2013 Kawasaki Jet Ski Ultra 300LX Owners Manual
2013 Kawasaki Jet Ski Ultra 300LX Manual
2013 Kawasaki Jet Ski Ultra 300LX manual content summary:
- 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 1
- 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 2
- 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 3
the possibility for an accident resulting in serious injury or death. To reduce the risk of severe injury or death, thoroughly read this owner's manual before operating your JET SKI watercraft. To reduce the risk of SEVER INJURY or DEATH: WEAR A PERSONAL FLOTATION DEVICE (PFD). All riders must wear - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 4
course is recommended and may be required in your state. ATTACH ENGINE SHUT-OFF CORD (LANYARD) to wrist and keep it free from handlebars so that the engine stops if operator falls off. After riding, remove the cord from PWC to avoid unauthorized use by children or others. RIDE WITHIN YOUR LIMITS AND - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 5
OPERATE DEFENSIVELY at safe speeds and keep a safe distance away from people, objects, and other watercraft. • Do not follow directly behind PWCs or other boats. • Do not go near others to spray or splash them with water. •Avoid sharp turns or other maneuvers that make it hard for others to avoid - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 6
care of your new JET SKI watercraft. Here are some of the cautions contained in this manual which must be followed for the protection of your watercraft. Be sure to read this Owner's Manual and understand it thoroughly before operating your watercraft. Rolling the watercraft to its STARBOARD side - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 7
use or every year, whichever comes first; and then every 50 hours or every year, whichever comes first. The jet pump bearings should also be serviced before any prolonged storage to prevent any water that may be left in the pump from corroding the bearings and causing premature failure. Moisture in - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 8
- 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 9
Quick Reference Guide This Quick Reference Guide will assist you in finding the information you're looking for. GENERAL INFORMATION OPERATING INSTRUCTIONS STORAGE MAINTENANCE AND ADJUSTMENTS TROUBLESHOOTING GUIDE ENVIRONMENTAL PROTECTION j j j j j j A Table of Contents is included after the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 10
Whenever you see the symbols shown below, heed their instructions! Always follow safe operating and maintenance practices. DANGER DANGER indicates a hazardous situation which, if not avoided, will result in death or serious injury. WARNING WARNING - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 11
-FOR-USPS, WWW. USPS. ORG To ensure a long, trouble-free life for your JET SKI watercraft, give it the proper care and maintenance described in this manual. For those who would like more detailed information on their JET SKI watercraft, a Service Manual is available for purchase from any authorized - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 12
available at the time of printing. However, there may be minor differences between the actual product and illustrations and text in this manual. All products are subject to change without prior notice or obligation. KAWASAKI HEAVY INDUSTRIES, LTD. Motorcycle & Engine Company © 2012 Kawasaki Heavy - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 13
Amplifier Indicator/"Innb" Character/ Warning Indicator Light...Immobilizer Key Matching Indicator/"I9nI" Character/Warning Indicator Light...Communication Trouble Indicator/"Err" Character/Warning Indicator Light...Fuel ...Fuel Requirements ...Filling the Tank ...Engine Oil...Oil Requirements...Oil - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 14
...Storage Compartment ...Center and Rear Storage Cases ...Accessory ...Tool Kit...Bilge Systems...Drain Screws ...Reboarding Step ...OPERATING INSTRUCTIONS ...Safe Operation ...Operation by Children ...Operation by unskilled riders...Operator Swimming Ability ...Maximum Number of Persons...Safe - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 15
Clearance ...Spark Plugs ...Battery ...Lubrication...Cooling System Flushing...Bilge System Flushing ...Jet Pump Bearings/Seals ...Fuses...TROUBLESHOOTING GUIDE...YOUR WARRANTY/OWNER SATISFACTION ...REPORTING SAFETY DEFECTS ...ENVIRONMENTAL PROTECTION ...MAINTENANCE RECORD ... 146 150 151 153 158 - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 16
14 SPECIFICATIONS SPECIFICATIONS JET SKI WATERCRAFT - MODELS JT1500H/J INBOARD BOAT LESS THAN 4.8 M (16 FEET) IN LENGTH Engine: Type Displacement Bore and Stroke Compression Ratio Ignition System Lubrication System Fuel System Starting System Tuning Specifications: Spark Plug Gap Terminal Ignition - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 17
SPECIFICATIONS 15 Drive System: Coupling Jet Pump: Steering Braking *Performance: Minimum Turning Radius Fuel Consumption Cruising Range Dimensions: Overall length Overall width Overall Height Curb Mass Air Draft (1) Maximum Draft (2) Fuel Tank Capacity Engine Oil: Type Viscosity Oil Capacity API SG - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 18
16 SPECIFICATIONS Electrical Equipment: Battery 12 V 18 Ah (1) Vertical distance between the floating plane in the light craft condition and the highest point of the craft structure, namely the handle top. (2) Draft in the fully loaded craft condition. * The information shown here represents - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 19
GENERAL INFORMATION 17 GENERAL INFORMATION Serial Numbers The hull and engine identification numbers are used to register the boat. They are the only means of identifying your particular machine from others of the same model. These serial numbers may be needed by your dealer when ordering parts. In - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 20
18 GENERAL INFORMATION j Parts Location A. B. C. D. E. Battery Rear View Mirror Front Storage Case Multifunction Meter Left Handlebar Switch Housing Engine Start/Stop Button Fuel Economy Assistance Mode Button Electric Trim-control Button F. Throttle Lever G. Handlebars H. Right Handlebar Switch - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 21
GENERAL INFORMATION 19 j A. Towing Eyes B. Engine Flushing Port C. Intercooler Flushing Port D. Reboarding Step E. Reverse Bucket F. Exhaust Outlet G. Drain Screws H. Steering Nozzle A. Jet Pump Cover B. Water Intake C. Grate D. Drive Shaft E. Speed Sensor - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 22
