Lenovo ThinkStation D30 Hardware Maintenance Manual (HMM) - ThinkStation D30
Lenovo ThinkStation D30 Manual
View all Lenovo ThinkStation D30 manuals
Add to My Manuals
Save this manual to your list of manuals |
Lenovo ThinkStation D30 manual content summary:
- Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 1
ThinkStation Hardware Maintenance Manual Machine Types: 4223, 4228 and 4229 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 2
- Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 3
ThinkStation Hardware Maintenance Manual Machine Types: 4223, 4228 and 4229 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 4
product it supports, be sure to read and understand the Chapter 2 "Safety information" on page 3 and Appendix A "Notices" on page 109. First Edition (April 2012) © Copyright Lenovo 2012. LIMITED AND RESTRICTED RIGHTS NOTICE: If data or software is delivered pursuant a General Services Administration - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 5
BIOS configuration utility . . . . 47 Deleting RAID volumes using the LSI MegaRAID BIOS configuration utility . . . . 48 Setting the hot spare hard disk drive . . . . 48 Chapter 8. Symptom-to-FRU Index . . 49 Hard disk drive boot error 49 Power Supply Problems 49 Beep symptoms 49 POST error codes - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 6
management 107 Automatic configuration and power interface (ACPI) BIOS 107 Automatic Power-On features 107 System memory speed 107 Appendix A. Notices 109 Television output notice 110 European conformance CE mark 110 Trademarks 110 Index 111 iv ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 7
Chapter 1. About this manual This manual provides service and reference information for ThinkStation® computers listed on the front cover. This manual is intended only for trained service personnel who are familiar with Lenovo® computer products. Before servicing a Lenovo computer product, be sure - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 8
2 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 9
To avoid personal injury or equipment damage, disconnect the attached power cords, telecommunication systems, networks, and modems before you open the server/workstation covers, unless instructed otherwise in the installation and configuration procedures. Observe the following rules when working on - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 10
; these instructions are in the safety sections of maintenance information. service the following parts with the power on when they are removed from their normal operating places in a machine: - Power supply power. - Send another person to get medical aid. 4 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 11
users and service personnel from injury. This guide problem. Consider these conditions and the safety hazards they present: • Electrical hazards, especially primary power hardware The guide consists of a series of steps presented in a checklist. Begin the checks with the power off, and the power - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 12
worn, frayed, or pinched cables. 8. Check that the power-supply cover fasteners (screws or rivets) have not been removed as those listed below, to provide protection that meets the specific service requirement. Note: The use of a grounding system is 6 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 13
or perform installation, maintenance, or reconfiguration of this product during an electrical storm. • Connect all power cords to a power cords, telecommunications systems, networks, and modems before you open the device covers, unless instructed otherwise in the installation and configuration - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 14
on the power supply do not turn off the electrical current supplied to the device. The device also might have more than one power cord. To remove all electrical current from the device, ensure that all power cords are disconnected from the power source. 8 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 15
2 1 Chapter 2. Safety information 9 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 16
≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) 10 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 17
2 1 PERIGO A corrente elétrica proveniente de cabos de alimentação, de telefone e de comunicações é perigosa. Para evitar risco de choque elétrico: • Não conecte nem desconecte nenhum cabo ou execute instalação, manutenção ou reconfiguração deste produto durante uma tempestade com raios. • - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 18
121.2 lbs) CUIDADO: Utilize procedimentos de segurança para levantar equipamentos. CUIDADO: O botão de controle de alimentação do dispositivo e o botão para ligar/desligar da fonte de alimentação não desligam estejam desconectados da fonte de alimentação. 12 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 19
2 1 Chapter 2. Safety information 13 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 20
2 1 14 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 21
Chapter 2. Safety information 15 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 22
et de configuration). • Lorsque vous installez, que vous déplacez, ou que vous manipulez le présent produit ou des périphériques qui lui sont raccordés, reportez-vous aux instructions ci-dessous pour connecter et déconnecter les différents cordons. 16 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 23
les unités SOUS TENSION. ATTENTION: Remplacer la pile au lithium usagée par une pile de référence identique exclusivement, (référence 45C1566), ou suivre les instructions du fabricant qui en définit les équivalences. Si votre système est doté d'un module contenant une pile au lithium, vous devez le - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 24
