Viking VQGI5361 Installation / Use and Care Instructions
Viking VQGI5361 Manual
 |
View all Viking VQGI5361 manuals
Add to My Manuals
Save this manual to your list of manuals |
Viking VQGI5361 manual content summary:
- Viking VQGI5361 | Installation / Use and Care Instructions - Page 1
Installation/ Use & Care MANUAL 5 SERIES Outdoor Gas Grills VQGI5301, VQGI5361, VQGI5421, VQGI5541 VQGFS5301, VQGFS5361, VQGFS5421, VQGFS5541 - Viking VQGI5361 | Installation / Use and Care Instructions - Page 2
away from walkways to avoid tripping hazard. • Do not repair or replace any part of the grill unless specifically recommended in this manual. Other service should be performed by a qualified technician. • If the grill is installed by a professional installer or technician, be sure that he/she shows - Viking VQGI5361 | Installation / Use and Care Instructions - Page 3
. THIS PRODUCT IS DESIGNED FOR OUTDOOR USE ONLY. Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death. Read this manual thoroughly before installation, use, or servicing of this product. DANGER IF YOU SMELL GAS: 1. Shut off all gas supply - Viking VQGI5361 | Installation / Use and Care Instructions - Page 4
from walkways to avoid creating a tripping hazard. 4. Do not repair or replace any part of the grill unless specifically recommended in this manual. Other service should be performed by a qualified technician. 5. All gas lines must have a shut-off that is readily and easily accessible. Be sure the - Viking VQGI5361 | Installation / Use and Care Instructions - Page 5
ProSear™ Burner 29 Using the Rotisserie Burner 30 Using the Smoker Box 31 CLEANING YOUR GRILL 32 TROUBLESHOOTING YOUR GRILL 34 Potential Problems 35 CONTACTING CUSTOMER SERVICE 38 VIKING RANGE, LLC OUTDOOR WARRANTY 39 WIRING SCHEMATICS 40 30 Rotisserie Grill 40 36 & 42 Rotisserie - Viking VQGI5361 | Installation / Use and Care Instructions - Page 6
incurred in transit. (See INDEX: "Obtaining Service" for further details.) CONCEALED LOSS OR front control panel (at your back when grilling), supporting the proper front-to-rear airflow. Built-in hitting the back of the grill directly may cause problems, as well as wind blowing along the hood gap - Viking VQGI5361 | Installation / Use and Care Instructions - Page 7
it from the bottom. 3" (7.6 cm) When using the insulated jacket in a combustible enclosure, the jacket must be supported from the bottom by a ledge on each side or a full deck beneath the jacket. (See INDEX: "Gas Requirements") Pay special attention to the provisions shown - Viking VQGI5361 | Installation / Use and Care Instructions - Page 8
INSTALLATION The guides, measurements and dimensions detailed below are designated to assist you with planning your outdoor kitchen. NOTE: Due to continuing product innovation, specifications are subject to change without notice. IMPORTANT: Please reference the Care & Use / Installation manual for - Viking VQGI5361 | Installation / Use and Care Instructions - Page 9
SPECIFICATIONS & INSTALLATION COUNTER TOP NOTCH DETAIL Only required if island counter top overhangs the face of the island A 5" (12.7 cm) 4.5" (11.4 cm) C 3" (7.6 cm) B MODEL-SPECIFIC BTU OUTPUTS & MAX. RUNS FOR APPLIANCES MODEL-SPECIFIC BTU OUTPUTS MODEL H BURNER (Btu) ROTISSERIE (Btu) - Viking VQGI5361 | Installation / Use and Care Instructions - Page 10
DIMENSIONS VQGI5301 303"0" (76.2 cm) 9" (22.9 c9m" ) 2½1/2""(6.4 cm) VQGFS5301 11" (27.911cm" ) 1111""(27.9 cm) REAR R22e1½/a2r""(MM6.aA4nNcifmIoFl)Od LD LocLaOtiCoAnTION 253/16" (26543./01c6m" ) 1¾" (31614.481½/c2"m" ) (4.4 cm) 13/4" 21½" (522415.613//2c8""m) (2265.73/c8m" ) 277/8" (7207.87 - Viking VQGI5361 | Installation / Use and Care Instructions - Page 11