20 GENERAL INFORMATION j Label Location All warning labels which are on your vehicle are repeated here. Read labels on your vehicle and understand them thoroughly. They contain information which is important for your safety and the safety of anyone else who may operate your vehicle. Therefore, it - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 23
GENERAL INFORMATION 21 j A. Notice/Warning (Tether Switch) B. Fire Extinguisher C. Emission Label D. Notice/Warning (Grab Handle & Step) E. Notice (Flushing) - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 24
22 GENERAL INFORMATION j F. Warning (Damper) G. Warning (Gasoline) H. Fuel Information I. NMMA Label J. Notice/Warning (Important Safety) K. Notice (Righting) L. Exhaust Emission Information - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 25
GENERAL INFORMATION 23 j M. Battery Danger/Poison - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 26
24 GENERAL INFORMATION (A) j - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 27
GENERAL INFORMATION 25 (A) j - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 28
26 GENERAL INFORMATION (B) (D) j (C) - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 29
GENERAL INFORMATION 27 (E) (G) j (F) (H) - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 30
28 GENERAL INFORMATION (I) j - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 31
GENERAL INFORMATION 29 (J) j - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 32
30 GENERAL INFORMATION (K) (M) j (L) - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 33
GENERAL INFORMATION 31 j Environmental Hang Tag - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 34
32 GENERAL INFORMATION j One Star - Low-Emission The one-star label identifies engines that meet the California Air Resources Board's 2001 exhaust emission standards. Engines meeting these standards have 75% lower emissions than conventional carbureted two-stroke engines. These engines are - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 35
GENERAL INFORMATION 33 j Registration Numbers The graphic design of your JET SKI watercraft provides a specific location on each side for the registration numbers and validation decals. A. Location for Registration Number B. Location for Validation Decal A. Location for Registration Number B. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 36
34 GENERAL INFORMATION letters must be equal to the width of any letter except "I" or any number except "1." j Multifunction Meter Ahead of the steering handlebars is a multifunction meter. When the ignition switch is turned on, all displays on the panel are shown together with the warning - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 37
GENERAL INFORMATION 35 j 1. "MODE" Button 2. "SET" Button 3. Multifunction Display Clock Time/Trip/Hour Meters Tachometer (Numerical Value) Maximum Speed & Engine rpm Water Temperature Outside Temperature 4. FI Indicator 5. Engine Cooling Water Temperature Indicator 6. Immobilizer Indicator 7. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 38
36 GENERAL INFORMATION Speedometer The speedometer shows the speed of the watercraft. During a sharp turn the speed shown can be 6 to 12 mph (10 to 20 km/h) lower than the actual speed. Tachometer The tachometer shows the engine speed in revolutions per minute (rpm). On the right side of the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 39
GENERAL INFORMATION 37 Boost Meter The boost meter segments show the amount of boost pressure produced by the supercharger. If the segments do not go on when the engine is running, have your authorized JET SKI watercraft dealer check the supercharger and meter unit. Clock j 1. 2. 3. 4. 5. A. Boost - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 40
38 GENERAL INFORMATION NOTE j żPushing the "MODE" button momentarily advances the hour or minute step by step. Holding the button down advances the hour or minute continuously. żThe clock works normally from the back-up power while the ignition switch is turned off. żWhen the battery is - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 41
GENERAL INFORMATION 39 Time Meter The time meter shows the time passed since it was last reset to zero. To reset the time meter: 1. Push and hold the "SET" button. All the displays in this mode start blinking. 2. After two seconds the displays stop blinking and the hour and minute display turns back - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 42
40 GENERAL INFORMATION Trip Meter The trip meter shows the distance traveled since it was last reset to zero. To reset the trip meter: 1. Push the "SET" button and hold it in. All the displays in this mode start blinking. 2. After two seconds the displays stop blinking and the figure display turns - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 43
GENERAL INFORMATION 41 Hour Meter The hour meter shows the total hours that the watercraft has been operated. This meter cannot be reset. j Tachometer (Numerical Value) The tachometer shows the engine speed in revolutions per minutes (rpm). NOTE żThe data is maintained even if the battery is - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 44
42 GENERAL INFORMATION Maximum Speed & Engine rpm The maximum speed ever recorded since last reset and its corresponding engine rpm are shown. "RPM" symbol blinks in this mode. j To reset this record: Push the "SET" button and hold it. All the displays in this mode start blinking. 2. After two - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 45
GENERAL INFORMATION 43 Water Temperature This display shows the ambient water temperature by numerical value. The water temperature display is renewed every 5 seconds. Economical Riding Indicator When the operator is driving the watercraft for optimum fuel-efficiency, the economical riding indicator - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 46
44 GENERAL INFORMATION Fuel Economy Assistance Indicator This indicator shows the operating state of the fuel economy assistance mode. For more detailed information about the fuel economy assistance mode, see the Fuel Economy Assistance Mode in the Controls section. j A. Electric Trim-control - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 47
GENERAL INFORMATION 45 Fuel Level Gauge/"FUEL" Character/Warning Indicator Light The fuel level is shown in segments. All fuel segments are displayed when the fuel tank is full. As the fuel is consumed, the segments go out accordingly. When the last segment is reached, it begins blinking (E mark). - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 48
controlled to 3 000 rpm. Return to shore immediately and check the cooling system for clogging (see the Special Procedures section in the Operating Instructions chapter). Buzzer sound will stop when any button is held down for more than one second. j NOTICE To prevent engine damage, do not - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 49
