Invacare TDXSCV Owners Manual 2

Invacare TDXSCV Manual

Get Invacare TDXSCV PDF manuals and user guides View all Invacare TDXSCV manuals
Add to My Manuals
Save this manual to your list of manuals

Invacare TDXSCV manual content summary:

  • Invacare TDXSCV | Owners Manual 2 - Page 1
    Invacare® TDX® SC, Invacare TDX Spree Power Wheelchair Base User Manual EN This manual MUST be given to the user of the product. BEFORE using this product, read this manual and save for future reference.
  • Invacare TDXSCV | Owners Manual 2 - Page 2
    modification in whole or in part is prohibited without prior written permission from Invacare. Trademarks are identified by ™ and ®. All trademarks are owned by or licensed to Invacare Corporation or its subsidiaries unless otherwise noted. Invacare® TDX® SC, Invacare TDX Spree 2 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 3
    ...14 Transport...15 Repair or Service Information ...17 Safety/Handling...18 A Note to Wheelchair Assistants...20 Stability and Balance ... Seats ...27 Storage ...28 Electrical - Grounding Instructions...29 Electrical - Batteries ...29 Part No 1149267 3 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 4
    Wheelchairs with TRRO ...35 TDX SC with TRRO...36 TDX Spree with TRRO...36 SECTION 4-TECHNICAL DATA 37 Typical Product Parameters ...37 Models...37 Overall Dimensions ...37 Seat ...38 Wheels ...38 Battery ...38 Axle...38 Footrests ...39 Weight ...39 Invacare® TDX® SC, Invacare TDX Spree 4 Part
  • Invacare TDXSCV | Owners Manual 2 - Page 5
    Remote On/Off Switch...54 Mode Switch ...55 Memory Card Slot...55 When to Charge Batteries...55 SPJ+, SPJ+ w/PSS and SPJ+ w/ACC Joysticks...56 Part No 1149267 5 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 6
    Transport Ready Packages...68 Compliance Information...69 Specifications...69 Positioning the Wheelchair in the Vehicle ...70 Securement Points ...71 Securing the Wheelchair ...71 Securing the Occupant ...72 Wheelchair-Anchored Belts ...72 Invacare® TDX® SC, Invacare TDX Spree 6 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 7
    ...79 Service Inspection ...80 Six Month Inspection ...80 Inspect/Adjust Every 18 Months ...82 Inspect/Adjust Every 2 Years ...82 Batteries ...83 Using the Proper Batteries ...84 Removing/Installing the Batteries From/Into the Wheelchair...85 Removing/Installing the Batteries on TDX SC without
  • Invacare TDXSCV | Owners Manual 2 - Page 8
    106 Wheelchairs with Elevating Seat ...107 SECTION 8-TROUBLESHOOTING 108 Driving Performance ...108 Electrical...108 SPJ+, SPJ+ w/PSS or SPJ+ w/ACC Joysticks ...108 CMPJ+, PSR+, PSF+ Joysticks or Displays ...111 Checking Battery Charge Level ...114 Invacare® TDX® SC, Invacare TDX Spree 8 Part No
  • Invacare TDXSCV | Owners Manual 2 - Page 9
    1 GENERAL 1.1 Symbols Warnings Signal words are used in this manual and apply to hazards or unsafe practices which could result in is not avoided.  Gives useful tips, recommendations and information for efficient, trouble-free use. Part No 1149267 9 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 10
    referenced in this manual. MK6i™ Electronics Programming Guide Adjustable ASBA Owner's Manual Van Seat Owner's Manual Formula™ CG Seating System Adjustable ASBA Service Manual MANUAL PART NUMBER 1141471 1143192 1143195 1143155 1143238 Invacare® TDX® SC, Invacare TDX Spree 10 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 11
    transferable or assignable to any subsequent purchaser or owner. Coverage under this warranty will end upon INVACARE. THE WARRANTY SHALL NOT APPLY TO PROBLEMS ARISING FROM NORMAL WEAR AND TEAR OR FAILURE TO ADHERE TO THE PRODUCT INSTRUCTIONS Part No 1149267 11 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 12
    transferable or assignable to any subsequent purchaser or owner. Coverage under this warranty will end upon INVACARE. THE WARRANTY SHALL NOT APPLY TO PROBLEMS ARISING FROM NORMAL WEAR AND TEAR OR FAILURE TO ADHERE TO THE PRODUCT INSTRUCTIONS Invacare® TDX® SC, Invacare TDX Spree 12 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 13
    type of wheelchair to be used by an individual rests solely with the user and his/ her healthcare professional capable of making such a selection. Invacare highly recommends working with a certified rehab technology supplier and/or a member of NRRTS or RESNA. Part No 1149267 13 Invacare® TDX® SC
  • Invacare TDXSCV | Owners Manual 2 - Page 14
    entered during the set-up procedure. If the wheelchair does not perform to specifications, turn the wheelchair Off immediately and reenter set-up specifications. Repeat this procedure until the wheelchair performs to specifications. Invacare® TDX® SC, Invacare TDX Spree 14 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 15
