IBM 2658 Hardware Maintenance Manual
IBM 2658 - ThinkPad R32 - Pentium 4-M 1.8 GHz Manual
 |
UPC - 087944841135
View all IBM 2658 manuals
Add to My Manuals
Save this manual to your list of manuals |
IBM 2658 manual content summary:
- IBM 2658 | Hardware Maintenance Manual - Page 1
ThinkPad R32 Series Hardware Maintenance Manual - IBM 2658 | Hardware Maintenance Manual - Page 2
Before using this information and the product it supports, be sure to read the general information under "Introduction" on information herein; these changes will be incorporated in new editions of the publication. IBM may make improvements or changes in the products or the programs described in this - IBM 2658 | Hardware Maintenance Manual - Page 3
, reference, and product-specific parts information. Important This manual is intended for trained servicers who are familiar with ThinkPad products. Use this manual along with the advanced diagnostic tests to troubleshoot problems effectively. Before servicing an IBM ThinkPad product, be sure to - IBM 2658 | Hardware Maintenance Manual - Page 4
iv ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 5
Contents Preface iii ThinkPad R32 Series Hardware Maintenance Manual 1 Introduction 1 Important Service Information 1 Drive and Diskette . . 53 Intermittent Problems 53 Undetermined Problems 54 ThinkPad R32 Series Part I 55 Product overview 56 FRU removals and replacements 62 - IBM 2658 | Hardware Maintenance Manual - Page 6
ThinkPad R32 Series Part II 115 Product overview 116 FRU removals and replacements 122 Locations 158 Parts list 161 ThinkPad R32 Series Part III 175 Product overview 176 FRU removals and replacements 182 Locations 219 Parts list 222 Notices 241 Trademarks 242 vi ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 7
ThinkPad R32 Series Hardware Maintenance Manual Introduction Important Service Information Important Diskette fixes are customer-installable. The diskette fixes are posted on the IBM support site http://www.pc.ibm.com/support/ . Advise customers to contact the PC Company HelpCenter at 800-772-2227 - IBM 2658 | Hardware Maintenance Manual - Page 8
hard disk drive. Attention: The drive startup sequence in the computer you are servicing to-FRU Index for the computer you are servicing. How drives. Diskette Capacity 1.0MB 2.0MB 4.0MB 1.44MB Drive Read/Write Read/Write Not Compatible 2.88MB Drive Read/Write Read/Write Read/Write 2 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 9
In this manual, safety notices . Safety Notice 1 Before the computer is powered-on after FRU replacement, make sure all screws, springs, or other small Verify this by shaking the computer and listening for rattling sounds. Metallic parts or metal flakes can cause electrical shorts. 2658/2659/2677 3 - IBM 2658 | Hardware Maintenance Manual - Page 10
disassemble it, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery kann zu Entzündung oder Explosion führen. 4 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 11
(Continued) Alcune batterie di riserva contengono una piccola quantità di nichel e cadmio. Non smontarle, ricaricarle, gettarle nel fuoco o nell'acqua né cortocircuitarle. de piezas. La utilización de una batería no apropiada puede provocar la ignición o explosión de la misma. MT 2658/2659/2677 5 - IBM 2658 | Hardware Maintenance Manual - Page 12
disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery explosión de la misma. 6 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 13
, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in non adatta potrebbe determinare l'incendio o l'esplosione della batteria stessa. MT 2658/2659/2677 7 - IBM 2658 | Hardware Maintenance Manual - Page 14
encima de los 100°C (212°F), ni la incinere ni exponga el contenido de sus celdas al agua. Deséchela tal como dispone la normativa local. 8 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 15
inmediatamente las áreas afectadas con agua durante 15 minutos como mínimo. Obtenga atención medica si se presenta algún síntoma del fluido despues de lavarse. MT 2658/2659/2677 9 - IBM 2658 | Hardware Maintenance Manual - Page 16
um brennbare Materialien zu entzünden oder Verletzungen bei Personen hervorzurufen. Sebbene le batterie di alimentazione siano a basso voltaggio, una batteria in corto circuito o a suficiente como para quemar material combustible o provocar quemaduras en el personal. 10 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 17
8 Before removing any FRU, power-off the computer, unplug all power cords from electrical outlets, remove the battery pack, then disconnect any information that you need to be familiar with before servicing an IBM mobile computer. General Safety Follow these rules to ensure MT 2658/2659/2677 11 - IBM 2658 | Hardware Maintenance Manual - Page 18
start the machine, ensure that other service representatives and the customer's personnel are place, away from all personnel, while you are servicing the machine. v Keep your tool case away from to your eyes. v After service, reinstall all safety shields, guards Do not use this type of mat to protect - IBM 2658 | Hardware Maintenance Manual - Page 19
frames. Observe the special safety precautions when you work with very high voltages; these instructions are in the safety sections of maintenance information. Use extreme care when measuring high voltages is conductive; such touching can cause personal injury and machine damage. MT 2658/2659/2677 13 - IBM 2658 | Hardware Maintenance Manual - Page 20
and service personnel from injury. This guide IBM features or options not covered by this inspection guide . If any unsafe conditions are present, you must determine how serious the apparent hazard could be and whether you can continue without first correcting the problem ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 21
type as specified in the parts listings. c. Insulation must not be frayed or worn. 4. Remove the cover. 5. Check for any obvious non-IBM alterations. Use good judgment as to the safety of any non-IBM Notes: 1. Use product-specific ESD procedures when they exceed the specific service requirement. - IBM 2658 | Hardware Maintenance Manual - Page 22
Some IBM Personal Computer models are equipped from the factory with a CD-ROM drive. CD-ROM drives are also sold separately as options. The CD-ROM drive is a laser product. The CD-ROM drive is certified in the U.S. to conform to the requirements of the Department of Health and Human Services 21 - IBM 2658 | Hardware Maintenance Manual - Page 23
controlli, regolazioni o l'esecuzione di procedure diverse da quelle specificate possono provocare l'esposizione a El uso de controles o -ROM drive could result in exposure to hazardous laser radiation. There are no serviceable parts inside the CD-ROM drive. Do not open. Some CD-ROM drives contain - IBM 2658 | Hardware Maintenance Manual - Page 24
al fascio. Radiación láser al abrir. No mire fijamente ni examine con instrumental óptico el haz de luz. Evite la exposición directa al haz. 18 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 25
General Descriptions This chapter includes descriptions for any ThinkPad model that has the PC-Doctor DOS diagnostics program. Some descriptions might not apply to your particular computer. MT 2658/2659/2677 19 - IBM 2658 | Hardware Maintenance Manual - Page 26
4. Date of purchase 5. Failure symptoms, error codes appearing on display, and beep symptoms 6. Procedure index and page number in which failing FRU was detected 7. Failing FRU name and part number 8. Machine type, model number and serial number 9. Customer's name and address 20 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 27
problems drive damage caused by pressing the diskette drive cover or inserting diskettes with multiple labels. v Damaged or bent diskette drive eject button. v CD-ROM/DVD-ROM drive : v Missing parts may be a symptom of unauthorized service or modification. v HDD spindles can become noisy if - IBM 2658 | Hardware Maintenance Manual - Page 28
replacing any FRU. LCD replacement service this machine: v Keep the screw kit (P/N 08K6560) in your tool bag. v Always use new screws if you are instructed. v Use a torque screwdriver if you have one. Loose screws can cause a reliability problem. The IBM ThinkPad computer addresses this problem - IBM 2658 | Hardware Maintenance Manual - Page 29
inverter stores its supported LCD type ID code. ThinkPad Maintenance Diskette and restart the computer. 2. When the IBM logo is displayed, press the ″ESC″ key few times until BIOS copyright and diagnostics screen appears. 3. Select 1. LCD Panel ID Utility from the main menu. 4. Follow the instruction - IBM 2658 | Hardware Maintenance Manual - Page 30
corresponds with the LCD brand and type. If you write a wrong ID threshold: 1. Install the ThinkPad Maintenance Diskette and restart the computer. 2. When the IBM logo is displayed, press Maintenance Diskette and restart the computer. 2. When the IBM logo is displayed, press the ″ESC″ key few - IBM 2658 | Hardware Maintenance Manual - Page 31
