2011 Kawasaki Brute Force 750 4x4i Owners Manual

2011 Kawasaki Brute Force 750 4x4i Manual

Get 2011 Kawasaki Brute Force 750 4x4i PDF manuals and user guides View all 2011 Kawasaki Brute Force 750 4x4i manuals

2011 Kawasaki Brute Force 750 4x4i manual content summary:

  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 1
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 2
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 3
    Quick Reference Guide This Quick Reference Guide will assist you in finding the information you're looking for. GENERAL INFORMATION BREAK-IN HOW TO RIDE SAFE OPERATION MAINTENANCE AND ADJUSTMENT STORAGE TROUBLESHOOTING GUIDE j j j j j j j A Table of Contents is included after the Foreword.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 4
    not avoided, will result in death or serious injury. HOW TO AVOID THE DANGER Read all DANGERS in this manual carefully and for your safety be sure to follow their instructions. NOTICE NOTICE is used to address practices not related to personal injury. WARNING HAZARD Failure to heed WARNING. WHAT
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 5
    this manual carefully and completely before starting your new Kawasaki. It contains important safety information. Never operate an ATV without proper instruction. , the sport has the potential to cause environmental problems as well as conflicts with other people. Responsible use of your off-
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 6
    to take proper precautions. SEVERE INJURY OR DEATH can result if you do not follow these instructions: żRead this manual and all labels carefully and follow the operating procedures described. żThe Owner's Manual should be kept in the waterproof plastic bag and stored in the storage area provided
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 7
    sharply to one side. Go straight down the hill where possible. żAlways follow proper procedures for crossing the side of a hill as described in this manual. Avoid hills with excessively slippery or loose surfaces. Shift your weight to the uphill side of the ATV. Never attempt to turn the ATV around
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 8
    tached. Reduce speed and follow instructions in this manual for carrying cargo or pulling a trailer. Allow greater distance for may affect vehicle handling. Refer to the Loading Information chapter in this manual. żNever exceed the stated load capacity for an ATV. Cargo should be properly distributed
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 9
    and limitations. This manual offers many safe riding tips, but its purpose is not to provide instruction in all the trouble-free life for your ATV, give it the proper care and maintenance described in this manual. For those who would like more detailed information on their ATVs, a Service Manual
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 10
    The KVF750E and KVF750F are models with camouflage-surface-treated or paint finish and are identical to the KVF750D, the base model, in every other aspect: controls, features, and specifications. KAWASAKI HEAVY INDUSTRIES, LTD. Consumer Products & Machinery Company © 2010 Kawasaki Heavy Industries
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 11
    /4WD Shifting ...Variable Limited Slip Front Differential ...Braking ...Stopping the Engine ...Parking the ATV...Stopping the ATV in an Emergency...SAFE OPERATION ...Read the Owner's Manual...55 55 56 56 57 57 57 57 59 60 61 62 63 64 65 65 67 68 69 69 71 72 72 73 75
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 12
    Breaker...General Lubrication ...Cleaning ...Bolt and Nut Tightening ...STORAGE ...Preparation for Storage ...Removal from Storage ...TRANSPORTING THE ATV ...TROUBLESHOOTING GUIDE...YOUR WARRANTY/OWNER SATISFACTION ...ENVIRONMENTAL PROTECTION ... 135 138 138 143 145 146 146 147 149 151 152 152 154
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 13
    MAINTENANCE RECORD ...186
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 14
    12 SPECIFICATIONS SPECIFICATIONS PERFORMANCE Maximum Torque Minimum Turning Radius DIMENSIONS Overall Length Overall Width Overall Height Wheelbase Tread: Ground Clearance Curb Mass ENGINE Type Displacement Bore × Stroke Compression Ratio Starting System Carburetion System Ignition System SOHC, V-
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 15
    SPECIFICATIONS 13 Ignition Timing (Electronically advanced) Spark Plug Lubrication System Engine Oil: Grade 10°/1 100 rpm (BTDC) NGK CR7E Forced lubrication (wet sump) Kawasaki Performance 4-Stroke ATV/UTV Oil* Kawasaki Performance 4-Stroke Semi-Synthetic Oil* Kawasaki Performance 4-Stroke Full
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 16
    14 SPECIFICATIONS Front Final Gear Case Oil: Grade Kawasaki Performance 4-Stroke ATV/UTV Oil* Kawasaki Performance 4-Stroke Semi-Synthetic Oil* Kawasaki Performance 4-Stroke Full Synthetic Oil* API SG, SH, SJ, SL, or SM with JASO MA, MA1 or MA2 Capacity Rear Final Gear Case Oil: FRAME Type Castor
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 17
    SPECIFICATIONS 15 *Kawasaki Performance Oils and Lubricants have been specifically engineered for your vehicle. Consistent use of these products meets or exceeds warranty and service requirements and can help to extend the life of your Kawasaki. Specifications subject to change without notice.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 18
    16 SERIAL NUMBER LOCATIONS SERIAL NUMBER LOCATIONS The frame and engine serial numbers are used to register the vehicle. They are the only means of identifying your particular machine from others of the same model type. These serial numbers may be needed by your dealer when ordering parts. In the
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 19
    LOCATION OF LABELS 17 LOCATION OF LABELS All warning labels which are on your ATV are repeated here. Read them and understand them thoroughly. They contain information which is important for your safety and the safety of anyone else who may operate your ATV. Therefore, it is very important that all
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 20
    18 LOCATION OF LABELS 7. 8. 9. 10. 11. Front Carrier Maximum Load Rear Carrier Maximum Load Passenger Warning Tire Pressure & Maximum Loading Warning Transmission Warning
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 21
    LOCATION OF LABELS 19 12. Vehicle Emission Control Information 13. Battery Danger/Poison (On the backside)
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 22
    20 LOCATION OF LABELS (1) (2) (3)
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 23
    LOCATION OF LABELS 21 (4) (5) (for KVF750F) (6) (5) (for KVF750D) (5) (for KVF750E) (7)
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 24
    22 LOCATION OF LABELS (8) (10) (9) (11)
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 25
    LOCATION OF LABELS 23 (12) (for KVF750D) (12) (for KVF750F) (12) (for KVF750E)
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 26
    24 LOCATION OF LABELS (13)
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 27
    LOCATION OF LABELS 25 (14) (15)
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 28
    26 LOCATION OF PARTS LOCATION OF PARTS 1. 2. 3. 4. 5. 6. 7. 8. Rear Brake Lever (Parking Brake) Brake Lever Lock Variable Front Differential Control Lever Starter Button Multifunction Meter Front Brake Reservoir Selectable 2WD/4WD Shift Switch Front Brake Lever 9. 10. 11. 12. 13. 14. 15. Light/
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 29
    LOCATION OF PARTS 27 16. 17. 18. 19. 20. 21. Front Carrier Shock Absorbers (front) Front Cylinder Spark Plug Air Cleaner Battery Fuses 22. 23. 24. 25. 26. 27. Seat Latch Rear Carrier Headlights Front Final Gear Case Disc Brake Caliper Oil Filler Plug 28. 29. 30. 31. Coolant Reserve Tank Shock
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 30