DIMENSIONS VQGI5361 36" (91.4 cm) 9" (22.9 cm) 11/8" (2.9 cm) VQGFS5361 11" (27.9 cm) 2½" (6.4 cm) Rear Manifold Location 11" (27.9 cm) 1¾" (4.4 cm) 23½" (59.7 cm) 147/8" (37.8 cm) 97/8" (25.1 cm) 19" (48.3 cm) 227/8" (58.1 cm) 253/8" (64.5 cm) 3" (7.6 cm) 61¾" (108.0 cm) 42½" (91.4 cm) 36" - Viking VQGI5361 | Installation / Use and Care Instructions - Page 12
DIMENSIONS 42" (106.7 cm) 9" (22.9 cm) 2½" (6.4 cm) VQGFS5421 11" (27.9 cm) 11" (27.911cm" ) 2½" (6.4 cm) Rear Manifold Location 253/16" (6245.03/c16m" ) 1¾" (4.4 cm) (31614.481½/c2"m" ) 13/4" 21½" (54.6 cm) (6245.533//c88m"" ) 277/8" 7 (70.8 cm) (120611.07/½2c""m) 3" 3" (7.6 cm) 36" ( - Viking VQGI5361 | Installation / Use and Care Instructions - Page 13
DIMENSIONS VQGI5541 54" (137.2 cm) 9" (22.9 cm) 2½" (6.4 cm) 11" (27.9 cm) 2½" (6.4 cm) Rear Manifold Location 11" (27.911cm" ) 1¾" (4.4 cm) 25½" (6245.83/c16m" ) (311744.6131//c126m"") 13/4" 21½" (54.6 cm) (2265.733//c88m"" ) 277/8" 7 (70.8 cm) (1201501.9/3/2c1"6m" ) 3" 3" (7.6 cm) - Viking VQGI5361 | Installation / Use and Care Instructions - Page 14
may weigh over 500 pounds. WARNING: EXCESSIVE WEIGHT HAZARD! Use two or more people to move or install this unit. Failure to follow this instruction can result in back or other personal injuries. INTERIOR PACKING Viking Range, LLC uses sturdy tie-down cables and straps to ensure your grill arrives - Viking VQGI5361 | Installation / Use and Care Instructions - Page 15
UNPACKING & ASSEMBLY ...continued Heat Shield Removed, Orifice/Venturi Position Oirniftiocethaellvthenetwuraiy Legs in slot Burner sitting flat Inside View, Orifice all the way into venturi | INSTALLATION / USE & CARE 15 - Viking VQGI5361 | Installation / Use and Care Instructions - Page 16
GAS CONNECTIONS WARNING NEVER CONNECT A GAS LINE DIRECTLY TO THE GRILL. A PRESSURE REGULATOR MUST BE INSTALLED ON ALL GAS EQUIPMENT. ALL LOCAL CODES REQUIRE THAT THE PRESSURE REGULATOR SUPPLIED WITH YOUR GRILL IS USED. REMOVING OR FAILING TO INSTALL THE PRESSURE REGULATOR CAN RESULT IN FIRE AND - Viking VQGI5361 | Installation / Use and Care Instructions - Page 17
GAS CONNECTIONS ...continued For freestanding units using natural gas, using a metal flex hose is recommended. This is available at your local hardware store or from your dealer. LP GAS Grills set up for LP gas come equipped with an LP hose/ regulator assembly for connection to a standard 20 lb. LP - Viking VQGI5361 | Installation / Use and Care Instructions - Page 18
on either Natural gas or LPG. These kits should be installed by a qualified technician. The kits come with complete installation instructions. These instructions should be read completely and fully understood before installing the conversion kit. BUILT-IN SIDE BURNER INSTALLATION • Shut off the - Viking VQGI5361 | Installation / Use and Care Instructions - Page 19
is recommended that the transformer be located below the grill in a readily accessible location. Be sure to provide adequate access to facilitate service if the transformer or connections should need future maintenance. If the electrical system fails to operate, a connection may have come loose in - Viking VQGI5361 | Installation / Use and Care Instructions - Page 20
FINAL CHECKS LEAK TESTING LOW HEAT BURNER ADJUSTMENT DANGER! To prevent fire or explosion hazard, DO NOT smoke or allow any potential source of ignition (sparks, electrical arcing, etc) in the area while performing a leak test. Leak tests should be conducted outdoors only. Never conduct a leak - Viking VQGI5361 | Installation / Use and Care Instructions - Page 21
Finally, for safety and for proper use & care, you must leave this manual with the owner. Make sure you advise them to keep it for future : BE EXTREMELY CAREFUL AROUND HOT BURNERS AND OTHER GRILL PARTS. Preferred Customer Service 888-845-4641 • Lift out the burner, loosen the set screw and - Viking VQGI5361 | Installation / Use and Care Instructions - Page 22