    WHEELCHAIRS To avoid injury or property damage when moving an unoccupied wheelchair down an incline, perform the following: • Engage motor lock levers. • Turn power on and adjust speed to minimal setting. • Drive wheelchair forward down incline. Part No 1149267 15 Invacare® TDX® SC, Invacare TDX
  • Invacare TDXSCV | Owners Manual 2 - Page 16
    . Extreme caution is advised when it is necessary to move an unoccupied power wheelchair up or down the stairs. Invacare recommends using two assistants and making thorough preparations. Make sure to use ONLY secure, non-detachable parts for hand-hold supports. DO NOT use an escalator to move
  • Invacare TDXSCV | Owners Manual 2 - Page 17
    (1) the owner's operator and maintenance manual, (2) the service manual (if applicable) and (3) the seating system's manual (if applicable). if you are unable to understand the warnings, cautions and instructions, contact Invacare technical support before attempting to service or operate
  • Invacare TDXSCV | Owners Manual 2 - Page 18
    wheelchair users often develop skills to deal with daily living activities that may differ from those described in this manual. Invacare . DO NOT leave the power button On when entering or exiting your wheelchair. DO NOT go UP wheelchair. Invacare® TDX® SC, Invacare TDX Spree 18 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 19
    your wheelchair unless it has the proper tire pressure (P.S.I.). DO NOT overinflate the tires. Failure to follow these recommendations may cause the tire to explode and cause bodily harm. The recommended tire pressure is listed on the side wall of the tire. Part No 1149267 19 Invacare® TDX® SC
  • Invacare TDXSCV | Owners Manual 2 - Page 20
    the wheelchair or as lifting supports, as they may be inadvertently released, resulting in possible injury to the user and/or assistant(s). When learning a new assistance technique, have an experienced assistant help you before attempting it alone. Invacare® TDX® SC, Invacare TDX Spree 20 Part No
  • Invacare TDXSCV | Owners Manual 2 - Page 21
    be different from other wheelchairs previously used. This power wheelchair has Invacare's SureStep® technology, a feature that provides the wheelchair with optimum traction and shift the users weight forward resulting in reduced stability. Part No 1149267 21 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 22
    in motion. The stability lock is not designed to operate while the wheelchair is at rest, such as during transfers in and out of the wheelchair. DO NOT assume that the stability lock feature is operating when the wheelchair is not moving. Invacare® TDX® SC, Invacare TDX Spree 22 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 23
    the drive wheels providing traction and motor strength to power the wheelchair over the obstacle. CAUTION Be aware of the condition will cause the wheelchair to feel unstable. Bump/Threshold FIGURE 1 Coping with Everyday Obstacles Part No 1149267 23 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 24
    walking beam. A pinch point exist between walking beam/head tube cap and telescoping tube when TDX SP is at the lowest seat to floor height. Pinch point may occur when rotating the Point Front Caster Front Caster FIGURE 2 Pinch Points Invacare® TDX® SC, Invacare TDX Spree 24 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 25
    positioning while leaning or bending could cause the wheelchair to tip forward onto anti-tippers. Engage motor locks and turn power off before reaching, leaning or bending only to FIGURE 3. FIGURE 3 Reaching, Leaning and Bending - Forward Part No 1149267 25 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 26
     For this procedure, refer to FIGURE 4. Position wheelchair as close as possible to the desired object. Position power off. Reach back only as far as your arm will extend without changing your sitting position. FIGURE 4 Reaching, Bending - Backward Invacare® TDX® SC, Invacare TDX Spree 26 Part
  • Invacare TDXSCV | Owners Manual 2 - Page 27
    transfer, little or no seat platform will be beneath you. Use a transfer board if at all possible. Front View Minimize Gap Distance Wheelchair Seat Top View Minimize Gap Distance Wheelchair Seat Seat Seat FIGURE 5 Pinch Points Part No 1149267 27 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 28
    power wheelchair from a rain storm and retain wheelchair operation. DO NOT leave power wheelchair in a rain storm of any kind. DO NOT use power wheelchair in a shower. DO NOT leave power wheelchair torn or cracked, replace IMMEDIATELY. Invacare® TDX® SC, Invacare TDX Spree 28 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 29