ühren von Oberflächen mit unterschiedlichem elektrischem Potenzial zu vermeiden. • Geräte niemals einschalten, wenn Hinweise auf Feuer, Wasser oder Gebäudeschäden vorliegen. 18 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 25
• Die Verbindung zu den angeschlossenen Netzkabeln, Telekommunikationssystemen, Netzwerken und Modems ist vor dem Öffnen des Gehäuses zu unterbrechen, sofern in den Installations- und Konfigurationsprozeduren keine anders lautenden Anweisungen enthalten sind. • Zum Installieren, Transportieren und Ö - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 26
mit mehreren Netzkabeln ausgestattet sein. Um die Stromversorgung für die Einheit vollständig zu unterbrechen, müssen alle zum Gerät führenden Netzkabel vom Netz getrennt werden. 2 1 20 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 27
Chapter 2. Safety information 21 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 28
a una presa di alimentazione correttamente cablata e dotata di messa a terra. • Collegare alle prese elettriche appropriate tutte le apparecchiature che verranno utilizzate per questo prodotto. 22 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 29
pericolose. All'interno dell'unità non vi sono parti su cui effettuare l'assistenza tecnica. • L'utilizzo di controlli, regolazioni o l'esecuzione di procedure non descritti nel presente manuale possono provocare l'esposizione a radiazioni pericolose. Chapter 2. Safety information 23 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 30
l'unità disponga di più cavi di alimentazione. Per disattivare l'alimentazione dall'unità, accertarsi che tutti i cavi di alimentazione siano scollegati dalla fonte di alimentazione. 2 1 24 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 31
Chapter 2. Safety information 25 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 32
mano para conectar o desconectar los cables de señal. • No encienda nunca un equipo cuando hay señales de fuego, agua o daños estructurales. 26 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 33
quedar expuesto a radiación láser peligrosa. Dentro del dispositivo no existe ninguna pieza que requiera servicio técnico. • Si usa controles o ajustes o realiza procedimientos que no sean los especificados aquí, podría exponerse a radiaciones peligrosas. PELIGRO Chapter 2. Safety information 27 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 34
121.2 lbs) PRECAUCIÓN: Adopte procedimientos seguros al levantar el equipo. PRECAUCIÓN: El botón de control de alimentación del dispositivo y el interruptor de alimentación de la fuente de alimentación no estén desconectados de la toma de corriente. 2 1 28 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 35
to all machine types supported by this publication. Specifications This section lists the physical specifications for your computer. Dimensions Width: 210 mm (8.3 inches) Height: 485 mm (19.1 inches) (floor to top of handle) Depth: 602 mm (23.7 inches) Weight Maximum configuration as shipped: 27 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 36
Rescue and Recovery program is a one button recovery and restore solution that includes a set of self-recovery tools to help you diagnose computer problems, get help, and recover from system crashes, even if you cannot start the Windows operating system. 30 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 37
your computer is available at: http://www.lenovo.com/support You can find the following information: • Customer Replaceable Unit (CRU) installation or replacement instructions • Downloads and drivers • Parts information • Publications • Troubleshooting information • Links to other useful sources of - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 38
32 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 39
a problem: 1. Turn off the computer and all external devices. 2. Check all cables and power cords. 3. Set all display controls to the middle position. 4. Turn on all external devices. 5. Turn on the computer. • Look for displayed error codes • Listen for beep codes • Look for readable instructions - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 40
(version) 7. Have the same configuration options set in the system 8. Have the same setup for operating-system-controlled files Comparing the configuration and software set-up between "working and non-working" systems will often lead to problem resolution. 34 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 41
program. You will need the log files when you speak to a Lenovo technical support representative. Lenovo Solution Center The Lenovo Solution Center program enables you to troubleshoot and resolve computer problems. It combines diagnostic tests, system information collection, security status, and - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 42
36 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 43
beeps or see a logo screen, release the F1 key. Note: If a Power- from your computer or the memory module size has decreased, an configuration. To view or change settings, start the Setup Utility program. See "Starting the Setup Utility program" on page 37. Then, follow the instructions on the screen - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 44
Utility program main menu, select Security. 3. Depending on the password type, select Set Power-On Password, Set Administrator Password, or Hard Disk Password. 4. Follow the instructions on the right side of the screen to set, change, or delete a password. 38 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 45
the computer cover and connect the power cord. See "Completing the parts replacement" on page 104. Enabling or disabling a device This section provides information on how to enable or disable user access to the following devices: USB Configuration SATA Configuration Use this option to enable or - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 46
