Husqvarna YTH22V46 Instruction Manual

Husqvarna YTH22V46 Manual

Get Husqvarna YTH22V46 PDF manuals and user guides View all Husqvarna YTH22V46 manuals
Add to My Manuals
Save this manual to your list of manuals

Husqvarna YTH22V46 manual content summary:

  • Husqvarna YTH22V46 | Instruction Manual - Page 1
    YTH22V46 Owner's Manual / 96043010100 / 2009-12 532 43 33-16
  • Husqvarna YTH22V46 | Instruction Manual - Page 2
    , leaves or other debris build-up which can touch hot exhaust / engine parts and burn. Do not allow the mower deck to plow leaves or other debris which can cause build-up to occur. Clean any oil or fuel spillage before operating or storing the machine. Allow machine to cool before storage. II. SLOPE
  • Husqvarna YTH22V46 | Instruction Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Husqvarna YTH22V46 | Instruction Manual - Page 4
    -30 (below 32°F) Oil Capacity: w/Filter: w/o Filter: 64 oz. 60 oz. Spark Plug: Champion QC12YC (Gap: .030") Ground Speed (MPH): Forward: Reverse: 0 - 5.2 0 - 2.9 Charging System: 3 AMPS BATTERY 5 AMPS HEADLIGHTS Battery: AMP/HR: MIN. CCA: Case Size: 28 230 U1R Blade Bolt Torque: 45-55
  • Husqvarna YTH22V46 | Instruction Manual - Page 5
    hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). • For battery and battery cable installation see "REPLACING BATTERY" in the "Service and Adjustments" section in this manual. LABEL Fig. 1 ADJUST SEAT (See Fig. 2) • Sit in seat. • Lift up adjustment
  • Husqvarna YTH22V46 | Instruction Manual - Page 6
    (See the Operation and Maintenance sections in this manual). ✓ It is important to purge the transmission before operating your tractor for the first time. Follow proper starting and transmission purging instructions (See "TO START ENGINE" and "PURGE TRANSMISSION" in the Operation section of this
  • Husqvarna YTH22V46 | Instruction Manual - Page 7
    NEUTRAL HIGH LOW CHOKE FAST SLOW IGNITION SWITCH ENGINE OFF REVERSE OPERATION SYSTEM (ROS) ENGINE ON ENGINE START PARKING BRAKE MOWER HEIGHT MOWER LIFT LIGHTS ON FUEL BATTERY REVERSE FORWARD CRUISE CONTROL CLUTCH/BRAKE PEDAL 15 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED
  • Husqvarna YTH22V46 | Instruction Manual - Page 8
    movement of tractor. (L) REVERSE DRIVE PEDAL - Used for reverse movement of tractor. (M) FREEWHEEL CONTROL - Disengages transmission for pushing or slowly towing the tractor with the engine off. (P) SERVICE REMINDER / HOUR METER - Indicates when service is required for the engine and mower. 8
  • Husqvarna YTH22V46 | Instruction Manual - Page 9
    grass. To eliminate this possibility, always stop engine when stopping tractor on grass areas. Fig. 4 STOPPING (See Fig. 5) MOWER BLADES - • To stop mower blades, place attachment clutch control in the "DISENGAGED" position ( ). CAUTION: Always stop tractor completely, as described above, and set
  • Husqvarna YTH22V46 | Instruction Manual - Page 10
    seat to prevent the engine from hesitating or cutting off when operating your equipment on rough, rolling terrain or hills. • Select desired height of cut (see "TO ADJUST MOWER CUTTING HEIGHT") • Start mower blades by engaging attachment clutch control. TO STOP MOWER BLADES • Disengage attachment
  • Husqvarna YTH22V46 | Instruction Manual - Page 11
    of your tractor. SERVICE REMINDER/HOUR METER Service reminder shows the total number of hours the engine has run and flashes to indicate that the engine or mower needs servicing. When service is required, the service reminder will flash for two hours. To service engine and mower, see the Maintenance
  • Husqvarna YTH22V46 | Instruction Manual - Page 12
    for a few seconds, remove and read oil level. If necessary, add oil until "FULL" mark on dipstick is reached. Do not overfill. • For cold weather operation you should change oil for easier starting (See "OIL VISCOSITY CHART" in the Maintenance section of this manual). • To change engine oil, see the
  • Husqvarna YTH22V46 | Instruction Manual - Page 13
    wheels. The air is being removed from hydraulic drive system. • Shut- off engine and set parking brake. • Engage transmission by placing freewheel control in engaged position (See "TO TRANSPORT" in this section of manual). • Sitting in the tractor seat, start engine. After the engine is running
  • Husqvarna YTH22V46 | Instruction Manual - Page 14
