Kenmore 32607 Owners Manual

Kenmore 32607 - 20 Gallon Tall Compact Electric Water Heater Manual

Get Kenmore 32607 - 20 Gallon Tall Compact Electric Water Heater PDF manuals and user guides View all Kenmore 32607 manuals
Add to My Manuals
Save this manual to your list of manuals

Kenmore 32607 manual content summary:

  • Kenmore 32607 | Owners Manual - Page 1
    * Troubleshooting . Parts List LISTED GAMA certification applies to all residential electric water heaters with capacities of 20 to 120 Gallons. Input rating of 12kW or less. manual and safety messages before installing, operating or servicing this water heater. Failure to follow instructions and
  • Kenmore 32607 | Owners Manual - Page 2
    appliance can cause low level exposure to some of the substances listed, including formaldehyde. harm. iMPORTANT DEFINITIONS Sears Service Center: The Sears Service of electric water heaters. The Sears Service Center also has a thorough understanding of this instruction manual, and is able to
  • Kenmore 32607 | Owners Manual - Page 3
    in location with drainage. o Fill tank with water before operation. - Be alert for thermal expansion. Refer to instruction manual for installation and service. I ) Explosion Hazard • Overheated water can cause water tank explosion. • Properly sized temperature and pressure relief valve must
  • Kenmore 32607 | Owners Manual - Page 4
    the local Sears Service Center or any Sears store. They will arrange for prompt, quality installation by Sears authorized contractors. Abbreviations Found in This Instruction Manual: ANSI -American National Standards Institute ASME - American Society of Mechanical Engineers GAMA - Gas Appliance
  • Kenmore 32607 | Owners Manual - Page 5
    HEATEREQUIREASBILITYEQUIVALETNOTTHATOF A LICENSETDRADESMAINNTHEFIELDINVOLVED. PLUMBINAGNDELECTRICWALORKAREREQUIRED. an earthquakeS.eeinstructionfsor correctinstallation procedureIsn.structionmsaybeobtainefdromCalifornia OfficeoftheStateArchitec4t,00PStreetS, acramento, E"
  • Kenmore 32607 | Owners Manual - Page 6
    Materials Needed To simplify the installation Sears has available the installation parts shown below. You may or EXPANSION CONDITIONS AVAILABLE IN 2 GALLONS , AND 5 GALLONS CAPACITY THROUGH LOCAL SEARS STORE OR SERVICE CENTER, DRAIN PANS AVAILABLE IN 20" DIAMETER FOR WATER HEATERS HAVING A
  • Kenmore 32607 | Owners Manual - Page 7
    Removing the Old Water Heater _j/j ® _ ® FIGURE 1. Q Turn "OFF" electrical supply to the water heater. * Burn hazard , Hot water discharge. - Keep hands clear of drain valve discharge. The water passing out of the drain valve may be extremely hot. To avoid being scalded, make sure all
  • Kenmore 32607 | Owners Manual - Page 8
    the most economical use of the appliance. This water heater is not intended Drain pans are available at your local Sears stores. Such drain pans must be provide adequate clearances for servicing and proper operation of . • Do not cover the instruction manual. Keep it on the side of the water
  • Kenmore 32607 | Owners Manual - Page 9
    . Read instruction manual for safe temperature setting. HOTTER WATER CAN SCALD: Water heaters are intended to produce hot water. Water heated to a temperature which will satisfy clothes washing, dish washing Contact the local utility or Sears Service Center on how to control
  • Kenmore 32607 | Owners Manual - Page 10
    compact models have optional plumbing connections. On these units, if top connection is preferred over the side connection, use the following instructions as they apply to your connection: PiPE INSULATION FIGURE 9A. NOTE: Figure above is used to illustrate installation of T&P and pipe
  • Kenmore 32607 | Owners Manual - Page 11
    or mentally disabled are at highest riskfor scald injury. Feel water before bathing or showering. Temperature limiting valves are available. Read instruction manual for safe temperature setting. To fill the water heater with water: Close the water heater drain valve by turning the handle to
  • Kenmore 32607 | Owners Manual - Page 12
    wiring to this water heater, obtain the service of a competent electrician. Contact your Sears salesperson to arrange for a professional electrician. the model rating plate. Failure to use the correct voltage can cause problems which can result in DEATH, SERIOUS BODILY INJURY, OR PROPERTY DAMAGE. If
  • Kenmore 32607 | Owners Manual - Page 13
    or showering. Temperature limiting valves are available. Read instruction manual for safe temperature setting. HOTTER WATER CAN SCALD: dishwasher manufacturers. Thermostat Adjustment (Refer to thermostat illustrations under "Thermostat" section) I ® Before removing any access panels or servicing
  • Kenmore 32607 | Owners Manual - Page 14