    28 LOCATION OF PARTS 32. 33. 34. 35. 36. Tail/Brake Light Tool Kit Rear Cylinder Spark Plug Shift Lever Fuel Tank 37. 38. 39. 40. 41. Fuel Tank Filler Cap Belt Drive Transmission (CVT) Rear Brake Pedal Radiator Winch Installing Position
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 31
    distributed and securely attached. Reduce speed when carrying cargo or pulling a trailer. Allow greater distance for braking. Always follow the instructions provided in this section for carrying cargo or pulling a trailer. With the exception of genuine Kawasaki Parts and Accessories, Kawasaki has
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 32
    30 LOADING INFORMATION NOTE żKawasaki Parts and Accessories have been spe- cially designed for use on Kawasaki vehicles. We strongly recommend that all parts and accessories you add to your vehicle be genuine Kawasaki components. • • • Because an all terrain vehicle is sensitive to increases in
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 33
    LOADING INFORMATION 31 Poorly designed or installed items can result in an unsafe riding condition. Never ride with passengers on the carriers. This ATV is not designed for carrying passengers on the carriers. •
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 34
    32 GENERAL INFORMATION j GENERAL INFORMATION Power Outlet Connector The power outlet connector is located under the left handlebar. The ignition switch also operates the power outlet circuit and this vehicle has an accessory fuse (10A) to protect this circuit. The connector has a cap. Remove it to
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 35
    GENERAL INFORMATION 33 j Auxiliary Electrical Accessory Connector The auxiliary electrical accessory connector is located at the rear end under the tail light. NOTICE Do not connect more than a 60 W load to the auxiliary electrical accessory terminals or the battery may become discharged. Always
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 36
    34 GENERAL INFORMATION j Multifunction Meter In the meter display face are the "LCD" (Liquid Crystal Display) speedometer, coolant temperature warning symbol, FI warning symbol, clock, 4WD/2WD indicator light, fuel level gauge, and odometer/trip meter/hour meter. An "LED" (Light Emitting Diode) is
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 37
    GENERAL INFORMATION 35 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. "SET/RESET" Button Belt Check Indicator Light Neutral Indicator Light Reverse Indicator Light Oil Pressure Warning Light "4WD" Indicator Light "2WD" Indicator Light Coolant Temperature Warning Symbol FI Warning Symbol Fuel
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 38
    36 GENERAL INFORMATION Speedometer: The speedometer shows the speed of the vehicle. j Fuel Level Gauge Symbol: The fuel in the fuel tank is shown in segments. All 7 segments are displayed when the fuel tank is full. As fuel is consumed the segments go out accordingly. When the bottom segment is
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 39
    when fuel-injection -related parts should fail to function properly. If the symbol starts flashing, have your authorized Kawasaki dealer check the vehicle for the trouble. j NOTE żWhen you touch the cooling fan, be sure to disconnect the (-) cable of the battery, since the cooling
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 40
    38 GENERAL INFORMATION Clock: 2. 3. 4. 5. Push the "SET/RESET" button to advance the hours. Push the "TIME SET" button. The hour display stops flashing and the minutes display starts flashing. Push the "SET/RESET" button to advance the minutes. Push the "TIME SET" button. The minutes display stops
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 41
    GENERAL INFORMATION 39 j
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 42
    40 GENERAL INFORMATION Odometer: The odometer shows the total distance in miles that the vehicle has been ridden. The meter cannot be reset. j NOTE żThe data is maintained even if the battery is disconnected. żWhen the figures come to 99999, they turn back NOTE żThe data is maintained even if
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 43
    GENERAL INFORMATION 41 NOTE j żThe data is maintained by the back-up power if the ignition switch is turned off. żWhen the trip meter is reset while the vehicle is stopped, it starts counting as soon as the vehicle starts moving. żWhen the trip meter reaches 999.9 when the vehicle is running, it
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 44
    42 GENERAL INFORMATION 2WD/4WD Indicator Light: This ATV can be driven in either "2WD" or "4WD". When the selectable 2WD/4WD shift switch is in "4WD", the "4WD" indicator light will be lit and vice -versa. After shifting there is a momentary delay before the indicator lights change. Flashing 2WD/4WD
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 45
    GENERAL INFORMATION 43 Failure Parts and Failure Indication Patterns j A. B. C. D. Belt Check Indicator Light Neutral Indicator Light Reverse Indicator Light Oil Pressure Warning Symbol Neutral: When the transmission is in neutral, the neutral indicator light is lit. Reverse: When the
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 46
    44 GENERAL INFORMATION enough. Refer to the MAINTENANCE AND ADJUSTMENT chapter for more detailed engine oil information. Belt Check Indicator Light: This vehicle is equipped with a drive belt failure detection system. Excessive belt wear or belt damage will activate a switch in the transmission
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 47
    GENERAL INFORMATION 45 j Brake Levers and Pedal The lever on the right side of the handlebar operates the front brake. A. Brake Lever (Parking Brake) B. Brake Lever Lock The foot pedal on the right side also operates the rear brake. A. Brake Lever The lever on the left side of the handlebar
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 48
    the front or rear brakes. Apply both front and rear brakes gradually. Refer to the HOW TO RIDE and SAFE OPERATION chapters for more instructions on braking. If you begin rolling backwards: Keep weight uphill. Never apply either front or rear brakes suddenly while rolling backwards. Apply both front
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 49
    GENERAL INFORMATION 47 (For "2WD") j WARNING HAZARD Stalling, rolling backwards or improperly dismounting while climbing a hill. WHAT CAN HAPPEN Could result in ATV overturning. HOW TO AVOID THE HAZARD Use low gearing and maintain steady speed when climbing a hill. If you lose all forward speed:
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 50
    48 GENERAL INFORMATION j Brake Lever Lock (Parking Brake) If the brake lever lock is used, the rear brake lever can be used as a parking brake. To lock the brake lever, first pull in the brake lever. Then pull in the lock lever and while holding it against the brake lever, release the brake lever.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 51
    for each carrier. Cargo should be properly distributed and securely attached. Reduce speed when carrying cargo. Allow greater distance for braking. Always follow the instructions in your Owner's Manual for carrying cargo. Maximum Load Front Rear A. Front Carrier 40 kg (88 lb) 80 kg (176 lb)
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 52
    50 GENERAL INFORMATION j Fuel Tank Filling the Tank: Only use gasoline with the recommended octane rating (See page 52). Avoid filling the tank in the rain or where heavy dust is blowing so that the fuel does not get contaminated. Never fill the tank completely to the top. As the fuel expands in a
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 53
    : j A. Fuel Tank B. Filler Neck C. Top Level Fuel Type Use clean, fresh unleaded gasoline with a minimum Antiknock Index of 87. The Antiknock Index is posted on service station pumps in the U.S.A. The
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 54
