Weber Summit Gold B LP Owner Manual
Weber Summit Gold B LP Manual
 |
View all Weber Summit Gold B LP manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Summit Gold B LP manual content summary:
- Weber Summit Gold B LP | Owner Manual - Page 1
SUMMIT® & LP Gas Grill Owners Guide YOU MUST READ THIS OWNERS GUIDE # BEFORE OPERATING YOUR GAS GRILL 43720 ƽ DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flames. 3. Open lid 4. If odor continues, keep away from the appliance and immediately call your gas - Weber Summit Gold B LP | Owner Manual - Page 2
use. See instructions in this manual for correct procedures. ƽ Do not operate the Weber® gas barbecue if there is a gas leak present. ƽ Do not use a flame to check for gas leaks. ƽ Combustible materials should never be within 24 inches of the top, bottom, back or sides of your Weber® gas barbecue - Weber Summit Gold B LP | Owner Manual - Page 3
11 Assembly Instructions B-a Gas Instructions C-1 Leak Checking C-4 Operating D-1 Grilling Methods D-1 Lighting ...D-3 Manual Lighting D-4 Lighting the Side Burner D-5 Troubleshooting D-6 Side Burner Troubleshooting D-7 Maintenance E-1 Replacing Main Burners E-2 Crossover® Ignition System - Weber Summit Gold B LP | Owner Manual - Page 4
ORIGINAL PURCHASER of this Weber® gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, lifetime, 1 year paint Stainless Steel Hood Section, 25 years Burners, 10 years Igniter, 3 years Cooking Grates, 7 years Flavorizer® Bars - Weber Summit Gold B LP | Owner Manual - Page 5
you the minimum requirements for assembling your Weber® gas barbecue. Please read the instructions carefully before using your Weber® gas barbecue. Improper assembly can be dangerous. • Not for use by children. • If there are local codes that apply to portable gas grills, you will have to conform to - Weber Summit Gold B LP | Owner Manual - Page 6
General Instructions Grilling Methods NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual. ƽ WARNING: Do not move the Weber® gas barbecue when operating or while barbecue is hot. You can adjust the Left and Right burners in each burner set as desired. The - Weber Summit Gold B LP | Owner Manual - Page 7
Summit® Silver B Exploded View 1 Summit® Silver B LP 012903 2 3 39 4 40 5 41 6 42 43 7 8 9 44 10 11 12 13 45 14 46 15 47 16 17 18 48 49 19 50 20 21 - Weber Summit Gold B LP | Owner Manual - Page 8
Assembly 48. Side Burner Igniter Wire 49. Manifold Assembly 50. Main Gas Line 51. Hose and QCC1 Regulator 52. Bottom Tray 53. Summit Catch Pan Holder 54. Summit Catch Pan 55. Summit Drip Pan 56. Side Burner Grate 57. Rear Frame Rail 58. Side Burner Cap 59. Side Burner Ring 60. Side Burner Control - Weber Summit Gold B LP | Owner Manual - Page 9
Summit® Gold B Exploded View 1 Summit® Gold B LP 012903 2 3 40 4 41 5 42 6 43 7 44 8 9 10 11 45 12 13 14 15 46 16 47 17 48 18 19 20 49 50 21 51 - Weber Summit Gold B LP | Owner Manual - Page 10
49. Side Burner Ignition Wire 50. Manifold Assembly 51. Main Gas Line 52. Hose and QCC1 Regulator 53. Bottom Tray 54. Summit Catch Pan Holder 55. Summit Catch Pan 56. Summit Drip Pan 57. Rear Frame Rail 58. Side Burner Grate 59. Side Burner Cap 60. Side Burner Ring 61. Side Burner 62. Side Burner - Weber Summit Gold B LP | Owner Manual - Page 11
Lid - 1 Cookbox - 1 Summit® Silver B Parts List Bottom Shelf - 1 Left Door - 1 Front Frame Rail - 1 Rear Frame Rail - 1 Right Door - 1 Side Table - 1 Left Frame Assembly - 1 Right Frame Assembly - 1 Rear Panel - 1 Side Burner - 1 Warming Rack - 1 Warm-Up™ Rack - 1 A-11 - Weber Summit Gold B LP | Owner Manual - Page 12
Summit® Silver B Parts List Flavorizor® Bars - 2 Sets Hinge Pin- 2 Stainless Steel Cooking Grates - 2 Bottom Tray - 1 Hair Pin Cotter- 2 1-1/4 inch Bolts (1/4 x 20 x 1-1/4 inch Bolt) - 2 Nut -Pan - 1 Plastic Washer - 1 Disposable Drip Pans - 2 Wrench - 1 7/16 inch Wrench - 1 LP Tank - 1 A-12 - Weber Summit Gold B LP | Owner Manual - Page 13
Lid - 1 Cookbox - 1 Summit® Gold B Parts List Bottom Shelf - 1 Left Door - 1 Front Frame Rail - 1 Rear Frame Rail - 1 Right Door - 1 Side Table - 1 Left Frame Assembly - 1 Right Frame Assembly - 1 Rear Panel - 1 Side Burner - 1 Warming Rack - 1 Warm-Up™ Rack - 1 A-13 - Weber Summit Gold B LP | Owner Manual - Page 14
Summit® Gold B Parts List Flavorizor® Bars - 2 Sets Hinge Pin- 2 Hair Pin Cotter- 2 1-1/4 inch Bolts (1/4 x 20 x 1-1/4 inch Bolt) - 2 Stainless Steel Cooking Grates - 3 Bottom Tray - 1 Nut Hex (1/4 x 20 Blk Zinc) - 2 1/2 inch Bolts (1/4 x 20 x 1/2 inch Bolt) - 8 Nylon Washer - 10 Catch-Pan - Weber Summit Gold B LP | Owner Manual - Page 15
