Poulan PO14542B User Manual

Poulan PO14542B Manual

Get Poulan PO14542B PDF manuals and user guides View all Poulan PO14542B manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan PO14542B manual content summary:

  • Poulan PO14542B | User Manual - Page 1
    OWNER'S MANUAL MODEL NO. PO14542B 14.5 HP 42 Inch Lawn Tractor For Parts and Service, contact our authorized distributor: call 1-800-849-1297 For Technical Assistance: call 1-800-829-5886 176038 11.21.00 RD PRINTED IN U.S.A.
  • Poulan PO14542B | User Manual - Page 2
    for Ride-On Mowers IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. I. GENERAL OPERATION • Read, understand, and follow all instructions in the manual and
  • Poulan PO14542B | User Manual - Page 3
    Operation Practices for Ride-On Mowers • Be sure traction with the ground and cause you to lose control of your tractor. CAUTION: In order to prevent accidental starting when setting up, transporting SCHEDULE 14 SERVICE AND ADJUSTMENTS 19-23 STORAGE 24 TROUBLESHOOTING 25-26 REPAIR PARTS 28-43
  • Poulan PO14542B | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service centre/department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan PO14542B | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Steering Wheel Adapter Seat Steering Extension Shaft Steering Wheel Insert Steering Boot (1) Large Flat Washer (1) Lockwasher 3/8 (1) Locknut 5/16-18 (1) Hex Bolt 3/8-16 x 1 (1) Washer
  • Poulan PO14542B | User Manual - Page 6
    hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). INSERT 3/8 HEX BOLT 3/8 LOCK WASHER LARGE FLAT WASHER TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut, from
  • Poulan PO14542B | User Manual - Page 7
    service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in CUSTOMER RESPONSIBILITIES section of this manual for charging instructions slot and pull seat towards rear of tractor. • Pivot seat and pan forward
  • Poulan PO14542B | User Manual - Page 8
    See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see that the brake is properly adjusted. See
  • Poulan PO14542B | User Manual - Page 9
    symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON OVER TEMP LIGHT FUEL CHOKE MOWER HEIGHT PARKING BRAKE LOCKED UNLOCKED
  • Poulan PO14542B | User Manual - Page 10
    . Save this manual for future reference. AMMETER THROTTLE/CHOKE CONTROL ATTACHMENT CLUTCH LEVER IGNITION SWITCH LIGHT SWITCH LIFT LEVER PLUNGER ATTACHMENT LIFT LEVER CLUTCH/BRAKE PEDAL GEARSHIFT LEVER MOWER DECK HEIGHT ADJUSTMENT POSITIONS PARKING BRAKE FIG. 4 Our tractors conform to the
  • Poulan PO14542B | User Manual - Page 11
    TRACTOR TO A COMPLETE STOP BEFORE SHIFTING OR CHANGING GEARS. FAILURE TO DO SO WILL SHORTEN THE USEFUL LIFE OF YOUR TRANSAXLE. TO ADJUST MOWER CUTTING to over 3 inches during hot months. For healthier and better looking lawns, mow often and after moderate growth. • For best cutting performance,
  • Poulan PO14542B | User Manual - Page 12
    prevent scalping in most terrain conditions. • Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO ADJUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • With mower in desired height of cut position, gauge wheels should be
  • Poulan PO14542B | User Manual - Page 13
    in storage. To avoid engine problems, the fuel system should be fuel next season. See Storage Instructions for additional information. Never use engine Service and Adjustments section of this manual. MOWING TIPS • Tire chains cannot be used when the mower housing is attached to tractor. • Mower
  • Poulan PO14542B | User Manual - Page 14
    receive full value from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season
  • Poulan PO14542B | User Manual - Page 15
    may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. OPERATOR PRESENCE SYSTEM Be sure operator presence and interlock systems are working properly. If your tractor does not function as described, repair the problem immediately. • The engine should not
  • Poulan PO14542B | User Manual - Page 16
    range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tractor is on level surface. • Oil will drain more freely overfill. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual. • Use gauge on oil fill cap/dipstick for checking level.
