Husqvarna YTH22V42LS Owners Manual
Husqvarna YTH22V42LS Manual
 |
View all Husqvarna YTH22V42LS manuals
Add to My Manuals
Save this manual to your list of manuals |
Husqvarna YTH22V42LS manual content summary:
- Husqvarna YTH22V42LS | Owners Manual - Page 1
07002 YTH22V42LS Owner's Manual Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. 532 43 86-83 Rev. 8 - Husqvarna YTH22V42LS | Owners Manual - Page 2
in the manual before starting. • Do not put hands or feet near rotating parts or under the machine. Keep clear of the discharge opening at all times. • Only allow responsible adults, who are familiar with the instructions, to operate the machine. • Clear the area of objects such as rocks, toys, wire - Husqvarna YTH22V42LS | Owners Manual - Page 3
with the engine running. • Check grass catcher components and the discharge chute frequently and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently - Husqvarna YTH22V42LS | Owners Manual - Page 4
and using your tractor. • Follow the instructions under "Maintenance" and "Storage" sections of this owner's manual. WARNING: This tractor is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush-covered or grass-covered land unless the - Husqvarna YTH22V42LS | Owners Manual - Page 5
on label (label is located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). • For battery and battery cable installation see "REPLACING BATTERY" in the "Service and Adjustments" section in - Husqvarna YTH22V42LS | Owners Manual - Page 6
FOR PROPER POSITION OF ALL BELTS See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the - Husqvarna YTH22V42LS | Owners Manual - Page 7
your tractor or in literature supplied with the product. Learn and understand their meaning. REVERSE NEUTRAL HIGH LOW CHOKE FAST SLOW IGNITION SWITCH ENGINE OFF REVERSE OPERATION SYSTEM (ROS) ENGINE ON ENGINE START PARKING BRAKE MOWER HEIGHT MOWER LIFT LIGHTS ON FUEL BATTERY REVERSE - Husqvarna YTH22V42LS | Owners Manual - Page 8
transmission for pushing or slowly towing the tractor with the engine off. (P) SERVICE REMINDER / HOUR METER - Indicates when service is required for the engine and mower. (Q) 12-VOLT POWER PORT - Used for 12 volt accessories. (Z) AMMETER - Indicates charging (+) or discharging (-) of battery. 8 - Husqvarna YTH22V42LS | Owners Manual - Page 9
parking brake lever. Pedal should remain in brake position. Make sure parking brake will hold tractor secure. C B Fig. 4 STOPPING (See Fig. 5) MOWER BLADES • To stop mower blades, place attachment clutch control in the "DISENGAGED" position ( ). ENGINE • Move throttle control (D) between half and - Husqvarna YTH22V42LS | Owners Manual - Page 10
will shut off the engine. You must remain fully and centrally positioned in the seat to prevent the engine from hesitating or cutting off when operating your equipment on rough, rolling terrain or hills. • Select desired height of cut (see "TO ADJUST MOWER CUTTING HEIGHT") • Start mower blades by - Husqvarna YTH22V42LS | Owners Manual - Page 11
mower without either the entire grass catcher, on mowers so equipped, or the deflector shield (S) in place (See Fig. 10). S Fig. 10 REVERSE OPERATION SYSTEM (ROS) Your tractor not drive across any slope. • Choose the slowest speed before starting up or down hills. • Avoid stopping or changing speed - Husqvarna YTH22V42LS | Owners Manual - Page 12
section of this manual. NOTE: Service reminder runs when the ignition key is in any position but "STOP". For accurate reading, be sure key remains in the "STOP" position when engine is not running. BEFORE STARTING THE ENGINE CHECK ENGINE OIL LEVEL The engine in your tractor has been shipped - Husqvarna YTH22V42LS | Owners Manual - Page 13
in engaged position (See "TO TRANSPORT" in this section of manual). 7. Sitting in the tractor seat, start engine. After the engine is running, move throttle control to half (1/2) speed. Disengage parking brake. 8. Drive tractor forward for approximately five feet then backwards for five feet. Repeat - Husqvarna YTH22V42LS | Owners Manual - Page 14
Check Mower Levelness Check V-Belts Check Engine Oil Level Change Engine Oil (with oil filter) Change Engine Oil (without oil filter) E N Clean Air Filter G Clean Air Screen I Inspect Muffler/Spark Arrester N Replace Oil Filter (If equipped) E Clean Engine Cooling Fins Replace Spark Plug Replace Air - Husqvarna YTH22V42LS | Owners Manual - Page 15
cable and remove battery from tractor. Rinse the battery with plain water and dry. Clean terminals and battery cable ends with wire brush until bright. Coat terminals with grease or petroleum jelly. Reinstall battery (See "REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). - Husqvarna YTH22V42LS | Owners Manual - Page 16
range expected before oil change. All oil must meet API service classification SG-SL. • Be sure tractor is on level surface. • Oil will drain more freely when warm. • Catch oil in a suitable container. LEFT LOWER DASH COVER REMOVAL • Raise hood. CAUTION: Remove lower dash cover carefully to ensure - Husqvarna YTH22V42LS | Owners Manual - Page 17
gasoline. CLAMP FUEL FILTER Fig. 17 CLEANING • Clean engine, battery, seat, finish, etc. of all foreign matter. • Clean debris from steering plate. Debris can restrict clutch/brake pedal shaft movement, causing belt slip and loss of drive. CAUTION: Avoid all pinch points and movable parts (See Fig - Husqvarna YTH22V42LS | Owners Manual - Page 18
each use. 1. Drive the tractor to a level, clear spot on your lawn, near enough to a water spigot for your garden hose to reach. IMPORTANT: Make certain the tractor's discharge chute is directed AWAY from your house, garage, parked cars, etc. Remove bagger chute or mulch cover if attached. 2. Make - Husqvarna YTH22V42LS | Owners Manual - Page 19
wire where it cannot come in contact with plug. TO REMOVE MOWER (See Fig. 20) • Place attachment clutch in "DISENGAGED" position. • Lower attachment lift lever to its lowest position. • Remove mower belt from electric clutch pulley (M). See Mower Drive Belt Removal in "TO REPLACE MOWER BLADE DRIVE - Husqvarna YTH22V42LS | Owners Manual - Page 20
FOR PROPER ROUTING IN ALL MOWER PULLEY GROOVES. • Raise attachment lift lever to highest position. • If necessary, adjust gauge wheels before operating mower as shown in the Operation section of this manual. See Mower Drive Belt Installation in "TO REPLACE MOWER BLADE DRIVE BELT" in this section of - Husqvarna YTH22V42LS | Owners Manual - Page 21
, see steps in Visual Adjustment instructions above. • Recheck measurements, adjust if necessary until both sides are equal. FRONT-TO-BACK ADJUSTMENT (See Figs. 28 & 29) IMPORTANT: Deck must be level side-to-side. To obtain the best cutting results, the mower blades should be adjusted so the front - Husqvarna YTH22V42LS | Owners Manual - Page 22
SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT MOWER DRIVE BELT REMOVAL (See Fig. 30) • Park tractor on a level surface. Engage parking brake. • Lower attachment lift lever to its lowest position. • Remove mandrel covers. • Remove any dirt or grass clippings which may have accumulated - Husqvarna YTH22V42LS | Owners Manual - Page 23
SERVICE AND ADJUSTMENTS TO REPLACE MOTION DRIVE BELT (See Fig. 33) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL - 1. Remove mower (See "TO REMOVE MOWER" section in this manual). NOTE: - Husqvarna YTH22V42LS | Owners Manual - Page 24
or prevent it from starting. • Check wiring. TO REPLACE FUSE Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash. TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 37) • Raise hood. • Unsnap headlight wire connector. • Stand in front of tractor. Grasp hood at sides - Husqvarna YTH22V42LS | Owners Manual - Page 25
a few seconds to distribute oil. • Replace with new spark plug(s). OTHER • Do not store gasoline from one season to another. • Replace your gasoline can if your can starts to rust. Rust and/or dirt in your gasoline will cause problems. • If possible, store your tractor indoors and cover it to give - Husqvarna YTH22V42LS | Owners Manual - Page 26
of grass, leaves, trash under mower. 3. Clean underside of mower housing. 4. Dirty air filter. 4. Clean/replace air filter. 5. Low oil level/dirty oil. 5. Check oil level/change oil. 6. Faulty spark plug. 6. Clean and regap or change spark plug. 7. Dirty fuel filter. 7. Replace fuel filter - Husqvarna YTH22V42LS | Owners Manual - Page 27
mower housing. 8. Mower drive belt worn. 8. Replace mower drive belt. 9. Blades improperly installed. 9. Reinstall blades sharp edge down. 10. Improper blades used. 10. Replace with blades listed in parts manual. 11. Clogged mower deck vent holes from buildup 11. Clean around mandrels to open - Husqvarna YTH22V42LS | Owners Manual - Page 28
43 29-14 5 532 42 38-29 6 532 43 84-74 7 539 10 57-43 8 539 11 32-24 9 532 14 50-05 DESCRIPTION Decal, Operators Badge, Hood Decal, Emblem Panel SD Decal, Eng. Decal, Customer Respons. Decal, Replacement Decal, No Step Decal, Warning Decal, Battery Dnge/Poi KEY PART NO. NO. 10 532 41 - Husqvarna YTH22V42LS | Owners Manual - Page 29
START B + S + A1 L+A2 BLACK IGNITION UNIT (OPTIONAL) SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES) BLUE HOUR METER BLACK FUEL LINE BLUE FUEL SHUT-OFF 52 41 DASH HARNESS CONNECTOR 29 WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE - Husqvarna YTH22V42LS | Owners Manual - Page 30
TRACTOR - MODEL NO. YTH22V42LS (96043011300), PRODUCT NO. 960 43 01-13 ELECTRICAL T15S 90 33 22 30 27 2 1 91 99 100 8 79 21 34 24 27 42 43 41 26 40 25 28 55 16 0 60 AM PS 60 45 46 With 12V Outlet Option 103 59 71 29 30 102 105 - Husqvarna YTH22V42LS | Owners Manual - Page 31
TRACTOR - MODEL NO. YTH22V42LS (96043011300), PRODUCT NO. 960 43 01-13 ELECTRICAL KEY PART NO. NO. DESCRIPTION 1 532 16 34-65 Battery 2 874 76 04-12 Bolt Hex Head 1/4-20 x 3/4 8 532 18 64-91 Box Battery 16 532 17 61-38 Switch Interlock Push-In 21 532 40 02-52 Harness Socket Light w/4152J 22 532 - Husqvarna YTH22V42LS | Owners Manual - Page 32
TRACTOR - MODEL NO. YTH22V42LS (96043011300), PRODUCT NO. 960 43 01-13 CHASSIS 15 208 3 204 297 336 159 346 203 130 14 214 206 137 5 176 176 178 234 - Husqvarna YTH22V42LS | Owners Manual - Page 33
