Acer Aspire 5738ZG Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv
Acer Aspire 5738ZG Manual
 |
View all Acer Aspire 5738ZG manuals
Add to My Manuals
Save this manual to your list of manuals |
Acer Aspire 5738ZG manual content summary:
- Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 1
Aspire 5738G/5738ZG/5738Z/5738/5338 Series Aspire 5536/5536G/5236 Series Service Guide Service guide files and updates are available on the ACER/CSD web; for more information, please refer to http://csd.acer.com.tw PRINTED IN TAIWAN - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 2
Revision History Please refer to the table below for the updates made on Aspire 5738G/5738ZG/5738Z/5738/5338 and Aspire 5536/5536G/5236 Series service guide. Date Chapter Updates II - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 3
by any means, electronic, mechanical, magnetic, optical, chemical, manual or otherwise, without the prior written permission of Acer Incorporated. Disclaimer The information in this guide is subject to change without notice. Acer Incorporated makes no representations or warranties, either expressed - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 4
Conventions The following conventions are used in this manual: SCREEN MESSAGES Denotes actual messages that appear on screen. NOTE WARNING CAUTION IMPORTANT Gives bits and pieces of additional information related to the current topic. Alerts you to any damage that might result from - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 5
supports, please read the following general information. 1. This Service Guide provides you with all technical information relating to the BASIC CONFIGURATION decided for Acer modem, or extra memory capability). These LOCALIZED FEATURES will NOT be covered in this generic service guide. In such cases - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 6
VI - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 7
29 Main 31 Security 33 Boot 37 Exit 38 BIOS Flash Utility 39 Remove HDD Password 40 Machine Disassembly and Replacement 43 Disassembly Requirements 43 General Information 44 Pre-disassembly Instructions 44 Disassembly Process 44 External Module Disassembly Process 45 External Modules - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 8
Problems 114 Connector Locations 115 Main Board 115 Clearing Password Check and BIOS Recovery 117 Clearing Password Check 117 BIOS Recovery by Crisis Disk 119 FRU (Field Replaceable Unit) List 123 Aspire 5738G/5738ZG/5738Z/5738/5338 Series and Aspire 5536/5536G/5236 Series Exploded - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 9
Chipset* • Acer InviLink™ Nplify™ 802.11b/g/Draft-N* • Acer InviLink™ 802.11b/g* For Aspire 5536/5536G/5236 Series AMD Better By MHz memory, upgradeable to 8 GB using two soDIMM modules* For Aspire 5536/5536G/5236 Series • Dual-channel SDRAM support • Up to 2 GB of DDR2 667 MHz memory, upgradeable to - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 10
Express Chipset* • NVIDIA® GeForce® G105M* For Aspire 5536/5536G/5236 Series: • ATI Radeon™ HD 3200 Graphics* • AATI Mobility Radeon™ HD 4570* • Screen resolution support • 1366*768 • 1280*768 • 1280*720 • 1024*768 • 800*600 Storage subsystem • 2.5" hard disk drive • Optical drive options: • Blu-ray - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 11
/5300* (For Aspire 5738G/5738ZG/5738Z/5738/5338 Series only) • Acer InviLink™ Nplify™ 802.11b/g/Draft-N* • Acer InviLink™ 802.11b/g* • WPAN: Bluetooth® 2.0+Enhanced Data Rate (EDR)* • LAN: Gigabit Ethernet; Wake-on-LAN ready • Modem: 56K ITU V.92; Wake-on-Ring ready I/O Ports • Acer Bio-Protection - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 12
System Block Diagram For Aspire 5738G/5738ZG/5738Z/5738/5338 Series: 4 Chapter 1 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 13
For Aspire 5536/5536G/5236 Series: Chapter 1 5 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 14
1 Acer Crystal Eye Web camera for video communication. webcam 2 Display screen Also called Liquid-Crystal Display (LCD), displays computer output (Configuration may vary by models). 3 Power button Turns the computer on and off. 4 3G Wireless LAN communication button/indicator Bluetooth - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 15
right) buttons. *The center button serves as Acer Bio-Protection fingerprint reader supporting Acer FingerNav 4-way control function (only for certain models). 9 Power1 Indicates the computer's power status. Battery1 Indicates the computer's battery status. 1. Charging: The light shows amber - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 16
Left View # 1 2 3 4 5 6 Icon HDMI Item DC-in jack Description Connects to an AC adapter. Ethernet (RJ-45) port HDMI port External display (VGA) port USB 2.0 port Line-in jack Microphone-in jack Connects to an Ethernet 10/100/1000-based network. Supports high definition digital video - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 17
to USB 2.0 devices (e.g., USB mouse, USB camera). Internal optical drive; accepts CDs or DVDs. Lights up when the optical drive is active. Ejects the optical disk from the drive. Ejects the optical drive tray when the computer is turned off. Note: Insert a paper clip to the emergency eject hole to - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 18
View Icon Item 1 Battery bay Description Houses the computer's battery pack. 2 Battery release latch Releases the battery for removal. 3 Battery lock Locks the battery in position. 4 Hard disk bay Houses the computer's hard disk (secured with screws). 5 Memory compartment Houses the - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 19
amber when the battery is charging. 2. Fully charged: The light shows green when in AC mode. Easy-Launch Buttons Located above the keyboard are application buttons. These buttons are called easy-launch buttons. They are: WLAN, Internet, email, Bluetooth, Arcade and Acer Empowering Technology. The - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 20
and your fingers - dry and clean. The touchpad is sensitive to finger Windows Control Panel. Using the Keyboard The keyboard has full-sized keys and an embedded numeric keypad, separate cursor, lock, Windows certain models. When Scroll Lock is on, the screen moves one line up or down when you press - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 21
off Type the letters in a normal manner. Windows Keys The keyboard has two keys that perform Windows-specific functions. Key Windows key Application key Description Pressed alone, this key has the same effect as clicking on the Windows Start button; it launches the Start menu. It can also be used - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 22
down Description Launches Acer eSettings in Acer Empowering Technology. Enables/disables Bluetooth function. Puts the computer in Sleep mode. Switches display output between the display screen, external monitor (if connected) and both. Turns the display screen backlight off to save power. Press any - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 23
on the keyboard, or hold and then press the key at the upper-center of the keyboard. NOTE: Some fonts and software do not support the Euro at the bottom-right of the keyboard, or hold and then press the key at the upper-center of the keyboard. NOTE: This function varies - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 24
dual-display compatible, allowing two displays to be partitioned independently. AcerGridVista is simple to set up: 1. Run Acer GridVista and select your preferred screen configuration for each display from the task bar. 2. Drag and drop each window into the appropriate grid. 3. Enjoy the convenience - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 25
NOTE: Please ensure that the resolution setting of the second monitor is set to the manufacturer's recommended value. Chapter 1 17 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 26
GM45/GL40/ PM45 Express Chipset Aspire 5536/5536G/5236: AMD M780G Chipset Aspire 5738G/5738ZG/5738Z/5738/5338: 478-pin micro-FCPGA Aspire 5536/5536G/5236: Socket S1 Aspire 5738G/5738ZG/5738Z/5738/5338: 1.0375V to 1.3V Aspire 5536/5536G/5236: 1.35V to 1.5V CPU Fan True Value Table DTS(degree C) 45 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 27
2048MB Slot 2 Total Memory 512MB 1024MB 2048MB 1024MB support compliant with ACPI 2.0 PCI v2.2 Bluetooth Interface Item Chipset Data throughput Protocol Interface Chapter 1 Specification Foxconn Bluetooth FOX_BRM_2.0 F/W 300 723 bps (full speed data rate) Bluetooth 1.1 (Upgradeable to Bluetooth - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 28
DC Power Requirements Voltage tolerance 5V(DC) +/- 5% USB Specification Specification Aspire 5738G/5738ZG/5738Z/5738/5338 Series: Foxconn Wireless LAN Atheros AR5B91 1x2 BGN/WLAN 802.11ABGN SHIRLEYPEAK1*2/Lan Intel WLAN 533AN_MMWG Shirley Peak MM#895362 Aspire 5536/5536G/5236 Series: Foxconn - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 29
