Weber Genesis Gold C NG Owner Manual
Weber Genesis Gold C NG Manual
 |
View all Weber Genesis Gold C NG manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Genesis Gold C NG manual content summary:
- Weber Genesis Gold C NG | Owner Manual - Page 1
GENESIS® GOLD-C Gas Grill Owners Guide ƽ DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flames. 3. Open lid 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department. Leaking gas may cause a fire or - Weber Genesis Gold C NG | Owner Manual - Page 2
. ƽ After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before use. See instructions in this manual for correct procedures. ƽ Do not operate the Weber gas barbecue if there is a gas leak present. ƽ Do not use a flame to check for - Weber Genesis Gold C NG | Owner Manual - Page 3
this Weber Gas Grill that in accordance with the printed instructions accompanying it. Weber may require reasonable proof of service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner's manual - Weber Genesis Gold C NG | Owner Manual - Page 4
Contents Danger & Warnings A-2 Warranty A-3 General Instructions A-5 Exploded View A-6 Parts List A-10 Assembly Instructions B-1 Installing Work Surfaces and Gas Connection Guidelines C-1 Operating D-1 Lighting D-1 Manual Lighting D-2 Lighting the side burner D-3 Cooking D-4 Storage and/ - Weber Genesis Gold C NG | Owner Manual - Page 5
you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before using your Weber Gas Barbecue. Improper assembly can be dangerous. • Not for use by children. • If there are local codes that apply to portable gas grills, you will have to conform to - Weber Genesis Gold C NG | Owner Manual - Page 6
1 Genesis Gold-C NG 2 3 34 4 5 6 35 7 8 36 9 37 38 39 10 40 11 41 12 16 13 19 14 15 42 16 18 17 43 18 44 19 45 46 20 47 21 48 22 23 49 24 50 25 39 51 26 52 27 53 54 28 29 55 26 56 30 57 31 58 32 59 33 A-6 - Weber Genesis Gold C NG | Owner Manual - Page 7
40. Side burner 41. Side Burner Bracket Right side 42. Sideburner support clip 43. Side Burner Bracket Left side 44. Crossover Tube 45. Front and Back Burners 46. Center Burner 47. Manifold Hardware 48. Manifold Support Bracket 49. Igniter 50. Igniter Bracket 51. Manifold, Hose and regulator - Weber Genesis Gold C NG | Owner Manual - Page 8
-Stephen Products Co., Weber, the silhouette, and the kettle configuration are registered trademarks ® of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL, 60067-6266, U.S.A. This product is covered by one or more United States patents and patents in - Weber Genesis Gold C NG | Owner Manual - Page 9
box. Pull out bottom tray from cooking box. Remove packaging material from bottom tray, catch pan holder, catch pan, and drip pan. Remove Grill from Lower Packaging ƽ WARNING: Lifting the barbecue from the lower packaging requires at least two people. With two people: lift straight up and over - Weber Genesis Gold C NG | Owner Manual - Page 10
WE BE R WE BE R You will need: Phillips screwdriver 7/16 open-end or an adjustable wrench 1/2 inch bolts (1/4 x 20 x 1/2 inch bolts) - 4 Nylon Washers - 4 Flavorizer Bars - 5 Cooking Grates - 2 Condiment basket - 1 Bottom Shelf - 1 Slide Out Buttom Tray - 1 Left Work Surface - 1 Right Work - Weber Genesis Gold C NG | Owner Manual - Page 11
Assembly Instructions Install the slide out bottom tray You will need: the slide out bottom tray(1), catch pan holder(2), catch pan and one disposable drip pan. Slide - Weber Genesis Gold C NG | Owner Manual - Page 12
between the two frame connectors underneath the cooking box. Installing the Warm-Up™ Basket You will need: Warm-Up Basket Insert one end of the Weber Warm-Up Basket into the hole at the right side of the inside of the lid, and the other end into the slot at the - Weber Genesis Gold C NG | Owner Manual - Page 13
Installing Work Surfaces & Gas Connection Guidelines Install Left Work Surface You will need left work surface, two 1/2 inch bolts, two nylon washers and a 7/16 inch or adjustable wrench. Insert - Weber Genesis Gold C NG | Owner Manual - Page 14
psi). I A manual shut-off valve must be installed outdoors, immediately ahead of the quick disconnect. I An additional manual shut-off valve indoors Pipe compound should be used which is resistant to the action of natural gas when connections are made. I The outdoor connector must be firmly attached - Weber Genesis Gold C NG | Owner Manual - Page 15
5/8" O.D. tube. One size larger should be used for lengths greater than 50 feet. I Gas piping may be copper tubing, type K or L; polyethylene plastic tube, with fittings for leaks before using your Weber Gas Barbecue. Shipping and handling may loosen or damage a gas fitting. ƽ WARNING: Perform these - Weber Genesis Gold C NG | Owner Manual - Page 16
