Husqvarna YTH22V46 Owners Manual
Husqvarna YTH22V46 Manual
 |
View all Husqvarna YTH22V46 manuals
Add to My Manuals
Save this manual to your list of manuals |
Husqvarna YTH22V46 manual content summary:
- Husqvarna YTH22V46 | Owners Manual - Page 1
07002 YTH22V46XLS Owner's Manual Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. 532 44 16-52 Rev. 2 - Husqvarna YTH22V46 | Owners Manual - Page 2
, leaves or other debris build-up which can touch hot exhaust / engine parts and burn. Do not allow the mower deck to plow leaves or other debris which can cause build-up to occur. Clean any oil or fuel spillage before operating or storing the machine. Allow machine to cool before storage. II. SLOPE - Husqvarna YTH22V46 | Owners Manual - Page 3
and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary - Husqvarna YTH22V46 | Owners Manual - Page 4
°F) SAE 5W-30 (below 32°F) Oil Capacity: W/ Filter: 64 oz W/O Filter: 60 oz Spark Plug: Champion QC12YC (Gap: .040") Ground Speed (MPH): Forward: Reverse: 0 - 5.5 0 - 2.4 Charging System: 16 AMPS @ 3600 RPM Battery: AMP/HR: MIN. CCA: Case Size: 28 230 U1R Blade Bolt Torque: 45-55 FT - Husqvarna YTH22V46 | Owners Manual - Page 5
(label is located between terminals) A charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). • For battery and battery cable installation see "REPLACING BATTERY" in the "Service and Adjustments" section in this - Husqvarna YTH22V46 | Owners Manual - Page 6
(See the Operation and Maintenance sections in this manual). ✓ It is important to purge the transmission before operating your tractor for the first time. Follow proper starting and transmission purging instructions (See "TO START ENGINE" and "PURGE TRANSMISSION" in the Operation section of this - Husqvarna YTH22V46 | Owners Manual - Page 7
NEUTRAL HIGH LOW CHOKE FAST SLOW IGNITION SWITCH ENGINE OFF REVERSE OPERATION SYSTEM (ROS) ENGINE ON ENGINE START PARKING BRAKE MOWER HEIGHT MOWER LIFT LIGHTS ON FUEL BATTERY REVERSE FORWARD CRUISE CONTROL CLUTCH/BRAKE PEDAL 15 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED - Husqvarna YTH22V46 | Owners Manual - Page 8
transmission for pushing or slowly towing the tractor with the engine off. (P) SERVICE REMINDER / HOUR METER - Indicates when service is required for the engine and mower. (Q) 12-VOLT POWER PORT - Used for 12 volt accessories. (Z) AMMETER - Indicates charging (+) or discharging (-) of battery - Husqvarna YTH22V46 | Owners Manual - Page 9
. 5) MOWER BLADES • To stop mower blades, place attachment clutch control in the "DISENGAGED" position ( ). NOTE: Failure to move throttle control between half and full speed (fast) position, before stopping may cause engine to "backfire". • Turn ignition key (F) to "STOP" position and remove key - Husqvarna YTH22V46 | Owners Manual - Page 10
fully and centrally positioned in the seat to prevent the engine from hesitating or cutting off when operating your equipment on rough, rolling terrain or hills. • Select desired height of cut (see "TO ADJUST MOWER CUTTING HEIGHT") • Start mower blades by engaging attachment clutch control. 10 - Husqvarna YTH22V46 | Owners Manual - Page 11
of your tractor. SERVICE REMINDER/HOUR METER Service reminder shows the total number of hours the engine has run and flashes to indicate that the engine or mower needs servicing. When service is required, the service reminder will flash for two hours. To service engine and mower, see the Maintenance - Husqvarna YTH22V46 | Owners Manual - Page 12
for a few seconds, remove and read oil level. If necessary, add oil until "FULL" mark on dipstick is reached. Do not overfill. • For cold weather operation you should change oil for easier starting (See "OIL VISCOSITY CHART" in the Maintenance section of this manual). • To change engine oil, see the - Husqvarna YTH22V46 | Owners Manual - Page 13
transmission is now purged and now ready for normal operation. MOWING TIPS • Tire chains cannot be used when the mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual - Husqvarna YTH22V46 | Owners Manual - Page 14
described in the Service and Adjustments section of this manual. • At least once a year you should replace the spark plug, clean or replace air filter, and check blades and belts for wear. A new spark plug and clean air filter assure proper air-fuel mixture and help your engine run better and - Husqvarna YTH22V46 | Owners Manual - Page 15