rate (KB/sec) Buffer Memory Interface Applicable disc format Loading mechanism Power Requirement Input Voltage Specification SONY SUPER-MULTI DRIVE DL 8X AD-7590S LF SONY SUPER-MULTI DRIVE DL 8X AD-7580S LF TOSHIBA SUPER-MULTI DRIVE DL 8X TS-L633B LF With CD Diskette With DVD Diskette Sustained - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 30
Blu-Ray Disc Drive Item Performance Specification Transfer rate (KB/sec) Buffer Memory Interface Applicable disc format Loading mechanism Power Requirement Input Voltage With CD Disc Specification With DVD Disc With Blu-ray Disc Sustained: Max 3.6Mbytes/sec Sustained: Max 10.08Mbytes/sec - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 31
/5738ZG/5738Z/5738/5338 Series: Intel ICH-9M Aspire 5536/5536G/5236 Series: AMD SB700 N/A Aspire 5738G/5738ZG/5738Z/5738/5338 Series: Foxconn Delphi-AM5 V2H 1.5_3.3v AUS T60M951 Aspire 5536/5536G/5236 Series: Lite-On Conexant -Unizion 1.5_3.3v AUS RD02-D330 Foxconn Bluetooth FOX_BRM_2.0 F/W 300 23 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 32
Keyboard Item Keyboard controller Total number of keypads Windows logo key Internal & external keyboard work simultaneously Controller Aspire 5738G/5738ZG/5738Z/5738/5338 Series: Lan Intel WLAN 533AN_MMWG Shirley Peak/Foxconn Wireless LAN Wireless LAN Ralink RT2700E 1x2 BGN Aspire 5536/5536G/5236 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 33
. All devices in the system are turned off completely. Individual devices such as the CPU and hard disc may be power managed in this state. CPU set power down VGA Suspend PCMCIA Suspend Audio Power Down Hard Disk Power Down CD-ROM Power Down Super I/O Low Power mode Also called Hibernation Mode - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 34
26 Chapter 1 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 35
Setup. Please also refer to Chapter 4 Troubleshooting when problem arises. To activate the BIOS Utility, press F2 during POST (when "Press to enter Setup" message is prompted on the bottom of screen). Press F2 to enter setup. The default parameter of F12 Boot Menu is set to "disabled". If you - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 36
Navigating the BIOS Utility There are five menu options: Information, Main, Security, Boot, and Exit. Follow these instructions: • To choose a menu, shown on the bottom of the screen. Help for parameters are found in the Item Specific Help part of the screen. Read this carefully when making changes - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 37
Aspire 5536/5536G/5236 Series: -/+ Change Values F9 Setup Defaults Enter Select Sub-Menu F10 Save and Exit Information Phoenix SecureCore(tm) Setup Utility Main Security Boot Exit CPU Type: CPU Speed: IDE0 Model Name: IDE0 Serial Number: ATAPI Model Name: System BIOS Version: VGA BIOS - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 38
BIOS Version VGA BIOS Version KBC Ver Serial Number Asset Tag Number Product Name Manufacturer Name UUID Number Description This field shows the CPU system. Displays system BIOS version. This field displays the VGA firmware version of the system. This field shows the keyboard This field displays the - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 39
Values F9 Setup Defaults Select Menu Enter Select Sub-Menu F10 Save and Exit Aspire 5536/5536G/5236 Series: Information Phoenix SecureCore(tm) Setup Utility Main Security Boot Exit System Time: System Date: Total Memory: [10:10:10] [03/06/2009] 4096 KB Item Specific Help , - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 40
Screen is enabled. Enables, disables the system boot from LAN (remote server). Enables, disables Boot Menu during POST. Enables, disables D2D Recovery function. The function allows the user to create a hidden partition on hard disc drive to store operation system and restore the system to factory - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 41
the whole setup utility. It can be used to boot up when Password on boot is enabled. F1 Help Esc Exit Select Item -/+ Change Values F9 Setup Defaults Select Menu Enter Select Sub-Menu F10 Save and Exit NOTE: Please refer to "Remove HDD/BIOS Password" section if you need to know how to remove - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 42
Set User Password Set HDD Password Password on Boot Description Shows the setting of the Supervisor password Shows the setting of the user password. Shows the setting of the hard disk password. Press Enter to set the supervisor password. When set, this password protects the BIOS Setup Utility - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 43
parameter to "Set". 5. If desired, you can enable the Password on boot parameter. 6. When you are done, press F10 to save the changes and exit the BIOS Setup Utility. If the verification is OK, the screen will display as following. The password setting is complete after the user presses F10. If the - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 44
If the new password and confirm new password strings do not match, the screen will display the following message. 36 Chapter 2 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 45
in module bay, the onboard hard disk drive and the CD-ROM in module bay. Information Phoenix SecureCore(tm) Setup Utility Main Security Boot Exit Boot priority order: 1: IDE0: XXXXXXXXXXX-(XX) 2: CD/DVD: XXXXXXXXXXX-XXXXX-(X 3: Network Boot: XXXXXXXXXXXXXXXX 4: USB HDD: 5: USB FDD: 6: USB - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 46
screen contains parameters that confirmed or discard the changes made to the parameters in the BIOS Setup Utility. Information Phoenix SecureCore(tm) Setup Utility Main Security Boot The table below describes the parameters in this screen. Parameter Exit Saving Changes Exit Discarding Changes - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 47
Disk in Windows XP/Vista" on page 119)before you use the Flash utility. NOTE: Do not install memory-related drivers (XMS, EMS, DPMI) when you use the Flash. NOTE: Please use the AC adaptor power supply when you run the Flash utility. If the battery pack does not contain enough power to finish BIOS - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 48
This section teaches you how to remove HDD password: Remove HDD Password: • If you key in the wrong HDD password thrice, "HDD password error code" will appear on the screen. See the image below. • If you need to solve HDD password locked problem, you can run HDD_PW.EXE 1. Key in "hdd_pw 15494 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 49
Chapter 2 41 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 50
42 Chapter 2 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 51
Chapter 3 Machine Disassembly and Replacement This chapter contains step-by-step procedures on how to disassemble the notebook computer for maintenance and troubleshooting. Disassembly Requirements To disassemble the computer, you need the following tools: • Wrist grounding strap and conductive mat - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 52
Instructions Before proceeding with the disassembly procedure, make sure that you do the following: 1. Turn off the power to the system and all peripherals. 2. Unplug the AC adapter and all power and signal cables from the system. 3. Place the system on a flat, stable surface. 4. Remove the battery - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 53
entire disassembly sequence and instructs you on the components that need to be removed during servicing. For example, if you want to remove the main board, you must first remove the keyboard, then disassemble the inside assembly frame in that order. EXTERNAL MODULE DISASSEMBLY TURN OFF POWER AND - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 54
Removing the Battery Pack 1. Turn base unit over. 2. Slide the battery lock/unlock latch to the unlock position. Note: Battery has been highlighted with the yellow circle as above image shows. Please detach the battery and follow the local regulations for disposal. 3. Slide the battery release latch - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 55
Removing the SD Dummy Card 1. Push the SD dummy card all the way in to eject it. 2. Pull it out from the slot. Chapter 3 47 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 56
the DIMM Module 1. See "Removing the Battery Pack" on page 46. 2. Remove the one captive screw and one screw (A) securing the DIMM module cover. Size (Quantity) M2.5 x L8 (1) Black Color Torque 3 kgf-cm Part No. 86.00E34.738 3. Use a plastic screw driver to carefully pry open the DIMM module - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 57
out the latches on both sides of the DIMM socket to release the DIMM. 5. Remove the DIMM module. Removing the Back Cover 1. See "Removing the Battery Pack" on page 46. 2. See "Removing the SD Dummy Card" on page 47. 3. See "Removing the DIMM Module" on page 48. 4. Remove the two captive - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 58
