Lenovo ThinkPad 570 English - Hardware Maintenance Manual for 570 systems
Lenovo ThinkPad 570 Manual
View all Lenovo ThinkPad 570 manuals
Add to My Manuals
Save this manual to your list of manuals |
Lenovo ThinkPad 570 manual content summary:
- Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 1
January 2000 This manual supports: ThinkPad 570 (MT 2643/2644) ThinkPad 570E (MT 2643/2644) - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 2
Note Before using this information and the product it supports, be sure to read the general information under this publication may contain references to, or information about, IBM products (machines and programs), programming, or services that are not announced in your country. Such references or - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 3
Related service information 22 Reset switch 22 Service Web site 22 Passwords 22 Power management features 24 Checkout guide 27 Testing the computer 27 Detecting system information with PC-Doctor . . 28 Power system checkout 29 ThinkPad 570 and 570E 33 Product overview 35 Specifications 35 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 4
LCD panel 88 2040 Hinges 91 3010 Blank bezel in the UltraBase 92 Battery pack in the UltraBase 93 Locations 94 Front view 94 Rear view 96 Bottom view 97 Password pads 98 Parts List 99 LCD FRU 103 Keyboard 106 Common Parts List 108 Notices 111 Trademarks 111 iv ThinkPad 570 and 570E - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 5
Ensure that all diskette fixes are installed prior to replacing any FRUs listed in this manual. Use the following strategy to prevent unnecessary FRU replacement and service expense: If you are instructed to replace a FRU and that does not correct the problem, reinstall the original FRU before you - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 6
service is complete. Hard Disk Drive Replacement Strategy: Always try to run a low-level format before replacing a hard disk drive. Attention The drive startup sequence in the computer you are servicing coming from an internal or an external device. 2 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 7
Read/Write Read/Write Read/Write The following table provides identification information for 5.25-inch diskette drives. Diskette Drive 5.25-Inch - 360KB (External) 5.25-Inch - 1.2MB (Internal) Identifying Mark Asterisk on bezel 1.2 on the eject button The following table provides compatibility - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 8
German, Italian, and Spanish languages. Safety Notice 1 Before the computer is powered-on after FRU replacement, make sure all screws, springs, or other small parts are in place and are not piezas metálicas pueden causar cortocircuitos eléctricos. 4 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 9
und Cadmium enthalten. Sie darf nur durch die Verkaufsstelle oder den IBM Kundendienst ausgetauscht werden. Sie darf nicht zerlegt, wiederaufgeladen, kurzgeschlossen, oder Feuer oder Wasser ausgesetzt werden. Die Batterie kann schwere Verbrennungen oder Verätzungen verursachen. Bei der Entsorgung - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 10
Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery. La batterie contient du nickel. provocar la ignición o explosión de la misma. 6 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 11
der zur richtigen Polung angebrachte Verbindungsstecker entfernt werden. Bei der Entsorgung die örtlichen Bestimmungen für Sondermüll beachten. Beim Ersetzen der Batterie nur Batterien des Typs verwenden, der in der Ersatzteilliste aufgeführt ist. Der Einsatz falscher Batterien kann zu Entzündung - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 12
LCD se rompe y el fluido de su interior entra en contacto con sus ojos o sus manos, lave inmediatamente las áreas afectadas con agua durante 15 minutos como mínimo. Obtenga atención medica si se presenta algún síntoma del fluido despues de lavarse. 8 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 13
To avoid shock, do not remove the plastic cover that surrounds the lower portion of the inverter card. Afin d'éviter tout risque de choc électrique zu entzünden oder Verletzungen bei Personen hervorzurufen. Sebbene le batterie di alimentazione siano a basso voltaggio, una batteria in corto circuito - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 14
branchez tous les cordons d'alimentation des socles de prise de courant, retirez la batterie et déconnectez tous les cordons d'interface. Die Stromzufuhr muß abgeschaltet, alle Stromkabel desconecte cualquier cable de conexión entre dispositivos. 10 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 15
