Weber Genesis 1300 LP Owner Manual
Weber Genesis 1300 LP Manual
 |
View all Weber Genesis 1300 LP manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Genesis 1300 LP manual content summary:
- Weber Genesis 1300 LP | Owner Manual - Page 1
factory. GENESIS® 1300 Series LP Gas Barbecue Owner's Manual WEBER WEBER ® NationalPROPANEGAS Association ƽ DANGER If you smell gas: 1. Shut off gas to TO INSTALLER: These instructions must be left with the owner and the owner should keep them for future use. THIS GAS APPLIANCE IS DESIGNED FOR - Weber Genesis 1300 LP | Owner Manual - Page 2
using. See instructions in this manual for correct procedures. ƽ Do not operate the Weber Gas Barbecue if there is a gas leak present. ƽ Do not use a flame to check for gas leaks. ƽ Combustible materials should never be within 24 inches of the top, bottom, back or sides of your Weber Gas Barbecue - Weber Genesis 1300 LP | Owner Manual - Page 3
operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of your Weber. This Warranty applies only to products sold at retail. WEBER-STEPHEN PRODUCTS CO. Customer Service Center 250 South Hicks Road Palatine, IL 60067-6241 (800) 446-1071 LP Tank The LP - Weber Genesis 1300 LP | Owner Manual - Page 4
Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Genesis Gas Barbecues are covered under the following patent nos.: U.S.A. #4,677,964; 4,727,853; #4,777,927; #4,829,978; #4,860 - Weber Genesis 1300 LP | Owner Manual - Page 5
Warranty & Patents 3-4 General Instructions 6 Assembly 7-22 Operating Instructions Lighting 23-24 Cooking 25 Storage and/or Nonuse 25 Cleaning 25 e Troubleshooting & Maintenance LP Tank Information 26-28 Annual Maintenance 29 General Maintenance 30-32 Troubleshooting 33 Parts Listing 35 - Weber Genesis 1300 LP | Owner Manual - Page 6
location in your yard or on your patio. Portability means you can take your Weber Gas Barbecue with you if you move. Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than charcoal fuel. s These instructions will give you the minimum requirements for assembling your - Weber Genesis 1300 LP | Owner Manual - Page 7
a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. LP tank filler adapter Bottom tray Two cooking grates Control panel 7 - Weber Genesis 1300 LP | Owner Manual - Page 8
Left frame Right frame Wheel frame Caster frame Two frame connectors Work table Swing table assembly Slide bar assembly Axle Two accessory trays Warming rack Warm-Up Basket Five long Flavorizer Bars Eight short Flavorizer Bars Tank panel assembly Front panel Catch pan holder Catch pan Two drip pans - Weber Genesis 1300 LP | Owner Manual - Page 9
Check contents of hardware packs Three burner control knobs Three tool holders Five tubing plugs (two are spares) Swing table end bracket Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) Five 1/4-20 x 2 inch bolts (actual size) 1/4-20 x 1 1/4 inch bolt (actual size) Six 1/4- - Weber Genesis 1300 LP | Owner Manual - Page 10
on the block of wood (or other protected surface). Tap on one hubcap. Put one wheel on the axle, WEBER side toward the hubcap. Slide the axle through the frame. Add the other wheel, WEBER side out. Tap on the hubcap. Figure 1. ER WE B ER WE B Step 3 Assemble frame You will need: left frame - Weber Genesis 1300 LP | Owner Manual - Page 11
Step 4 Continue frame assembly You will need: caster frame, wheel frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel frame onto the tabs of the right frame - Weber Genesis 1300 LP | Owner Manual - Page 12
in the ends of the caster legs. Figure 5. Step 7 Add front panel You will need: front panel and two plastic buttons. Turn frame assembly right side up. Align the panel with the holes in the frame and insert the plastic buttons through the front panel and frame. Figure 6. Plastic buttons Figure - Weber Genesis 1300 LP | Owner Manual - Page 13
the frame brace. Figure 7. Burner tubes Frame brace Your Weber Gas Barbecue burner assembly has been factory assembled, pressure and flame answered NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use barbecue. Guide screw Figure 7 Slide the cooking box to the - Weber Genesis 1300 LP | Owner Manual - Page 14
