford Expedition | Owner Guide 1st Printing - Page 160
the normal operating temperature, or if the downshifts and other throttle conditions do not function normally, see your dealer or a qualified service technician as soon as possible. Understanding gearshift positions To put your vehicle in gear, start the engine, depress the brake pedal, then move - 2001 Ford Expedition | Owner Guide 1st Printing - Page 161
pressing the transmission control switch (TCS) on the end of the gearshift lever. The transmission control indicator light (TCIL) ( engine downhill braking is desired. If towing a trailer, refer to Driving while you tow in the Trailer towing section. (Overdrive) mode, press the transmission control - 2001 Ford Expedition | Owner Guide 1st Printing - Page 162
for customer driving habits and conditions, your 4R100 automatic transmission electronically controls the shift quality by using an adaptive learning strategy. The adaptive learning strategy is maintained by power from the battery. When the battery is disconnected or a new battery is installed, the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 163
4WD Low can be engaged, the vehicle must be at a complete stop with the brake pedal depressed and the transmission in N (Neutral). 4H or 4L operation is not CONTROL-TRAC AUTOMATIC FOUR-WHEEL DRIVE SYSTEM (IF EQUIPPED) Your 4x4 features the heavy-duty Control-Trac system which includes a computer- - 2001 Ford Expedition | Owner Guide 1st Printing - Page 164
of the Control-Trac system The Control-Trac A4WD system 4H functions in three modes: A4WD 4L • A4WD position delivers power to the rear axle. If the rear wheels lose traction, power will be automatically delivered to the front axle to maintain traction throughout the slippery condition. • 4H - 2001 Ford Expedition | Owner Guide 1st Printing - Page 165
brake. 3. Place the gearshift in N (Neutral). 4. Move the 4WD control to the 4H (or 4L) position. A4WD 4H 4L Shifting to A4WD Move the 4WD control control at all times, especially in rough terrain. Since sudden changes before driving. Map out your route before driving in the area. For more - 2001 Ford Expedition | Owner Guide 1st Printing - Page 166
lightly on the accelerator in each gear. Do not rock the vehicle if the engine is not at normal operating temperature through high water, drive slowly. Traction or brake capability may be limited. When driving through water, their fluids should be checked and changed, if necessary. Water intrusion - 2001 Ford Expedition | Owner Guide 1st Printing - Page 167
gear when added engine braking is desired. When speed control is on and you are driving uphill, your vehicle speed may drop considerably, especially if you are carrying a heavy load. If vehicle speed drops more than 16 km/h (10 mph), the speed control will cancel automatically. Resume speed with - 2001 Ford Expedition | Owner Guide 1st Printing - Page 168
brake capability may be limited and if the ignition system gets wet, your engine may stall. Water may also enter your engine's air intake and severely damage your engine and is listed on the Safety Certification Label on the driver's door pillar. • GAWR (Gross Axle Weight Rating): Carrying capacity - 2001 Ford Expedition | Owner Guide 1st Printing - Page 169
is determined by subtracting the vehicle curb weight for each engine/ transmission combination, any required option weight for trailer Replacement tires with a higher limit than the originals do not increase the GVWR and GAWR limitations. The Safety Certification Label, found on the driver's door - 2001 Ford Expedition | Owner Guide 1st Printing - Page 170
instructions for owners of pickup trucks and utility-type vehicles For important information regarding safe operation of this type of vehicle, see the Preparing to drive your vehicle section inthe Driving chapter of this owner guide. Loaded vehicles, with a higher center your type engine and rear - 2001 Ford Expedition | Owner Guide 1st Printing - Page 171
this chapter. • Service your vehicle more frequently if you tow a trailer. Refer to the severe duty schedule in the scheduled maintenance guide. • Do not tow a trailer until your vehicle has been driven at least 800 km (500 miles). • Refer to the instructions included with towing accessories for the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 172
Driving Engine Rear axle ratio 3.31 3.31 3.31 3.55 3.55 3.73 3.73 Tire size cm (inches) Maximum GCWR - kg (lbs.) 4x2 4 990 (11 000) 4 990 (11 000) 5 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 173
in engine damage, transmission damage, structural damage, loss of control auxiliary coolers are recommended for the automatic transmission system if you are planning on air suspension (if equipped) control to OFF. 3. Measure the height of a reference point on the front and rear bumpers at the center - 2001 Ford Expedition | Owner Guide 1st Printing - Page 174
for turning corners. If you use a rental trailer, follow the instructions that the rental agency gives to you. Do not attach safety chains to the bumper. Trailer brakes Electric brakes and manual, automatic or surge-type trailer brakes are safe if installed properly and adjusted to the manufacturer - 2001 Ford Expedition | Owner Guide 1st Printing - Page 175
