2005 Toyota Highlander Warranty, Maitenance, Services Guide - Page 33

Maintenance Log: SUVs and Trucks 5,000-Mile Maintenance Intervals 7,500-Mile Maintenance Intervals To determine the appropriate maintenance interval for your vehicle, see page 16. 90,000 Miles or 108 Months u Replace engine oil and oil filter1 u Replace engine air filter u Rotate tires u Replace cabin air filter (if equipped) u Lubricate drive shaft bushing (Land Cruiser) u Lubricate propeller shaft4 u Lubricate wheel bearings (Land Cruiser) u Replace limited-slip differential oil, if equipped5 u Replace spark plugs6 u Replace timing belt7 u Re-torque drive shaft bolt (4WD RAV4) u Re-torque propeller shaft bolt (all models except Highlander and RAV4) u Inspect the following: __ Automatic transmission fluid __ Ball joints and dust covers __ Brake lines and hoses __ Brake linings/drums and brake pads/discs8 __ Drive belts __ Drive shaft boots3 __ Engine coolant9 __ Exhaust pipes and mountings __ Front differential oil (4WD models, Highlander and RAV4) __ Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses __ Fuel tank cap gasket __ Manual transmission oil (RAV4, Tundra) __ Radiator core and condenser __ Rear differential oil (all models except 2WD Highlander and 2WD RAV4) __ Steering gear box __ Steering linkage and boots __ Transfer case oil (all 4WD models) Dealer Service Verification: Additional Maintenance Items for Special Operating Conditions2 Driving in desert or on dirt roads: u Tighten nuts and bolts on chassis Driving while towing: u Replace front differential oil (2WD RAV4 with manual transmission, all 4WD models except RAV4 with automatic transmission and Highlander) u Replace manual transmission oil (RAV4, Tundra) u Replace rear differential oil, including limited slip (all models except 2WD Highlander and 2WD RAV4) u Replace transfer case oil (4WD models) u Tighten nuts and bolts on chassis Dealer Service Verification: Date: Mileage: Dealer Service Verification: 6 Applies to Tacoma with 1GR-FE, Tundra with 1GR-FE and 4Runner with 1GR-FE. Required under the terms of the Date: Emission Control Warranty. 7 Applies to Highlander with 3MZ-FE, Land Cruiser, Sequoia, Tundra with 2UZ-FE and 4Runner with 2UZ-FE. Mileage: 8 Inspect thickness measurement and disc runout. 9 See page 37 for details. 31