Lenovo P500 Laptop Hardware Maintenance Manual

Lenovo P500 Laptop Manual

Get Lenovo P500 Laptop PDF manuals and user guides View all Lenovo P500 Laptop manuals
Add to My Manuals
Save this manual to your list of manuals

Lenovo P500 Laptop manual content summary:

  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 1
    Lenovo Z/P Series Hardware Maintenance Manual
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 2
    information and the product it supports, be sure to read the general information under "Notices" on page 116. ••This manual applies to the following models: Lenovo Z400/Z500/Z400 Touch/ Z500 Touch/P400 Touch/ P500. The illustrations used in this manual are for Lenovo Z500 unless otherwise stated
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 3
    ) mode 25 Lenovo Z/P Series 26 Specifications 26 Status indicators 28 Function key combinations 30 FRU replacement notices 31 Screw notices 31 Removing and replacing an FRU 32 1010 Keyboard 33 1020 Optical drive 36 1030 Base cover 39 1040 Battery pack 44 1050 Hard disk drive 46 1060 PCI
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 4
    required for servicing computers. •• The product-specific section includes service, reference, and product-specific parts information. Important: This manual is intended only for trained servicers who are familiar with Lenovo products. Use this manual to troubleshoot problems effectively. Before
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 5
    the following safety information that you need to get familiar with before you service an Lenovo Z/P Series computer: •• "General safety" on page 2 •• "Electrical safety" on page 3 •• "Safety inspection guide" on page 5 •• "Handling devices that are sensitive to electrostatic discharge" on page
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 6
    Wear safety glasses when you are hammering, drilling, soldering, cutting wire, attaching springs, using solvents, or working in any other conditions that may be hazardous to your eyes. •• After service, reinstall all safety shields, guards, labels, and ground wires. Replace any safety device that is
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 7
    to insulate you from grounds such as metal floor strips and machine frames. Observe the special safety precautions when you work with very high voltages; instructions for these precautions are in the safety sections of maintenance information. Be extremely careful when you measure the high voltages
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 8
    Manual •• Always look carefully for possible hazards in your work area. Examples of these hazards are moist floors, nongrounded power extension cables, power surges, and missing safety grounds. •• Do not touch such touching can cause personal injury and machine damage. •• Do not service the
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 9
    users and service personnel from injury. This guide loose, broken, or sharp edges). 2. Turn off the computer. Disconnect the power cord. 3. Check the power cord batteries. 5. Remove the cover. 6. Check for any obvious non-Lenovo alterations. Use good judgment as to the safety of any non-Lenovo
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 10
    eliminate static on your body. •• Prevent the part from touching your clothing. Most clothing is insulative and retains a charge even when you are wearing a wrist strap. •• Use the black side of a grounded work mat to provide a static-free work surface. The mat is especially useful when handling ESD
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 11
    translations The safety notices in this section are provided in English, French, German, Hebrew, Italian, Japanese, and Spanish. Safety notice 1 Before the computer is powered on after FRU replacement, make sure all screws, springs, and other small parts are in place and are not left loose inside
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 12
    Z/P Series Hardware Maintenance Manual Safety notice 2 DANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it into fire or water, or shortcircuit it. Dispose of the battery as required by local ordinances or regulations
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 13
    , veillez à n'utiliser que les modèles cités dans la liste de pièces détachées adéquate. En effet, une batterie inappropriée risque de prendre feu ou d'exploser. Akkus enthalten geringe Mengen von Nickel. Sie dürfen nicht zerlegt, wiederaufgeladen, kurzgeschlossen, oder Feuer oder Wasser ausgesetzt
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 14