safety information that you need to be familiar with before servicing an IBM mobile computer. General Safety Follow these rules to ensure After service, reinstall all safety shields, guards, labels, and ground wires. Replace any safety device that is worn or defective. Reinstall all covers correctly - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 16
approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working instructions are in the safety sections of maintenance information. Use extreme care when measuring high voltages. 12 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 17
required safety items installed to protect users and service personnel from injury. This guide addresses only those items. However, good judgment should be used to identify potential safety hazards due to attachment of non-IBM features or options not covered by this inspection guide. If any unsafe - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 18
worn. 4. Remove the cover. 5. Check for any obvious non-IBM alterations. Use good judgment as to the safety of any non-IBM alterations. 6. Check that the power-supply cover fasteners (screws or rivets) have not been removed or tampered with. 14 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 19
is especially useful when handling ESD-sensitive devices. Select a grounding system, such as those listed below, to provide protection that meets the specific service requirement. Note The use of a grounding system is desirable but not required to protect against ESD damage. - Attach the ESD ground - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 20
Werden Steuer- und Einstellelemente anders als hier festgesetzt verwendet, kann gefährliche Laserstrahlung auftreten. L'utilizzo di controlli, regolazioni o l'esecuzione di procedure diverse da quelle specificate possono provocare l'esposizione a 16 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 21
aquí especificados puede provocar la exposición a radiaciones peligrosas. Opening the CD-ROM drive could result in exposure to hazardous laser radiation. There are no serviceable parts inside the CD-ROM drive. Do not open. Some CD-ROM drives contain an embedded Class 3A or Class 3B laser diode. Note - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 22
18 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 23
any FRU. Use new nylon-coated screws when you replace FRUs. Be extremely careful during such write operations as copying, saving, or formatting. Drives in the computer that you are servicing might have been rearranged, or the drive startup sequence might have been altered. If you select an incorrect - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 24
covered under warranty: LCD drive cover or by the insertion of a diskette with multiple labels. Damaged or bent diskette eject button. Fuses blown by attachment of a nonsupported device. Forgotten computer password (making the computer unusable). 20 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 25
Important The following symptoms might indicate damage caused by nonwarranted activities: Missing parts might be a symptom of unauthorized service or modification. Hard disk drive spindles can become noisy from being subjected to excessive force or from being dropped. I9990303 errors can be caused - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 26
HDP-1 or the HDP-2 is automatically enabled, but the HDP prompt does not appear. The HDP-1 or the HDP-2 are then set to the same password as the PAP. 22 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 27
system board must be replaced. If the customer forgets the hard disk password, the hard disk drive must be replaced. How to remove the power-on passwords: If only the power-on password is set, do the following to remove it: 1. Turn off the computer. 2. Remove the DIMM cover from the bottom of the - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 28
in the "Power Management Properties" window, the computer goes into hibernation mode.) Note: Even if you don't set the low-battery alarm, the charge indicator lets you know that the battery is low, and then the ThinkPad automatically enters 24 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 29
to use hibernation mode, you should reinstall Windows NT with a FAT format system. In hibernation mode, the following occurs: The system status, RAM, VRAM, and setup data are stored on the hard disk. The system is powered off. Notes 1. In the ThinkPad Configuration program, the computer can be set - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 30