IBM logo is displayed, press the ″ESC″ key few times until BIOS copyright and diagnostics screen appears. 3. Select 2.VPD Utility from the main menu. 4. Follow the instruction : 1. Install the ThinkPad Maintenance Diskette and restart the computer. 2. When the IBM logo is displayed, 2658/2659/2677 25 - IBM 2658 | Hardware Maintenance Manual - Page 32
Erase Hard Drive or Quick Erase Hard Drive in Utility of the PC-Doctor for DOS program. Refer to "Testing the computer" on page 34. Service Web site When the latest maintenance diskette and system program service diskette are available, they are posted on: Maintenance diskette: http://www.pc.ibm.com - IBM 2658 | Hardware Maintenance Manual - Page 33
to access the IBM BIOS Setup Utility and make changes to system configuration settings. Attention: If the SVP has been forgotten and cannot be made available to the servicer, there is no service procedure to reset 2. Enter correct SVP (Supervisor password) at the password prompt. MT 2658/2659/2677 27 - IBM 2658 | Hardware Maintenance Manual - Page 34
any services to reset the hard drive password nor recover data from the hard drive. The hard drive can be replaced for a scheduled fee. Power management features Power management modes are available in the computer system to reduce power consumption and to prolong battery life. 28 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 35
The LCD backlight turns off. v The hard disk motor either spins down or stops screen. v An embedded modem signals the modem ring indicator v The battery power is at a critical level. Display off mode When in data are stored on the hard disk. v The system is powered off. Events that cause the - IBM 2658 | Hardware Maintenance Manual - Page 36
hard disk drive (the Service Partition) that is not displayed by Windows Explorer. Use the Recovery CD if it was provided with the computer. Note: The recovery process might take up to 2 hours. To use the Product Recovery program to restore the pre-installed software, do the following: 30 ThinkPad - IBM 2658 | Hardware Maintenance Manual - Page 37
32 for instructions for making the instructions on the screen. Creating the Service Partition To create Service Partition and install the preloaded system from Recovery CD, do the following; To create Service Partition [SP]: 1. Erase all partitions on the hard-disk drive to the Service Partition, - IBM 2658 | Hardware Maintenance Manual - Page 38
]″. * To install Service Partition, go to step 4. * To preload hard-disk drive without installing Service Partition, press ″N″. 8. drive to the computer. 3. Insert the Recovery Repair diskette into the drive; then turn on the computer. 4. Follow the on-screen instructions. 32 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 39
Service Diskette (SPSD) Save 1MUDXXUS.DSK file to C:\SPSD Note: XXrepresents for the version of BIOS. 2. Boot the computer with SPSD. a. Insert the created floppy diskette into floppy diskette drive before you turn on the computer. b. Press the power button. 3. Follow the on-screen instructions - IBM 2658 | Hardware Maintenance Manual - Page 40
code appears, go to "Symptom-to-FRU Index" on page 39. Remove Disk #1 and Insert PC-Doctor DOS Disk #2 into the diskette drive when prompted to do so. The applicable function test. 4. Follow the instructions on the screen. If there is a problem, PC-Doctor shows some messages. 34 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 41
Interactive Tests, the Fn key is scanned only once. Each key should be pressed for at least 2 seconds; otherwise, it cannot be sensed. Related service information PC-Doctor can detect the following system information: Hardware Info: v System Configuration v Memory Contents MT 2658/2659/2677 35 - IBM 2658 | Hardware Maintenance Manual - Page 42
Run External Tests v Surface Scan Hard Disk v Benchmark System v DOS Shell v Tech Support Form v Battery Rundown v View Test Log v Print Log v Save Log v Full Erase Hard Drive v Quick Erase Hard Drive Power systems checkout To verify the symptom of the power problem on the computer, do the following - IBM 2658 | Hardware Maintenance Manual - Page 43
still persist, go to "Undetermined Problems" on page 54. Note: An audible noise from the AC Adapter does not always indicate a defect. Checking operational charging To check operational charging, use a discharged battery pack (Battery ASM) or a Battery ASM that has less than 50% of the total - IBM 2658 | Hardware Maintenance Manual - Page 44
, replace the battery. 4. If the voltage is more than 9V for LiION, measure the resistance between battery terminals 5 and 6. The resistance must be 4 to 30K . If the resistance is not correct, replace the Battery ASM. If the resistance is correct, replace the system board. 38 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 45
are available, use narrative symptoms. If the symptom, is not listed, go to "Undetermined Problems" on page 54. Note: For any IBM device not supported by the diagnostic codes in this ThinkPad computer, see the manual for that device. Numeric Error Codes and Messages Error Code 0176 Message System - IBM 2658 | Hardware Maintenance Manual - Page 46
send the system back to the service centers. System Security-IBM Security password retry count exceeded System administrator password retry expired (if failed 3 times) 1. Run IBM BIOS Setup Utility, and then interactive tests of the keyboard and the auxiliary input devices. 40 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 47
memory not working or not configured properly at offset nnnn, 1. DIMM 2. System Board System battery is dead Replace and run SETUP The CMOS clock battery indicator shows the battery is dead. Replace the battery and run Setup to reconfigure the system. Replace the backup battery and run IBM - IBM 2658 | Hardware Maintenance Manual - Page 48
drive A error Diskette drive B error Drive A: or B: is present but fails the BIOS POST diskette tests. CHeck to see that the drive is defined with the proper diskette type in Setup and that the diskette drive is attached corretly. Load ″Setup Default″ in IBM BIOS Setup Utility. 42 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 49
Meanings Comment or Action Type of floppy drive Diskette Drive A: not correctly identified in Setup Type of floppy drive Diskette Drive B: not correctly identified for specified device. 1. Load Setup Defaults in IBM BIOS Setup Utility. 2. Backup battery 3. System Board MT 2658/2659/2677 43 - IBM 2658 | Hardware Maintenance Manual - Page 50
Load Setup Defaults in IBM BIOS Setup Utility. 2. Backup battery 3. System Board CD ROM Drive CD ROM Drive identified. Entering SETUP System,Extended, or Shadow memory. 1. DIMM 2. System Board Fixed Disk n Fixed disk n (0-3) identified. Invalid System Problem with Configuration Data NVRAM - IBM 2658 | Hardware Maintenance Manual - Page 51
and is installed correctly. 2. Enter the IBM BIOS Setup Utility and see whether the hard-disk drive and the diskette drive are properly identified. 3. Reseat the hard-disk drive. 4. Reinstall the operating system. 5. Diskette drive. 6. Hard-disk drive. 7. System board. MT 2658/2659/2677 45 - IBM 2658 | Hardware Maintenance Manual - Page 52
the address nnnn of the upper limit of Upper Memory Blocks, indicating released segments of the BIOS which can be reclaimed by a virtual memory manager. Video BIOS shadowed Video BIOS successfully copied to not planar. UUID correct (block #4,5). needs to be reinstalled. 46 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 53
battery Critical Low Battery. Charge the error Battery supported by the product. Fan error Cooling fan is FAN failing. Do you want abort resume from hibernation? (Y/N)System memory removed, press F3 to power off system and restore memory If the memory size has 1 Critical low battery pi (1250Hz) - IBM 2658 | Hardware Maintenance Manual - Page 54
2 Low battery alarm pi (1250Hz) for 125ms no (yellow-> Red) sound for 125ms sound for 125ms po (315Hz) for 125ms no sound for 125ms po (315Hz) for 125ms 15 Bay alarm pi (1760Hz) for 125ms no sound for 125ms pi (1760Hz) for 125ms no sound for 125ms pi (1760Hz) for 125ms 48 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 55
FRU Replacement Notice The TFT LCD for the computer contains many thin-film transistors (TFTs). A small number of missing, discolored, or lighted dots (on all the time) is characteristic of TFT LCD technology, but excessive pixel problems (13.3″/14.1″) v LCD v System board MT 2658/2659/2677 49 - IBM 2658 | Hardware Maintenance Manual - Page 56
FRU/Action in Sequence v Go to "FRU tests" on page 60. v Reseat keyboard cable. v Keyboard v System board v Go to "FRU FRU/ FRU/Action in Sequence Power shuts down during operation. v Go to "Power systems checkout" on page 36. v AC Adapter v Battery v AC Adapter v Battery assembly v Keyboard v - IBM 2658 | Hardware Maintenance Manual - Page 57