  • Poulan PO14542B | User Manual - Page 17
    from overheating. • Remove oil fill cap/dipstick. • Remove hex bolts from blower housing and lift housing off engine. • Cover oil fill opening to prevent over cartridge. • Reinstall cover and secure with knob(s). TO SERVICE CARTRIDGE • Remove cartridge nut. • Carefully remove cartridge to prevent
  • Poulan PO14542B | User Manual - Page 18
    type and gap setting are shown in "PRODUCT SPECIFICATIONS" section of this manual. IN-LINE FUEL FILTER (See Fig. 15) The fuel filter should type wax. We do not recommend using a garden hose to clean your tractor unless the electrical system, muffler, air filter and carburetor are covered to keep
  • Poulan PO14542B | User Manual - Page 19
    side of tractor. • Lower lift lever to its lowest position. • Install mower in reverse order of removal instructions. SMALL RETAINER SPRING CLUTCH SPRING RETAINER SPRING ANTI-SWAY BAR COLLAR SUSPENSION ARMS SQUARE HOLE ENGINE PULLEY FRONT LINK RETAINER SPRINGS (BOTH SIDES) HOUSING GUIDE LARGE
  • Poulan PO14542B | User Manual - Page 20
    • Install new belt in reverse order of removal. • Make sure belt is in all pulley grooves and inside all belt guides. • Install mower in reverse order of removal instructions. Check adjustment on right side of tractor. Measure distance "D" directly in front and behind the mandrel at bottom edge of
  • Poulan PO14542B | User Manual - Page 21
    MOTION DRIVE BELT (See Fig. 23) Park the tractor on level surface. Engage parking brake. For assistance, there is a belt installation guide decal on bottom side of left footrest. • Remove mower (See "TO REMOVE MOWER" in this section of this manual.) • Remove belt from stationary idler and clutching
  • Poulan PO14542B | User Manual - Page 22
    SERVICE AND ADJUSTMENTS POSITIVE TERMINAL NEGATIVE TERMINAL KEPS NUT HEX BOLT RELAYS Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts section. TO REPLACE FUSE Replace with 20
  • Poulan PO14542B | User Manual - Page 23
    THE FACTORY HIGH SPEED SETTING CAN BE DANGEROUS. IF YOU THINK THE ENGINE-GOVERNED HIGH SPEED NEEDS ADJUSTING, CONTACT YOUR NEAREST AUTHORIZED SERVICE CENTER/ DEPARTMENT, WHICH HAS PROPER EQUIPMENT AND EXPERIENCE TO MAKE ANY NECESSARY ADJUSTMENTS. IDLE SPEED SCREW THROTTLE LEVER IDLE MIXTURE VALVE
  • Poulan PO14542B | User Manual - Page 24
    TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Customer Responsibilities section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan PO14542B | User Manual - Page 25
    TROUBLESHOOTING POINTS PROBLEM 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/ Service Adjustments section. 15. Contact an authorized service center/department. Excessive vibration 1. Worn, bent or loose blade. 2. Bent blade mandrel. 3. Loose/damaged part
  • Poulan PO14542B | User Manual - Page 26
    TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Engine continues to run when operator leaves seat with attachment clutch engaged 1. Faulty operator-safety presence control system. 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department.
  • Poulan PO14542B | User Manual - Page 27
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B SCHEMATIC RED BATTERY BLACK A AMMETER (OPTIONAL) RED WHITE RED S BM G A1 L A2 CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 27
  • Poulan PO14542B | User Manual - Page 28
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B ELECTRICAL 21 22 42 24 41 43 27 27 26 27 27 25 33 30 40 16 16 8 2 1 27 D.C. AMPERES 45 52 28 29 28
  • Poulan PO14542B | User Manual - Page 29
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B ELECTRICAL KEY PART NO. NO. 1 144925 2 74760412 8 156417 16 153664 21 166181 22 4152J 24 4799J 25 146147 26 175158 27 73510400 28 4207J 29 121305X 30 175566
  • Poulan PO14542B | User Manual - Page 30
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B CHASSIS AND ENCLOSURES 17 30 24 212 29 25 26 31 3 208 11 18 25 26 209 9 15 209 24 5 5 58 12 28 53 51 52 55 57 209 8 54 209 26 33 10 2 206 3 35 6 16 37 3 1 13 145 37 35 3 34 208 38 26 3 38 3 30
  • Poulan PO14542B | User Manual - Page 31
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B CHASSIS AND ENCLOSURES KEY PART NO. NO. DESCRIPTION 1 169831 Chassis 2 169061 Drawbar 3/4 37 17490508 Screw Thdrol 5/16-18 x 1/2 Tyt 38 169834 Bracket Asm. Pivot Mower Rear 51 73800400 Nut Lock Hex W/Ins. 1/4-20 52 19091416 Washer 9/32 x 7/8
  • Poulan PO14542B | User Manual - Page 32
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B DRIVE 89 57 90 61 51 19 42 115 19 42 31 88 87 86 81 59 83 84 42 82 61 85 10 13