To view or permanently change the configured startup device sequence, do the instructions on the screen. 4. Press F10 to save changes and exit the Setup Utility program. Press Enter when prompted to confirm the exit. • Enabling the after power loss feature 40 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 47
to wake up when the power supply resumes after a sudden loss of electricity. To enable the after power loss feature, do the following: 1. Start the Setup Utility program. 2. From the Setup Utility program main menu, select Power ➙ After Power Loss, and press Enter. 3. Select Power On and press Enter - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 48
42 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 49
RAID This chapter provides instructions on how to install hard disk drives and configure Redundant Array of Independent Disks (RAID) for your computer. Depending on your computer model, RAID can be enabled by Intel Rapid Storage Technology enterprise (RSTe) or the LSI MegaRAID BIOS. Note: The RAID - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 50
arrow keys to select an option. After you configure an option, press Tab or Enter to go to the next option. a. Name: Volume name. You can use the default name or type a preferred name. b. RAID Level: You can change the RAID Level to one of the following: 44 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 51
utility Notes: • The LSI MegaRAID SAS adapter and the LSI MegaRAID BIOS configuration utility are only available on some models. • The following steps in this section are intended to guide you through a quick setup of basic RAID functions with the LSI MegaRAID SAS adapter. For advanced setup and - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 52
at http://support.lenovo.com/en_US/guides-and-manuals/detail.page?DocID=UM007543. This section provides information about the following topics: • "Installing SATA or SAS hard disk drives" on page 46 • "Entering the LSI MegaRAID BIOS configuration utility" on page 47 • "Creating RAID volumes using - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 53
, follow the instructions on the screen. 2. Press Ctrl+H to enter the CONTROLLER SELECTION window. 3. Select the controller you want to configure, and then click Start to enter the LSI MegaRAID BIOS configuration utility. Creating RAID volumes using the LSI MegaRAID BIOS configuration utility This - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 54
displayed. 3. Select Make Global HSP or Make Dedicated HSP, and then click Go. 4. The main screen of the LSI MegaRAID BIOS configuration utility is displayed, and the hard disk drive you selected is listed as a hot spare hard disk drive in the right pane. 48 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 55
On/Off switch power supply connector • System board power supply connectors • Microprocessor(s) connection Check the power cord for continuity. Check the turn on switch for continuity. FRU/Action Reseat connectors Power cord Turn on switch Beep symptoms Beep symptoms are tones or a series of tones - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 56
error message appears on the screen. A single problem can cause several error messages to appear. When you correct the cause of the first error message, the other error messages probably will not appear on the screen the next time you turn on the system. 50 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 57
testing, additional information appears. This information gives specifics about the type and location of the memory error. Pressing the TAB key permits the user to toggle between the default POST display screen and a custom POST display screen. The BIOS was unable to find a suitable boot device - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 58
above (including blank or illegible display) 1. Display 2. System board Turn on indicator or hard disk drive in-use light not on, but computer works correctly 1. Power switch/LED assembly 2. System board 52 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 59
Printer problems 1. Printer 2. System board Program loads from the hard disk with a known-good diagnostics diskette in the first 3.5-inch diskette drive 1. Run the Setup Utility program and check Startup sequence. 2. Diskette drive 3. Diskette drive cable 4. System board 5. Power supply RPL - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 60
If all devices and adapters have been removed, and the problem continues, replace the system board. 54 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 61
, control, and indicator locations 1 Optical drive eject/close button 2 USB 2.0 connector 3 Microphone connector 4 Headphone connector 5 USB 2.0 connector 6 1394 connector (available on some models) 7 Power switch 8 Power indicator 9 Hard disk drive activity indicator © Copyright Lenovo 2012 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 62
on the rear of your computer are color-coded to help you determine where to connect the cables on your computer. Figure 2. Rear connector locations 1 Power cord connector 2 PS/2 keyboard and mouse connectors , see "Removing the computer cover" on page 64. 56 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 63
Figure 3. Locating major FRUs and CRUs Chapter 9. Locations 57 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 64
, such as the FRU part numbers and supported computer models, go to: http:/www.lenovo.com/serviceparts-lookup Locating parts on the system board Figure 4 "System board part locations" on page 59 shows the locations of the parts on the system board. 58 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 65