    Service and Adjustments section of this manual. • At least once a year you should replace the spark plug, clean or replace air filter, and check blades and belts for wear. A new spark plug and clean air filter assure proper air-fuel mixture and help your engine run better and last longer. ➀ SPINDLE
  • Husqvarna YTH22V46 | Instruction Manual - Page 15
    , repair the problem immediately. CAUTION: Use only a replacement blade approved by the manufacturer of your tractor. Using a blade not approved by the manufacturer of your tractor is hazardous, could damage your tractor and void your warranty. BLADE REMOVAL (See Fig. 14) • Raise mower to highest
  • Husqvarna YTH22V46 | Instruction Manual - Page 16
    tube securely when finished. ENGINE OIL FILTER Replace the engine oil filter every season or every other oil change if the tractor is used more than 100 hours in one year. See engine manual. AIR FILTER Your engine will not run properly using a dirty air filter. Service air cleaner more often under
  • Husqvarna YTH22V46 | Instruction Manual - Page 17
    Operator's Manual) onto the end of your garden hose. 4. Pull back the lock collar of the nozzle adapter and push the adapter onto the deck washout port at the left end of the mower deck. Release the lock collar to lock the adapter on the nozzle. FUEL FILTER Fig. 17 CLEANING • Clean engine, battery
  • Husqvarna YTH22V46 | Instruction Manual - Page 18
    moving parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TO REMOVE MOWER (See Fig. 20) • Place attachment clutch in "DISENGAGED" position. • Lower attachment lift lever to its lowest position. • Roll belt off engine
  • Husqvarna YTH22V46 | Instruction Manual - Page 19
    slide collar (L) onto guide and secure with retainer spring (K). • Install belt on engine pulley (M), in belt keepers (G). M C D Fig. 22 • ATTACH FRONT LINK (E) - Work from left side of trac- tor. Insert rod end of link assembly through front hole in tractor front suspension bracket (F). R Q Fig
  • Husqvarna YTH22V46 | Instruction Manual - Page 20
    , see step in Visual Adjustment instructions above. • Recheck measurements, adjust if necessary until both sides are equal. FRONT-TO-BACK ADJUSTMENT (See Figs. 28 & 29) IMPORTANT: Deck must be level side-to-side. To obtain the best cutting results, the mower blades should be adjusted so the front
  • Husqvarna YTH22V46 | Instruction Manual - Page 21
    SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 30) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL • Remove mower from tractor (See "TO REMOVE MOWER" in this section of manual). • Work belt off both
  • Husqvarna YTH22V46 | Instruction Manual - Page 22
    eye protection when around batteries. SEAT PAN If your battery is too weak to start the engine, it should be recharged. (See "BATTERY" in the MAINTENANCE section of this manual). If "jumper cables" are used for emergency starting, follow this procedure: IMPORTANT: YOUR TRACTOR IS EQUIPPED WITH
  • Husqvarna YTH22V46 | Instruction Manual - Page 23
    wiring may cause your tractor to run poorly, stop running, or prevent it from starting. • Check wiring. See electrical wiring diagram in the Repair Parts section. TO REPLACE FUSE Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash. TO REMOVE HOOD AND GRILL
  • Husqvarna YTH22V46 | Instruction Manual - Page 24
    the gas tank and carburetor if using fuel stabilizer. ENGINE OIL Drain oil (with engine warm) and replace with clean engine oil. (See "ENGINE" in the Maintenance section of this manual). CYLINDER(S) • Remove spark plug(s). • Pour one ounce of oil through spark plug hole(s) into cylinder(s). • Turn
  • Husqvarna YTH22V46 | Instruction Manual - Page 25
    underside of mower housing. 4. Dirty air filter. 4. Clean/replace air filter. 5. Low oil level/dirty oil. 5. Check oil level/change oil. 6. Faulty spark plug. 6. Clean and regap or change spark plug. 7. Dirty fuel filter. 7. Replace fuel filter. 8. Stale or dirty fuel. 8. Empty fuel tank
  • Husqvarna YTH22V46 | Instruction Manual - Page 26
    TROUBLESHOOTING PROBLEM CAUSE Engine continues to run when operator leaves seat with attachment clutch engaged 1. Faulty operator-safety presence control system. CORRECTION 1. Check wiring, switches and connections. If not corrected, contact an authorized service center/ department. Poor cut -
  • Husqvarna YTH22V46 | Instruction Manual - Page 27
    CHASSIS HARNESS SEAT SWITCH (NOT OCCUPIED) SHORTING CONNECTOR BLACK /WHITE IGNITION UNIT (OPTIONAL) SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES) BLUE HOUR METER BLACK BLUE FUEL LINE 12V POWER OUTLET (OPTIONAL) FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED) CHARGING SYSTEM OUTPUT 3 AMP DC
