2007 Ford F350 Owner Guide 2nd Printing
2007 Ford F350 Manual
2007 Ford F350 manual content summary:
- 2007 Ford F350 | Owner Guide 2nd Printing - Page 1
Introduction Instrument Cluster Warning lights and chimes Gauges 4 12 12 16 Entertainment Systems AM/FM stereo AM/FM stereo with CD AM/FM stereo with in-dash six CD Satellite radio information 21 21 23 28 34 Climate Controls Heater only Manual heating and air conditioning Automatic temperature - 2007 Ford F350 | Owner Guide 2nd Printing - Page 2
shut-off switch Fuses and relays Changing tires Lug nut torque Jump starting Wrecker towing 208 208 210 210 211 220 232 233 238 Customer Assistance Reporting safety defects (U.S. only) Reporting safety defects (Canada only) 2 240 246 247 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt - 2007 Ford F350 | Owner Guide 2nd Printing - Page 3
Table of Contents Cleaning Maintenance and Specifications Hood Engine compartment Engine oil Battery Engine coolant Fuel information Air filter(s) Part numbers Refill capacities 248 256 257 258 261 265 267 273 291 293 294 Accessories Index 301 304 All rights reserved. Reproduction by any means, - 2007 Ford F350 | Owner Guide 2nd Printing - Page 4
cut off the fuel supply to the engine. The switch can also be activated through sudden vibration (e.g. collision when parking). To reset the switch, refer to the Fuel pump shut-off switch in the Roadside Emergencies chapter. 4 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 5
or special break-in oils during the first few thousand miles (kilometers) of operation, since these additives may prevent piston ring seating. See Engine oil in the Maintenance and Specifications chapter for more information on oil usage. 5 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt - 2007 Ford F350 | Owner Guide 2nd Printing - Page 6
of Ford Motor Company, Ford of Canada and Ford Motor Company, S.A. de C.V. Vehicle Modification Data Recording Some aftermarket products may cause severe engine and/or transmission damage; refer to the What is not covered section in The new vehicle 6 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 7
the specific warnings and instructions could result in personal injury. Front seat mounted rear-facing child or infant seats should NEVER be placed in front of an active passenger safe to operate Mobile Communications Equipment. 7 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 8
light truck as an ambulance, without the Ford Ambulance Preparation Package voids the Ford New Vehicle Limited Warranty and may void the Emissions Warranties. In addition, ambulance usage without the preparation package could cause high underbody temperatures. 8 2007 F-250/350/450/550 (f23) Owners - 2007 Ford F350 | Owner Guide 2nd Printing - Page 9
to the pages in the provided supplement, you can properly identify those features, recommendations and specifications that are unique to your vehicle. Refer to this Owner's Guide for all other required information and warnings. 9 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 10
Petroleum Based Speed Control Powertrain Malfunction Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Defrost/Demist Windshield Wash/Wipe Rear Window Defrost/Demist 10 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 11
Flames, or Sparks Explosive Gas Battery Acid Fan Warning Maintain Correct Fluid Level Engine Air Filter Jack MAX MIN Power Steering Fluid Emission System Passenger Compartment Air Filter Check Fuel Cap Low Tire Pressure Warning 11 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 12
) Harley-Davidson instrument cluster Warning lights and gauges can alert you to a vehicle condition that may become serious enough to cause expensive repairs. A warning light may illuminate when a problem exists with one of your vehicle's functions. 12 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 13
If your vehicle is equipped with a diesel engine, it has a unique cluster; refer to Starting the engine in your 6.0 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement. Service engine soon: The Service engine soon indicator light illuminates when the ignition is first turned to - 2007 Ford F350 | Owner Guide 2nd Printing - Page 14
Instrument Cluster Brake system warning light: To ! P confirm the brake system warning light is functional, it will BRAKE momentarily illuminate when the ignition is turned to the ON position when the engine chime feature. 14 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 15
key is not in the ignition) and the driver's door is opened. Parking brake ON warning chime: Sounds when the parking brake is set, the engine is running and the vehicle is driven more than 3 mph (5 km). 15 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 16
GAUGES Speedometer: Indicates the current vehicle speed. Standard instrument cluster Harley-Davidson instrument clusters Engine coolant temperature gauge: Indicates engine coolant temperature. At normal operating temperature, the needle will be in the normal range (between "H" and "C"). If - 2007 Ford F350 | Owner Guide 2nd Printing - Page 17
Instrument Cluster Odometer: Registers the total miles (kilometers) of the engine hours display. • With Full Message Center Press and release the message center INFO button until ENG HRS XXXX.X appears in the display. Press the RESET button to reset. 17 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 18
may damage the engine. Standard instrument cluster Harley-Davidson instrument cluster Engine oil pressure gauge: Indicates engine oil pressure. The needle in the Maintenance and Specifications chapter for more information. 18 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 19
Instrument Cluster Battery voltage gauge (manual transmission only): Indicates the battery voltage when the ignition is in the ON position. If the pointer moves and stays outside the normal operating range, have the vehicle's electrical system checked as soon as possible. Transmission fluid - 2007 Ford F350 | Owner Guide 2nd Printing - Page 20
Instrument Cluster If the gauge is operating in the Yellow or Red area, stop the vehicle and verify the airflow is not restricted such as snow or debris blocking airflow through the grill. If the gauge continues to show high temperatures, see your authorized dealer. 20 2007 F-250/350/450/550 (f23) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 21
/FM stereo system does not contain rear speakers; only front driver side and passenger side speakers. Accessory delay: Your vehicle is equipped with accessory delay. With this feature, the reach the treble setting. / / SEEK . Use 21 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 22
hours begin to flash. Press manually increase/decrease the hours. Press CLK again to the set the / / SEEK to manually increase/decrease the minutes using minutes. Allow 10 seconds to pass to confirm that the time has been set. 22 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 23
(if equipped) / (Tuner): Press to 1. manually go up or down the radio frequency. Press and through the current song title, artist, channel category and SIRIUS Long Channel Name. In TEXT MODE, sometimes the display text requires 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 24
SEEK to set. Allows you to set the strongest local radio stations without losing your original manually set preset stations for AM/FM1/FM2. When the six strongest stations are filled, the between the left Use and right speakers. 24 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 25
the fade setting. Use / / SEEK, SEEK to adjust the audio between the front and rear speakers. SPEEDVOL (Speed sensitive volume) (if equipped): Press MENU to reach the SEEK to fast seek through the previous/next channels. 25 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 26
FF (Fast forward): In CD mode, press FF to manually advance in a CD track. 10. REW (Rewind): In CD mode, press REW to manually reverse in a CD track. 11. Memory presets: Each number with your authorized dealer for availability 26 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 27
where it ended last. (CD eject): Press 16. eject a CD. to 17. CD slot: Insert a CD with label side up in the CD slot. 27 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 28
/ (Tuner/Disc selector): In radio mode, press to manually go up or down the radio frequency. Press and hold the current song title, artist, channel category and SIRIUS Long Channel Name. In TEXT MODE, sometimes the display text 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 29
to set. the Allows you to set the strongest local radio stations without losing your original manually set preset stations for AM/FM1/FM2. When the six strongest stations are filled, the between the left Use and right speakers. 29 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 30
the fade setting. Use / / SEEK, SEEK to adjust the audio between the front and rear speakers. SPEEDVOL (Speed sensitive volume) (if equipped): Press MENU to reach the SPEEDVOL press previous/additional display text. 30 to view the 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 31
. 9. FF (Fast forward): In CD mode, press FF to manually advance in a CD track. 10. REW (Rewind): In CD mode, press REW to manually reverse in a CD track. 11. Memory presets: Each number has a : Press AM/FM to select AM/FM1/FM2. 31 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 32
that can affect radio reception: • Distance/strength: The further you travel from an FM station, the weaker the signal and the weaker the reception. 32 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 33
, mountains, tall buildings, power lines, electric fences, traffic lights and thunderstorms can interfere with your reception. • Station overload: Ford CD players. Do not use any irregular shaped CDs or discs with a scratch protection film attached. 33 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 34
for further information. Audio system warranty and service Refer to the Warranty Guide for audio system warranty information. If service is necessary, see your authorized may display NO SIGNAL to indicate the interference. 34 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 35
and its prices, at any time, with or without notice to you. Ford Motor Company shall not be responsible for any such programming changes. Satellite Radio have a fault. See your authorized dealer for service. SAT FAULT 35 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 36
properly. Category information Category information not available. not available at this time on this channel. The system is working properly. Condition Channel no longer available. UNSUBSCRIBED NO TEXT NO TEXT NO TEXT 36 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 37
. Call SIRIUS at 1-888-539-7474 to re-activate or resolve subscription issues. UPDATING Update of channel programming in progress. Satellite service has been deactivated by SIRIUS Satellite Radio. CALL SIRIUS 1-888-539-7474 37 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 38
flow selector in the O (OFF) position. • Do not put objects under the front seats that will interfere with the air flow to the rear seats. • Remove any snow, ice or leaves from the air intake area at the base of the windshield. 38 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 39
instrument panel. Do not place objects on top of the instrument panel as these objects may become projectiles in a collision or sudden stop. MANUAL HEATING AND AIR CONDITIONING outside air through the instrument panel vents to cool the vehicle. 39 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 40