    damage. Gasoline quality is important. Fuels of low quality or not meeting standard industry specifications may result in unsatisfactory performance. Operating problems that result from the use of poor quality or nonrecommended fuel may not be covered under your warranty. NOTICE Avoid using blends
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 55
    "gasohol" in the fuel system. Before storage it is recommended that you drain all fuel from the fuel tank. See the Storage section in this manual. j Ignition Switch The ignition switch is located on the right front fender. It is a 2-position, key-operated switch. The key can be removed only when
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 56
    54 GENERAL INFORMATION j Keys This ATV has a key, which is used for the ignition switch and one spare key. Included with the key is a key number, which is stamped on the key itself. Record the key number in the space provided and store the number in a safe place. A. Ignition Switch B. "ON"
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 57
    GENERAL INFORMATION 55 dealer may have the number in its records. If the key number is lost completely, you will need to replace the ignition switch and all other locks operated by that key. Contact your Kawasaki dealer to purchase additional spare keys either using your original key as a master or
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 58
    speed and power return to the reduced mode. Starter Button: Refer to the "Starting the Engine" section of the "How to Ride" chapter for starting instructions. To start the engine, push the starter button with the front or rear brake applied in any shift position. j NOTE żFor the electric starter
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 59
    GENERAL INFORMATION 57 Shift Lever This vehicle is equipped with a sub-transmission and a reverse gear. The shift lever is located at the right side of the engine and it has four positions: "H" (High), "L" (Low), "N" (Neutral), and "R" (Reverse). To shift into high range, stop the vehicle
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 60
    58 GENERAL INFORMATION j WARNING HAZARD Shifting into "H" (High) or "L" (Low) or "R" (Reverse) while moving. WHAT CAN HAPPEN Shifting the transmission while the vehicle is moving can cause abrupt changes in speed and direction resulting in loss of control and accident with severe personal injury
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 61
    GENERAL INFORMATION 59 Variable Front Differential Control Lever This vehicle is equipped with a variable limited slip differential (LSD) for the front wheels. The differential control lever is located on the left side of the handlebar. When one front wheel loses traction, it can slip reducing the
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 62
    60 GENERAL INFORMATION j Selectable 2WD/4WD Shift Switch You can select "2WD" or "4WD" to suit various riding conditions. To shift, first stop the vehicle completely, then press the electrically selectable 2WD/4WD shift switch up or down. The switch is located on the right handlebar switch housing.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 63
    GENERAL INFORMATION 61 j Throttle Lever The throttle lever is located on the right side of the handlebar. Pushing the lever forward increases engine speed. When released, spring pressure returns the lever to the rear. Always check that the throttle lever returns normally before starting the engine.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 64
    the maximum engine power. WARNING HAZARD Operating this ATV without proper instruction. WHAT CAN HAPPEN The risk of an accident is greatly increased in the course and the operating techniques described in the Owner's Manual. For more information about the training course, contact an authorized
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 65
    GENERAL INFORMATION 63 NOTICE If the throttle limiter is adjusted, verify the changes in throttle in an open, non-traffic area. Never try to adjust the limiter by racing the engine in neutral or in gear with brake on, or the engine may be damaged. j Seat To remove the seat: lift the latch lever
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 66
    64 GENERAL INFORMATION j Storage Box The storage box is located on the left side front fender. Keep this Owner's Manual and other light items in this storage box. Keep the cover securely fastened with the strap when driving the vehicle. A. Front Hooks B. Front Receivers C. Rear
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 67
    Kit The tool kit is stored under the seat. Remove the seat for the kit. The minor adjustments and replacement of parts explained in this manual can be performed with the tools in the kit. Trailer Hitch Bracket A trailer hitch bracket is fitted at the rear end of the main frame
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 68
    66 GENERAL INFORMATION j WARNING HAZARD Improperly attaching and loading a trailer. Overloading a trailer. WHAT CAN HAPPEN Can cause changes in vehicle handling which could lead to an accident. HOW TO AVOID THE HAZARD Attach a trailer to the trailer hitch bracket only. For example, attaching a
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 69
    vehicle handling which could lead to an accident. HOW TO AVOID THE HAZARD Do not operate or install winch without reading and understanding the operators manual supplied with the winch. A. Winch-installing Position
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 70
    the engine while the transmission is in neutral. żIt is important to perform the initial service after the first 10 hours (100 km, 60 mi) of operation as described in this manual and the service manual for this vehicle. See the Periodic Maintenance Chart in the MAINTENANCE AND ADJUSTMENT chapter.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 71
    . If any irregularities are found during these checks, refer to the MAINTENANCE AND ADJUSTMENT chapter, see your dealer, or refer to the Service Manual for the action required to return the vehicle to a safe operating condition. DANGER HAZARD Running the engine without ventilation. WHAT CAN HAPPEN
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 72
    70 HOW TO RIDE Fuel ...Engine Oil ...Coolant ...Tires ...Enough fuel in tank, no leaks. Oil level between "H" (High) and "L" (Low) lines, no leaks. Coolant level between level lines (when engine is cold), no leaks. Air Pressure (when cold): Front: 35 kPa (0.35 kgf/cm², 5 psi) Rear: 35 kPa (0.35 kgf/
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 73
    HOW TO RIDE 71 Starting the Engine the starter button. • Push starts. Repeat until the engine DANGER HAZARD Running the engine without ventilation. WHAT CAN HAPPEN Breathing exhaust gas leads to carbon monoxide poisoning, asphyxiation, and death. Exhaust gases contain carbon monoxide; a
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 74
    72 HOW TO RIDE Moving Off the shift lever into the "H" (High) or "L" (Low) • Move position. the parking brake. • Release Gradually increase engine speed by pushing the • throttle lever forward. Shifting Gears the vehicle completely. • Stop Move the shift lever into the "H" (High) or "L" (Low) •
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 75
    HOW TO RIDE 73 WARNING HAZARD Shifting into "H" (High) or "L" (Low) or "R" (Reverse) while moving. WHAT CAN HAPPEN Shifting the transmission while the vehicle is moving can cause abrupt changes in speed and direction resulting in loss of control and accident with severe personal injury or death.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 76
    74 HOW TO RIDE WARNING HAZARD Changing from "2WD" to "4WD" or from "4WD" to "2WD" while the ATV is moving. WHAT CAN HAPPEN The handling characteristics of this ATV differ between "2WD" and "4WD" according to riding conditions. Changing operating mode while moving can cause a sudden change in
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 77
