Poulan HDK19H42 User Manual

Poulan HDK19H42 Manual

Get Poulan HDK19H42 PDF manuals and user guides View all Poulan HDK19H42 manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan HDK19H42 manual content summary:

  • Poulan HDK19H42 | User Manual - Page 1
    Throw Away 02478 OPERATOR'S MANUAL MODEL: HDK19H42 960160004 LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 197788 02.18.05
  • Poulan HDK19H42 | User Manual - Page 2
    / engine parts and burn. Do not allow the mower deck to plow leaves or other debris which can cause build-up to occur. Clean any oil or fuel understand, and follow all instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts or under the machine.
  • Poulan HDK19H42 | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan HDK19H42 | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan HDK19H42 | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Boot (1) Large Flat Washer Steering Wheel Adapter Steering Wheel Insert Steering Extension Shaft (1) 5/16 Lock Washer (1) Hex Bolt 5/16-18 x 4 (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Key (2) Keys (1) Oil Drain Tube Slope Sheet 5
  • Poulan HDK19H42 | User Manual - Page 6
    tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness. TOOLS REQUIRED FOR ASSEMBLY A socket wrench set will STAPLES IN SKID THAT MAY PUNCTURE TIRES WHERE TRACTOR IS TO ROLL OFF SKID. ADAPTER LOWER STEERING SHAFT TABS
  • Poulan HDK19H42 | User Manual - Page 7
    section of this manual). • Roll tractor forward off skid. • Remove banding holding the deflector shield up against tractor. TO DRIVE TRACTOR OFF SKID (See Operation section for location and function of controls) WARNING: Before starting, read, understand and follow all instructions in the Operation
  • Poulan HDK19H42 | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan HDK19H42 | User Manual - Page 9
    P ENGINE OFF REVERSE OPERATION SYSTEM (ROS) ENGINE ON ENGINE START PARKING BRAKE PARKING BRAKE PARKING BRAKE LOCKED UNLOCKED OVER TEMP LIGHT FUEL OIL PRESSURE BATTERY REVERSE FORWARD MOWER HEIGHT 15 MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED DANGER, KEEP
  • Poulan HDK19H42 | User Manual - Page 10
    - Used to engage the mower blades, or other attachments mounted to your tractor. ATTACHMENT LIFT LEVER - Used to raise and lower the mower deck or other attachments mounted to your tractor. CLUTCH/BRAKE PEDAL - Used for declutching and braking the tractor and starting the engine. FREEWHEEL CONTROL
  • Poulan HDK19H42 | User Manual - Page 11
    brake will hold tractor secure Start tractor with motion control lever in neutral (N) position. • Release parking brake. CLUTCH/BRAKE PEDAL "DRIVE" POSITION PARKING BRAKE "DISENGAGED" POSITION FIG. 5 STOPPING (See Fig. 5) MOWER BLADES For healthier and better looking lawns, mow often and after
  • Poulan HDK19H42 | User Manual - Page 12
    clutch engaged will shut off the engine. You must remain fully and centrally positioned in the seat to prevent the engine from hesitating or cutting off when operating your equipment on rough, rolling terrain or hills. • Select desired height of cut. • Start mower blades by engaging attachment
  • Poulan HDK19H42 | User Manual - Page 13
    is reached. Do not overfill. • For cold weather operation you should change oil for easier starting (See "OIL VISCOSITY CHART" in the Maintenance section of this manual). • To change engine oil, see the Maintenance section in this manual. ADD GASOLINE • Fill fuel tank to bottom of filler neck. Do not
  • Poulan HDK19H42 | User Manual - Page 14
    tractor for the first time. This procedure will remove any trapped air inside the transmission which may have developed during shipping of your tractor. IMPORTANT: SHOULD YOUR TRANSMISSION REQUIRE REMOVAL FOR SERVICE manual). • Sitting in the tractor seat, start Wet grass will plug mower and leave
  • Poulan HDK19H42 | User Manual - Page 15
    to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should replace the spark plug, clean or replace air filter, and check blades and belts for wear
  • Poulan HDK19H42 | User Manual - Page 16