can't be charged. v Go to "Power systems checkout" on page 36. v Battery assembly v System board Memory-Related Symptom Symptom/Error Memory count (size) appears different from the actual size. FRU/Action in Sequence v Go to "FRU tests" on page 60. v Enter BIOS Utility and execute ″Load Setup - IBM 2658 | Hardware Maintenance Manual - Page 58
display does not v Both display mode, press Fn+F7. work correctly. v System board Printer problems. v Run printer self-test. v Printer driver v Printer cable v Ensure that ″Parallel Port″ in the ″Config sub-menu″ menu of the BIOS Utility is correctly set. v System board 52 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 59
device. v Enter IBM BIOS Setup Utility and see whether the hard disk drive and the diskette drive are properly identified. v Reseat the hard disk drive. v Reinstall the operating system. v Diskette drive v Hard disk drive v System board Intermittent Problems Intermittent system hang problems can be - IBM 2658 | Hardware Maintenance Manual - Page 60
them for damage. If any problems are found, replace the FRU. 3. Remove or disconnect all of the following devices: v Non-IBM devices v Printer, external mouse & keyboard, and other external devices v Battery pack v Hard disk drive v CD-ROM drive/Diskette drive (optional) v PC Card (PCMCIA) 4. Power - IBM 2658 | Hardware Maintenance Manual - Page 61
ThinkPad R32 Series Part I This section applies to the following models: 2658-F2X, 2658-DBX, 2658-DDX, 2658-DEX, 2658-DSX, 2658-DTX, 2658-G4X, 2658-G5X, 2658-G6X, 2658-G7X, 2658-G8X, 2658-G9X, 2658-GAX, 2658-GBX, 2658-GCX, 2658-GDX, 2658-GEX, 2658-GFX, 2658-GGX, 2658-GHX, 2658-GJX, 2658-GKX, 2658- - IBM 2658 | Hardware Maintenance Manual - Page 62
memory CMOS RAM Video Video memory LCD(Bright Ctrl) Audio Floppy Diskette drive (By model) Hard disk drive via USB interface (Bootable) 20GB, 30GB or 40GB, 2.5-inch 9.5mm height, E-IDE interface 24X CD/ 8X DVD/ 8X, 4X, 24X Max CD-RW/ CD-RW- DVD (Combo)/ Bay Battery support 56 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 63
-Ion Intelligent Battery Pack IBM BIOS Status indicators The system-status indicators on the computer show the current status of your computer by their on or off states and colors (green and orange). Each indicator is identified with a symbol. The following shows the location and the MT 2658/2659 - IBM 2658 | Hardware Maintenance Manual - Page 64
Symbol (1) Drive in use Color Green (2) Numeric lock Green (3) Caps lock Green (4) Scroll lock Green Meaning Data is being read from or written to the hard disk. programs support this function. You enable or disable Scroll Lock mode by pressing the ScrLk key. 58 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 65
Color Green Blinking green Blinking orange Orange (2) Standby mode Green Meaning Enough battery power remains for operation. The battery power charges up to 80% full power The battery pack needs to be charged The battery pack is being charged. The computer is in standby mode MT 2658/2659/2677 59 - IBM 2658 | Hardware Maintenance Manual - Page 66
if the pointer movement stops in a short period of time. Hard disk drive CD-ROM drive If this does not correct the TrackPoint problem, continue with the following: Mouse (Interactive Tests). Fixed Disks (Diagnostics) CD-ROM, DVD, CD-RW, DVD/CD-RW (Interactive Tests) 60 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 67
FRU Memory Fan Applicable test 1. If a DIMM is installed, remove it and run Memory Test-Quick (Diagnostics) 2. If the problem does not recur, replace the DIMM and run the test again. 3. If the test does not detect the error, run Memory Test-Full (Diagnostics) 1. Power on system and check the air - IBM 2658 | Hardware Maintenance Manual - Page 68
shaking the computer and listening for rattling sounds. Metallic parts or metal flakes can cause electrical shorts. Safety Notice 3 Translations in ″Safety Notices (Multi-lingual Translations)″ section: The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or - IBM 2658 | Hardware Maintenance Manual - Page 69
grounding. Note: When disassembling the computer, please battery terminals. CAUTION: Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type recommended by the manufacturer. Dispose of used batteries according to the manufacturer's instructions. MT 2658 - IBM 2658 | Hardware Maintenance Manual - Page 70
1020 Mini-PCI cover and Mini-PCI card Disassembly v "1010 Battery Disassembly" on page 63 2 1 Note: The screw does not separate from the PCI cover. 3 3 4 Note: There are 2 cables on step 4 : no step 3 if the Mini-PCI card is not stalled, then this cable will be connected to the 64 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 71
CDC card. Note: When you install the PCI card, remember to insert it into its socket at 20°, press it down and ensure the connection is well. 1030 Memory cover and Memory card Disassembly v "1010 Battery Disassembly" on page 63 2 1 MT 2658/2659/2677 65 - IBM 2658 | Hardware Maintenance Manual - Page 72
of the memory card toward the right side of the socket, insert the memory card, at an angle of approximately 20°, into the socket; then press it firmly. Pivot the memory card until it snaps into place. Side View 1040 Hard Disk Drive Disassembly v "1010 Battery Disassembly" on page 63 66 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 73
copy of all the information on the drive if possible. Never remove the drive while the system is operating or is in suspend mode. 1050 Hard Disk Drive Cover Disassembly v "1010 Battery Disassembly" on page 63 1 1060 CD-ROM Disassembly v "1010 Battery Disassembly" on page 63 MT 2658/2659/2677 67 - IBM 2658 | Hardware Maintenance Manual - Page 74
1 2 3 1070 Keyboard Disassembly v "1010 Battery Disassembly" on page 63 1a 1b Step 1 Size (Quantity) M2.5 x L10 (2) Color Black 68 ThinkPad R32 Series Torque 3.2 kgf-cm - IBM 2658 | Hardware Maintenance Manual - Page 75
function will be rendered useless. 3. The cable of the keyboard are fragile and could be damaged. Be careful when pulling out the cable. 1080 Backup Battery Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 MT 2658/2659/2677 69 - IBM 2658 | Hardware Maintenance Manual - Page 76
regulations. Use of an incorrect battery can result in ignition or explosion of the battery. Replacement batteries can be ordered from IBM or IBM Authorized Dealers. 1090 Safety Cover Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 70 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 77
1 1100 Middle Cover Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 1 2 MT 2658/2659/2677 71 - IBM 2658 | Hardware Maintenance Manual - Page 78
Cover Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 1 Step 1 Size (Quantity) M2.5 x L5 (1) Color Silver Torque 2.5 kgf-cm 72 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 79
Modem Card) v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1110 CDC Cover Disassembly" on page 72 2 1 Notes: 1. If the Thinkpad R32 products are equipped - IBM 2658 | Hardware Maintenance Manual - Page 80
modem cable. 1130 Modem Cable Disassembly (With CDC Modem Card) v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1110 CDC Cover Disassembly" on page 72 1 Notes: 1. If the Thinkpad R32 products are equipped with the CDC - IBM 2658 | Hardware Maintenance Manual - Page 81
the system. 1150 Auxiliary Antenna Reassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1110 CDC Cover Disassembly" on page 72 MT 2658/2659/2677 75 - IBM 2658 | Hardware Maintenance Manual - Page 82
Cable and Inverter Cable Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1110 CDC Cover Disassembly" on page 72 1a 1b 76 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 83
antenna from the system. 1170 LCD Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1110 CDC Cover Disassembly" on page 72 MT 2658/2659/2677 77 - IBM 2658 | Hardware Maintenance Manual - Page 84
v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1040 Hard Disk Drive Disassembly" on page 66 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1170 LCD Disassembly" on page 77 78 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 85
1 Step 1 Size (Quantity) M2.5 x L10 (7) Color Black Torque 3.2 kgf-cm MT 2658/2659/2677 79 - IBM 2658 | Hardware Maintenance Manual - Page 86
the latches. 1190 VGA Heat Sink Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1040 Hard Disk Drive Disassembly" on page 66 v "1070 Keyboard Disassembly" on page 68 v "1090 Safety Cover Disassembly" on page 70 v "1100 Middle - IBM 2658 | Hardware Maintenance Manual - Page 87
1 Step 1 Size (Quantity) M2.5 x L5 (1) Color Silver Torque 2.5 kgf-cm 1200 PCMCIA Holder Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 v "1030 Memory cover and Memory card Disassembly" on page 65 1 MT 2658/2659/2677 81 - IBM 2658 | Hardware Maintenance Manual - Page 88