    HOW TO RIDE 75 Variable Limited Slip Front Differential WARNING HAZARD Increasing limited slip differential (LSD) traction while turning or before entering a turn. WHAT CAN HAPPEN Pulling the front differential control lever can reduce steering response, increasing the effort to turn. An
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 78
    76 HOW TO RIDE Braking the throttle completely. • Close Under most conditions stop by pulling in the front • brake lever and pressing down the rear brake stop while riding in reverse, close the throttle • To and gradually apply the brakes. Sudden application of the rear brake or the front brake (
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 79
    HOW TO RIDE 77 (For "4WD") WARNING HAZARD Stalling, rolling backwards or improperly dismounting while climbing a hill. WHAT CAN HAPPEN Could result in ATV overturning. HOW TO AVOID THE HAZARD Use low gearing and maintain steady speed when climbing a hill. If you lose all forward speed: Keep weight
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 80
    78 HOW TO RIDE (For "2WD") WARNING HAZARD Stalling, rolling backwards or improperly dismounting while climbing a hill. WHAT CAN HAPPEN Could result in ATV overturning. HOW TO AVOID THE HAZARD Use low gearing and maintain steady speed when climbing a hill. If you lose all forward speed: Keep weight
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 81
    HOW TO RIDE 79 Parking the ATV parking inside a garage or other structure, be • If sure it is well ventilated and the vehicle is not close to any source of flame or sparks; this includes any appliance with a pilot light. • Stop the vehicle on a level surface. WARNING HAZARD Parking on a steep
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 82
    . Improper maintenance can create a dangerous situation known as throttle failure. Two of the most common causes of throttle failure are: 1. 2. An improperly serviced or clogged air cleaner may allow dirt and dust to enter the throttle body assembly and stick the throttle open. During removal of the
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 83
    ride there without the express written permission of the owner. Always try to preserve nature and the environment. Read the Owner's Manual Read and understand this Owner's Manual, and carry it with you when you ride. This is especially important for younger riders and beginners. Refer to this Owner
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 84
    to reach to put their feet on the footboards and their hands on the handlebars. Study this manual with your child to be sure he or she fully understands all of the special safety instructions. WARNING HAZARD Failure to follow the age recommendations for this ATV. Failure to supervise children 16
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 85
    are designed for off-road use only. WARNING HAZARD Operating this ATV without proper instruction. WHAT CAN HAPPEN The risk of an accident is greatly increased if the and the operating techniques described in the Owner's Manual. For more information about the training course, contact an authorized ATV
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 86
    84 SAFE OPERATION Off-Road Use Only This vehicle is designed for off-road use only. Operation on public streets, roads, and highways is not recommended and is not safe. ATV tires are not designed to operate on paved or concrete surfaces. The tires will not slip as necessary which may seriously
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 87
    SAFE OPERATION 85 Dress Properly Always wear an approved helmet, eye protection, and protective clothing. The proper clothing can make riding more comfortable and reduce the chance of injury If you take a spill. Long pants will also protect your legs from the hot exhaust system. j
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 88
    86 SAFE OPERATION WARNING HAZARD Operating this ATV without wearing an approved motorcycle helmet, eye protection and protective clothing. WHAT CAN HAPPEN Operating without an approved motorcycle helmet increases your chances of a severe head injury or death in the event of an accident. Operating
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 89
    SAFE OPERATION 87 WARNING HAZARD Carrying a passenger on this ATV. WHAT CAN HAPPEN Passengers affect balance and steering and increase risk of losing control. Carrying a passenger could cause an accident, resulting in harm to you and/or your passenger. HOW TO AVOID THE HAZARD Never carry a
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 90
    88 SAFE OPERATION WARNING HAZARD Attempting wheelies, stunts. jumps, and other Never Drink and Drive Alcohol and drugs impair your judgement and slow your reactions. Even drugs prescribed by a physician can be dangerous. Check with your doctor. WHAT CAN HAPPEN Increases the chance of an accident,
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 91
    SAFE OPERATION 89 Keep Your Feet on the Footboards and Hands on the Handlebars Always ride with your feet on the footboards. If your feet touch the ground while you are moving, you could be injured. It is possible to have the rear wheel run over your foot. If you have a lot of motorcycle experience
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 92
    90 SAFE OPERATION Before Starting the Engine Three "musts" before starting the engine are: 1) Set the parking brake, 2) Put the transmission in neutral, Use the Parking Brake Always apply the parking brake before getting off your vehicle. NOTE NOTICE The brake light goes on whenever you apply
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 93
    affect the handling of your ATV. See the Loading Information chapter of this manual for more detailed information. Kawasaki does not recommend that you modify your ATV ATV and should be installed and used according to instructions. If you have questions, consult an authorized Kawasaki ATV dealer. j
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 94
    92 SAFE OPERATION Loading Your ATV Never ride with passengers on the carriers. This vehicle is not designed for carrying passengers on the carriers. Make sure all cargo is securely attached. Don't carry heavy or bulky items that exceed the cargo maximum load capacity or that may interfere with your
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 95
    shock absorber spring force. Refer to the Suspension section in MAINTENANCE AND ADJUSTMENT chapter. Also refer to the instructions in the Loading Information chapter of this manual. Overloading this ATV or carrying or towing cargo improperly will adversely affect vehicle handling and could cause an
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 96
    and securely attached. Reduce speed when carrying cargo or pulling a trailer. Allow greater distance for braking. Always follow the instructions in your Owner's Manual for carrying cargo or pulling a trailer. Perform the Daily Safety Checks Refer to the Daily Safety Checks section for a list
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 97
    to make sure the ATV is in safe operating condition. Always follow the inspection and maintenance procedures and schedules described in the Owner's Manual. Tire Air Pressure This vehicle is equipped with low pressure tires. Tire inflation and type can affect the vehicle's handling characteristics
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 98
    an accident. HOW TO AVOID THE HAZARD Always use the size and type tires specified in the Owner's Manual for this vehicle. Always maintain proper tire pressure as described in the Owner's Manual. Riding Terrain Before riding in a new area be sure to check for hidden obstacles or hazards. Keep your
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 99
    ride over large obstacles, such as large rocks or fallen trees. When you go over obstacles, always follow proper procedures as described in the Owner's Manual. j