    Hardware Maintenance Manual Safety notice 4 DANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of the battery as
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 15
    Entsorgung die örtlichen Bestimmungen für Sondermüll beachten. Der LCD-Bildschirm besteht aus Glas und kann zerbrechen, wenn er unsachgemäß behandelt wird oder der Computer auf den Boden fällt. Wenn der Bildschirm beschädigt ist und die darin befindliche Flüssigkeit in Kontakt mit Haut und Augen ger
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 16
    Z/P Series Hardware Maintenance Manual Safety notice 6 DANGER To avoid shock, do not remove the plastic abgeben, um brennbare Materialien zu entzünden oder Verletzungen bei Personen hervorzurufen. Sebbene le batterie di alimentazione siano a basso voltaggio, una batteria in corto circuito o a massa
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 17
    Safety information Safety notice 8 DANGER Before removing any FRU, turn off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables. Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, dé
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 18
    Z/P Series Hardware Maintenance Manual Laser compliance statement Some models of Lenovo computer are equipped from the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 19
    Safety information A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: DANGER Emits visible and invisible
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 20
    FRUs listed in this manual. After a system board is replaced, ensure that the latest BIOS is loaded to the system board before completing the service action. To download software fixes, drivers, and BIOS, follow the steps below: 1. Go to http://consumersupport.lenovo.com/. 2. Enter a serial number
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 21
    the following strategy to prevent unnecessary expense for replacing and servicing FRUs: •• If you are instructed to replace an FRU, but the replacement does not solve the problem, reinstall the original FRU before you continue. •• Some computers have both a processor board and a system board. If you
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 22
    Z/P Series Hardware Maintenance Manual Important information about replacing RoHS compliant FRUs RoHS, and function are identified with unique FRU part numbers. Lenovo plans to transit to RoHS compliance well before the implementation date and expects its suppliers to be ready to support Lenovo's
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 23
    or formatting. Drives in the computer that you are servicing sequence might have been altered. If you select an incorrect drive, data or electrostatic discharge, or software errors. Consider replacing an FRU only when a problem recurs. If you suspect that an FRU is defective, clear the error logs
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 24
    keys caused by spilling a liquid onto the keyboard •• Use of an incorrect AC adapter on laptop products The following symptoms might indicate damage caused by nonwarranted activities: •• Missing parts might be a symptom of unauthorized service or modification. •• If the spindle of a hard disk drive
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 25
    board. •• If the problem continues, go to "Lenovo Z/P Series" on page 26. Note: Noise from the AC adapter does not always indicate a defect. Checking operational charging To check whether the battery charges properly during operation, use a discharged battery pack or a battery pack that has less
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 26
    Maintenance Manual Perform operational charging. If the battery status indicator or icon does not light on, remove the battery pack and let it return to room temperature. Reinstall the battery pack. If the charge indicator or icon is still off, replace the battery pack. If the charge indicator
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 27
    , the hard disk in a Lenovo computer includes a hidden partition when it is shipped. If you need to restore the system to the point of your first boot up, just enter Lenovo OneKey Recovery System and run System Recovery. For details of OneKey Recovery System, see the User Guide for Lenovo OneKey
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 28
    Manual When you use the recovery discs to boot your computer, the system will enter the user Lenovo computer: the power-on password (POP) and the supervisor password (SVP). If any of these passwords has been set, a prompt for it appears on the screen whenever the computer is turned on. The computer
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 29