controlled to 3 000 rpm. Return to the shore immediately and have your authorized Kawasaki JET SKI watercraft dealer check your boat to determine the suspected problem. Hold down any button for more than one second to stop the buzzer sound. j - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 50
than a clogged cooling system or low oil level, have your authorized Kawasaki JET SKI watercraft dealer check your boat to determine the suspected problem (see the TROUBLE SHOOTING for the causes listed Engine RPM does not increase more than 3 000). Hold down any button for more than one second to - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 51
GENERAL INFORMATION 49 Immobilizer Amplifier Indicator/"Innb" Character/ Warning Indicator Light If the amplifier for the immobilizer system should fail to function properly, the warning indicator light, the immobilizer indicator and the "Innb" character blink with buzzer sound to warn the operator. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 52
Character/Warning Indicator Light If there should be a trouble in communication between the multifunction meter and the Electronic gasoline with a minimum Antiknock Index of 90. The Antiknock Index is posted on service station pumps in the U.S.A. The octane rating of a gasoline is a measure of - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 53
rating. Gasoline quality is important. Fuels of low quality or not meeting standard industry specifications may result in unsatisfactory performance. Operating problems that result from the use of poor quality or nonrecommended fuel may not be covered under your warranty. Fuels Containing Oxygenates - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 54
fuel system. Before storage it is recommended that you drain all fuel from the fuel tank and fuel system. See the Storage section in this manual. Filling the Tank WARNING Gasoline is extremely flammable and can be explosive under certain conditions. To avoid a possible fire or explosion, pull the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 55
GENERAL INFORMATION 53 Remove the seats and observe the fuel level in the fuel tank to avoid overfilling when filling. Also observe the fuel level gauge on the meter for the segments to increase while filling. Fill the tank with the recommended octane rating gasoline. The use of a small diameter - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 56
vehicle. Consistent use of these products meets or exceeds warranty and service requirements and can help to extend the life of your Kawasaki oil if necessary. Refer to the Pre-Ride Check List in Operating Instruction chapter. Whenever you check the oil level, keep your watercraft level side to side - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 57
GENERAL INFORMATION 55 the dipstick, wipe it dry and insert it back • Remove into the dipstick tube so that the finger grip is positioned toward the left side of the hull, and then remove it again to check the oil level. NOTE j żBe careful when reading the dipstick as different level marks on the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 58
56 GENERAL INFORMATION j NOTICE Dirt and other foreign materials can cause serious engine damage. To prevent engine damage, do not allow dirt or foreign materials to enter the engine. Controls Steering Handlebars A. Handlebars The steering handlebars allow the ride to control direction of the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 59
GENERAL INFORMATION 57 Tilt Lever The handlebar tilt can be changed to your choice. Push down the tilt lever and move the handlebars up or down, you can select the best position in five different angles. Kawasaki Smart SteeringTM (KSSTM) Your JET SKI watercraft provides turning action under certain - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 60
58 GENERAL INFORMATION Important Information When you make an emergency maneuver: YOU MUST HAVE THRUST TO TURN, so keep the throttle on or apply throttle as needed to maintain thrust at the jet nozzle. You can turn quicker by applying the throttle as needed and not relying upon the steering system. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 61
and the engine shut-off lanyard key must be pushed under the stop button. żRefer to the Starting the Engine section in the Operating Instructions chapter. Throttle Lever The throttle lever is located on the right hand side of the handlebars. Squeezing the lever towards the handlebar grip increases - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 62
alert any passengers before shifting to reverse. Refer to the Operating the JET SKI Watercraft in Reverse section in the OPERATING INSTRUCTIONS chapter. Fuel Economy Assistance Mode This watercraft is equipped with a fuel economy assistance mode that helps maximize fuel efficiency. Activating the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 63
GENERAL INFORMATION 61 Fuel Economy Assistance Mode Deactivation omy assistance mode. j the fuel economy assistance mode button for • Push more than 2 seconds to deactivate the fuel econ- NOTE żRider input affects vehicle fuel efficiency. Fuel consumption may not change due to sudden start or - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 64
62 GENERAL INFORMATION activated, "8 km/h" ("5 mph") in the speedometer starts blinking. j NOTE żWhen the one-touch 5 mph mode is activated, the buzzer sounds two times. One-touch 5 mph Mode Deactivation deactivate the one-touch 5 mph mode, perform • To either one of the following two - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 65
GENERAL INFORMATION 63 Electronic Cruise Control Mode Activation j the throttle lever until the desired engine • Operate speed is reached. the set button on the right switch housing to • Push activate the electronic cruise control mode. sure that the mode has changed by the buzzer • Be sounds and - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 66
64 GENERAL INFORMATION Electronic Cruise Control Mode Deactivation the throttle lever will • Releasing electronic cruise control mode. deactivate the j NOTE żWhen the electronic cruise control mode is deactivated, the buzzer sounds three times. Watercraft Speed Adjustment When the electronic - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 67
GENERAL INFORMATION 65 Trim angle adjustment The electric trim-control button on the left handle switch housing is used to adjust the trim angle. To put the bow up, push the upper side of the button. To put the bow down, push the lower side of the button. appropriate direction and the jet nozzle - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 68