is a leak at connections(2),(3),(4) or(5), turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. When leak checks are complete, turn gas supply OFF at the source and rinse connections - Weber Genesis Gold C NG | Owner Manual - Page 17
to be damaged in any way, do not use the barbecue. Replace using only Weber authorized replacement hose. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. 1 1) Open the lid. 2) Make sure all burner control knobs are turned OFF - Weber Genesis Gold C NG | Owner Manual - Page 18
Manual Lighting ƽ DANGER Failure to open lid while igniting the barbecue's burners, or not waiting 5 minutes to allow the gas to control knob clockwise to the OFF position. Turn gas supply OFF at the source. 1 2 7 3 4,6 5 *The grill illustrated may have slight differences than the model purchased - Weber Genesis Gold C NG | Owner Manual - Page 19
see on a bright sunny day. ƽ WARNING: If the side burner does not light: 1) Turn OFF the side burner control valve. 2) Wait 5 minutes to let the gas clear before you try again or try to light with a match. 3 6 ƽ CAUTION: Side burner flame may be difficult to see on a bright sunny day. ƽ WARNING - Weber Genesis Gold C NG | Owner Manual - Page 20
secured in the OFF position. When the Weber Gas Barbecue is stored indoors, the gas supply MUST BE DISCONNECTED. s After a period of storage and/or nonuse, the Weber Gas Grill should be checked for gas leaks and any obstructions in the burner tubes before using. (See "Maintenance" Section.) s Check - Weber Genesis Gold C NG | Owner Manual - Page 21
. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. When leak checks are complete, turn gas supply OFF at the source and rinse connections with water. (1) (2) (3) (4) (5) Inspection and Cleaning of the Weber Spider Stopper - Weber Genesis Gold C NG | Owner Manual - Page 22
Barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown. 1) Burner tube 2) Tips occasionally flicker yellow 3) Light blue 4) Dark blue (1) (2) (3) (4) (2) (3) The Weber Spider Stopper™ Guard(1) is factory installed. It fits tightly around the - Weber Genesis Gold C NG | Owner Manual - Page 23
Replacing Main Burners 1) Your Weber Gas Barbecue must be OFF and cool. 2) Turn gas OFF at source. 3) To remove control panel: take off the burner manifold in place. (2) (1) (1) 6) Slide the burner assembly out from under the guide screw and washer(1) in the corners of the cooking box. (1) D-7 - Weber Genesis Gold C NG | Owner Manual - Page 24
ƽ CAUTION: If the Spider Stopper Guards do not fit tightly, contact the Customer Service Representative in your region using the contact information sheet provided with your manual. ƽ WARNING: After reinstalling the gas lines, they should be leak checked with a soap and water solution before using - Weber Genesis Gold C NG | Owner Manual - Page 25
Troubleshooting Problem Check Burners burn with a yellow or Inspect Weber Spider Stopper orange flame, in conjunction with Guards for possible obstructions. the smell of gas of the burner tube. Are burners problems cannot be corrected by using these methods, please contact the Customer Service - Weber Genesis Gold C NG | Owner Manual - Page 26
any troubleshooting steps, all gas controls and supply valves should be in the OFF position. Problem Side Burner does not light. Check Is gas supply Burner makes popping noise in conjunction with the smell of gas. Clean Weber Spider Stopper Guard. (See section "Annual Maintenance") Push button
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
 |
 |
barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instruc-
tions must be left with the owner and the
owner should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
±
WARNING: Do not try to light this appli-
ance without reading the “Lighting” In-
structions section of this manual
±
WARNING
Do not store or use gasoline or other
flammable liquids or vapors within 25 feet
(8m) of this appliance.
±
WARNING: Follow all leak-check proce-
dures carefully in this manual prior to
55024 1199
Natural Gas
±
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flames.
3.
Open lid
4.
If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
A064.a
B053.a
C049.a
D006.c
Owners Guide
Y
OU
MUST
READ
THIS
O
WNERS
G
UIDE
BEFORE
OPERATING
YOUR
GAS
GRILL
National
Association
PROPANE
GAS
®
W
E
B
E
R
W
E
B
E
R
W
E
B
E
R
W
E
B
E
R
G
OLD–C
G
ENESIS
®
G
OLD–C
G
ENESIS
®
Gas Grill