    manual are based on the use of deep cycle gel cell batteries. Invacare strongly recommends their use as the power source for this unit. Carefully read battery/battery charger information prior to installing, servicing or operating your wheelchair. Part No 1149267 29 Invacare® TDX® SC, Invacare
  • Invacare TDXSCV | Owners Manual 2 - Page 30
    wheelchair is outside. DO NOT sit in the wheelchair while charging the batteries. READ and CAREFULLY follow the manufacturer's instructions for each charger (supplied or purchased). If charging instructions plug or the extension cord plug. Invacare® TDX® SC, Invacare TDX Spree 30 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 31
    radios, and cellular phones. The interference (from radio wave sources) can cause the powered wheelchair to release its brakes, move by itself, or move in unintended directions. It can also listed below, your risk to EMI will be minimized. Part No 1149267 31 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 32
    radios, and cellular phones can affect powered wheelchairs and motorized scooters. FOLLOWING THE WARNINGS LISTED BELOW SHOULD REDUCE THE CHANCE OF UNINTENDED BRAKE RELEASE OR POWERED WHEELCHAIR MOVEMENT WHICH COULD RESULT IN SERIOUS INJURY. Invacare® TDX® SC, Invacare TDX Spree 32 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 33
    , or turn ON personal communication devices, such as cellular phones, while the powered wheelchair is turned ON; 2) Be aware of nearby transmitters, such as radio or as manufactured by Invacare may adversely affect the EMI immunity levels. Part No 1149267 33 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 34
    Turn power on and adjust speed to minimal setting. • Drive wheelchair forward down incline. Serial Number Label Invacare® TDX® SC, Invacare TDX Spree personal injury and/or damage to the electrical system. See Owner's Manual. DO NOT remove fuse or mounting hardware from POSITIVE (+) Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 35
    TRRO Auto style seat positioning strap shown. This label is also on the airline style seat positioning strap. 3.3 All Wheelchairs with Elevate 3 LABEL LOCATIONS 3.4 All Wheelchairs with TRRO Part No 1149267 Also on opposite side. Also on opposite side. 35 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 36
    LOCATIONS 3.5 TDX SC with TRRO 3.6 TDX Spree with TRRO THIS WHEELCHAIR COMPLIES WITH ANSI/RESNA WC/19 Refer to attached TRANSPORT READY OPTION Instruction card and wheelchair Owner's Manual before use. Lower seat to lowest position, ensure docking pins are fully engaged and power is turned
  • Invacare TDXSCV | Owners Manual 2 - Page 37
    With Elevating ASBA Seat: 4 TECHNICAL DATA TDXSC, TDXSCV, TDXSC2-CG TDXSPREE, TDXSPREE-CG TDX SC TDX SPREE 24 inch 34 inch (Without Front Rigging), 39 inch (With Center Mount Front Rigging are ± .50 inches unless otherwise indicated. Part No 1149267 37 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 38
    10°) TDX SPREE TDX SC TDX SPREE 6 x 2 inch Semi-pneumatic with Precision Sealed Bearings Two sided fork (Standard), One sided fork (Optional) 10 x 3 Foam Filled Non-adjustable TDX SC U1 TDX SPREE TDX SC Non-adjustable TDX SPREE Invacare® TDX® SC, Invacare TDX Spree 38 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 39
    items that the user may require [back pack, etc.]). Example: If weight limitation of the wheelchair is 300 lbs and additional items equal 25 lbs, subtract 25 lbs from 300 lbs this means the maximum weight limitation of the user is 275 lbs. Part No 1149267 39 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 40
    5 WHEELCHAIR OPERATION 5 Wheelchair Operation ƽ WARNING After ANY adjustments, repair or service and before use, make sure that all attaching hardware is Mounting Tube FIGURE 1 Adjustment Lock Lever Preparing the Joystick for Use Invacare® TDX® SC, Invacare TDX Spree 40 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 41
    following steps: JOYSTICK CMPJ+ SPJ+ ACTION Move the On/Off switch Back to the Off position. Press the On/Off button. 5 WHEELCHAIR OPERATION SPJ+ Joysticks On/Off Button CMPJ+ Joystick On/Off Switch FIGURE 2 Turning the Power On/Off Part No 1149267 41 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 42
    stop smoothly. To drive the wheelchair, perform the following: 1. Adjust speed control knob to the appropriate setting. 2. Turn the power On. Refer to Turning the Power On/Off on page 41. 3. Maneuver the joystick in the following manner: Invacare® TDX® SC, Invacare TDX Spree 42 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 43
    information about the joystick installed on the wheelchair, refer to one of these procedures: • SPJ+, MK6i™ SPJ+ w/PSS and MK6i SPJ+ w/ACC Joystick Switches and Indicators on page 44. • CMPJ+ Joystick Switches and Indicators on page 47. Part No 1149267 43 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 44
    Service Indicator  *The mode button is only present on SPJ+ w/ACC joystick. Additional Input for Powered Seating Switch Charger/ Programming Input Active (If Programed) FIGURE 4 SPJ+, MK6i™ SPJ+ w/PSS and MK6i SPJ+ w/ACC Joystick Switches and Indicators Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 45
    drive speed to a pre-programmed value, typically when the seat has been elevated and the wheelchair is required to drive at 20% speed. Speed Control Buttons The speed control buttons (tortoise the speed in smaller increments. The smaller Part No 1149267 45 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 46
    of the wheelchair: 1. Power is wheelchair status. Service Indicator The AMBER service indicator will light when an error or fault occurs. Refer to Service Indicator Light Diagnostics on page 110 for a listing of the flash codes and what they indicate. Invacare® TDX® SC, Invacare TDX Spree 46 Part
  • Invacare TDXSCV | Owners Manual 2 - Page 47
     For this procedure, refer to FIGURE 5. 5 WHEELCHAIR OPERATION On/Off - Drive Select Toggle Switch The Part No 1149267 Programmable Mono Port 1/2 or External Mode Switch Remote On/ Off Input To Controller FIGURE 5 CMPJ+ Joystick Switches and Indicators 47 Invacare® TDX® SC, Invacare TDX
  • Invacare TDXSCV | Owners Manual 2 - Page 48
    is located in front of the joystick and provides information on the status of the wheelchair through a backlit display. The LCD display is readable in both bright sunlight and Main Screen. FIGURE 6 LCD Display Screens - Splash Screen Invacare® TDX® SC, Invacare TDX Spree 48 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 49
    Information Center. The Information Center displays current data on the wheelchair. Refer to LCD Display table on page 49 for power. This indicator is shown on every screen. This area displays status or instructions. Displays current time. Part No 1149267 49 Invacare® TDX® SC, Invacare TDX
  • Invacare TDXSCV | Owners Manual 2 - Page 50
    5 WHEELCHAIR OPERATION ITEM STATUS INDICATOR MODES DESCRIPTION The status indicator Powered Seating 4-Switch Level 1 (L1, L1 Latched) 4-Switch Level 2 (L2, L2 Latched) Drive Select to ECU Output Activated ASM 1 ASM 2 Infrared Mouse Mouse B Invacare® TDX® SC, Invacare TDX Spree 50 Part
  • Invacare TDXSCV | Owners Manual 2 - Page 51
    . Top, Highlighted Icon Indicates Selected Mode) Status/Info Message Area 5 WHEELCHAIR OPERATION Drive Profile Name Battery Gauge Display Status Indicator Clock FIGURE 7 LCD this screen. FIGURE 8 LCD Display Screens - Driving Screen Part No 1149267 51 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 52
    a service call. FAULT CODES - Displays time and date stamped fault codes. This information can be helpful to a provider prior to making a service call. CONNECTED DEVICES - Displays device connections. Refer to Connected Devices Screen on page 53. Invacare® TDX® SC, Invacare TDX Spree 52 Part No
  • Invacare TDXSCV | Owners Manual 2 - Page 53
    5 WHEELCHAIR OPERATION CG Tilt Shark Power Module (SPM) supports G-Trac Mouse Only IR/Mouse Digital Attendant Control Micro Extremity Control Peachtree Control ASL Digital Control FIGURE 9 LCD Display Screens - Connected Devices Screen Part No 1149267 53 Invacare® TDX® SC, Invacare TDX
  • Invacare TDXSCV | Owners Manual 2 - Page 54
    mono port 2. Remote Stop Switch The remote reset switch may be used to stop the wheelchair if the wheelchair is in motion. The remote reset switch also functions in the same way as the switch will alternately turn the joystick On or Off. Invacare® TDX® SC, Invacare TDX Spree 54 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 55
    wheelchair parameters. 5.5 When to Charge Batteries  Keep Batteries charged. When possible, DO NOT allow battery charge to empty. If battery charge becomes so low that no battery indicators are lit, allow the batteries to charge overnight. Part No 1149267 55 Invacare® TDX® SC, Invacare TDX
  • Invacare TDXSCV | Owners Manual 2 - Page 56
    . It also provides the following information to the user on the status of the wheelchair: A. GREEN LEDs are lit, indicating well charged batteries. B. AMBER LEDs are Gage Display Batteries Empty Batteries Full FIGURE 11 CMPJ+ Joystick Invacare® TDX® SC, Invacare TDX Spree 56 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 57
    the wheelchair will not be used for a long period of time. The range per battery charge using recommended batteries should be approximately 5 to 9 hours of typical operation. Extensive use on inclines may substantially reduce per charge mileage. Part No 1149267 57 Invacare® TDX® SC, Invacare TDX
  • Invacare TDXSCV | Owners Manual 2 - Page 58