5. Use a plastic screw driver to carefully pry open the back cover. 6. Remove the back cover from the lower case. Removing the Hard Disk Drive Module 1. See "Removing the Battery Pack" on page 46. 2. See "Removing the SD Dummy Card" on page 47. 3. See "Removing the DIMM Module" on page 48. 4. See " - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 59
5. Remove the one screw (F) securing the hard disk drive module. Size (Quantity) M2 x L4 (1) Color Silver Torque 1.6 kgf-cm 6. Slide the hard disk drive module away from the connector. Part No. 86.9A552.4R0 Chapter 3 51 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 60
prevent damage to device, avoid pressing down on it or placing heavy objects on top of it. 8. Remove the two screws (D) securing the hard disk to the bracket and remove the hard disk from the bracket. Size (Quantity) M3 x L4 (2) Color Silver Torque 3.0 kgf-cm Part No. 86.9A554.4R0 52 Chapter 3 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 61
1. See "Removing the Battery Pack" on page 46. 2. See "Removing the SD Dummy Card" on page 47. 3. See "Removing the DIMM Module" on page 48. 4. See "Removing the Back Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. Disconnect the black antenna cable from connector - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 62
on the WLAN board (for 3G model). NOTE: For non-3G WLAN board module with 3 antenna cables connected to the WLAN board module. The black antenna cable is connected to the connector #1, the White antenna cable is connected to connector #2 and the Gray antenna cable is connected to connector - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 63
NOTE: When attaching the antenna back to the WLAN board, make sure the cable are arranged properly. Removing the Optical Drive Module 1. See "Removing the Battery Pack" on page 46. 2. See "Removing the SD Dummy Card" on page 47. 3. See "Removing the DIMM Module" on page 48. 4. See "Removing the Back - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 64
7. Use a screw driver to push out the locker bracket of the optical drive (ODD) module. Slowly pull out the ODD module from the ODD drive bay. 8. Remove the one screw (C) securing the locker bracket and remove the locker bracket from the optical disk drive module. Size (Quantity) M2 x L3 (1) 56 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 65
Main Unit Disassembly Process Main Unit Disassembly Flowchart MAIN UNIT DISASSEMBLY MAIN UNIT MIDDLE COVER F x 1 VOLUME BUTTON BOARD KEYBOARD Ax2 Gx2 LCD MODULE A x 10 F x 3 UPPER CASE Ex1 RIGHT SPEAKER MODULE BLUETOOTH MODULE Fx1 MODEM CARD FINGERPRINT MODULE Fx1 USB MODULE TOUCHPAD - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 66
See "Removing the Back Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. See "Removing the WLAN Modules" on page 53. 7. See "Removing the Optical Drive Module" on page 55. 8. Use a plastic screw driver to pry loose the side of the middle cover. 9. Carefully pry loose the - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 67
10. Detach the cable from the volume button board on the middle cover. 11. Remove the one screw (F) from the volume button board and release the volume button board from the latch. Size (Quantity) M2 x L4 (1) Color Silver Torque 1.6 kgf-cm Part No. 86.9A552.4R0 Chapter 3 59 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 68
board from the middle cover. Removing the Keyboard 1. See "Removing the Battery Pack" on page 46. 2. See "Removing the SD Dummy Card" on page 47. 3. See "Removing the DIMM Module" on page 48. 4. See "Removing the Back Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. See - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 69
main board and detach the keyboard. Removing the LCD Module 1. See "Removing the Battery Pack" on page 46. 2. See "Removing the SD Dummy Card" on page 47. 3. See "Removing the DIMM Module" on page 48. 4. See "Removing the Back Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 70
For 3G model For non-3G model 11. Carefully pull out the wireless antenna cables from the hole(s). 12. Release the cables from the latches. 62 Chapter 3 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 71
13. Turn over the system and remove the two screws (A) from the bottom of the left and right hinges. Size (Quantity) M2.5 x L8 (2) Black Color Torque 3.0 kgf-cm 14. Detach the LCD cable from the connector on the main board. Part No. 86.00E34.738 Chapter 3 63 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 72
15. routed well. Separating the Upper Case from the Lower Case 1. See "Removing the Battery Pack" on page 46. 2. See "Removing the SD Dummy Card" on . 4. See "Removing the Back Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. See "Removing the WLAN Modules" on page 53. - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 73
11. Remove the three screws (F) from the middle cover. Size (Quantity) M2 x L4 (3) Color Silver Torque 1.6 kgf-cm Part No. 86.9A552.4R0 12. Release the latch and disconnect the volume button board cable from its connector the main board. 13. Release the latch and disconnect the touch pad cable - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 74
14. Release the latch and disconnect the fingerprint cable from FPCN1 connector on the main board. 15. Disconnect the speaker cable from its connector on the main board. 16. Disconnect the microphone connector from the main board and remove the microphone. 66 Chapter 3 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 75
17. Remove the ten screws (A) securing the lower case to the upper case. Size (Quantity) M2.5 x L8 (10) Black Color Torque 3.0 kgf-cm 18. Gently detach the upper case from the lower case. Part No. 86.00E34.738 19. Remove the upper case. Chapter 3 67 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 76
Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. See "Removing the WLAN Modules" on page 53. 7. See "Removing the Optical Drive Module" on page 55. 8. See "Removing the Middle Cover" on page 58. 9. See "Removing the Keyboard" on page 60. 10. See "Removing the LCD Module - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 77
14. Release the fingerprint board metal bracket from the latches and detach it from the upper case. 15. Release the fingerprint board from the latches and detach it from the upper case. Chapter 3 69 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 78
16. Pry to loosen the touchpad board. WARNING: The touchpad board is glued to the upper case, only remove the touchpad board if it is defective. Note: Circuit board >10 cm² has been highlighted with the yellow rectangle as above image shows. Please detach the Circuit boards and follow local - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 79
the Left Speaker Module 1. See "Removing the Battery Pack" on page 46. 2. See "Removing the Back Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. See "Removing the WLAN Middle Cover" on page 58. 9. See "Removing the Keyboard" on page 60. 10. See "Removing the LCD Module - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 80
speaker module and remove it from the upper case. Size (Quantity) M2 x L4 (2) Black Color 13. Detach the left speaker module. Torque 1.6 kgf-cm Part No. 86.00E13.524 Removing the USB Board Module 1. See "Removing the Battery Pack" on page 46. 2. See "Removing the SD Dummy Card" on page 47 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 81
12. Disconnect the cables from the USB board module. 13. Remove the one screw (F) securing the USB board module to the lower case. Size (Quantity) M2 x L4 (1) Color Silver Torque 1.6 kgf-cm Part No. 86.9A552.4R0 Chapter 3 73 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 82
14. Remove the USB board module from the lower case. 74 Chapter 3 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 83
Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. See "Removing the WLAN Modules" on page 53. 7. See "Removing the Optical Drive Module" on page 55. 8. See "Removing the Middle Cover" on page 58. 9. See "Removing the Keyboard" on page 60. 10. See "Removing the LCD Module - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 84
lower case. Removing the Bluetooth Module 1. See "Removing the Battery Pack" on page 46. Disk Drive Module" on page 50. 6. See "Removing the WLAN Modules" on page 53. 7. See "Removing the Optical Drive Module" on page 55. 8. See "Removing the Middle Cover" on page 58. 9. See "Removing the Keyboard - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 85
13. See "Removing the USB Board Module" on page 72. 14. See "Removing the Modem Module" on page 75. 15. Disconnect the bluetooth cable from its connector on the main board. 16. Remove the Bluetooth module. NOTE: Be careful when removing the Bluetooth module as it is glued in place. Chapter 3 77 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 86
disk to the bracket and remove the hard disk from the bracket." on page 52. 7. See "Removing the Optical Drive Module" on page 55. 8. See "Removing the Middle Cover" on page 58. 9. See "Removing the Keyboard 15. See "Removing the Bluetooth Module" on page 76. 16. Release right speaker - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 87