66 GENERAL INFORMATION j Keys Your JET SKI watercraft has electronic keys used to activate the ignition switch in the FPO or SLO mode. These keys are programmed to match the engine's ECU and can only be duplicated by your Kawasaki dealer using at least one of the original keys. If both keys are - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 69
GENERAL INFORMATION 67 j A. FPO Key (Full Power Operation Mode: orange-colored) B. SLO Key (Smart Learning Operation Mode: yellow-colored and marked SLO) And when SLO key is inserted: NOTE żThe ignition key floats on water by itself, however, when being attached to an accessory or accessories - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 70
68 GENERAL INFORMATION NOTE j żWhen shifted to the SLO mode, the initial display, as shown when the ignition switch is turned on, is shown together with a buzzer sound. żThen, "SLO" is shown blinking every three seconds. żWhen shifted to the normal operation mode (Full Power Operation mode, FPO), - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 71
an alarm buzzer and warning indicator light blinks at the multifunction meter. Alarms are also given if immobilizer system causes any trouble, see Multifunction Meter section in this chapter. j NOTE żSince the immobilizer system uses the electric wave for communication, key identification error - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 72
70 GENERAL INFORMATION Declaration of conformity FCC Warning Changes or modifications not expressly approved by the party responsible for compliance could void the user's authority to operate the equipment. This device complies with Part 15 of the FCC Rules and RSS-Gen of IC Rules. Operation is - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 73
GENERAL INFORMATION 71 JT1500J Model JT1500H Model j A. Rear Seat B. Latch Handle A. Front Seat B. Latch Handle - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 74
be held by the observer who faces rearward to watch the water skier. It is not designed for any other purposes. See page 90 for instructions on where to attach tow ropes. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 75
GENERAL INFORMATION 73 j Storage Compartment The box type storage case is located in the bow. Store this Owner's Manual, put in a plastic bag, in the storage case. To open the lid, pull the knob and raise the lid all the way up. To close - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 76
74 GENERAL INFORMATION j Center and Rear Storage Cases There is a center storage case in front of the seat. The ignition switch is inside this case. To open the lid, pull the knob. To close the lid, push the knob until it latches. A. Battery (Fuse) Cover B. ECU Cover C. Drain Plug NOTICE Running - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 77
GENERAL INFORMATION 75 j Accessory (For JT1500J model only) A specified GPS device (not supplied) can be installed under the cover on the center of the handlebar if necessary. A separate mounting bracket (not supplied) is required to install the GPS device. A. Rear Storage Case B. Drain Plugs A. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 78
76 GENERAL INFORMATION j Tool Kit The tool kit container is stored at the back of the rear seat. Unhook the rubber straps to remove the tool kit. A. GPS device (not supplied) Usable GPS devices: GARMIN 72/76 series (76C and 76CSx are included.) A. Tool Kit B. Rubber Straps - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 79
GENERAL INFORMATION 77 j Bilge Systems This watercraft is equipped with a jet vacuum drainage system at the rear end of the engine compartment. This system utilizes the water jet for propulsion to drain the bilge in the engine compartment. This system functions when the engine is running on the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 80
by using this step and the hand rail behind the rear end of the seat (see the Safe Operation and Launching sections in the OPERATING INSTRUCTIONS chapter). Also, this step is designed only for reboarding from deep water, so it should not be used for pulling other crafts. WARNING The reboarding - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 81
OPERATING INSTRUCTIONS 79 OPERATING INSTRUCTIONS Safe Operation Operation by Children Unskilled operators should practice operation of the craft using the SLO mode until they become more familiar with its operation. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 82
80 OPERATING INSTRUCTIONS WARNING Overloading this watercraft can adversely affect handling and stability which can lead to an accident. To reduce the risk of having an accident, do - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 83
OPERATING INSTRUCTIONS 81 before opening throttle. Do not try to throw off passengers. recommends that the operator and pas• Kawasaki sengers of personal watercraft wear protective swimwear - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 84
82 OPERATING INSTRUCTIONS if it is capsized (see Righting the Capsized Watercraft in the Riding the JET SKI Watercraft section). Never operate the watercraft after dark. It was - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 85
OPERATING INSTRUCTIONS 83 Jet Pump Safety Although the jet pump is inherently safer than a propeller drive, certain safety precautions must always be observed. Keep your hands, feet, - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 86
84 OPERATING INSTRUCTIONS Drowning Hazard: a personal flotation device (PFD) must be worn by the operator and passengers. Kawasaki recommends that the operator and passengers wear a vest-type PFD (type 1, 2 or 3) at all times. j - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 87
OPERATING INSTRUCTIONS 85 WARNING Water spray can impair your vision, injure the eyes and create the potential for an accident resulting in injury or death. To prevent - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 88
86 OPERATING INSTRUCTIONS Watercraft Helmet...Something You Should Know A helmet could protect your head, but could contribute to neck injuries. Before wearing a helmet on a personal watercraft you must - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 89
and result in an unsafe riding condition. Before you ride the watercraft, make sure that it is not overloaded and that you have followed these instructions. Load Capacity Limits 3 persons or 225 kg (496 lb) including cargo. Cargo carried in open storage area must not exceed 23 kg (50 lb). With - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 90
88 OPERATING INSTRUCTIONS We strongly recommend that all parts and accessories you add to your and not interfere with the operation of the watercraft. Do not carry animals on your watercraft. You should instruct any passenger before riding to hold on to the person in front of them or hand strap; or - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 91