14 Microprocessor 1 memory slot 8 (DIMM8) 15 Microprocessor 1 memory slot 4 (DIMM4) 16 Microprocessor 1 memory slot 7 (DIMM7) 17 Microprocessor 1 memory slot 3 (DIMM3) 18 Front fan connector 19 Microprocessor 1 memory cooler connector 29 ATX power connector 30 12 volt power connector 31 SATA - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 66
) 50 Rear fan connector 51 Microprocessor 2 memory slot 1 (DIMM1) 52 Microprocessor 2 memory slot 5 (DIMM5) 53 Microprocessor 2 memory slot 2 (DIMM2) 54 Microprocessor 2 memory slot 6 (DIMM6) 55 Microprocessor 2 12 volt power connector 56 Microprocessor 2 60 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 67
to read other types of media. Internal drives are installed in bays. In this manual, the bays are referred to as bay 1, bay 2, and so on. When . Refer to the appropriate section in "Installing or replacing hardware" on page 63 for instructions on how to install or replace internal drives for your - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 68
62 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 69
service technicians. Installing or replacing hardware This section provides instructions on how to install or replace hardware components carefully. Handle PCI cards, memory modules, system boards, and microprocessors external option, see "Locating connectors, controls, and indicators on the front of - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 70
connectors, controls, and indicators on the front of your computer" on page 55 and "Locating connectors on the rear of your computer" on page 56. 4. Remove any locking device that secures the computer cover, such as a padlock or an integrated cable lock. 64 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 71
understanding the "Important Safety Information" on page 1. This section provides instructions on how to remove and reinstall the front bezel. To remove , do the following: 1. Turn off the computer and disconnect all power cords from electrical outlets. 2. Remove the computer cover. See "Removing the - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 72
page 1. This section provides instructions on how to install or power cords from electrical outlets. 2. Remove the computer cover. See "Removing the computer cover" on page 64. 3. Open the PCI card retainer by lifting the retainer and then pivoting it out. 66 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 73
Figure 8. Opening the PCI card retainer 4. Depending on whether you are installing or replacing a PCI card, do one of the following: • If you are installing a PCI card, remove the appropriate metal card slot cover. • If you are replacing an old PCI card, grasp the old card that is currently - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 74
Figure 9. Removing a PCI card Notes: a. The card fits tightly into the card slot. If necessary, alternate moving each side of the card a small amount until it is removed from the card slot. 68 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 75
the PCI card. What to do next: • To work with another piece of hardware, go to the appropriate section. • To complete the installation or replacement, go to the parts replacement" on page 104. Installing or replacing a memory module Attention: Do not open your computer or attempt any repair - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 76
replace a memory module, do the following: 1. Turn off the computer and disconnect all power cords memory fan duct. Figure 10. Removing the memory fan duct 8. Depending on whether you are installing or replacing a memory module, do one of the following: 70 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 77
open the retaining clips and gently pull the memory module out of the memory slot. Figure 11. Removing a memory module • If you are installing a memory module, open the retaining clips of the memory slot into which you want to install the memory module. Figure 12. Opening the retaining clips Chapter - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 78
fan duct downward until the fan duct snaps into position. Figure 14. Installing the memory fan duct 11. Reconnect the memory fan cable to the system board. See "Locating parts on the system board" understanding the "Important Safety Information" on page 1. 72 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 79
This section provides instructions on how to install or replace the optical drive. To install or replace an optical drive, do the following: 1. Turn off the computer and disconnect all power cords from electrical outlets. 2. Remove the computer cover. See "Removing the computer cover" on page 64. 3. - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 80
drive into the drive bay from the front of the computer until the optical drive snaps into position. Figure 17. Installing the optical drive 74 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 81
power cable to the new optical drive. Figure 18. Connecting the optical drive 9. Reinstall the front bezel. See "Removing and reinstalling the front bezel" on page 65. What to do next: • To work with another piece of hardware on page 1. This section provides instructions on how to install or replace - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 82
6. Press the blue retaining clip 1 to remove the card reader out of the chassis. Figure 19. Removing the card reader 7. Install the card reader retainer on the side of the new card reader. Figure 20. Installing the card reader retainer 76 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 83
with another piece of hardware, go to the memory that maintains the date, time, and settings for built-in features, such as parallel-port assignments (configuration). A battery keeps this information active when you turn off the computer. The battery normally requires no charging or maintenance - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 84
ThinkStation Safety and Warranty Guide for information about replacing and disposing of the battery. To replace the battery, do the following: 1. Turn off the computer and disconnect all power instructions on how to replace the heat sink and fan assembly. 78 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 85
cool before removing the computer cover. To replace the heat sink and fan assembly, do the following: 1. Turn off the computer and disconnect all power cords from electrical outlets. 2. Remove the computer cover. See "Removing the computer cover" on page 64. 3. Lay the computer on its side for - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 86
"Important Safety Information" on page 1. This section provides instructions on how to replace the hard disk drive fan assembly do the following: 1. Turn off the computer and disconnect all power cords from electrical outlets. 2. Remove the computer cover. See ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 87
to do next: • To work with another piece of hardware, go to the appropriate section. • To complete the " on page 1. This section provides instructions on how to replace the rear fan following: 1. Turn off the computer and disconnect all power cords from electrical outlets. 2. Remove the computer cover - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 88
push the rubber mounts through the holes. Pull on the tips of the rubber mounts until the rear fan assembly is secured in place. 82 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 89
with another piece of hardware, go to the appropriate instructions on how to install or replace a hard disk drive. Notes: If you are installing additional hard disk drives, ensure that your computer is properly configured to support power cords from electrical outlets. Chapter 10. Replacing FRUs 83 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 90
cable and the power cable from the hard disk drive. 5. Pull the bracket handle out to remove the hard disk drive from the chassis. Figure 28. Removing the hard disk drive 6. Flex the sides of the bracket to remove the hard disk drive from the bracket. 84 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 91
to 3.5-inch converter bracket. Then install the 2.5-inch hard disk drive with the converter bracket into the 3.5-inch hard disk drive bracket. Figure 30. Installing 2.5-inch to 3.5-inch converter bracket before installing the outer bracket 8. Slide the new hard disk drive into the drive cage until - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 92
. Note: If you are installing SAS hard disk drives, you must connect the signal cables and power cables to the SAS-to-SATA conversion adapter before you connect them to the hard disk drive. Figure 32. Connecting SAS cables to SAS-to-SATA conversion adapter 86 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 93
work with another piece of hardware, go to the appropriate Safety Information" on page 1. This section provides instructions on how to install or replace a hard disk do the following: 1. Turn off the computer and disconnect all power cords from electrical outlets. 2. Remove the computer cover. See - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 94
Important Safety Information" on page 1. This section provides instructions on how to replace the front audio and USB assembly do the following: 1. Turn off the computer and disconnect all power cords from electrical outlets. 2. Remove the computer cover. See ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 95
system board" on page 58. What to do next: • To work with another piece of hardware, go to the appropriate section. • To complete the installation or replacement, go to "Completing " on page 1. This section provides instructions on how to replace the internal speaker. Chapter 10. Replacing FRUs 89 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 96
speaker, do the following: 1. Turn off the computer and disconnect all power cords from electrical outlets. 2. Remove the computer cover. See "Removing the the microprocessor This topic provides instructions on how to install or replace the microprocessor. 90 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 97
on page 1. This topic provides instructions on how to install the second microprocessor the correct type of microprocessor option your computer supports. When two microprocessors are installed, both must and the computer. Then, disconnect all power cords from electrical outlets and disconnect all - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 98
release it from the secured position. Then, open the other small handle 1 by following the same instructions. Ensure that the small handles are in the fully open position. Note: There are two marks the gold contacts on the bottom of the microprocessor. 92 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 99
• Do not drop anything onto the microprocessor socket while it is exposed. The socket pins must be kept as clean as possible. Figure 39. Removing the microprocessor 8. Touch the static-protective package that contains the new microprocessor to any unpainted surface on the outside of the computer. - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 100
the microprocessor socket. Figure 41. Installing the microprocessor 11. Pivot the microprocessor retainer downward to close the retainer. Figure 42. Closing the microprocessor retainer 94 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 101
What to do next: • To work with another piece of hardware, go to the appropriate section. • To complete the replacement, go Information" on page 1. This section provides instructions on how to replace a microprocessor. Depending option your computer supports. When two microprocessors are installed, both must - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 102