you are having. Please feel free to contact us with any questions or problems, or just to share a new recipe. Please include the model number will provide years of troublefree service. Should your grill change ownership, please make sure that the new owner receives this manual. Thanks again for your - Viking VQGI5361 | Installation / Use and Care Instructions - Page 23
IMPORTANT SAFETY PRECAUTIONS PLEASE REVIEW THESE IMPORTANT SAFETY PRECAUTIONS BEFORE YOU USE YOUR GRILL. 1. NEVER LEAVE THE GRILL UNATTENDED WHILE COOKING. 2. Ensure all tie-down wires have been removed from the burners. 3. Always use caution when operating the grill in a windy area. (See INDEX: " - Viking VQGI5361 | Installation / Use and Care Instructions - Page 24
GRILLING IN WINDY CONDITIONS Outdoor grills create more heat than interior kitchen ranges. That's how they sear and grill steaks and other foods. These high-performance burners require a constant, steady supply of fresh air to mix with the fuel. Your grill pulls air in through the front and vents - Viking VQGI5361 | Installation / Use and Care Instructions - Page 25
USING YOUR GRILL Grilling requires high heat for searing and low, controlled heat for slow cooking. Thinner cuts of food are often cooked at a "HI" heat setting with the lid open. On the other hand, large, thick pieces of meat or poultry are often first seared at the high setting and then grilled - Viking VQGI5361 | Installation / Use and Care Instructions - Page 26
is securely connected and leak tested. (See INDEX: "Cylinder Retention Instructions" for details.) LIGHTING YOUR GRILL • ... you know where the main grill. The main burners must sit level and firmly on the burner mounting support frame. (See INDEX: "Unpacking & Assembly" for further details.) • - Viking VQGI5361 | Installation / Use and Care Instructions - Page 27
to "LITE". If the burner doesn't light within 5 seconds turn the knob off and wait 5 minutes before attempting to light it again. ProSear™ Burner MANUAL LIGHTING If a burner doesn't light after several attempts, it can be match lit using the lighting rod stored in the drip tray. Match-lighting - Viking VQGI5361 | Installation / Use and Care Instructions - Page 28
BASIC GRILLING Then close the hood and allow the grill to heat for 10 to 15 minutes. Once you've reached your desired pre-heat temperature, turn off the burners that you won't be using to cook your food. WARNING! DO NOT LEAVE THE GRILL UNATTENDED DURING THE PRE-HEAT CYCLE OR AT ANY TIME WHILE THE - Viking VQGI5361 | Installation / Use and Care Instructions - Page 29
USING THE ProSear™ BURNER heated because food particles and grease dripping onto a cold ProSear™ burner can clog the tiny ports and damage the burner. For the same reason you should minimize water spills on the ProSear™ burner and should not use water to control flareups. Take special care to - Viking VQGI5361 | Installation / Use and Care Instructions - Page 30
Rotisserie cooking provides an even delivery of heat to your foods. It has no equal. The constant rotation not only cooks foods evenly, it also self bastes. As juices rise to the surface of the food, they naturally flow around it as it rotates. And, by moving the burner out from beneath the food, - Viking VQGI5361 | Installation / Use and Care Instructions - Page 31
control knob in for at least 60 seconds, the burner still will not stay lit when releasing the control knob, call for service. (See INDEX: "Obtaining service" for further details.) Shut off all other burners while using the rotisserie burner. USING THE SMOKER BOX Professional chefs far and wide - Viking VQGI5361 | Installation / Use and Care Instructions - Page 32