and replacing the PCMCIA holder, make sure that the PCMCIA cards are removed and the eject levers are sticking out. 1210 Heat Sink Module Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 82 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 89
is replaced. Thermal Pad is stuck on the bottom side of Heat Sink Module with adhesive. Do not re-use the thermal pad. 1220 Fan Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 MT 2658/2659/2677 83 - IBM 2658 | Hardware Maintenance Manual - Page 90
1b Step 1 Size (Quantity) M2.5 x L5 (3) Color Silver Torque 2.5 kgf-cm 1230 CPU Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1210 Heat Sink Module Disassembly" on page 82 1 84 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 91
re-use the thermal pad. 1240 Speaker Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1040 Hard Disk Drive Disassembly" on page 66 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1170 LCD - IBM 2658 | Hardware Maintenance Manual - Page 92
Torque 2.5 kgf-cm 1250 System Board Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1040 Hard Disk Drive Disassembly" on page 66 v "1060 CD-ROM Disassembly" on page 67 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle - IBM 2658 | Hardware Maintenance Manual - Page 93
the thermal pad. 1260 I/O Port Bracket Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1040 Hard Disk Drive Disassembly" on page 66 v "1060 CD-ROM Disassembly" on page 67 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle - IBM 2658 | Hardware Maintenance Manual - Page 94
1 2 Step 1 2 Size (Quantity) M2.5 x L6 M2 x L12 Color Silver Silver Torque 3.2 kgf-cm 1.6 kgf-cm 3 4 5 6 78 88 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 95
attached beneath the one marked number 8. CAUTION: There are several types of system board FRU for the Thinkpad R32 series, as followed: v System board with IBM security chip a v System board without IBM security chip a Begin by checking the FRU number of the system board, and be sure to use the - IBM 2658 | Hardware Maintenance Manual - Page 96
warranty. 1270 LCD Bezel Disassembly (14.1″) v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1170 LCD Disassembly" on page 77 1 90 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 97
the LCD bezel. Be careful not to break these latches. v Gently push the two LCD latches outward to remove the LCD bezel. 1280 LCD Inveter Disassembly(14.1″) v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card - IBM 2658 | Hardware Maintenance Manual - Page 98
PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1170 LCD Disassembly" on page 77 v "1270 LCD Bezel Disassembly (14.1″)" on page 90 v "1280 LCD Inveter Disassembly(14.1″)" on page 91 1 92 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 99
2 Step 2 Size (Quantity) M2 x L4(2) Color Silver Torque 2.5 kgf-cm 3a 3b 4 Step 3 Size (Quantity) M2.5 x L6(2) Color Black Torque 2.5 kgf-cm MT 2658/2659/2677 93 - IBM 2658 | Hardware Maintenance Manual - Page 100
main antenna cable is lifted gently. 5 6 1300 LCD Bracket Hinges Disassembly (14.1″) v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 94 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 101
Torque 2.5 kgf-cm 1310 Main Antenna Disassembly(14.1″) v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1170 LCD Disassembly" on page 77 v "1270 LCD Bezel - IBM 2658 | Hardware Maintenance Manual - Page 102
Cover Disassembly" on page 71 v "1170 LCD Disassembly" on page 77 v "1270 LCD Bezel Disassembly (14.1″)" on page 90 v "1280 LCD Inveter Disassembly(14.1″)" on page 91 v "1290 LCD Board Disassembly(14.1″)" on page 92 v "1300 LCD Bracket Hinges Disassembly (14.1″)" on page 94 96 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 103
MT 2658/2659/2677 97 - IBM 2658 | Hardware Maintenance Manual - Page 104
Locations Front View System-status indicators Computer display TrackPoint Rear View Ultrabay Plus Power jack TV port Parallel port Modem connector USB connector Monitor connector Ethernet connector 98 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 105
Bottom View 1 4 3 2 1. Battery pack 2. Memory slot door 3. Mini-PCI Card slot door 4. Docking connector MT 2658/2659/2677 99 - IBM 2658 | Hardware Maintenance Manual - Page 106
Switch Locations SW2 Pin1 10 Boot Block Disabled 10 Boot Block Enabled Pin2 10 10 Check Check Password Password Enabled Disabled 100 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 107
Parts list 1 2 3 4 6 5 22 23 7 20 21 19 18 9 11 10 12 8 8 17 14 16 13 15 Note: The parts marked with asterisk are CRUs (customer replaceable units.) MT 2658/2659/2677 101 - IBM 2658 | Hardware Maintenance Manual - Page 108
removals. 2. Some technical experience required. 3. Helpcenter assistance may be used. 4. Problem Determination can be done by customers or with Helpcenter assistance. No. Description FRU No. 1 Hinge Cap 26P9722 LG/ IBM Logo Kit 08K5860 3 Middle Cover Asm 46L6509 4 Upper Case-KBD Bezel - IBM 2658 | Hardware Maintenance Manual - Page 109
No. Description FRU No. HDD w/tray & screws module IBM Csacard / IBM High Rate Wireless Mini-PCI Adapter 26P8472 15 Mini-PCI / DIMM door kit 46L6524 16 Main Battery Speaker Kit 08K4618 18 RTC Battery(P/N 02K7063) 02K7062 19 CD-ROM Module TEAC (CD-224E-B01) LG (CRN-8245B) 27L3436* - IBM 2658 | Hardware Maintenance Manual - Page 110
asm 21 Heat Sink Asm. (w/ thermal pad) 22 I/O Bracket 23 CPU Intel Pentium-4M 1.7 GHz CPU Intel Pentium-4M 1.6 GHz CPU Intel Pentium-4M 1.8 GHz FRU No. 27L4297* 27L4359* 05K9283* 46L6527 46P2589 46L6526 46P2587 46L6507 46P2588 46P2590 26P8449 26P8345 26P8346 104 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 111
13.3-inch TFT: 1 3 2 3 4 6 5 7 No. Description FRU No. 1 LCD Bezel asm ″R32″ (13″ TFT) 46L6505 2 LCD Panel asm (13″ TFT) Tori-Sanyo LG 11P8212 11P8220 3 LCD Hinge/Bracket kit (13″ TFT) 26P9720 4 LCD Invertor / LED card 14/13″ TFT 26P8139 (P/N 26P8140) 5 LCD cable Asm. (13 - IBM 2658 | Hardware Maintenance Manual - Page 112
Description FRU No. 1 LCD Bezel asm ″R32″ (14″ TFT) 46L6503 2 LCD Panel asm (14″ TFT) DBU LG/LW Samsung 05K9888 11P8283 11P8280 3 LCD Hinge/Bracket kit (14″ TFT) 26P9719 4 LCD Invertor / LED card 14/13″ TFT 26P8139 (P/N 26P8140) 5 LCD cable asm (14″ TFT) 27L0720 106 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 113
LCD Rear Cover asm (13/14″ TFT)-Wireless LCD Rear Cover asm (13/14″ TFT) FRU No. 27L0723 46L6323 26P9709 26P9707 Keyboard Description KBD ASM US English KBD ASM Canadian French KBD ASM 08K4550** 08K4552** 08K4554** 08K4556** 08K4558** 08K4560** 08K4562** 08K4564** 08K4566** MT 2658/2659/2677 107 - IBM 2658 | Hardware Maintenance Manual - Page 114
Chicony Chicony Chicony Chicony Chicony Chicony Chicony Chicony Chicony FRU No. 08K4568** 08K4570** 08K4572** 08K4574** 08K4576** Socket Wrench Screwdriver Wireless Antenna Connector Tool ThinkPad hardware maintenance diskette version 1.07 FRU No. 72X8546 35G4703 66G5180 05K2580 95F3598 05K4694 - IBM 2658 | Hardware Maintenance Manual - Page 115
diskette version is different. There is no FRU number for ThinkPad hardware maintenance diskette. Telephone cable: Description FRU No. 02K6751* 02K6754* 02K6756* 02K6753* Power cords: IBM power cords for a specific country are usually available only in that country. For 2-pin power cords: IBM - IBM 2658 | Hardware Maintenance Manual - Page 116
FRU -BPU, BQU, CFU, CGU, CHU 2658-BPU, 2658-BPH, BQH, CFH, CGH, CHH, BDH, BJH, CVH 2677-CFM, CGM: 2659-BPM, BQM, CFM, CGM, CHM 2658-BPM, BQM, CFM, CGM, CHM, A5M, A9M, BCM, BUM, BLM, BVM, CPM, CTM 2677-CFJ, CGJ: 2659-BPJ, BQJ, CFJ, CGJ, CHJ: 2658-BPJ, BQJ, CFJ, CGJ, CHJ, BGJ, BRJ, BTJ 110 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 117
, BQG, CFG, CGG, CHG, BAG, BJG, CMG, CNG, CUG 2677-CFP, CGP: 2659-BPP, BQP, CFP, CGP: 2658-BPPS, BQP, CFP, CGP, A5P, CRP, CTP 2677-CFG, CGG: 2659-BPG, BQG, CFG, CGF, CHG: 2658-BPG, BQG, CFG, CGG, CHG, BAG, BJG, CMG, CNG, CUG 2677-CFG, CGG: 2659-BPG, BQG, CFG - IBM 2658 | Hardware Maintenance Manual - Page 118
32P7575 32P7575 32P7579 Recovery CD Win2000 (LA-BR) Recovery CD Win2000 (DK) 32P7579 32P7580 Recovery CD Win2000 (FR) 32P7581 112 ThinkPad R32 Series 2677-CFG, CGG: 2659-BPG, BQG, CFG, CGF, CHG: 2658-BPG, BQG, CFG, CGG, CHG, BAG, BJG, CMG, CNG, CUG 2677-CFG, CGG: 2659-BPG, BQG, CFG, CGF, CHG - IBM 2658 | Hardware Maintenance Manual - Page 119
C3G 2659-BMG, BNG: 2658-BMG, BNG, C2G, C3G 2659-BMG, BNG: 2658-BMG, BNG, C2G, C3G 2659-BMJ, BNJ: 2658-BMJ, BNJ, A3J, BHJ, BSJ 2658-A4U, C6U, CCU, CDU 2658-A4A, ABA, B5A, B6A 2658-C6M 2658-B2G, B3G 2658-A4P, C6P, CCP, CDP 2658-B2G, B3G 2658-B2G, B3G 2658-B2G, B3G 2658-B2G, B3G MT 2658/2659/2677 113 - IBM 2658 | Hardware Maintenance Manual - Page 120
-250 drive 2nd HDD adapter Ultrabay Plus device carrier Ultrabay Plus numeric keypad Ultrabay Plus cradle for WorkPad c500 series FRU No. 27L4359* 08K9785* 08K9644* 27L4351* 27L4355* 27L4301* 27L3436* 08K9606* 08K9607* 08K9615* 00N8254* 08K6067* 26P9388* 19K2056* 26P9389* 114 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 121