17. Disconnect the speaker cable from its connector on the main board. 18. Remove the one screw (E) securing the speaker module and remove it from the lower case. Size (Quantity) M2 x L4 (1) Black Color Torque 1.6 kgf-cm Part No. 86.00E13.524 Chapter 3 79 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 88
Disk Drive Module" on page 50. 6. See "Removing the WLAN Modules" on page 53. 7. See "Removing the Optical Drive Module" on page 55. 8. See "Removing the Middle Cover" on page 58. 9. See "Removing the Keyboard page 75. 15. See "Removing the Bluetooth Module" on page 76. 16. See "Removing the Right - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 89
(Quantity) M2 x L4 (1) Color Silver Torque 1.6 kgf-cm Part No. 86.9A552.4R0 Note: RTC battery has been highlighted with the yellow circle as shown in the figure above. Please detach the RTC battery and follow local regulations for disposal. Note: Circuit boards >10 cm² has been highlighted with - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 90
the picture below: 1. See "Removing the Battery Pack" on page 46. 2. See " " on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. See "Removing on page 58. 9. See "Removing the Keyboard" on page 60. 10. See "Removing 15. See "Removing the Bluetooth Module" on page 76. 16. See - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 91
page 80. 18. Disconnect the heatsink connector from the main board. 19. Remove the six screws securing the heatsink module in the order shown. NOTE: Aspire 5738G/5738ZG/5738Z/5738/5338 Series uses the NVdia VGA board, while Aspire 5536/ 5536G/5236 Series uses the ATI VGA board. Chapter 3 83 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 92
CPU NOTE: Aspire 5738G/5738ZG/5738Z/5738/5338 Series uses the Intel® processor, while Aspire 5536/5536G/ 5236 Series uses the AMD® processor. But the process in removing the CPU are the same for all the models. 1. See "Removing the Battery on page 75. 15. See "Removing the Bluetooth Module" on page - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 93
19. Using a flat screwdriver, turn the CPU socket latch counter-clockwise to release the CPU. Chapter 3 85 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 94
20. Lift up carefully to remove the CPU. NOTE: When installing the CPU, make sure to install the CPU with PIN 1 at the corner as shown. 86 Chapter 3 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 95
LCD Module Disassembly Process LCD Module Disassembly Flowchart LCD MODULE DISASSEMBLY LCD MODULE Bx4 LCD BEZEL Bx4 LCD ASSEMBLY LCD FPC CABLE Cx2 Cx2 LEFT LCD RIGHT LCD BRACKET BRACKET LCD BACK PANEL ANTENNAS WEB CAMERA Screw List Item B C Screw M2.5 x L6 M2 x L3 Color Black Silver Part - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 96
58. 9. See "Removing the Keyboard" on page 60. 10. See "Removing the LCD Module" on page 61. 11. Remove the four screw covers from the top and bottom of the LCD bezel. 12. Remove the four screws (B) on the LCD module as shown. Size (Quantity) M2.5 x L6 (4) Black Color 88 Torque 3.0 kgf - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 97
LCD panel with the Brackets 1. See "Removing the Battery Pack" on page 46. 2. See "Removing the Back Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. See "Removing the WLAN Cover" on page 58. 9. See "Removing the Keyboard" on page 60. 10. See "Removing the LCD Module" - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 98
12. Disconnect the cable from the web camera. 13. Remove the four screws (B) securing the LCD assembly. Size (Quantity) M2.5 x L6 (4) Black Color Torque 3.0 kgf-cm Part No. 86.00E12.536 90 Chapter 3 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 99
LCD Brackets 1. See "Removing the Battery Pack" on page 46. 2. See the Back Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. See "Removing the WLAN Modules" the Middle Cover" on page 58. 9. See "Removing the Keyboard" on page 60. 10. See "Removing the LCD Module" on - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 100
Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. See "Removing the WLAN Modules" on page 53. 7. See "Removing the Optical Drive Module" on page 55. 8. See "Removing the Middle Cover" on page 58. 9. See "Removing the Keyboard" on page 60. 10. See "Removing the LCD Module - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 101
Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. See "Removing the WLAN Modules" on page 53. 7. See "Removing the Optical Drive Module" on page 55. 8. See "Removing the Middle Cover" on page 58. 9. See "Removing the Keyboard" on page 60. 10. See "Removing the LCD Module - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 102
13. Release the antenna cables from the aluminium tapes. 14. Remove the left and right antenna cables together with the tapes holding them in place. NOTE: There is no need to remove the antenna unless you really need to replace it. 94 Chapter 3 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 103
Cover" on page 49. 5. See "Removing the Hard Disk Drive Module" on page 50. 6. See "Removing the WLAN Modules" on page 53. 7. See "Removing the Optical Drive Module" on page 55. 8. See "Removing the Middle Cover" on page 58. 9. See "Removing the Keyboard" on page 60. 10. See "Removing the LCD Module - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 104
96 Chapter 3 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 105
Chapter 4 Troubleshooting Use the following procedure as a guide for computer problems. NOTE: The diagnostic tests are intended to test only Acer products. Non-Acer products, prototype cards, or modified options can give false errors and invalid system responses. 1. Obtain the failing symptoms in as - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 106
fail. Do the following to select the test device: 1. Boot from the diagnostics diskette and start the diagnostics program. 2. See if CD-ROM Test is passed when the program runs to CD-ROM Test. 3. Follow the instructions in the message window. If an error occurs, reconnect the connector on the System - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 107
error messages on the screen, or hang the system. 1. Boot from the diagnostics diskette and start the diagnostic program (please refer to main board. 2. Go to the diagnostic memory in the test items. 3. Press F2 in the test items. 4. Follow the instructions in the message window. NOTE: Make sure - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 108
can also help you determine the next possible FRU to be replaced when servicing a computer. If the symptom is not listed, see "Undetermined Problems" on page 114. The following lists the error messages that the BIOS displays on the screen and the error symptoms classified by function. NOTE: Most of - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 109
Causes: 1. CPU BIOS Update Code Mismatch 2. IDE Primary Channel Master Drive Error (THe causes will be shown before "Equipment Configuration Error") Memory Error at xxxx:xxxx:xxxxh (R:xxxxh, W:xxxxh) Real Time Clock Error CMOS Battery Bad CMOS Checksum Error System disabled. Incorrect password is - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 110
disabled CPU ID: DMA Test Failed Software NMI Failed Fail-Safe Timer NMI Failed Device Address Conflict Allocation Error for device Failing Bits: nnnn Fixed Disk n Invalid System Configuration Data I/O device IRQ conflict Operating system not found FRU/Action in Sequence RTC battery Run BIOS Setup - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 111
every connector is connected tightly and correctly. Reconnect the DIMM. LED board. System board. Power source (battery pack and power adapter). See "Power System Check" on page 99.. Reconnect the LCD connector Hard disk drive LCD inverter ID LCD cable LCD Inverter LCD System board Reconnect the LCD - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 112
with initial POST values Restore CPU control word during warm boot Initialize PCI Bus Mastering devices Initialize keyboard controller BIOS ROM checksum Initialize cache before memory autosize 8254 timer initialization 8237 DMA controller initialization Reset Programmable Interrupt Controller Test - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 113
devices Initialize all video adapters in system QuietBoot start (optional) Shadow video BIOS ROM Display BIOS copyright notice Display CPU type and speed Initialize EISA board Test keyboard Set key click if enabled Test for unexpected interrupts Initialize POST display service Display prompt "Press - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 114
Extended BIOS Data Area Test and initialize PS/2 mouse Initialize floppy controller Determine number of ATA drives (optional) Initialize hard-disk controllers Initialize local-bus hard-disk controllers Jump to UserPatch2 Build MPTABLE for multi-processor boards Install CD ROM for boot Clear - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 115
