Viking VQGSB5131 Installation / Use and Care Instructions
Viking VQGSB5131 Manual
 |
View all Viking VQGSB5131 manuals
Add to My Manuals
Save this manual to your list of manuals |
Viking VQGSB5131 manual content summary:
- Viking VQGSB5131 | Installation / Use and Care Instructions - Page 1
Installation/ Use & Care MANUAL 5 SERIES GAS SIDE BURNER ACCESSORIES VQGSB5131 VQGPB5201 - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 2
. THIS PRODUCT IS DESIGNED FOR OUTDOOR USE ONLY. Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death. Read this manual thoroughly before installation, use, or servicing of this product. DANGER IF YOU SMELL GAS: 1. Shut off all gas supply - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 3
from walkways to avoid tripping hazard. • Do not repair or replace any part of the accessory unless specifically recommended in this manual. Other service should be performed by a qualified technician. • If the accessory is installed by a professional installer or technician, be sure that he/she - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 4
in excess of 0.5 psi (3.5 kPa). 2. The outdoor cooking gas appliance must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psi (3.5 kPa). STATE OF - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 5
Manual HOW TO LIGHT YOUR ACCESSORY USING THE POWER BURNER Smell of Gas While Cooking Yellow Flames LIGHTING INSTRUCTIONS FOR ALL ACCESSORIES Safety Practices and Precautions At Each New Season Purging the Gas Lines Match Lighting Low Heat Flame Adjustment CONTACTING CUSTOMER SERVICE - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 6
for damage or loss incurred in transit. (See INDEX: "Obtaining Service" for further details.) IMPORTANT NOTES WHERE'S THE WIND? ARE YOU blows into the front control panel (at your back when grilling), supporting the proper front-to-rear airflow. Proper leveling during installation is critical - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 7
materials. The accessory drops into the opening shown in the cutout detail drawing and hangs from its counter-top trim. A deck is not required to support it from the bottom. Pay special attention to the provisions shown for gas line hook-up. (See INDEX: "Cut-out Dimensions for Built-in Grills - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 8
INSTALLATION The guides, measurements and dimensions detailed below are designated to assist you with planning your outdoor kitchen. NOTE: Due to continuing product innovation, specifications are subject to change without notice. IMPORTANT: Please reference the Care & Use / Installation manual for - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 9
SPECIFICATIONS & INSTALLATION COUNTER TOP NOTCH DETAIL Only required if island counter top overhangs the face of the island A C 5" 4.5" 3" B MAXIMUM RUNS FOR ALL APPLIANCES ON SUPPLY LINE Run Length 3/4" Pipe (in feet) Max BTU for all Appliances on line 10 360,000 20 245,000 30 198, - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 10
GAS CONNECTIONS GAS PLUMBING WARNING Never connect a gas line directly to the accessory. A pressure regulator must be installed on all gas equipment. All local codes require that the pressure regulator supplied with your accessory is used. Removing or failing to install the pressure regulator can - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 11
operate on either Natural Gas or LPG. These kits should be installed by a qualified technician. These kits come with complete installation instructions and should be read completely and fully understood before installing the conversion kit. When exchanging your cylinder for a refill, exchange only - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 12
GAS CONNECTIONS ...continued PROPANE HOOK UP NATURAL GAS HOOK UP WARNING COLD WEATHER WARNING: PROPANE Extremely cold temperatures may cause your burner to light inside the burner instead of outside. Once lit, if you hear a 'whooshing' sound, immediately turn the burner knob off to extinguish the - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 13
be installed. Each electrical kit ships with an instructional sheet for assembly. Assembly instructions and schematics/drawings can also be found on the GFI may have tripped, requiring a reset. See the Troubleshooting section for more details. CONNECTING THE WIRING The accessory electrical - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 14
all appliances. 4. Perform a leak test if you have not done so since plumbing the unit. 5. Check all burners for proper ignition. Refer to the Lighting Instructions for Side Burners. FIXING A GAS LEAK 1. Shut off the gas supply 2. Turn all grill controls to the "ON" position to purge the grill of - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 15
IMPORTANT SAFETY PRECAUTIONS PLEASE REVIEW THESE IMPORTANT SAFETY PRECAUTIONS BEFORE YOU USE YOUR GRILL ACCESSORY. 1. NEVER LEAVE THE GRILL ACCESSORY UNATTENDED WHILE COOKING. 2. Ensure all tie-down wires have been removed from the burners. 3. Always use caution when operating the grill accessory - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 16
in your correspondence. With the proper use and care this product will provide years of trouble-free service. Should your appliance change ownership, please make sure that the new owner receives this manual. Thanks again for your purchase. Enjoy! | 16 SIDE BURNER ACCESSORY CARE & USE/INSTALLATION - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 17
and use of these accessories is identical. ACCESSORIES COVERED IN THIS MANUAL POWER BURNER MODEL VQGPB5201(N/L)SS The Power Burner is a dual- please continue. • Do all control knobs turn freely? If not, call for service; if yes, please continue. • Are all burners properly seated in the side burner - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 18
USING THE POWER BURNER The power burner incorporates a cast brass, dual-ring, burner. SMELL OF GAS WHILE COOKING Each ring can be independently operated for maximum heat con- WARNING! IF YOU SMELL GAS WHILE THE GRILL ACCESSORY IS OPERATING, IMMEDIATELY TURN OFF ALL BURNERS AND SHUT OFF THE MAIN - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 19
PRACTICES AND PRECAUTIONS WARNING Read the 'User Manual/Installation Instructions carefully and completely before using your grill and can disrupt air flow, causing damage to the accessory and personal injury. Using the manual lighting rod, pass a lit match over the ports of the burner. The power - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 20
INSTRUCTIONS FOR ALL CONTACTING CUSTOMER SERVICE ACCESSORIES ...continued LOW HEAT FLAME ADJUSTMENT If service is required, call your authorized service problem that you are having. If you are unable to obtain the name of an authorized service agency, or if you continue to have service problems, - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 21
SCHEMATICS WHITE | SIDE BURNER ACCESSORY CARE & USE/INSTALLATION 21 - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 22
damage or injury resulting from use in a commercial application. To support the manufacturing quality of its appliance's Viking will provide a full or premium rates shall not be covered by the warranty. To obtain warranty service contact Viking Range LLC Customer Care at 1-888-845-4641. Please have - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 23
| SIDE BURNER ACCESSORY CARE & USE/INSTALLATION 23 - Viking VQGSB5131 | Installation / Use and Care Instructions - Page 24
068962-000A EN Viking Range, LLC 111 Front Street Greenwood, Mississippi 38930 USA (662) 455-1200 For product information, call 1-888-(845-4641) or visit our web site at vikingrange.com (022820)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
 |
 |
Installation/
Use & Care
MANUAL
5 SERIES
GAS SIDE BURNER ACCESSORIES
VQGSB5131
VQGPB5201