when battery becomes low. When the power is turned on, the computer leaves hibernation mode and resumes operation. The hibernation file in the boot record on the hard disk drive is read, and system status is restored from the hard disk drive. 26 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 31
guide in identifying and correcting problems with the ThinkPad computer. Note: The diagnostic tests are intended to test only IBM products. The use of non-IBM PC-Doctor disk into the diskette drive; then power on the computer the model and press Enter. Follow the instructions on the screen. 2. The PC- - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 32
Sound Card is not recognized in the Hardware Info. 4. Run the applicable function test. 5. Follow the instructions on the screen. If there is a problem, PC-Doctor shows some Configuration Memory Contents Physical Disk Driver Logical Disk Driver 28 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 33
Info FRU Info Checkout guide Utility: Run External Tests Surface Scan Hard Disk Benchmark System DOS Shell Tech Support Form Battery Rundown View Test Log Print Log Save Log Full Erase Hard Drive Quick Erase Hard Drive Power system checkout To verify the symptom of a problem, do the following - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 34
and after it cools down, reinstall and recharge it. To check the battery pack, do the following: 1. Power off the computer. 2. Remove the battery pack and measure the voltage between battery terminals 1 (+) and 4 (−). See the following figure: 30 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 35
terminals 3 and 4. The resistance must be 4 to 30 K ohm. If the resistance is not correct, replace the battery pack. If the resistance is correct, replace the system board. Checking the backup battery: Do the following: 1. Power off the computer, and unplug the ac adapter from it. 2. Turn the - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 36
Checkout guide If the voltage is correct, replace the system board. If the voltage is not correct, replace the backup battery. If the backup battery discharges quickly after replacement, replace the system board. 32 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 37
system board . . . 82 2010 LCD front bezel 84 2020 Inverter card 87 2030 LCD panel 88 2040 Hinges 91 3010 Blank bezel in the UltraBase 92 Battery pack in the UltraBase 93 Locations 94 Front view 94 Rear view 96 Bottom view 97 Password pads 98 Parts List 99 Copyright IBM Corp. 2000 33 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 38
ThinkPad 570 and 570E LCD FRU 103 Keyboard 106 Common Parts List 108 34 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 39
"Structure" on page 38 "Fn key combinations" on page 41 Specifications The following table lists the specifications of the ThinkPad 570 series: Feature Processor Bus architecture Memory (standard) Memory (option) CMOS RAM Description 570 Mobile Pentium II 300 MHz, L2 256-KB cache Intel Mobile - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 40
Serial USB RJ11 56.6 Kbps Internal microphone Software control volume IrDA 1.1 One Type-III or two Type-II 56-watt type CD-ROM/DVD drive - 24 x CD-ROM drive - 2 x DVD drive (570 only) - 6 x DVD drive (570E only) Audio - Internal monaural speaker 36 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 41
battery is charging. The battery needs charging. Suspend mode Entering suspend mode Data is read from or written to the hard disk drive. The numeric keypad on the keyboard is enabled. Caps Lock mode is enabled. Arrow keys can be used as screen-scroll function keys. Power on ThinkPad 570 and 570E - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 42
Product overview Structure The following illustration shows the overall organization if the FRUs. 38 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 43
to the TrackPoint pointer. This symptom is not a hardware problem. No service action necessary if the pointer stops after a short time. If this does not correct the TrackPoint problem, continue with the following. Interactive Tests --> Mouse Diagnostics --> Fixed Disks ThinkPad 570 and 570E 39 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 44
, replace the DIMM and run the test again. 3. If the test does not detect the error, run Memory Test - Full (Diagnostics). 1. Turn on the computer and check the air turbulence at the louver near the power switch. 2. Run the fan test in Other Devices (Diagnostics) 40 ThinkPad 570 and 570E Hardware - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 45