stops and brake gradually. Exceeding the GCWR rating may cause internal transmission damage and void your warranty coverage. Servicing after towing If you tow a trailer for long distances, your vehicle will require more frequent service intervals. Refer to your scheduled maintenance guide for more - 2001 Ford Expedition | Owner Guide 1st Printing - Page 176
brakes check your hitch, electrical connections and trailer wheel lug nuts. • When stopped in traffic for long periods of time in hot weather, place the gearshift in P (Park) and increase idle speed. This aids engine cooling and air conditioner checked or changed unless a leak is suspected or repair - 2001 Ford Expedition | Owner Guide 1st Printing - Page 177
Driving LUGGAGE RACK (IF EQUIPPED) The rear cross-bar can be adjusted to fit the item being carried. The front cross-bar does not move. To adjust the luggage rack, push the adjustment lever forward (toward the front of the vehicle), then slide the cross-bar forward and lock the adjusting levers by - 2001 Ford Expedition | Owner Guide 1st Printing - Page 178
Ford offers a complimentary roadside assistance program. This program is separate from the New Vehicle Limited Warranty. The service is whichever comes first on Ford and Mercury vehicles, and four years or 80 000 km (50 000 miles) on Lincoln vehicles Roadside assistance will cover: • changing a - 2001 Ford Expedition | Owner Guide 1st Printing - Page 179
through the Ford Auto Club by contacting your Ford or Lincoln lights control is located on top of the steering column. • Depress hazard lights control to activate all hazard flashers simultaneously. • Depress control again to turn the flashers off. FUEL RESETTING THE FUEL PUMP SHUT-OFF SWITCH RESET - 2001 Ford Expedition | Owner Guide 1st Printing - Page 180
fuel pump shut-off switch is located in the passenger's foot well, by the kick panel. Use the following procedure to reset the fuel pump shut-off switch. 1. Turn the ignition to the OFF position. 2. Check the fuel system for leaks. 3. If no fuel leak is apparent, reset the fuel pump shut-off switch - 2001 Ford Expedition | Owner Guide 1st Printing - Page 181
the fuse. Check the appropriate fuses before replacing any electrical components. NOTE: Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire. Standard fuse amperage rating and color COLOR - 2001 Ford Expedition | Owner Guide 1st Printing - Page 182
2 5 9 10 RELAY 2 RELAY 3 RELAY 4 20 RELAY 5 The fuses are coded as follows. Fuse/Relay Location 1 2 Fuse Amp Rating 25A 5A Passenger Compartment Fuse Panel Description Audio Overhead Trip Computer, Electronic Automatic Temperature Control (EATC), Powertrain Control Module (PCM), Cluster Cigar - 2001 Ford Expedition | Owner Guide 1st Printing - Page 183
Motor, Rear Washer Pump Relay Air Suspension Switch Stop Lamp Switch (Lamps), Turn/Hazard Flasher, Speed Control Module Rear Wipers, Running Board Lamps, Battery Saver Relay, Interior Lamp Relay, Accessory Delay Relay (Power Windows, Moonroof, Flip Windows) Stop Lamp Switch, (Speed Control, Brake - 2001 Ford Expedition | Owner Guide 1st Printing - Page 184
Range Switch Air Bag Module, Intelligent Passenger Airbag Deactivation Module Aux A/C, Heated Seats, Trailer Tow Battery Charge, Turn/Hazard Flasher, 4x4 Clutch Relay, Overhead Console, E/C Mirror, 4 Wheel Anti-Lock Brake System (4WABS) Module EATC Module, EATC Blower Relay, Climate Control Switch - 2001 Ford Expedition | Owner Guide 1st Printing - Page 185
Relay Power distribution box The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle's main electrical systems from overloads. Always disconnect the battery before servicing high current fuses. Always replace - 2001 Ford Expedition | Owner Guide 1st Printing - Page 186
HALF RELAY 204 Fuse/Relay Location 1 2 3 4 5 6 Roadside emergencies The high-current fuses are coded as follows. 10 11 12 13 14 15 Power Distribution Box Description 20A* 30A* 15A* Fuse Amp Rating 20A * 30A* 30A* 20A* 20A* 15A* 20A* 20A* 10A* 15A* - 10A* Power Point Powertrain Control Module - 2001 Ford Expedition | Owner Guide 1st Printing - Page 187
Not Used Trailer Tow Electric Brake Air Suspension Compressor Heated Seats Ignition Switch Battery Feed (Run/Start Circuit) Drivers Power Seat, Adjustable Pedals, Memory Module Ignition Switch Battery Feed (Run and Accessory Circuits) Climate Control Auxiliary Blower Not Used Rear Window Defroster - 2001 Ford Expedition | Owner Guide 1st Printing - Page 188
Fuel Pump Relay Trailer Tow Battery Charge Relay Wiper Hi/Lo Relay Powertrain Control Module Relay Not Used Powertrain Control Module Diode A/C Clutch Diode Not Used Delayed Accessory (Power Windows, Flip Windows, Moonroof) Not Used 602 - *Mini fuses **Maxi fuses Relays Relays are located in the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 189
tire Jack, wheel nut wrench, instructions Jack handle Location Under the vehicle, just forward of the rear bumper Behind the access panel located on the right rear quarter panel interior trim On top of the radiator support at the front of the engine compartment Removing the jack handle 1. Open - 2001 Ford Expedition | Owner Guide 1st Printing - Page 190
parts together. To disassemble, unscrew. Removing the spare tire 1. Open the liftgate. 2. Twist counterclockwise and remove access plug (if equipped) from guide tube located just above the rear bumper up. 2. Install the retainer through the wheel center and slide the wheel under the vehicle. 3. - 2001 Ford Expedition | Owner Guide 1st Printing - Page 191
