Home » Chevrolet Manuals » 2003 Chevrolet Astro » Manual Viewer

2003 Chevrolet Astro Owner's Manual - Page 243

2003 Chevrolet Astro Manual

Get 2003 Chevrolet Astro PDF manuals and user guides

View all 2003 Chevrolet Astro manuals

Page 243 highlights

Get the vehicle warmed up by driving about 15 miles (24 km) when outside temperatures are above 50°F (10°C). If it's colder than 50°F (IOOC), drive the vehicle in THIRD (3) until the engine temperature gage moves and then remains steady for 10 minutes. A cold fluid check can be made after the vehicle has been sitting for eight hours or more with the engine off, but this is used only as a reference. Let the engine run at idle for five minutes if outside temperatures are 50°F (1OOC) or more. If it's colder than 50°F (IOOC), you may have to idle the engine longer. Should the fluid level be low during this cold check, you must check the fluid hot before adding fluid. Checking the fluid hot will give you a more accurate reading of the fluid level. Then, without shutting off the engine, follow these steps: Checking the Fluid Level Prepare your vehicle as follows: Park your vehicle on a level place. Keep the engine running. With the parking brake applied, place the shift lever in PARK (P). With your foot on the brake pedal, move the shift lever through each gear range, pausing for about three seconds in each range. Then, position the shift lever in PARK (P). Let the engine run at idle for three minutes or more. The transmission dipstick has a red handle and is located near the center of the engine compartment behind the air cleaner. See Engine Compartment Overview on page 5-14 for more information on location. 1. Flip the handle up and then pull out the dipstick and wipe it with a clean rag or paper towel. 2. Push it back in all the way, wait three seconds and then pull it back out again. 5-26