    been set on the timer, and the user does not do any operation with the keyboard, the hard disk, the parallel connector, or the diskette drive within that time. •• If the battery indicator is amber, indicating that the battery power is low. To cause the computer to return from sleep (standby) mode
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 30
    table lists the specifications of the Lenovo Z/P Series : Table 1. Specifications Feature Processor Core Chipset Bus architecture Graphic memory chip Display Standard memory CMOS RAM Hard disk drive Optical drive Description • Intel Chief River platform • Intel Panther Point HM76/70 • FDI 2.7GT
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 31
    port × 1 • 2 in 1 slot × 1 (SD/MMC) • 1/8" Combo audio jack • 2 × 2W speakers • 1 × Internal digital Microphone • 10/100M • 100/1000M(option) • 2 slot • Combo w/ Wifi, BT 4.0 option • 6 Row, ISO Full Size Keyboard • Multi-touch type • 720P HD or 0.3 Mega • 4 cell, 41.6 Wh or 48 Wh • 20 V, 65 W or 90
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 32
    Z/P Series Hardware Maintenance Manual Status indicators The system status indicators below show the computer status: Z400 1 2 28
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 33
    to the AC power adapter. The computer is powered off. The battery has more than 80% charge. The battery has more than 20% charge. The battery has between 5% and 20% charge. The battery has between 20% and 80% charge. When the battery reaches 80% charge, the light will stop blinking. However
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 34
    active window. : Enables/disables the touchpad. : Enables/disables Airplane mode. : Displays all currently active apps. : Turns on/off the backlight of the LCD screen. : Toggles the display between the computer and an external device. : Decreases display brightness. : Increases
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 35
    Loose screws can cause a reliability problem. In the Lenovo computer, this problem is addressed with special nylon-coated Turn an additional 180° after the screw head touches the surface of the logic card: more than 180° (Cross-section) •• Torque driver If you have a torque screwdriver , refer to
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 36
    Z/P Series Hardware Maintenance Manual Removing and replacing an FRU This section presents exploded figures with the instructions to indicate how to remove and replace the FRU. Make sure to observe the following general rules: 1. Do not attempt to service any computer unless you have been trained
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 37
    Lenovo Z/P Series 1010 Keyboard Figure 1. Removal steps of keyboard Remove the two screws 1. Z400 1 1 Z500/P500 1 1 Step Screw (quantity) 1 M2 × 12 mm, flat-head, nylok-coated (2) (Z400) 1 M2 × 12 mm, flat-head, nylok-coated (2) (Z500/ P500) Color Black Black Torque 1.85+/-0.15 kgf*cm 3.62
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 38
    Z/P Series Hardware Maintenance Manual Figure 1. Removal steps of keyboard (continued) Insert the screwdriver into one of the screw hole on the bottom 2. Then pull the keyboard out of the keyboard bezel 3. Z400 2 3 Z500/P500 2 3 34
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 39
    Lenovo Z/P Series Figure 1. Removal steps of keyboard (continued) Lift the keyboard a little, and then detach the connectors in the direction shown by arrows 4 5. Remove the keyboard in the direction shown by arrow 6. Z400 4 6 5 Z500/P500 4 5 6 4 5 When installing: Make sure that the FPC
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 40
    Z/P Series Hardware Maintenance Manual 1020 Optical drive For access, remove this FRU: •• "1010 Keyboard" on page 33 Figure 2. Removal steps of optical drive Remove the screw 1. Z400 1 36
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 41
    Lenovo Z/P Series Figure 2. Removal steps of Optical drive (continued) Z500/P500 1 Step 1 1 Screw (quantity) Color M2.5 × 6 mm, flat-head, nylok-coated (1) (Z400) Black M2.5 × 6 mm, flat-head, nylok-coated (1) (Z500/ Black P500) Torque 3.0+/-0.3 kgf*cm 8.03 kg-cm 37
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 42
    Z/P Series Hardware Maintenance Manual Figure 2. Removal steps of Optical drive (continued) Insert a screwdriver into the screw hole and push the optical drive in the direction shown by arrow 2 . Pull the optical drive out in the direction shown by arrow 3. Z400 2 3 Z500/P500 2 3 38
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 43