the Air Suspension switch prior to jacking, hoisting or towing your vehicle. Refer to the instruction sheet (located behind the interior trim access panel with the jack) for detailed tire change instructions. 1. Park on a level surface, activate hazard flashers and set the parking brake. 2. Place - 2001 Ford Expedition | Owner Guide 1st Printing - Page 192
ground. 7. Turn OFF the air suspension switch (if equipped). 8. Position the jack according to the following guides and turn the jack handle Park). To prevent the vehicle from moving when you change the tire, be sure that the parking brake is set and the diagonally opposite wheel is blocked. - 2001 Ford Expedition | Owner Guide 1st Printing - Page 193
Roadside emergencies • Front (4x2) • Front (4x4) • Rear 193 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 194
Turn on the air suspension switch (if equipped). JUMP STARTING YOUR VEHICLE The gases around the battery can explode if exposed to flames, sparks, or lit cigarettes. An explosion could result in injury or vehicle damage. Do not push-start your vehicle. You could damage the catalytic converter. 194 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 195
two vehicles do not touch. Set the parking brake on both vehicles and stay clear of the engine cooling fan and other moving parts. 4. Check all battery terminals and remove any excessive corrosion before you attach the battery cables. Ensure that vent caps are tight and level. 5. Turn the heater fan - 2001 Ford Expedition | Owner Guide 1st Printing - Page 196
jumper cables 1. Connect the positive (+) booster cable to the positive (+) terminal of the discharged battery. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Connect the other end of the positive (+) cable to the positive (+) terminal of the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 197
points. Do not connect the end of the second cable to the negative (-) terminal of the battery to be jumped. A spark may cause an explosion of the gases that surround the battery. 5. Ensure that the cables are clear of fan blades, belts, moving parts of both engines, or any fuel delivery system - 2001 Ford Expedition | Owner Guide 1st Printing - Page 198
3. Once the disabled vehicle has been started, run both engines for an additional three minutes before disconnecting the jumper cables. Removing , lightning bolts are used to designate the assisting (boosting) battery. 2. Remove the jumper cable on the negative (-) connection of the booster vehicle - 2001 Ford Expedition | Owner Guide 1st Printing - Page 199
has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. When the battery is disconnected or a new battery is installed, the transmission must relearn its adaptive strategy. As a result of this, the transmission may - 2001 Ford Expedition | Owner Guide 1st Printing - Page 200
a member, your roadside assistance center. It is recommended that your vehicle be towed with a wheel lift or flatbed equipment. Do not tow with a slingbelt. Ford Motor Company has not approved a slingbelt towing procedure. If equipped with air suspension, the air suspension control must be turned to - 2001 Ford Expedition | Owner Guide 1st Printing - Page 201
it-yourself items in the engine compartment for easy location. • We provide a scheduled maintenance guide which makes tracking routine service easy. If your vehicle requires professional service, your dealership can provide the necessary parts and service. Check your Warranty Guide to find out which - 2001 Ford Expedition | Owner Guide 1st Printing - Page 202
HOOD 1. Inside the vehicle, pull the hood release handle located under the bottom of the instrument panel. 2. Go to the front of the vehicle and release the auxiliary latch that is located under the front center of the hood. 3. Lift the hood until the lift cylinders hold it open. HOOD BRAKE 202 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 203
Maintenance and care IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT 4.6L V8 and 5.4L V8 engines 1. Battery 2. Automatic transmission fluid dipstick 3. Engine oil filler cap 4. Engine oil dipstick 5. Power steering fluid reservoir 6. Brake fluid reservoir 7. Power distribution box 8. Air filter - 2001 Ford Expedition | Owner Guide 1st Printing - Page 204
Maintenance and care 2. Turn the engine off and wait a few minutes for the oil to drain into the oil pan. 3. Set the parking brake and ensure the gearshift is securely latched in P (Park). 4. Open the hood. Protect yourself from engine heat. 5. Locate and carefully remove the engine oil level - 2001 Ford Expedition | Owner Guide 1st Printing - Page 205
Maintenance and care • Oil levels above the MAX mark may cause engine damage. Some oil must be removed from the engine by a service technician. 7. Put the indicator back in and ensure it is fully seated. Adding engine oil 1. Check the engine oil. For instructions, refer to Checking the engine oil in - 2001 Ford Expedition | Owner Guide 1st Printing - Page 206
oil filter (or another brand meeting Ford specifications) for your engine application. BRAKE FLUID Checking and adding brake fluid Brake fluid should be checked and refilled as needed. Refer to the scheduled maintenance guide for the service interval schedules. 1. Clean the reservoir cap before - 2001 Ford Expedition | Owner Guide 1st Printing - Page 207
