Poulan PR675Y22RHPE Owner Manual
Poulan PR675Y22RHPE Manual
 |
View all Poulan PR675Y22RHPE manuals
Add to My Manuals
Save this manual to your list of manuals |
Poulan PR675Y22RHPE manual content summary:
- Poulan PR675Y22RHPE | Owner Manual - Page 1
TROUBLESHOOTING (continued) See appropriate section in manual unless directed to an authorized Service Center. PROBLEM CAUSE CORRECTION Grass catcher 1. Cutting height too low. not filling 2. Lift on blade worn off. (If so equipped) 3. Catcher not venting air. 1. Raise cutting height. 2. - Poulan PR675Y22RHPE | Owner Manual - Page 2
at all times. • Only allow responsible individuals, who are familiar with the instructions, to operate the machine. • Clear the area of objects such as rocks, support while mowing. TROUBLESHOOTING See appropriate section in manual unless directed to an authorized Service Center. PROBLEM CAUSE - Poulan PR675Y22RHPE | Owner Manual - Page 3
and/or dirt in your gasoline will cause problems. • If possible, store your unit indoors and in the Maintenance section of this manual). 34 SAFETY RULES • Do not . • See manufacturer's instructions for proper operation and Vibration is generally a warning of trouble. • Always wear eye protection - Poulan PR675Y22RHPE | Owner Manual - Page 4
problems you cannot easily remedy, please contact your nearest authorized service center. They have competent, well trained technicians and the proper tools to service or repair this unit. • Read the SAFETY RULES and this Operator's Manual for storage. ON 18" HI-VAC MODELS ONLY: 1. Loosen the two (2) - Poulan PR675Y22RHPE | Owner Manual - Page 5
SERVICE AND ADJUSTMENTS 4. Remove engine. See the ADJUSTMENT section of your engine manual for further instructions. ENGINE SPEED The engine speed has been factory RIGHT HAND SIDE "QUICK RELEASE" HANDLES (ON 18" HI-VAC MODELS ONLY) • Move height adjustment lever forward to raise mower to highest - Poulan PR675Y22RHPE | Owner Manual - Page 6
comfort. Refer to "ADJUST HANDLE" in the Service Lower handle and Adjustments section of this manual. NOTE: For shipping purposes, the rear wheels on plug. 21" (53cm) HI-VAC MODELS: Belt retainer Belt keepers Drive belt 22PLUS REAR WHEEL DRIVE MODELS: 1. Remove screws securing rear baffle. - Poulan PR675Y22RHPE | Owner Manual - Page 7
into loop of rope guide. • Tighten T-knob. INSTALL REAR WHEELS ("HIGH WHEEL" MOWERS ONLY) Some high wheel models require washers which will manual. Look at the different grass catcher illustrations that follow. Determine which type of grass catcher you have and follow the appropriate instructions - Poulan PR675Y22RHPE | Owner Manual - Page 8
plug. Spark plug Catcher frame hook 8 Boot SERVICE AND ADJUSTMENTS REAR WHEEL DRIVE MODELS: MODELS WITH IDLER ASSEMBLY: • Disconnect spark plug wire arm spring assembly • Turn lawn mower on its side. See engine manual for proper direction of turning over the engine. NOTE: Before tipping lawn - Poulan PR675Y22RHPE | Owner Manual - Page 9
SERVICE AND ADJUSTMENTS TO REMOVE / REPLACE DRIVE BELT FRONT WHEEL DRIVE MODELS: "STANDARD" OR "DUAL BAIL" MODELS: • Remove drive cover. Remove belt from gearcase pulley by pushing down on pulley and rolling belt off it. • Turn lawn mower on its side. See engine manual for proper direction of - Poulan PR675Y22RHPE | Owner Manual - Page 10
ON position. FAST SLOW TO ADJUST CUTTING HEIGHT ALL MODELS: Adjust cutting height to suit your requirements. Medium 10 SERVICE AND ADJUSTMENTS CAUTION: Before performing any service or adjustments HEIGHT" in the Operation section of this manual. REAR DEFLECTOR The rear deflector, attached - Poulan PR675Y22RHPE | Owner Manual - Page 11