air flow selector in the O (OFF) position. • Do not put objects under the front seats that will interfere with the airflow to the rear seats. • Remove any snow, ice or leaves from the air the outer instrument panel vents towards the side windows. 2007 F-250/350/450/550 (f23) Owners Guide (post-2002 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 41
top of the instrument panel as these to activate/deactivate air conditioning. Use with recirculated air to improve cooling performance air through the windshield defroster vents and demister vents. Can be used to clear windshield of fog and thin ice. 41 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 42
air through the instrument panel vents and 8. center console vents (if equipped). 9. OFF: Outside air is shut out and the climate control system is turned off. 10. Manual override controls: The manual °F (22°C) and 75°F (24°C). 42 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 43
airflow to the outer instrument panel vents, close the vents located in the middle of the instrument panel. Do not place objects on top of the instrument panel as these objects may become projectiles in a collision or sudden stop. 43 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 44
instrument panel lamps, license plate lamps and tail lamps. Turns the headlamps on. Autolamp control (if equipped) The autolamp system provides light sensitive automatic on-off control of the exterior lights will turn off. 44 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 45
Daytime Running Lamp (DRL) system does not activate the tail lamps and generally may not provide adequate lighting during these conditions. Failure to activate your headlamps under these conditions may result in a collision. 45 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 46
Use to adjust the brightness of the instrument panel and all applicable switches in the vehicle during headlamp and parklamp operation. Move the control to the full upright position, past detent, to turn on the interior lamps. 46 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 47
Lights AIMING THE HEADLAMPS Your vehicle may be equipped with a sealed beam or aerodynamic headlamp system. Sealed blocked, per the instructions for the brand of long horizontal line on the wall or screen (1) at this height (masking tape works well). 47 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 48
it. 8. Locate the horizontal adjuster (1) for each headlamp. Turn it clockwise or counterclockwise, to place the left edge of the high intensity area even with the vertical line corresponding to the headlamp under adjustment. 48 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 49
wall or screen at this height (a piece of masking tape works well). 3. Turn on the low beam headlamps to illuminate the wall light pattern up to the horizontal line. 6. Repeat Steps 3-5 for the other headlamp. 7. Close the hood and turn off the lamps. 49 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 50
the rocker controls next to each lamp. MAP LAMPS (IF EQUIPPED) To turn on the map lamps, press the control next to each lamp. 50 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 51
lamp (if 4 194 equipped) Rear identification 3 194 All replacement bulbs are clear in color except where noted. To replace all instrument panel lights - see your authorized dealer * Dual rear wheels, or if equipped. 51 Function 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 52
of children's reach. Grasp the bulb only by its plastic base and do not touch the glass. The oil from your hand could cause the bulb to break the next time the headlamps are operated. Install the new bulb(s) in reverse order. 52 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 53
Lights Replacing park/turn and sidemarker lamp bulbs (aerodynamic) 1. Make sure that the headlamp control is in the OFF position and open the hood. 2. Remove the four screws from the top and bottom front (s) in reverse order. 53 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 54
Lights Replacing headlamp bulbs (sealed beam) 1. Make sure that the headlamp control is in the OFF position and open the hood. 2. Remove the four screws from the top and bottom front . Install the new bulb(s) in reverse order. 54 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 55
Lights Replacing park/turn/sidemarker bulbs (sealed beam) 1. Make sure that the headlamp control is in the OFF position and open the hood. 2. Remove the four screws from the top and bottom front the new bulb(s) in reverse order. 55 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 56
Lights Replacing brake/tail/turn/back-up lamp bulbs - F-250/F-350 only 1. Make sure the headlamp switch is in the OFF position and then open the Carefully pull the bulb straight out of the socket and push in the new bulb. 56 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 57
OFF position. 2. Remove the bulb socket from the foglamp by turning counterclockwise. 3. Disconnect the electrical connector from the foglamp bulb. Install the new bulb(s) in reverse order. 57 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 58
Lights Replacing license plate lamp bulbs The license plate bulbs are located behind the rear bumper. To change the license plate lamp bulbs: 1. Reach behind the rear bumper to locate the lamp assembly by turning it clockwise. 58 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 59
you. 2. Move the steering wheel up or down until you find the desired location. 3. Release the steering wheel release control. This will lock the steering wheel in position. Never adjust the steering wheel when the vehicle is moving. 59 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 60
) (if equipped) To activate, press the transmission control switch (TCS) located on the gearshift. The TOW/HAUL indicator light will illuminate in the instrument cluster. The transmission will operate in all gears. Press the transmission control switch again to deactivate Tow/Haul mode. When - 2007 Ford F350 | Owner Guide 2nd Printing - Page 61
point(s) over the vehicle capacity of 12 VDC/180W. To prevent the battery from being discharged, do not use the power point longer than necessary when the engine is not running. Always keep the power point caps closed when not being used. 61 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt - 2007 Ford F350 | Owner Guide 2nd Printing - Page 62
) Do not plug optional electrical accessories into the cigarette lighter socket. . Improper use of the lighter can cause damage not covered by your warranty. POWER WINDOWS (IF EQUIPPED) Do not leave children unattended in the 62 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 63
reach the mirror. When the mirror detects bright light from front or behind, it will automatically adjust to minimize glare. Do not clean the housing or glass of any mirror with harsh abrasives, fuel or other petroleum-based cleaning products. 63 2007 F-250/350/450/550 (f23) Owners Guide (post-2002 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 64
, is not heated and must be adjusted manually. Do not remove ice from the mirrors with a scraper or attempt to readjust the mirror glass if it is frozen in place. These actions could cause damage to the glass and mirrors. 64 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 65
or backing out of a garage with the trailer tow mirror. The telescoping feature (if equipped) allows the mirror to extend approximately 3.15 inches (80 mm). This feature is especially useful to the driver when towing a trailer. 65 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 66
without keeping your foot on the accelerator pedal. Speed control does not work at speeds below 30 mph (48 km/h). Do not use the steering wheel for your convenience. 1. Press the ON control and release it. 2. Accelerate to the desired speed. ON OFF 66 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 67
Take your foot off the accelerator pedal. light on the 5. The indicator instrument cluster will turn on. Note: • Vehicle speed previously set speed. The RES/RESUME control will not work if the vehicle speed is not faster than 30 mph 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 68
or the ignition, your speed control set speed memory is erased. ON OFF Indicator light (if equipped) This light comes on when either the SET ACCEL or RES controls are pressed. The vehicle speed is turned to the OFF position. 68 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 69
switches for extended duration or higher current draws. (This is even more important for vehicles with diesel engines since the glow plugs are also draining battery power when the ignition key is in the 4 [ON] position.) 69 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 70
commercial uses. If your vehicle is equipped with this option, there will also be a relay box with a fuse located inside the glove box. The relays and fuse in the glove box are coded as shown in the accompanying illustration. 70 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 71
found as a blunt-cut and sealed wire located behind the passenger compartment fuse panel. They are coded as follows: Circuit number Wire color Fuse 1936 Orange with Light 30A Green Trace AUX 2 1933 the AUTO or 71 Switch AUX 1 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 72
you to possible problems or malfunctions in your vehicle's operating systems. All warning messages will also provide an indicator tone. Note: The following warning messages will reappear after an ignition OFF-ON cycle has been completed. 72 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt - 2007 Ford F350 | Owner Guide 2nd Printing - Page 73
(refer to Fuel gauge in this chapter). Check gauge: Displays when any of the following conditions has occurred: • The engine coolant temperature is high. • The engine oil pressure is low. • The fuel gauge is at or near empty. 73 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 74
are English and French. The feature works as follows: 1. If present language message center, located on your instrument cluster, displays important vehicle information through problems with a display of system warnings followed by a long indicator chime. 74 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 75
Average Fuel Economy/Odometer/Compass • Engine hour meter/Odometer/Compass Odometer/Trip odometer Refer to Gauges in the Instrument Cluster chapter. Distance to empty (DTE a factory default value if the battery is disconnected. 75 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 76
in the automatic shut-off points on the fuel pumps at service stations • Variations in top-off procedure from one fill-up vehicle in normal conditions. If the compass still appears to be inaccurate, a manual calibration may be 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 77
an open area free from steel structures and high voltage lines. For optimum calibration, turn off all electrical accessories (heater/air conditioning, wipers, etc.) and make sure all up to five circles to complete calibration. 77 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 78
from the INFO menu to display the accumulated running time of the engine. Setup menu Press this control for the following displays: • System Check as follows: 1. ENGINE TEMP 2. TRANS TEMP 3. OIL PRESSURE 4. BRAKE FLUID LEVEL 78 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 79
6. FUEL CAP (gasoline engine only) 7. AIR FILTER (diesel engine only) 8. FUEL LEVEL autolocks ON or OFF. Autolamp delay This feature keeps your headlights on for up to three minutes after the ignition is switched be displayed. 79 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 80
. System warnings System warnings alert you to possible problems or malfunctions in your vehicle's operating systems. In conditions still exist within the vehicle. Warning display Reduced engine power Stop engine safely Status Warning cannot be reset 80 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 81