    Base cover For access, remove this FRU: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 Figure 3. Removal steps of base cover Z400 Remove the four screws 1. 1 1 1 Lenovo Z/P Series Step 1 Screw (quantity) M2.5 × 6 mm, flat-head, nylok-coated (4) Color Torque Black 3.0+/-0.3 kgf
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 44
    Z/P Series Hardware Maintenance Manual Figure 3. Removal steps of base cover (continued) Remove the two rubber feet 2. Remove a total of eight screws (two 3, three 4 and three 5) from the bottom. 2 3 4 5 4 4 2 3 Step
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 45
    Lenovo Z/P Series Figure 3. Removal steps of base cover (continued) Z500/P500 Remove the five screws 1. 1 1 1 1 Step 1 Screw (quantity) M2.5 × 6 mm, flat-head, nylok-coated (5) Color Black Torque 8.03 kg-cm 41
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 46
    Z/P Series Hardware Maintenance Manual Figure 3. Removal steps of base cover (continued) Open the four rubber feet 2. Remove a total of ten screws (four 3, three 4 and three 5) from the bottom. 3 4 5 3 4 2 3 3 2 2 2 Step 3 4 5
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 47
    Lenovo Z/P Series Note: Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds. the label kit and apply them to the new base cover. For the location of each label, refer to the following figure: d e f a g h b i j c TM Windows®8 43
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 48
    Series Hardware Maintenance Manual 1040 Battery pack For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 DANGER Only use the battery specified in the parts list for your computer. Any other battery could ignite or
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 49
    Lenovo Z/P Series Figure 4. Removal steps of battery pack (continued) Remove the battery pack in the direction shown by arrow 3. Z400 3 Z500/P500 3 When installing: Make sure the battery pack connector is attached firmly. 45
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 50
    Manual 1050 Hard disk drive For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 •• "1040 Battery pack" on page 44 Attention: • Do not drop the hard disk drive or apply any physical shock to it. The hard disk drive
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 51
    Lenovo Z/P Series Figure 5. Removal steps of hard disk drive (continued) Detach the HDD connector in the direction shown by arrow 2. Remove the hard disk drive from the slot in the direction shown by arrow 3. Z400 3 2 Z500/P500 3 2 When installing: Make sure that the HDD connector is attached
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 52
    Manual 1060 PCI Express Mini Card for wireless LAN For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 •• "1040 Battery M2 × 3 mm, flat-head, nylok-coated (1) (Z400) Black 2 M2 × 2.5 mm, flat-head, nylok-coated (1) (
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 53
    Lenovo Z/P Series Figure 6. Removal steps of PCI Express Mini Card for wireless LAN (continued) Remove the card in the direction shown by arrow 3. Z400 3 Z500/P500 3 When installing: •• In models with a wireless LAN card that has two antenna connectors, plug the black cable (1st) (MAIN) into the
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 54
    Z/P Series Hardware Maintenance Manual 1070 DIMM For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 •• "1040 Battery pack" on page 44 Figure 7. Removal steps of DIMM Release the two latches on both edges of the
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 55
    Lenovo Z/P Series Figure 7. Removal steps of DIMM (continued) Z500/P500 1 1 2 When installing: Insert the notched end of the DIMM into the socket. Push the DIMM firmly, and pivot it until it snaps into the place. Make sure that it is firmly fixed in the slot and difficult to be moved. 51
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 56
    Z/P Series Hardware Maintenance Manual 1080 Fan assembly and Heat Sink assembly For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 •• "1040 Battery pack" on page 44 Figure 8. Removal steps of fan assembly and
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 57
    Lenovo Z/P Series Figure 8. Removal steps of fan assembly and heat sink assembly (continued) Z500/P500 3 3 2 2 4 1 Step 2 3 4 Screw (quantity) M2 × 3.2, flat-head, nylok-coated (3) M2 × 2.5, flat-head,
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 58
    Z/P Series Hardware Maintenance Manual Figure 8. Removal steps of fan assembly and heat sink assembly (continued) Lift the fan assembly and heat sink assembly in the direction shown by arrow 5. Be careful not to damage the connector. Z400 5 Z500/P500 5 Attention: Do not handle the heat sink assembly
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 59