. Reserved. Reserved. Switch between the LCD and an external monitor. Turn screen Windows 98, only the CPU speed is changed. Turn hibernation mode on. Increase the volume, or unmute. Decrease the volume, or unmute. Mute. Note: To turn on the sound, press Fn + PgUp or Fn + PgDn. ThinkPad 570 and 570E - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 46
problems" on page 46. Note For IBM devices not supported by diagnostic codes in the ThinkPad notebook computers, see the manual for that device. Numeric error codes Symptom or error FRU or action, in sequence 0200 Fixed disk failure 1. Reseat the hard disk drive. 2. Load Setup Defaults in IBM - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 47
Utility. 2. DIMM. 3. System board. 1. Load Setup Defaults in IBM BIOS Setup Utility. 2. DIMM. 3. System board. 1. Check that the drive is defined with the proper diskette type in IBM BIOS Setup Utility. 2. Run the diskette diagnostics test. 1. System board. 1. System board. ThinkPad 570 and 570E 43 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 48
Setup Defaults in IBM BIOS Setup Utility. 2. Backup battery. 3. System board. 1. Enter IBM BIOS Setup Utility and see whether the hard disk drive and diskette drive are properly identified. 2. Diskette drive. 3. Hard disk drive. 4. System board. 44 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 49
Reseat DIMM. 2. System board. 1. Speaker. LCD-related symptoms Important The TFT LCD for the notebook computer contains many thin-film transistors (TFTs). A small number of dots that are missing, discolored, or always lighted is characteristic of TFT LCD technology, but excessive pixel problems can - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 50
devices are supported by the computer. Verify that the power supply being used at the time of the failure is operating correctly. (See "Power system checkout" on page 29.) 1. Power off the computer. 2. Visually check each FRU for damage. Replace any damaged FRU. 46 ThinkPad 570 and 570E Hardware - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 51
Non-IBM devices b. Devices attached to the port replicator c. Printer, mouse, and other external devices d. Battery pack e. Hard disk drive f. External diskette drive g. DIMM h. CD-ROM and diskette drive in the UltraslimBay i. PC Cards 4. Power on the computer. 5. Determine whether the problem has - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 52
the screw head touches the surface of the logic card: Torque driver If you have a torque driver, refer to the "Torque" column with each step. Make sure you use the correct screw. If you have a torque screwdriver, tighten all screws firmly to the 48 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 53
the unique number is designed to provide unique IDs until the year A.D. 3400. No two computers in the world have the same number. When you replace the system board, you must set the UUID on the new system board as follows: ThinkPad 570 and 570E 49 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 54
FRU replacement notices 1. Install the ThinkPad Hardware Maintenance Diskette Version 1.60, and restart the computer. 2. Select 4. Assign UUID from the main menu. A new UUID is created and written. If a valid UUID already exists, it is not overwritten. 50 ThinkPad 570 and 570E Hardware Maintenance - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 55
the battery pack as required by local ordinances or regulations. Safety Notice 8: Translation on page 10 Before removing any FRU, power off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables. ThinkPad 570 and 570E 51 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 56
Removing and replacing a FRU Attention The system board is sensitive to, and can be damaged by, electrostatic discharge. Establish touching these units. You must use electrostatic discharge (ESD) strap (P/N 6405959) to establish personal grounding. 52 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 57
Removing and replacing a FRU 1010 Battery pack ThinkPad 570 and 570E 53 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 58
. Dispose of the battery as required by local ordinances or regulations. The use of an incorrect battery can result in ignition or explosion of the battery. Battery pack (1010) Step 1 Screw (quantity) M2.5 x 3 mm (1) (continued) Torque 4 kgcm 54 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 59
Cable route: Removing and replacing a FRU ThinkPad 570 and 570E 55 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 60