OPERATING INSTRUCTIONS 89 Pulling a Water Skier, Tuber, Wakerboarder, etc. Water skiing should be considered a three person team sport. Do not consider the rear view mirrors as an - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 92
90 OPERATING INSTRUCTIONS power to raise the skier. Ease up on the throttle once the skier is up. Remember, before pulling up the skier, double check the path - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 93
OPERATING INSTRUCTIONS 91 Navigation Rules The navigation rules or nautical "rules of the road" are like highway traffic laws. They dictate who has the right -way over power boats in nearly all cases. Stay clear of these craft and do not create a wake which may cause them trouble. j A. Towing Eyes - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 94
92 OPERATING INSTRUCTIONS Overtaking and Passing Situation Meeting Situation j If you are meeting another power boat head on, neither you nor the other boat has right-of-way. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 95
OPERATING INSTRUCTIONS 93 Crossing Situation carefully for a water skier or any towed object. Pass behind the object in tow. If you have another boat on the left, - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 96
94 OPERATING INSTRUCTIONS Pre-ride Checklist Each day before using the watercraft, check the following items: Check Outside Craft Ƒ CLEAN PUMP - Clear the water intake, jet pump, and - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 97
OPERATING INSTRUCTIONS 95 Ƒ FIRE EXTINGUISHER - Check your fire extinguisher for a full charge. Ƒ FUEL PRESSURE - Loosen the fuel tank cap to relieve any pressure, then tighten the cap - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 98
96 OPERATING INSTRUCTIONS Break-In A new watercraft should be ridden with care during an authorized Kawasaki JET SKI dealer after the first ten hours of operation for initial maintenance service. See the Periodic Maintenance Chart in the MAINTENANCE AND ADJUSTMENTS chapter. Stopping the Engine The - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 99
OPERATING INSTRUCTIONS 97 WARNING JET SKI watercraft requires throttle (thrust) to steer and help you to avoid objects - you have no directional control when the engine is stopped. If the throttle fails, do not operate the watercraft until the source of the problem is found and corrected. j - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 100
NOTICE Starting the Engine the Pre-ride Checklist in this manual and • Read follow its instructions before putting the watercraft transporting or refueling and before starting • After the engine, open the front storage compartment lid and remove the seats for several - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 101
OPERATING INSTRUCTIONS 99 section in GENERAL INFORMATION chapter for more details. sure Wait 15 seconds before trying again. If the engine does not start after several attempts, see the TROUBLESHOOTING GUIDE chapter. • Excessive idling can foul the spark plugs. Check that water comes out of the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 102
100 OPERATING INSTRUCTIONS Launching Launching from a Dock Do not jump onto the watercraft from the dock. First place one foot on the deck near the dock, then while - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 103
OPERATING INSTRUCTIONS 101 NOTICE Avoid quick turns or acceleration when leaving the dock, or you might hit the dock and damage the watercraft. The operator should make - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 104
102 OPERATING INSTRUCTIONS WARNING The reboarding step is adjacent to the jet pump nozzle, and water and/or debris ejected from the jet thrust nozzle can cause severe - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 105
OPERATING INSTRUCTIONS 103 Stopping the JET SKI Watercraft Normal Stopping WARNING This high-performance watercraft is capable of high speeds that can be hazardous when directly approaching - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 106
104 OPERATING INSTRUCTIONS Releasing the throttle slows forward motion but the engine will still be running, so you can steer the boat after reapplying the throttle. In this - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 107
OPERATING INSTRUCTIONS 105 Stopping Skills Stopping distance depends partially on rider and passenger weight and position, idle set speed, and operating speed. Experienced operators can usually shorten - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 108
106 OPERATING INSTRUCTIONS Using the throttle is another important part of turning maneuvers. Applying the throttle produces thrust from the jet pump giving you directional control over the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 109
OPERATING INSTRUCTIONS 107 If you release the throttle completely, there is little thrust of the jet pump. The boat turns slowly and steering ability is reduced. If - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 110
108 OPERATING INSTRUCTIONS WARNING This is a very maneuverable, sport watercraft and quick turns or sudden acceleration can cause the passengers to fall overboard, causing an accident with other - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 111
OPERATING INSTRUCTIONS 109 Docking the JET SKI Watercraft docking use the throttle efficiently both to • When control the craft's speed and to keep directional you are approaching - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 112
110 OPERATING INSTRUCTIONS Riding the JET SKI Watercraft On your first ride, straddle the craft and sit down on the seat. Familiarize yourself with the handling of the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 113
OPERATING INSTRUCTIONS 111 best way to hit the water is bottom first, legs • The together, with your arms over your head. This can back aboard from the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 114
112 OPERATING INSTRUCTIONS NOTICE If the engine continues running with the craft capsized, water can enter the supercharger, throttle body and engine, locking the engine and causing severe - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 115
OPERATING INSTRUCTIONS 113 the load on yours, and prevent it from taking on more water. the watercraft slowly to shore, beach it, and • Tow drain the water - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 116
114 OPERATING INSTRUCTIONS Summary of the steps Details of the steps 1. Remove A. Air Box B. Drain Cap 4. 5. 6. If there is water, take the watercraft to the dealer for services immediately since there is a great possibility that water has entered the supercharger and the engine. If there is no - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 117