    assembly (continued) Z400 Z500/P500 a b a b When installing: Before you attach the fan assembly to the computer, apply thermal grease, at an amount of 0.2 grams, to the a b part shown in the figure above. Either too much or too less grease application can cause a thermal problem due to imperfect
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 60
    Base cover" on page 39 •• "1040 Battery pack" on page 44 •• "1050 Hard disk drive" on page 46 •• "1060 PCI Express Mini Card for wireless LAN" on page 48 •• "1080 Fan assembly and Heat Sink assembly" on page 52 Attention: CPU is extremely sensitive. When you service the CPU, avoid any kind of rough
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 61
    Figure 9. Removal steps of CPU (continued) Z500/P500 Lenovo Z/P Series 1 a b 2 When installing: Place the CPU on the CPU socket in the direction shown by arrow a , and then rotate the head of the screw in the direction shown by arrow b to secure the CPU. 57
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 62
    page 36 •• "1030 Base cover" on page 39 •• "1040 Battery pack" on page 44 •• "1050 Hard disk drive" on page 46 •• "1060 PCI Express Mini Card for wireless LAN" on page 48 •• "1080 Fan assembly and Heat Sink assembly" on page 52 Figure 10. Removal steps of ODD board and LED board Detach the
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 63
    Lenovo Z/P Series Figure 10. Removal steps of ODD board and LED board (continued) Remove the two boards in the direction shown by arrows 5. 5 5 When installing: Make sure that the two FPC connectors are attached firmly. 59
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 64
    Manual 1110 Speakers For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 •• "1040 Battery pack" on page 44 •• "1050 Hard disk drive the direction shown by arrow 1. Remove the four screws 2. Z400 2 2 2 2 1 60
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 65
    Lenovo Z/P Series Figure 11. Removal steps of speakers (continued) Z500/P500 2 2 2 1 Step 2 Screw (quantity) M2 × 5.7, flat-head, nylok-coated (4) Color Black Torque 8.03 kg-cm 61
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 66
    Z/P Series Hardware Maintenance Manual Figure 11. Removal steps of speakers (continued) Remove the speakers 3. Z400 3 3 Z500/P500 3 3 When installing: Make sure that the speakers connector is attached firmly. 62
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 67
    material. For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 •• "1040 Battery pack" on page 44 •• "1050 Hard disk drive" on page 46 •• "1060 PCI Express Mini Card for wireless LAN" on page 48 •• "1080 Fan
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 68
    Z/P Series Hardware Maintenance Manual Figure 12. Removal steps of system board (continued) Z500/P500 1 2 1 2 Detach the power connector and LCD connector in the direction shown by arrows 3. Remove a total of six screws (four 4, one 5 and one 6) from the bottom. Z400 3 4 4 5 3 6 64
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 69
    Lenovo Z/P Series Figure 12. Removal steps of system board (continued) Z500/P500 3 4 5 3 6 When installing: Make sure that the power connector is attached firmly. Step 4 4 5 5 6 6 Screw (quantity) Color M2.5 × 3 mm, flat-head, nylok-coated (4) Black (Z400) M2.5 × 3 mm, flat-head, nylok-
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 70
    Z/P Series Hardware Maintenance Manual Figure 12. Removal steps of system board (continued) Remove the RJ-45 door in the direction shown by arrow 7. Remove the system board in the direction shown by arrow 8. Z400 8 7 Z500/P500 8 7 66
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 71
    Lenovo Z/P Series 1130 Keyboard bezel For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 •• "1040 Battery pack" on page 44 •• "1050 Hard disk drive 13. Removal steps of keyboard bezel Z400 Remove the two screws 1. 1
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 72
    Z/P Series Hardware Maintenance Manual Figure 13. Removal steps of keyboard bezel (continued) Z500/P500 Remove a total of three screws (two 1 and one 2) . 1 2 Step 1 2 Screw (quantity) M2.5 × 3 mm, flat-head,
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 73
    Lenovo Z/P Series 1140 LCD unit For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 •• "1040 Battery pack" on page 44 •• "1050 Hard disk drive" on page 46 •• "1060 PCI Express Mini Card for wireless LAN" on page 48
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 74