Removing and replacing a FRU 1030 DIMM Battery pack (1010) Note The ThinkPad 570E computer's DIMM slot faces in the direction opposite that shown here. However, the procedure for removing DIMM is the same. Step 1 Screw (quantity) Not removable Torque 4 kgcm 56 ThinkPad 570 and 570E Hardware - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 61
the user make a backup copy of all the information on the drive if possible. Never remove the drive while the system is operating or in suspend mode. Battery pack (1010) 1 Coin screw or security screw Note: Use a 2.5-mm allen wrench to remove the security screw. (continued) ThinkPad 570 and 570E 57 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 62
Removing and replacing a FRU When removing the hard disk drive, open the LCD a little as shown in the figure. Attention Be careful not to drop the hard disk drive. It is still attached to the cover when you push it up. 58 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 63
Removing and replacing a FRU 1050 Keyboard Battery pack (1010) Hard disk drive (1040) Step 1 Screw (quantity) M2.5 x 9 mm (3) Torque 4 kgcm (continued) ThinkPad 570 and 570E 59 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 64
Removing and replacing a FRU 60 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 65
Removing and replacing a FRU 1060 Center cover Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Step 1 2 3 Screw (quantity) M2.5 x 3 mm (2) M2.5 x 9 mm (1) M2.5 x 9 mm (1) Torque 4 kgcm 4 kgcm 4 kgcm ThinkPad 570 and 570E 61 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 66
Removing and replacing a FRU 1070 Modem card Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) 62 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 67
Removing and replacing a FRU 1080 Frame and power switch Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Step 1 Screw (quantity) M2.5 x 3 mm (4) (continued) Torque 4 kgcm ThinkPad 570 and 570E 63 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 68
Removing and replacing a FRU Step 2 Screw (quantity) M2.5 x 4.8 mm (4) Torque 4 kgcm 64 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 69
Removing and replacing a FRU 1090 Audio card Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Modem card (1070) Frame and power switch (1080) Step 4 Screw (quantity) M2.5 x 4.8 mm (1) Torque 4 kgcm ThinkPad 570 and 570E 65 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 70
and replacing a FRU 1100 Modem jack Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Modem card (1070) Frame and power switch (1080) Audio card (1090) Step 1 Screw (quantity) M2.5 x 4.8 mm (1) Torque 4 kgcm 66 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 71
replacing a FRU 1110 Speaker Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Modem card (1070) Frame and power switch (1080) Audio card (1090) For the ThinkPad 570 computer Step 1 Screw (quantity) M2.5 x 4.8 mm (2) (continued) Torque 4 kgcm ThinkPad 570 and 570E - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 72
Removing and replacing a FRU For the ThinkPad 570E computer 68 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 73
cable Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Modem card (1070) Frame and power switch (1080) Audio card (1090) When replacing: Make sure you install the cable in the correct direction. Installing it the wrong direction will cause audio problems. ThinkPad 570 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 74
Removing and replacing a FRU 1130 PC Card slots Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) Step 1 Screw (quantity) M2.5 x 4.8 mm (1) Torque 4 kgcm 70 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 75
Removing and replacing a FRU 1140 Hard disk drive cable Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) For the ThinkPad 570 computer Step 1 Screw (quantity) M2.5 x 4.8 mm (2) (continued) Torque 4 kgcm ThinkPad 570 and 570E 71 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 76
Removing and replacing a FRU For the ThinkPad 570E computer Step 1 Screw (quantity) M2.5 x 4.8 mm (2) (continued) Torque 4 kgcm 72 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 77
the hard disk drive. To install them correctly, do as follows: 1. Insert the tab of the cable 1 and catch the cable shield by the base cover latches 2 . 2. Catch the cable by the base cover latch 3 . 3. Insert the tabs of the cable shield 4 into the holes of the base cover. ThinkPad 570 and 570E 73 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 78
and replacing a FRU 1150 Upper shield Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) Step 2 3 Screw (quantity) M2.5 x 4.8 mm (3) M2 x 9 mm (4) (continued) Torque 4 kgcm 2 kgcm 74 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 79
