Weber Genesis 2 LP Owner Manual

Weber Genesis 2 LP Manual

Get Weber Genesis 2 LP PDF manuals and user guides View all Weber Genesis 2 LP manuals
Add to My Manuals
Save this manual to your list of manuals

Weber Genesis 2 LP manual content summary:

  • Weber Genesis 2 LP | Owner Manual - Page 1
    with the factory. GENESIS® 2000 Series Natural Gas Barbecue Owner's Manual WE BER BER WE ® WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must be left with
  • Weber Genesis 2 LP | Owner Manual - Page 2
    . ƽ After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before using. See instructions in this manual for correct procedures. ƽ Do not operate the Weber Gas Barbecue if there is a gas leak present. ƽ Do not use a flame to check for
  • Weber Genesis 2 LP | Owner Manual - Page 3
    of this Weber Gas Barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, 10 years, Cooking Grates and Flavorizer Bars, 3 years, All Remaining Parts, 5 years, when assembled and operated in accordance with the printed instructions
  • Weber Genesis 2 LP | Owner Manual - Page 4
    Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Genesis Gas Barbecues are covered under the following patent nos.: U.S.A. #4,677,964; 4,727,853; #4,777,927; #4,829,978; #4,860
  • Weber Genesis 2 LP | Owner Manual - Page 5
    Contents WARNINGS 2 Warranty & Patents 3-4 General Instructions 6 Assembly 7-20 Operating Instructions Lighting 21-22 Cooking 23 Storage and/or Nonuse 23 Cleaning 23 Troubleshooting & Maintenance Annual Maintenance 24 General Maintenance 25-27 Troubleshooting 28 Parts Listing 31 e a b c
  • Weber Genesis 2 LP | Owner Manual - Page 6
    Weber Gas Barbecue with you if you move. The natural gas supply is easy to use and gives you more cooking control than charcoal fuel. s These instructions will give you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before using your Weber Gas
  • Weber Genesis 2 LP | Owner Manual - Page 7
    You will need a soap and water solution to check for gas leaks. (See Step "Check for gas leaks.") Note - The hardware size of nuts, bolts and screws store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number
  • Weber Genesis 2 LP | Owner Manual - Page 8
    Caster frame Two casters Two cooking grates Warming rack Warm-Up Basket Thermometer Left hand slide bar assembly Assembly consists of: Left hand slide bar Support rod Slide 8
  • Weber Genesis 2 LP | Owner Manual - Page 9
    Catch pan holder Manifold bracket Check contents of hardware packs Three burner control knobs Three tool holders Five tubing plugs (two are spares) Two wheel hubcaps (actual size) Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) Five 1/4-20 x 2 inch bolts (actual size) Six
  • Weber Genesis 2 LP | Owner Manual - Page 10
    the block of wood (or other protected surface). Tap on one hubcap. Put one wheel on the axle, WEBER side toward the hubcap. Slide the axle through the frame. Add the other wheel, WEBER side out. Tap on the hubcap. Figure 1. ER WE B ER WE B Step 3 Assemble frame You will need: left
  • Weber Genesis 2 LP | Owner Manual - Page 11
    Step 4 Continue frame assembly You will need: frame assembly, wheel frame assembly, front panel, caster frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel
  • Weber Genesis 2 LP | Owner Manual - Page 12
    the frame brace. Figure 6. Burner tubes Frame brace Your Weber Gas Barbecue burner assembly has been factory assembled, pressure and flame answered NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use your barbecue. Guide screw Figure 6 Slide the cooking box to
  • Weber Genesis 2 LP | Owner Manual - Page 13
    as a unit and hook onto the frame brace. Manifold bracket Frame brace Step 9 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter. This was done to factory test the ignition system. The igniter lock nut is on the igniter. Insert the
  • Weber Genesis 2 LP | Owner Manual - Page 14
    psi). s A manual shut-off valve must be installed outdoors, immediately ahead of the quick disconnect. s An additional manual shut-off valve indoors Pipe compound should be used which is resistant to the action of natural gas when connections are made. s The outdoor connector must be firmly attached
  • Weber Genesis 2 LP | Owner Manual - Page 15
    not turn they are off, proceed to the next step. Figure 12. Step 12 Connect flexible hose to manifold You will need: the 12 foot natural gas supply hose and a 3/4 inch wrench. Thread fitting end of hose onto manifold. Figure 13 (a). Tighten with wrench. (a) Figure 12 Figure 13 15
  • Weber Genesis 2 LP | Owner Manual - Page 16
    for leaks before using your Weber Genesis Gas Barbecue. Shipping and handling may have loosened or damaged a gas fitting. ƽWARNING: Perform these retightening the fitting, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. b) Valves to manifold connections. Figure
  • Weber Genesis 2 LP | Owner Manual - Page 17