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 100
    98 SAFE OPERATION WARNING HAZARD Failure to use extra care when operating on excessively rough, slippery or loose terrain. WHAT CAN HAPPEN Could cause loss of traction or vehicle control, which could result in an accident, including an overturn. HOW TO AVOID THE HAZARD Do not operate on excessively
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 101
    SAFE OPERATION 99 Riding in Reverse Start the engine following the procedure in the "Starting the Engine" section. Before shifting into reverse, make certain that the vehicle is completely stopped, and then move the shift lever into the "R" (Reverse) position. Refer to the "Shift Lever" section.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 102
    100 SAFE OPERATION WARNING HAZARD Inattentive operation in "R" (Reverse). Backing up without looking where you are going. WHAT CAN HAPPEN Inattentive operation in "R" (Reverse) could cause you to hit a person or obstacle behind you, resulting in severe personal injury or death. HOW TO AVOID THE
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 103
    SAFE OPERATION 101 NOTICE Shifting from "2WD" to "4WD" range when the vehicle is in motion could cause front drive train damage. WARNING HAZARD Increasing limited slip differential (LSD) traction while turning or before entering a turn. WHAT CAN HAPPEN Pulling the variable front differential
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 104
    102 SAFE OPERATION Turning the Vehicle The new rider must learn this turning technique to make turns smoothly and quickly. Slide forward on the seat, and turn the handlebar in the direction of the turn. Lean your body to the inside of the turn while shifting your body weight onto the footboard on
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 105
    SAFE OPERATION 103 WARNING HAZARD Removing hands from handlebars or feet from footboards during operation. WHAT CAN HAPPEN Removing even one hand or foot can reduce your ability to control the ATV or could cause you to lose your balance and fall off of the ATV. If you remove a foot from a footboard
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 106
    loss of control or cause ATV to overturn. HOW TO AVOID THE HAZARD Always follow proper procedures for climbing hills as described in the Owner's Manual. Always check the terrain carefully before you start up any hill. Never climb hills with excessively slippery or loose surfaces. Shift your weight
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 107
    TO AVOID THE HAZARD Never attempt to turn the ATV around on any hill until you have mastered the turning technique as described in this manual on level ground. Be very careful when turning on any hill. This ATV is equipped with the electrically selectable 2WD/4WD. When driving in "4WD
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 108
    parking brake. Dismount on uphill side or to a side if pointed straight uphill. Turn the ATV around and remount, following the procedure described in this manual.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 109
    parking brake. Dismount on uphill side or to a side if pointed straight uphill. Turn the ATV around and remount, following the procedure described in this manual.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 110
    108 SAFE OPERATION Antenna Flag In hilly country, use an antenna flag so others can see you coming from the other side of a hill or sand dune. Take extra care when approaching blind hill tops and corners. Traversing Hillsides When riding across the side of a hill, keep your body weight toward the
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 111
    HAZARD Avoid crossing the side of a steep hill if possible. When crossing the side of a hill: Always follow proper procedures as described in this manual. Avoid hills with excessively slippery or loose surfaces. Shift your weight to the uphill side of the ATV. Descending Hills Slow down or stop at
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 112
    loss of control or cause ATV to overturn. HOW TO AVOID THE HAZARD Always follow proper procedures for going down hills as described in this manual. Note: a special technique is required when braking as you go down a hill. Always check the terrain carefully before you start down any hill. Shift your
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 113
    SAFE OPERATION 111 Normally you should descend straight down a hill, since riding at an angle could cause the vehicle to lean to one side and possibly tip over. Select low gearing before beginning your descent. Sit back on the seat and brace yourself by straightening your arms. Hold your speed down
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 114
    112 SAFE OPERATION Sliding and Skidding On slippery or loose surfaces, special care is required. Sliding may be hazardous because the wheels may suddenly regain traction and cause the vehicle to tip or overturn and have an accident. Therefore, never ride "over your head" when you are unprepared for
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 115
    SAFE OPERATION 113 żDon't ride on public streets, roads, or highways. Riding in Water Choose a location to enter and exit the water where the banks are not too steep or slippery. Check the water before entering for rocks, holes or other obstacles which may cause you to overturn or become stuck or
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 116
    114 SAFE OPERATION WARNING HAZARD Operating this ATV through deep or fast flowing water. WHAT CAN HAPPEN Tires may float, causing loss of traction and loss of control, which could lead to an accident. HOW TO AVOID THE HAZARD Never operate this ATV in fast flowing water or in water deeper than the
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 117
    SAFE OPERATION 115 Wash the vehicle in fresh water if it is exposed to salt water or operated in muddy conditions. Wet brakes provide little or no efficiency and could lead to an accident and injury. After operation in water, always apply the brakes long enough for the friction to dry the pads. Also
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 118
    116 MAINTENANCE AND ADJUSTMENT MAINTENANCE AND ADJUSTMENT The maintenance and adjustments outlined in this chapter must be carried out in accordance with the Periodic Maintenance Chart to keep the vehicle in good running condition. The initial maintenance is vitally important and must not be
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 119
    make sure that the recommended maintenance is carried out according to the instructions in this Owner's Manual at your own expense. You should keep a maintenance record for Owner's Manual carefully and keep it valid by complying with the owner's obligations it contains. To obtain warranty service,
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 120
    118 MAINTENANCE AND ADJUSTMENT TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) the removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement, of any device or element of design
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 121
    system is activated, return the vehicle immediately to an authorized Kawasaki dealer for drive belt inspection and adjustment or replacement. FREQUENCY First Service Regular Service Every 90 days of vehicle use, 1 700 km (1 100 mi), or when Every Belt indicator year of light turns on use (100
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 122
    mi) use of use Every year of use j Drive belt failure detection system function-inspect* Engine brake control lever-inspect * Air cleaner-service* Throttle lever play-inspect Valve clearance-inspect* Idle speed-inspect Engine oil-change* Oil filter-replace* Spark plug-clean and gap Spark arrester
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 123
    MAINTENANCE AND ADJUSTMENT 121 FREQUENCY First Service Regular Service Every 90 days of vehicle use, 1 700 km (1 Every Every10 30 days 100 mi), or days or Every when Belt or 600 200 km year