    Z/P Series Hardware Maintenance Manual Figure 14. Removal steps of LCD unit Z500/P500 Remove the five screws 1. 1 1 Step 1 1' Screw (quantity) M2.5 × 6 mm, flat-head, nylok-coated (5) M2 × 2 mm, flat-head, nylok-coated (1) (Z400) Color Torque Black 8.03 kg-cm Black 1.85+/-0.15 kgf*cm 70
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 75
    Lenovo Z/P Series Figure 14. Removal steps of LCD unit (continued) Release the LCD cable from the cable guides in the direction shown by arrows 2. Then lift the LCD hinge in the direction shown by arrow 3. Z400 3 2 2 2 3 Z500/P500 3 2 2 2 3 When installing: •• Route the antenna cables
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 76
    Z/P Series Hardware Maintenance Manual Figure 14. Removal steps of LCD unit (continued) Remove the keyboard bezel from the LCD unit in the direction shown by arrows 4. Z400 4 Z500/P500 4 72
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 77
    Lenovo Z/P Series 1150 LCD front bezel For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 •• "1040 Battery pack" on page 44 •• "1050 Hard disk drive bezel in the direction shown by arrows 1. Z400 1 1 1 1 73
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 78
    Z/P Series Hardware Maintenance Manual Figure 15. Removal steps of LCD front bezel Z500/P500 1 1 1 1 74
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 79
    Lenovo Z/P Series 1160 LCD panel and hinges For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 •• "1040 Battery pack" on page 44 •• "1050 Hard disk drive and hinges Remove the four screws 1. Z400 1 1 1 1 75
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 80
    Z/P Series Hardware Maintenance Manual Figure 16. Removal steps of LCD panel and hinges Z500/P500 1 1 1 1 Step 1 1 Screw (quantity) M2 × 3 mm, flat-head, nylok-coated (4) (Z400) M2 × 2.5 mm, flat-head, nylok-coated (4) (Z500/P500) Color Black Black Torque 1.85+/-0.15 kgf*cm 3.62 kg-cm Lift the
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 81
    Lenovo Z/P Series Figure 16. Removal steps of LCD panel and hinges (continued) Z500/P500 2 3 When installing: Make sure that the metal connector is attached firmly. Remove the LCD panel 4. Z400 4 77
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 82
    Z/P Series Hardware Maintenance Manual Figure 16. Removal steps of LCD panel and hinges (continued) Z500/P500 4 Z400 Remove a total of eight screws (two 5 and six 6). Then release the two hinges in the direction shown by arrows 7. 7 6 5 6 5 7 78
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 83
    Lenovo Z/P Series Figure 16. Removal steps of LCD panel and hinges ( (quantity) Color 5 M2 × 2.5 mm, flat-head, nylok-coated (2) Black 6 M2 × 3 mm, flat-head, nylok-coated (6) (Z400) Black 6 M2 × 3 mm, flat-head, nylok-coated (8) Black (Z500/P500) Torque 3.62 kg-cm 1.85+/-0.15 kgf*cm 8.03
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 84
    Manual 1170 Integrated camera, LCD cable and antenna assembly For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 •• "1040 Battery pack" on page 44 •• "1050 Hard disk drive in the direction shown by arow 1. Z400 1 80
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 85
    Lenovo Z/P Series Figure 17. Removal steps of integrated camera, LCD cable and antenna assembly (continued) Z500/P500 1 When installing: Stick the integrated camera ajust the placement of it to make sure the connector is attached firmly. Remove the camera in the direction shown by arrow 2. Z400 2 81
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 86
    Z/P Series Hardware Maintenance Manual Figure 17. Removal steps of integrated camera, LCD cable and antenna assembly (continued) Z500/P500 2 Remove the LCD cable and antenna assembly in the direction shown by arrow 3. Z400 3 3 3 82
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 87
    Lenovo Z/P Series Figure 17. Removal steps of integrated camera, LCD cable and antenna assembly (continued) Z500/P500 3 3 83
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 88
    Z/P Series Hardware Maintenance Manual 1180 Power board (Z400) For access, remove these FRUs in order: •• "1010 Keyboard" on page 33 •• "1020 Optical drive" on page 36 •• "1030 Base cover" on page 39 •• "1040 Battery pack" on page 44 •• "1050 Hard disk drive" on page 46 •• "1060 PCI Express Mini
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 89
    -in microphone 3 Wireless LAN antennas 4 Computer display 5 Power button 6 Touchpad 7 System status indicators Note: For the description of each indicator, see "Status indicators" on page 28. 8 Combo audio jack 9 USB port J Optical drive K Kensington slot Z400 2 3 1 3 4 5 6 7 9 8 11 10 85
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 90
    Z/P Series Hardware Maintenance Manual Z500/P500 4 2 3 1 3 5 6 7 9 8 11 10 86