OPERATING INSTRUCTIONS 115 WARNING A water and gasoline mixture will be forcibly out from the plug holes, discharge the water and take the watercraft to your authorized dealer for services immediately. Do not operate the starter for longer than 5 seconds. Wait 15 seconds before using it again - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 118
116 OPERATING INSTRUCTIONS 14. Remove the dipstick and check for water presence in the engine oil. (If there is water, oil protect the environment, do not discard gasoline; always return it to an authorized recycling center. 18. Continued trouble may require cleaning of the fuel line to drain water. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 119
OPERATING INSTRUCTIONS 117 19. Open the front storage lid, remove the storage case and check for water in the storage compartment. If necessary, drain the water from - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 120
118 OPERATING INSTRUCTIONS NOTICE Running the engine with the watercraft out of the water for more than 15 seconds at a time will cause overheating resulting in engine and - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 121
OPERATING INSTRUCTIONS 119 using a maintenance charger (see the Battery section in the MAINTENANCE AND ADJUSTMENT chapter). Wipe the engine compartment dry, and install the seats. When the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 122
throttle. NOTICE Towing the JET SKI Watercraft In case you run out of fuel, have engine problems or other complications, the watercraft may be towed. Attach one end of a 6 m ( NOTICE It is important that these instructions be followed or the engine compartment could flood and the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 123
OPERATING INSTRUCTIONS 121 Jump Starting If your watercraft's battery is run down, it should be removed and charged. If this is not practical, a booster battery and jumper - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 124
122 OPERATING INSTRUCTIONS the other end of the remaining jumper • Connect cable to the exhaust pipe bolt. NOTICE Do not operate the starter continuously for more than 5 seconds - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 125
OPERATING INSTRUCTIONS 123 NOTICE If the engine overheats, the warning indicator light goes on and "HEAt" or "OILH" characters, with engine cooling water temperature indicator or engine - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 126
124 OPERATING INSTRUCTIONS Electronic Throttle Valve (ETV) System This watercraft has the ETV system which opens and closes the throttle valve electrically, not to the shore immediately and have your authorized Kawasaki JET SKI watercraft dealer check your boat to determine the suspected problem. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 127
watercraft so that when the time comes to use it again, it will be in top condition. See your Kawasaki JET SKI dealer for this service or do the following. Preparation for Storage Cooling System Clean the cooling system (see the Cooling System Flushing section in the MAINTENANCE AND ADJUSTMENTS - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 128
126 STORAGE Bilge System Remove the handrail plate. • j A. Blow air through all two hoses. B. Breather Fitting A. Nuts B. Handrail Plate • Clean the bilge system (see the Bilge System Flushing section in the MAINTENANCE AND ADJUSTMENTS chapter), and before reconnecting the four hoses to the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 129
STORAGE 127 WARNING Gasoline is extremely flammable and can be explosive under certain conditions. To avoid a possible fire or explosion, pull the lanyard key off the stop button. Do not smoke. Make sure the area is well ventilated and free from any source of flame or sparks; this includes any - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 130
128 STORAGE fogging oil directly into each cylinder. • Spray Turn the over several times with the start • button to engine coat the cylinder walls. WARNING An air/oil mist will be forcibly ejected from the spark plug holes and could injure your eyes. To prevent eye injury, do not lean over the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 131
). Jet Pump Bearings/Seals • Engine Mount Bracket Bolts Tighten all engine mount bracket bolts. NOTE j żWe recommend that you have this service done by your authorized dealer since it requires special tools. • • Supercharger Take the watercraft to your authorized dealer for the following - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 132
130 STORAGE bearings to corrode and fail prematurely. Major engine damage can occur if the jet pump bearings fail due to lack of maintenance. Cleaning Wash the exterior and dry it thoroughly. Semi-gloss Finish washing the watercraft, always use a mild • When neutral detergent and water. semi-gloss - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 133
131 Removal from Storage The following procedure explains the steps necessary to put the watercraft back in service following a storage period. See your Kawasaki JET SKI dealer for this service, or do the following. See the MAINTENANCE AND ADJUSTMENTS chapter for detailed procedures. Carry out all - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 134
132 STORAGE DANGER Exhaust gas contains carbon monoxide, a colorless, odorless poisonous gas. Inhaling carbon monoxide can cause serious brain injury or death. DO NOT run the engine in enclosed areas. Operate only in a well-ventilated area. the engine and run it for 15 seconds. Check • Start for - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 135
MAINTENANCE AND ADJUSTMENTS 133 MAINTENANCE AND ADJUSTMENTS The maintenance and adjustments outlined in this chapter must be carried out in accordance with the Periodic Maintenance Chart to keep the watercraft in good running condition. The initial maintenance is vitally important and must not be - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 136
the antiknock index is recommended. The antiknock index is posted on service station pumps in the U.S.A. Maintenance and Warranty Proper maintenance is recommended maintenance is carried out according to the instructions in this Owner's Manual at your own expense. The Kawasaki Limited Emission - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 137
MAINTENANCE AND ADJUSTMENTS 135 Periodic Maintenance Chart NOTE Complete the Pre-Ride Checklist before each outing. Frequency Initial 10 Description * * Inspect supercharger drive belt for wear/damage Apply corrosion protection coating to the supercharger rotors Inspect all hoses, hose clamps, nuts - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 138
136 MAINTENANCE AND ADJUSTMENTS Frequency Initial 10 Description Hours Every 25 Hours Every 50 Every 100 Hours Hours ż* Inspect/adjust valve clearances Inspect/clean air box drain cap Replace engine oil Replace engine oil filter * * Inspect/tighten engine mount bolts Inspect fuel vent check valve - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 139