    Step 14 Install Flavorizer Bars and Cooking Grates You will need: five long Flavorizer Bars, eight short Flavorizer Bars and two cooking grates. Set the long Flavorizer Bars side to side in the lower position, then set the short Flavorizer Bars front to back in the upper position in the cooking box.
  • Weber Genesis 2 LP | Owner Manual - Page 18
    Step 16 Install the lid You will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small holes in the hinge pins. Figure 21. Hair pin cotter Hinge pin Step 17
  • Weber Genesis 2 LP | Owner Manual - Page 19
    bracket is in any way cracked or damaged, do not use swing table. Call our Customer Service Center to order a new part. ƽWARNING: The load limit for the swing table is 30 pounds. Hinge rod (a) (b) Support rod (a) Figure 23 View from rear of barbecue (c) Figure 24 Slot in frame (view from below
  • Weber Genesis 2 LP | Owner Manual - Page 20
    rack, thermometer, three tubing plugs and a hammer. Insert one end of the Weber Warm-Up Basket into the hole in the right end of the lid and the lightly with a hammer. Figure 27 (f). Figure 25 To lower table: Pull support rod up to disengage slide lock, and lower table. To raise table, lift table
  • Weber Genesis 2 LP | Owner Manual - Page 21
    hose. Order from Weber-Stephen Products Co., Customer Service Center or authorized dealer. Crossover Ignition System 1 1) Open the lid. Figure 1. 2) Make sure all burner control knobs are turned OFF. (Push each burner control knob down and turn clockwise.) 3) Turn gas supply valve on. ƽWARNING
  • Weber Genesis 2 LP | Owner Manual - Page 22
    knobs are turned OFF. (Push each burner control knob down and turn clockwise.) 3) Turn gas supply valve on. 4) Strike a match and put the flame into the matchlight hole in the front of the cooking box. 1 Manual Lighting ƽWARNING: If the burner does not light, turn the Front burner control knob to
  • Weber Genesis 2 LP | Owner Manual - Page 23
    BACK at medium). See your Weber cookbook for detailed cooking instructions. Note: The temperatures inside 5 minutes before relighting. Preheating Your Weber Genesis Gas Barbecue is an energy efficient appliance. brass bristle brush. As needed, remove from grill and wash with warm soapy water. Catch
  • Weber Genesis 2 LP | Owner Manual - Page 24
    replacement hose. Order from Weber-Stephen Products Co., Customer Service Center or authorized dealer. s Inspect the burners for correct flame pattern. Clean if necessary, following the procedures outlined in the "General Maintenance" section of this manual. s Check all gas fittings for leaks
  • Weber Genesis 2 LP | Owner Manual - Page 25
    burner ports are fully open. Figure 8 ƽCAUTION: Do not enlarge the burner ports when cleaning. Replacing Main Burners a) Your Weber Gas Barbecue must be OFF and cool. b) Turn gas OFF at source. c) Remove control panel: take off the burner control knobs. Remove the screws holding the control panel in
  • Weber Genesis 2 LP | Owner Manual - Page 26
    valve orifices. Figure 13a. Check proper assembly before fastening manifold in place. Figure 13b. (a) Valve Figure 10 f) Slide the burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 11
  • Weber Genesis 2 LP | Owner Manual - Page 27
    CAUTION: If the Spider Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. ƽCAUTION: After reinstalling the gas lines, they should be leak checked with a soap and water System still fails to light, See Section "Manual Lighting", and contact Weber-Stephen Customer Service. 27
  • Weber Genesis 2 LP | Owner Manual - Page 28
    TROUBLESHOOTING & MAINTENANCE Problem Check Burners burn with a yellow or orange flame, in Inspect Weber Spider Stopper conjunction with the smell of gas. Guards for possible obstructions. (Blockage of holes.) Cure Clean Weber Spider Stopper Guards. (See Section "Annual Maintenance".) Burner
  • Weber Genesis 2 LP | Owner Manual - Page 29
  • Weber Genesis 2 LP | Owner Manual - Page 30
    1 2 3 4 5 6 7 8 9 10 11 12 13-14 15 16 17 10,14 18 19 20 21 22 23 ® ® E BE R W E BE R W 24 25 30 26 27 28 29 31 32 30 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 50 49-53 54 55
  • Weber Genesis 2 LP | Owner Manual - Page 31
    Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South 54 Igniter wire (white) 55 Gas catcher ignition chamber 56 Hose 57 Control panel inserts (2) ƽWARNING: Use only Weber factory authorized parts. The use
  • Weber Genesis 2 LP | Owner Manual - Page 32
    problems with parts or assembly. Call our toll free number 1-800-446-1071. For quicker service, please have your owner's manual available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish your family the best in outdoor cooking enjoyment. Weber
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
W
E
B
E
R
W
E
B
E
R
98629
12/97
GENESIS
®
2000 Series
Natural Gas Barbecue
Owner’s Manual
®
Serial Number
Please use this number in registering your warranty and
any correspondence with the factory.
FOR YOUR SAFETY
Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.