2014 Polaris Ranger 570 EPS Owners Manual - Page 61
2014 Polaris Ranger 570 EPS Manual
Page 61 highlights
MAINTENANCE Periodic Maintenance Chart Item Cooling system (if applicable) Ź Oil lines, fasteners Ź Engine oil and filter change D E Front Gearcase oil (if equipped) Middle Gearcase oil (if equipped) Rear gearcase oil (if equipped) Transmission oil Fuel system (whichever comes first) Hours Calendar Miles (Km) 50 H 6M Inspect coolant strength seasonally; pressure test system yearly 50 H 6M Inspect for leaks and loose fittings 100 H 6M 1000 (1600) Change oil and filter; (perform a breakin oil change at one month) 100 H 6M Inspect level; change yearly 100 H 6M Inspect level; change yearly 100 H 6M Inspect level; change yearly 100 H 12 M 1000 (1600) Change fluid 100 H 12 M 1000 (1600) Check for leaks at tank cap, lines, pump, throttle body; replace lines every 2 years 100 H 12 M Inspect; clean external surfaces 100 H 12 M Inspect for leaks 100 H 12 M Inspect 100 H 12 M Inspect 100 H 12 M 1000 (1600) Inspect; replace as needed 100 H 100 H 100 H 100 H 200 H 300 H 500 H 12 M 12 M 12 M 12 M 24 M 36 M Inspect Inspect for wear, routing, security; apply dielectric grease to connectors subjected to water, mud, etc. 1000 (1600) Inspect; clean; replace worn parts 5000 (8000) Inspect; replace as needed Change every two years Clean out Inspect; adjust as needed Adjust as needed Inspect periodically; adjust when parts are replaced Inspect daily; adjust as needed Adjust as needed - Maintenance Interval Remarks Ź Radiator (if applicable) Ź Cooling Hoses Ź Engine mounts Exhaust muffler/pipe Ź Spark plug E D Ignition timing Ź Wiring D Clutches Ź D Front wheel bearings D Brake fluid Spark arrester Valve clearance Idle speed D Toe adjustment D Auxiliary brake (if equipped) Ź Headlight aim Lubrication Recommendations Check and lubricate all components at the intervals outlined in the Periodic Maintenance Chart beginning on page 57, or more often under severe use, such as wet or dusty conditions. Items not listed in the chart should be lubricated at the general lubrication interval. Item Engine Oil Brake Fluid Main Gearcase Oil (Transmission) Front Gearcase Oil Front Prop Shaft Yoke Lube PS-4 5W-50 4-Cycle Oil DOT 4 Brake Fluid See page 60. See page 74. Method AGL Gearcase Lubricant & Transmission See page 63. Fluid Demand Drive Fluid U-Joint Grease See page 64. Locate fittings and grease (3 pumps maximum). 59