    been connected to the wheelchair and wall outlet and, Refer to owner's manual shipped with instructions for each charger (supplied or purchased). If charging instructions are not supplied, consult a qualified service technician for proper procedures. Invacare® TDX® SC, Invacare TDX Spree 58 Part
  • Invacare TDXSCV | Owners Manual 2 - Page 59
    WHEELCHAIR OPERATION Required Items: TOOL QUANTITY COMMENTS Battery Charger 1 1. Attach the battery charger connector to the charger port on the joystick. 2. Plug the charger's AC power Back of Display) Part No 1149267 FIGURE 12 Charging Batteries 59 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 60
    wheelchair to disengage the motor. ENGAGE MOTOR (Drive) - Move Motor Lock Lever DOWN Motor Lock Lever Drive Wheel Rear Caster Outside of Wheelchair DISENGAGE MOTOR (Push) Move Motor Lock Lever UP FIGURE 13 Disengaging/Engaging Motor Lock Levers Invacare® TDX® SC, Invacare TDX Spree 60 Part
  • Invacare TDXSCV | Owners Manual 2 - Page 61
    DO NOT use the wheel locks when the wheelchair power is on and the clutches are engaged - otherwise damage to the wheelchair may result.  For this procedure, refer to Wheel Lock Handle FIGURE 14 Removing/Installing the Footboard Part No 1149267 61 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 62
    to disengage seat from pivot brackets located in the rear. Latch Bar  TDX SC with Transport Brackets (TRBKTS) shown. Rear Pivot Brackets Seat Clevis Pins Invacare® TDX® SC, Invacare TDX Spree FIGURE 15 62 Removing/Installing the Seat Assembly - Wheelchairs with Latch Bars Only Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 63
    with seat clevis pins. Tilting the Seat Assembly - Wheelchairs without Latch Bar Only ƽ WARNING Make sure power to the wheelchair is OFF before performing this procedure. Never leave the seat the batteries and the underside of the seat. Part No 1149267 63 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 64
    not servicing the wheelchair. Ensure the seat is locked in place before using. Mounting Screw DOWN/ CLOSED Position Seat Frame Plate Washer and Locknut Front Seat Post FIGURE 16 - Tilting the Seat Assembly - Wheelchairs without Latch Bar Only Invacare® TDX® SC, Invacare TDX Spree 64 Part
  • Invacare TDXSCV | Owners Manual 2 - Page 65
    , adjustment or service, verify that wheelchair. If the user's feet are allowed to rest off the side of the footboard they may come in contact with the caster possibly resulting in injury.  For this procedure, refer to FIGURE 17 on page 66. Part No 1149267 65 Invacare® TDX® SC, Invacare TDX
  • Invacare TDXSCV | Owners Manual 2 - Page 66
    footboard support. 2. Using the socket heat screw, three washers, spacer and locknut secure the footboard to the footboard support. Washer Spacer Footboard Support Washers Socket Head Screw Footboard Assembly Locknut FIGURE 17 Removing Invacare® TDX® SC, Invacare TDX Spree 66 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 67
    should be removed and secured separately. Postural supports, positioning devices, and/or strap(s) should NOT be relied on for occupant restraint. These items may be used IN ADDITION TO the wheelchair-anchored or vehicle-anchored belts. Part No 1149267 67 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 68
    users of wheelchairs should be transferred into appropriate seating in vehicles for transportation and use be made of the restraints made available by the auto industry. Invacare cannot and does not recommend any wheelchair transportation system. Invacare® TDX® SC, Invacare TDX Spree 68 Part No
  • Invacare TDXSCV | Owners Manual 2 - Page 69
    Engineering and Assistive Technology Society of North America. This wheelchair has been dynamically tested in a forward-facing mode TDX SC TDX Spree MOTOR 2 Pole HD 2 Pole HD WEIGHT LIMIT ADULT JUNIOR Up to 250 lbs N/A N/A Up to 165 lbs Part No 1149267 69 Invacare® TDX® SC, Invacare TDX
  • Invacare TDXSCV | Owners Manual 2 - Page 70
    the wheelchair-seated occupant's head ranges from approximately 47-inches for a small adult female to about 61-inches for a tall adult male . (Frontal Clear Zone) 16in. FCZ Side View 8in. 8in. HHT 16in. FCZ (Frontal Clear Zone) Top View Invacare® TDX® SC, Invacare TDX Spree 70 Part No
  • Invacare TDXSCV | Owners Manual 2 - Page 71
    been installed in accordance with the manufacturer's instructions and SAE J2249.  A copy of SAE J2249 Wheelchair Tie-down and Occupant Restraint Systems (WTORS) brackets in accordance with the manufacturer's instructions and SAE J2249. Part No 1149267 71 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 72