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 124
    122 MAINTENANCE AND ADJUSTMENT FREQUENCY First Service Regular Service Every 90 days of vehicle use, 1 700 km (1 100 mi), or Every when Belt year of indicator light use turns on (100 hours of use)
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 125
    MAINTENANCE AND ADJUSTMENT 123 Engine Oil In order for the engine and transmission to function properly, maintain the engine oil at the proper level, and change the oil and replace the oil filter in accordance with the Periodic Maintenance Chart. Not only do dirt and metal particles collect in the
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 126
    124 MAINTENANCE AND ADJUSTMENT the plug and check the oil level. The oil • Unscrew level should be between the "H" (High) and "L" (Low) lines on the dipstick. WARNING HAZARD Engine or transmission seizure. WHAT CAN HAPPEN Can lock the front and rear wheels (For "2WD": rear wheels) causing an
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 127
    MAINTENANCE AND ADJUSTMENT 125 the oil filter is to be replaced, remove the oil filter • If cartridge and replace it with a new one. j A. Drain Plug the oil completely drain with the vehicle on • Let level ground. A. Cartridge WARNING HAZARD Improper disposal of used motor oil. WHAT CAN HAPPEN
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 128
    126 MAINTENANCE AND ADJUSTMENT Engine Oil Grade: Kawasaki Performance 4-Stroke ATV/UTV Oil* Kawasaki Performance 4-Stroke Semi-Synthetic Oil* Kawasaki Performance 4-Stroke Full Synthetic Oil* API SG, SH, SJ, SL, or SM with JASO MA, MA1 or MA2 Viscosity: Capacity: A. Gasket j the engine oil drain
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 129
    . *Kawasaki Performance Oils and Lubricants have been specifically engineered for your vehicle. Consistent use of these products meets or exceeds warranty and service requirements and can help to extend the life of your Kawasaki. HOW TO AVOID THE HAZARD Do not operate this vehicle with insufficient
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 130
    128 MAINTENANCE AND ADJUSTMENT Oil Level Inspection the vehicle level front-to-rear and side-to • With -side, remove the filler caps from the front and rear final gear cases. j A. Rear Final Gear Case B. Filler Cap C. Rear Suspension A. Front Final Gear Case B. Filler Cap C. Front Axle Shaft
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 131
    MAINTENANCE AND ADJUSTMENT 129 j A. Front Final Gear Case B. Filler Opening C. Bottom Thread A. Rear Final Gear Case B. Filler Opening C. Bottom Thread • Install each filler cap. NOTE żFront and rear final gear cases use different types of oils. Use the specified type and brand of oil in each
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 132
    130 MAINTENANCE AND ADJUSTMENT the vehicle level, place an oil pan beneath • With each gear case. (Rear Final Gear Case) To remove the drain plug, first remove the rear guard under the plug by releasing fitting bolts. • (Front Final Gear Case) Remove the filler cap and drain plug. j A. Drain
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 133
    MAINTENANCE AND ADJUSTMENT 131 the oil has completely drained out, install the • After drain plugs and gaskets. Replace damaged gaskets with new ones. Tightening Torque Front Final Gear 15 N·m (1.5 kgf·m, 11.0 ft·lb) Case Rear Final Gear Case 13 N·m (1.3 kgf·m, 9.6 ft·lb) WARNING HAZARD Getting
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 134
    . *Kawasaki Performance Oils and Lubricants have been specifically engineered for your vehicle. Consistent use of these products meets or exceeds warranty and service requirements and can help to extend the life of your Kawasaki. j Rear Final Gear Case Oil Oil Capacity 0.72 L (0.76 US qt
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 135
    MAINTENANCE AND ADJUSTMENT 133 Cooling System Radiator and Cooling Fan: Check and clean the screen and radiator fins for obstruction by insects or mud in accordance with the Periodic Maintenance Chart. In dusty areas, the radiator should be cleaned more frequently than the recommended interval.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 136
    134 MAINTENANCE AND ADJUSTMENT Coolant: Coolant absorbs heat from the engine and transfers it to the air at the radiator. If the coolant level becomes low, the engine overheats and may suffer damage. Check the coolant level each day before operating the vehicle, and replenish coolant if the level is
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 137
    MAINTENANCE AND ADJUSTMENT 135 NOTE żIn an emergency you can add water alone to the Spark Plug The standard spark plug is shown in the table. The spark plugs should be taken out in accordance with the Periodic Maintenance Chart for cleaning, inspection, and resetting of the plug gap. coolant
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 138
    136 MAINTENANCE AND ADJUSTMENT Spark Plug Removal Front Cylinder Carefully pull the spark plug cap from the spark plug. • j Spark Plug Standard Plug Plug Gap Tightening Torque NGK CR7E 0.7 ~ 0.8 mm (0.028 ~ 0.032 in.) 13 N·m (1.3 kgf·m, 9.4 ft·lb) A. Spark Plug Cap B. Front Cylinder C. Exhaust
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 139
    MAINTENANCE AND ADJUSTMENT 137 WARNING HAZARD Hot exhaust pipe. WHAT CAN HAPPEN Can burn your hands. HOW TO AVOID THE HAZARD Check the exhaust pipe first and, if hot, wait until it gets cold. Rear Cylinder Rear cylinder plug is located behind the air duct of the belt drive transmission. We suggest
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 140
    and stick the throttle open. This could cause an accident. HOW TO AVOID THE HAZARD Clean the air cleaner regularly and according to the instructions in this section. j NOTICE A clogged air cleaner may allow dirt and dust to enter the engine causing excessive wear and possibly engine damage. The
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 141
    MAINTENANCE AND ADJUSTMENT 139 Element Cleaning up the snaps and remove the air cleaner hous• Pull ing cap. j A. B. C. D. A. Air Cleaner Housing Cap B. Snaps Air Filter Element Air Cleaner Housing Screw Element Frame the screw and pull out the element and • Remove element frame from the air
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 142
    140 MAINTENANCE AND ADJUSTMENT WARNING HAZARD Dirt or dust allowed into the throttle body. WHAT CAN HAPPEN Can cause the throttle to stick open. This could cause an accident. HOW TO AVOID THE HAZARD Be sure to cover the air cleaner opening to the throttle body after removing the element. Clean the
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 143
    MAINTENANCE AND ADJUSTMENT 141 WARNING HAZARD Cleaning the air cleaner element with gasoline or low flash-point solvent. WHAT CAN HAPPEN Gasoline or low flash-point solvents are extremely flammable and can be explosive under certain conditions. A fire or explosion can cause severe injury or death.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 144
    142 MAINTENANCE AND ADJUSTMENT then wrap it in a clean rag and squeeze it as dry as possible. Be careful not to tear the element. Remove the vinyl from the intake tract. Install the element in the air cleaner housing to avoid the edges of the element from turning over. Clamp the air cleaner housing
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 145
    ADJUSTMENT 143 Spark Arrester Cleaning Spark Arrester This vehicle is equipped with a spark arrester approved for off-road use by the U.S. Forest Service. It must be properly maintained to ensure its efficiency. In accordance with the Periodic Maintenance Chart, clean the spark arrester. HAZARD
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 146
    144 MAINTENANCE AND ADJUSTMENT an open area away from combustible materials, • In start the engine with the transmission in neutral. DANGER HAZARD Running the engine without ventilation. WHAT CAN HAPPEN Breathing exhaust gas leads to carbon monoxide poisoning, asphyxiation, and death. Exhaust gases