    with a file or on a grind- ing wheel. Do not attempt to sharpen while on the mower. • To check blade balance, you will need a 5/8" diameter steel bolt, pin, or a cone balancer. (When using a cone balancer, follow the instructions supplied with balancer). NOTE: Do not use a nail for balancing
  • Poulan HDK19H42 | User Manual - Page 17
    crankcase oil level before starting the engine and after each eight (8) hours of operation. TO CHANGE ENGINE OIL (See Figs. 12 and 13) Determine temperature range expected before oil change. All oil must meet API service classification SG-SL. • Be sure tractor is on level surface. • Oil will drain
  • Poulan HDK19H42 | User Manual - Page 18
    and stubborn dried gum fibers. AIR FILTER Your engine will not run properly using a dirty air filter. Service air cleaner more often under dusty conditions. See Engine Manual. ENGINE OIL FILTER Replace the engine oil filter every season or every other oil change if the tractor is used more than 100
  • Poulan HDK19H42 | User Manual - Page 19
    key to "STOP" and remove key. • Make sure the blades and all moving parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig. 15) Mower will be easier to remove from the right side of
  • Poulan HDK19H42 | User Manual - Page 20
    19) IMPORTANT: DECK MUST BE LEVEL SIDE-TO-SIDE. IF THE FOLLOWING FRONT-TO-BACK ADJUSTMENT IS NECESSARY, BE SURE TO ADJUST BOTH FRONT LINKS EQUALLY SO MOWER WILL STAY LEVEL SIDE-TO-SIDE. • Remove mower from tractor (See "TO REMOVE MOWER" in this section of this manual). • Work belt off both mandrel
  • Poulan HDK19H42 | User Manual - Page 21
    toward front of tractor and roll around the top groove of engine pulley. • Install belt through stationary idler and clutching idler. • Make sure belt is in all pulley grooves and inside all belt guides and keepers. • Install mower (See "TO INSTALL MOWER" in this sec- tion of manual). ENGINE PULLEY
  • Poulan HDK19H42 | User Manual - Page 22
    SERVICE AND ADJUSTMENTS NOTE: If additional clearance is needed to get to adjustment bolt, move mower deck height to the lowest position. After above adjustment is made, if the tractor still creeps forward or backward while motion control lever is in neutral position, follow these steps: • Loosen
  • Poulan HDK19H42 | User Manual - Page 23
    bolt and keps nut. Tighten securely. INTERLOCKS AND RELAYS Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts section. TO REPLACE FUSE Replace with 20 amp automotive-type plug-in
  • Poulan HDK19H42 | User Manual - Page 24
    . Store in a clean, dry area. • Clean entire tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual). • Lubricate as shown in the Maintenance section of
  • Poulan HDK19H42 | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM Will not start CAUSE 1. Out of fuel. 2. Engine not "CHOKED" properly. 3. Engine flooded. 4. Bad spark plug. 5. Dirty air filter. 6. Dirty fuel filter. 7. Water in fuel. 8. Loose or damaged wiring. 9. Carburetor out of adjustment. 10. Engine valves out of adjustment.
  • Poulan HDK19H42 | User Manual - Page 26
    before mowing. 4. Level mower deck. 5. Check tires for proper air pressure. 6. Replace/sharpen blade. Tighten blade bolt. 7. Clean underside of mower housing. 8. Replace mower drive belt. 9. Reinstall blades sharp edge down. 10. Replace with blades listed in this manual. 11. Clean around mandrels
  • Poulan HDK19H42 | User Manual - Page 27
    parts submitted for replacement under this warranty must be paid by the purchaser unless such return is requested by Electrolux Home Products. 3. Battery Warranty: On products equipped with a Battery, we will with the instructions furnished. This this Warranty are belts, blades, blade adapters, normal
  • Poulan HDK19H42 | User Manual - Page 28
    SERVICE NOTES 28
  • Poulan HDK19H42 | User Manual - Page 29
    29 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan HDK19H42 | User Manual - Page 30
    Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized distributors and dealers; therefore, all requests for parts and service should be directed to your local dealer
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
OPERATOR'S MANUAL
MODEL:
HDK19H42
960160004
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
197788
02.18.05
TR
Printed in U.S.A.
02478