If master cylinder runs dry, this may cause the brakes to fail. WINDSHIELD WASHER FLUID Washer fluid Check the washer fluid whenever you stop for fuel. The in the engine coolant reservoir. Washer fluid placed in the cooling system may harm engine and cooling system components. Checking and adding - 2001 Ford Expedition | Owner Guide 1st Printing - Page 208
and care ENGINE COOLANT Checking engine coolant The concentration and level of engine coolant should be checked at the mileage intervals listed in the scheduled maintenance guide. The coolant concentration should be maintained at 50/50 coolant and water, which equates to a freeze point of - 2001 Ford Expedition | Owner Guide 1st Printing - Page 209
and care • Refer to the Scheduled Maintenance Guide for service interval schedules. • Be sure to read and understand Precautions when servicing your vehicle in this chapter. If the engine coolant has not been checked at the recommended interval, the engine coolant reservoir may become low or empty - 2001 Ford Expedition | Owner Guide 1st Printing - Page 210
or any orange-colored extended life product with your factory filled coolant can result in degraded corrosion protection. • A large amount of water without engine coolant may be added, in case of emergency, to reach a vehicle service location. In this instance, the cooling system must be drained and - 2001 Ford Expedition | Owner Guide 1st Printing - Page 211
full. 6. Replace the cap. Turn until tightly installed. (Cap must be tightly installed to prevent coolant loss.) After any coolant has been added, check the coolant concentration see Checking Engine Coolant section). If the concentration is not 50/50 (protection to -34°F/-36°C), drain some coolant - 2001 Ford Expedition | Owner Guide 1st Printing - Page 212
on the coolant container to ensure the coolant concentration in your vehicle will provide adequate protection at the temperatures in which you drive. Vehicles driven year-round in non-extreme climates should use a 50/50 mixture of engine coolant and distilled water for optimum cooling system and - 2001 Ford Expedition | Owner Guide 1st Printing - Page 213
• the will illuminate. • the Service Engine Soon indicator light will illuminate. If the engine reaches a preset over-temperature condition, the engine will automatically switch to alternating cylinder operation. Each disabled cylinder acts as an air pump and cools the engine. When this occurs the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 214
Check the power steering fluid. Refer to the scheduled maintenance guide for the service interval schedules. If adding fluid is necessary, use only Ford Premium Power Steering Fluid. 1. Start the engine and let it run until it reaches normal operating temperature (the engine coolant temperature - 2001 Ford Expedition | Owner Guide 1st Printing - Page 215
MIN and MAX lines. Be sure to put the cap back on the reservoir. MAX MIN MAX MIN TRANSMISSION FLUID Checking automatic transmission fluid Refer to your scheduled maintenance guide for scheduled intervals for fluid checks and changes. Your transmission does not consume fluid. However, the fluid - 2001 Ford Expedition | Owner Guide 1st Printing - Page 216
30 km (20 miles) of driving. You can check the fluid without driving if the ambient temperature is above 10°C (50°F). However, if fluid is added at this time, an overfill condition could result when the vehicle reaches normal operating temperature. The transmission fluid should be in this range if - 2001 Ford Expedition | Owner Guide 1st Printing - Page 217
which normally does not require additional water during its life of service. However, for severe usage or in high temperature climates, check the battery electrolyte level. Refer to the scheduled maintenance guide for the service interval schedules. Keep the electrolyte level in each cell up to - 2001 Ford Expedition | Owner Guide 1st Printing - Page 218
flames, sparks or lighted substances to come near the battery. When working near the battery, always shield your face and protect your eyes. Always provide proper ventilation. When lifting a plastic-cased battery, excessive pressure on the end walls could cause acid to flow through the vent caps - 2001 Ford Expedition | Owner Guide 1st Printing - Page 219
dealer or a qualified service technician as soon as possible. Because your vehicle's engine is also electronically controlled by a computer, some control conditions are maintained by power from the battery. When the battery is disconnected or a new battery is installed, the engine must relearn its - 2001 Ford Expedition | Owner Guide 1st Printing - Page 220
automotive batteries. RE D TU LE A RN RECYCLE AIR FILTER MAINTENANCE Refer to the scheduled maintenance guide for the appropriate intervals for changing the air filter element. When changing the air filter element, use only the Motorcraft air filter element listed. Refer to Motorcraft Part - 2001 Ford Expedition | Owner Guide 1st Printing - Page 221
Maintenance and care Changing the air filter element 1. Loosen the clamp that secures the air inlet tube to the engine air filter cover and disconnect the tube from the cover. 2. Loosen the clamp that secures the air filter cover to the air filter housing and carefully separate the cover from - 2001 Ford Expedition | Owner Guide 1st Printing - Page 222