Section	Page
Table of Contents	2
Seats and Restraint Systems	8
Front Seats	9
Manual Seats	9
Power Seat	10
Manual Lumbar	10
Reclining Seatbacks	11
Head Restraints	12
Seatback Latches	13
Rear Seats	14
Rear Seat Operation	14
Bench Seat	18
Bucket Seats	19
Safety Belts	20
Safety Belts: They Are for Everyone	20
Questions and Answers About Safety Belts	24
How to Wear Safety Belts Properly	25
Driver Position	25
Safety Belt Use During Pregnancy	33
Right Front Passenger Position	34
Center Passenger Position	34
Rear Seat Passengers	36
Rear Safety Belt Comfort Guides for Children and Small Adults	39
Safety Belt Extender	41
Child Restraints	42
Older Children	42
Infants and Young Children	45
Child Restraint Systems	51
Where to Put the Restraint	54
Top Strap	55
Top Strap Anchor Location	57
Lower Anchorages and Top Tethers for Children (LATCH System)	59
Securing a Child Restraint Designed for the LATCH System	61
Securing a Child Restraint in a Rear Outside Seat Position	61
Securing a Child Restraint in a Center Seat Position	64
Securing a Child Restraint in the Right Front Seat Position	66
Air Bag System	69
Where Are the Air Bags?	71
When Should an Air Bag Inflate?	73
What Makes an Air Bag Inflate?	74
How Does an Air Bag Restrain?	74
What Will You See After an Air Bag Inflates?	75
Servicing Your Air Bag-Equipped Vehicle	76
Adding Equipment to Your Air Bag-Equipped Vehicle	77
Restraint System Check	78
Checking Your Restraint Systems	78
Replacing Restraint System Parts After a Crash	78
Features and Controls	80
Keys	81
Remote Keyless Entry System	83
Remote Keyless Entry System Operation	84
Doors and Locks	86
Door Locks	86
Front Doors	87
Power Door Locks	87
Programmable Automatic Door Locks	88
Leaving Your Vehicle	89
Sliding Side Door	89
Rear Doors	92
Windows	95
Manual Windows	95
Power Windows	96
Sun Visors	96
Theft-Deterrent Systems	97
Passlock	97
Starting and Operating Your Vehicle	98
New Vehicle Break-In	98
Ignition Positions	98
Starting Your Engine	100
Engine Coolant Heater	101
Automatic Transmission Operation	102
All-Wheel Drive	105
Parking Brake	105
Shifting Into Park (P)	106
Shifting Out of Park (P)	108
Parking Over Things That Burn	109
Engine Exhaust	109
Running Your Engine While You Are Parked	110
Mirrors	111
Manual Rearview Mirror	111
Outside Manual Mirrors	111
Outside Power Mirrors	111
Outside Convex Mirror	112
HomeLink Transmitter	113
Programming the HomeLink Transmitter	114
Storage Areas	117
Overhead Console	118
Luggage Carrier	123
Convenience Net	124
Instrument Panel	126
Instrument Panel Overview	127
Hazard Warning Flashers	129
Other Warning Devices	130
Horn	130
Tilt Wheel	130
Turn Signal/Multifunction Lever	131
Exterior Lamps	137
Interior Lamps	140
Accessory Power Outlets	141
Ashtrays and Cigarette Lighter	142
Climate Controls	143
Climate Control System	143
Rear Heating System	144
Rear Air Conditioning System	145
Rear Climate Control System	146
Warning Lights, Gages and Indicators	148
Instrument Panel Cluster	149
Speedometer and Odometer	150
Safety Belt Reminder Light	151
Air Bag Readiness Light	151
Charging System Light	152
Voltmeter Gage	153
Brake System Warning Light	153
Anti-Lock Brake System Warning Light	154
Engine Coolant Temperature Gage	155
Malfunction Indicator Lamp	155
Oil Pressure Gage	159
Security Light	160
Service All-Wheel Drive Light	160
Tow/Haul Mode Light	161
Check Gages Warning Light	161
Fuel Gage	161
Low Fuel Warning Light	162
Audio System(s)	163
Setting the Time for Radios with the Set Button	163
Setting the Time for Radios with HR and MN Buttons	163
AM-FM Radio	164
Radio with CD	166
Rear Seat Audio (RSA) . .	171
Theft-Deterrent Feature	172
Understanding Radio Reception	175
Care of Your CDs	175
Care of Your CD Player	175
Fixed Mast Antenna	175
Driving Your Vehicle	176
Your Driving, the Road, and Your Vehicle	177
Defensive Driving	177
Drunken Driving	178
Control of a Vehicle	181
Braking	181
Steering	184
Off-Road Recovery	186
Passing	187
Loss of Control	188
Driving at Night	189
Driving in Rain and on Wet Roads	191
City Driving	194
Freeway Driving	195
Before Leaving on a Long Trip	196
Highway Hypnosis	197
Hill and Mountain Roads	197
Winter Driving	199
If You Are Stuck: In Sand, Mud, Ice or Snow	203
Towing	204
Towing Your Vehicle	204
Recreational Vehicle Towing	204
Loading Your Vehicle	204
Towing a Trailer	206
Service and Appearance Care	218
Service	220
Doing Your Own Service Work	220
Adding Equipment to the Outside of Your Vehicle	221
Fuel	222
Gasoline Octane	222
Gasoline Specifications	222
California Fuel	223
Additives	223
Fuels in Foreign Countries	224
Filling Your Tank	225
Filling a Portable Fuel Container	227
Checking Things Under the Hood	228
Hood Release	228
Engine Compartment Overview	231
Engine Oil	232
Engine Cover	237
Engine Air Cleaner/Filter	241
Automatic Transmission Fluid	242
Engine Coolant	245
Radiator Pressure Cap	247
Engine Overheating	248
Cooling System	250
Engine Fan Noise	256
Power Steering Fluid	257
Windshield Washer Fluid	258
Brakes	259
Battery	263
Jump Starting	264
All-Wheel Drive	269
Rear Axle	270
Front Axle	271
Bulb Replacement	272
Halogen Bulbs	272
Headlamps	272
Front Turn Signal Lamps	276
Taillamps	277
Replacement Bulbs	278
Windshield Wiper Blade Replacement	279
Tires	280
Inflation - Tire Pressure	281
Tire Inspection and Rotation	281
When It Is Time for New Tires	283
Buying New Tires	283
Uniform Tire Quality Grading	284
Wheel Alignment and Tire Balance	286
Wheel Replacement	286
Tire Chains	287
If a Tire Goes Flat	287
Changing a Flat Tire	288
Compact Spare Tire	299
Appearance Care	300
Cleaning the Inside of Your Vehicle	300
Care of Safety Belts	303
Weatherstrips	303
Cleaning the Outside of Your Vehicle	303
Sheet Metal Damage	305
Finish Damage	305
Underbody Maintenance	306
Chemical Paint Spotting	306
GM Vehicle Care/Appearance Materials	306
Vehicle Identification	308
Vehicle Identification Number (VIN)	308
Service Parts Identification Label	308
Electrical System	309
Add-on Electrical Equipment	309
Headlamp Wiring	309
Windshield Wiper Fuses	309
Power Windows and Other Power Options	309
Fuses and Circuit Breakers	310
Capacities and Specifications	316
Capacities and Specifications	316
Normal Maintenance Replacement Parts	318
Maintenance Schedule	320
Maintenance Schedule	321
Introduction	321
Your Vehicle and the Environment	321
Maintenance Requirements	321
How This Section is Organized	322
Part A: Scheduled Maintenance Services	323
Using Your Maintenance Schedule	323
Selecting the Right Schedule	324
Short Trip/City Scheduled Maintenance	326
Long Trip/Highway Scheduled Maintenance	337
Part B: Owner Checks and Services	345
At Each Fuel Fill	345
At Least Once a Month	345
At Least Twice a Year	345
At Least Once a Year	346
Part C: Periodic Maintenance inspections	349
Steering. Suspension and Front Drive Axle Boot and Seal Inspection	349
Exhaust System Inspection	349
Fuel System Inspection	349
Engine Cooling System Inspection	349
Throttle System Inspection	350
Transfer Case and Front Axle (All-Wheel Drive) Inspection	350
Brake System Inspection	350
Part D: Recommended Fluids and Lubricants	351
Part E: Maintenance Record	353
Customer Assistance Information	356
Customer Assistance Information	357
Customer Satisfaction Procedure	357
Online Owner Center	359
Customer Assistance for Text Telephone (TTY) Users	359
Customer Assistance Offices	359
GM Mobility Program for Persons with Disabilities	360
Roadside Assistance Program	361
Courtesy Transportation	363
Reporting Safety Defects to the United States Government	366
Reporting Safety Defects to the Canadian Government	366
Reporting Safety Defects to General Motors	366
Service Publications Ordering Information	366