  • Husqvarna YTH22V46 | Instruction Manual - Page 28
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 ELECTRICAL T06S With 12V Outlet Option 103 22 79 21 33 30 87 59 34 With Service Minder Option 46 26 27 43 42 40 41 25 16 90 71 2 102 29 28 55 105 28
  • Husqvarna YTH22V46 | Instruction Manual - Page 29
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 ELECTRICAL KEY PART NO. NO. DESCRIPTION 1 532 16 34-65 2 874 76 04-12 8 532 19 32-28 16 532 17 61-38 21 532 18 37-59 22 532 00 41-52 25 532 41 28-95 26 532 17 51-58 27
  • Husqvarna YTH22V46 | Instruction Manual - Page 30
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 CHASSIS                                                 
  • Husqvarna YTH22V46 | Instruction Manual - Page 31
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 CHASSIS KEY PART 58 532 41 22-80 68 Engine Screw 5/16-18 x 3/4 Fender Nut Lock 5/16-18 Drawbar Upper 2PC Sml. Fender Screw Thdrol 5/16-18 x 1/2 Screw #10 x 0.750 Bumper Dash Cupholder Air Plug Hole Dash Lower Console Asm. Deck
  • Husqvarna YTH22V46 | Instruction Manual - Page 32
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 DRIVE 221 213 207 206 92 125 116 56 209 143 160 26 185 216 221 184 35
  • Husqvarna YTH22V46 | Instruction Manual - Page 33
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 DRIVE KEY PART Pulley Idler Flat Lock Nut 3/8-16 Idler V-Groove 910" Offset V-Belt, Drive Shaft Asm. Pedal Brake Control Bolt Hex 5/16-18 Gr Idler Spacer Axle KEY PART NO. NO. 184 532 40 31-18 185 872 11 06-22 186 532 19 43-
  • Husqvarna YTH22V46 | Instruction Manual - Page 34
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 ENGINE 1 21 20         ENGINE TEX?BS CYL?  69 62 45 84 84 12 82 81 71 70 79 42 85 9 2 29 SPARK ARRESTER KIT 34
  • Husqvarna YTH22V46 | Instruction Manual - Page 35
    of factors including, but not limited to, accessories (air cleaner, exhaust, charging, cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions (temperature, humidity, altitude), and engine-toengine variability. Due to manufacturing and capacity limitations
  • Husqvarna YTH22V46 | Instruction Manual - Page 36
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 STEERING ASSEMBLY 26 45 51 1 63 21 57 16 19 60 57 63 59 64 28 13 22 35 58 6 9 87 67 2 66 9 87 61 4 15 69 68 70 steering-tex_HUSQHR_1_r1 67 14 62 14 15 6 5 13 53 8 13 36
  • Husqvarna YTH22V46 | Instruction Manual - Page 37
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 STEERING ASSEMBLY KEY PART 21 532 18 67-37 22 532 42 05-37 26 Spindle Washer 25/32 x 1-1/4 x 16 Ga. Washer, Lock Hvy Hlcl Spr 3/8 Nut, Crown Lock 3/8-24 unf Shaft Steering Plate Steering Adapter, Wheel Steering Steering Support
  • Husqvarna YTH22V46 | Instruction Manual - Page 38
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 MOWER DECK 70 67 7 152 37 7 46 3 116 30 38 57 43 42 56 40 145 59 60 57 56 64 197 240 36 47 55 46
  • Husqvarna YTH22V46 | Instruction Manual - Page 39
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 MOWER DECK KEY PART NO. NO. 1 532 41 08-63 2 532 40 55-06 3 532 40 55-07 6 532 19 51-86 7 532 41 63-58 8 532 19 30-
  • Husqvarna YTH22V46 | Instruction Manual - Page 40
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 MOWER LIFT 87 7 87 10 3 97 90 98 89 100 2 88 97 91 101* 89 87 lift-tex_22 *Key 91 may be substituted for Key 101 KEY PART Cotter 5/16 Bow Tie Lock Link Lift Susp Mower Rear KEY PART NO. NO. 97 817 00 06-12 98
  • Husqvarna YTH22V46 | Instruction Manual - Page 41
    TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01 SEAT ASSEMBLY 1 8 7 41 40 88 7 8 10 21 6 37 6 37 2 44 43 21 seat-tex_6.5SL_3 KEY PART NO. NO. 1 532 42 40-68 2 532 18 01-66 3 532 14 06-75 6 873 80 06-00 7 532 12 41-81 8 532 17 18-
  • Husqvarna YTH22V46 | Instruction Manual - Page 42
    . Keep Hands Away WHEELS AND TIRES 1 2 11 3 4 7 10 5 9 6 8 wheel_art_1-tex KEY PART NO. NO. DESCRIPTION 9 532 14 50-05 Decal, Battery Dnge/Poi 12 532 16 03-96 Decal, Mower V-Belt Schematic - - 532 16 69-60 Decal, Bypass - - 532 41 08-05 Pad, Footrest, LH - - 532 41 08-06 Pad, Footrest
  • Husqvarna YTH22V46 | Instruction Manual - Page 43
    43 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Husqvarna YTH22V46 | Instruction Manual - Page 44
    12.14.09 TH Printed in the U.S.A.
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
Owner's Manual
/ 96043010100 / 2009-12
532 43 33-16
YTH22V46