Reinstall battery (See "REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). Fig. 13 V-BELTS BLADE CARE Check V-belts for deterioration and wear after 100 hours For best results mower blades must be kept sharp. Replace of operation and replace if necessary. The belts are - Husqvarna YTH22V46 | Owners Manual - Page 16
oil level. ENGINE OIL FILTER Replace the engine oil filter every season or every other oil change if the tractor is used more than 100 hours in one year. CLEAN AIR SCREEN TO CHANGE ENGINE OIL (See Fig. 15 & 16) Determine temperature range expected before oil change. All oil must meet API service - Husqvarna YTH22V46 | Owners Manual - Page 17
of operation, whichever occurs first. Spark plug type and gap setting are shown in "PRODUCT SPECIFICATIONS" section of this manual. IN-LINE FUEL FILTER (See Fig. 17) The fuel filter should be replaced once each season. If fuel filter becomes clogged, obstructing fuel flow to carburetor, replacement - Husqvarna YTH22V46 | Owners Manual - Page 18
ANY SERVICE OR ADJUSTMENTS: • Depress brake pedal fully and set parking brake. • Place attachment clutch in "DISENGAGED" position. • Turn ignition key to "STOP" and remove key. • Make sure the blades and all moving parts have completely stopped. • Disconnect spark plug wire from spark plug and - Husqvarna YTH22V46 | Owners Manual - Page 19
clutch pulley (M). M C D Fig. 22 Fig. 24 IMPORTANT: CHECK BELT FOR PROPER ROUTING IN ALL MOWER PULLEY GROOVES. • Raise attachment lift lever to highest position. • If necessary, adjust gauge wheels before operating mower as shown in the Operation section of this manual. B F M A E C D Fig. 25 - Husqvarna YTH22V46 | Owners Manual - Page 20
, see step in Visual Adjustment instructions above. • Recheck measurements, adjust if necessary until both sides are equal. FRONT-TO-BACK ADJUSTMENT (See Figs. 28 & 29) IMPORTANT: Deck must be level side-to-side. To obtain the best cutting results, the mower blades should be adjusted so the front - Husqvarna YTH22V46 | Owners Manual - Page 21
proper routing in all mower pulley grooves. • Raise attachment lift lever to highest position. V M • Pull belt slack toward rear of tractor. Carefully remove belt upwards from transmission input pulley and over cooling fan blades (F). • Remove belt downward from engine pulley and around electric - Husqvarna YTH22V46 | Owners Manual - Page 22
wear eye protection when around batteries. If your battery is too weak to start the engine, it should be recharged. (See "BATTERY" in the MAINTENANCE section of this manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH A 12 VOLT - Husqvarna YTH22V46 | Owners Manual - Page 23
cause your tractor to run poorly, stop running, or prevent it from starting. • Check wiring. TO REPLACE FUSE Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash. Fig. 35 TRANSMISSION REMOVAL/REPLACEMENT Should your transmission require removal for service or - Husqvarna YTH22V46 | Owners Manual - Page 24
the gas tank and carburetor if using fuel stabilizer. ENGINE OIL Drain oil (with engine warm) and replace with clean engine oil. (See "ENGINE" in the Maintenance section of this manual). CYLINDER(S) • Remove spark plug(s). • Pour one ounce of oil through spark plug hole(s) into cylinder(s). • Turn - Husqvarna YTH22V46 | Owners Manual - Page 25
underside of mower housing. 4. Dirty air filter. 4. Clean/replace air filter. 5. Low oil level/dirty oil. 5. Check oil level/change oil. 6. Faulty spark plug. 6. Clean and regap or change spark plug. 7. Dirty fuel filter. 7. Replace fuel filter. 8. Stale or dirty fuel. 8. Empty fuel tank - Husqvarna YTH22V46 | Owners Manual - Page 26
, trash under mower. 7. Clean underside of mower housing. 8. Mower drive belt worn. 8. Replace mower drive belt. 9. Blades improperly installed. 9. Reinstall blades sharp edge down. 10. Improper blades used. 10. Replace with blades listed in parts manual. 11. Clogged mower deck vent holes - Husqvarna YTH22V46 | Owners Manual - Page 27
GRAY JUNCTION CONNECTOR CHASSIS HARNESS SEAT SWITCH (NOT OCCUPIED) SHORTING CONNECTOR IGNITION UNIT (OPTIONAL) SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES) BLUE HOUR METER BLACK FUEL BLUE LINE BLUE FUEL SHUT-OFF SOLENOID (IF EQUIPPED) RED CHARGING SYSTEM OUTPUT 9-15 AMP DC @ 3600 RPM - Husqvarna YTH22V46 | Owners Manual - Page 28