Step 9 Install manifold bracket You will need: manifold bracket Hook the bracket onto the manifold at the center burner valve. Place your hand underneath the bracket. Lift the manifold, bracket and cooking box slightly and hook the tab of the bracket onto the frame brace. Figure 10. Frame brace - Weber Genesis 1300 LP | Owner Manual - Page 15
tank panel. Make sure indicator rod of fuel scale is on the left side of the wheel frame. Add washers then wing nuts and tighten. Figure 13 Step 12 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter. This was done to factory test the - Weber Genesis 1300 LP | Owner Manual - Page 16
the issue to your satisfaction, then call Weber-Stephen Products Co., Customer Service Center. To fill, take the LP tank and filler adapter to an RV center or look up gas-propane in the phone book for other sources of LP gas. ƽWARNING: We recommend that your LP tank be filled at an authorized - Weber Genesis 1300 LP | Owner Manual - Page 17
be at 3, 6, or 9 o'clock. It should not be pointed up. Figure 18 (c). Figure 16 Step 16 Connect LP tank ƽWARNING: Make sure that the LP tank valve is closed. Close by turning clockwise. Hook the LP tank onto the fuel scale. Loosen the tank lock wing nut. Swing the tank lock down. Tighten - Weber Genesis 1300 LP | Owner Manual - Page 18
for leaks with soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. c) Valves to manifold connections. Figure 20 (c). d) The hose to regulator connection. Figure 20 (d). ƽWARNING: If there - Weber Genesis 1300 LP | Owner Manual - Page 19
short Flavorizer Bars and two cooking grates. Set the long Flavorizer Bars side to side in the lower position, then set the short Flavorizer Bars front to box. Figure 22. Finger grip on front edge of bottom tray Front side of catch pan holder Figure 23 Hook the ends of the catch pan holder - Weber Genesis 1300 LP | Owner Manual - Page 20
Step 20 Install Lid You will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small holes in the hinge pins. Figure 26. Hair pin cotter Hinge pin Step 21 Add - Weber Genesis 1300 LP | Owner Manual - Page 21
bracket is in any way cracked or damaged, do not use swing table. Call our Customer Service Center to order a new part. ƽWARNING: The load limit for the swing table is 30 pounds. Hinge rod (a) (b) Support rod (a) Figure 28 View from rear of barbecue Figure 29 Slot in frame (view from below - Weber Genesis 1300 LP | Owner Manual - Page 22
and a hammer. Insert one end of the Weber Warm-Up Basket into the hole in the Figure 32 (b). Set the work table onto the left side rails. Figure 32 (c). Set the accessory rack in hammer. Figure 32 (f). Figure 30 To lower table: Pull support rod up to disengage slide lock, and lower table. To raise - Weber Genesis 1300 LP | Owner Manual - Page 23
barbecue. Replace using only Weber authorized replacement manifold assembly. Order from Weber- Stephen Products Co., Customer Service Center or authorized dealer. LP tank valve, the excess flow control will activate, limiting the flow of gas from the LP tank. If this should occur, turn OFF the LP - Weber Genesis 1300 LP | Owner Manual - Page 24
Manual Lighting ƽ DANGER Failure to open lid while igniting the barbecue, or not waiting 5 minutes to allow the gas to clear if the turn on the LP tank valve, the excess flow control will activate, limiting the flow of gas from the LP tank. If this should occur, turn OFF the LP tank valve and burner - Weber Genesis 1300 LP | Owner Manual - Page 25
See your Weber cookbook for detailed cooking instructions. Note: The gas must be turned off at the LP tank when the Weber Gas Barbecue is not in use. s When the Weber Gas Barbecue is stored indoors, the gas supply must be DISCONNECTED and the LP tank stored outdoors in a well-ventilated space. s LP - Weber Genesis 1300 LP | Owner Manual - Page 26
and turn tank lock up out of the way. 4) Lift tank off. To refill take LP tank and tank filler adapter to a "Gas Propane" dealer. ƽWARNING: We recommend that your LP tank be filled at an authorized LP gas dealer, by a qualified attendant, who fills the tank by weight. IMPROPER FILLING IS DANGEROUS - Weber Genesis 1300 LP | Owner Manual - Page 27
a leak. If leak does not stop, turn off the gas and contact Weber-Stephen Customer Service. Do not use the barbecue. g) When leak checks are complete, turn gas supply OFF and rinse connections with water. LP Tank The LP tank manufacturer is responsible for the materials, workmanship and performance - Weber Genesis 1300 LP | Owner Manual - Page 28
been tested within five years. Your LP gas supplier can do this for you. Figure 7. If you have questions about spare LP tanks, please call Weber-Stephen Customer Service. D.O.T. Certification (example) DOT 4BA240 1/98 20 lb LP tank Figure 7 Date Tested s All LP tank supply systems must include - Weber Genesis 1300 LP | Owner Manual - Page 29
manual. s Check all gas fittings for leaks. c) Valves to manifold connections. Figure 7 (c). d) The hose to regulator connection. Figure 7 (d). ƽWARNING: If there is a leak at connection (b), (c) or (d), turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When - Weber Genesis 1300 LP | Owner Manual - Page 30
ports are fully open. Figure 13 ƽCAUTION: Do not enlarge the burner ports when cleaning. Replacing Main Burners a) Your Weber Gas Barbecue must be OFF and cool. b) Turn gas OFF at source. c) Remove control panel: take off the burner control knobs. Remove the screws holding the control panel in - Weber Genesis 1300 LP | Owner Manual - Page 31
15. View from behind cooking box Wing nuts Figure 15 f) Slide the burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 16. Guide screw Figure 17 h) To reinstall the burners, reverse steps c) through g). ƽCAUTION: The burner openings must be positioned - Weber Genesis 1300 LP | Owner Manual - Page 32
20. White wire Check fit around burner Figure 19 ƽCAUTION: If the Spider Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. ƽWARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. See Step"Check for - Weber Genesis 1300 LP | Owner Manual - Page 33
. (See Section "Periodic Cleaning".) Fuel scale shows that there is gas in the LP Check adjustment of fuel scale. tank, but tank is empty. Fuel scale must be adjusted with an empty tank. If problems cannot be corrected by using these methods, please contact Weber-Stephen Customer Service. 33 - Weber Genesis 1300 LP | Owner Manual - Page 34
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17-18 19 20 13, 18 21 22 23 24 25 26 27 28 29 W E BE R W ® ® E BE R 34 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 38 46 47 48 49 50-51 52 53 54 55 56-57 58 59 60 61 - Weber Genesis 1300 LP | Owner Manual - Page 35
Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South ) 59 1/4-20 x 1 1/4 inch bolt 60 Filler adapter 61 LP tank ƽWARNING: Use only Weber factory authorized parts. The use of any part that is not factory - Weber Genesis 1300 LP | Owner Manual - Page 36
problems with parts or assembly. Call our toll free number 1-800-446-1071. For quicker service, please have your owner's manual available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish your family the best in outdoor cooking enjoyment. Weber
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
 |
 |
W
E
B
E
R
W
E
B
E
R
Serial Number
Please use this number in registering your warranty and
any correspondence with the factory.
Owner’s Manual
National
Association
PROPANE
GAS
®
92725
11/98
GENESIS
®
1300 Series
LP Gas Barbecue
m
WARNING
1.
Do not store spare LP Cylinder within
10 feet (3m) of this appliance.
2.
Do not
store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
m
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, Keep away from the
appliance and immediately call your
gas supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death or damage to property.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.