AIR FILTER (diesel only): Refer to Instrument Cluster in your 6.0 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement. LOW BRAKE FLUID LEVEL Indicates the brake fluid level is low and the brake system should be inspected immediately. Refer to Brake fluid in the Maintenance - 2007 Ford F350 | Owner Guide 2nd Printing - Page 82
on or continues to come on, contact your authorized dealer as soon as possible. WATER IN FUEL (diesel only): Refer to Instrument Cluster in your 6.0 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement. 82 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 83
modules. • Odometer • Fuel flow • Fuel level • Trans temp • Fuel cap • Engine sensor • Brake fluid • Auto lock • Auto lamp delay Contact your authorized dealer as soon as lock. • Turn ignition key to the left to unlock. 83 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 84
of the support screw. Disconnect cable. 3. Disconnect the other cable. 4. Lift tailgate to a 45-degree angle. 5. Lift right side off of its hinge. 6. Lift left side off of its hinge. To install, follow the removal procedures in reverse order. 84 2007 F-250/350/450/550 (f23) Owners Guide (post-2002 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 85
The vehicle can still be locked, with the key in the ignition, using the manual lock button on the door, locking the driver's door with a key, by simultaneously conditions are met: • the ignition key is in the 4 (ON) position, • all the doors are closed, 85 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 86
5 mph (8 km/h). Relock The autolock feature repeats when the following conditions are met: • the vehicle's speed is less than 5 mph (8 will chirp twice (one short and one long chirp) when the system has been successfully reactivated 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 87
or twice (one short and one long chirp) if autolock was activated. Note locks are set, the rear doors cannot be opened from the inside. • The rear doors can be opened is subject to the following two conditions: (1) This device may not 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 88
in operating range could be caused by: • weather conditions, • nearby radio towers, • structures around the to the authorized dealer in order to aid in troubleshooting the problem. Unlocking the doors and release to unlock the 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 89
The UNLOCK feature will work again after: • a battery: 1. Twist a thin coin between the two halves of the remote entry transmitter near the key ring. DO NOT TAKE THE RUBBER COVER AND CIRCUIT BOARD OFF THE FRONT HOUSING OF THE REMOTE ENTRY TRANSMITTER. 89 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 90
batteries. 4. Insert the new battery. Refer to the diagram inside the remote entry transmitter for the correct orientation of the battery. Press the battery down to ensure that the battery is fully seated in the battery . 90 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 91
entry system is used to unlock the door(s). The illuminated entry system will turn off the interior lights if: • the ignition switch is turned to the 4 (ON) position, or • the remote transmitter lock control is pressed, or 91 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 92
lights will not turn off if: • they have been turned on with the dimmer control, or • any door is open. The battery entry code; this code is located on the owner's wallet card in the glove box, is marked on the computer module, and is 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 93
Step 2. Your personal code is now erased and only the factory set 5-digit code will work. Anti-scan feature If an incorrect code has been entered 7 times (35 consecutive button first. Note: The interior lamps will turn off. 93 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 94
The purpose of these head restraints is to help limit head motion in the event of a rear collision. To properly adjust your head restraints, lift the head restraint so that it is located Push control to lower head restraint. 94 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 95
the seat up to recline the seat. • Push down the lever located at the bottom of the seatback to quickly fold the seatback forward. 95 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 96
Seating and Safety Restraints 40/20/40 front seat armrest and console (if equipped) To release the armrest, pull forward on the strap and be opened in the upright position. Lift up armrest to return it to a center seatback. 96 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 97
outboard side of the seat cushion. Your vehicle will only be equipped with one of the two controls shown. Press to raise or lower the front portion of the seat cushion. • Type A • Type B 97 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 98
Seating and Safety Restraints Press to raise or lower the rear portion of the seat cushion. • Type A • Type B Press the control to move the seat forward, backward, up or down. • Type A • Type B 98 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 99
light on the control will illuminate when activated. The system will not automatically shut off unless control is pushed to deactivate. If system is not manually terminated at last use, then system will remain active at next ignition key cycle. 99 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 100
SEAT SYSTEM WITH LOAD FLOOR (IF EQUIPPED) The rear seatback has a split 60/40 seat. Each seat cushion can be flipped up into the seatback . An unlatched seat may become dangerous in the event of a sudden stop or collision. 100 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 101
protect the child from injury in a collision. All occupants of the vehicle, including the driver, should always properly wear their safety belts, even when an air bag supplemental restraint system (SRS) is provided. 101 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 102
the outside shoulder only. Never wear the shoulder belt under the arm. 2) Never swing the safety belt around your neck over the Front and rear seat occupants, including pregnant women, should wear safety belts for optimum protection in an accident. 102 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 103
passengers. On SuperCab and Crew Cab models, the front seat belt system can also be made to lock manually by quickly pulling on the shoulder belt. Rear seat belts (if equipped) cannot be made to lock up by pulling quickly on the belt. 103 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt - 2007 Ford F350 | Owner Guide 2nd Printing - Page 104
child safety seat is installed, except a booster, in a passenger front or outboard rear seating position (if equipped). Children 12 years old and under should be properly restrained vehicle sensitive (emergency) locking mode. 104 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 105
any vehicle collision, the front passenger and rear outboard seat belt systems must properly when checked according to the procedures in the Workshop Manual. Failure to replace the belt and retractor assembly could increase . 105 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 106
Seating and Safety Restraints • Regular Cab and 4-door Crew Cab • 4-door Super Cab To adjust the shoulder belt height, push the button and slide the 1st row center seating position The lap belt does not adjust automatically. 106 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 107
before trying to pull it out again. Safety belt warning light and indicator chime The safety belt warning light illuminates in the instrument cluster and a chime sounds to remind the occupants to fasten their safety belts. 107 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 108
warning lamp in the instrument cluster. If...The driver's light illuminates 1-2 minutes and the warning chime sounds 4-8 seconds. The safety belt warning light and warning chime turn off. The safety belt warning light and indicator chime remain off. 108 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 109
, when used properly, reduce risk of death to front seat occupants by 45% in cars, and by 60% in light trucks. Nearly 1 of 2 deaths occur in single-vehicle " "Safety belts don't work" "Traffic is light" "Belts wrinkle my clothes" 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 110
rear 's air bag system conditions are met: • the parking brake is set • the gearshift is in P (Park) (automatic transmission) or the neutral position (manual transmission) • the ignition switch is in the OFF position • all vehicle doors are closed 110 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 111
THE ENGINE) 2. Wait until the safety belt warning light turns light off, then followed by the safety belt warning light flashing 4 times per second for 3 seconds again. 5. After receiving confirmation, the deactivation/activation procedure is complete. 111 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 112
if necessary replace the safety belt assembly under the above conditions could result in severe personal injuries in the event of a collision. For proper care of soiled safety belts, refer to Interior in the Cleaning chapter. 112 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 113
is designed to work with the safety belt to help protect the driver and right front passenger from certain always properly wear their safety belts, even when an air bag supplemental restraint system (SRS) is provided. Always 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 114
risk of injury. Do not modify the front end of the vehicle. Additional equipment such as snowplow equipment may effect the performance of the airbag sensors increasing the risk of injury. Please refer to the Ford Truck Body Builders Layout Book for instructions about the appropriate installation of - 2007 Ford F350 | Owner Guide 2nd Printing - Page 115
restrained. Failure to follow these instructions may increase the risk of injury in a collision. An infant in a rear-facing seat faces a high risk of serious or fatal injuries from a deploying passenger airbag. Rear facing infant seats should NEVER be placed in the front seats, unless the passenger - 2007 Ford F350 | Owner Guide 2nd Printing - Page 116
until the problem and/or light are repaired. If any of these things happen, even intermittently, have the SRS serviced at your authorized dealer immediately. Unless serviced, the system may not function properly in the event of a collision. 116 2007 F-250/350/450/550 (f23) Owners Guide (post-2002 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 117
in accordance with these instructions and warnings. Failure to air bag switch serviced at your authorized dealer immediately. In order to avoid inadvertent activation of the switch, always remove the ignition key from the passenger air bag ON/OFF switch. 117 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 118
was designed to work with the airbag. If you are not a person who meets the requirements stated in the NHTSA/Transport Canada deactivation criteria turning OFF the airbag can increase the risk of serious injury or death in a collision. 118 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt - 2007 Ford F350 | Owner Guide 2nd Printing - Page 119
• the vehicle has no rear seat; • although children ages 1 to 12 ride in the rear seat(s) whenever possible, children ages 1 to 12 sometimes must ride in the front because no space is available in the rear seat(s) of the vehicle; or 119 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 120