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 ELECTRICAL T27S 90 2 27 1 91 99 100 8 22 79 21 81 34 26 40 28 55 33 30 24 27 42 43 41 25 16 0 60 AMPS 60 45 46 With 12V Outlet Option 103 59 71 29 28 102 105 - Husqvarna YTH22V46 | Owners Manual - Page 29
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 ELECTRICAL KEY PART NO. NO. 1 532 16 34-65 2 874 76 04-12 8 532 18 64-91 16 532 17 61-38 21 532 40 02-52 22 532 00 41-52 24 532 40 02-53 25 532 41 28-95 26 532 - Husqvarna YTH22V46 | Owners Manual - Page 30
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 CHASSIS 297 208 15 204 18 3 203 206 137 5 336 176 214 14 130 130 130 130 191 - Husqvarna YTH22V46 | Owners Manual - Page 31
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 CHASSIS KEY PART NO. NO. 3 Engine Screw 5/16-18 x 3/4 Fender Nut Lock 5/16-18 Screw 5/16-18 x 1/2 Screw #10 x 0.750 BOS Thread Bumper Dash Air Duct Pivot Bracket Shield Browning Screw 3/8-16 x 3/4 Window Fuel Screw Support - Husqvarna YTH22V46 | Owners Manual - Page 32
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 DRIVE 221 213 207 206 92 125 116 160 56 209 26 216 171 221 184 42 143 - Husqvarna YTH22V46 | Owners Manual - Page 33
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 DRIVE KEY PART NO. NO. DESCRIPTION 1 Transaxle, TUFFTORQ K46BT 2 532 12 91-64 Nut Push 167 532 40 52-57 Latch Brake Parking 170 532 19 43-22 Keeper Belt Centerspan 171 872 11 06-16 Bolt RDHD SQNK 3/8-16 unc x 2 183 532 - Husqvarna YTH22V46 | Owners Manual - Page 34
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 ENGINE 1 91 37 28 18 37 15 29 90 30!2+ª!22%34%2ª+)4 engine-tex_bs-2cyl_23 87 45 62 84 69 71 12 11 70 41 42 79 85 9 2 34 - Husqvarna YTH22V46 | Owners Manual - Page 35
of factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions (temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing and capacity limitations - Husqvarna YTH22V46 | Owners Manual - Page 36
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 STEERING ASSEMBLY 26 45 51 1 63 21 57 16 19 60 57 63 59 64 28 13 22 35 58 6 9 87 67 2 66 9 87 61 4 15 69 68 70 steering-tex_HUSQHR_1_r1 67 14 62 14 15 6 5 13 53 8 13 36 - Husqvarna YTH22V46 | Owners Manual - Page 37
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 STEERING ASSEMBLY KEY PART NO. NO. DESCRIPTION 1 532 43 97-40 Wheel, Steering 2 532 19 59-68 Axle Asm., Front 4 532 40 30-87 Spindle Asm., LH 5 532 40 30-88 Spindle 18 67-37 Adapter, Wheel Steering 22 532 42 05-37 Strg. - Husqvarna YTH22V46 | Owners Manual - Page 38
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 SEAT ASSEMBLY 1 8 8 7 7 8 41 40 8 10 21 44 43 6 37 2 37 21 3 seat-tex_6.5SL_2 KEY PART NO. NO. 1 532 42 40-71 2 532 18 01-66 3 532 14 06-75 6 873 80 06-00 7 532 12 41-81 8 532 17 18- - Husqvarna YTH22V46 | Owners Manual - Page 39
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 MOWER LIFT 87 7 10 3 97 90 98 89 100 2 91 88 97 87 89 101* 89 87 lift-tex_17_r3 *Key 91 may be substituted for Key 101 KEY PART 5/16 Bow Tie Lock Link Lift Susp Mower Rear KEY PART NO. NO. 97 817 00 06-12 - Husqvarna YTH22V46 | Owners Manual - Page 40
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 MOWER DECK 40 46 145 59 34 2 117 116 119 40 1 57 147 56 55 62 197 36 241 30 242 200 40 188 189 6 19 189 - Husqvarna YTH22V46 | Owners Manual - Page 41
TRACTOR - - MODEL NUMBER YTH22V46XLS (96043011201), PRODUCT NO. 960 43 01-12 MOWER DECK KEY PART Mower Housing Cover Mandrel RH Cover Mandrel LH Arm Suspension Bolt/Washer asm 7/16-20 unf Blade Mower 28-70 - - 532 41 82-26 DESCRIPTION V-Belt Bolt Bolt, Shoulder Wheel, Gauge Nut Centerlock 3/8-16 - Husqvarna YTH22V46 | Owners Manual - Page 42
16-52 - - 532 44 16-53 DESCRIPTION Decal, Battery Dnge/Poi Decal, Mower V-Belt Schematic Decal, Bypass Pad, Footrest, LH Pad, Footrest, RH Manual, Owner's (English) Manual, Owner's (Spanish) WHEELS AND TIRES 1 2 11 3 4 7 10 6 wheel_art_1-tex 5 9 8 KEY PART NO. NO. 1 532 05 91-92 2 532 06 - Husqvarna YTH22V46 | Owners Manual - Page 43
43 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than - Husqvarna YTH22V46 | Owners Manual - Page 44
02.09.11 BAD Printed in the U.S.A.
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
 |
 |
YTH22V46XLS
Owner's Manual
07002
532 44 16-52 Rev. 2
Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine.
The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty.