Maytag MGR7775WB Installation Guide
Maytag MGR7775WB Manual
 |
View all Maytag MGR7775WB manuals
Add to My Manuals
Save this manual to your list of manuals |
Maytag MGR7775WB manual content summary:
- Maytag MGR7775WB | Installation Guide - Page 1
INSTRUCTIONS 30" (76.2 CM) FREESTANDING GAS RANGES Table of Contents RANGE SAFETY 1 INSTALLATION REQUIREMENTS 3 Tools and Parts 3 Location Requirements 3 Electrical Requirements 5 Gas Supply Requirements 5 INSTALLATION INSTRUCTIONS 6 Unpack Range 6 Install Anti-Tip Bracket 7 Make Gas - Maytag MGR7775WB | Installation Guide - Page 2
from a neighbor's phone. Follow the gas supplier's instructions. • If you cannot reach your gas supplier, call the fire department. - Installation and service must be performed by a qualified installer, service agency or the gas supplier. WARNING: Gas leaks cannot always be detected by smell - Maytag MGR7775WB | Installation Guide - Page 3
's responsibility to comply with installation clearances specified on the model/serial rating plate. The model/serial rating plate is located on the oven frame behind the top left side of the oven door. ■ The range should be located for convenient use in the kitchen. ■ Recessed installations - Maytag MGR7775WB | Installation Guide - Page 4
range hood or microwave hood combination above the range, follow the range hood or microwave hood combination installation instructions rating plate (located on the oven frame behind the top left side of the oven door) *Range areas are recommended for installation of rigid gas pipe. G. 4¹⁄₂" (11.4 cm) - Maytag MGR7775WB | Installation Guide - Page 5
instructions. Type of Gas Natural gas: This range is design-certified by CSA International for use with Natural gas or, after proper conversion, for use with LP gas. ■ This range is factory set for use with Natural gas. See "Gas Conversions" section. The model/serial rating plate located on the oven - Maytag MGR7775WB | Installation Guide - Page 6
) or lower The range must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than ½ psi (3.5 kPa). INSTALLATION INSTRUCTIONS Unpack Range WARNING Excessive Weight - Maytag MGR7775WB | Installation Guide - Page 7
mounting holes through your type of floor covering. Before moving range, slide range onto shipping base, cardboard or hardboard. 1. Remove template from the anti-tip bracket kit (found inside the oven cavity) or from the back of this manual. 2. Place template on the floor in cabinet opening so that - Maytag MGR7775WB | Installation Guide - Page 8
2. Using a pipe wrench to tighten, connect the gas supply to the range. B C A D F E J A. Gas pressure regulator B. 90° elbow (must have ½" male pipe thread) C. Nipple D. Union E. Black iron pipe I HG F. Manual gas shutoff valve G. ½" or ¾" gas pipe H. Nipple I. Union J. 90° elbow Typical - Maytag MGR7775WB | Installation Guide - Page 9
use an adapter. Do not use an extension cord. Failure to follow these instructions can result in death, fire, or electrical shock. 5. Plug into a grounded Range must be level for satisfactory baking performance. Electronic Ignition System Initial lighting and gas flame adjustments Cooktop and oven - Maytag MGR7775WB | Installation Guide - Page 10
bake and broil burners. Refer to the Use and Care Guide for proper operation of the oven controls. Adjust Oven Bake Burner Flame (if needed) 1. On models with occur. 3. If the oven bake flame needs to be adjusted, locate the air shutter near the center rear of the range. Loosen the locking screw and - Maytag MGR7775WB | Installation Guide - Page 11
to the Use and Care Guide for proper operation of the oven controls. Adjust Oven Broil Burner Flame (if needed) Look through oven window to check broil burner Remove all items from inside the warming drawer, and allow the range to cool completely before attempting to remove the drawer. To Remove: - Maytag MGR7775WB | Installation Guide - Page 12
and Care Guide for specific instruction on range operation. If range does not operate, check the following: ■ Household fuse is intact and tight, or circuit breaker has not tripped. ■ Range is plugged into a grounded 3 prong outlet. ■ Electrical supply is connected. ■ See "Troubleshooting" in the - Maytag MGR7775WB | Installation Guide - Page 13
is moved. Failure to follow these instructions can result in death or serious burns to children and adults. 1. Turn the manual shutoff valve to the closed position. B A C A. To range B. Manual shutoff valve "closed" position C. Gas supply line 2. Unplug range or disconnect power. C Side view after - Maytag MGR7775WB | Installation Guide - Page 14
the range near the gas inlet. Gas gas orifice spud with the correct LP gas orifice spud. LP Gas Orifice Spud Chart for Surface Burners Burner Rating Oven Bake Burner (Natural Gas to LP Gas) 1. Remove the oven racks. 2. Remove 2 screws at the rear of the oven bottom. 3. Lift the rear of the oven - Maytag MGR7775WB | Installation Guide - Page 15
orifice, disconnect the igniter wire, and set the bake burner aside on a covered surface. B To Convert Oven Broil Burner (Natural Gas to LP Gas) 1. Remove the screw from the broil burner. 2. Remove the broil burner from the broil burner orifice hood. NOTE: The broil burner will hang in the - Maytag MGR7775WB | Installation Guide - Page 16
is moved. Failure to follow these instructions can result in death or serious burns to children and adults. 1. Turn the manual shutoff valve to the closed position. B A C A. To range B. Manual shutoff valve "closed" position C. Gas supply line 2. Unplug range or disconnect power. B D E NG NG - Maytag MGR7775WB | Installation Guide - Page 17
flame spreader and pull forward to remove tabs from rear of oven and set it aside on a covered surface. B A. Stamped number Refer to the following chart for the correct Natural gas orifice spud placement. Natural Gas Orifice Spud Chart Burner Rating Color Size ID Number 17,000 BTU 15,000/15 - Maytag MGR7775WB | Installation Guide - Page 18
Checking for proper cooktop, bake and broil burner flame is very important. Natural gas flames do not have yellow tips. 3. Refer to "Complete Installation" in the "Installation Instructions" section of this manual to complete this procedure. B A C A. Broil burner B. Screws C. Orifice hood 3. Use - Maytag MGR7775WB | Installation Guide - Page 19
Left edge ANTI-TIP BRACKET TEMPLATE Cut on dotted lines and place the left edge against the left side cabinet and the top edge against the rear wall. Top edge 19 - Maytag MGR7775WB | Installation Guide - Page 20
W10413012A © 2011. All rights reserved. 5/11 Printed in U.S.A.
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
 |
 |
INSTALLATION INSTRUCTIONS
30" (76.2 CM) FREESTANDING GAS RANGES
RANGE SAFETY
Table of Contents
RANGE SAFETY
.............................................................................
1
INSTALLATION REQUIREMENTS
...............................................
3
Tools and Parts
............................................................................
3
Location Requirements
...............................................................
3
Electrical Requirements
...............................................................
5
Gas Supply Requirements
..........................................................
5
INSTALLATION INSTRUCTIONS
.................................................
6
Unpack Range
.............................................................................
6
Install Anti-Tip Bracket
................................................................
7
Make Gas Connection
.................................................................
8
Verify Anti-Tip Bracket Location
.................................................
9
Level Range
.................................................................................
9
Electronic Ignition System
...........................................................
9
Warming Drawer
........................................................................
11
Storage Drawer
..........................................................................
11
Oven Door
..................................................................................
12
Complete Installation
.................................................................
12
GAS CONVERSIONS
...................................................................
13
LP Gas Conversion
....................................................................
13
Natural Gas Conversion
............................................................
16
ANTI-TIP BRACKET TEMPLATE
................................................
19
You can be killed or seriously injured if you don't immediately
You
can be killed or seriously injured if you don't follow
All safety messages will tell you what the potential hazard is, tell you how to reduce the chance of injury, and tell you what can
happen if the instructions are not followed.
Your safety and the safety of others are very important.
We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety
messages.
This is the safety alert symbol.
This symbol alerts you to potential hazards that can kill or hurt you and others.
All safety messages will follow the safety alert symbol and either the word “DANGER” or “WARNING.”
These words mean:
follow instructions.
instructions.
DANGER
WARNING
IMPORTANT:
Save for local inspector's use.
Installer:
Leave installation instructions with the homeowner.
Homeowner:
Keep installation instructions for future reference.
W10413012A