25 Hours Every 50 Every 100 Hours Hours • *: These items must be performed with the proper tools. See an authorized Kawasaki JET SKI dealer for service, unless you have the proper equipment and mechanical proficiency (refer to the - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 140
watercraft is equipped with the supercharger and its intercooler, which play an essential role for high engine performance. Have your authorized dealer service them in accordance with the Maintenance Chart and Preparation for Storage. Moisture in the air drawn through the supercharger during use can - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 141
MAINTENANCE AND ADJUSTMENTS 139 Control Cables Throttle Cable Play Inspection There must be play in the throttle mechanism. Measure the distance the throttle lever moves before the engine begins to pick up speed. Play should be about 2 mm (0.08 in.). If there is improper play, adjust it. • • A. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 142
140 MAINTENANCE AND ADJUSTMENTS Steering Cable Adjustment the handlebars in a straight ahead steering • Center position. j A. Equal A. Handlebars it is not, adjust the steering cable. • If Loosen the locknut on the end of the steering ca• ble located to the right of the steering nozzle. that - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 143
MAINTENANCE AND ADJUSTMENTS 141 j A. B. C. D. Steering Nozzle Joint Bolt Locknut A. Joint B. Locknut the bolt and disconnect the cable joint • Remove from the steering nozzle. the handlebars in a straight ahead steering • Center position. • Turn the joint on the cable to adjust the steering. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 144
142 MAINTENANCE AND ADJUSTMENTS Trim-control Cable Adjustment Trim-control cable adjustment should be done by your authorized Kawasaki JET SKI dealer. Trim-control Cable Inspection Trim-control cable inspection is best performed by your authorized Kawasaki JET SKI dealer. If the steering feels - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 145
MAINTENANCE AND ADJUSTMENTS 143 Shift Cable Adjustment • Put the shift lever in the "F (Forward)" position. j A. Reverse Bucket B. Steering Nozzle A. Shift Lever ("F" position) lower edge of the bucket should be held • The above the top of the steering nozzle with slight play so it doesn't - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 146
144 MAINTENANCE AND ADJUSTMENTS lower stopper on the bucket should • The against the rear edge of the pump cover. rest j A. Stopper B. Pump Cover End A. Locknut B. Ball Joint C. Sleeve either position is incorrect, adjust the shift cable. • If Put the shift lever in Reverse. • Loosen the locknut - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 147
MAINTENANCE AND ADJUSTMENTS 145 Fuel System Throttle Adjustments Idle Speed Idle speed adjustment is best performed by your authorized Kawasaki JET SKI dealer. If the idle speed is unstable have your dealer inspect the throttle body. Idle Speed 1 300 ±100 rpm - in water 1 300 ±100 rpm - out of - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 148
146 MAINTENANCE AND ADJUSTMENTS Engine Oil System In order for the engine to function properly, maintain the engine oil at the proper level, and change the oil and replace the oil filter in accordance with the Periodic Maintenance Chart. Not only do dirt and metal particles collect in the oil, but - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 149
MAINTENANCE AND ADJUSTMENTS 147 a rag or cloth under the oil filter to receive the • Put remaining oil. • Remove the oil filter. j A. Oil Filler Cap B. Dipstick NOTICE Dirt and other foreign materials can cause serious engine damage. To prevent engine damage, do not allow dirt or foreign - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 150
when hot *Kawasaki Performance Oils and Lubricants have been specifically engineered for your vehicle. Consistent use of these products meets or exceeds warranty and service requirements and can help to extend the life of your Kawasaki. NOTE żDo not add any chemical additive to the oil. Oils - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 151
Check for oil leaks. • NOTE żThis procedure requires mechanical skills and tools. If you see it beyond your skill, ask your Kawasaki dealer for the services. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 152
measuring procedure with the watercraft afloat should be followed when the oil level is found low and to be added. See OPERATING INSTRUCTIONS chapter. Valve Clearance Valve and valve seats wear decreasing valve clearances, and upsetting valve timing. NOTICE If valve clearance is left unadjusted - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 153
MAINTENANCE AND ADJUSTMENTS 151 Spark Plugs Since the engine is water-cooled and is generally operated at a constant throttle opening, cylinder head temperature is relatively stable. For this reason, if the engine is in good condition and properly tuned, it should not be necessary to use a spark - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 154
electrodes appear overheated, or if there are gray metallic deposits on the plugs, combustion chamber temperatures are too high. Refer to the TROUBLESHOOTING GUIDE. NOTE żIf the plug is oily or has carbon built up. NOTICE Excessive operating temperature can cause serious engine damage. To prevent - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 155
MAINTENANCE AND ADJUSTMENTS 153 NOTE żBe sure to install the plug caps so that the spark plug wires are at a right angle to the engine center line. Battery The battery is located in the front storage compartment. Remove the battery recess cover in the front storage compartment. • j A. Spark - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 156
154 MAINTENANCE AND ADJUSTMENTS Quick Rivet Removal Quick Rivet Installation j A. Quick Rivet B. Central Pin C. Push in A. B. C. D. Quick Rivet Central Pin Pull up fully. Push in - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 157
MAINTENANCE AND ADJUSTMENTS 155 Battery Removal • the battery with fresh water. Dry it thoroughly and coat the terminals with waterproof grease. Perform a visual inspection. Inspect for defective or cracked case and cover, and loose or damaged terminal posts or cables. Replace battery and/or - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 158
sealed type, and the sealing strip should not be removed at any time after the specified electrolyte has been installed in the battery for initial service. It is not necessary to check the battery electrolyte level or add distilled water. However, in order to maximize battery life and ensure that it - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 159