notebook docking (optional) Initialize notebook docking late Force check (optional) Extended checksum (optional) Unknown interrupt Initialize the chipset Initialize the bridge Initialize the CPU Initialize the system timer Initialize system I/O Check force recovery boot Checksum BIOS ROM Go to BIOS - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 116
Code F5h F6h F7h Beeps Boot to Mini DOS Clear Huge Segment Boot to Full DOS 108 Chapter 4 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 117
in Sequence Power source (battery pack and power adapter). See "Power System Check" on page 99. Battery pack Power adapter Hard drive & battery connection board System board Power source (battery pack and power adapter). See "Power System Check" on page 99. Battery pack Power adapter Hard drive - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 118
The system doesn't power-off. Battery can't be charged Action in Sequence Power source (battery pack and power adapter). See "Power System Check" on page 99. Hold and press the power switch for more than 4 seconds. System board See "Check the Battery Pack" on page 100. Battery pack System board - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 119
device problems. Action in Sequence Enter BIOS Setup Utility to execute "Load Default Settings", then reboot system. Reconnect hard disk/CD-ROM/diskette drives. Press Fn+F5, LCD/CRT/Both display switching System board System board Onboard Devices Configuration Run printer self-test. Printer driver - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 120
Modem-Related Symptoms Symptom / Error Action in Sequence Internal modem does not work correctly. Modem phone port modem combo board System board NOTE: If you cannot find a symptom or an error in this list and the problem remains, see "Undetermined Problems" on page 114. 112 Chapter 4 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 121
to do with a hardware defect, such as: cosmic radiation, electrostatic discharge, or software errors. FRU replacement should be considered only when a recurring problem exists. When analyzing an intermittent problem, do the following: 1. Run the advanced diagnostic test for the system board in loop - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 122
them for damage. If any problems are found, replace the FRU. 3. Remove or disconnect all of the following devices: • Non-Acer devices • Printer, mouse, and other external devices • Battery pack • Hard disk drive • DIMM • CD-ROM/Diskette drive Module • PC Cards 4. Power-on the computer. 5. Determine - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 123
View Chapter 5 No. Code 1 SPKR_L1 2 KB1 3 AMIC1 4 SPKR_R1 5 PSCN1 6 TPCN1 7 FPCN1 8 RTC1 9 USBCN1 Connector Left speaker cable connector Keyboard cable connector MIC cable connector Right speaker cable connector Volume button board cable connector Touchpad board cable connector - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 124
BT1 2 LOUT1 3 MICIN1 4 LIN1 5 USB1 & USB3 6 CRT1 7 FAN1 8 HDMI1 9 RJ45 10 DCIN1 11 CPU1 Connector Bluetooth board cable connector Headphone/speaker/line-out jack Microphone-in jack Line-in port USB 2.0 ports VGA port Heatsink fan cable connector HDMI port Ethernet port DC-in port - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 125
procedures for clearing the password and BIOS recovery for Aspire 5738G/5738ZG/5738Z/5738/5338 and the Aspire 5536/5536G/5236 Series. There is one Hardware Open Gap on the main board for clearing the password check and one Hotkey for enabling BIOS Recovery. Clearing Password Check Hardware Open Gap - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 126
name in Aspire 5536/5536G/5236 Series is G106. G106 Steps for Clearing BIOS Password Check If the user sets the BIOS Password (Supervisor Password and/or User Password) for a security reason, the BIOS will ask for the password during system POST or when the system enters into the BIOS Setup menu - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 127
AC adapter and the battery must be connected. If this function is enabled, the system will force the BIOS to enter a special BIOS block called Boot Block. Steps for BIOS Recovery by Crisis Disk Before doing this, prepare a Crisis Disk (refer to the "Steps for Creating the Crisis Disk in Windows XP - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 128
3. Decompress the Crisis Package Source. Select WINCRIS.EXE and then select Run as administrator under Vista. 4. Keep the default settings and then click on the Start button. 5. When the pop-up warning dialog box appears, press OK to continue creating the Crisis Disk. 120 Chapter 5 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 129
6. The Crisis Disk will be created after a few seconds. 7. Press No if you do not want to create another Crisis Disk. Chapter 5 121 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 130
8. Reconnect the USB removable storage device and check if it contains the 3 files shown in the following figure. 122 Chapter 5 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 131
you the FRU (Field Replaceable Unit) listing in global configurations of Aspire 5738G/5738ZG/5738Z/ 5738/5338 Series. Refer to this chapter made, it will not be noted on the printed Service Guide. For ACER AUTHORIZED SERVICE PROVIDERS, your Acer office may have a DIFFERENT part number code from - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 132
Aspire 5738G/5738ZG/5738Z/5738/5338 Series and Aspire 5536/5536G/5236 Series Exploded Diagram 124 Chapter 6 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 133
5738G/5738ZG/5738Z/5738/5338 Series and Aspire 5536/5536G/5236 Series FRU List 1. ACER_ASPIRE 5738Z UMA_JV50_MV (NO:91.4CG01.001G) Category ADAPTER No. 1 1 1 Part Name and Description ADAPTER 65W 19V 3PIN HIPRO HP-A0652R3B 1LF LV5 LED LF YELLOW ADAPTER 65W 19V 3PIN DELTA ADP-65JH DB A LV5 LED - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 134
POWER CORD 2.5A 125V USA 27.01518.A11 1 POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE 27.01518.781 1 POWER CORD 10A 250V SWISS 27.01518.691 1 POWER CORD 10A 250V 3PIN SWISS BK 27.01518.581 1 POWER CORD 10A 250V ARGENTINE 27.01518.0U1 1 POWER CORD 10A 125V US 27.01518.641 1 POWER CORD - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 135
Category CASE/COVER/BRACKET ASSEMBLY CPU/PROCESSOR No. 1 1 1 1 1 1 1 1 1 1 2 Part Name and Description POWER CORD 250V 10A 3PIN ISRAEL POWER CORD 10A 250V 1.8M BRAZIL BLK POWER CORD ACA / ACNZ POWER CORD 7.5A 250V 3P AUSTRALIA BK POWER CODE 7A 125V 2PIN JAPAN USB BOARD CABLE USB BOARD CABLE USB - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 136
2 1 1 1 Part Name and Description Acer Part No. HDD 160GB 5400RPM SATA WD CPU HEATSINK W/FAN 60.4CG31.001 CPU HEATSINK W/FAN 60.4CG24.001 CPU HEATSINK W/FAN 60.4CG19.001 KEYBOARD 1 KEYBOARD 107KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 KB.I170A.044 STANDARD BLACK TEXTURE JAPANESE 1 KEYBOARD - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 137
104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH/SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK Acer Part No. KB.I170A.055 KB.I170A.051 KB.I170A.039 KB.I170A - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 138
-TLE1 LF 220NIT 8MS 400:1 LK.15605.003 LED LCD MODULE 15.6" WXGA GLARE W/ANTENNA*3 W/O CAMERA (NONE 3G) 6M.PAQ01.002 MAINBOARD JV50_MV UMA GL40 ICH9M LF W/RTC BATTERY&MODEM BOARD NONE 3G MB.P5601.005 MEMORY MICROPHONE MISCELLANEOUS 1 SODIMM 1GB DDRIII 1066MHZ MICRON MT8JSF12864HY- 1G1D1 KN - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 139
86.9A552.4R0 SCREW MACH WAFER M3*L4 NI 86.9A554.4R0 2. ACER AS5738ZG_N10 Category No. ADAPTER 1 1 1 BATTERY 1 1 1 1 1 1 Part Name and Description Acer Part No. ADAPTER 65W 19V 3PIN HIPRO HP-A0652R3B 1LF LV5 LED LF YELLOW ADAPTER 65W 19V 3PIN DELTA ADP-65JH DB A LV5 LED LF YELLOW - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 140
Category BOARDS No. Part Name and Description 1 BLUETOOTH BOARD FOXCONN BCM2045 V2 T60H928.11 Acer Part No. BT.21100.005 2 INVERTER BOARD YEC YNV 50.4CG04.001 2 MODEM CABLE 50.4CG04.011 1 POWER CORD 3A 250V 3PIN UK 27.03118.001 1 POWER CORD 5A 250V 3PIN UK BK 27.01518.541 Chapter 6 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 141
Description POWER CORD 2.5A 125V USA POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE POWER CORD 10A 250V SWISS POWER CORD 10A 250V 3PIN SWISS BK POWER CORD 10A 250V ARGENTINE POWER CORD 10A 125V US POWER CORD 10A 125V 3PIN US BK POWER CORD 7A 250V 2PIN KOREAN POWER CORD 7A 125V 2PIN JAPAN POWER CORD 10A - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 142
UNITLOAD COVER 42.PAW01.002 WIRELESS LAN COVER 42.PAW01.003 CPU INTEL PENTIUM DUAL-CORE T4200 PGA 2.0G 1M 800 35W KC.42001.DTP R-0 CPU INTEL MEROM PENTIUM DUAL-CORE T3400 2.16G 1M 667 KC.34001.DTP MV HDD/HARD DISK DRIVE 1 HDD MODULE 160GB 5400RPM SATA 2 HDD 160GB 5400RPM SATA WD - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 143