Maintenance and care 4. Install a new air filter element. Be careful not to crimp the filter element edges between the air filter housing and cover. This could cause filter damage and allow unmetered air to enter the engine if not properly seated. 5. Replace the air filter cover and secure the clamp - 2001 Ford Expedition | Owner Guide 1st Printing - Page 223
driving habits, service practices, and differences in road characteristics and climate. Traction AA A B C The traction grades, from highest to lowest are AA, A, B, and C. Those grades represent the tire's ability to stop on wet pavement as measured under controlled conditions on specified government - 2001 Ford Expedition | Owner Guide 1st Printing - Page 224
dissipate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material and possible tire failure. SERVICING YOUR TIRES Checking the tire pressure • Use an accurate tire pressure gauge. • Check the tire pressure when tires - 2001 Ford Expedition | Owner Guide 1st Printing - Page 225
. To make sure your tires wear evenly and last longer, rotate them as indicated in the scheduled maintenance guide. If you notice that the tires wear unevenly, have them checked. • Four tire rotation Replacing the tires Replace the tires when the wear band is visible through the tire treads. When - 2001 Ford Expedition | Owner Guide 1st Printing - Page 226
only cable type chains offered by Ford as an accessory or equivalent. SAE class "S" or other conventional link type chains may contact and cause damage to the vehicle's wheel house and/or body. • Install chains securely, verifying that the chains do not touch any wiring, brake lines or fuel lines - 2001 Ford Expedition | Owner Guide 1st Printing - Page 227
Maintenance and care WHAT YOU SHOULD KNOW ABOUT AUTOMOTIVE FUELS Important safety precautions Do not overfill the fuel tank. The pressure in an overfilled tank may cause leakage and lead to fuel spray and fire. The fuel system may be under pressure. If the fuel filler cap is venting vapor or if you - 2001 Ford Expedition | Owner Guide 1st Printing - Page 228
Maintenance and care Observe the following guidelines when handling automotive fuel: • Extinguish refueling always shut the engine off and never allow sparks or open flames near the filler neck. Never smoke while refueling. Fuel vapor is extremely hazardous under certain conditions. Care should be - 2001 Ford Expedition | Owner Guide 1st Printing - Page 229
Maintenance with metallic compounds, including manganese-based compounds containing MMT. Repairs to correct the effects of using a fuel for which Do not be concerned if your engine sometimes knocks lightly. However, if it knocks heavily under most driving conditions while you are using fuel with - 2001 Ford Expedition | Owner Guide 1st Printing - Page 230
cycle the ignition from OFF to ON several times after refueling, to allow the fuel system to pump the fuel from the tank to the engine. • Your "Service Engine Soon" indicator may come on. For more information on the "Service Engine Soon" indicator, refer to the Instrumentation chapter. 230 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 231
If the "Service Engine Soon/Check Engine" indicator comes on and stays on after you start the engine, the fuel filler cap may not be properly installed. Turn off the engine, remove the fuel filler cap, align the cap properly and reinstall it. If you must replace the fuel filler cap, replace it with - 2001 Ford Expedition | Owner Guide 1st Printing - Page 232
Maintenance and care ESSENTIALS OF GOOD FUEL ECONOMY Measuring techniques Your best in the reading will result if the engine is left running. • Use the same filling rate setting (low - medium - high) each time the tank is filled. • Allow no more than 2 automatic click-offs when filling. • Always - 2001 Ford Expedition | Owner Guide 1st Printing - Page 233
provide an accurate estimate of the vehicle's fuel economy under current driving conditions. Additionally, keeping records during summer and winter will show how temperature impacts fuel economy. In general, lower temperatures give lower fuel economy. Driving style - good driving and fuel economy - 2001 Ford Expedition | Owner Guide 1st Printing - Page 234
Maintenance and care • Using the air conditioner or defroster may reduce fuel economy. • You may want to turn off the speed control in hilly maintenance items. Follow the recommended maintenance schedule and owner maintenance checks found in your vehicle scheduled maintenance guide. Conditions - 2001 Ford Expedition | Owner Guide 1st Printing - Page 235
and to its emissions system. If other than Ford, Motorcraft or Ford-authorized parts are used for maintenance replacements or for service of components affecting emission control, such non-Ford parts should be equivalent to genuine Ford Motor Company parts in performance and durability. Do not park - 2001 Ford Expedition | Owner Guide 1st Printing - Page 236
and chimes section of the Instrumentation chapter. Your vehicle may not pass the I/M test with the "Check Engine/Service Engine Soon" light on. If the vehicle's powertrain system or its battery has just been serviced, the on-board diagnostics system is reset to a "not ready for I/M test" condition - 2001 Ford Expedition | Owner Guide 1st Printing - Page 237