  • Poulan PO14542B | User Manual - Page 33
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B DRIVE KEY PART NO. NO. 1 ------ 2 146682 3 123666X 4 12000028 Bolt, Hex 7/16-20 x 4 Grade 5 Washer, Lock, Hvy Hlcl Spring 7/16 Keeper Belt Engine Flproof Guide Belt Dr Mower Rh Washer 13/32 X 1-1/4 X 12 Ga Spacer Axle Washer 25/32 X 1 1/4 X 16 Ga E
  • Poulan PO14542B | User Manual - Page 34
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B STEERING ASSEMBLY 38 63 11 39 1 37 62 44 51 41 42 37 36 54 8 27 17 18 19 23 22 11 66 40 29 79 80 25 68 29 82 15 15 29 15 46 8 6 9 2 7 9 5 3 40 68 67 67 47 13 65 85 85 32 11 26 67 46 8 6 9 47 7 9 5 4 43 28 10 30 34 43 6 8
  • Poulan PO14542B | User Manual - Page 35
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B STEERING ASSEMBLY KEY PART Lt 18 57079 Washer Thrust 515x 750x 033 19 160395 Support Shaft 22 165857 Screw Hex Wsh Hd Torx 23 165851 Hex 5/16-18 Unc P 62 167902 Kit Steering Assembly Service 63 74780616 Bolt Fin Hex 3/8-16unc x Gr. 5 65 160367
  • Poulan PO14542B | User Manual - Page 36
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B ENGINE 2 3 72 1 62 81 13 4 78 38 32 14 16 44 78 46 33 31 37 40 33 45 29 23 OPTIONAL EQUIPMENT Spark Arrester 36
  • Poulan PO14542B | User Manual - Page 37
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B ENGINE KEY PART NO. NO. DESCRIPTION 1 170551 2 17720410 3 ------ 4 137352 Throt /Ch Flag Screw Hex Thd Cut 1/4-20x5/8 T Engine Briggs Model 287707 (Order Parts From Engine Manufacturer) Muffler Exhaust B&S Lt Gasket 1 313 Id Tin Plated Tube Drain Oil
  • Poulan PO14542B | User Manual - Page 38
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B SEAT ASSEMBLY 1 8 9 14 7 10 24 26 16 15 5 25 23 13 17 12 8 9 7 2 5 6 22 21 4 3 KEY PART NO. NO. 1 140116 2 140551 3 71110616 4 19131610 5 145006 6 73800600 7 124181X 8 17000616 9 19131614 10 174894 12 121246X 13 121248X DESCRIPTION Seat
  • Poulan PO14542B | User Manual - Page 39
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B DECALS 2 3 9 12 4 10 12 16 1 6 11 20 14 KEY PART NO. NO. 1 157163 2 158168 3 158037 4 158038 6 170563 9 158166 10 157140 11 101892X DESCRIPTION Decal Instruction Operat English Decal Ins Strg Wh Decal Hood Rh Decal Hood Lh Decal, Warning
  • Poulan PO14542B | User Manual - Page 40
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B MOWER LIFT 7 8 5 11 19 13 13 4 6 12 13 31 32 19 13 31 32 3 1 2 6 5 4 20 15 17 18 20 16 20 20 15 40
  • Poulan PO14542B | User Manual - Page 41
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B MOWER LIFT KEY PART NO. NO. 1 159460 2 159471 3 105767X 4 12000002 5 19211621 6 120183X 7 109413X 8 124526X 11 139865 12 139866 13 4939M 15 173288 16 73350800 17 130171 18 73800800 19
  • Poulan PO14542B | User Manual - Page 42
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B MOWER DECK 158 151 152 67 157 156 153 155 159 46 153 154 68 40 37 36 40 143 144 45 150 40 37 145
  • Poulan PO14542B | User Manual - Page 43
    REPAIR PARTS TRACTOR - - MODEL NUMBER PO14542B MOWER DECK KEY PART NO. NO. DESCRIPTION 1 165892 Mower Deck Assembly, 42" 2 72140506 Bolt 3 139888 Bolt, Shoulder 5/16-18 UNC 53 131845 Arm Assembly, Pad, Brake KEY PART NO. NO. 54 133943 55 155046 56 165723 59 141043 67 106932X 68 144959
  • Poulan PO14542B | User Manual - Page 44
    SERVICE NOTES 44
  • Poulan PO14542B | User Manual - Page 45
    option, without charge for parts or labor incurred in replacing parts, any part which we find to be . Battery must be maintained in accordance with the instructions furnished. 4. The Warranty period for any products used the product to an authorized service dealer. Should you have any unanswered
  • Poulan PO14542B | User Manual - Page 46
    instructions contained in an Instruction Manual for the operation of the Power Train Component and parts. The cost of normal maintenance and replacement of service legal rights which vary from state to state. E. No Dealer Warranty Tecumseh neither assumes nor authorizes any other person, natural
  • Poulan PO14542B | User Manual - Page 47
    FOR SIGHTING SLOPES FOR SAFE OPERATION SIGHTING GUIDE CUT THIS IOSUAT1O5°NSDLOOTPTEED LINES ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE. 15° MAX. 47 Operate your Tractor up and down the face of slopes (not greater than 15°), never across the
  • Poulan PO14542B | User Manual - Page 48
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
OWNER'S
MANUAL
MODEL NO. PO14542B
14.5 HP 42 Inch
Lawn Tractor
For Parts and Service, contact our authorized distributor: call 1-800-849-1297
For Technical Assistance:
call 1-800-829-5886
176038
11.21.00
RD
PRINTED IN U.S.A.