Removing and replacing a FRU For the ThinkPad 570 computer Step 6 7 2 kgcm Screw (quantity) M2.5 x 4.8 mm (3) M2 x 9 mm (3) (continued) Torque 4 kgcm Yellow ThinkPad 570 and 570E 75 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 80
Removing and replacing a FRU For the ThinkPad 570E computer Step 5 6 Screw (quantity) M2 x 9 mm (3) M2.5 x 4.8 mm (1) Torque 4 kgcm 4 kgcm 76 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 81
Removing and replacing a FRU 1160 Fan Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) Upper shield (1150) For the ThinkPad 570 computer Note: Do not pinch the fan cable when re-installing the fan. Step 1 Screw (quantity) M2 x 9 mm (2) - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 82
Step 1 Screw (quantity) M2.5 x 4.8 mm (2) Torque 2 kgcm When replacing: 1. Make sure not to pinch the fan cable when re-installing the fan. 2. Apply grease to the underside of the surface shown in the dotted square in the following figure: 78 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 83
Removing and replacing a FRU 1170 LCD unit Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) Step 1 Screw (quantity) M2.5 x 4.8 mm (4) (continued) Torque 4 kgcm ThinkPad 570 and 570E 79 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 84
Removing and replacing a FRU Step 2 3 5 Screw (quantity) M2 x 9 mm (1) M2.5 x 4.8 mm (1) M2.5 x 4.8 mm (2) Torque 4 kgcm 4 kgcm 4 kgcm 80 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 85
cover (1060) Modem card (1070) Frame and power switch (1080) Audio card (1090) Modem jack (1100) Speaker (1110) Audio cable (1120) PC Card slots (1130) Hard disk drive cable (1140) Upper shield (1150) LCD unit (1170) Step 1 Screw (quantity) M2.5 x 4.8 mm (4) Torque 4 kgcm ThinkPad 570 and 570E - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 86
switch (1080) Audio card (1090) Modem jack (1100) Speaker (1110) Audio cable (1120) PC Card slots (1130) Hard disk drive cable (1140) Upper shield (1150) LCD unit (1170) Step 1 Screw (quantity) M2.5 x 4.8 mm (2) (continued) Torque 4 kgcm 82 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 87
Removing and replacing a FRU ThinkPad 570 and 570E 83 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 88
and replacing a FRU 2010 LCD front bezel Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) LCD unit (1170) CAUTION: The inverter card has a high tension current. To avoid shock hazard, never power on the computer when the LCD cover is - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 89
Removing and replacing a FRU 13.1-inch XGA TFT LCD Step 1 Screw (quantity) M2.5 x 3 mm (2) Torque 4 kgcm ThinkPad 570 and 570E 85 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 90
Removing and replacing a FRU 12.1-inch SVGA TFT LCD Step 1 Screw (quantity) M2.5 x 3 mm (4) Torque 4 kgcm 86 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 91
Removing and replacing a FRU 2020 Inverter card Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) LCD unit (1170) LCD front bezel (2010) Note: Be careful of high voltage on the cable. Connect the LCD connector firmly to the inverter card by - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 92
and replacing a FRU 2030 LCD panel Battery pack (1010) Hard disk drive (1040) Center cover (1060) LCD unit (1170) LCD front bezel (2010) Inverter card (2020) 13.3-inch XGA TFT LCD Step 1 2 Screw (quantity) M2.5 x 3 mm (2) M2.5 x 3 mm (2) (continued) Torque 4 kgcm 4 kgcm 88 ThinkPad 570 and 570E - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 93
Removing and replacing a FRU Step 4 Screw (quantity) M2.5 x 3 mm (2) Torque 4 kgcm Note Blue, Small head ThinkPad 570 and 570E 89 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 94
Removing and replacing a FRU 12.1-inch SVGA TFT LCD Step 1 Screw (quantity) M2.5 x 3 mm (4) Torque 4 kgcm 90 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 95
and replacing a FRU 2040 Hinges Battery pack (1010) Hard disk drive (1040) Keyboard (1050) Center cover (1060) Frame and power switch (1080) LCD unit (1170) LCD front bezel (2010) Inverter card (2020) LCD panel (2030) 13.3-inch XGA TFT LCD: See "2030 LCD panel" on page 88. 12.1-inch SVGA TFT LCD - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 96
Removing and replacing a FRU 3010 Blank bezel in the UltraBase In the UltraslimBay In the diskette-drive/battery bay 92 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 97
Removing and replacing a FRU Battery pack in the UltraBase ThinkPad 570 and 570E 93 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 98