ThinkPad R32 Series Part II This section applies to the following models: 2677-BZX, 2659-CHX, 2659-BZX, 2658-CHX, 2658-BZX, 2658-DFX, 2658-G2X, 2658-G3X. MT 2658/2659/2677 115 - IBM 2658 | Hardware Maintenance Manual - Page 122
memory CMOS RAM Video Video memory LCD(Bright Ctrl) Audio Floppy Diskette drive (By model) Hard disk drive via USB interface (Bootable) 20GB, 30GB or 40GB, 2.5-inch 9.5mm height, E-IDE interface 24X CD/ 8X DVD/ 8X, 4X, 24X Max CD-RW/ CD-RW- DVD (Combo)/ Bay Battery support 116 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 123
-Ion Intelligent Battery Pack IBM BIOS Status indicators The system-status indicators on the computer show the current status of your computer by their on or off states and colors (green and orange). Each indicator is identified with a symbol. The following shows the location and the MT 2658/2659 - IBM 2658 | Hardware Maintenance Manual - Page 124
Symbol (1) Drive in use Color Green (2) Numeric lock Green (3) Caps lock Green (4) Scroll lock Green Meaning Data is being read from or written to the hard disk. programs support this function. You enable or disable Scroll Lock mode by pressing the ScrLk key. 118 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 125
Green Blinking green Blinking orange Orange (2) Standby mode Green Meaning Enough battery power remains for operation. The battery power charges up to 80% full power The battery pack needs to be charged The battery pack is being charged. The computer is in standby mode MT 2658/2659/2677 119 - IBM 2658 | Hardware Maintenance Manual - Page 126
if the pointer movement stops in a short period of time. Hard disk drive CD-ROM drive If this does not correct the TrackPoint problem, continue with the following: Mouse (Interactive Tests). Fixed Disks (Diagnostics) CD-ROM, DVD, CD-RW, DVD/CD-RW (Interactive Tests) 120 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 127
FRU Memory Fan Applicable test 1. If a DIMM is installed, remove it and run Memory Test-Quick (Diagnostics) 2. If the problem does not recur, replace the DIMM and run the test again. 3. If the test does not detect the error, run Memory Test-Full (Diagnostics) 1. Power on system and check the air - IBM 2658 | Hardware Maintenance Manual - Page 128
shaking the computer and listening for rattling sounds. Metallic parts or metal flakes can cause electrical shorts. Safety Notice 3 Translations in ″Safety Notices (Multi-lingual Translations)″ section: The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or - IBM 2658 | Hardware Maintenance Manual - Page 129
grounding. Note: When disassembling the computer, please battery terminals. CAUTION: Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type recommended by the manufacturer. Dispose of used batteries according to the manufacturer's instructions. MT 2658 - IBM 2658 | Hardware Maintenance Manual - Page 130
1020 Mini-PCI cover and Mini-PCI card Disassembly v "1010 Battery Disassembly" on page 123 2 1 Note: The screw does not separate from the PCI cover. 3 4 3 Note: There are 2 cables on step 3 if the Mini-PCI card is not stalled, then this cable will be connected to the 124 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 131
CDC card. Note: When you install the PCI card, remember to insert it into its socket at 20°, press it down and ensure the connection is well. 1030 Memory cover and Memory card Disassembly v "1010 Battery Disassembly" on page 123 2 1 MT 2658/2659/2677 125 - IBM 2658 | Hardware Maintenance Manual - Page 132
the memory card toward the right side of the socket, insert the memory card, at an angle of approximately 20°, into the socket; then press it firmly. Pivot the memory card until it snaps into place. Side View 1040 Hard Disk Drive Disassembly v "1010 Battery Disassembly" on page 123 126 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 133
copy of all the information on the drive if possible. Never remove the drive while the system is operating or is in suspend mode. 1050 Hard Disk Drive Cover Disassembly v "1010 Battery Disassembly" on page 123 1 1060 CD-ROM Disassembly v "1010 Battery Disassembly" on page 123 MT 2658/2659/2677 127 - IBM 2658 | Hardware Maintenance Manual - Page 134
1 2 3 1070 Keyboard Disassembly v "1010 Battery Disassembly" on page 123 1a 1b Step 1 Size (Quantity) M2.5 x L10 (2) Color Black 128 ThinkPad R32 Series Torque 3.2 kgf-cm - IBM 2658 | Hardware Maintenance Manual - Page 135
function will be rendered useless. 3. The cable of the keyboard are fragile and could be damaged. Be careful when pulling out the cable. 1080 Backup Battery Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 MT 2658/2659/2677 129 - IBM 2658 | Hardware Maintenance Manual - Page 136
. Use of an incorrect battery can result in ignition or explosion of the battery. Replacement batteries can be ordered from IBM or IBM Authorized Dealers. 1090 Safety Cover Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 130 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 137
1 1100 Middle Cover Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 1 2 MT 2658/2659/2677 131 - IBM 2658 | Hardware Maintenance Manual - Page 138
Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 1 Step 1 Size (Quantity) M2.5 x L5 (1) Color Silver Torque 2.5 kgf-cm 132 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 139
Card) v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1110 CDC Cover Disassembly" on page 132 2 1 Notes: 1. If the Thinkpad R32 products are equipped - IBM 2658 | Hardware Maintenance Manual - Page 140
modem cable. 1130 Modem Cable Disassembly (With CDC Modem Card) v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1110 CDC Cover Disassembly" on page 132 1 Notes: 1. If the Thinkpad R32 products are equipped with the - IBM 2658 | Hardware Maintenance Manual - Page 141
. 1150 Auxiliary Antenna Reassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1110 CDC Cover Disassembly" on page 132 MT 2658/2659/2677 135 - IBM 2658 | Hardware Maintenance Manual - Page 142
and Inverter Cable Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1110 CDC Cover Disassembly" on page 132 1a 1b 136 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 143
from the system. 1170 LCD Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1110 CDC Cover Disassembly" on page 132 MT 2658/2659/2677 137 - IBM 2658 | Hardware Maintenance Manual - Page 144
Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1040 Hard Disk Drive Disassembly" on page 126 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1170 LCD Disassembly" on page 137 138 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 145
1 Step 1 Size (Quantity) M2.5 x L10 (7) Color Black Torque 3.2 kgf-cm MT 2658/2659/2677 139 - IBM 2658 | Hardware Maintenance Manual - Page 146
latches. 1190 VGA Heat Sink Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1040 Hard Disk Drive Disassembly" on page 126 v "1070 Keyboard Disassembly" on page 128 v "1090 Safety Cover Disassembly" on page 130 v "1100 Middle - IBM 2658 | Hardware Maintenance Manual - Page 147
1 Step 1 Size (Quantity) M2.5 x L5 (1) Color Silver Torque 2.5 kgf-cm 1200 PCMCIA Holder Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 v "1030 Memory cover and Memory card Disassembly" on page 125 1 MT 2658/2659/2677 141 - IBM 2658 | Hardware Maintenance Manual - Page 148
replacing the PCMCIA holder, make sure that the PCMCIA cards are removed and the eject levers are sticking out. 1210 Heat Sink Module Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 142 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 149
is replaced. Thermal Pad is stuck on the bottom side of Heat Sink Module with adhesive. Do not re-use the thermal pad. 1220 Fan Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 MT 2658/2659/2677 143 - IBM 2658 | Hardware Maintenance Manual - Page 150
Step 1 Size (Quantity) M2.5 x L5 (3) Color Silver Torque 2.5 kgf-cm 1230 CPU Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1210 Heat Sink Module Disassembly" on page 142 1 144 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 151
the thermal pad. 1240 Speaker Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1040 Hard Disk Drive Disassembly" on page 126 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1170 LCD - IBM 2658 | Hardware Maintenance Manual - Page 152
2.5 kgf-cm 1250 System Board Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1040 Hard Disk Drive Disassembly" on page 126 v "1060 CD-ROM Disassembly" on page 127 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle - IBM 2658 | Hardware Maintenance Manual - Page 153
thermal pad. 1260 I/O Port Bracket Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1040 Hard Disk Drive Disassembly" on page 126 v "1060 CD-ROM Disassembly" on page 127 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle - IBM 2658 | Hardware Maintenance Manual - Page 154
1 2 Step 1 2 Size (Quantity) M2.5 x L6 M2 x L12 Color Silver Silver Torque 3.2 kgf-cm 1.6 kgf-cm 3 4 5 6 78 148 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 155