Frame Assembly to level the frames for Frame Rail Assembly. b c (1) (3) Ba401.c ƽ CAUTION: Before proceeding to the next step check that frame rail (2) is on the side with the swing tables (3). The tab on frame rail (2) must be (2) (3) facing toward the wheels. B-a - Weber Summit Gold B LP | Owner Manual - Page 16
2 a b ƽ ATTENTION! Only start these bolts. Do not tighten yet. B-b - Weber Summit Gold B LP | Owner Manual - Page 17
3 B-c - Weber Summit Gold B LP | Owner Manual - Page 18
4 a b ƽ ATTENTION! Completely remove both partially started bolts from top rear frame rail c 1 2 ƽ ATTENTION! Reinstall both bolts through rear panel and into rear frame rail. B-d - Weber Summit Gold B LP | Owner Manual - Page 19
5 ƽ ATTENTION! Remove packing tape holding the gas line and bracket(1). When installing cookbox route the gas line and bracket(1) inside the frame rails(2). a (1) (2) (2) (1) (2) (2) B-e - Weber Summit Gold B LP | Owner Manual - Page 20
6 b (1) (2) (3) B-f - Weber Summit Gold B LP | Owner Manual - Page 21
7 c (1) (2) (1) (2) B-g - Weber Summit Gold B LP | Owner Manual - Page 22
8 a b Matchlight Holder B-h - Weber Summit Gold B LP | Owner Manual - Page 23
9 a b (1) (2) (3) B-i - Weber Summit Gold B LP | Owner Manual - Page 24
10 a b a b B-j - Weber Summit Gold B LP | Owner Manual - Page 25
11 a (1) (2) NOTE: Igniter b Wire(1) is located up under right side of control panel. (1) B404_LP.b B-1 - Weber Summit Gold B LP | Owner Manual - Page 26
c ƽ CAUTION: Hold burner cap(1) down while pushing side burner ignition wire(2) on. (1) (2) d B-2 - Weber Summit Gold B LP | Owner Manual - Page 27
12 b a 13 14 B-3 - Weber Summit Gold B LP | Owner Manual - Page 28
15 16 B-4 - Weber Summit Gold B LP | Owner Manual - Page 29
B B-5 - Weber Summit Gold B LP | Owner Manual - Page 30
B B-6 - Weber Summit Gold B LP | Owner Manual - Page 31
then contact the Customer Service Representative in your region using the contact information sheet provided with your manual. To fill, take DANGER ƽNEVER store a spare LP Cylinder under or near this barbecue. ƽNEVER fill the tank beyond 80% full. Your Weber® gas grill is equipped with a cylinder - Weber Summit Gold B LP | Owner Manual - Page 32
. These types of tanks are illustrated below. You will need: LP cylinder, a soap and water solution and a rag or brush to apply it. 1) Turn the LP cylinder so the opening of the valve is either to the front, side or rear of the Weber® gas barbecue. Lift and hook the cylinder onto the fuel gauge - Weber Summit Gold B LP | Owner Manual - Page 33
before operating your Summit® gas grill. Remove control panel Put your fingers under the front edge of the control panel and lift off. Completely remove the control panel (4) from the cooking box assembly exposing the valves, burners, igniter, and manifold. Part required: Phillips Screwdriver - Weber Summit Gold B LP | Owner Manual - Page 34
all fittings for leaks before using your Weber Gas Barbecue. Shipping and handling may loosen or damage a gas fitting. ƽ WARNING: Perform these leak side burner is OFF. To perform leak checks: open cylinder valve by turning the cylinder valve hand-wheel counterclockwise. ƽ WARNING: Do not ignite - Weber Summit Gold B LP | Owner Manual - Page 35
the fitting, turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. 3) Side burner hose to manifold connection 4) Side burner hose to side burner connection 5) Regulator to cylinder - Weber Summit Gold B LP | Owner Manual - Page 36
Gas Instructions Reinstall control panel Parts required: control panel, screws, and burner control knobs. Place the control panel back onto the control panel brackets on either side of the control panel, replace the two wires (1,2) of each igniter. -+ -+ ac bd -+ -+ ac bd a = Yellow Tab - Weber Summit Gold B LP | Owner Manual - Page 37
Gas Instructions Liquid Propane Cylinder The liquid propane cylinder manufacturer is responsible for the materials, workmanship and performance of the tank. If the tank has a defect malfunctions, or you have a question regarding the tank, call the tank manufacturer's customer service center. The - Weber Summit Gold B LP | Owner Manual - Page 38
date tested(2) is within five years. Your LP gas supplier can do this for you. If you have questions about spare LP cylinders contact the Customer Service Representative in your region using the contact information sheet provided with your manual. s All LP tank supply systems must include a collar - Weber Summit Gold B LP | Owner Manual - Page 39