TRACTOR - MODEL NO. YTH22V42LS (96043011300), PRODUCT NO. 960 43 01-13 CHASSIS KEY PART Hood Spacer Fender Nut Lock 5/16-18 unc Clip Retainer Console Console Deck Lift Console Shift Console Insert RH Console Insert LH Screw 1/4-20 X 3/8 Insert Reflective LH Cover LH Cover RH Clip Clip Insulator Kit - Husqvarna YTH22V42LS | Owners Manual - Page 34
TRACTOR - MODEL NO. YTH22V42LS (96043011300), PRODUCT NO. 960 43 01-13 DRIVE 221 213 207 206 92 125 116 160 56 209 26 185 221 184 35 42 197 196 125 125 125 170 64 167 159 231 80 285 226 160 51 214 208 153 284 49 185 186 188 189 187 - Husqvarna YTH22V42LS | Owners Manual - Page 35
TRACTOR - MODEL NO. YTH22V42LS (96043011300), PRODUCT NO. 960 43 01-13 DRIVE KEY PART NO. NO. DESCRIPTION 1 Transaxle, TUFFTORQ K46BT (426120) (Order parts from transaxle manufacturer) 2 532 12 35-83 Key 15 819 13 13-16 Washer 13/32 x 13/16 x 16 Ga. 17 532 41 36-78 Spring, Brake 26 532 19 96-79 - Husqvarna YTH22V42LS | Owners Manual - Page 36
TRACTOR - MODEL NO. YTH22V42LS (96043011300), PRODUCT NO. 960 43 01-13 ENGINE 30!2+ª!22%34%2ª+)4 ENGINE TEX?BS CYL? 36 - Husqvarna YTH22V42LS | Owners Manual - Page 37
TRACTOR - MODEL NO. YTH22V42LS (96043011300), PRODUCT NO. 960 43 01-13 ENGINE KEY PART NO. NO. DESCRIPTION 1 ------ 2 532 14 97-23 9 532 19 43-20 11 532 40 00-08 12 532 40 50-97 15 532 43 80-80 18 532 43 92-08 20 532 42 43-40 21 532 41 63-58 28 - Husqvarna YTH22V42LS | Owners Manual - Page 38
TRACTOR - MODEL NO. YTH22V42LS 37 22 532 42 05-37 26 Support Lower Insert, Wheel Steering Screw 3/8-16 x 3/4 Gear, Sector Plate Washer 9/16 ID x 2-3/8 OD 12 Ga. Nut Lock Flg. 3/8-16 unc KEY PART 532 19 98-49 Retainer Clip Spring Steering 65 532 19 47-34 61-97 Bracket Deck Susp. Front 78 532 05 70-79 - Husqvarna YTH22V42LS | Owners Manual - Page 39
TRACTOR - MODEL NO. YTH22V42LS (96043011300), PRODUCT NO. 960 43 01-13 SEAT ASSEMBLY 1 8 7 41 40 88 7 8 10 21 6 37 6 37 2 44 43 21 seat-tex_6.5SL_3 KEY PART NO. NO. 1 532 42 40-71 2 532 18 01-66 3 532 14 06-75 6 873 80 06-00 7 532 12 41-81 8 532 17 18-77 10 532 19 - Husqvarna YTH22V42LS | Owners Manual - Page 40
TRACTOR - MODEL NO. YTH22V42LS (96043011300), PRODUCT NO. 960 43 01-13 MOWER DECK 52 25 34 27 56 28 29 35 26 38 37 24 54 53 32 57 55 41 40 34 31 42 44 14 45 24 25 33 46 30 50 23 5 22 19 51 3 4 18 10 8 59 36 1 9 13 12 60 43 21 - Husqvarna YTH22V42LS | Owners Manual - Page 41
TRACTOR - MODEL NO. YTH22V42LS (96043011300), PRODUCT NO. 960 43 01-13 MOWER DECK KEY PART NO. NO. 1 575 43 80-01 2 539 11 21-70 3 539 10 75-20 4 539 10 76-30 5 539 10 75-90 6 539 11 20-78 7 539 10 75-22 8 532 17 60-66 9 532 17 91-27 10 539 19 42-08 - Husqvarna YTH22V42LS | Owners Manual - Page 42
TRACTOR - MODEL NO. YTH22V42LS (96043011300), PRODUCT NO. 960 43 01-13 MOWER LIFT 7 87 3 10 97 91 87 89 88 2 97 91 lift-tex_28 89 87 KEY PART NO. NO. 2 532 42 20-27 3 532 19 52-31 7 532 41 15-55 10 532 19 63-14 87 532 19 42-09 88 532 41 07-10 DESCRIPTION - Husqvarna YTH22V42LS | Owners Manual - Page 43
43 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than - Husqvarna YTH22V42LS | Owners Manual - Page 44
08.11.11 BD Printed in the U.S.A.
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
 |
 |
YTH22V42LS
Owner's Manual
532 43 86-83 Rev. 8
07002
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine.
The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty.