Poulan 271150 User Manual

Poulan 271150 Manual

Get Poulan 271150 PDF manuals and user guides View all Poulan 271150 manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan 271150 manual content summary:

  • Poulan 271150 | User Manual - Page 1
    MODEL NO. 271150 13.5 HP 38 INCH LAWN TRACTOR • Assembly • Operation • Maintenance • Service and Adjustments • Troubleshooting • Repair Parts For Parts and Service, contact our authorized distributor: call 1-800-849-1297 For Technical Assistance: call 1-800-829-5886 185514 11.25.02
  • Poulan 271150 | User Manual - Page 2
    Service and Adjustments 20 Storage 25 Troubleshooting 26 Repair Parts 30 Warranty 46 SAFETY RULES IMPORTANT: This cutting machine is capable of amputating hands and feet and throw- ing objects. Failure to observe the following safety instructions NOT: percentage of riding mower-related in- •
  • Poulan 271150 | User Manual - Page 3
    check components and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp and can cut. Wrap the blade(s) or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Ad- just and service as required. • Be sure the area is
  • Poulan 271150 | User Manual - Page 4
    Too heavy of a load, while on a slope, is dangerous. Tires can lose traction with the ground and cause you to lose control of your tractor. WARNING: Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the State of California to cause cancer and
  • Poulan 271150 | User Manual - Page 5
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, welltrained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan 271150 | User Manual - Page 6
    UNASSEMBLED PARTS Steering Wheel Steering Wheel Insert (1) Hex nut 1/2-20 (1) Large Flat Washer (1) Hex Bolt 1/4-28 x 1-1/4 (1) Locknut 1/4-28 Steering Wheel Adapter Seat Steering Boot Steering Extension Shaft (1)
  • Poulan 271150 | User Manual - Page 7
    right or left hand is mentioned in this manual, it means, from your point of view, when you are in the operating position (seated behind the steering wheel). TO REMOVE TRACTOR FROM CARTON UNPACK CARTON 1. Remove all accessible loose parts and parts boxes from carton. 2. Cut along dotted lines on
  • Poulan 271150 | User Manual - Page 8
    service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). Seat pan Terminal Label Terminal NOTE: You may now roll or drive your tractor
  • Poulan 271150 | User Manual - Page 9
    . Verify that the belts are routed correctly. CHECK DECK LEVELNESS For best cutting results, mower housing should be properly leveled. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. CHECK BRAKE SYSTEM After you learn how to operate your tractor, check to see
  • Poulan 271150 | User Manual - Page 10
    MOWER HEIGHT MOWER LIFT 15 15 15 ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) Failure to follow instructions in damage to the tractor and/or engine. HOT
  • Poulan 271150 | User Manual - Page 11
    Standards Institute. ATTACHMENT CLUTCH LEVER - Used to engage the mower blades, or other attachments mounted to your tractor. ATTACHMENT LIFT LEVER - Used to raise, lower, and adjust the mower deck or other attachments mounted to your tractor. CLUTCH/BRAKE PEDAL - Used for declutching and braking
  • Poulan 271150 | User Manual - Page 12
    reduces the battery charging rate. • Full throttle offers the best bagging and mower performance. TO MOVE FORWARD AND BACKWARD The direction and speed of movement is controlled by the gearshift lever. 1. Start tractor with clutch/brake pedal depressed and gearshift lever in neutral (N) position
  • Poulan 271150 | User Manual - Page 13
    lawns, mow often and after moderate growth. • For best cutting performance, grass over 6 inches in height should be mowed twice. Make the first cut relatively high; the second to desired height. TO OPERATE MOWER Your tractor . Use the slope guide provided at the back of this manual. • Choose the
  • Poulan 271150 | User Manual - Page 14
    system of an engine while in storage. To avoid engine problems, the fuel system should be emptied before storage of 30 are empty. Use fresh fuel next season. See Storage Instructions for additional information. Never use engine or carburetor cleaner Service and Adjustments section of this manual). 14
  • Poulan 271150 | User Manual - Page 15
    TIPS • Tire chains cannot be used when the mower housing is attached to tractor. • Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so
  • Poulan 271150 | User Manual - Page 16
    receive full value from the warranty, operator must maintain tractor as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. All adjustments in the Service and Adjustments section of this manual should be checked at least once each season
  • Poulan 271150 | User Manual - Page 17
    may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. OPERATOR PRESENCE SYSTEM Be sure operator presence and interlock systems are working properly. If your tractor does not function as described, repair the problem immediately. • The engine should not
  • Poulan 271150 | User Manual - Page 18
    or checking level of electrolyte is not necessary. Determine temperature range expected before oil change. All oil must meet API service classification SF-SJ. • Be sure tractor is on level surface. TO CLEAN BATTERY AND TERMINALS Corrosion and dirt on the battery and terminals can cause the battery
  • Poulan 271150 | User Manual - Page 19
    " section of this manual. IN-LINE FUEL FILTER tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower
  • Poulan 271150 | User Manual - Page 20
    4. Turn ignition key to "STOP" and remove key. 5. Make sure the blades and all moving parts have completely stopped. 6. Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER Mower will be easier to remove from the right side of
  • Poulan 271150 | User Manual - Page 21
    that both front links are equal in length. Front Links TO REPLACE MOWER BLADE DRIVE BELT The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL 1. Place attachment clutch in "DISEN- GAGED" position. 2. Move attachment lift
  • Poulan 271150 | User Manual - Page 22
    TO REMOVE MOWER" in this section of manual). NOTE: Observe entire motion drive belt and position of all belt guides and keepers. 2. Remove belt from stationary idler and clutching idler. 3. Remove belt downward from around engine pulley. 4. Pull belt slack toward rear of tractor. Remove belt upwards
  • Poulan 271150 | User Manual - Page 23
    tractor. If damage has occurred to affect the front wheel toe-in or camber, contact your nearest authorized service may be purchased from your local parts dealer. Tire sealant also prevents tire manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: Your tractor
  • Poulan 271150 | User Manual - Page 24
    tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts If the carburetor does need adjustment, see engine manual. High speed stop is factory adjusted. Do an authorized service center/department, which has proper equipment
  • Poulan 271150 | User Manual - Page 25
    in any enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is to be stored tractor (See "CLEANING" in the Maintenance section of this manual). 2. Inspect and replace belts, if necessary (See belt replacement instructions in the Service and Adjustments section of this manual
  • Poulan 271150 | User Manual - Page 26
    TROUBLESHOOTING CHART PROBLEM Will not start CAUSE CORRECTION 1. Out of fuel. 1. Fill fuel tank. 2. Engine not Check/replace ignition switch. 8. Check/replace solenoid or starter. 9. Contact a qualified service center/department. Engine clicks but will not start 1. Weak or dead battery. 2.
  • Poulan 271150 | User Manual - Page 27
    TROUBLESHOOTING CHART PROBLEM Loss of power CAUSE 1. Cutting too much grass/too fast. 2. Throttle in "CHOKE" position. 3. Build-up of grass, leaves and trash under mower. 4. Dirty air filter. 5. Low oil level/dirty oil. 6. Faulty spark plug. 7. Dirty fuel filter. 8. Stale or dirty fuel. 9. Water in
  • Poulan 271150 | User Manual - Page 28
    TROUBLESHOOTING CHART PROBLEM CAUSE Mower blades will 1. Obstruction in clutch not rotate mechanism. 2. Worn/damaged mower drive belt. 3. Frozen idler pulley. 4. Frozen blade mandrel. CORRECTION 1. Remove obstruction. 2. Replace mower drive belt. 3. Replace idler pulley. 4. Contact a quali
  • Poulan 271150 | User Manual - Page 29
    SCHEMATIC TRACTOR -- MODEL NUMBER 271150 RED BATTERY BLACK A AMMETER (OPTIONAL) RED WHITE RED S BM G A1 L A2 IGNITION SWITCH CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 29
  • Poulan 271150 | User Manual - Page 30
    ELECTRICAL REPAIR PARTS TRACTOR -- MODEL NUMBER 271150 22 21 42 24 41 43 27 27 26 40 27 27 25 33 30 16 16 8 2 1 48 27 52 29 28 90 30
  • Poulan 271150 | User Manual - Page 31
    ELECTRICAL TRACTOR -- MODEL NUMBER 271150 KEY PART NO. NO. DESCRIPTION 1 163465 Battery 2 74760412 Bolt, Hex Head 1/4-20 unc x 3/4 8 176689 Box Battery Fender 16 176138 Switch, Interlock 21 175685 Harness, Light Socket (Includes
  • Poulan 271150 | User Manual - Page 32
    TRACTOR -- MODEL NUMBER 271150 CHASSIS AND ENCLOSURES 30 25 26 31 209 208 11 17 24 18 25 26 209 9 15 209 24 5 5 209 8 209 212 29 12 28 53 51 52 55 57 54 26 33 10 3 35 6 16 37 3 1 13 145 37 2 35 205 34 208 38 26 206 3 38 205 32
  • Poulan 271150 | User Manual - Page 33
    TRACTOR -- MODEL NUMBER 271150 CHASSIS AND ENCLOSURES KEY PART NO. NO. DESCRIPTION 1 174620 Chassis 2 176554 Drawbar 3 3/8-16 x 3/4 37 17490508 Screw Thdrol 5/16-18 x 1/2 38 175710 Bracket Asm Pivot Mower Rear 51 73800400 Nut Lock Hex w/Ins 1/4-20 52 19091416 Washer 9/32 x 7/8 x 16
  • Poulan 271150 | User Manual - Page 34
    TRACTOR -- MODEL NUMBER 271150 GROUND DRIVE 57 51 21 8 12 59 7 10 61 12 13 56 14 112 16 11 52 30 32 18 113 41 170 6 6 51 5 18
  • Poulan 271150 | User Manual - Page 35
    TRACTOR -- MODEL NUMBER 271150 GROUND DRIVE KEY PART NO. NO. 1 ------ 2 146682 3 123666X 4 12000028 5 Pulley Eng Cl Cable Bolt Hex 7/16-20 x 4 Gr 5 Washer Lock Hlcl Spr 7/16 Keeper Belt Engine FP Guide Belt Mower Drive RH Spacer Axle Washer 25/32 x 1-1/4 x16 Ga E-ring #5133-75 Key Square 2 0
  • Poulan 271150 | User Manual - Page 36
    STEERING TRACTOR -- MODEL NUMBER 271150 38 12 39 1 37 44 51 91 43 41 42 37 36 54 88 71 68 29 15 15 82 15 29 46 8 6 17 9 2 7 9 5 3 40 29 68 67 67 47 13 65 85 85 32 11 26 67 46 8 6 9 47 7 9 5 4 43 28 10 30 43 6 8 36
  • Poulan 271150 | User Manual - Page 37
    STEERING TRACTOR -- MODEL NUMBER 271150 KEY PART NO. NO. DESCRIPTION 1 140044X428 Steering Wheel 2 175131 Axle Assembly 3 169840 Spindle Assembly, L.H. 4 169839 Spindle Assembly, R.H. 5 6266H Bearing, Race, Thrust, Hardened 6 121748X Washer 25/32 x 1-5/8 x 16
  • Poulan 271150 | User Manual - Page 38
    ENGINE 2 1 TRACTOR -- MODEL NUMBER 271150 3 72 81 13 4 78 38 32 14 16 44 78 46 33 31 37 33 40 45 29 23 OPTIONAL EQUIPMENT Spark Arrester 38
  • Poulan 271150 | User Manual - Page 39
    ENGINE TRACTOR -- MODEL NUMBER 271150 KEY PART NO. NO. 1 170551 2 17720408 3 ------ 4 137348 13 165291 14 81 73510400 DESCRIPTION Control Th/ch Screw Hex Thd Cut 1/4-20 x 1/2 Engine Briggs Model 28R707-1147-E1 (Order parts from Engine Manufacturer) Muffler Gasket Eng 1 313 Id Tin Plated Tube Drain
  • Poulan 271150 | User Manual - Page 40
    TRACTOR -- MODEL NUMBER 271150 SEAT ASSEMBLY 1 14 24 8 9 7 10 5 8 9 7 5 6 22 21 2 16 25 15 11 13 17 12 KEY PART NO. NO. 1 127427 2 140551 3 71110616 4 19131610 5 145006 6 73800600 7 124181X 8 17000616 9 19131614 10 182493 11 166369 12 121246X DESCRIPTION Seat Bracket Pvt St Bolt Fin Hex
  • Poulan 271150 | User Manual - Page 41
    Dr Sch tractor Decal V-Belt sch Decal Handle Lft Height Adjust (Lift Handle) Owner's Manual, English Owner's Manual, Spanish WHEELS AND TIRES 1 2 5,8 4,10 7 6 KEY PART NO. NO. DESCRIPTION 1 59192 Cap Valve Tire 2 65139 Stem Valve 3 106222X Tire F Ts 15 X 6 0 - 6 Service 4 59904 Tube
  • Poulan 271150 | User Manual - Page 42
    TRACTOR -- MODEL NUMBER 271150 LIFT ASSEMBLY 5 11 19 13 13 4 6 12 13 31 32 19 13 31 32 7 8 3 1 2 6 5 4 20 15 17 18 20 16 20 20 15 42
  • Poulan 271150 | User Manual - Page 43
    TRACTOR -- MODEL NUMBER 271150 LIFT ASSEMBLY KEY PART NO. NO. 1 159460 2 159471 3 105767X 4 12000002 5 19211621 6 120183X 7 125631X 8 122365X 11 139865 12 139866 13 4939M 15 173288 16 73350800 17 175689 18 73800800 19
  • Poulan 271150 | User Manual - Page 44
    MOWER DECK TRACTOR -- MODEL NUMBER 271150 158 151 152 21 40 146 89 107 67 157 38 42 148 68 108 36 156 153 155 89 153 154 56 36 69
  • Poulan 271150 | User Manual - Page 45
    MOWER DECK TRACTOR -- MODEL NUMBER 271150 KEY PART NO. NO. DESCRIPTION 1 170280 Mower Housing Assembly 2 72140506 Bolt, 17720408 - - 130794 - - 171665 DESCRIPTION Washer Hardened Idler Arm Assembly Spacer, Retainer Knob Belt Pin, Cotter 3/32 x 3/4 Runner, LH Runner, RH Washer 11/32 x 3/4
  • Poulan 271150 | User Manual - Page 46
    parts or labor incurred in replacing parts, any part the instructions furnished. belts, blades, blade adapters, normal wear, normal adjustments, standard hardware and normal maintenance. 7. In the event you have a claim under this Warranty, you must return the product to an authorized service dealer
  • Poulan 271150 | User Manual - Page 47
    47 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan 271150 | User Manual - Page 48
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
For Parts and Service, contact our authorized distributor:
call 1-800-849-1297
For Technical Assistance:
call 1-800-829-5886
MODEL NO.
271150
13.5 HP 38 INCH
LAWN
TRACTOR
185514
11.25.02
RD
PRINTED IN U.S.A.
•
Assembly
•
Operation
•
Maintenance
•
Service and Adjustments
•
Troubleshooting
•
Repair Parts