Cuisinart CPO-600 User Manual - Page 2

Table of Contents 1. Warnings and Safety Instructions 3 2. Illustrated Parts List 4 3. Exploded View 5 4. Assembly Instructions 6 5. Operating Your Grill 5.1 Choosing a location for installation 8 5.2 Special Instructions for the use of regulator and cylinder 8 5.3 Installing the LP gas cylinder 9 5.4 Checking for leak 9 5.5 Lighting instructions 10 5.6 Match lighting 10 5.7 Using the grill 10 5.8 Warming Tray 11 5.9 Tool Hooks 11 6. Care and Maintenance 11 7. Frequently Asked Questions 12 8. Troubleshooting 12 9. What To Expect 13 10. Warranty Program and Replacement Parts 14 2 1. Warnings and Safety Instructions y Instructions If these instructions are ignored, there is a possibility of a hazardous fire or explosion which could result in physical injury or property damage! It is your responsibility to assemble, operate and maintain your gas grill properly. READ ALL WARNINGS AND INSTRUCTIONS PRIOR TO ASSEMBLING AND OPERATING YOUR GRILL WARNINGS: m This grill is for outdoor use only. It should NOT be used in a building, garage or any other enclosed area. m The use of alcohol, prescription or non-prescription drugs may impair an individual's ability to properly assemble or safely operate this appliance. m Do not leave the grill unattended. Keep children and pets away from the grill all the times. m Do not use the grill in high wind. m This grill must be used with propane gas only. Liquid propane is not natural gas. The conversion or attempted use of natural gas in a liquid propane grill is dangerous and will void your warranty. m Do not attempt to attach this grill to the self-contained propane system of a camper, trailer, motor home or house. m Do not use charcoal or lighter fluid. m Do not use gasoline, kerosene or alcohol for lighting. The LP-gas cylinder must be constructed and marked in accordance with the specifications for propane gas cylinder of the U.S. Department of Transportation (DOT). m Do not move appliance when in use. m Do not use the grill unless it is COMPLETELY assembled and all parts are securely fastened and tightened. If there are any missing or damaged parts, contact customer service for a replacement. m Do not alter the grill in any manner. m Do not operate the grill if there is gas leak present. m The use and installation of this product must conform to local codes. In the absence of local codes, use the National Fuel Gas Code: ANSI Z223.1/NFPA54, Storage and Handling of Liquefied Petroleum Gases, ANSI.NFPA 58 or Natural Gas and Propane Installation Code, CSA C149.1; Propane Storage and Handling, CSA B149.2. m This appliance is not intended to be installed in or on a boat or recreational vehicle. m Locate the grill away from any combustible or non-combustible materials or construction by at least 24 inches (61cm) from the back and sides. m When cooking with oil or grease, have a type BC or ABC fire extinguisher readily available. In the event of an oil or grease fire do not attempt to extinguish with water. Immediately call the fire department. A type BC or ABC fire extinguisher may, in some circumstances contain the fire. m This appliance shall not be used under overhead unprotected combustible construction. m This appliance is not intended for and should never be used as a heater. m This appliance will be hot during and after use. Use insulated oven mitts or gloves for protection from hot surfaces or splatter from cooking liquids. m This appliance is not intended for commercial use. m The pressure regulator supplied with the Cuisinart Gas Grill must be used. m Do not touch or open the lid without a glove when the grill is hot. Only open the lid for cleaning when it is completely cool down. CALIFORNIA PROPOSITION 65 Warning: Combustion by-products produced when using this product contains chemicals known to State of Californian to cause cancer, birth defects, and other reproductive harm. To reduce the risk of exposure to these substances, always use the grill in a well ventilated area. 3