Poulan 2050 User Manual - Page 15

S Replace with Champion RCJ--7Y spark plug and tighten with a 3/4 inch socket wrench (10-12 ft/lbs). Spark plug gap should be 0.025 inches. S Reinstall the spark plug boot. S Reinstall the cylinder cover and 3 screws (15-20 in/ lbs). Screws Spark Plug Boot Cylinder Cover Spark Plug STORAGE WARNING: Stop engine and allow to cool, and secure the unit before storing or transporting in a vehicle. Store unit and fuel in an area where fuel vapors cannot reach sparks or open flames from water heaters, electric motors or switches, furnaces, etc. TROUBLESHOOTING TABLE Store unit with all guards in place. Position so that any sharp object cannot accidentally cause injury to passersby. Store the unit out of reach of children. S Before storing, drain all fuel from the unit. Start engine and allow to run until it stops. S Clean the unit before storing. Pay particular attention to the air intake area, keeping it free of debris. Use a mild detergent and sponge to clean the plastic surfaces. S Do not store the unit or fuel in a closed area where fuel vapors can reach sparks or an open flame from hot water heaters, electric motors or switches, furnaces, etc. S Store in a dry area out of the reach of children. CAUTION: It is important to prevent gum deposits from forming in essential fuel system parts such as the carburetor, fuel filter, fuel hose, or fuel tank during storage. Alcohol blended fuels (called gasohol or using ethanol or methanol) can attract moisture which leads to fuel mixture separation and formation of acids during storage. Acidic gas can damage the engine. WARNING: Always stop unit and disconnect spark plug before performing all of the recommended remedies below except remedies that require operation of the unit. TROUBLE CAUSE REMEDY Engine will not start or will run only a few seconds after starting. S Ignition switch off. S Engine flooded. S Fuel tank empty. S Spark plug not firing. S Fuel not reaching . carburetor. S Move ignition switch to ON. S See "Difficult Starting" in Operation Section. S Fill tank with correct fuel mixture. S Install new spark plug. S Check for dirty fuel filter; replace. Check for kinked or split fuel line; repair or replace. Engine will not idle properly. S Carburetor requires . adjustment S Crankshaft seals worn. S Contact an Authorized Service Dealer. S Contact an Authorized Service Dealer. Engine will not accelerate, lacks power, or dies under a load. S Air filter dirty. S Spark plug fouled. S Carburetor requires adjustment. S Clean or replace air filter. S Clean or replace plug and regap. S Contact an Authorized Service Dealer. . Engine smokes excessively. S Too much oil mixed with S Empty fuel tank and refill with . gasoline. . correct fuel mixture. NEED ASSISTANCE? NEED ASSISTANCE? Call 1---800---554---6723. NEED SERVICE PART? Contact your dealer or place of purchase. LIMITED WARRANTY ELECTROLUX HOME PRODUCTS NORTH AMERICA, Division of WCI Outdoor Products, Inc., warrants to the original purchaser that each new Poulan or Poulan Pro brand gasoline chain saw is free from defects in material and workmanship and agrees to repair or replace under this warranty any defective gasoline chain saw as follows from the original date of purchase. 1 YEAR -- Parts and Labor, when used for Household purposes. 60 DAYS -- Parts and Labor, when used for Commercial, Professional, or Income Producing purposes. 30 DAYS -- Parts and Labor, if used for rental purposes. This warranty is not transferable and does not cover damage or liability caused by improper 15