• my vehicle has no rear seat; • although children age 12 and under ride in the rear seat whenever possible, children age 12 and under have no option but to sometimes ride in the front seat because rear seat space is insufficient; or 120 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 121
SRS) in this chapter for special instructions about using airbags. Important child rear seat of your vehicle. Accident statistics suggest that children are safer when properly restrained in the rear seating positions than in the front seating position. 121 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 122
in a collision. Always follow the instructions and warnings that come with any infant does not cross or rest in front of the child's face or neck who have outgrown child safety seats, Ford Motor Company recommends use of a belt- 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 123
the top of the seat. In this case, move the backless booster to another seating position with a higher seat back and lap/shoulder belts. 123 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 124
find a seating position that adequately supports your child's head, a high back booster seat would be a or carpet liner under the booster seat may improve this condition. The importance of shoulder belts Using a booster without a 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 125
Follow all instructions provided by the manufacturer of the booster seat. Never put the shoulder belt under a child's arm or behind mode (passenger side front and outboard rear seating positions) (if equipped) section in this chapter. 125 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt - 2007 Ford F350 | Owner Guide 2nd Printing - Page 126
booster. Ford recommends instructions front seats, unless the passenger airbag switch is turned off, See Passenger airbag on/off switch. Rear facing child seats should NEVER be placed in the front seats unless the passenger airbag switch is turned off. 126 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 127
portions together, route the tongue through the child seat according to the child seat manufacturer's instructions. Be sure the belt webbing is not twisted. 4. Insert the belt tongue into is latched securely by pulling on it. 127 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 128
not locked, unbuckle the belt and repeat Steps two through nine. Check to make sure the child seat is properly secured before each use. 128 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 129
. Tether straps are available as an accessory for many older safety seats. Contact the on the rear edge of the seat cushion or an work properly if attached somewhere other than the correct tether anchor. • F-Series Regular Cab • F-Series SuperCab 129 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 130
• F-Series Crew Cab Tether strap Rear folding seat system with load floor section in this chapter for information on how to operate the rear seats. 5. Clip the tether strap to the anchor as shown. • Front seats (Regular Cab) • Front seat (SuperCab) 130 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 131
• Rear seats (Crew Cab) If the tether strap is clipped incorrectly, the child safety seat may not be retained properly in the event of a collision. 6. Refer to the Installing child safety seats in combination lap and shoulder belt seating positions section of this chapter for further instructions - 2007 Ford F350 | Owner Guide 2nd Printing - Page 132
. Follow the instructions in this chapter. 4. Tighten the tether strap according to the child seat manufacturer's instructions. A single in the center rear seat and as an anchoring loop for child seats installed in the outboard rear seats. 132 2007 F-250/350/450/550 (f23) Owners Guide (post-2002- - 2007 Ford F350 | Owner Guide 2nd Printing - Page 133
(when you select the 4WD mode) has the ability to use all four wheels to power itself. This increases traction which may enable you to safely drive over terrain and road conditions that a conventional two-wheel drive vehicle cannot. 133 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 134
4WD vehicles allow you to select different drive modes as necessary. Information on shifting procedures and maintenance can be found in your Owner's Guide quicker to respond to steering inputs than a vehicle with a longer wheelbase. 134 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 135
trucks Ford to give you the following information about tire grades exactly as the government has written it. Treadwear The treadwear grade is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified 135 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 136
conditions of their use, however, and may depart significantly from the norm due to variations in driving habits, service controlled conditions on a specified indoor laboratory test wheel. Sustained high weight the vehicle can carry. 136 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 137
the vehicle. • Rim: The metal support (wheel) for a tire or a air pressure without appearing flat. Every day before you drive, check your tires. If one looks lower than the others, use a tire gauge to check pressure of all tires and adjust if required. 137 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 138
Ford Motor Company. Use a tire gauge to check the tire inflation pressure, including the spare (if equipped), at least monthly and before long trips. You are strongly urged to buy a reliable tire pressure gauge, as automatic service 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 139
descriptions): Store and maintain at the higher of the front and rear inflation pressure as shown on the or Safety Compliance and cause an air leak. 7. Check the sidewalls to make sure there are no gouges, cuts or bulges. 139 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 140
they cannot be treated like normal light truck tires. Tire service, including adjusting the air pressure, must be performed by personnel add air to tires or replace tires or wheels without first taking precautions to protect persons and property. 140 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 141
glass that may be wedged in the tread grooves. Check for holes or cuts that may permit air leakage from the tire and make necessary repairs. Also inspect the tire sidewalls for cracking, cuts, more likely to blow out or fail. 141 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 142
frequent high loading conditions can accelerate the aging process and may require tires to be replaced more frequently. You should replace your spare tire when you replace the road tires or after 6 years due to aging even if it has not been used. 142 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 143
Identification Number for safety standard certification and in case of a recall provided by Ford. The steering, suspension, axle or transfer case/power transfer unit failure. If you have questions regarding tire replacement, see an authorized dealer. 143 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 144
is recommended that the two front tires or two rear tires generally be replaced as a pair. Safety practices Driving habits have a great deal to do with your tire mileage and safety. • Observe point indicated on the speedometer. 144 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 145
the scheduled maintenance information that comes with your vehicle) will help your tires wear more evenly, providing better tire performance and longer tire life. Unless otherwise specified, rotate the tires approximately every 5,000 miles (8,000 km). 145 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 146
Tires, Wheels and Loading • Rear Wheel Drive (RWD) vehicles/Four Wheel Drive (4WD) (front tires at top of diagram) Sometimes irregular tire wear can be corrected by must be checked and adjusted to the vehicle requirements. 146 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 147
dual rear wheels it is recommended that the front and rear tires (in pairs) be rotated only side to side. We do not recommend splitting up the dual rear wheels. Tire Identification Number for safety standard certification and in case of a recall. 147 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 148
for service on cars, SUVs, minivans and light trucks. weight a tire can carry. You may find this information in your Owner's Guide conditions. The ratings range from 81 mph (130 km/h) to 186 mph (299 km/h). These ratings are listed in the following chart. 148 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 149
25th week of 2001. The numbers in between are identification codes used for traceability. This information is used to contact customers if a tire defect requires a recall. 9. M+S or M/S: Mud and Snow, or for your vehicle. 149 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 150
is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150 would wear one as standard load, radial tubeless, etc. 150 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 151
on the rear axle (a total of six or more tires on the vehicle). 4. Maximum Load Single lb. (kg) at psi (kPa) cold: Indicates the maximum load and tire pressure when the tire is used as a single; defined as two tires (total) on the rear axle. 151 2007 F-250/350/450/550 (f23) Owners Guide (post-2002 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 152
by the Tire and Rim Association (T&RA), that is intended for temporary service on cars, SUVs, minivans and light trucks. 2. 145: Indicates the nominal width of the tire in millimeters from - with and without a trailer section. 152 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 153
chains on front tires of . If this does not work, remove the chains to suspension insulation and bumpers will help prevent Weight - is the weight of your new vehicle when you picked it up from your authorized dealer plus any aftermarket equipment. 153 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 154
. The appropriate loading capacity of your vehicle can be limited either by volume capacity (how much space is available) or by payload capacity (how much weight the vehicle should carry vehicle control and vehicle rollover. 154 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 155
equipment. When towing, trailer tongue load or king pin weight is also part of cargo weight. GAW (Gross Axle Weight) - is the total weight placed on each axle (front and rear) - including vehicle curb weight and all payload. 155 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 156
For trailer towing information refer to Trailer towing found in this chapter or the RV and Trailer Towing Guide provided by your authorized dealer. GVW (Gross Vehicle Weight) - is the Vehicle Curb Weight + cargo + passengers. 156 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 157
conventional trailer) or king pin weight of 15-25% (fifth wheel trailer), and driver only (150 lb. [68 kg]). Consult your authorized dealer (or the RV and Trailer Towing Guide provided by your authorized dealer) for more detailed information. 157 2007 F-250/350/450/550 (f23) Owners Guide (post-2002 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 158
0.25 to obtain a proper king pin load range of 1,725 to 2,875 lb. (782 to 1,304 kg) Do not exceed the GVWR or the GAWR specified on Consult this manual to determine how this reduces the available cargo and luggage load capacity of your vehicle. 158 2007 F-250/350/450/550 (f23) Owners Guide (post- - 2007 Ford F350 | Owner Guide 2nd Printing - Page 159
manner that does not overload the Front or the Rear Gross Axle Weight Rating specified for your vehicle on the Tire Label or Safety Compliance Certification Label found on the edge of the driver's door. Special loading instructions for owners of pickup trucks and utility-type vehicles For important - 2007 Ford F350 | Owner Guide 2nd Printing - Page 160