Match case Limit results 1 per page

Get the vehicle warmed up

by driving about

miles

(24

km) when outside temperatures are above 50°F

(10°C).

it's colder than 50°F

(IOOC),

drive the vehicle

in THIRD

(3)

until the engine temperature gage

moves and then remains steady

for

minutes.

A cold fluid check can be made after the vehicle has

been sitting for eight hours or more with the engine

off,

but this

used only

reference. Let the engine

run at idle for five minutes

outside temperatures are

50°F

OOC) or

more.

If it's colder than 50°F (IOOC), you may have to idle the

engine longer. Should the fluid level be low during

this cold check, you

must

check the fluid hot before

adding fluid. Checking the fluid hot

will

give you a more

accurate reading of the fluid level.

Checking the Fluid Level

Prepare your vehicle as follows:

Park

your vehicle on a level place. Keep the engine

running.

With the parking brake applied, place the shift lever

PARK

(P).

With your foot on the brake pedal, move the shift

lever through each gear

range, pausing for about

three seconds in each range. Then, position the shift

lever in

PARK

(P).

Let the engine run at idle for three minutes or more.

Then,

without shutting

off

the

engine,

these

steps:

The transmission dipstick has a

red

handle

and is

located near the center of the engine

compartment

behind the air cleaner. See

Engine

Compartment

Overview on page 5-14

for

information

location.

Flip the handle up and then pull out the dipstick

and wipe it with

a clean rag or

paper

towel.

Push it back in all the

way,

wait

three

seconds

and

then pull

back out

again.

5-26