    wheelchair has been provided with a pelvic belt which meets the requirements of ANSI/RESNA WC/19. The pelvic belt provided by Invacare has been designed to accommodate use on either side of the vehicle. If necessary, follow the instructions Invacare® TDX® SC, Invacare TDX Spree 72 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 73
    secure the vehicle anchored upper-torso belt) Small End of Slot DETAIL "C" - SP JUNIOR SEATS ONLY Large End of Slot Belt Mounting Bracket Male End Part No 1149267 FIGURE 2 Wheelchair-Anchored Belts Small End of Slot 73 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 74
    • TDX SC Adult - 0.47 in (11.9 mm) • TDX Spree Junior - 0.53 in (13.0 mm) Point (P) Rear View Test Platform 45° NOTE: Rear view of wheelchair and human surrogate secured on test platform and tilted to 45 degrees. FIGURE 3 Vehicle-Anchored Belts Invacare® TDX® SC, Invacare TDX Spree 74 Part No
  • Invacare TDXSCV | Owners Manual 2 - Page 75
    secured to the wheelchair frame before operation. Refer to the seating system owner's manual. Positioning Belts if the pelvic belt is intended to be used for postural support in addition to occupant restraint in a frontal crash. Steeper 76. Part No 1149267 75 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 76
    The belt(s) should not be held away from the body by wheelchair components or parts, including but not limited to wheelchair armrests or wheels. Refer to FIGURE 4 for proper and improper of armrests, wheels, etc. FIGURE 4 Positioning Belts Invacare® TDX® SC, Invacare TDX Spree 76 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 77
    necessary, take your wheelchair to a qualified technician for a thorough inspection and servicing. Refer to Service Inspection on page 80.  Check all parts for shipping damage of powered functions (Example: drive, seating and legrests). Part No 1149267 77 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 78
    as necessary, take your wheelchair to a qualified technician for a thorough inspection and servicing. Service Inspection on page 80. and hardware.  Ensure proper operation of powered functions (Example: drive, seating and legrests). Invacare® TDX® SC, Invacare TDX Spree 78 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 79
    to frame is secure and undamaged. Replace if necessary. Inspect/Adjust Periodically  Ensure wheelchair rolls straight (no excessive drag or pull to one side).  Inspect all that all labels are present and legible. Replace if necessary. Part No 1149267 79 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 80
    the service inspection may vary according to the specific wheelchair: Six Month Inspection  Clean upholstery and armrests.  Clean dirt and lint from axles.  Clean dirt and lint from bearings.  Check that all labels are present and legible. Replace if necessary. Invacare® TDX® SC, Invacare TDX
  • Invacare TDXSCV | Owners Manual 2 - Page 81
    hardware that attaches strap to frame is secure and undamaged. Replace if necessary.  Ensure wheelchair rolls straight (no excessive drag or pull to one side).  Ensure that there is looseness.  Ensure wheel locks are easy to engage. Part No 1149267 81 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 82
    and damaged during normal operation of seating system.  Ensure proper operation of powered functions (drive, seating, legrests, ect...).  Inspect motor brushes and gearbox 2 Years  For optimum performance, replace gas-locking cylinders. Invacare® TDX® SC, Invacare TDX Spree 82 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 83
    from POSITIVE (+) red battery cable mounting screw. Unless otherwise indicated, make sure power to the wheelchair is OFF before performing these procedures.  If there is battery acid in a battery with a cracked or otherwise damaged case. Part No 1149267 83 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 84
    NOT USE THIS TYPE OF BATTERY Terminal Cross Hole NEGATIVE (-) Battery Terminal/Post POSITIVE (+) Battery Terminal/Post POSITIVE (+) Battery Terminal/ Post NEGATIVE (-) Battery Terminal/Post Invacare® TDX® SC, Invacare TDX Spree 84 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 85
    COMMENTS Not Supplied Not Supplied Removing/Installing the Batteries on TDX SC without Elevating Seat ƽ CAUTION Place the wheelchair in a well ventilated area where work can be battery out of the battery tray using the battery handles. Part No 1149267 85 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 86
    Lower the seat assembly to the down position. Refer to Removing/Installing the Seat Assembly - Wheelchairs with Latch Bars Only on page 62. 8. Connect joystick cable (not shown). Refer to Disconnecting/Connecting the Joysticks on page 104. Invacare® TDX® SC, Invacare TDX Spree 86 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 87