attached beneath the one marked number 8. CAUTION: There are several types of system board FRU for the Thinkpad R32 series, as followed: v System board with IBM security chip a v System board without IBM security chip a Begin by checking the FRU number of the system board, and be sure to use the - IBM 2658 | Hardware Maintenance Manual - Page 156
. 1270 LCD Bezel Disassembly (14.1″) v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1170 LCD Disassembly" on page 137 1 150 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 157
to break these latches. v Gently push the two LCD latches outward to remove the LCD bezel. 1280 LCD Inveter Disassembly(14.1″) v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 MT 2658/2659/2677 151 - IBM 2658 | Hardware Maintenance Manual - Page 158
and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1170 LCD Disassembly" on page 137 v "1270 LCD Bezel Disassembly (14.1″)" on page 150 v "1280 LCD Inveter Disassembly(14.1″)" on page 151 1 152 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 159
2 Step 2 Size (Quantity) M2 x L4(2) Color Silver Torque 2.5 kgf-cm 3a 3b 4 Step 3 Size (Quantity) M2.5 x L6(2) Color Black Torque 2.5 kgf-cm MT 2658/2659/2677 153 - IBM 2658 | Hardware Maintenance Manual - Page 160
the LED board, please make sure the main antenna cable is lifted gently. 5 6 1300 LCD Bracket Hinges Disassembly (14.1″) v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 154 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 161
Torque 2.5 kgf-cm 1310 Main Antenna Disassembly(14.1″) v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1170 LCD Disassembly" on page 137 v "1270 LCD - IBM 2658 | Hardware Maintenance Manual - Page 162
Cover Disassembly" on page 131 v "1170 LCD Disassembly" on page 137 v "1270 LCD Bezel Disassembly (14.1″)" on page 150 v "1280 LCD Inveter Disassembly(14.1″)" on page 151 v "1290 LCD Board Disassembly(14.1″)" on page 152 v "1300 LCD Bracket Hinges Disassembly (14.1″)" on page 154 156 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 163
1330 Mylar Assembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 2 1 MT 2658/2659/2677 157 - IBM 2658 | Hardware Maintenance Manual - Page 164
Locations Front View System-status indicators Computer display TrackPoint Rear View Ultrabay Plus Power jack TV port Parallel port Modem connector USB connector Monitor connector Ethernet connector 158 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 165
Bottom View 1 4 3 2 1. Battery pack 2. Memory slot door 3. Mini-PCI Card slot door 4. Docking connector MT 2658/2659/2677 159 - IBM 2658 | Hardware Maintenance Manual - Page 166
Switch Locations SW2 Pin1 10 Boot Block Disabled 10 Boot Block Enabled Pin2 10 10 Check Check Password Password Enabled Disabled 160 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 167
Parts list 1 2 3 4 6 5 22 23 7 20 21 19 18 9 11 10 12 8 8 17 14 16 13 15 Note: The parts marked with asterisk are CRUs (customer replaceable units.) MT 2658/2659/2677 161 - IBM 2658 | Hardware Maintenance Manual - Page 168
removals. 2. Some technical experience required. 3. Helpcenter assistance may be used. 4. Problem Determination can be done by customers or with Helpcenter assistance. No. Description FRU No. 1 Hinge Cap 26P9722 LG/ IBM Logo Kit 08K5860 3 Middle Cover Asm 46L6509 4 Upper Case-KBD Bezel - IBM 2658 | Hardware Maintenance Manual - Page 169
No. Description FRU No. HDD w/tray & screws module IBM Csacard / Mini-PCI / DIMM door kit 46L6524 16 Main Battery Assy. (Li-Ion) Sanyo-W/W Sanyo-Japan Panasonic-W/W Panasonic Speaker Kit 08K4618 18 RTC Battery(P/N 02K7063) 02K7062 19 CD-ROM Module TEAC (CD-224E-B01) LG (CRN-8245B) 27L3436* - IBM 2658 | Hardware Maintenance Manual - Page 170
asm 21 Heat Sink Asm. (w/ thermal pad) 22 I/O Bracket 23 CPU Intel Pentium-4M 1.6 GHz CPU Intel Pentium-4M 1.7 GHz CPU Intel Pentium-4M 1.8 GHz FRU No. 27L4297* 27L4359* 05K9283* 46L6527 46P2589 46L6526 46P3133 46P2587 46L6507 46P2588 46P2590 26P8345 26P8449 26P8346 164 - IBM 2658 | Hardware Maintenance Manual - Page 171
No. Description FRU No. 4 LCD Invertor / LED card 14/13″ TFT 26P8139 (P/N 26P8140) 6 Antenna Kit for D-1.5 (w/ puller TABs) 08K4072 Antenna Kit 13″/14″ LCD for D-1.5 08K4073 7 LCD Rear Cover asm (13/14″ TFT)-Wireless 26P9709 LCD Rear Cover asm (13/14″ TFT) 26P9707 MT 2658/2659/2677 - IBM 2658 | Hardware Maintenance Manual - Page 172
14.1-inch TFT: 1 2 3 4 5 7 3 6 No. Description FRU No. 1 LCD Bezel asm ″R32″ (14″ TFT) 46L6503 2 LCD Panel asm (14″ TFT) DBU LG/LW Samsung 05K9888 11P8283 11P8280 3 LCD Hinge/Bracket kit (14″ TFT) )-Wireless 26P9709 LCD Rear Cover asm (13/14″ TFT) 26P9707 166 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 173
NMB NMB Chicony Chicony Chicony Chicony Chicony Chicony Chicony Chicony Chicony Chicony Chicony FRU No. 08K4506** 08K4508** 08K4510** 08K4512** 08K4514** 08K4516** 08K4518** ** 08K4564** 08K4566** 08K4568** 08K4570** 08K4572** 08K4574** 08K4576** 08K4578** 08K4580** 08K4582** MT 2658/2659/2677 167 - IBM 2658 | Hardware Maintenance Manual - Page 174
hardware maintenance diskette version 1.07 FRU No. 72X8546 35G4703 66G5180 05K2580 95F3598 05K4694 27L8126 08K7159 Note: The data may look the same with the sample hmm but the diskette version is different. There is no FRU number for ThinkPad hardware maintenance diskette. 168 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 175
72W 2-pinS (ASTEC) FRU No. 02K6751* 02K6754* 02K6756* 02K6753* Power cords: IBM power cords for a specific country are usually available only in that country. For 2-pin power cords: IBM power cord part number came with your computer, see "Safety Information" on page 11. MT 2658/2659/2677 169 - IBM 2658 | Hardware Maintenance Manual - Page 176
IBM FRU 2658-CHH, BZH 2677-BZM:2659-CHM, BZM: 2658-CHM,BZM 2677-BZA: 2659-BZA: 2658-BZA 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 170 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 177
, BZG 2677-BZF: 2659-CHF, BZF: 2658-CHF, BZF 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2677-BZP: 2659-BZP: 2658-BZP 2677-BZJ: 2659-CHJ, BZJ: 2658-CHJ, BZJ 2677-BZB: 2659-CHB, BZB: 2658-CHB, BZB 2677-BZT: 2659-BZT: 2658-BZT 2677-BZC: 2659-CHC, BZC: 2658-CHC, BZC 2677-BZG: 2659-CHG - IBM 2658 | Hardware Maintenance Manual - Page 178
01R5738 01R5736 01R5736 01R5736 01R5733 172 ThinkPad R32 Series 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2658-L6U, L7U, N7U, N8U 2658-N6A 2658-N7S, N8S, L6S, L7S 2658-N7X, N8X, L6X, L7X 2658-N7P, N8P, L6P, L7P 2658-K2J 2658-L8G, L9G 2658-LCU, K3U, K4U, N9U, NGU - IBM 2658 | Hardware Maintenance Manual - Page 179
-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G Option Parts List Battery charges: Description Main Battery Li-Ion Option-W/W Main Battery Li-Ion Sanyo-W/W Main Battery Li-Ion Panasonic-W/W Main Battery Li-Ion Option-Japan Main Battery Li-Ion Sanyo-Japan Main Battery Li-Ion Panasonic-Japan FRU - IBM 2658 | Hardware Maintenance Manual - Page 180
SuperDisk drive (LS240) ZIP-250 drive 2nd HDD adapter Ultrabay Plus device carrier Ultrabay Plus numeric keypad Ultrabay Plus cradle for WorkPad c500 series FRU No. 08K9644* 27L4351* 27L4355* 27L4301* 27L3436* 08K9606* 08K9607* 08K9615* 00N8254* 08K6067* 26P9388* 19K2056* 26P9389* 174 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 181
ThinkPad R32 Series Part III This section applies to the following models: 2677-J3X, 2677-N3X, 2677-N4X, 2659-J3X, 2659-N3X, 2659-N4X, 2659-N5X, 2658-J3X, 2658-N3X, 2658-N4X, 2658-N5X, 2658-H4X, 2658-H3X, 2658-HAX, 2658-HBX, 2658-K3X, 2658-K4X, 2658-K5X, 2658-K6X, 2658-K7X, 2658-K8X, 2658-K9X, 2658- - IBM 2658 | Hardware Maintenance Manual - Page 182
memory CMOS RAM Video Video memory LCD(Bright Ctrl) Audio Floppy Diskette drive (By model) Hard disk drive via USB interface (Bootable) 20GB, 30GB or 40GB, 2.5-inch 9.5mm height, E-IDE interface 24X CD/ 8X DVD/ 8X, 4X, 24X Max CD-RW/ CD-RW- DVD (Combo)/ Bay Battery support 176 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 183
-Ion Intelligent Battery Pack IBM BIOS Status indicators The system-status indicators on the computer show the current status of your computer by their on or off states and colors (green and orange). Each indicator is identified with a symbol. The following shows the location and the MT 2658/2659 - IBM 2658 | Hardware Maintenance Manual - Page 184
Symbol (1) Drive in use Color Green (2) Numeric lock Green (3) Caps lock Green (4) Scroll lock Green Meaning Data is being read from or written to the hard disk. programs support this function. You enable or disable Scroll Lock mode by pressing the ScrLk key. 178 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 185
Green Blinking green Blinking orange Orange (2) Standby mode Green Meaning Enough battery power remains for operation. The battery power charges up to 80% full power The battery pack needs to be charged The battery pack is being charged. The computer is in standby mode MT 2658/2659/2677 179 - IBM 2658 | Hardware Maintenance Manual - Page 186