vehicle's engine, transmission, axle, brakes, tires and suspension. Inspect these components carefully prior to and after any towing operation. Refer to Transmission fluid temperature gauge in the Instrument Cluster chapter for the transmission fluid temperature information. 160 2007 F-250/350/450 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 161
the vehicle's GCWR, GVWR, GAWR or tire ratings could result in engine damage, transmission damage, structural damage, loss of vehicle control, vehicle rollover and personal injury. Maximum GCWR - lb. (kg.) Rear axle Manual Automatic ratio transmission transmission F-250/F-350 Single Rear Wheel (SRW - 2007 Ford F350 | Owner Guide 2nd Printing - Page 162
(2721) 12500 (5670) 600 (272) 1250 (567) Towing trailers beyond the maximum tongue weight exceeds the limit of the towing system and could result in vehicle structural damage, loss of vehicle control and personal injury. 162 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 163
point on the front and rear bumpers at the center of the vehicle. 3. Attach the trailer to the vehicle and adjust the hitch equalizers so that the front bumper height is within rated for operation at the GVWR not GCWR. 163 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 164
pressure. The Ford TBC has only been verified to be compatible with trailers having electric-actuated drum brakes (one to four axles) and not the manual control will display the GAIN setting, OUTPUT bar graph and light the trailer indicator red. 164 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 165
adjusting GAIN section for instructions on proper use of this feature). If the manual control is activated 1. Make sure the trailer brakes are in good working condition, functioning normally, and properly adjusted. See your trailer 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 166
km/h) and squeeze the manual control lever completely. 6. If instrument cluster messages: The TBC interacts with the instrument cluster bumper. If the message is only displayed with a trailer connected, the problem Ford warranty. 166 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 167
.4 mm) shank diameter. The bumper has a 5,000 lb. (2,270 kg) trailer weight and 500 lb. (227 kg) tongue weight capacity. If it is necessary to relocate the trailer hitch ball position, a frame-mounted trailer hitch must be installed. 167 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 168
long distances, your vehicle will require more frequent service intervals. Refer to your scheduled maintenance information for more information. Trailer towing safety tips General • Ensure that the trailer, safety chains and 7-pin electrical connectors are securely fastened. • Make sure the truck - 2007 Ford F350 | Owner Guide 2nd Printing - Page 169
up • Practice backing up, particularly if you are a novice. Turn the steering wheel to the right to move the trailer's rear end to the right. • Sharp steering movements may cause the trailer to jackknife or go out of control. 169 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 170
driveability, emissions and reliability. Replace front and rear axle lubricants any time the axles have been submerged in water. Axle lubricant quantities are not to be checked unless a leak is suspected. RECREATIONAL TOWING This applies to all 4x2 trucks with rear wheel drive capability. An - 2007 Ford F350 | Owner Guide 2nd Printing - Page 171
shift transfer case vehicles with automatic transmissions: Regarding recreational towing or having your vehicle towed, 4x4 vehicles with electronic shift on the fly cannot be towed with any wheels on the ground unless the rear driveshaft is removed and the front hub locks are in free mode (with - 2007 Ford F350 | Owner Guide 2nd Printing - Page 172
removal. For vehicles equipped with a manual transmission, you must depress the ignition release lever to release the key. 3 2 1 4 5 3. OFF, shuts off the engine and all accessories without locking the steering wheel. This position also allows the automatic transmission shift lever to be moved - 2007 Ford F350 | Owner Guide 2nd Printing - Page 173
Exhaust fumes can be toxic. Always open the garage door before you start the engine. See Guarding against exhaust fumes in this chapter for more instructions. If you smell exhaust headlamps and electrical accessories are off. 173 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 174
an automatic transmission: 1. Make sure the parking brake is set. 2. Make sure the gearshift is in P (Park). If starting a vehicle with a manual transmission: 1. Make sure the parking brake is set. 2. Push the clutch pedal to the floor. 174 2007 F-250/350/450/550 (f23) Owners Guide (post-2002 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 175
Driving • Turn the key to 4 (ON) without turning the key to 5 (START). 4 3 5 2 1 175 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 176
Carbon monoxide is present in exhaust fumes. Take precautions to avoid its dangerous effects. If you smell exhaust fumes inside your vehicle, have your dealer inspect your vehicle immediately. Do not drive if you smell exhaust fumes. 176 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 177
or shudder in the steering wheel while braking, the vehicle should be inspected by your authorized dealer. Refer to Brake system warning ! P light in the Instrument Cluster chapter for information on the brake BRAKE system warning light. 177 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt - 2007 Ford F350 | Owner Guide 2nd Printing - Page 178
increase your vehicle's stopping distance. The ABS will be activated immediately, allowing you to retain full steering control during hard braking and on slippery surfaces. However, the ABS does not decrease stopping distance. 178 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 179
down until the pedal stops. The BRAKE warning lamp in the instrument cluster illuminates and remains illuminated until the parking brake is released. Pull (Park) (automatic transmission) or in 1 (First) (manual transmission). 179 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 180
steering components are serviced or replaced, install new fasteners (many are coated with thread adhesive or have prevailing torque features which may not be re-used). Never re-use a bolt or nut. Torque fasteners to specifications in Workshop Manual. 180 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 181
or high crosswinds may also make the steering seem to wander/pull. TRACTION-LOK AXLE (IF EQUIPPED) This axle provides added traction on slippery surfaces, particularly when one wheel is on a poor traction surface. Under normal conditions, the Traction-Lok axle functions like a standard rear axle - 2007 Ford F350 | Owner Guide 2nd Printing - Page 182
lever, it is possible that a fuse has blown or the vehicle's brakelamps are not operating properly. Refer to Fuses and relays in the Roadside Emergencies may not be working properly. See your authorized dealer as soon as possible. 182 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 183
may occur. After this learning process, normal shift feel and shift scheduling will resume. P (Park) This position locks the transmission and prevents the rear wheels from turning. To put your vehicle in gear: • Start the engine • Depress the brake pedal • Move the gearshift lever into the desired - 2007 Ford F350 | Owner Guide 2nd Printing - Page 184
Haul OFF). Do not use the Tow/Haul feature when driving in icy or slippery conditions as the increased engine braking can cause the rear wheels to slide and the vehicle to swing around with the possible loss of vehicle control. 184 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 185
occur, or the engine may overheat. MANUAL TRANSMISSION OPERATION (IF EQUIPPED) R 1 3 D L 2 4 Using the clutch The manual transmission has a starter interlock that prevents cranking the engine unless the clutch pedal is fully depressed. 185 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt - 2007 Ford F350 | Owner Guide 2nd Printing - Page 186
the neutral position. 3. Start the engine. 4. Press the brake pedal and move the gearshift lever to the desired gear; 1 (First) or R (Reverse). 5. Release the parking brake, 40 mph (64 km/h) 15 mph (24 km/h) 4 - D (Overdrive) 186 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 187
4WD equipped vehicles. Downshift at lower speeds when driving on slippery surfaces. 1 2 Reverse 1. Make sure that your vehicle is at a complete stop before you shift into R (Reverse). Failure to do so may damage the transmission 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 188
remove the key. PUSH REVERSE SENSING SYSTEM (IF EQUIPPED) The Reverse Sensing System (RSS) sounds a tone to warn the driver of obstacles near the rear bumper when the R (Reverse) is selected and the may create false beeps. 188 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 189
recycled. Keep the RSS sensors (located on the rear bumper/fascia) free from snow, ice and large accumulations of dirt (do not clean the sensors with sharp objects). If the sensors are covered, it will affect the accuracy of the RSS. 189 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 190
with the electronic shift 4WD System, and the instrument panel control is moved to 4X4 LOW(4WD Low) while the vehicle is moving above 3 mph (5 km/h), the system will not engage and no damage will occur to the 4WD system. Before 4X4 190 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 191
following conditions. If these lights illuminate when driving in 2WD, contact your authorized dealer as soon as possible. • 4x4 - momentarily illuminates after the engine is started. Illuminates when 4H (4x4 High) or 4L (4x4 Low) is engaged. 4x4 191 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 192
speed below 3 mph (5 km/h). • For proper operation, make sure that both indicator arrows on the hub are aligned, and that both hubs are set to LOCK. • Do not shift into 4H (4WD High) with the rear wheels slipping. 2H 4H N 4L 192 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 193
move at a speed above 1 mph (1.6 km/h), then repeat steps 2 and 3. 5. If shifting to 2H (2WD High) with the vehicle at a complete stop, disengage the locking hubs (optional) by rotating the hub lock control from LOCK to FREE. 193 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 194
off-road conditions. Sends power to front and rear wheels. 4L (4WD Low) - For low-speed off-road applications that require extra power such as steep grades, deep sand or pulling a boat out of the water. Sends power to front and rear wheels. 194 2007 F-250/350/450/550 (f23) Owners Guide (post-2002 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 195
your front hubs, but it will eliminate any torque bind and allow the system to immediately disengage. Shifting from 4x4 HIGH (4WD High) to 4x4 LOW (4WD Low) 1. Bring the vehicle to a complete stop. 2. Depress the brake. 3. Place the gearshift in N (Neutral). 195 2007 F-250/350/450/550 (f23) Owners - 2007 Ford F350 | Owner Guide 2nd Printing - Page 196
LOW (4WD Low) to 4x4 HIGH (4WD High) or 2WD (2WD High) 1. Bring the vehicle to a complete stop. 2. Depress the brake. 3. Place the gearshift in N (Neutral). 4. Move the 4WD control to the 4x4 HIGH (4WD High) or 2WD (2WD High) position. 5. Hold the shift conditions until the LOW RANGE indicator light - 2007 Ford F350 | Owner Guide 2nd Printing - Page 197
drive components. 4WD modes are only intended for consistently slippery or loose surfaces. • Drive slower in strong crosswinds which can affect the normal steering characteristics of your others should be your primary concern. 197 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 198