soapy water or an oven-style cleaning product and re-install. When using an oven-style cleaning product be sure to carefully follow the manufacturer's instructions. Many of these cleaners are toxic and can damage the stainless steel finish if not used properly. Also, check the tray after rain. If - Viking VQGI5361 | Installation / Use and Care Instructions - Page 33
CLEANING YOUR GRILL ...continued WARNING DO NOT ALLOW EXCESS GREASE OR LIQUIDS TO ACCUMULATE IN THE DRIP TRAY AS THIS MAY CREATE A FIRE HAZARD. NEVER USE GRILL WITHOUT DRIP TRAY PROPERLY INSTALLED. GRILLING RACKS The easiest way to clean the grill racks is to do so immediately after turning off the - Viking VQGI5361 | Installation / Use and Care Instructions - Page 34
shaken out. Do not touch the ceramic surface. BEFORE YOU CALL FOR SERVICE Please check a few things before calling for service: • Is there fuel supplied to the grill? • Is the main the above items, review the trouble-shooting list below before calling for service. | 34 INSTALLATION / USE & CARE - Viking VQGI5361 | Installation / Use and Care Instructions - Page 35
PROBLEMS GRILL WON'T LIGHT First, confirm that the grill is getting electricity by turning on the lights, then: Check The Igniters If the burner will light with a match, then the igniter may not be functioning correctly. Call for service don't glow, proceed with troubleshooting or match-light the - Viking VQGI5361 | Installation / Use and Care Instructions - Page 36
POTENTIAL PROBLEMS ...continued REPLACE any damaged supply lines. • Check the Regulator Make sure that the regulator & hose assembly is the one designed for and supplied with your - Viking VQGI5361 | Installation / Use and Care Instructions - Page 37
the problem is being caused by location. If the grill is subject to high winds, reposition it to provide some protection. • Check the Flame If, after holding the control knob in for at least 60 seconds, the burner still will not stay lit when releasing the control knob, call for service. (See - Viking VQGI5361 | Installation / Use and Care Instructions - Page 38
describe the problem that you are having. If you are unable to obtain the name of an authorized service agency, or if you continue to have service problems, contact If service requires installation of parts, use only authorized parts to ensure protection under the warranty. KEEP THIS MANUAL FOR - Viking VQGI5361 | Installation / Use and Care Instructions - Page 39
damage or injury resulting from use in a commercial application. To support the manufacturing quality of its appliance's Viking will provide a full or premium rates shall not be covered by the warranty. To obtain warranty service contact Viking Range LLC Customer Care at 1-888-845-4641. Please have - Viking VQGI5361 | Installation / Use and Care Instructions - Page 40
WIRING SCHEMATICS 30" ROTISSERIE GRILL | 40 INSTALLATION / USE & CARE - Viking VQGI5361 | Installation / Use and Care Instructions - Page 41
WIRING SCHEMATICS 36" & 42" ROTISSERIE GRILL | INSTALLATION / USE & CARE 41 - Viking VQGI5361 | Installation / Use and Care Instructions - Page 42
WIRING SCHEMATICS 54" ROTISSERIE GRILL | 42 INSTALLATION / USE & CARE - Viking VQGI5361 | Installation / Use and Care Instructions - Page 43
| INSTALLATION / USE & CARE 43 - Viking VQGI5361 | Installation / Use and Care Instructions - Page 44
068958-000B EN Viking Range, LLC 111 Front Street Greenwood, Mississippi 38930 USA (662) 455-1200 For product information, call 1-888-(845-4641) or visit our web site at vikingrange.com (022820)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
 |
 |
Installation/
Use & Care
MANUAL
5 SERIES
Outdoor Gas Grills
VQGI5301, VQGI5361, VQGI5421, VQGI5541
VQGFS5301, VQGFS5361, VQGFS5421, VQGFS5541