No. 1 1 1 Part Name and Description CPU HEATSINK W/FAN CPU HEATSINK W/FAN CPU HEATSINK W/FAN Acer Part No. 60.4CG22.001 60.4CG27.001 60.4CG15.001 KEYBOARD 1 KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 KB.I170A.055 STANDARD BLACK TEXTURE UK 1 KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 144
104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK TBD KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK TBD LED LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*2&CAMERA (NONE 3G) 6M.PAT01.001 LED LCD 15.6" WXGA GLARE CMO N156B6-L04 LF 220NIT 8MS LK - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 145
*3 & LOGO (FOR 3G) 1 LOWER CASE W/MODEM CABLE&SPEAKER WITH 3G 1 MIDDLE COVER W/3G BUTTON WITH GREEN LIGHT 1 LED LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*3&CAMERA (FOR 3G) 1 CCFL LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*3&CAMERA WITH 3G Acer Part No. TBD TBD TBD TBD TBD TBD Chapter 6 137 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 146
AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK 1 KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK 1 LED LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*3&CAMERA (FOR 3G) 1 CCFL LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*3&CAMERA (FOR 3G) Acer Part No. TBD TBD TBD - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 147
USB BOARD Acer Part No. BLUETOOTH BOARD CABLE 50.4CG06.021 1 BLUETOOTH BOARD CABLE 50.4CG06.001 1 BLUETOOTH COVER 15.6" W/ANTENNA*3 & LOGO NONE 3G TBD 2 LCD BEZEL 15.6" W/ POWER CORD 3A 250V 3PIN UK 27.03118.001 1 POWER CORD 5A 250V 3PIN UK BK 27.01518.541 1 POWER CORD 2.5A 125V - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 148
Name POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE POWER CORD 10A 250V SWISS POWER CORD 10A 250V 3PIN SWISS BK POWER CORD 10A 250V ARGENTINE POWER CORD 10A 125V US POWER CORD 10A 125V 3PIN US BK POWER CORD 7A 250V 2PIN KOREAN POWER CORD 7A 125V 2PIN JAPAN POWER CORD 10A 3PIN BK DENMARK POWER CORD 10A - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 149
35W R-0 CPU INTEL MEROM PENTIUM DUAL-CORE T3400 2.16G 1M 667 MV Acer Part No. 34.4CG13.011 34.4CG13.001 60.PAW01.001 TBD 33.PAW01.002 42.TKJ01.001 33.PAW01.001 60.PAW01.002 42.PAW01.002 42.PAW01.003 KC.42001.DTP KC.34001.DTP HDD/HARD DISK DRIVE - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 150
104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH ARABIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH/SLOVAK Acer Part No. KB.I170A.055 KB.I170A.056 KB - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 151
Category LCD MAINBOARD No. 1 1 2 2 2 1 1 2 2 2 2 1 1 1 Part Name Acer Part No. KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK TBD KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK TBD LCD AUO 15.6" WXGA GLARE AUO B156XW01 V0 LF - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 152
HIPRO HP-A0652R3B 1LF LV5 LED LF YELLOW ADAPTER 65W 19V 3PIN DELTA ADP-65JH DB A LV5 LED LF YELLOW ADAPTER 65W 19V 3PIN LITEON PA-1650-22AC LV5 LED LF YELLOW Acer Part No. AP.06503.024 AP.0650A.012 AP.06501.026 BATTERY BOARDS 1 BATTERY SIMPLO AS-2007A LI-ION 3S2P LGC 6 CELL - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 153
POWER CORD 2.5A 125V USA 27.01518.A11 1 POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE 27.01518.781 1 POWER CORD 10A 250V SWISS 27.01518.691 1 POWER CORD 10A 250V 3PIN SWISS BK 27.01518.581 1 POWER CORD 10A 250V ARGENTINE 27.01518.0U1 1 POWER CORD 10A 125V US 27.01518.641 1 POWER CORD - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 154
1.8M BRAZIL BLK POWER CORD ACA / ACNZ POWER CORD 7.5A 250V 3P AUSTRALIA BK POWER CODE 7A 125V 2PIN JAPAN TOUCHPAD CABLE TOUCHPAD CABLE USB BOARD CABLE USB BOARD CABLE USB BOARD CABLE CAMERA 0.3M CHICONY CNF701721004973L CAMERA 0.3M SUYIN CN0314-SN30-OV03-5 DVD-RW SUPER-MULTI BEZEL Acer Part No. 27 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 155
W:01.01A01 KH.50004.001 CPU HEATSINK UMA W/FAN 60.4CH17.001 CPU HEATSINK UMA W/FAN 60.4CH11.001 CPU HEATSINK UMA W/FAN 60.4CH04.001 KEYBOARD Chapter 6 1 KEYBOARD 107KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 KB.I170A.044 STANDARD BLACK TEXTURE JAPANESE 1 KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 156
104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH/SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK Acer Part No. KB.I170A.057 KB.I170A.032 KB.I170A.048 TBD TBD - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 157
GLARE SAMSUNG LTN156AT02-A01 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE AUO B156XW02 V0 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE LG LP156WH2-TLE1 LF 220NIT 8MS 400:1 MAINBOARD JV50_PU UMA RS780MN SB700 LF W/RTC BATTERY&MODEM BOARD Acer Part No. 6M.PAW01.003 LK.15606.003 LK.15608.002 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 158
3PIN DELTA ADP-65JH DB A LV5 LED LF YELLOW ADAPTER 65W 19V 3PIN HIPRO HP-A0652R3B 1LF LV5 LED LF YELLOW ADAPTER 65W 19V 3PIN LITEON PA-1650-22AC LV5 LED LF YELLOW Acer Part No. AP.06503.024 AP.06501.026 AP.0650A.012 BATTERY 1 BATTERY SONY AS-2007A LI-ION 3S2P SONY 6 CELL - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 159
POWER CORD 2.5A 125V USA 27.01518.A11 1 POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE 27.01518.781 1 POWER CORD 10A 250V SWISS 27.01518.691 1 POWER CORD 10A 250V 3PIN SWISS BK 27.01518.581 1 POWER CORD 10A 250V ARGENTINE 27.01518.0U1 1 POWER CORD 10A 125V US 27.01518.641 1 POWER CORD - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 160
250V 1.8M BRAZIL BLK POWER CORD ACA / ACNZ POWER CORD 7.5A 250V 3P AUSTRALIA BK POWER CODE 7A 125V 2PIN JAPAN TOUCHPAD CABLE TOUCHPAD CABLE USB BOARD CABLE USB BOARD CABLE USB BOARD CABLE CAMERA 0.3M SUYIN CN0314-SN30-OV03-5 CAMERA 0.3M CHICONY CNF701721004973L BLUE-RAY COMBO BEZEL Acer Part No. 27 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 161
Category CPU/PROCESSOR HDD/HARD DISK DRIVE HEATSINK No. 1 1 1 1 1 1 1 1 1 2 2 2 2 1 2 2 2 2 1 2 2 2 2 1 2 2 2 2 1 1 1 Part Name Acer Part No. UPPER CASE W/LED BUTTON BOARD CABLE&MICROPHONE&SPEAKER&FINGER PRINT HOLE 60.PAX01.001 WIRELESS LAN COVER 42.PAW01.003 CPU AMD TURION RM72 PGA 2.1G 1M - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 162
107KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE JAPANESE KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GREEK KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TAIWAN Acer Part No. KB.I170A.055 KB.I170A.056 KB.I170A.044 KB.I170A.041 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 163
104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH/SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK Acer Part No. KB.I170A.053 KB.I170A.057 KB.I170A.032 KB.I170A - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 164
15.6" WXGA GLARE SAMSUNG LTN156AT02-A01 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE LG LP156WH2-TLE1 LF 220NIT 8MS 400:1 LED LCD MODULE 15 UMA RS780MN SB700 LF W/RTC BATTERY&MODEM BOARD Acer Part No. 6M.PAW01.003 025 KU.0080D.040 MB.P4201.001 MEMORY MISCELLANEOUS 1 SODIMM 1GB DDRII667 SAMSUNG - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 165
LITEON PA-1900-34AR LV5 LED LF BLUE ADAPTER 90W 19V 3PIN DELTA ADP-90CD DB A LV5 LED LF BLUE ADPAPTER 90W 19V 3PIN HIPRO HP-A0904A3 B1LF LV5 LED LF BLUE Acer Part No. AP.0900A.005 AP.09003.021 AP.09001.027 BATTERY BOARDS 1 BATTERY SIMPLO AS-2007A LI-ION 3S2P PANASONIC - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 166
POWER CORD 2.5A 125V USA 27.01518.A11 1 POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE 27.01518.781 1 POWER CORD 10A 250V SWISS 27.01518.691 1 POWER CORD 10A 250V 3PIN SWISS BK 27.01518.581 1 POWER CORD 10A 250V ARGENTINE 27.01518.0U1 1 POWER CORD 10A 125V US 27.01518.641 1 POWER CORD - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 167
CASE/COVER/BRACKET ASSEMBLY CPU/PROCESSOR No. 1 1 1 1 1 1 2 2 2 Part Name POWER CODE 7A 125V 2PIN JAPAN USB BOARD CABLE USB BOARD CABLE USB BOARD CABLE TOUCHPAD CABLE TOUCHPAD CABLE CAMERA 0.3M CHICONY CNF701721004973L CAMERA 0.3M SUYIN CN0314-SN30-OV03-5 BLUE-RAY COMBO BEZEL Acer Part No. 27 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 168
Category HDD/HARD DISK DRIVE HEATSINK No. 1 2 2 2 2 1 2 2 2 2 1 2 2 2 2 1 2 2 2 2 1 Part Name Acer Part No. HDD MODULE 22ZAT0 F/ W:01.01A01 KH.50004.001 CPU HEATSINK DISCRETE W/FAN 60.4CH13.001 1 CPU HEATSINK DISCRETE W/FAN 1 CPU HEATSINK DISCRETE W/FAN 60.4CH07.001 60.4CH02.001 160 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 169
103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE RUSSIAN KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE KOREA KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK Acer Part No. KB.I170A.056 KB.I170A.055 KB.I170A.044 KB.I170A.041 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 170
104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH/SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK LED LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*2&CAMERA (NONE 3G) LED - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 171