MAINTENANCE AND ADJUSTMENTS 157 WARNING Lead is a toxic substance. Battery posts, terminals and related accessories contain lead and lead compounds. Wash hands after handling. Battery Sulfation A common cause of battery failure is sulfation. Sulfation occurs when the battery is left in a discharged - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 160
craft, adequate lubrication and corrosion protection is an absolute necessity to provide long, reliable service. Refer to the Periodic Maintenance Chart and Pre-ride Checklist in the OPERATING INSTRUCTIONS chapter for the frequency of the following items: Lubricate the following with a penetrating - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 161
MAINTENANCE AND ADJUSTMENTS 159 Steering Nozzle/Reverse Bucket Pivots Shift Link Ball Joint j A. Steering Nozzle Pivot B. Reverse Bucket Pivot A. Shift Link Ball Joint the following with a high quality water• Lubricate proof marine grease. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 162
160 MAINTENANCE AND ADJUSTMENTS Steering Link Joint Trim-control Link Ball Joints j A. Steering Joint A. Trim-control Link Ball Joint - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 163
MAINTENANCE AND ADJUSTMENTS 161 Trim-control Link Joint Throttle Cable Fitting at Throttle Case j A. Trim-control Link Joint A. Apply grease. • Lubrication of the other link joints should be performed by your Kawasaki JET SKI dealer. NOTICE Disassemble and lubricate the handlebar pivot. This - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 164
162 MAINTENANCE AND ADJUSTMENTS Cooling System Flushing To prevent sand or salt deposits from accumulating in the cooling system, it must be flushed occasionally. Flush the system according to the Periodic Maintenance Chart, after each use in salt water, or whenever there is reduced water flow from - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 165
MAINTENANCE AND ADJUSTMENTS 163 the engine idle for several minutes with the • Let water running. off the water. Leave the engine idling. • Turnthe engine few times to clear the water out of • Rev the exhaust system. Bilge System Flushing To prevent clogging, the bilge system should be flushed out - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 166
164 MAINTENANCE AND ADJUSTMENTS the engine stops or idles. It may be necessary to remove the fitting. j A. Bilge Hoses B. Breather Fitting the bilge filter hose (from the hull bottom) • Connect to the garden hose, turn the water on, and flush it out for about a minute. During this procedure, - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 167
use or every year, whichever comes first; and then every 50 hours or every year, whichever comes first. The jet pump bearings should also be serviced before any prolonged storage to prevent any water that may be left in the pump from corroding the bearings and causing premature failure. j A. Main - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 168
166 MAINTENANCE AND ADJUSTMENTS NOTICE Substituting fuses can damage the electrical system and may lead to a fire. To prevent damage and fire, do not substitute fuses. Replace the blown fuse with a new one of the correct capacity, as specified on the electric case. j A. Fuse Case B. Fuse C. Spare - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 169
TROUBLESHOOTING GUIDE 167 TROUBLESHOOTING GUIDE If this procedure does not isolate your problem, see your JET SKI dealer or refer to the Service Manual. j - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 170
168 TROUBLESHOOTING GUIDE j - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 171
TROUBLESHOOTING GUIDE 169 j - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 172
For? You are responsible for maintaining your watercraft according to the maintenance schedule shown in this owner's manual. You are responsible for taking your product to the dealer immediately if there is a problem, and you, as the owner, will need to authorize the dealer to inspect the unit. - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 173
, be sure to record your service in the Maintenance Record section of this Owner's Manual. Keep all receipts for the service and/or items necessary to perform watercraft if there is a failure, determining the cause of the problem, and getting any needed authorization from Kawasaki if the repair is - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 174
by a Kawasaki dealer. What if I am not Satisfied With My Warranty Service? If you aren't satisfied with your dealership's repair work or operations, dealership and work with it in resolving your problem. Want to Contact Kawasaki? This owner's manual should answer most of your questions about your - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 175
YOUR WARRANTY/OWNER SATISFACTION 173 Please send your correspondence to:. Consumer Services Kawasaki Motors Corp., U.S.A. P.O. Box 25252 Santa Ana, CA 92799-5252 (949) 460-5688 - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 176
exists in a group of watercrafts, it may order a recall and remedy campaign. However, the U.S.C.G. cannot become involved in individual problems between you, your dealer, or Kawasaki Motors Corporation, U.S.A. Please send your correspondence to:. Office of Boating Safety Product Assurance Division - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 177
ENVIRONMENTAL PROTECTION 175 ENVIRONMENTAL PROTECTION Kawasaki subscribes to the guidelines of Tread Lightly! a program dedicated to protecting the great outdoors through education and fostering responsible enjoyment of public lands. When using your Kawasaki JET SKI watercraft, please follow these - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 178
176 MAINTENANCE RECORD MAINTENANCE RECORD Owner Name...Address ...Phone Number ...Hull Number ...Engine Number ...Selling Dealer Name ...Address ...Phone Number ...Warranty Start Date ...Note: Keep this information and a spare key in a secure location. Date Engine Hours Maintenance Performed Dealer - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 179
MAINTENANCE RECORD 177 Date Engine Hours Maintenance Performed Dealer Name Dealer Address - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 180
178 MAINTENANCE RECORD Date Engine Hours Maintenance Performed Dealer Name Dealer Address - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 181
MAINTENANCE RECORD 179 Date Engine Hours Maintenance Performed Dealer Name Dealer Address - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 182
180 MAINTENANCE RECORD Date Engine Hours Maintenance Performed Dealer Name Dealer Address - 2013 Kawasaki Jet Ski Ultra 300LX | Owners Manual - Page 183
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
 |
 |