    Plug into Controller Rear of Wheelchair Battery Handle 7 SETUP/MAINTENANCE RED and BLACK Connectors Front Battery Wheelchair Base Frame Front of Wheelchair FIGURE 1 Removing/Installing the Batteries on TDX SC without Elevating Seat Part No 1149267 87 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 88
    from the wheelchair. 9. Using the battery handle, lift the front battery up and away from the wheelchair. 10. If replacing the batteries, remove the front and rear battery wiring harness. Refer to Disconnecting Battery Cables on page 95. Invacare® TDX® SC, Invacare TDX Spree 88 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 89
    joystick. Refer to Disconnecting/Connecting the Joysticks on page 104. 8. Verify the joystick On/Off switch is in the On position and lower the seat. Part No 1149267 89 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 90
    Controller Rear Battery RED and BLACK Battery Connectors Battery Handle Front Battery Wheelchair Base Frame Rear of Wheelchair Front of Wheelchair FIGURE 2 Installing/Removing the Batteries on TDX SC with Elevating Seat or TDX Spree Invacare® TDX® SC, Invacare TDX Spree 90 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 91
    from the wheelchair. 11. Using the battery handle, lift the front battery up and away from the wheelchair. 12. If replacing the batteries, remove the front and rear battery wiring harness. Refer to Disconnecting Battery Cables on page 95. Part No 1149267 91 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 92
    post. 6. Position the docking pin bracket onto the wheelchair base frame so that the four tabs set into the notches in both sides of the wheelchair base frame. 7. Apply loctite® 242 to the screws and flat washers. Torque to 75i-/lbs ± 20%. Invacare® TDX® SC, Invacare TDX Spree 92 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 93
    X .75 Socket Head Screws Docking Pin Bracket Tabs Flat Washers Elevating Seat Post Wheelchair Base Frame Wheelchair Base Frame Notch Right Docking Pin Mounting Bracket Part No 1149267 FIGURE 3 Installing/Removing the Batteries on TDX Spree with TRRO 93 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 94
    seat assembly not shown. Seat pan and socket screws not shown. TDX SC with elevating seat shown. TDX Spree seating removes the same. 2. Using four mounting bolts and page 104 FIGURE 4 Removing/Installing the Elevating Seat Assembly Invacare® TDX® SC, Invacare TDX Spree 94 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 95
    page 98. 1. Remove the batteries. Refer to Removing/Installing the Batteries From/Into the Wheelchair on page 85. 2. Cut the tie-wrap that secures the battery terminal cap in NEGATIVE (-) battery cable from NEGATIVE (-) battery terminal. Part No 1149267 95 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 96
    on battery type), otherwise damage to the battery cable may result when installing battery terminal caps.  For this procedure, refer to FIGURE 5 on page 98. Invacare® TDX® SC, Invacare TDX Spree 96 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 97
    the Batteries From/Into the Wheelchair on page 85.  New batteries MUST be fully charged before using, otherwise the life of the batteries will be reduced. 6. If necessary, charge the battery. Refer to Charging Batteries on page 57. Part No 1149267 97 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 98
    into controller  Battery terminal caps not shown on front battery for clarity. Handles on batteries removed for clarity. U1 Batteries FIGURE 5 Disconnecting/Connecting Battery Cables Invacare® TDX® SC, Invacare TDX Spree 98 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 99
    MAINTENANCE Cleaning Battery Terminals ƽ WARNING Most batteries are not sold with instructions. However, warnings are frequently noted on the cell caps. Read areas should be shiny, not dull. 4. Carefully dust off all metal particles. Part No 1149267 99 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 100
    wheelchair for maneuverability. 5. Readjust locknuts if necessary, and repeat STEPS 1-3 until correct. 6. Snap headtube cover into the caster headtube. 7. Reinstall retaining screws. Retaining Screw Headtube Cover Locknut Caster Headtube Fork FIGURE 6 Adjusting Forks Invacare® TDX® SC, Invacare
  • Invacare TDXSCV | Owners Manual 2 - Page 101
    tighten the jam nut and washer to secure the mounting screw in place. 7 SETUP/MAINTENANCE Set Screw Jam Nut Footboard FIGURE 7 Adjusting the Footboard Angle Part No 1149267 101 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 102
    the joystick mounting tube from the mounting bracket. 2. Remove the joystick from the wheelchair. 3. Remove the three hex screws that secure both halves of the mounting bracket Tube FIGURE 8 Repositioning Joystick - Adjustable ASBA Seats Invacare® TDX® SC, Invacare TDX Spree 102 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 103