Category MAINBOARD No. 1 Part Name MAINBOARD AS5536G ATI RS780 SB700 M92M-XT 512MB LF W/RTC BATTERY&MODEM BOARD Acer Part No. MB.P4201.002 MEMORY MICROPHONE MISCELLANEOUS ODD SCREWS SPEAKER 1 SODIMM 1GB DDRII667 NANYA NT1GT64UH8D0FN-3C LF (0.07U) KN.1GB0G.022 1 SODIMM 1GB DDRII667 MICRON - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 172
AS-2007A LI-ION 3S2P LGC 6 CELL 2150MAH 2ND COMMON 1 BATTERY SIMPLO AS-2007A LI-ION 3S2P SAMSUNG 6 CELL 4400MAH MAIN COMMON SDI 2.2MAH F TYPE 1 BLUETOOTH BOARD FOXCONN BCM2045 V2 T60H928.11 Acer Part No. AP.0900A.005 AP.09001.027 AP.09003.021 BT.00607.034 BT.00603.041 BT.00604.024 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 173
POWER CORD 2.5A 125V USA POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE POWER CORD 10A 250V SWISS POWER CORD 10A 250V 3PIN SWISS BK POWER CORD 10A 250V ARGENTINE POWER CORD 10A 125V US POWER CORD 10A 125V 3PIN US BK POWER CORD 7A 250V 2PIN KOREAN POWER CORD 3A 250V 3PIN UK POWER CORD 6 Acer Part No - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 174
3G LCD BEZEL 15.6" W/CAMERA HOLE LOWER CASE W/MODEM CABLE&SPEAKER MIDDLE COVER W/BLUETOOTH BUTTON WITH BLUE LIGHT NONE 3G BUTTON OPTICAL BRACKET SD DUMMY CARD TOUCHPAD BRACKET UNITLOAD COVER UPPER CASE W/LED BUTTON BOARD CABLE&MICROPHONE&SPEAKER&FINGER PRINT HOLE WIRELESS LAN COVER CPU AMD TURION RM - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 175
W:01.01A01 CPU HEATSINK DISCRETE W/FAN 60.4CH13.001 CPU HEATSINK DISCRETE W/FAN 60.4CH07.001 CPU HEATSINK DISCRETE W/FAN 60.4CH02.001 KEYBOARD Chapter 6 1 KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 KB.I170A.056 STANDARD BLACK TEXTURE US-INTERNATIONAL 1 KEYBOARD 104KEYS NSK-ALA0J - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 176
104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK TBD KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK TBD LED LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*2&CAMERA (NONE 3G) 6M.PAW01.003 LED LCD 15.6" WXGA GLARE CMO N156B6-L04 LF 220NIT 8MS LK - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 177
MICROPHONE MICROPHONE MICROPHONE MICROPHONE MAINBOARD AS5536G ATI RS780 SB700 M92M-XT 512MB LF W/RTC BATTERY&MODEM BOARD Acer Part No. 23.42239.001 23.42231.001 23.40544.001 23.42238.001 MB.P4201.002 ODD MEMORY MISCELLANEOUS SCREWS SPEAKER 1 BLU-RAY COMBO MODULE 4X SATA 6M.PAW01.001 2 ODD - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 178
Appendix A Model Definition and Configuration Appendix A 170 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 179
Aspire 5738G/5738ZG/5738Z/5738/5338 Series Model RO Country Acer Part No Description CPU Memory 1 Memory 2 N SO1GBIII10 N HDD 1(GB) N160GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 180
Acer 643G50Mn VHP32ATAU1 MC N10MGE1512CFbbM 2G+1G/500_L/BT/6L/ 5R/ CB_n2_FP_0.3D_EN12 CPU 1 Memory 1 Memory 2 SP1x2M MW SP1x2M MW SP1x2M MW WLAN1 Bluetooth Finger -print Battery 3rd WiFi N 1x2 BGN N 6CELL2 10 SP1x2 MMW BT 2.0 AES16 6CELL2.2 10 Adapter Camera 65W 0.3M DV 65W 0.3M DV 65W - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 181
Acer CB_n2_0.3D_EN12 CPU LCD VRAM 1 Memory 1 Memory 2 N10MG SP1x2M MW SP1x2M MW SP1x2M MW WLAN1 Bluetooth Finger -print Battery SP1x2 MMW BT 2.0 AES16 6CELL2.2 6CELL2.2 SP1x2 N MMW N 6CELL2.2 SP1x2 N MMW N 6CELL2.2 Adapter Camera 65W 0.3M DV 65W 0.3M DV 65W 0.3M DV 65W - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 182
Country Acer CPU C2DT6400 LCD NLED15.6WXGAG VGA Chip N10MG E1 VRAM 1 Memory 1 Memory 2 512MDDR2(6 4*16*4) SO2GBIII10 SO1GBIII 10 HDD 1(GB) N320GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN SP1x2M MW WLAN1 SP1x2 MMW Bluetooth Finger -print BT 2.0 N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 183
Country Acer Part CPU C2DT6400 LCD NLED15.6WXGAG VGA Chip N10MG E1 VRAM 1 Memory 1 Memory 2 512MDDR2(6 4*16*4) SO2GBIII10 SO2GBIII 10 HDD 1(GB) N320GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN SP1x2M MW WLAN1 SP1x2 MMW Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 184
Country Acer Part CPU C2DT6400 LCD NLED15.6WXGAG VGA Chip N10MG E1 VRAM 1 Memory 1 Memory 2 512MDDR2(6 4*16*4) SO2GBIII10 SO2GBIII 10 HDD 1(GB) N320GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN SP1x2M MW WLAN1 SP1x2 MMW Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 185
Country Acer Part CPU C2DT6400 LCD NLED15.6WXGAG VGA Chip N10MG E1 VRAM 1 Memory 1 Memory 2 512MDDR2(6 4*16*4) SO2GBIII10 SO2GBIII 10 HDD 1(GB) N320GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN SP1x2M MW WLAN1 SP1x2 MMW Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 186
Acer CB_bgn_FP_0.3D_EN1 2 CPU LCD C2DT6400 N15 Chip VRAM 1 Memory 1 Memory 2 N10MG E1 WiFi 1x2 BGN 3rd WiFi 1x2 BGN WLAN1 Bluetooth Finger -print Battery N N AES16 6CELL2.2 10 N N AES16 3rd WiFi 1x2 BGN BT 2.0 AES16 6CELL2.2 10 Adapter Camera 65W 0.3M DV 65W 0.3M DV 65W - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 187
423G25Mn RO Country Acer Part No Description CPU WW WW AAP EME N10MG E1 VRAM 1 512MDDR2(6 4*16*4) Memory 1 SO2GBIII10 Memory 2 SO1GBIII 10 HDD 1(GB) N320GB5. 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth BT 2.0 Finger -print AES16 10 Battery 6CELL2.2 Adapter 65W Camera 0.3M DV 3rd WiFi - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 188
Acer Part CPU PMDT420 0 LCD NLED15.6WXGAG VGA Chip N10MG E1 VRAM 1 512MDDR2(6 4*16*4) Memory 1 SO2GBIII10 Memory 2 SO2GBIII 10 HDD 1(GB) N250GB5. 4KS ODD NSM8XS Card Reader 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth N Finger -print N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 189
Acer Part CPU PMDT420 0 LCD NLED15.6WXGAG VGA Chip N10MG E1 VRAM 1 512MDDR2(6 4*16*4) Memory 1 SO2GBIII10 Memory 2 SO2GBIII 10 HDD 1(GB) N320GB5. 4KS ODD NSM8XS Card Reader 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth N Finger -print N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 190
Acer CPU PMDT420 0 LCD NLED15.6WXGAG VGA Chip N10MG E1 VRAM 1 512MDDR2(6 4*16*4) Memory 1 SO2GBIII10 Memory 2 SO2GBIII 10 HDD 1(GB) N320GB5. 4KS ODD NSM8XS Card Reader 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth N Finger -print N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 191
Acer CPU PMDT420 0 LCD NLED15.6WXGAG VGA Chip N10MG E1 VRAM 1 512MDDR2(6 4*16*4) Memory 1 SO2GBIII10 Memory 2 SO1GBIII 10 HDD 1(GB) N250GB5. 4KS ODD NSM8XS Card Reader 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth N Finger -print N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 192
Acer Part CPU PMDT420 0 LCD NLED15.6WXGAG VGA Chip N10MG E1 VRAM 1 512MDDR2(6 4*16*4) Memory 1 SO2GBIII10 Memory 2 SO1GBIII 10 HDD 1(GB) N250GB5. 4KS ODD NSM8XS Card Reader 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth N Finger -print N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 193
Acer Part CPU PMDT420 0 LCD NLED15.6WXGAG VGA Chip N10MG E1 VRAM 1 512MDDR2(6 4*16*4) Memory 1 SO2GBIII10 Memory 2 SO1GBIII 10 HDD 1(GB) N250GB5. 4KS ODD NSM8XS Card Reader 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth N Finger -print N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 194
Acer Part CPU PMDT420 0 LCD NLED15.6WXGAG VGA Chip N10MG E1 VRAM 1 512MDDR2(6 4*16*4) Memory 1 SO2GBIII10 Memory 2 SO2GBIII 10 HDD 1(GB) N320GB5. 4KS ODD NSM8XS Card Reader 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth N Finger -print N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 195
AS5738Z- EME Denmark 424G32Mn A Acer Part No Description CPU LX.PAT0X.049 LX.PAT0X. VRAM 1 512MDDR2(6 4*16*4) Memory 1 SO2GBIII10 Memory 2 SO2GBIII 10 HDD 1(GB) 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth N Finger -print N Battery 6CELL2.2 Adapter 65W Camera 0.3M DV 3rd WiFi N 1x2 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 196
Acer 1G/320/ BT/6L/5R/ CB_bgn_0.3D_ES22 CPU PMDT420 0 PMDT420 0 PMDT420 0 PMDT420 0 Memory 1 Memory 2 N SO2GBIII10 SO1GBIII 10 HDD 1(GB) N160GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 197
AS5738Z423G50Mn AS5738Z423G32Mn RO Country Acer Part No Description CPU EME A EME A Memory 1 Memory 2 N SO2GBIII10 N HDD 1(GB) N320GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 198
Acer ACLASpanish LX.PAR0X.06 0 Description CPU AS5738Z-422G25Mn LINPUSAME2 UMACbb 1*2G Memory 1 Memory 2 N SO2GBIII10 N HDD 1(GB) N250GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth Finger -print BT 2.0 N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 199
A Acer Part LX.PAR0X.04 3 Description CPU AS5738Z-422G25Mn EM VHP32ATEA1 MC Memory 1 Memory 2 N SO1GBIII10 SO1GBIII 10 HDD 1(GB) N250GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 200
AS5738Z421G16Mn RO Country Acer Part No Description CPU AAP AAP EME Memory 1 Memory 2 N SO1GBIII10 N HDD 1(GB) N160GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth Finger -print BT 2.0 N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 201
AS5738Z423G25Mn AS5738Z423G25Mn RO Country Acer Part No Description CPU AAP EME A Memory 1 Memory 2 N SO2GBIII10 N HDD 1(GB) N320GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth Finger -print BT 2.0 N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 202