in microphone 4 External diskette drive 5 Diskette eject button 6 Headphone jack 7 Line-In jack 8 Microphone jack 9 Reset switch 1 PC Card slots 11 PC Card eject button 12 Status indicator 13 TrackPoint 14 Click buttons 15 Fn Key 16 Suspend switch 94 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 99
Locations ThinkPad 570 and 570E 95 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 100
Locations Rear view 1 Security keyhole 2 AC Adapter jack 3 External-diskette-drive connector 4 Serial connector 5 Parallel connector 6 External-monitor connector 7 External-input-device connector 8 Modem connector 96 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 101
Bottom view 1 Battery pack 2 Battery release switch 3 Built-in speaker 4 Expansion connector 5 Power switch 6 USB port 7 Memory slot 8 Hard disk drive 9 LCD latches Locations ThinkPad 570 and 570E 97 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 102
Locations Password pads 98 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 103
Parts List Parts list ThinkPad 570 and 570E 99 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 104
replacement unit). No. FRU 1 LCD unit (see "LCD FRU" on page 103.) 2 Center cover, for 12.1-inch Center cover (570), for 13.3-inch Center cover (570E), for 13.3-inch 3 Keyboard (see "Keyboard" on page 106) 4 Keyboard bezel (570) Keyboard bezel (570E ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 105
13 DIMM cover* 05K6071 14 Battery pack*, Panasonic 02K6638 Battery pack*, SANYO 02K6639 15 Backup battery* 02K6572 Holder, backup battery (see system misc. parts) 16 Hard disk drive* (4.0 GB) 22L0018 Hard disk drive* (6.0 GB) 22L0055 Hard disk drive* (6.4 GB) 22L0019 Hard disk drive - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 106
(5) System miscellaneous parts* (including nylon-coated screws): Power switch knob Holder, backup battery Cover, microphone Cover, I/O connector LID modem blank GND spring, LCD I/F Hard disk drive screw kit* P/N 08K5892 05K6066 08K6444 05K6073 102 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 107
LCD FRU 13.3-inch XGA TFT Parts list (continued) ThinkPad 570 and 570E 103 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 108
(see LCD Unit) 3 LCD rear cover 4 Hinges 5 Shield 6 LCD cables 7 LCD miscellaneous parts kit 8 Inverter card Rear shield Copper tape P/N 05K9506 05K9492 05K6456 05K6455 05K6077 08K6454 08K5290 08K6384 05K2836 05K6080 10L1249 08K6384 27L6460 104 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 109
inch SVGA TFT Parts list No. FRU LCD unit LCD rear cover kit for Korea 1 LCD front bezel 2 LCD panel (see LCD unit) 3 Inverter card 4 LCD rear cover 5 Hinges 6 LCD miscellaneous parts kit 7 LCD cables P/N 05K9505 10L1909 05K6076 10L1248 05K6074 05K6078 05K6080 27L0507 ThinkPad 570 and 570E 105 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 110
10L2184 10L2172 10L2174 10L2170 10L2198 10L2194 10L2202 10L2192 10L2196 10L2186 10L2204 10L2178 10L2166 02K6555 02K6554 02K6557 02K6556 84G6536 05K2707 10L2149 05K6211 08K6585 11J9003 05K5666 106 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 111
8X stereo CD-ROM drive 6.4-GB hard disk drive DVD 6X (RPC II) UltraslimBay drive DVD UltraslimBay drive for North America (Region 1) for Japan and EMEA (Region 2) for AP North and AP South (Region 3) for LA and AP South (Region 4) for Russia (Region 5) for China (Region 6) 32-MB SDRAM SO DIMM* 64-MB - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 112
test cable Screwdriver kit Torque screwdriver 5mm socket wrench Screwdriver ThinkPad hardware maintenance diskette version 1.60 Note: Download the file from the Web site. 72X8546 35G4703 66G5180 05K2580 95F3598 05K4695 05K4694 27L8126 - 108 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 113
Parts list Power cords: IBM power cords for a specific country are usually available only in that country: For 2-pin power cords: Used in these , Italy, Libya Israel Korea P/N 36L8867 76H3514 76H3516 02K0539 76H3518 76H3520 76H3522 76H3524 76H3528 76H3530 76H3532 76H3535 ThinkPad 570 and 570E 109 - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 114
Parts list 110 ThinkPad 570 and 570E Hardware Maintenance Manual - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 115
in the United States or other countries or both: IBM ThinkPad TrackPoint Asset ID PC-Doctor DOS is a trademarks of Watergate Software, Inc., in the United States and other countries. Microsoft, Windows, Windows NT, and the Windows logo are trademarks of Microsoft Corporation in the United States - Lenovo ThinkPad 570 | English - Hardware Maintenance Manual for 570 systems - Page 116
Part Number: 09N8609 Printed in U.S.A.
January 2000
This manual supports:
ThinkPad 570 (MT 2643/2644)
ThinkPad 570E (MT 2643/2644)