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 91
    Bottom and Left-side view 1 Speakers 2 Memory card slot 3 USB port 4 HDMI port 5 RJ-45 port 6 VGA port 7 Fan louvers 8 Novo button 9 AC power adapter jack Z400 1 Z500/P500 1 1 Lenovo Z/P Series 9 8 7 6 5 4 3 2 9 8 7 6 5 4 3 2 87
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 92
    Z/P Series Hardware Maintenance Manual Parts list This section presents the following service parts: •• "Overall" on page 89 •• "LCD FRUs" on page 97 •• "Keyboard" on page 102 •• "Miscellaneous parts" on page 111 •• "AC adapters" on page 112 •• "Power
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 93
    Overall Z400 1 19 f 5 e 7 9 10 12 14 17 Lenovo Z/P Series 2 3 a 8 4 b 6 13 16 c 18 d 89
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 94
    Z/P Series Hardware Maintenance Manual Z500/P500 1 f 5 7 9 10 12 14 e 17 90 2 3 4 a 8 6 b 11 13 15 16 c 18 d
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 95
    1 Touch module for Z400 Touch, GZE LEG-04M-1D 73044074 GFF Na SY Z400 TSP 1 Touch module for Z400 Touch, OFO MCF-140-0650 73044075 N GFF Na SY Z400 TSP 2 Keyboard (see "Keyboard" on page 102.) 3 VIWP1 Upper Case 90202307 4 Battery, 4S1P, 4cell, 48Wh, sanyo, Z400Z500 SY 121500113 L12S4K01 14
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 96
    Maintenance Manual Table 5. Parts list-Overall (continued) No. FRU FRU no. CRU ID. 6 Platform, Chief River platform 35w, Intel I5-3360M 102500297 2.8G L1 3M 2cPGA 6 Platform, Chief River platform 35w, Intel I5-3320M 102500299 2.6G L1 3M 2cPGA 6 Platform, Chief River platform 35w, Intel I5
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 97
    Lenovo Z/P Series No. FRU FRU no. CRU ID. 12 RAM, Nanya, NT4GC64B8HG0NS-DI DDR3 1600 11201042 4GB 12 RAM, Samsung, M471B1G73BH0-CK0 DDR3 1600 11200342 8GB 12 RAM, Hynix, HMT41GS6MFR8C-PB DDR3 1600 11200345 8GB 13 VIWP1 USB Board W/Cable 90002114 14 WLAN, Intel 2230 BGN+BT M PCIE HMC
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 98
    4cPGA processor 6 Platform, Chief River platform 35w, Intel I7-3520M 102500295 2.9G L1 4M 2cPGA processor 6 Platform, Chief River platform 35w, Intel I5-3360M 2.8G 102500297 L1 3M 2cPGA processor 6 Platform, Chief River platform 35w, Intel I5-3320M 2.6G 102500299 L1 3M 2cPGA processor 6 Platform
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 99
    , 9.5mm Tray in BD Rambo, PSN 25209259 UJ262 9.5mm Tray in BD Rambo 8 Optical Disk Driver, 9.5mm Tray in BD Rambo, HLDS 25209260 BU10N 9.5mm Tray in BD Rambo 9 VIWZ2 DC-IN Cable 90202118 10 VIWZ2 Power Board W/Cable 90001771 11 VIWZ2 ODD Board W/Cable BD 90001772 11 VIWZ2 ODD Board W/Cable
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 100
    20200222 1x1BGN+BT4.0 HMC 14 W l a n , W i F i 1 x 1 B G N + B T 4 . 0 , L i t e o n W B 2 2 5 20200224 1x1BGN+BT4.0 HMC 15 VIWZ2 LED Board W/Cable 90001774 16 Hard disk drive, 500G 5400rpm, Samsung M8, 16200210 ST500LM012 5.4K RPM 9.5mm 500G 16 Hard disk drive, 500G 5400rpm, WD (MN500S
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 101
    Lenovo Z/P Series LCD FRUs In Lenovo Z400/Z500/P500, there are following types of LCDs. •• "14-in. HD TFT" 1 2 3 4 5 6 7 97
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 102
    Z/P Series Hardware Maintenance Manual •• "15.6-in. HD TFT" 1 2 3 4 5 6 7 98
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 103
    Lenovo Z/P Series 14-in. HD TFT Table 7. Parts list-14-in. HD TFT No. FRU FRU no. CRU ID. 1 VIWP1 LCD Bezel 90202316 2 VIWP1 LCD Hinge L+R 90202311 3 Panel, HD, LGD LP140WH2-TLE2 HD G F LED1 NB
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 104
    Z/P Series Hardware Maintenance Manual 100 15.6-in. HD TFT Table 8. Parts list-15.6-in. HD TFT No. FRU FRU no. CRU ID. 1 VIWZ2 LCD Bezel 90202123 2 VIWZ2 LCD Bracket L+R
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 105
    Lenovo Z/P Series Table 8. Parts list-15.6-in. HD TFT (continued) No. FRU FRU no. CRU ID. 4 Camera, 0.3M(For P500), AWA AM-VS058 0.3M NB camera
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 106
    Z/P Series Hardware Maintenance Manual Keyboard Table 9. Parts list-Keyboard (Z400) Language Chicony Z400 (win8) Sunrex English U.K. English Italian Spanish Turkish Thai Portuguese Latin Canadian Bilingual (En+Fr) Korean Traditional Chinese Russian French German Arabic Brazilian Japanese Dutch
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 107
    Lenovo Z/P Series Table 9. Parts list-Keyboard (Z400) (continued) Language Sunrex (continued) Z400 (win8) (continued) Darfon Arabic Brazilian Dutch Greek Hebrew Hungarian Nordic Belgian Icelandic Slovenian Swiss US international Czech&Slovak Bulgarian Indic English U.K. English Italian Spanish