return the vehicle to a safe direction of travel. • In the event of an emergency stop, avoid skidding the tires and do not attempt any sharp steering wheel movements. 198 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 199
a transfer case. On 4WD vehicles, the transfer case allows you to select 4WD when necessary. Information on transfer case operation and shifting procedures can be found in the Driving chapter. Information on transfer case maintenance 199 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 200
until you regain control of the vehicle. If the transmission, transfer case or front axle are submerged in water, their fluids should be checked and changed, if necessary. Driving through deep water may damage the transmission. 200 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 201
Driving Refer to Transmission temperature gauge in the Instrument Cluster chapter for transmission fluid temperature information. If the front or rear axle is submerged in water, the axle lubricant should be replaced. After driving through mud, clean off residue stuck to rotating driveshafts and - 2007 Ford F350 | Owner Guide 2nd Printing - Page 202
neutral; instead, manually shift to a lower to road conditions. Make sure so that you may steer in the direction front tires of 4WD vehicles without also putting them on the rear tires. This could cause the rear to slide and swing around during braking. 202 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 203
the duration of operation limit for the aftermarket PTO may be less than 10 minutes. A more complete description of PTO operation is discussed in the Ford Truck Body Builders Layout Book, found at www.fleet.ford.com/truckbbas. 203 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 204
and satisfy Ford compliance certification to FMVSS. Exceeding this weight may require the auxiliary equipment installer additional safety certification responsibility. The Front Accessory Reserve Capacity (FARC) is added for customer convenience. 204 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 205
airflow to the radiator. • If you are driving less than 15 miles (24 km) at speeds up to 40 mph (64 km/h) in cold weather you will not need to adjust blade position Follow the severe duty schedule in your scheduled maintenance information for engine oil and transmission fluid change intervals - 2007 Ford F350 | Owner Guide 2nd Printing - Page 206
for more than a minute. The transmission and tires may be damaged or the engine may overheat. Refer to Transmission fluid temperature gauge in the Instrument Cluster chapter for transmission fluid temperature information. 206 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 207
the snowplow frame mount A metal crossmember is included below the front bumper on Super Duty vehicles called a "BlockerBeam". Typical snowplow installations require removal of this ensure proper airbag deployment in a crash. 207 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 208
covered up to $100 if the disabled eligible vehicle requires service at the nearest authorized dealer. If the trailer is disabled, but the towing vehicle is operational, the trailer does not qualify for any roadside services. 208 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 209
yourself, Ford Motor Company will reimburse a reasonable amount. To obtain reimbursement information, U.S. Ford or Warranty's Roadside Assistance expiring. For more information and enrollment, contact 1-877-294-2582 or visit our website at www.ford.ca. 209 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 210
battery. FUEL PUMP SHUT-OFF SWITCH This device stops the electric fuel pump from sending fuel to the engine when your vehicle has had a substantial jolt. After an accident, if the engine cranks but does not start, this switch may have been activated. 210 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 211
before replacing any electrical components. 15 Note: Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire. 211 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 212
of the steering wheel by the brake pedal. Remove the panel cover to access the fuses. To remove the fuse panel cover, pull the panel downward by the finger slots on top of the panel. When the top clips of the panel disengage, let the panel fall easily. 212 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 213
servicing high current fuses. Always replace the cover to the passenger compartment fuse panel before reconnecting the battery. If the battery has been disconnected and reconnected, refer to the Battery section of the Maintenance and Specifications chapter. 213 2007 F-250/350/450/550 (f23) Owners - 2007 Ford F350 | Owner Guide 2nd Printing - Page 214
Compartment Fuse Panel Description Adjustable pedals Cluster Upfitter #3 Power point (Instrument panel) Upfitter #4 Not used High beam headlamps, Flash-to-pass Back-up lamps Not used Not used Radio (Main) Cigar lighter, OBD II Power mirrors Not used 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 215
) Cluster, 4x4, Wipers BOO switch (Low current) Instrument cluster Not used Horn Trailer tow park lamps Heated mirrors 215 24 15A* 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 - 10A* 15A* 10A* 10A* 15A* 15A* 5A* 15A* 10A* 10A* - 15A* 20A* 15A* 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 216
ISO relay Full ISO relay - Passenger Compartment Fuse Panel Description Fuel pump Instrument cluster Delayed accessory Fog lamps Not used Ignition switch RUN/START used Trailer tow battery charge Powertrain Control Module (PCM) Not used 216 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt - 2007 Ford F350 | Owner Guide 2nd Printing - Page 217
Battery section of the Maintenance and Specifications chapter. Fuse/Relay Location 304 305 306 307 601 Passenger Compartment Fuse Panel Description Not used Upfitter control Delayed accessory Starter Delayed accessory, Power windows, Moonroof Not used 217 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 218
Trailer tow turn signals Powertrain Control Module (PCM) keep alive power, Canister vent solenoid (gasoline engine only) Anti-lock Brake System (ABS) Brake pressure switch Daytime Running Lamps (DRL) 11 12 13 218 10A** 2A** 15A** 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 219
used Trailer tow back-up lamps Not used ABS (Coils) ABS (Pump) Trailer tow right turn signal/stop lamp Trailer tow left turn signal/stop lamp A/C clutch Not used DRL #1 DRL #2 DRL #3 Not used Blower IDM (Diesel engine only) 219 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 220
as possible with a road tire/wheel that is the same size and type as the road tires and wheels that were originally provided by Ford. If the dissimilar spare tire or wheel is damaged, it should be replaced rather than repaired. 220 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 221
driving capability It is not recommended that the vehicle be operated in 4WD modes with a temporary emergency spare tire. If 4WD operation is necessary, do not operate above speeds of 10 mph with the dissimilar spare tire/wheel 221 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 222
a full-size dissimilar spare tire/wheel and seek service as soon as possible. T-type/Mini-spare tire information (Harley-Davidson only) Your vehicle may be equipped with a temporary and braking performance • Comfort and noise 222 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 223
rear bumper Regular cab, Super Cab without rear bench seat and Crew Cab: Fastened to floor pan behind rearmost seat on passenger side SuperCab with rear bench seat: Under rear bench on passenger side Regular cab: Fastened to floor behind front seat Super Cab: Fastened to floor under rear seat Crew - 2007 Ford F350 | Owner Guide 2nd Printing - Page 224
rear wheels, insert the lug wrench extension into the lug wrench to reach the lug nuts. 2. Attach the spare tire lock key (A) to the jack handle (B). 3. Fully insert the jack handle through the bumper hole and into the guide 224 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 225
is in P (Park) (automatic transmission) or R (Reverse) (manual transmission). To prevent the vehicle from moving when you change the tire, be sure that the parking brake is set and the diagonally opposite wheel is blocked. 225 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 226
to slide the jack under the vehicle. 7. Position the jack according to the following guides: • Front (4x2) • Front driver side (4x4) Note: Make sure the jack fits onto the flat area on the outboard side of the differential. 226 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 227
the jack. The jack is only meant for changing the tire. 8. Turn the jack handle clockwise until the wheel is completely off the ground and high enough to install the spare tire. 9. Remove the lug nuts with the lug wrench. 227 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 228
according to the following guides: • Front (4x2): F-350 DRW Note: Place jack directly under I-beam. • Front driver side (4x4): F-350 DRW Note: Make sure the jack fits onto the flat area on the outboard side of the differential housing. 228 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt - 2007 Ford F350 | Owner Guide 2nd Printing - Page 229
Roadside Emergencies • Front passenger side (4x4): F-350 DRW Note: View shown from the rear of the vehicle to clearly identify the jack point. Note: Place the jack directly under axle and inboard of the radius arm so that the jack clears the radius arm. • Front: F-450/F-550 • Rear: F-450/F-550 14. - 2007 Ford F350 | Owner Guide 2nd Printing - Page 230
outward on all front an inboard rear wheels. If replacing the outboard wheel, the valve stem must be facing inward. Reinstall the lug nuts until the wheel is snug against the hub. Do not sequence 10-lug nut torque sequence 230 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 231
maintenance information), or at any time that the spare tire is disturbed through service of other components. 6. If removed, install the spare tire lock (if equipped) into the bumper drive tube with the spare tire lock key (if equipped) and jack handle. 231 2007 F-250/350/450/550 (f23) Owners - 2007 Ford F350 | Owner Guide 2nd Printing - Page 232
hub and rotor that contacts the wheel. Installing wheels without correct metal-to-metal contact at the wheel mounting surfaces can cause the wheel nuts to loosen and the wheel to come off while the vehicle is in motion, resulting in loss of control. 232 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 233
remove any excessive corrosion before you attach the battery cables. Ensure that vent caps are tight and level. 5. Turn the heater fan on in both vehicles to protect from any electrical surges. Turn all other accessories off. 233 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 234
Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Connect the other end of the positive (+) cable to the positive (+) terminal of the assisting battery. 234 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - - - + - + + + - 2007 Ford F350 | Owner Guide 2nd Printing - Page 235
, belts, moving parts of both engines, or any fuel delivery system parts. Jump starting 1. Start the engine of the booster vehicle and run the engine at moderately increased speed. 2. Start the engine of the disabled vehicle. 235 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 236
engines for an additional three minutes before disconnecting the jumper cables. Removing the jumper cables Remove the jumper cables in the reverse ) battery. 2. Remove the jumper cable on the negative (-) connection of the booster vehicle's battery. 236 2007 F-250/350/450/550 (f23) Owners Guide ( - 2007 Ford F350 | Owner Guide 2nd Printing - Page 237