leaks are present, start engine (as described in the Operation section of this manual) and let engine run until the underside of the lawn mower is clean. life. 8. Start engine (as described in the Operation section of this manual) and let engine run for a full minute to remove excess water from - Poulan PR675Y22RHPE | Owner Manual - Page 12
. IN-LINE FUEL FILTER (KOHLER or B&S PRO / ENDURANCE ENGINES ONLY) The fuel filter should filler hole or to "FULL" line on dipstick on models so SPARK PLUG Replace spark plug at the beginning of Service air cleaner more often under dusty conditions. See the maintenance section of your engine manual - Poulan PR675Y22RHPE | Owner Manual - Page 13
bolt, pin, or a cone balancer. (When using a cone balancer, follow the instructions supplied with balancer.) NOTE: Do not use a nail for balancing blade. The lobes do not turn freely, contact your nearest authorized service center. 18" (45cm) HI-VAC MODELS ONLY: 1. Remove hubcaps (if equipped) and - Poulan PR675Y22RHPE | Owner Manual - Page 14
if equipped) Grass catcher frame hook Full bag indicator window (if equipped) Open mulcher door Discharge deflector "REAR DOOR PROP" (IF EQUIPPED) (22PLUS MODELS ONLY) NOTE: Rear door will remain open until operator presence control bar is held down to the handle. CAUTION: Do NOT force rear door - Poulan PR675Y22RHPE | Owner Manual - Page 15
instructed in this manual. Some adjustments will need to be made periodically to properly maintain your unit. All adjustments in the Service and Adjustments section of this manual catcher TO EMPTY GRASS CATCHER (REAR DISCHARGE AND MULTI-CUT MODELS) • Simply open rear door and lift grass catcher up - Poulan PR675Y22RHPE | Owner Manual - Page 16
when emptying; it will cause unnecessary wear. Handle 21" (53cm) HI-VAC MODELS: Your lawn mower was shipped ready to be used as a mulcher. To convert up grass and trash. See "CLEANING" in the Maintenance section of this manual. • The special mulching blade will recut the grass clippings many times - Poulan PR675Y22RHPE | Owner Manual - Page 17
on models equipped with choke feature). • If your mower has a primer, to start a cold engine, push primer as many times as instructed in the engine manual packed the fuel system of an engine while in storage. To avoid engine problems, the fuel system should be emptied before storage of 30 days or - Poulan PR675Y22RHPE | Owner Manual - Page 18
NOTE: If after releasing the drive control the mower will not roll backwards, push the mower forward slightly to disengage drive wheels. FRONT WHEEL DRIVE MODELS ONLY: • To keep drive control engaged when turning corners, push down on the handle to lift the front wheels off the ground while turning
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
 |
 |
Grass catcher
1.
Cutting height too low.
1. Raise cutting height.
not filling
2. Lift on blade worn off.
2. Replace blade.
(If so equipped)
3. Catcher not venting air.
3. Clean grass catcher.
Hard to push
1. Grass is too high or wheel
1. Raise cutting height.
height is too low.
2. Rear of lawn mower
2. Raise rear of lawn mower
housing or cutting blade
housing one (1) setting
dragging in grass.
higher.
3. Grass catcher too full.
3. Empty grass catcher.
4. Handle height position not
4. Adjust handle height to suit.
right for you.
Loss of drive
1. Belt wear.
1. Check/replace drive belt.
or slowing of
2. Belt off of pulley.
2. Check/reinstall drive belt.
drive speed
3. Drive cable worn or broken.
3. Replace drive cable.
4. “Loose” drive control system.
4. Adjust drive control.
PROBLEM
CAUSE
CORRECTION
See appropriate section in manual unless directed to an authorized
Service Center.
TROUBLESHOOTING
(continued)
SELF-PROPELLED ROTARY
LAWN MOWER
115 58 78-27 Rev. 4
04.23.15
BY
Printed in U.S.A.