    line, and (2) the water manually discharged will not cause any property water heater, follow the draining instructions, and replace the temperature- relief valve on the appliance weeps or discharges periodically check valve. Consult your local Sears Service Center for further information. Do
  • Kenmore 32607 | Owners Manual - Page 15
    to unclip the terminal cover from the thermostat. The terminal cover can now be removed from the thermostat. I = Before removing any access panels or servicing the water heater, make sure the electrical supply to the water heater is turned "OFF". • Failure to do this could result in death, serious
  • Kenmore 32607 | Owners Manual - Page 16
    plate affixed to the water heater. 10. A new gasket should be used in all cases to prevent a possible water leak. (See Element Gasket in the "Parts Order List " Chart). Place the new element gasket on the thread side of the cleaned or new element and screw into tank, securing tightly using
  • Kenmore 32607 | Owners Manual - Page 17
    the Sears Service Center for an authorized contractor. At a minimum, the anode(s) should be checked annually after the warranty period. Service Before calling for repair service, read the "Start Up Conditions" and "Operational Conditions" section of this manual. found in the Troubleshooting
  • Kenmore 32607 | Owners Manual - Page 18
    , etc...to control these types of problems. When these devices are not equipped with Sears stores and through the Sears Service Centers. Contact the local plumbing inspector, water supplier and/or the Sears Service is installed one anode rod (see parts section) for corrosion protection of the
  • Kenmore 32607 | Owners Manual - Page 19
    appliances which are connected to the hot water system are used (such as a dishwasher or washing machine). button located on the thermostat. Follow the resetting instructions behind the access panel. which refer to the call Sears Service Department to find out why high limit turned "OFF"
  • Kenmore 32607 | Owners Manual - Page 20
    problem may be due to the high temperature shut off system. See "High Temperature Shut Off System" in the "Troubleshooting" section. 8. During very cold weather leaks. 10. If you can not determine the problem, then call the Sears Service Department. WATER IS TOO HOT Adjust the thermostat
  • Kenmore 32607 | Owners Manual - Page 21
    Sears Service Center to check the water heater. manual and safety messages before installing, operating or servicing this water heater. Failure to follow instructions ON" power. A. *Condensation may be seen on pipes in humid weather or pipe connections may be leaking. B. Small amounts of water from
  • Kenmore 32607 | Owners Manual - Page 22
    Valve 3. Drain Valve Washer 17/32"xl 3/64"xl/8 Tk 4. Element 5. Element Gasket 6. Inlet Nipple - 2-1/2" 7. Junction Box Cover 8. Manual # 9. Model Rating Plate heater, should a need ever exist for repair parts or service, simply contact any Sears Service Center or call 1-800-4-MY-HOME (1-800-469
  • Kenmore 32607 | Owners Manual - Page 23
    Part Description 1 Access Panel 2 Anode Rod 3 Drain Valve 4 Drain Valve Washer !17/32" x 13/64" x 118" Thick)** 5 Element 6 Element Gasket 7 Element Insulation Cap 8 Inlet Water Nipple 9 Junction Box Cover 10 Manual repair parts or service, simply contact any Sears Service Center
  • Kenmore 32607 | Owners Manual - Page 24
    owner's manual instructions and all local applicable plumbing codes, Sears will KENMORE LABOR WARRANTY For the first year from the date of purchase, Sears will, free of charge, supply and install new water heater parts SEARS INSTALLATION SERVICE For Sears professional Installation of home appliances
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
Owner's
ManuaJ
®
THE
ECONOMIZERrM
COMPACT
ELECTRIC
WATER
HEATER
FOR POTABLE
WATER HEATING
ONLY.
NOT SUITABLE
FOR SPACE
HEATING.
6
MODEL
NO.
153.316040
153.316050
153.316060
153.316070
153.316331
153.326060
153.326070
153.326331
6
GALLON
10 GALLON
19 GALLON
SHORT
19.9
GALLON
TALL
30
GALLON
19 GALLON
240
V. SHORT
19.9
GALLON
240
V, TALL
30
GALLON
240
V,
LISTED
*
Safety
instructions
* installation
*
Operation
* Care
and
Maintenance
* Troubleshooting
. Parts
List
GAMA
certification
applies
to all residential
electric
water
heaters
with
capacities
of
20
to
120
Gallons.
Input
rating
of
12kW
or
less.
manual and safety messages
before installing, operating or
servicing this water heater.
Failure to follow instructions
and
safety messages could result in
death or serious
injury.
Instruction
manual must remain
with water heater.
SAVE
THIS
MANUAL
FOR FUTURE
REFERENCE.
Sears,
Roebuck
and
Co.,
Hoffman
Estates,
IL
60179
U.S.A
PRINTED
0607
www.seats.com
PART NO. 185775-000