Maytag MGR4452BDB Installation Manual
Maytag MGR4452BDB - 4.5 GAS RANGES Manual
 |
UPC - 719881167992
View all Maytag MGR4452BDB manuals
Add to My Manuals
Save this manual to your list of manuals |
Maytag MGR4452BDB manual content summary:
- Maytag MGR4452BDB | Installation Manual - Page 1
THESE INSTRUCTIONS WITH THE APPLIANCE INSTALLATION MANUAL 'Gas 30-inch Wide Free-standingRange PLEASE KEEP THIS MANUAL FOR FUTURE REFERENCE THE MANUAL IS INTENDED TO ASSIST IN THE INITIAL INSTALLATION AND ADJUSTMENTS OF THE RANGE. Only qualified personnel should install or service this range. Read - Maytag MGR4452BDB | Installation Manual - Page 2
INSTALLATION DRAWINGS 36" (91.4 CM) HEIGHT OF CABINET ///_30" (76_2 CM) |/ CABINET OPENING RECOMMENDED GAS LINE LOCATION SELF-CLEAN MODELS. GAS LINE LOCATION NON-SELF CLEANING MODELS. -PROVIDE FOR 120 VOLT GROUNDED ELECTRICAL OUTLET IN THIS AREA. OUTLET MUST BE FLUSH. AREA IS 13"W X 9"H, (33 - Maytag MGR4452BDB | Installation Manual - Page 3
ABOVE COOKING SURFACE TOP BURNER RATE FOR NATURAL GAS (SEE RATING PLATE) 9,200 BTU/HR OR LESS MORE THAN 9,200 BTU/HR CONVENTIONAL OVEN 0 INCHES 1 INCH (2.5 CM) SELF-CLEAN OVEN 3 INCHES (7.6 CM) 3 INCHES (7.6 CM) Check the range model number plate to see if the range is approved for installation - Maytag MGR4452BDB | Installation Manual - Page 4
MANUAL and avoid using the oven door and/or lower drawer as a step stool. Installation instructions where either the right or left rear "edge" of the range will be located and mark the floor or wall. g. Place at a hardware store. Drill the required size hole for the screws obtained into the concrete - Maytag MGR4452BDB | Installation Manual - Page 5
according to the instructions given in section h. NATURAL GAS SUPPLY LINE MUST HAVE A NATURAL GAS SERVICE REGULATOR. INLET PRESSURE work its way into the range manifold and in turn cause failure of the gas valves or controls and clog burners and/or pilot orifices. CAUTION: DO NOT LIFT OR MOVE RANGE - Maytag MGR4452BDB | Installation Manual - Page 6
, turn on the supply line gas shut off valve, and retest for leaks. CAUTION: NEVER CHECK FOR LEAKS WITH A FLAME. WHEN LEAK CHECK IS COMPLETE, WIPE OFF ALL RESIDUE. Remove shipping screw from ALL top burners. (Conventional top burner models only). This is to hold the burners in place on the - Maytag MGR4452BDB | Installation Manual - Page 7
RANGE ADJUSTMENTS Top Section - Gas Top Pilot Adjustment (See figure 6) Purge all air from supply system by turning on one top burner valve. Then turn off valve and adjust top pilot flame using adjusting screw "A" (figure 6) so that flame is even with top of flash tube. To light the burner, push and - Maytag MGR4452BDB | Installation Manual - Page 8
when cold. (See #2 on figure 9). C. The oven burner air shutter adjustment is the same on ranges with a gas pilot or electric ignition. 1 LOCK SCREW ORIFICE HOOD AIR SHUTTER /2 Removing Sealed Burner For Adjustment Or Service: Mark ignitor location relative to main top with pencil. This mark on - Maytag MGR4452BDB | Installation Manual - Page 9
GAS CONVERSION To access the regulator from front of range, remove the storage drawer or warming drawer REMOVE WARMING DRAWER: 1. Empty drawer and pull out to its full open position. 2. Locate the black triangle levers on each side of the drawer. TO REPLACE WARMING DRAWER: a. Pull the bearing glides - Maytag MGR4452BDB | Installation Manual - Page 10
rear leveling leg into the anti-tip bracket. SERVICE-PARTS INFORMATION When your range requires service or replacement parts, contact your dealer or authorized service agency. Please give the complete model and serial numbers of the range which is located on the range model number plate. -10-
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
 |
 |
INSTALLER:
LEAVE
THESE
INSTRUCTIONS
WITH
THE
APPLIANCE
INSTALLATION
MANUAL
'Gas
30-inch Wide Free-standing Range
PLEASE
KEEP
THIS
MANUAL
FOR
FUTURE
REFERENCE
THE MANUAL
IS INTENDED
TO ASSIST
IN THE INITIAL
INSTALLATION
AND ADJUSTMENTS
OF
THE RANGE.
Only qualified
personnel
should
install
or service
this
range.
Read
"Safety
Instructions"
in the
Use & Care
book before
using
range.
Improper
installation,
adjustment,
alteration,
service,
maintenance
or
use
of range
can
result
in serious
injury
or property
damage.
WARNING
•
ALL
RANGES CAN
TIP
AND
CAUSE INJURIES TO PERSONS.
•
INSTALL
ANTI-TIP
DEVICES
PACKED WITH RANGE.
•
FOLLOW
ALL
INSTALLATION
INSTRUCTIONS.
CLEARANCE
DIMENSIONS
Range
may
be installed
with
zero
inches
clearance
adjacent
to (against)
combustible
construction
at the
rear
and on the
sides
below
the
cooktop.
For complete
information
in regard
to the
installation
of wall
cabinets
above
the
range
and clearances
to combustible
wall
above
the cooking
top
see
the
installation
drawings.
For
SAFETY
CONSIDERATIONS
do not install
a range
in
any
combustible
cabinetry
which
is
not
in
accord
with
the
installation
drawings.
*
NOTE:
30 inch
(76.2
cm)
dimension
between
cooking
top and
wall
cabinet
shown
on illustration
does
not apply
to ranges
with
an elevated
oven.
The
36 inch
(76.2
cm)
dimension
may
be reduced
to not
less
than
24 inches
(61
cm) when
the wall
cabinets
in
a domestic
home
are
protected
with
fireproof
materials
in accordance
with
American
National
Standards
- National
Fuel
Gas
Code
or
in mobile
homes
when
they
are protected
with
fireproof
materials
in
accordance
with
the
Federal
Standard
for
Mobile
Home
Construction
and Safety.
To eliminate
the
risk of burns
or fire
by reaching
over
heated
surface
units,
cabinet
storage
space
located
above
the surface
units
should
be avoided.
If cabinet
storage
is to be provided,
the
risk can
be reduced
by
installing
a range
hood
that
projects
horizontally
a
minimum
of 5
inches
(13 cm)
beyond
the
bottom
of the
cabinets.
CAUTION:
This
range
has
been
designed
in
accordance
with
the
requirements
of
various
safety
agencies
and
complies
with
the
maximum
allowable
wood
cabinet
temperatures
of
194°F.
If this
range
is installed
with
cabinets
that
have
a lower
working
temperature
than
194°F,
discoloration,
delamination
or
melting
may
occur.
8101 P624-60
(12-03-00)