grill before grilling is important. Light your Summit® gas grill according to the instructions in this Owner's Manual the fire, or arrange the fire on either side of it. Using the right method is gas grill for Direct cooking, preheat the grill with all burners on High. Place food on the cooking grate - Weber Summit Gold B LP | Owner Manual - Page 40
Operating Instructions Indirect cooking The Indirect Method is similar to roasting, but with the added benefits of that grilled texture, flavor, and appearance you can't get from an oven. To set up for Indirect cooking, gas burners are lit on either side of the food but not directly beneath it. - Weber Summit Gold B LP | Owner Manual - Page 41
to be damaged in any way, do not use the barbecue. Replace using only Weber® authorized replacement hose. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. 1) Open the lid. 2) Make sure all burner control knobs are turned OFF - Weber Summit Gold B LP | Owner Manual - Page 42
Operating Instructions Manual Lighting 1 ƽ DANGER Failure to open the lid while igniting the 4,5,7 barbecue's burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. 6 - Weber Summit Gold B LP | Owner Manual - Page 43
Operating Instructions Side Burner Lighting Instructions ƽ DANGER Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flame-up which can cause serious bodily injury or death. - Weber Summit Gold B LP | Owner Manual - Page 44
Main Burner Troubleshooting Problem Check Burners burn with a yellow or Inspect Weber® Insect / Spider orange flame, in conjunction with screens for possible instructions. the smell of gas. (Blockage of holes.) Cure Clean Weber® Insect / Spider screens. (See Section "Annual Maintenance") - Weber Summit Gold B LP | Owner Manual - Page 45
Side Burner Troubleshooting Problem Side Burner does not light. Check Is gas supply off? Cure Turn supply on. Flame is low in HIGH position. Is the fuel hose bent or kinked? Straighten hose. Push button ignition does not work. Does burner light with a match? If match lights burner, - Weber Summit Gold B LP | Owner Manual - Page 46
Weber-Stephen Products Customer Service for replacement parts. Main Burner Flame Pattern The Weber® gas barbecue burners have been factory set for the correct air and gas heats unevenly. 4) One or more of the burners do not ignite. ƽ DANGER Failure to correct the above mentioned symptoms may result - Weber Summit Gold B LP | Owner Manual - Page 47
1. Your Summit® gas grill must be OFF and cool. 2. Turn gas OFF at source. 3. Disconnect regulator. 4. Remove cooking grates. 5. Remove Smoker box. 6. Remove Flavorizer® bars. 7. To remove control panel refer to "Remove the control panel" under "Check for Gas Leaks." 8. Disconnect all ignition wires - Weber Summit Gold B LP | Owner Manual - Page 48
Maintenance 9. Remove screws from the manifold assembly: (a) Locate the screws on both sides of the manifold frame. (b) Remove the screws from manifold frame. 10. Pull manifold assembly out from the manifold frame. (a) (b) (a) (b) (a) (b) (a) (b) E-3 - Weber Summit Gold B LP | Owner Manual - Page 49
the selected burner(s) tube(s) from manifold frame and replace with a new burner tube. Check proper assembly before fastening manifold in place. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the - Weber Summit Gold B LP | Owner Manual - Page 50
system still fails to light, contact the Customer Service Representative in your region using the contact information sheet provided with your manual. (1) (2) Replace Igniter Batteries Parts required: 1 AA alkaline battery per igniter. Unscrew igniter button from top of control panel. Remove
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
 |
 |
SUMMIT
®
±
WARNING: Follow all leak-check
procedures carefully in this manual prior to
barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
±
WARNING
1.
Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2.
Do not store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
±
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flames.
3.
Open lid
4.
If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
Y
OU
MUST
READ
THIS
O
WNERS
G
UIDE
BEFORE
OPERATING
YOUR
GAS
GRILL
LP Gas Grill Owners Guide
±
WARNING: Do not try to light this
appliance without reading the “Lighting”
Instructions section of this manual
A404_LP.d
Ba401.c
B404_LP.b
C404_LP.c
D404_LP.d
E403.b
#
43720 US 01/29/03
LP
43720
&