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 147
    MAINTENANCE AND ADJUSTMENT 145 Throttle Cable There must be free play in the throttle mechanism. Measure the distance the throttle lever moves before the engine begins to pick up speed. Free play should be 2 ~ 3 mm (0.08 ~ 0.12 in.). j A. Adjuster B. Locknut If the free play cannot be set by
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 148
    146 MAINTENANCE AND ADJUSTMENT Idle Adjustment Idle adjustment is controlled by the ECU and cannot be adjusted. If the idle speed is unstable or out of specification, have your authorized Kawasaki dealer inspect the fuel injection system. Specified Idle Speed: 1 100 ±50 rpm Fuel Tank Vent The fuel
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 149
    MAINTENANCE AND ADJUSTMENT 147 Variable Differential Control Lever By pulling the control lever toward the handlebar, the driving force of the front wheels equalizes providing more traction. If the differential control lever has excessive play, adjust the differential control cable. Inspection
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 150
    148 MAINTENANCE AND ADJUSTMENT j A. Handlebar Cover B. Screws A. Differential Control Cable B. Cable Locknut C. Adjuster the locknut at the middle of the differential • Loosen control cable. the adjuster until the cable has the proper • Turn amount of play. • Tighten the locknut after adjustment.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 151
    MAINTENANCE AND ADJUSTMENT 149 Belt Drive Transmission (CVT) The vehicle is equipped with a belt-driven Continuously Variable Transmission (CVT). This automatic drive system, although simple to operate, does require periodic inspection since the drive belt wears with normal use. Inspection should
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 152
    150 MAINTENANCE AND ADJUSTMENT Causes of accelerated Belt Wear Avoid these hard usage conditions to obtain maximum belt life and prevent accelerated belt wear and deterioration. Operating the vehicle in high range while climbing hills, carrying heavy loads, pulling a trailer or sustained low-speed
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 153
    MAINTENANCE AND ADJUSTMENT 151 High Altitude Use The original belt drive transmission settings for this vehicle are best for sea level use. When the vehicle is used at high altitude the engine performance will decrease. This is why readjustment of both weights and spring preload of transmission are
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 154
    152 MAINTENANCE AND ADJUSTMENT Brakes Front Brake: Disc and brake pad wear is automatically compensated for and has no effect on the brake lever action. There are no parts that require adjustment on the front brake. WARNING HAZARD Air in brake line. WHAT CAN HAPPEN Can make the brake feel mushy or
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 155
    MAINTENANCE AND ADJUSTMENT 153 WARNING HAZARD Contaminated brake fluid. WHAT CAN HAPPEN Can reduce braking performance or cause brake failure, resulting in an accident. HOW TO AVOID THE HAZARD Do not use brake fluid from a container that has been left open or that has been unsealed for a long time.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 156
    154 MAINTENANCE AND ADJUSTMENT Brake Pedal Position Adjustment adjust the pedal position, loosen the locknut, • To turn the adjusting bolt, and make the bolt length 4 ∼ 6 mm (0.16 ∼ 0.24 in.), and then tighten the locknut. Now adjust the brake pedal free play. j A. Upper Level Line Fluid Change
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 157
    MAINTENANCE AND ADJUSTMENT 155 WARNING HAZARD Incorrect adjustment of the brake pedal and/or brake lever free play. WHAT CAN HAPPEN Can cause brake damage or malfunction and result in an accident. HOW TO AVOID THE HAZARD Always maintain proper pedal and/or lever free play. A. Brake Lever Adjuster
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 158
    156 MAINTENANCE AND ADJUSTMENT Brake Light Switch Only the switch at the rear brake pedal can be adjusted. When the brake pedal is depressed, the brake light goes on. The brake light switch should be inspected in accordance with the Periodic Maintenance Chart. The brake light switches of the front
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 159
    MAINTENANCE AND ADJUSTMENT 157 the brake light does not illuminate, check the • If bulb and, if necessary, adjust the brake light switch. Adjustment To adjust the brake light switch (located near the • brake pedal), move the switch forward or rearward by turning the adjusting nut. NOTICE To avoid
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 160
    vehicle and possibly result in a loss of control. żInstallation of tubeless tires on rims requires compressed air and is normally recommended as a dealer service operation. However, a tube can be inserted into the tire by the operator as an emergency repair. j Maximum Tire Air Pressure for Seating
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 161
    an accident. HOW TO AVOID THE HAZARD Always use the size and type tires specified in the Owner's Manual for this vehicle. Always maintain proper tire pressure as described in this Owner's Manual. A. Tire Depth Gauge j Minimum Tread Depth Front Tire 3 mm (0.12 in.) Rear Tire 4 mm (0.16 in.) inspect
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 162
    mounting bolts. Wheel nut tightening is a two-step process. Follow these instructions carefully. Install the wheel onto the hub, make sure it is seated żIf a torque wrench is not available, this item should be serviced by a Kawasaki Dealer. Front wheel A. Nut B. Washer Rear wheel A. Nut B. Plate
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 163
    knuckles (2 pieces), propeller shaft (3 pieces), and rear axles (4 pieces) for cracks, holes, damage or deterioration. If there is any indication of these troubles, have the joint boot replaced by an authorized Kawasaki dealer. To inspect the boots at the engine, remove the left engine cover
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 164
    162 MAINTENANCE AND ADJUSTMENT j A. Tie Rod B. Joint Boots A. Rear Propeller Shaft B. Joint Boot A. Front Propeller Shaft B. Joint Boots A. Rear Axles B. Joint Boots
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 165
    MAINTENANCE AND ADJUSTMENT 163 Suspension Shock Absorber Spring Force Adjustment The spring adjusting sleeves on the front and rear shock absorbers have 5 positions so that the springs can be adjusted for different riding and loading conditions. j A. Adjusting Sleeve B. Turn here with a hook
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 166
    164 MAINTENANCE AND ADJUSTMENT Spring Action Position 1 2 3 4 5 Spring Force | | | Ļ Stronger Setting Load Soft Ĺ | Ļ Hard Light Ĺ | Ļ Heavy Surface Good Ĺ | Ļ Bad Headlight Beam Speed Low Ĺ | Ļ High • The headlight beams can be adjusted vertically. Turn the adjusting screw on each headlight rim
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 167
    a sealed type, and the sealing strip should not be removed at any time after the specified electrolyte has been installed in the battery for initial service. It is not necessary to check the battery electrolyte level or add distilled water. However, in order to maximize battery life and ensure that
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 168
    166 MAINTENANCE AND ADJUSTMENT Current Drain (Y50-N18L-A) Days from 100% DischargCharged to 50% ing Ampere Discharged 7 mA 10 mA 15 mA 20 mA 30 mA 60 Days 42 Days 28 Days 21 Days 14 Days Days from 100 % Charged to 100 % Discharged 119 Days 83 Days 56 Days 42 Days 28 Days Battery Maintenance It is
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 169