Acer LX.PAR0X.01 A 7 Description CPU AS5738Z-423G25Mn VHP32ATFI2 MC UMACbbM 2G Memory 1 Memory 2 N SO2GBIII10 SO1GBIII 10 HDD 1(GB) N250GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 203
Acer A LX.PAR0X.01 9 Description CPU AS5738Z-423G25Mi VHP32ATRU1 MC UMACbbM 2G+1G Memory 1 Memory 2 N SO2GBIII10 SO1GBIII 10 HDD 1(GB) N250GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi BG Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 204
Canada EME UK A EME UK A Acer Part No Description CPU LX.PAR0X.00 8 LX.PAR0Y. Memory 1 Memory 2 N SO2GBIII10 SO1GBIII 10 HDD 1(GB) N250GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 205
Acer 2G+1G/250/ 6L/CB_n2_0.3D_XC21 CPU LCD PMDT420 NLED15.6WXGAG 0 PMDT420 Memory 1 Memory 2 N SO1GBIII10 SO1GBIII 10 HDD 1(GB) N250GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN 3rd WiFi 1x2 BGN WLAN1 3rd WiFi 1x2 BGN Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 206
Acer 2G+1G/250/ 6L/CB_abg_0.3D_RU11 CPU LCD C2DT6400 NLED15.6WXGAG C2DT6400 NLED15.6WXGAG Memory 1 Memory 2 N SO2GBIII10 SO1GBIII 10 HDD 1(GB) N320GB5. 4KS ODD NBDCB4 XS Card Reader 5 in 1Build in WLAN SP1x2M MW WLAN1 SP1x2 MMW Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 207
Italy A Acer Part +1G/250/ 6L/CB_n2_0.3D_DE11 CPU LCD C2DT6400 NLED15.6WXGAG C2DT6400 NLED15 Memory 1 Memory 2 N SO2GBIII10 SO1GBIII 10 HDD 1(GB) N250GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN SP1x2M MW WLAN1 SP1x2 MMW Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 208
PA USA PA USA PA ACLAPortuguese PA Canada Acer Part No LX.PAJ0X.022 LX.PAJ0X.035 LX CPU Memory 1 Memory 2 N SO2GBIII10 SO1GBIII 10 HDD 1(GB) N250GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN SP1x2M MW WLAN1 SP1x2 MMW Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 209
PA USA PA ACLAPortuguese PA Canada Acer Part No Description LX.PAJ0Y.005 CB_n2_FR32 CPU LCD Memory 1 Memory 2 N SO1GBIII10 SO1GBIII 10 HDD 1(GB) N250GB5. 4KS ODD Card Reader NSM8XS 5 in 1Build in WLAN SP1x2M MW WLAN1 SP1x2 MMW Bluetooth Finger -print N N Battery 6CELL2.2 Adapter - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 210
Aspire 5536/5536G/5236 Series Model RO Country Acer Part No Description CPU M92X WXGAG T NLED15.6 M92X WXGAG T VRAM 1 Memory 1 Memor y 2 HDD 1(GB) ODD N SO2GBII6 in Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN N Finger Print N Battery 6CELL2.2 5 in 1- 3rd - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 211
Acer Part No Description CPU AS5536G-643G50Mn LINPUSAPL1 Memory 1 Memor y 2 HDD 1(GB) ODD 512MDDR2( 64*16* 4) SO2GBII6 SO2G BII6 N320GB5.4KS NSM8XS Card Reade r 5 in 1Build in Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN BT 2.0 Finger Print AES16 10 Battery - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 212
Model RO Country Acer Part No Description CPU AS5536G- EME WXGAG T NLED15.6 M92X WXGAG T NLED15.6 M92X WXGAG T VRAM 1 Memory 1 Memor y 2 HDD 1(GB) ODD 512MDDR2( 64*16* 4) Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN N Finger Print N Battery 6CELL2.2 5 in - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 213
Model RO Country Acer Part No Description CPU AS5536G- EME WXGAG T NLED15.6 M92X WXGAG T NLED15.6 M92X WXGAG T VRAM 1 Memory 1 Memor y 2 HDD 1(GB) ODD 512MDDR2( 64*16* 4) Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN N Finger Print N Battery 6CELL2.2 5 in - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 214
Model RO Country Acer Part No Description CPU AS5536G- EME WXGAG T NLED15.6 M92X WXGAG T NLED15.6 M92X WXGAG T VRAM 1 Memory 1 Memor y 2 HDD 1(GB) ODD 512MDDR2( 64*16* 4) Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN N Finger Print N Battery 6CELL2.2 5 in - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 215
Acer Part No Description CPU AS5536G WXGAG T NLED15.6 M92X WXGAG T NLED15.6 M92X WXGAG T VRAM 1 Memory 1 Memor y 2 HDD 1(GB) ODD 512M- SO2GBII6 N DDR2( 1Build in Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN N Finger Print N Battery 6CELL2.2 5 in 1- 3rd - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 216
LCD VGA Chip NLED15.6 UMA WXGAG VRAM 1 Memory 1 Memor y 2 HDD 1(GB) ODD N SO2GBII6 N N250GB5.4KS NSM8XS Card Reade r 5 in 1Build in Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN BT 2.0 Finger Print AES16 10 Battery 6CELL2.2 Camera 0.3M DV NLED15.6 UMA - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 217
A 209 Model RO Country Acer Part No Description CPU AS5536- PA 642G25Mn AS5536- Memory 1 Memor y 2 HDD 1(GB) ODD N SO1GBII6 SO1G N250GB5.4KS NSM8XS BII6 Card Reade r 5 in 1Build in Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN N Finger Print N Battery - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 218
Appendix A Model RO Country Acer Part No Description CPU AS5536- EME UK 724G25Mn A Memory 1 Memor y 2 HDD 1(GB) ODD N SO2GBII6 SO2G N250GB5.4KS NSM8XS BII6 Card Reade r 5 in 1Build in Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN N Finger Print N Battery - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 219
A 211 Model RO Country Acer Part No Description CPU AS5536- AAP Japan 642G25Mn LX Memory 1 Memor y 2 HDD 1(GB) ODD N SO2GBII6 N N250GB5.4KS NSM8XS Card Reade r 5 in 1Build in Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN BT 2.0 Finger Print N Battery - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 220
RO Country Acer Part No 2G/250/6L/ CB_bgn_0.3D_HU13 CPU AAQL64 AAQL64 AAQL64 AAQL64 AAQL64 Memory 1 Memor y 2 HDD 1(GB) ODD N SO2GBII6 SO2G N250GB5.4KS NSM8XS BII6 Card Reade r 5 in 1Build in Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN N Finger Print N Battery - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 221
RO Country Acer Part 2G/250/6L/ CB_bgn_0.3D_NL13 CPU AAQL64 AAQL64 AAQL64 AAQL64 AAQL64 Memory 1 Memor y 2 HDD 1(GB) ODD N SO2GBII6 SO2G N250GB5.4KS NSM8XS BII6 Card Reade r 5 in 1Build in Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN N Finger Print N Battery - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 222
Appendix A Model RO Country Acer Part No Description CPU AS5536- EME 644G25Mn A Memory 1 Memor y 2 HDD 1(GB) ODD N SO2GBII6 SO2G N250GB5.4KS NSM8XS BII6 Card Reade r 5 in 1Build in Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN N Finger Print N Battery - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 223
Model RO Country Acer Part No Description CPU AS5536644G25Mn AS5536721G32Mn Memory 1 Memor y 2 HDD 1(GB) ODD N SO2GBII6 SO2G N250GB5.4KS NSM8XS BII6 Card Reade r 5 in 1Build in Wireless LAN Wireless LAN1 Bluetooth 3rd WiFi 1x2 BGN 3rd WiFi 1x2 BGN N Finger Print N Battery - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 224
Appendix A 216 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 225
Windows® XP Pro environment, Windows® Vista. Refer to the following lists for components, adapter cards, and peripherals which have passed these tests. Regarding configuration, combination and test procedures, please refer to the Aspire 5738G/5738ZG/5738Z/ 5738/5338 series and Aspire 5536/5536G/5236 - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 226
Projector USB Port Test USB Keyboard/Mouse USB Speaker/Joystick USB Storage Drive USB Camera USB HUB and Others USB Printer/Scanner USB Flash Drive USB ODD 1394 Camera Access Point 802.11a Access Point 802.11g Access Point 802.11n Bluetooth Device 218 Specification Acer 211c 21", ViewSonic G220F - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 227
NETGEAR Wireless LAN card 802.11a ISDN Card Toshiba Type B for Bluetooth 128K ISDN Card GPRS Card Vodafone QL1ACC-21581 3G/GPRS card Sony Test Express Card Abcom 5-in-1 Adapter ExpressCard Reader Abcom GigaLan ExpressCard Sunix ECF2400 2 Ports 1394A ExpressCard Memory Card Test (SD/MS/MMC/SM - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 228
220 Appendix B - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 229
and valuable support resources whenever you need them. In the Technical Information section you can download information on all of Acer's Notebook, Desktop and Server models including: • Service guides for all models • User's manuals • Training materials • Bios updates • Software utilities - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 230
222 Appendix C - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 231
46 battery power indicator 11 BIOS 18 vendor 18 Version 18 BIOS Recovery 117 BIOS Recovery Boot Block 119 BIOS Recovery by Crisis Disk 119 steps 119 BIOS Recovery Hotkey 119 BIOS Utility 27-39 Navigating 28 Security 32 System Security 38 block diagram Aspire 5536/5536G/5236 Series 5 Aspire 5738G - Acer Aspire 5738ZG | Acer Aspire 5236, Aspire 5536, and Aspire 5536G Series Serv - Page 232
Battery Pack 100 Power Adapter 99 Processor 18 S Screw List 44 speakers hotkey 14 System 4 Block Diagram 4 System Check Procedures 98 System Memory 18 System Utilities 27 T Test Compatible Components 217 Touchpad Check 100 Troubleshooting 97 TV Tuner Board 50 U Undetermined Problems 114 utility BIOS