the positive (+) terminal of the disabled vehicle's battery. After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 238
case vehicles, the front wheel hub locks are in the FREE position prior to towing. Note: Towing an ESOF 4WD vehicle with the front wheels on the ground without disengaging the front hubs may cause damage to the automatic transmission. 238 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt - 2007 Ford F350 | Owner Guide 2nd Printing - Page 239
incorrectly, vehicle damage may occur. Ford Motor Company produces a towing manual for all authorized tow truck operators. Have your tow truck operator refer to this manual for proper hook-up and towing procedures for your vehicle. 239 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 240
authorized dealer to help you. In the United States: Ford Motor Company Customer Relationship Center P.O. Box 6248 Dearborn, MI 48121 1-800-392-3673 (FORD) (TDD for the hearing impaired: 1-800-232-5952) www.customersaskford.com 240 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 241
odometer reading • The vehicle identification number (VIN) Additional Assistance If you still have a complaint involving a warranty dispute, you may wish to contact the Better Business Bureau (BBB) AUTO LINE program (U.S. only). 241 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 242
to its applicable express warranties if, within the first condition that substantially impairs the use, value or safety of the vehicle) OR 3. The vehicle is out of service Ford Motor Company 16800 Executive Plaza Drive Mail Drop 3NE-B Dearborn, MI 48126 242 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 243
, Suite 800 Arlington, Virginia 22203-1833 Note: Ford Motor Company reserves the right to change eligibility limitations, modify procedures, or to discontinue this process at any time without notice and without obligation. 243 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 244
for your new car or light truck by purchasing Ford Extended Service Plan (Ford ESP) coverage. It provides the following: • Benefits during the warranty period depending on the plan you purchase (such as: reimbursement for rentals; coverage for certain maintenance and wear items). • Protection - 2007 Ford F350 | Owner Guide 2nd Printing - Page 245
in North America and then relocate outside of the U.S. or Canada, register your vehicle identification number (VIN) and new address with Ford Motor Company Export Operations. Customers in the U.S. should call 1-800-392-3673. 245 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 246
, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Ford Motor Company. 246 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 247
400 Seventh Street, SW Washington, D.C. 20590 You can also obtain other information about motor vehicle safety from http://www.safercar.gov. REPORTING SAFETY DEFECTS (CANADA ONLY) If you their toll-free number: 1-800-333-0510. 247 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 248
to the vehicle's paintwork and trim over time. • Remove any exterior accessories, such as antennas, before entering a car wash. • Suntan lotions and non-body (low-gloss black) colored trim, such as grained door handles, roof 248 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 249
. • Do not spray a hot engine with cold water to avoid cracking the engine block or other engine components. • Spray Motorcraft Engine Shampoo and Degreaser (ZC-20) on all parts that require cleaning and pressure rinse clean. 249 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 250
damage when cleaning the engine. • 5.4L V8 gasoline engine • 6.8L V10 gasoline engine PLASTIC (NON-PAINTED) EXTERIOR PARTS Use only approved products to clean plastic parts. These products are available from your authorized dealer. 250 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 251
AND WIPER BLADES The windshield, rear and side windows and the wiper thinner to clean any parts. INSTRUMENT PANEL AND CLUSTER LENS Clean the instrument panel with a damp cloth when cleaning the steering wheel or instrument panel to 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 252
vacuum cleaner. • Remove light stains and soil with Motorcraft KING RANCH F-250 AND F-350 CREWCAB) Your leather seating surfaces have a clear, protective coating over the leather. For King Ranch F-250 and F-350 , or oil/petroleum-based 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 253
cleaning information, contact the King Ranch Saddle Shop at 1-800-282-KING (5464). • Do not spill coffee, ketchup, mustard, orange juice or oil-based products on the following the same instructions as in the Conditioning section. 253 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 254
King Ranch Leather Conditioner, use another premium leather conditioner. • Apply your first conditioning treatment within six months of taking delivery of your vehicle. Condition twice yearly in order to replenish lost oils -A) 254 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 255
only) (ZC-11-A) Detail Wash (ZC-3-A) Dusting Cloth (ZC-24) Engine Shampoo and Degreaser (U.S only) (ZC-20) Engine Shampoo (Canada only) (CXC-66-A) One Step Wash and Wax Concentrate (ZC (CXC-94) Wheel and Tire Cleaner (ZC-37-A) 255 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 256
in the engine compartment for easy location. • We provide a scheduled maintenance guide which makes tracking routine service easy. If your vehicle requires professional service, your authorized dealer can provide the necessary parts and service. Check your Warranty Guide/Owner Information Guide to - 2007 Ford F350 | Owner Guide 2nd Printing - Page 257
of the instrument panel. 2. Go to the front of the vehicle and release the auxiliary latch located under the right center of the hood. Slide the handle to release the auxiliary latch. 3. Lift the hood until the lift cylinders hold it open. 257 2007 F-250/350/450/550 (f23) Owners Guide (post-2002 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 258
Brake fluid reservoir 5. Clutch fluid reservoir (manual transmission) 6. Power distribution box 7. Power steering fluid reservoir 8. Engine oil dipstick 9. Engine oil filler cap 10. Windshield washer fluid reservoir 11. Battery 258 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 259
4. Clutch fluid reservoir (manual transmission) 5. Power distribution box 6. Power steering fluid reservoir 7. Air filter assembly 8. Engine oil dipstick 9. Engine oil filler cap 10. Windshield washer fluid reservoir 11. Battery 259 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 260
wiper blade down toward the windshield to remove it from the arm. 2. Attach the new wiper to the wiper arm and press it into place until a click is heard. 3. Replace wiper blades at least once per year for optimum performance. 260 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 261
is securely latched in P (Park) (automatic transmission) or 1 (First) (manual transmission). 4. Open the hood. Protect yourself from engine heat. 5. Locate and carefully remove the engine oil level indicator (dipstick). 261 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 262
Maintenance and Specifications • 5.4L V8 engine • 6.8L V10 engine 262 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 263
the engine oil filler cap by turning the filler cap clockwise 1/4 of a turn or until the cap is fully seated. To avoid possible oil loss, DO NOT operate the vehicle with the engine oil level indicator and/or the engine oil filler cap removed. 263 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 264
not covered by Ford warranty. Change your engine oil and filter according to the appropriate schedule listed in the scheduled maintenance information. Ford production and aftermarket (Motorcraft) oil filters are designed for added engine protection and long life. If a replacement oil filter is used - 2007 Ford F350 | Owner Guide 2nd Printing - Page 265
can cause personal injury. Therefore, do not allow flames, sparks or lighted substances to come near the battery. When working near the battery, always shield your face and protect your eyes. Always provide proper ventilation. 265 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 266
(16 km) or more to relearn the idle and fuel trim strategy. • If you do not allow the engine to relearn its idle trim, the idle quality of your vehicle may be adversely affected until the idle trim is eventually relearned. 266 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 267
batteries. RE LE AD TU RN RECYCLE ENGINE COOLANT Checking engine coolant The concentration and level of engine coolant should be checked at the mileage (kilometer) intervals listed in the scheduled maintenance to work properly. 267 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 268
location. Adding engine coolant When adding coolant, make sure it is a 50/50 mixture of engine coolant and distilled water. Add the mixture to the coolant reservoir, when the engine is cool, until the appropriate fill level is obtained. 268 2007 F-250/350/450/550 (f23) Owners Guide (post-2002 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 269
vehicles which have a coolant degas system with a pressurized cap, or if it is necessary to remove the coolant pressure relief cap on the radiator of a vehicle with an overflow system, follow these steps to add engine coolant. 269 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 270
engine damage. Recycled engine coolant Ford Motor Company does NOT recommend the use of recycled engine coolant in vehicles originally equipped with Motorcraft Premium Gold Engine Coolant since a Ford-approved recycling process is not yet available. 270 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 271
your vehicle is equipped with a diesel engine, refer to the Maintenance Product Specifications and Capacities section of your 6.0 Liter Power Stroke Direct Injection Turbo Diesel Owner's Guide Supplement. Fill your engine coolant reservoir as outlined in Adding engine coolant in this section. Severe - 2007 Ford F350 | Owner Guide 2nd Printing - Page 272
high-speed operation and the engine will run rough. Remember that the engine is capable of completely shutting down automatically to prevent engine damage, therefore: 1. Pull off the road as soon as safely possible and turn off the engine. 272 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 273
engine problem increases the chance of engine damage. Take your vehicle to a service facility as soon as possible. FUEL FILTER For fuel filter replacement, see your authorized dealer. Refer to the scheduled maintenance . 273 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 274
Maintenance gasoline is highly toxic and engine off and never allow sparks or open flames near the filler neck. Never smoke while refueling. Fuel vapor is extremely hazardous under certain conditions. Care should be taken to avoid inhaling excess fumes. 274 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 275
Maintenance and Specifications The flow of avoid injuries to you and others: Read and follow all the instructions on the pump island; Turn off your engine when you are refueling; Do not smoke if you are near until it clicks. 275 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 276
that is designed for your vehicle. The vehicle warranty may be void for any damage to the fuel tank or fuel system if the correct genuine Ford or Motorcraft fuel filler cap is not used. than regular fuel. We recommend using 276 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 277