Maintenance and care • Foglamps • High-mount brakelamp • Brakelamps • Parking lamps • Turn signals • License plate lamp • Tail lamps • Back-up lamps Do not remove lamp bulbs unless they can be replaced affect lamp performance. Replacing headlamp bulbs 1. Make sure that the headlamp control is in the - 2001 Ford Expedition | Owner Guide 1st Printing - Page 238
Maintenance and care Handle a halogen headlamp bulb carefully and keep out of the vehicle and push down on the clips to lock the lamp into place. Replacing front parking lamp/turn signal bulbs 1. Make sure that the headlamp control is in the OFF position. 2. Open the hood. 3. Remove the screw - 2001 Ford Expedition | Owner Guide 1st Printing - Page 239
Maintenance and care 4. Rotate the bulb socket counterclockwise and remove from the until parking lamp assembly seats. 9. Install screw on the lamp assembly. Replacing tail lamp/backup lamp bulbs The tail lamp/backup lamp bulbs are located in the same portion of the tail lamp assembly, one just below - 2001 Ford Expedition | Owner Guide 1st Printing - Page 240
Maintenance and care Replacing foglamp bulbs 1. Remove the bulb socket from the foglamp by turning counterclockwise. 2. Disconnect the electrical connector from the foglamp bulb. 3. Connect the new foglamp bulb - 2001 Ford Expedition | Owner Guide 1st Printing - Page 241
Maintenance and care Replacing license plate lamp bulbs The license plate bulbs are located behind the rear bumper. To change the license plate lamp bulbs: 1. Reach behind the rear bumper to locate the bulb. 2. Twist the bulb socket counterclockwise and carefully pull to remove it from the lamp - 2001 Ford Expedition | Owner Guide 1st Printing - Page 242
Maintenance and care REPLACING THE INTERIOR BULBS Check the operation of the following interior bulbs frequently: • interior overhead lamp • map lamp For bulb replacement, see a dealer or qualified technician. Map lamps To change should be checked by a qualified service technician. CLEANING AND CARING FOR - 2001 Ford Expedition | Owner Guide 1st Printing - Page 243
not removed promptly can cause damage to the vehicle's paintwork. Remove any exterior accessories, such as antennas, before entering a car wash. If you have wax apply the brakes several times to dry them. Underbody Flush the complete underside of vehicle frequently. Keep body drain holes unplugged. - 2001 Ford Expedition | Owner Guide 1st Printing - Page 244
Kit (F7AZ-19K507-BA), Lacquer Touch-up Paint (ALBZ-19500-XXXXA), or Exterior Acrylic Spray Lacquer (ALAZ-19500-XXXXA) from the Ford Car Care Chemicals line. Please note that the part numbers (shown as XXXX above) will vary with your vehicle's specific coloring. Observe the application instructions - 2001 Ford Expedition | Owner Guide 1st Printing - Page 245
Maintenance and care • Cover the highlighted areas to prevent water damage when cleaning the engine. • Never wash or rinse the engine while it is running; water in the running engine may cause internal damage. Cleaning non-painted plastic exterior parts Use vinyl cleaner for routine cleaning. Clean - 2001 Ford Expedition | Owner Guide 1st Printing - Page 246
or instrument panel to avoid contamination of the air bag system. Cleaning the instrument cluster lens Clean with a damp cloth, then dry with a dry cloth. Do not use household or glass cleaners as these may damage the lens. Cleaning the overhead console Clean with a damp cloth, then wipe dry with - 2001 Ford Expedition | Owner Guide 1st Printing - Page 247
the seat mounted side air bag. Such products could contaminate the side air bag system and affect performance of the side air bag in a collision. Cleaning and maintaining the safety belts Clean the safety belts with a mild soap solution recommended for cleaning upholstery or carpets. Do not bleach - 2001 Ford Expedition | Owner Guide 1st Printing - Page 248
Control Information (VECI) decal for spark plug gap information. REFILL CAPACITIES Fluid Brake fluid Ford Part Name High Performance DOT 3 Motor Vehicle Brake Fluid Motorcraft SAE 5W-20 Super Premium Motor Oil N/A Application All Capacity Fill to line on reservoir Engine oil (includes filter change - 2001 Ford Expedition | Owner Guide 1st Printing - Page 249
Fluid Transmission fluid 1 Ford Part Name Motorcraft MERCONV ATF Engine Coolant (green-colored) or Motorcraft Premium Gold Engine Coolant (yellow-colored) 4x4 vehicles 4.6L V8 engine with 1 row radiator 4.6L V8 engine with 2 row radiator 5.4L V8 engine with 1 row radiator 5.4L V8 engine - 2001 Ford Expedition | Owner Guide 1st Printing - Page 250
the correct automatic transmission fluid is used. Transmission fluid requirements are indicated on the dipstick or on the dipstick handle. Check the container to verify the fluid being added is of the correct type. Refer to your scheduled maintenance guide to determine the correct service interval - 2001 Ford Expedition | Owner Guide 1st Printing - Page 251
, latches, striker plates and rotors, seat tracks, fuel filler door hinge and spring Lock cylinders, Penetrating and swing-away Lock Lubricant spare tire carrier padlock Brake fluid High Performance DOT 3 Motor Vehicle Brake Fluid Motorcaft XL-1 none C6AZ-19542-AB ESA-M6C25-A and DOT 3 251 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 252
