Poulan PB19H42LT User Manual

Poulan PB19H42LT Manual

Get Poulan PB19H42LT PDF manuals and user guides View all Poulan PB19H42LT manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PB19H42LT manual content summary:

  • Poulan PB19H42LT | User Manual - Page 1
    Do Not Throw Away 02478 OPERATOR'S MANUAL MODEL: PB19H42LT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 402559 10.24.05 TR
  • Poulan PB19H42LT | User Manual - Page 2
    lose control of your tractor. WARNING • Do riding mower-related injuries. These operators should evaluate their ability to operate the riding mower parts and burn. Do not allow the mower deck instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts
  • Poulan PB19H42LT | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan PB19H42LT | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PB19H42LT | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Boot Steering Wheel Adapter (1) Large Flat Washer Steering Wheel Insert Steering Extension Shaft (1) 5/16 Lock Washer (1) Hex Bolt 5/16-18 x 4 (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Knob Key (2) Keys (1) Oil Drain Tube Slope Sheet 5
  • Poulan PB19H42LT | User Manual - Page 6
    hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). INSERT 5/16 HEX BOLT 5/16 LOCK WASHER LARGE FLAT WASHER TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut along
  • Poulan PB19H42LT | User Manual - Page 7
    is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in MAINTENANCE section of this manual for charging instructions). SEAT PAN LABEL NOTE: You may now roll or drive your tractor off the
  • Poulan PB19H42LT | User Manual - Page 8
    DECK LEVELNESS For best cutting results, mower housing should be properly leveled. See"TO LEVEL MOWER HOUSING"in the Service and Adjustments section of this manual. CHECK FOR PROPER POSITION OF ALL BELTS See the figures that are shown for replacing motion and mower blade drive belts in the Service
  • Poulan PB19H42LT | User Manual - Page 9
    tractor or in literature supplied with the product. Learn and understand their meaning. REVERSE NEUTRAL HIGH LOW CHOKE FAST SLOW IGNITION SWITCH ENGINE OFF REVERSE OPERATION SYSTEM (ROS) ENGINE ON ENGINE START PARKING BRAKE MOWER HEIGHT MOWER Models only) Failure to follow instructions
  • Poulan PB19H42LT | User Manual - Page 10
    Standards Institute. ATTACHMENT CLUTCH LEVER - Used to engage the mower blades, or other attachments mounted to your tractor. ATTACHMENT LIFT LEVER - Used to raise and lower the mower deck or other attachments mounted to your tractor. CLUTCH/BRAKE PEDAL - Used for declutching and braking the
  • Poulan PB19H42LT | User Manual - Page 11
    MOWER BLADES - • To stop mower blades,move attachment clutch lever to "DISENGAGED" position. GROUND DRIVE - • To stop ground drive key. Always remove key when leaving tractor to prevent unauthorized use. • Never use months. For healthier and better looking lawns, mow often and after moderate growth
  • Poulan PB19H42LT | User Manual - Page 12
    then keep the deck in proper position to help prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO ADJUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • With mower in desired
  • Poulan PB19H42LT | User Manual - Page 13
    this manual). • To change engine oil, see the Maintenance section in this manual. in storage. To avoid engine problems, the fuel system should be fuel next season. See Storage Instructions for additional information. Never use oil with tractor on level ground. Do not run starter continuously for
  • Poulan PB19H42LT | User Manual - Page 14
    UP • Before driving the unit in cold weather, the transmission should be warmed up as follows: • Be sure the tractor is on level ground "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so that clippings
  • Poulan PB19H42LT | User Manual - Page 15
    Check Mower Levelness Check V-Belts Check instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual
  • Poulan PB19H42LT | User Manual - Page 16
    . BRAKE OPERATION If tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual). TIRES • Maintain proper
  • Poulan PB19H42LT | User Manual - Page 17
    tractor. • Rinse the battery with plain water and dry. • Clean terminals and battery cable ends with wire brush until bright. • Coat terminals with grease or petroleum jelly. • Reinstall battery (See "REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). V-BELTS Check V-belts
  • Poulan PB19H42LT | User Manual - Page 18
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 18
  • Poulan PB19H42LT | User Manual - Page 19
    and secure with small retainer spring. • Install belt onto engine pulley. TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you
  • Poulan PB19H42LT | User Manual - Page 20
    STAY LEVEL SIDE-TO-SIDE. • Remove mower from tractor (See "TO REMOVE MOWER" in this section of this manual). • Work belt off both mandrel pulleys and idler pulleys. • Pull belt away from mower. BELT INSTALLATION - To obtain the best cutting results, the mower housing should be adjusted so that the
  • Poulan PB19H42LT | User Manual - Page 21
    MOTION DRIVE BELT (See Fig. 22) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. BELT REMOVAL • Remove mower (See "TO REMOVE MOWER" in this section of manual). NOTE: Observe entire motion drive belt and
  • Poulan PB19H42LT | User Manual - Page 22
    mower deck height to the lowest position. After above adjustment is made, if the tractor from your local parts dealer. Tire sealant service or replacement, it should be purged after reinstallation and before operating the tractor. See"PURGETRANSMISSION" in the Operation section of this manual
  • Poulan PB19H42LT | User Manual - Page 23
    engne manual. problems, take your tractor to an authorized service center for repair and/or adjustment. INTERLOCKS AND RELAYS Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts
  • Poulan PB19H42LT | User Manual - Page 24
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PB19H42LT | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM starter. 9. Contact an authorized service Clean underside of mower housing. 4. Clean/replace Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PB19H42LT | User Manual - Page 26
    Level mower deck. 5. Check tires for proper air pressure. 6. Replace/sharpen blade. Tighten blade bolt. 7. Clean underside of mower housing. 8. Replace mower drive belt. 9. Reinstall blades sharp edge down. 10. Replace with blades listed in this manual. 11. Clean around mandrels to open vent holes
  • Poulan PB19H42LT | User Manual - Page 27
    parts or labor incurred in replacing parts, any part with the instructions furnished. 4. The Warranty are belts, blades, Service Dept. 1030 Stevens Creek Road Augusta, GA 30907 USA In Canada contact: Electrolux Canada Corp. 7075 Ordan Drive Mississauga, Ontario L5T 1K6 giving the model
  • Poulan PB19H42LT | User Manual - Page 28
    900, 910, 915, 920, 930 transaxles and Series 1100 angle drive and ONEYEAR for all other Peerless products. New Power Train Components instructions contained in an Instruction Manual for the operation of the Power Train Component and parts. The cost of normal maintenance and replacement of service
  • Poulan PB19H42LT | User Manual - Page 29
    29 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan PB19H42LT | User Manual - Page 30
    the following information: a. Model Number/Manufacturer's I.D. Number b. Description of part. For Techical Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
OPERATOR'S MANUAL
MODEL:
PB19H42LT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
402559
10.24.05
TR
Printed in U.S.A.
02478