power instructions. Ensure that the small handles are in the fully open position. Figure 44. Opening the handles 7. Gently press down the small handle 2 to open the microprocessor retainer. Pivot the retainer upward until it is in the fully open position. 96 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 103
Figure 45. Opening the microprocessor retainer 8. Touch only the edges of the microprocessor and carefully lift it straight up and out of the microprocessor socket. Place the old microprocessor on a static-protective surface. Notes: • Do not touch the gold contacts on the bottom of the - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 104
. The new microprocessor is in the correct orientation when this indicator faces the beveled corner 4 of the microprocessor socket. Figure 48. Installing the microprocessor 98 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 105
. See "Replacing the heat sink and fan assembly" on page 78. 15. If you are instructed to return the old microprocessor, follow all packaging instructions and use any packaging materials that are supplied to you for shipping. 16. To complete the replacement, go to "Completing the parts replacement - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 106
attached devices and the computer. Then, disconnect all power cords from electrical outlets and disconnect all cables that board. 4. Remove all memory modules and PCI cards that are currently installed. See "Installing or replacing a memory module" on page 69 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 107
the chassis by following the sequence from 10 to 1 . 14. Remove the microprocessor socket cover(s) from the new system board. 15. Install the memory modules, PCI cards, battery, microprocessor, heat sink and fan assembly, hard disk drive enablement module (if applicable), and the hard disk drive fan - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 108
reading and understanding the "Important Safety Information" on page 1. This document provides instructions on how to replace the power supply assembly. CAUTION: Never remove the cover on a power supply or any part that has the following label attached. 102 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 109
attached. There are no serviceable parts inside these components. CAUTION: The heat sink and microprocessor might be very hot. Turn off the computer and wait three to five minutes to let the computer cool before removing the computer cover. To replace the power supply assembly, do the following - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 110
a few days after the CRU arrives. Obtaining device drivers You can obtain device drivers for operating systems that are not preinstalled at http://www.lenovo.com/support. Installation instructions are provided in readme files with the device-driver files. 104 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 111
BIOS available 1. Lenovo support web site: http://www.lenovo.com/support 2. Lenovo Customer Support Center 3. Levels 1 and 2 Support To update (flash) the BIOS, see "Updating (flashing) the BIOS" on page 105. Updating (flashing) the BIOS This section provides instructions on how to update the BIOS - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 112
screen after the download begins. 5. Follow the printed instructions to download, extract, and install the update. Recovering from a POST/BIOS update failure If the power to your computer is interrupted while the POST and BIOS is being updated jumper. 106 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 113
components of the computer such as the system power supply, processor, hard disk drives, and some monitors. Automatic configuration and power interface (ACPI) BIOS Being an ACPI BIOS system, the operating system is allowed to control the power management features of the computer and the setting - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 114
-2630/2630L, E5-2640, E5-2667 E5-2637, E5-2643, E5-2650/2650L, E5-2660, E5-2665, E5-2670, E5-2680, E5-2685, E5-2690, Memory frequency 1066 MHz 1333 MHz Memory frequency 1066 MHz 1333 MHz Memory frequency 1066 MHz 1333 MHz 1066 MHz 1333 MHz 1600 MHz 108 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 115
are not intended for use in implantation or other life support applications where malfunction may result in injury or death to persons. The information contained in this document does not affect or change Lenovo product specifications or warranties. Nothing in this document shall operate as an - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 116
the United States, other countries, or both. Linux is a trademark of Linus Torvalds in the United States, other countries, or both. Other company, product, or service names may be trademarks or service marks of others. 110 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 117
devices, handling static-sensitive 63 drivers, device 104 drives bays 61 specifications 61 E environment, operating 29 exiting, Setup Utility 41 external options, installing 63 F failure, recovering from POST/BIOS 106 flashing the BIOS 105 front connectors, controls, indicators 55 front audio and - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 118
63 system board locating parts 58 locations 58 memory module 69 T temporary startup device 40 the BIOS, updating (flashing) 105-106 trademarks 110 U updating (flashing) the BIOS 105 updating (flashing) the BIOS 106 112 ThinkStation Hardware Maintenance Manual using passwords 37 Setup Utility 37 - Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 119
- Lenovo ThinkStation D30 | Hardware Maintenance Manual (HMM) - ThinkStation D30 - Page 120
ThinkStation
Hardware Maintenance Manual
Machine Types: 4223, 4228 and 4229