your warranty. high altitude areas. Do not be concerned if your engine sometimes knocks lightly. However, if it knocks heavily under most driving conditions air Ford endorses the use of reformulated "cleaner-burning" gasolines to improve air quality. 277 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 278
Service engine soon indicator ( ) may come on. For more information on the Service engine soon indicator, refer to the Instrument Cluster chapter of the advertised capacity of the fuel tank due to the empty reserve still present in the tank. 278 2007 F-250/350/450/550 (f23) Owners Guide (post-2002- - 2007 Ford F350 | Owner Guide 2nd Printing - Page 279
economy habits Give consideration to the lists that follow and you may be able to change a number of variables and improve your fuel economy. 279 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 280
Use recommended engine oil. Refer to Maintenance Product Specifications and Capacities in this chapter. • Perform all regularly scheduled maintenance items. Follow the recommended maintenance schedule and owner maintenance checks found in your vehicle's scheduled maintenance information. Conditions - 2007 Ford F350 | Owner Guide 2nd Printing - Page 281
information performed according to the specified schedule. The scheduled maintenance items listed in the scheduled maintenance information are essential to the life and performance of your vehicle and to its emissions system. 281 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 282
genuine Ford Motor Company parts in performance and durability. Do not park, idle, or drive your vehicle in dry grass or other dry ground cover. The emission system heats up the engine compartment and exhaust system, which can start a fire. Illumination of the Service engine soon light ( ), charging - 2007 Ford F350 | Owner Guide 2nd Printing - Page 283
off the engine until the above driving cycle is complete. POWER STEERING FLUID Check the power steering fluid. Refer to the scheduled maintenance information for the service interval schedules. If adding fluid is necessary, use only MERCON ATF. 283 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 284
Maintenance and Specifications • Gasoline engine shown; diesel engine similar. Refer to Identifying components in the engine compartment in the 6.0/6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner Guide the reservoir. 284 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 285
) Check the clutch fluid level. Refer to the scheduled maintenance information for the service interval schedules. Use only a DOT 3 brake fluid designed to meet Ford specifications. Refer to Maintenance product specifications and capacities in this chapter. Carefully read cautionary information on - 2007 Ford F350 | Owner Guide 2nd Printing - Page 286
(if equipped) Refer to your scheduled maintenance information for scheduled intervals for fluid checks and changes. Your transmission does not consume fluid. However, the fluid level should be checked if the transmission is not working properly, i.e., if the transmission slips or shifts slowly or if - 2007 Ford F350 | Owner Guide 2nd Printing - Page 287
and Capacities section in this chapter. Use of a non-approved automatic transmission fluid may cause internal transmission component damage. If necessary, add fluid in 1/2 pint (250 ml) increments through the filler tube until the level is correct. 287 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 288
mounted on the frame rail. Refer to the scheduled maintenance information for service intervals. To replace the transmission filter: 1. Shut off the engine. 2. Unscrew filter housing. 3. Replace filter with a new authorized Motorcraft filter element. Refer to the Motorcraft part numbers chart - 2007 Ford F350 | Owner Guide 2nd Printing - Page 289
Maintenance and Specifications Checking and adding manual transmission fluid (if equipped) 1. Clean the filler Use only fluid that meets Ford specifications. Refer to Maintenance Product Specifications and Capacities in this chapter. 289 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA - 2007 Ford F350 | Owner Guide 2nd Printing - Page 290
to the scheduled maintenance information for the appropriate intervals for changing the air filter element. When changing the air filter element, use only the Motorcraft air filter element listed. Refer to Motorcraft part numbers in this chapter. 290 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 291
two retainer clamps. 2. Pull air filter tray assembly out toward front of vehicle and lift air filter element up and out of housing. The air filter box needs to be free of any debris before installing a new air filter. 291 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 292
and slots. Secure the clamps, making sure not to crimp the air filter edges between the two halves of the air filter housing. This could cause filter damage and allow unmetered air to enter the engine if not properly seated. 292 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 293
Maintenance and Specifications MOTORCRAFT PART NUMBERS Component Air filter element Fuel filter Oil filter PCV valve Battery (Standard) Battery (Optional) Spark plugs-platinum Remote Automatic Transmission Filter 3 1 5.4L V8 engine FA-1754 6.8L V10 engine FA-1782 FG-1011 FL-820-S 1 BXT-65-650 BXT - 2007 Ford F350 | Owner Guide 2nd Printing - Page 294
-A1 (yellow-colored) Motorcraft Premium 27.5 quarts VC-7-B / Gold Engine Coolant (26.0L) WSS-M97B51-A1 (yellow-colored) 5.8 pints (2.8L) Capacity Ford part name Ford part number / Ford specification 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) Maintenance and Specifications - 2007 Ford F350 | Owner Guide 2nd Printing - Page 295
Diesel Owner's Guide Supplement 19.0 gallons (71.9L) - - - - Multi-Purpose Grease Motorcraft Penetrating and Lock Lubricant - - - - XG-4 or XL-5 / ESB-M1C93-B XL-1 / None Engine oil (includes filter change) - diesel engine6 Fuel tank - Mid-ship tank (optional on Chassis Cab) Fuel tank - Short box - 2007 Ford F350 | Owner Guide 2nd Printing - Page 296
steering fluid Transfer case fluid Manual transmission fluid 5.8 quarts (5.5L)4 2.0 quarts (1.9L) Fill to FULL COLD range on dipstick Motorcraft MERCON ATF XT-2-QDX / MERCON XT-2-QDX / MERCON XT-2-QDX / MERCON 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) Maintenance - 2007 Ford F350 | Owner Guide 2nd Printing - Page 297
operating range. 6 Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the requirements of Ford specification WSS-M2C930-A and the API Certification mark. 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) Maintenance and Specifications 297 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 298
)* Coil on plug 9.8:1 6.8L V10 engine 415 87 octane 1-6-5-10-2-7-3-8-4-9 1.02-1.28mm (0.040-0.050 inch)* Coil on plug 9.2:1 *The 5.4L 3V and 6.8L 3V spark plug gap CANNOT be adjusted. Drivebelt routing 5.4L V8/6.8L V10 engines 298 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 299
Maintenance and Specifications identification number is attached to a metal tag and is located on the driver side instrument panel. (Please note that in the graphic XXXX is representative of your vehicle identification number.) XXXXXXXXXXXXXXXXX 299 2007 F-250/350/450/550 (f23) Owners Guide - 2007 Ford F350 | Owner Guide 2nd Printing - Page 300
or transaxle each code represents. Code 5 7 T B Description Six-speed manual, Dana (ZF S6-650) Six-speed manual, Dana (ZF M6HD-W) Five-speed automatic, TorqShift (gas engines) Five-speed automatic, TorqShift (diesel engine) 300 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 301
from high quality materials and meets or exceeds Ford's rigorous engineering and safety specifications. Ford Motor Company will repair or replace any properly authorized dealer-installed Genuine Ford Accessory found to be defective in factory-supplied materials or workmanship during the warranty - 2007 Ford F350 | Owner Guide 2nd Printing - Page 302
accessories or equipment to your vehicle: • When adding accessories, equipment, passengers and luggage to your vehicle, do not exceed the total weight capacity of the vehicle or of the front or rear axle (GVWR automotive use. 302 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 303
Antennas in the area of the driver's side hood. • Electrical or electronic accessories or components that are added to the vehicle by the authorized dealer or the owner may adversely affect battery performance and durability. 303 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 304
seat ...126 in rear seat ...126 Cleaning your vehicle engine compartment ...249 instrument panel ...251 interior ...252 interior trim ...252 plastic parts ...250 safety belts ...252 washing ...248 waxing ...248 wheels ...249 wiper blades ...251 2007 F-250/350/450/550 (f23) Owners Guide (post-2002 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 305
-259 starting after a collision ...210 Engine block heater ...177 Engine oil ...261 checking and adding ...261 dipstick ...261 filter, specifications ...264, 293 recommendations ...264 refill capacities ...294 Exhaust fumes ...176 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus - 2007 Ford F350 | Owner Guide 2nd Printing - Page 306
I Ignition ...172, 298 Infant seats (see Safety seats) ...125 Inspection/maintenance (I/M) testing ...283 Instrument panel cleaning ...251 cluster ...12 lighting up panel and interior ...46 J Jump-starting your vehicle ...233 306 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 307
distribution box (see Fuses) ...217 Power door locks ...85 Power mirrors ...64 Power point ...61 Power steering ...180 fluid, checking and adding ...283 fluid, refill capacity ...294 Power Windows ...62 Preparing to drive your vehicle ...181 307 2007 F-250/350/450/550 (f23) Owners Guide (post - 2007 Ford F350 | Owner Guide 2nd Printing - Page 308
103-105 for children ...121-122 lap belt ...106 safety belt maintenance ...112 warning light and chime ...107-108 Safety seats for children ...125 Safety ...164 trailer towing ...160 wrecker ...238 Traction-lok rear axle ...181 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus) - 2007 Ford F350 | Owner Guide 2nd Printing - Page 309
...177 W Warning lights (see Lights) ...12 Washer fluid ...260 Water, Driving through ...204 Windows power ...62 Windshield washer fluid and wipers ...59 checking and adding fluid ...260 replacing wiper blades ...260 Wrecker towing ...238 309 2007 F-250/350/450/550 (f23) Owners Guide (post-2002 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 310
310 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 311
311 - 2007 Ford F350 | Owner Guide 2nd Printing - Page 312
312
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
-
249
-
250
-
251
-
252
-
253
-
254
-
255
-
256
-
257
-
258
-
259
-
260
-
261
-
262
-
263
-
264
-
265
-
266
-
267
-
268
-
269
-
270
-
271
-
272
-
273
-
274
-
275
-
276
-
277
-
278
-
279
-
280
-
281
-
282
-
283
-
284
-
285
-
286
-
287
-
288
-
289
-
290
-
291
-
292
-
293
-
294
-
295
-
296
-
297
-
298
-
299
-
300
-
301
-
302
-
303
-
304
-
305
-
306
-
307
-
308
-
309
-
310
-
311
-
312
 |
 |
Introduction
4
Instrument Cluster
12
Warning lights and chimes
12
Gauges
16
Entertainment Systems
21
AM/FM stereo
21
AM/FM stereo with CD
23
AM/FM stereo with in-dash six CD
28
Satellite radio information
34
Climate Controls
38
Heater only
38
Manual heating and air conditioning
39
Automatic temperature control
41
Lights
44
Headlamps
44
Turn signal control
50
Bulb replacement
51
Driver Controls
59
Windshield wiper/washer control
59
Steering wheel adjustment
59
Power windows
62
Mirrors
64
Speed control
66
Upfitter controls
69
Moon roof
71
Message center
72
Tailgate
83
Table of Contents
1
2007 F-250/350/450/550
(f23)
Owners Guide (post-2002-fmt)
USA
(fus)