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 108
    Z/P Series Hardware Maintenance Manual Table 9. Parts list-Keyboard (Z400) (continued) Language Chicony (with backlight) Z400 (win8) (continued) Darfon (with backlight) English U.K. English Italian Spanish Turkish Thai Portuguese Latin Canadian Bilingual (En+Fr) Korean Traditional Chinese Russian
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 109
    Lenovo Z/P Series Table 9. Parts list-Keyboard (Z400) (continued) Language Z400 (win8) Darfon (with backlight) (continued) (continued) Japanese Dutch Greek Hebrew Hungarian Nordic Belgian Icelandic Slovenian Swiss US international Czech&Slovak Bulgarian Indic P/N 25206105 25206106 25206107
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 110
    Z/P Series Hardware Maintenance Manual 106 Table 10. Parts list-Keyboard (Z500/P500) Language Chicony Z500 (win8) Darfon Arabic Belgian Brazilian Bulgarian Canadian Bilingual (En+Fr) Czech&Slovak Dutch French German Greek Hebrew
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 111
    Lenovo Z/P Series Table 10. Parts list-Keyboard (Z500/P500) (continued) Language Darfon (continued) Z500 (win8) (continued) Darfon (with backlight) Japanese Korean Latin Nordic Portuguese Russian Slovenian Spanish Swiss Traditional
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 112
    Z/P Series Hardware Maintenance Manual 108 Table 10. Parts list-Keyboard (Z500/P500) (continued) Language OKI (with backlight) Z500 (win8) (continued) Sunrex Arabic Belgian Brazilian Bulgarian Canadian Bilingual (En+Fr) Czech&Slovak Dutch
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 113
    Lenovo Z/P Series Table 10. Parts list-Keyboard (Z500/P500) (continued) Language Sunrex (continued) Z500 (win8) (continued) Sunrex (with backlight) Nordic Portuguese Russian Slovenian Spanish Swiss Traditional Chinese Thai Turkish U.K.
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 114
    Z/P Series Hardware Maintenance Manual Table 10. Parts list-Keyboard (Z500/P500) (continued) Language Darfon P500 (win8) Darfon (with backlight) Chicony OKI (with backlight) Sunrex Sunrex (with backlight) Canadian Bilingual (En+Fr)
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 115
    Lenovo Z/P Series Miscellaneous parts Z400 Table 11. Parts list-Miscellaneous parts (Z400) FRU System miscellaneous parts: • (a) VIWP1 ODD Bracket • (b) VIWP1 ODD Bezel Brown Rambo • (b) VIWP1 ODD Bezel Pink Rambo • (b) VIWP1 ODD Bezel Blue Rambo • (b) VIWP1 ODD Bezel
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 116
    Z/P Series Hardware Maintenance Manual AC adapters Table 13. Parts list-3-pin AC adapters FRU 65W, Delta ADP-65KH BD 20V/3.25A Adapter 65W, Liteon PA-1650-56LC Adapter 65W,
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 117
    Z/P Series Power cords A Lenovo power cord for a specific country or region is usually available only in that country or region: Table 14. Parts list-3-pin power cords Region CCC • LINETEK PC323+RVV300/300+LS15 1m Argentina • LINETEK LS15+H03VV-F+LP39 1m Danmark • LINETEK LS15+H03VV-F+LP-38
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 118
    Z/P Series Hardware Maintenance Manual 114 Table 14. Parts list-3-pin power cords (continued) Region Israel • Longwell LP-41+H03VV-F+LS-18 1m UL • Longwell LP-30B+SPT-2 18AWG+LS-18 1m UK •
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 119
    Lenovo Z/P Series Table 14. Parts list-3-pin power cords (continued) Region Argentina • VOLEX VA2073+H03VV-F+VAC5S 1m Brazil • VOLEX CH10S3+H03VV-F+VAC5S 1m Israel • VOLEX SI16S3+H03VV-F+VAC5S 1m
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 120
    Lenovo product, program, or service may be used. Any functionally equivalent product, program, or service that does not infringe any Lenovo intellectual property right may be used instead. However, it is the user for use in implantation or other life support applications where malfunction may result
  • Lenovo P500 Laptop | Hardware Maintenance Manual - Page 121
    the United States, other countries, or both: Windows® Windows Vista® Windows® 7 Windows® 8 The following are trademarks of Intel Corporation or its subsidiaries in the United States, other countries, or both: Intel® Intel® Core™ 2 Duo Other company, product, or service names may be the trademarks or
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
  • 99
  • 100
  • 101
  • 102
  • 103
  • 104
  • 105
  • 106
  • 107
  • 108
  • 109
  • 110
  • 111
  • 112
  • 113
  • 114
  • 115
  • 116
  • 117
  • 118
  • 119
  • 120
  • 121
Lenovo Z/P Series
Hardware
Maintenance
Manual