joint center ball Engine coolant Ford part name Premium Long Life Grease Ford part number XG-1-K or XG-1-C or XG-1-T VC-4-A (US) or CXC-10 (Canada) VC-7-A Ford specification ESA-M1C75-B Motorcraft Premium Engine Coolant (green-colored) Motorcraft Premium Gold Engin Coolant (yellow-colored) Engine - 2001 Ford Expedition | Owner Guide 1st Printing - Page 253
the correct automatic transmission fluid is used. Transmission fluid requirements are indicated on the dipstick or on the dipstick handle. Check the container to verify the fluid being added is of the correct type. Refer to your scheduled maintenance guide to determine the correct service interval - 2001 Ford Expedition | Owner Guide 1st Printing - Page 254
Capacities and specifications ENGINE DATA Engine Cubic inches Required fuel Firing order Spark plug gap Ignition system V8 engine 281 87 octane 1-3-7-2-6-5-4-8 1.3-1.4 mm (0.052-0.056 inch) Coil on plug 9.37:1 5.4L V8 engine 330 87 octane 1-3-7-2-6-5-4-8 1.3-1.4 mm (0.052-0.056 inch) Coil on plug - 2001 Ford Expedition | Owner Guide 1st Printing - Page 255
Capacities and specifications 2 Vehicle equipped with 16" tires and base suspension 4 1 3 5 2 255 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 256
the Certification label may be located. The Certification label is located on the front door latch pillar on the located on the driver side instrument panel. (Please note that in the graphic XXXX is representative of your vehicle identification number.) XXXXXXXXXXXXXXXXX Engine number The engine - 2001 Ford Expedition | Owner Guide 1st Printing - Page 257
or Ford Motor Service Company (in the U.S.) and Ford of Canada (in Canada). It provides the following: • benefits during the warranty period depending on the plan you purchase (such as: reimbursement for rentals; coverage for certain maintenance and wear items) • protection against covered repair - 2001 Ford Expedition | Owner Guide 1st Printing - Page 258
needs service, or if you need more help than the dealership could provide, after following the steps described above, contact the Ford Customer Relationship Center to find an authorized dealership to help you. In the United States: Ford Motor Company Customer Relationship Center 16800 Executive - 2001 Ford Expedition | Owner Guide 1st Printing - Page 259
Motor Company of Canada, Limited P.O. Box 2000 Oakville, Ontario L6J 5E4 1-800-565-3673 (FORD) In order to help you service your Ford or Lincoln Mercury vehicle, please have the following information available when contacting a Customer Relationship Center: • Your telephone number (home and business - 2001 Ford Expedition | Owner Guide 1st Printing - Page 260
Company vehicles The Dispute Settlement Board may not be available in all states. Ford Motor Company reserves the right to change eligibility limitations, modify procedures and/or to discontinue this service without notice and without incurring obligations per applicable state law. What kinds of - 2001 Ford Expedition | Owner Guide 1st Printing - Page 261
you must complete the application in the DSB brochure and mail it to the address provided on Ford Motor Company representative will then be asked to submit statements. To properly review your case, the Board needs the following information: • legible copies of all documents and maintenance or repair - 2001 Ford Expedition | Owner Guide 1st Printing - Page 262
state or federal law. To Request a DSB Brochure/Application For a brochure/application, speak to your dealer or write/ Center at 1-800-392-3673 (Ford), TDD for the hearing impaired: 1-800-232-5952 or by writing to the Center at the following address: Ford Motor Company Customer Relationship Center - 2001 Ford Expedition | Owner Guide 1st Printing - Page 263
. The use of leaded fuel in your vehicle without proper conversion may damage the effectiveness of your emission control system and may cause engine knocking or serious engine damage. Ford Motor Company/Ford of Canada is not responsible for any damage caused by use of improper fuel. In the United - 2001 Ford Expedition | Owner Guide 1st Printing - Page 264
Customer assistance If your vehicle must be serviced while you are traveling or living in Central or South America, the Caribbean, or the Middle East, contact the nearest Ford dealership. If the dealership cannot help you, write or call: FORD MOTOR COMPANY WORLDWIDE DIRECT MARKET OPERATIONS 1555 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 265
dealer for complete warranty information and availability. Not all accessories are available for all models. Vehicle Security Styled wheel protector locks Vehicle security systems Comfort and convenience Battery warmer Cabin air filter Cargo nets Cargo organizers Cargo storage box Cargo trays 265 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 266
Customer assistance Carpeted cargo mat Dash trim (wood grain) Engine block heaters Tire step Travel equipment Auto headlamps with DRL Bike rack Bumper mount bike carrier Canoe carrier Cell phone holder Daytime running lights (DRL) Factory luggage rack adaptors Fog lights Framed luggage covers Hard - 2001 Ford Expedition | Owner Guide 1st Printing - Page 267