if the pointer movement stops in a short period of time. Hard disk drive CD-ROM drive If this does not correct the TrackPoint problem, continue with the following: Mouse (Interactive Tests). Fixed Disks (Diagnostics) CD-ROM, DVD, CD-RW, DVD/CD-RW (Interactive Tests) 180 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 187
FRU Memory Fan Applicable test 1. If a DIMM is installed, remove it and run Memory Test-Quick (Diagnostics) 2. If the problem does not recur, replace the DIMM and run the test again. 3. If the test does not detect the error, run Memory Test-Full (Diagnostics) 1. Power on system and check the air - IBM 2658 | Hardware Maintenance Manual - Page 188
shaking the computer and listening for rattling sounds. Metallic parts or metal flakes can cause electrical shorts. Safety Notice 3 Translations in ″Safety Notices (Multi-lingual Translations)″ section: The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or - IBM 2658 | Hardware Maintenance Manual - Page 189
grounding. Note: When disassembling the computer, please battery terminals. CAUTION: Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type recommended by the manufacturer. Dispose of used batteries according to the manufacturer's instructions. MT 2658 - IBM 2658 | Hardware Maintenance Manual - Page 190
1020 Mini-PCI cover and Mini-PCI card Disassembly v "1010 Battery Disassembly" on page 183 2 1 Note: The screw does not separate from the PCI cover. 3 4 3 Note: There are 2 cables on step 3 if the Mini-PCI card is not stalled, then this cable will be connected to the 184 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 191
CDC card. Note: When you install the PCI card, remember to insert it into its socket at 20°, press it down and ensure the connection is well. 1030 Memory cover and Memory card Disassembly v "1010 Battery Disassembly" on page 183 2 1 MT 2658/2659/2677 185 - IBM 2658 | Hardware Maintenance Manual - Page 192
the memory card toward the right side of the socket, insert the memory card, at an angle of approximately 20°, into the socket; then press it firmly. Pivot the memory card until it snaps into place. Side View 1040 Hard Disk Drive Disassembly v "1010 Battery Disassembly" on page 183 186 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 193
copy of all the information on the drive if possible. Never remove the drive while the system is operating or is in suspend mode. 1050 Hard Disk Drive Cover Disassembly v "1010 Battery Disassembly" on page 183 1 1060 CD-ROM Disassembly v "1010 Battery Disassembly" on page 183 MT 2658/2659/2677 187 - IBM 2658 | Hardware Maintenance Manual - Page 194
1 2 3 1070 Keyboard Disassembly v "1010 Battery Disassembly" on page 183 1a 1b Step 1 Size (Quantity) M2.5 x L10 (2) Color Black 188 ThinkPad R32 Series Torque 3.2 kgf-cm - IBM 2658 | Hardware Maintenance Manual - Page 195
function will be rendered useless. 3. The cable of the keyboard are fragile and could be damaged. Be careful when pulling out the cable. 1080 Backup Battery Disassembly v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 MT 2658/2659/2677 189 - IBM 2658 | Hardware Maintenance Manual - Page 196
. Use of an incorrect battery can result in ignition or explosion of the battery. Replacement batteries can be ordered from IBM or IBM Authorized Dealers. 1090 Safety Cover Disassembly v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 190 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 197
1 1100 Middle Cover Disassembly v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 1 2 MT 2658/2659/2677 191 - IBM 2658 | Hardware Maintenance Manual - Page 198
Disassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 1 Step 1 Size (Quantity) M2.5 x L5 (1) Color Silver Torque 2.5 kgf-cm 192 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 199
Card) v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1110 CDC Cover Disassembly" on page 192 2 1 Notes: 1. If the Thinkpad R32 products are equipped - IBM 2658 | Hardware Maintenance Manual - Page 200
modem cable. 1130 Modem Cable Disassembly (With CDC Modem Card) v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1110 CDC Cover Disassembly" on page 192 1 Notes: 1. If the Thinkpad R32 products are equipped with the - IBM 2658 | Hardware Maintenance Manual - Page 201
. 1150 Auxiliary Antenna Reassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1110 CDC Cover Disassembly" on page 192 MT 2658/2659/2677 195 - IBM 2658 | Hardware Maintenance Manual - Page 202
and Inverter Cable Disassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1110 CDC Cover Disassembly" on page 192 1a 1b 196 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 203
from the system. 1170 LCD Disassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1110 CDC Cover Disassembly" on page 192 MT 2658/2659/2677 197 - IBM 2658 | Hardware Maintenance Manual - Page 204
Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1040 Hard Disk Drive Disassembly" on page 186 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1170 LCD Disassembly" on page 197 198 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 205
1 Step 1 Size (Quantity) M2.5 x L10 (7) Color Black Torque 3.2 kgf-cm MT 2658/2659/2677 199 - IBM 2658 | Hardware Maintenance Manual - Page 206
latches. 1190 VGA Heat Sink Disassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1040 Hard Disk Drive Disassembly" on page 186 v "1070 Keyboard Disassembly" on page 188 v "1090 Safety Cover Disassembly" on page 190 v "1100 Middle - IBM 2658 | Hardware Maintenance Manual - Page 207
1 Step 1 Size (Quantity) M2.5 x L5 (1) Color Silver Torque 2.5 kgf-cm 1200 PCMCIA Holder Disassembly v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 v "1030 Memory cover and Memory card Disassembly" on page 185 1 MT 2658/2659/2677 201 - IBM 2658 | Hardware Maintenance Manual - Page 208
replacing the PCMCIA holder, make sure that the PCMCIA cards are removed and the eject levers are sticking out. 1210 Heat Sink Module Disassembly v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 202 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 209
is replaced. Thermal Pad is stuck on the bottom side of Heat Sink Module with adhesive. Do not re-use the thermal pad. 1220 Fan Disassembly v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 MT 2658/2659/2677 203 - IBM 2658 | Hardware Maintenance Manual - Page 210
1 2 4 3c 3a 3b Step 3 Size (Quantity) M2.5 x L5 (3) Color Silver 204 ThinkPad R32 Series Torque 2.5 kgf-cm - IBM 2658 | Hardware Maintenance Manual - Page 211
is replaced. Thermal Pad is stuck on the bottom side of Heat Sink Module with adhesive. Do not re-use the thermal pad. 1240 Speaker Disassembly v "1010 Battery Disassembly" on page 183 MT 2658/2659/2677 205 - IBM 2658 | Hardware Maintenance Manual - Page 212
2.5 kgf-cm 1250 System Board Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1040 Hard Disk Drive Disassembly" on page 186 v "1060 CD-ROM Disassembly" on page 187 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle - IBM 2658 | Hardware Maintenance Manual - Page 213
1 Step 1 Size (Quantity) M2.5 x L5(2) Color Silver Torque 2.5 kgf-cm 3 2 Notes: 1. When removing the system board from the bottom cover, gently raise the side of the system board facing the rear I/O ports; then pull out the system board. MT 2658/2659/2677 207 - IBM 2658 | Hardware Maintenance Manual - Page 214
thermal pad. 1260 I/O Port Bracket Disassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1040 Hard Disk Drive Disassembly" on page 186 v "1060 CD-ROM Disassembly" on page 187 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle - IBM 2658 | Hardware Maintenance Manual - Page 215
one marked 5 should be installed above the one marked 6; the one marked number 7 should be aligned with and attached beneath the one marked number 8. MT 2658/2659/2677 209 - IBM 2658 | Hardware Maintenance Manual - Page 216
CAUTION: There are several types of system board FRU for the Thinkpad R32 series, as followed: v System board with IBM security chip a v System board without IBM security chip a Begin by checking the FRU number of the system board, and be sure to use the correct system board FRU for the computer. - IBM 2658 | Hardware Maintenance Manual - Page 217
ThinkPad computer you are servicing Disassembly (14.1″) v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1170 LCD Disassembly" on page 197 1 MT 2658 - IBM 2658 | Hardware Maintenance Manual - Page 218
to break these latches. v Gently push the two LCD latches outward to remove the LCD bezel. 1280 LCD Inveter Disassembly(14.1″) v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 212 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 219
Torque 2.5 kgf-cm 1290 LCD Board Disassembly(14.1″) v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1170 LCD Disassembly" on page 197 v "1270 LCD - IBM 2658 | Hardware Maintenance Manual - Page 220