    żIf you charge the sealed battery, never fail to observe the instructions shown on the label on the battery. WARNING HAZARD Handling battery parts that contain lead and lead compounds. WHAT CAN HAPPEN Could cause health problem. HOW TO AVOID THE HAZARD Wash hands after handling battery. the
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 170
    168 MAINTENANCE AND ADJUSTMENT connect the red cable with protective cap • Securely to the (+) terminal, and then securely connect the Fuse The main fuse and the fuse for the POWER OUTLET are located under the seat, and the spare fuses next to them. If the electrical systems do not function,
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 171
    MAINTENANCE AND ADJUSTMENT 169 j A. Main Fuse (30A) B. E/G BRK Control Fuse (10A) C. ACC Fuse (10A) D. Fuel Pump Fuse (10A) E. Spare Fuses F. Breaker for Radiator Fan
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 172
    170 MAINTENANCE AND ADJUSTMENT NOTE Breaker The breaker for the radiator fan is located under the seat near the fuse case. If the fan does not function, inspect the breaker. In order to reset the breaker, push the button at the side of the breaker case. Before resetting, however, check that the
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 173
    MAINTENANCE AND ADJUSTMENT 171 NOTE General Lubrication Lubricate the points shown below, with either motor oil or regular grease, in accordance with the Periodic Maintenance Chart or whenever the vehicle has been operated under wet or rainy conditions, and especially after using a high-pressure
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 174
    172 MAINTENANCE AND ADJUSTMENT Cleaning For the prolonged life of your vehicle, wash it down immediately after it has been splashed with seawater or exposed to the sea breeze, or operated on rainy days, rough terrain, or in dusty areas. bearings and other components causing eventual failure from
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 175
    173 Bolt and Nut Tightening Every day before riding, check the tightness of the nuts and bolts listed here. Please refer to the Service Manual or ask your authorized dealer for the torque values. j 1. 2. 3. 4. Front Carrier Mounting Bolts Brake Lever Pivot Nut Brake Lever Holder Screws Variable
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 176
    174 MAINTENANCE AND ADJUSTMENT j 13. Throttle Case Screws 14. Brake Master Cylinder Clamp Bolts 15. Brake Lever Pivot Nut
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 177
    STORAGE 175 STORAGE Preparation for Storage • Empty the fuel from the fuel tank. WARNING HAZARD Draining the fuel system without following proper precautions. WHAT CAN HAPPEN Gasoline is extremely flammable and can be explosive under certain conditions. A fire or explosion can cause severe injury
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 178
    176 STORAGE WARNING HAZARD Improper disposal of gasoline. WHAT CAN HAPPEN Gasoline is a toxic substance, which can pollute the environment. HOW TO AVOID THE HAZARD Contact your local authorities for approved disposal methods and follow those methods at all times. the spark plug and spray fogging
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 179
    STORAGE 177 NOTICE Keep the battery well charged during cold weather so that the electrolyte does not freeze and crack open the battery. The more discharged a battery becomes, the more easily it freezes. a plastic bag over the muffler to prevent mois• Tie ture from entering. a cover over the
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 180
    178 TRANSPORTING THE ATV TRANSPORTING THE ATV Note the following points for transporting the vehicle. Check that the vent hoses for the fuel tank are properly routed. • WARNING HAZARD Transporting this ATV tipped up on its rear end. WHAT CAN HAPPEN Can cause gasoline to leak from the fuel tank
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 181
    TROUBLESHOOTING GUIDE 179 TROUBLESHOOTING GUIDE Starter Motor Not Rotating Engine stop switch "OFF" Fuse failed Battery cables do not make good electrical contact with battery terminals. Battery discharged Engine Cranks,
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 182
    180 TROUBLESHOOTING GUIDE belt slipping • Drive Water in belt drive torque converter housing • Drive belt failure switch activated • Kawasaki Engine Brake Control System and selectable 2WD/4WD system
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 183
    Am I Responsible For? You are responsible for maintaining your vehicle according to the maintenance schedule shown in this owner's manual. You are responsible for notifying your dealer immediately if there is a problem, and you, as the owner, will need to authorize the dealer to inspect the unit.
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 184
    , be sure to record your service in the Maintenance Record section of this Owner's Manual. Keep all receipts for the service and/or items necessary to perform vehicle if there is a failure, investigating the cause of the problem, and getting any needed authorization from Kawasaki if the repair is
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 185
    YOUR WARRANTY/OWNER SATISFACTION 183 How Do I Get Warranty Service? If there is a problem with your vehicle within the limited warranty period, you will need to schedule a service appointment and provide any maintenance records to an authorized Kawasaki dealer for inspection and diagnosis. You can
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 186
    ? This owner's manual should answer most of your questions about your Kawasaki. Your Kawasaki dealer should either be able to answer any other questions you might have immediately or be able to find the answer for you. Please send your correspondence to:. Consumer Services Kawasaki Motors Corp
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 187
    ENVIRONMENTAL PROTECTION 185 ENVIRONMENTAL PROTECTION To protect our environment, properly discard used tire, engine oil, or other vehicle components that you might dispose of in the future. Consult your authorized Kawasaki dealer or local environmental waste agency for their proper disposal
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 188
    186 MAINTENANCE RECORD MAINTENANCE RECORD Owner Name...Address ...Phone Number ...Engine Number ...Vehicle Number...Key Code ...Selling Dealer Name ...Address ...Phone Number ...Warranty Start Date ...Note: Keep this information and a spare key in a secure location. Date Traveled Distance
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 189
    MAINTENANCE RECORD 187 Date Traveled Distance Maintenance Performed Dealer Name Dealer Address
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 190
    188 MAINTENANCE RECORD Date Traveled Distance Maintenance Performed Dealer Name Dealer Address
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 191
    MAINTENANCE RECORD 189 Date Traveled Distance Maintenance Performed Dealer Name Dealer Address
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 192
    190 MAINTENANCE RECORD Date Traveled Distance Maintenance Performed Dealer Name Dealer Address
  • 2011 Kawasaki Brute Force 750 4x4i | Owners Manual - Page 193
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
  • 99
  • 100
  • 101
  • 102
  • 103
  • 104
  • 105
  • 106
  • 107
  • 108
  • 109
  • 110
  • 111
  • 112
  • 113
  • 114
  • 115
  • 116
  • 117
  • 118
  • 119
  • 120
  • 121
  • 122
  • 123
  • 124
  • 125
  • 126
  • 127
  • 128
  • 129
  • 130
  • 131
  • 132
  • 133
  • 134
  • 135
  • 136
  • 137
  • 138
  • 139
  • 140
  • 141
  • 142
  • 143
  • 144
  • 145
  • 146
  • 147
  • 148
  • 149
  • 150
  • 151
  • 152
  • 153
  • 154
  • 155
  • 156
  • 157
  • 158
  • 159
  • 160
  • 161
  • 162
  • 163
  • 164
  • 165
  • 166
  • 167
  • 168
  • 169
  • 170
  • 171
  • 172
  • 173
  • 174
  • 175
  • 176
  • 177
  • 178
  • 179
  • 180
  • 181
  • 182
  • 183
  • 184
  • 185
  • 186
  • 187
  • 188
  • 189
  • 190
  • 191
  • 192
  • 193