Air bag anti-theft locks Cargo liners, interior Carpet floor mats Door edge guards Fender flares Flat splash guards Front end covers (full and sport) Hood deflectors Inside mirror with compass display Inside mirror with compass and temperature display Leather steering wheel Locking gas cap Molded - 2001 Ford Expedition | Owner Guide 1st Printing - Page 268
and theft alarms cause the engine to stumble door openers and other transmitters with outputs of five watts or less will not ordinarily affect your vehicle's operation.) • Ford guide French Owner's Guides can be obtained from your dealer or by writing to Ford Motor Company of Canada, Limited, Service - 2001 Ford Expedition | Owner Guide 1st Printing - Page 269
) California Civil Code Section 1793.2(d) requires that, if a manufacturer or its representative is unable to repair a motor vehicle to conform to the vehicle's applicable express warranty after a reasonable number of attempts, the manufacturer shall be required to either replace the vehicle with - 2001 Ford Expedition | Owner Guide 1st Printing - Page 270
safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer or Ford Motor Company. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800-424-9393 (202-366-0123 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 271
air bag ...134 Air cleaner filter ...220-221, 248 Air conditioning ...56 automatic temperature control system ...60 auxiliary heater and air conditioner ...66 Air suspension ...156 description ...156 warning light ...14 Ambulance packages ...5 Antifreeze (see Engine coolant) ...208 Anti-lock brake - 2001 Ford Expedition | Owner Guide 1st Printing - Page 272
-247 plastic parts ...245 safety belts ...247 washing ...243 waxing ...243 wheels ...244 windows ...246 wiper blades ...245 woodtone trim ...247 Climate control (see Air conditioning or Heating) ...56 Clock ...37, 49 Compass, electronic ...78 calibration ...80 set zone adjustment ...79 Console ...91 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 273
speed control ...217 lubrication specifications ...251, 254 refill capacities ...248 service points ...203 starting after a collision ...179 Engine block heater ...150 Engine oil ...203 change oil soon warning, message center ...203 checking and adding ...203 dipstick ...203 filter, specifications - 2001 Ford Expedition | Owner Guide 1st Printing - Page 274
...13, 21 replacing bulbs ...237 turning on and off ...21 warning chime ...15 Heating ...56 heating and air conditioning system ...56 HomeLink universal transceiver (see Garage door opener) ...84, 86-87 Hood ...202 I Ignition ...68, 254 Infant seats (see Safety seats) ...138 Inspection/maintenance - 2001 Ford Expedition | Owner Guide 1st Printing - Page 275
241 Lane change indicator (see Turn signal) ...68 Liftgate ...92 Lights, warning and indicator ...10 air bag ...11 air suspension ...157 anti-lock brakes (ABS) ...12, 153 anti-theft ...13 brake ...12 charging system ...13 check coolant ...13 cruise indicator ...15 door ajar ...14 engine oil pressure - 2001 Ford Expedition | Owner Guide 1st Printing - Page 276
light and chime ...12, 15, 123-124 Safety seats for children ...138 Seat belts (see Safety restraints) ...116 Seats ...104 child safety seats ...138 cleaning ...247 memory seat ...100, 108 SecuriLock passive anti-theft system ...93, 95 Servicing your vehicle ...201 Snowplowing ...5 Spark plugs - 2001 Ford Expedition | Owner Guide 1st Printing - Page 277
chimes ...15 Warning lights (see Lights) ...10 Washer fluid ...207 Water, Driving through ...168 Windows power ...88 rear wiper/washer ...74 Windshield washer fluid and wipers checking and adding fluid ...207 checking and cleaning ...222 liftgate reservoir ...207 operation ...74 replacing wiper - 2001 Ford Expedition | Owner Guide 1st Printing - Page 278
278 - 2001 Ford Expedition | Owner Guide 1st Printing - Page 279
DO NOT USE Ford Extended Life Engine Coolant (orange in color). Refer to Adding engine coolant, in the Maintenance and Care chapter. 2 Ensure the correct automatic transmission fluid is used. Transmission fluid requirements are indicated on the dipstick or on the dipstick handle. Check the container - 2001 Ford Expedition | Owner Guide 1st Printing - Page 280
Some transmission fluids may be labeled as dual usage, such as MERCON and MERCON V. These dual usage fluids are not to be used in an automatic transmission that requires use of the MERCON type fluid. However, these dual usage fluids may be used in transmissions that require the MERCON V type
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
-
249
-
250
-
251
-
252
-
253
-
254
-
255
-
256
-
257
-
258
-
259
-
260
-
261
-
262
-
263
-
264
-
265
-
266
-
267
-
268
-
269
-
270
-
271
-
272
-
273
-
274
-
275
-
276
-
277
-
278
-
279
-
280
 |
 |
Before driving
Introduction
2
Instrumentation
8
Controls and features
21
Seating and safety restraints
104
Starting and driving
Starting
147
Driving
152
Roadside emergencies
178
Servicing
Maintenance and care
201
Capacities and specifications
248
Customer assistance
257
Reporting safety defects
270
Index
271
All rights reserved. Reproduction by any means, electronic or mechanical including
photocopying, recording or by any information storage and retrieval system or translation
in whole or part is not permitted without written authorization from Ford Motor Company.
Ford may change the contents without notice and without incurring obligation.
Copyright © 2000 Ford Motor Company
Contents
1