2 Step 2 Size (Quantity) M2 x L4(2) Color Silver Torque 2.5 kgf-cm 3a 3b 4 Step 3 Size (Quantity) M2.5 x L6(2) Color Black Torque 2.5 kgf-cm 214 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 221
removing the LED board, please make sure the main antenna cable is lifted gently. 5 6 1300 LCD Bracket Hinges Disassembly (14.1″) v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 MT 2658/2659/2677 215 - IBM 2658 | Hardware Maintenance Manual - Page 222
Cover Disassembly" on page 191 v "1170 LCD Disassembly" on page 197 v "1270 LCD Bezel Disassembly (14.1″)" on page 211 v "1280 LCD Inveter Disassembly(14.1″)" on page 212 v "1290 LCD Board Disassembly(14.1″)" on page 213 v "1300 LCD Bracket Hinges Disassembly (14.1″)" on page 215 216 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 223
2.5 kgf-cm 1320 Main Antenna Cable Reassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1170 LCD Disassembly" on page 197 v "1270 LCD Bezel - IBM 2658 | Hardware Maintenance Manual - Page 224
1330 Mylar Assembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 2 1 218 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 225
Locations Front View System-status indicators Computer display TrackPoint Rear View Ultrabay Plus Power jack TV port Parallel port Modem connector USB connector Monitor connector Ethernet connector MT 2658/2659/2677 219 - IBM 2658 | Hardware Maintenance Manual - Page 226
Bottom View 1 4 3 2 1. Battery pack 2. Memory slot door 3. Mini-PCI Card slot door 4. Docking connector 220 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 227
Switch Locations SW2 Pin1 10 Boot Block Disabled 10 Boot Block Enabled Pin2 10 10 Check Check Password Password Enabled Disabled MT 2658/2659/2677 221 - IBM 2658 | Hardware Maintenance Manual - Page 228
Parts list 1 2 3 4 6 5 22 23 7 20 21 19 18 9 11 10 12 8 8 17 14 16 13 15 Note: The parts marked with asterisk are CRUs (customer replaceable units.) 222 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 229
expertise required. 3. Minimal Problem Determination is required (less Problem Determination can be done by customers or with Helpcenter assistance. No. Description FRU No. 1 Hinge Cap 26P9722 LG/ IBM 46L6530 10 HDD w/tray & screws module IBM Csacard./ 20 GB 08K9761* * HDD w/tray - IBM 2658 | Hardware Maintenance Manual - Page 230
Description FRU No. HDD w/tray & screws module IBM Csacard IBM High Rate Wireless Mini-PCI Adapter 26P8472 15 Mini-PCI / DIMM door kit for D-2 62P4164 16 Main Battery Assy. (Li-Ion) Sanyo-W/W Sanyo-Japan Panasonic-W/W Panasonic-Japan 02K7054* 02K7058* 02K6928* 02K7060* 224 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 231
18 RTC Battery(P/N 02K7063) 19 CD-ROM Module TEAC (CD-224E-B01) LG (CRN-8245B) DVD-ROM Module Hitachi (GDR-8081N) MKE (SR-8176-MBZ) CD-RW Module TEAC (CD-W28E-001)CD-RW / 12XDVD Module FRU No. 26P8346 CPU Intel Pentium-4M 2.0 GHz 26P8473 CPU Celeron 1.5GHz 26P8469 MT 2658/2659/2677 225 - IBM 2658 | Hardware Maintenance Manual - Page 232
Description FRU No. 4 LCD Invertor / LED card 14/13″ TFT 26P8139 (P/N 26P8140) 6 Antenna Kit for D-1.5 (w/ puller TABs) 08K4072 Antenna Kit 13″/14″ LCD for D-1.5 08K4073 7 LCD Rear Cover asm (13/14″ TFT)-Wireless 26P9709 LCD Rear Cover asm (13/14″ TFT) 26P9707 226 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 233
14.1-inch TFT: 1 2 3 4 5 7 3 6 No. Description FRU No. 1 LCD Bezel asm ″R32″ (14″ TFT) 46L6503 2 LCD Panel asm (14″ TFT) DBU LG/LW Samsung 05K9888 11P8283 11P8280 3 LCD Hinge/Bracket kit (14″ TFT) )-Wireless 26P9709 LCD Rear Cover asm (13/14″ TFT) 26P9707 MT 2658/2659/2677 227 - IBM 2658 | Hardware Maintenance Manual - Page 234
Italian KBD ASM European Spanish 228 ThinkPad R32 Series Vendor NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB Chicony Chicony Chicony Chicony Chicony Chicony Chicony Chicony Chicony Chicony Chicony FRU - IBM 2658 | Hardware Maintenance Manual - Page 235
hardware maintenance diskette version 1.07 FRU No. 72X8546 35G4703 66G5180 05K2580 95F3598 05K4694 27L8126 08K7159 Note: The data may look the same with the sample hmm but the diskette version is different. There is no FRU number for ThinkPad hardware maintenance diskette. MT 2658/2659/2677 229 - IBM 2658 | Hardware Maintenance Manual - Page 236
72W 2-pinS (ASTEC) FRU No. 02K6751* 02K6754* 02K6756* 02K6753* Power cords: IBM power cords for a specific country are usually available only in that country. For 2-pin power cords: IBM power cord part number came with your computer, see "Safety Information" on page 11. 230 ThinkPad R32 Series - IBM 2658 | Hardware Maintenance Manual - Page 237
IBM China (P.R.C.) Switzerland Recovery CD List: Description FRU No. Recovery CD 01R6094 English-WinXP PRO , L5U, N2U, N3U, N4U, N5U: 2659- L2U, L3U, L4U, L5U, N2U, N3U, N4U, N5U, H2U 2658-L2U, L3U, L4U, L5U, N2U, N3U, N4U, N5U, H3U, H2U, K7U, K8U, KAU, KCU, KGU, KHU, KJU 2658-MGU, NWU, NYU - IBM 2658 | Hardware Maintenance Manual - Page 238
01R6103 01R6103 232 ThinkPad R32 Series 2677-L2H, L3H, L4H, L5H, N2H, N3H, N4H, N5H: 2659-L2H, L3H, L4H, L5H, N2H, N3H, N4H, N5H, H2H 2658-L2H, L3H, L5G, N2G, N3G, N4G, N5G 2659- L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G, H2G 2658- L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G, H3G, H2G, LHG, LJG, LKG, LYG - IBM 2658 | Hardware Maintenance Manual - Page 239
01R6101 Recovery CD Spanish-WinXP PRO 01R6099 Recovery CD Spanish-WinXP PRO 01R6099 Recovery CD Spanish-WinXP PRO 01R6099 Recovery CD Spanish-WinXP PRO 01R6099 2658- L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G, H3G, H2G, LHG, LJG, LKG, LYG, LZG, M6G, M7G 2677- L2G, L3G, L4G, L5G, N2G, N3G, N4G - IBM 2658 | Hardware Maintenance Manual - Page 240
-WinXP PRO 234 ThinkPad R32 Series 2677- L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G: 2659- L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G, H2G 2658-L2G, L3G, L5G, N2G, N3G, N4G, N5G 2659-L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G, H2G 2658-L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G, H3G, H2G, LHG, LJG, LKG, LYG, - IBM 2658 | Hardware Maintenance Manual - Page 241
Recovery CD Hong Kong-TC-WinXP PRO 67P4980 Recovery CD Traditional Chinese-WinXP PRO 67P4974 2658- L2F, L3F, L4F, L5F, N2F, N3F, N4F, N5F, H3F, H2F 2677- L2P, L3P, L4P, N2P, N3P, N4P: 2659-L2P, L3P, L4P, N2P, N3P, N4P, H3P 2658- L2P, L3P, L4P, N2P, N3P, N4P, H3P, H2P, KAP, LWP, LXP, NTP, NUP, NVP - IBM 2658 | Hardware Maintenance Manual - Page 242
CD Hungary-WinXP PRO Recovery CD Hungary-WinXP PRO Recovery CD Hungary-WinXP PRO 01R6111 01R6111 01R6111 Recovery CD Russian-WinXP PRO 01R6112 236 ThinkPad R32 Series 2658- L2T, L3T, L4T, N2T, N3T, N4T, H3T, H2T, KDT, KET, KFT, LVT, NLT, NMT, NPT, NRT 2677- L2C, L3C, L4C, L5C, N2C, N3C, N4C - IBM 2658 | Hardware Maintenance Manual - Page 243
Win2000 (US) 01R5670 01R5670 2659- L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G, H2G 2658- L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G, H3G, H2G, LHG, LJG, LKG L5G, N2G, N3G, N4G, N5G 2659- L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G, H2G 2658- L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G, H3G, H2G, LHG, LJG, LKG, LYG, - IBM 2658 | Hardware Maintenance Manual - Page 244
HOME 01R5735 238 ThinkPad R32 Series 2658-L6X, L7X, N7X, N8X 2658-L6S, L7S, N7S, N8S 2658-L6P, L7P, N7P, N8P 2658-MJJ 2658-L8G, L9G 2658- K3U, K4U, LCU, N9U, NGU, NHU 2658-K4A, K5A: 2658-N9M: 2658-LAH, NEH, NFH 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-K4S, N9S - IBM 2658 | Hardware Maintenance Manual - Page 245
-K4P, N9P, NGP, NHP 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-LAB 2658-K6T, NAT, NBT, NCT, NET, LAT, LBT, LDT, LFT 2658-LAC Option Parts List Battery charges: Description Main Battery Li-Ion Option-W/W Main Battery Li-Ion Sanyo-W/W Main - IBM 2658 | Hardware Maintenance Manual - Page 246
-250 drive 2nd HDD adapter Ultrabay Plus device carrier Ultrabay Plus numeric keypad Ultrabay Plus cradle for WorkPad c500 series FRU No. 08K9785* 08K9818* 08K9820* 08K9644* 27L4351* 27L4355* 27L4301* 27L3436* 08K9606* 08K9607* 08K9615* 00N8254* 08K6067* 26P9388* 19K2056* 26P9389* 240 ThinkPad R32 - IBM 2658 | Hardware Maintenance Manual - Page 247
IBM operates. Any reference to an IBM product, program, or service is not intended to state or imply that only IBM product, program, or service may be used. Subject to IBM , in writing, to: IBM Director of Licensing IBM Corporation 500 Columbus Avenue Thornwood, NY 10594 U.S.A. MT 2658/2659/2677 241 - IBM 2658 | Hardware Maintenance Manual - Page 248
or service marks of IBM Corporation in the United States and other countries: IBM USB ThinkPad TrackPoint TrackPoint IV The following terms are trademarks or service and Company Watergate Software, Inc. Personal Computer Memory Card Interface Association Intel Corporation 242 ThinkPad R32 Series
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
 |
 |
ThinkPad R32 Series Hardware
Maintenance Manual
±²³