2003 Hyundai Tiburon Owner's Manual - Page 145

DO-IT-YOURSELF MAINTENANCE G180A01A-AAT G190A01A-AAT G200A01A-AAT CHECKING BRAKE PEDAL CLEARANCE CHECKING DRIVE BELTS DOHC Water Pump Pulley 0.2 ~ 0.24 in. (5.1 ~ 6 mm) V6 Power steering Auto tensioner CHECKING AND REPLACING FUSES Replacing a Fusible Link 1.78 in. (45.1 mm) Generator COMP Eng.pulley G190A01GK Bad Good Generator Pulley Crankshaft Pulley SSA6180A You need a helper to check the brake pedal clearance. With the engine running, have your helper press down on the brake pedal several times and then hold it down with a force of about 110 lbs (50 kg, 490 N). The brake pedal clearance is the distance from the top surface of the brake pedal to the asphalt sheeting under the floor mat. If the brake pedal clearance is not within the limits specified in the illustration, have it inspected by your Hyundai dealer and adjusted or repaired if necessary. Drive belts should be checked periodically for proper tension and adjusted if necessary. At the same time, belts should be examined for cracks, wear, fraying or other evidence of deterioration and replaced if necessary. Belt routing should also be checked to be sure there is no interference between the belts and other parts of the engine. After a belt is replaced, the new belt should be adjusted again after two or three weeks to eliminate slack resulting from initial stretching after use. AS60310A A fusible link will melt if the electrical circuits from the battery are ever overloaded, thus preventing damage to the entire wiring harness. (This could be caused by a short in the system drawing too much current.) If this ever happens, have a Hyundai dealer determine the cause, repair the system and replace the fusible link. The fusible links are located in a relay box for easy inspection. CAUTION: When replacing a fusible link, never use anything but a new fusible link with the same or lower amperage rating. Never use a piece of wire or a higher-rated fusible link. This could result in serious damage and create a fire hazard. 6-14