Poulan PB195A42LT User Manual

Poulan PB195A42LT Manual

Get Poulan PB195A42LT PDF manuals and user guides View all Poulan PB195A42LT manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PB195A42LT manual content summary:

  • Poulan PB195A42LT | User Manual - Page 1
    Do Not Throw Away OPERATOR'S MANUAL MODEL: PB195A42LT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 532 43 88-82 10.25
  • Poulan PB195A42LT | User Manual - Page 2
    to operate the riding mower safely enough to protect themselves and others from serious injury. • Follow the manufacturer's recommendation for wheel weights or counterweights. • Keep machine free of grass , leaves or other debris build-up which can touch hot exhaust / engine parts and burn. Do
  • Poulan PB195A42LT | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan PB195A42LT | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PB195A42LT | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Steering Wheel Insert Steering Wheel Adapter Steering Wheel (1) Large Flat Washer (1) Lock Washer (1) Hex Bolt Steering Boot Seat Steering Extension Shaft (1) Washer (1) Seat (1) Bolt Slope Sheet Key(s) 5
  • Poulan PB195A42LT | User Manual - Page 6
    MAY PUNCTURE TIRES WHERE TRACTOR IS TO ROLL OFF SKID. UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton . manual for charging instructions). • For battery and battery cable installation see "REPLACING BATTERY" in the "Service and Adjustments" section in this manual
  • Poulan PB195A42LT | User Manual - Page 7
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is operating properly. See
  • Poulan PB195A42LT | User Manual - Page 8
    MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) LIGHTS ON Failure to follow instructions result in damage to the tractor and/or engine. HOT
  • Poulan PB195A42LT | User Manual - Page 9
    Standards Institute. ATTACHMENT CLUTCH LEVER - Used to engage the mower blades, or other attachments mounted to your tractor. ATTACHMENT LIFT LEVER - Used to raise, lower, and adjust the mower deck or other attachments mounted to your tractor. CLUTCH/BRAKE PEDAL - Used for declutching and braking
  • Poulan PB195A42LT | User Manual - Page 10
    damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend standard safety speed (fast) offers the best mower performance. Fig. 6 STOPPING (See Fig. 7) MOWER BLADES • To stop mower blades, place attachment clutch control
  • Poulan PB195A42LT | User Manual - Page 11
    and to over 3" during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance, tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual
  • Poulan PB195A42LT | User Manual - Page 12
    of the manufacturer of your tractor. Use common sense when towing problems, the fuel system should be emptied before storage of 30 days or longer. Drain the gas tank, start the engine and let it run until the fuel lines and carburetor are empty. Use fresh fuel next season. See Storage Instructions
  • Poulan PB195A42LT | User Manual - Page 13
    TIPS • Tire chains cannot be used when the mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so
  • Poulan PB195A42LT | User Manual - Page 14
    C Check/Replace Mower Blades T Lubrication instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual
  • Poulan PB195A42LT | User Manual - Page 15
    tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted. (See "TO CHECK BRAKE" in the Service and Adjustments section of this manual your local parts dealer. Tire results mower blades must
  • Poulan PB195A42LT | User Manual - Page 16
    every season or every other oil change if the tractor is used more than 100 hours in one year. See engine manual. AIR FILTER Your engine will not run properly using a dirty air filter. Service air cleaner more often under dusty conditions. See engine manual. CLEAN AIR SCREEN Air screen must be kept
  • Poulan PB195A42LT | User Manual - Page 17
    movable parts (See section of this manual. IN-LINE FUEL tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower
  • Poulan PB195A42LT | User Manual - Page 18
    SERVICE the blades and all moving parts have completely stopped. • MOWER IS TO BE MOUNTED ON THE TRACTOR, REMOVE THE FRONT LINK (E) AND REAR LIFT LINKS (C) FROM TRACTOR AND HOOK THE CLUTCH SPRING (Q) INTO THE CABLE GUIDE ON FRONT EDGE OF LOWER DASH. TO INSTALL MOWER (See Fig. 23-28) Be sure tractor
  • Poulan PB195A42LT | User Manual - Page 19
    SERVICE AND ADJUSTMENTS • ATTACH MOWER SIDE SUSPENSION ARMS (A) TO CHASSIS - Position hole in arm over pin (B) on outside of tractor chassis and secure with retainer spring. • Repeat on opposite side of tractor. • Insert end of link (E) into hole in front mower bracket and secure with washer and
  • Poulan PB195A42LT | User Manual - Page 20
    SERVICE AND ADJUSTMENTS TO LEVEL MOWER Make sure tires are properly inflated to the PSI shown on tires. If tires are over or under inflated, it may affect the appearance of your lawn and lead you to think the mower than the rear tip, go to the front of tractor. • With an 11/16" or adjustable wrench,
  • Poulan PB195A42LT | User Manual - Page 21
    (A) and clutching idler (B). 6. Make sure belt is in all pulley grooves and inside all belt guides and keepers. 7. Install mower (See "TO INSTALL MOWER" section in this manual). Fig. 33 TO CHECK BRAKE If tractor requires more than five (5) feet to stop at highest speed in highest gear on a level
  • Poulan PB195A42LT | User Manual - Page 22
    to adjustment bolt, move mower deck height to the lowest tractor. If damage has occurred to affect the front wheel toe-in or camber, contact your nearest authorized service be purchased from your local parts dealer. Tire sealant also prevents tire instructions in the Assembly section of this manual.
  • Poulan PB195A42LT | User Manual - Page 23
    AND RELAYS Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service
  • Poulan PB195A42LT | User Manual - Page 24
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PB195A42LT | User Manual - Page 25
    TROUBLESHOOTING PROBLEM mower. 3. Clean underside of mower service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part(s). 1. Replace blade. Tighten blade bolt. 2. Replace blade mandrel. 3. Tighten loose part(s). Replace damaged parts
  • Poulan PB195A42LT | User Manual - Page 26
    belt. 9. Blades improperly installed. 9. Reinstall blades sharp edge down. 10. Improper blades used. 10. Replace with blades listed in parts manual. 11. Clogged mower deck vent holes from buildup 11. Clean around mandrels to open vent holes. of grass, leaves, trash around mandrels. Headlight
  • Poulan PB195A42LT | User Manual - Page 27
    27 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PB195A42LT | User Manual - Page 28
    charge for parts or labor incurred in replacing parts, any part which be maintained in accordance with the instructions furnished. 4. The Warranty period for service dealer. Should you have any unanswered questions concerning this Warranty, please contact: HOP Outdoor Products Customer Service
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
OPERATOR'S MANUAL
MODEL:
PB195A42LT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings
and Safety Instructions.
Failure to do so can
result in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
532 43 88-82
10.25.10 BAD
Printed in the U.S.A.