    from the mounting bracket. 2. Remove the joystick mounting tube from the wheelchair. 3. Remove the three hex mounting screws, bushings and locknuts that secure Joystick not shown. Locknuts Part No 1149267 FIGURE 9 Repositioning Joystick - Van Seats 103 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 104
    the wheelchair in the other and align them. 2. Lightly push to engage the joystick connector and the controller connector. Light Grey Collar Joystick Connector Controller Connector FIGURE 10 Disconnecting/Connecting the Joysticks - SPJ+ Joysticks Invacare® TDX® SC, Invacare TDX Spree 104 Part
  • Invacare TDXSCV | Owners Manual 2 - Page 105
    -wraps. Top Connector Cap Network Connectors 7 SETUP/MAINTENANCE Latch Gasket Controller Cable Gasket Bottom Connector Cap Gasket FIGURE 11 Disconnecting/Connecting the Joysticks - CMPJ+ Joysticks Part No 1149267 105 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 106
    wheelchair fame. 5. Pulling up, remove the front half of the top shroud. Thumb Screws Front Half of Top Shroud Rear Half of Top Shroud Thumb Screws Wheelchair Frame Invacare® TDX® SC, Invacare TDX Spree FIGURE 12 Removing/Installing the Top Shroud - Wheelchairs without Elevating Seat 106 Part
  • Invacare TDXSCV | Owners Manual 2 - Page 107
    to the seating system owners manual. 2. Remove the four thumb screws securing the rear half of the top shroud to the wheelchair fame. 3. Pulling up Wheelchair Frame FIGURE 13 Removing/Installing the Top Shroud - Wheelchairs with Elevating Seat Part No 1149267 107 Invacare® TDX® SC, Invacare TDX
  • Invacare TDXSCV | Owners Manual 2 - Page 108
    in a particular pattern or the service indicator light will flash. The number or type of flashes indicates the nature of the error. If multiple errors are found, only the first error encountered by the control module will be displayed. Invacare® TDX® SC, Invacare TDX Spree 108 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 109
    DESCRIPTION DEFINITION All LEDs are off. Power is off. 8 TROUBLESHOOTING COMMENTS Part No 1149267 All LEDs are on. Power is on. Fewer than three slowly. Joystick has detected Out-ofNeutral-at-Power-Up mode. Release the joystick back to Neutral. 109 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 110
    is plugged into the controller. Contact Invacare/Dealer for service. Ensure brake lever is in the drive position before turning on the wheelchair. Ensure motor cable is plugged into the controller. Contact Invacare/Dealer for service. Invacare® TDX® SC, Invacare TDX Spree 110 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 111
    /Connecting Battery Cables on page 95. JOYSTICK TIMEOUT displays and the wheelchair does not drive. Joystick or input device is disconnected (Error code 32). Turn off power, reconnect the joystick of input device and turn power on. Part No 1149267 111 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 112
    power off and then back on. Replace the controller if necessary. Turn the wheelchair off and back on. Reconnect the device. This is normal behavior. Have batteries checked for shorted cell. Replace if necessary. Contact Dealer/Invacare for service. Invacare® TDX® SC, Invacare TDX Spree 112 Part
  • Invacare TDXSCV | Owners Manual 2 - Page 113
    page 95. Stop use of Wheelchair. Contact Dealer/Invacare for Service. Contact Dealer/Invacare for Service. Contact Dealer/Invacare for Service. Contact Dealer/Invacare to have controller reprogrammed. Contact Dealer/Invacare for Service. Part No 1149267 113 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 114
    first reading this manual. Read and understand this manual and any service information that accompanies a battery and charger before operating the wheelchair. Don't perform and chargers. Use ONLY a GEL charger for a GEL battery. Invacare® TDX® SC, Invacare TDX Spree 114 Part No 1149267
  • Invacare TDXSCV | Owners Manual 2 - Page 115
    Notes 8 TROUBLESHOOTING Part No 1149267 115 Invacare® TDX® SC, Invacare TDX Spree
  • Invacare TDXSCV | Owners Manual 2 - Page 116
    Part No 1149267 Rev F - 05/11 Invacare Corporation USA One Invacare Way Elyria, Ohio USA 44036-2125 800-333-6900 www.invacare.com Canada 570 Matheson Blvd E Unit 8 Mississauga Ontario L4Z 4G4 Canada 800-668-5324
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
  • 99
  • 100
  • 101
  • 102
  • 103
  • 104
  • 105
  • 106
  • 107
  • 108
  • 109
  • 110
  • 111
  • 112
  • 113
  • 114
  • 115
  • 116
User Manual
This manual MUST be given to the user of the product.
BEFORE using this product, read this manual and save for future reference.
EN
Invacare®
TDX® SC,
Invacare
TDX Spree
Power Wheelchair Base