2007 Dodge Caravan Owner's Manual
2007 Dodge Caravan Manual
2007 Dodge Caravan manual content summary:
- 2007 Dodge Caravan | Owner's Manual - Page 1
SECTION 1 2 3 4 5 6 7 8 9 10 TABLE OF CONTENTS PAGE INTRODUCTION ...3 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE ...9 UNDERSTANDING THE FEATURES OF YOUR VEHICLE ...91 UNDERSTANDING YOUR INSTRUMENT PANEL ...203 STARTING AND OPERATING ...307 WHAT TO DO IN EMERGENCIES ...383 MAINTAINING YOUR - 2007 Dodge Caravan | Owner's Manual - Page 2
- 2007 Dodge Caravan | Owner's Manual - Page 3
INTRODUCTION CONTENTS Introduction ...4 How To Use This Manual ...4 Warnings And Cautions ...6 Vehicle Identification Number ...6 Vehicle Modifications/Alterations ...7 1 - 2007 Dodge Caravan | Owner's Manual - Page 4
service, remember that your dealer knows your vehicle best, has the factory-trained technicians and genuine Mopar parts, and is interested in your satisfaction. WARNING! Engine you desire. The detailed index, at the rear of this manual, contains a complete listing of all subjects. Consult the - 2007 Dodge Caravan | Owner's Manual - Page 5
INTRODUCTION 5 1 - 2007 Dodge Caravan | Owner's Manual - Page 6
which could result in damage to your vehicle. If you do not read this entire manual, you may miss important information. Observe all Warnings and Cautions. VEHICLE IDENTIFICATION NUMBER The on your vehicle, the vehicle registration and title. VIN Location NOTE: It is illegal to remove the VIN. - 2007 Dodge Caravan | Owner's Manual - Page 7
INTRODUCTION 7 VEHICLE MODIFICATIONS/ALTERATIONS 1 WARNING! Any modifications or alterations to this vehicle could seriously affect its roadworthiness and safety and may lead to an accident resulting in serious injury or death. - 2007 Dodge Caravan | Owner's Manual - Page 8
- 2007 Dodge Caravan | Owner's Manual - Page 9
...14 ▫ Locking Doors With The Key ...14 Steering Wheel Lock - If Equipped ...14 ▫ If You Wish To Manually Lock The Steering Wheel ...14 ▫ To Release The Steering Wheel Lock ...14 ▫ Automatic Transaxle Ignition Interlock System . .15 Sentry Key - If Equipped ...15 ▫ Shaft Lock Module (Vehicles - 2007 Dodge Caravan | Owner's Manual - Page 10
Panic Alarm ...23 ▫ To Program Transmitters ...23 ▫ General Information ...25 ▫ Transmitter Battery Service ...26 Door Locks ...27 ▫ Manual Door Locks ...27 ▫ Power Door Locks - If Equipped ...28 Windows ...31 ▫ Manual Rear Vent Windows ...31 ▫ Power Vent Windows - If Equipped ...32 ▫ Power Windows - 2007 Dodge Caravan | Owner's Manual - Page 11
Procedure ...53 ▫ Center Lap Belts ...53 ▫ Seat Belt Pretensioners ...54 ▫ Enhanced Seat Belt Use Reminder System (BeltAlert) ...54 ▫ Seat Belts And Pregnant Women ...56 ▫ Seat Belt Extender ...56 ▫ Driver And Front Passenger Supplemental Restraint Systems (SRS) - Airbags ...57 ▫ Event Data Recorder - 2007 Dodge Caravan | Owner's Manual - Page 12
the key code numbers for your vehicle locks. These numbers can be used to a safe place. Ignition Key Removal Automatic Transaxle Place the shift lever in PARK inward, rotate the key to the LOCK position, and remove the key. NOTE engine can be started and stopped but the key cannot be removed until - 2007 Dodge Caravan | Owner's Manual - Page 13
operate power windows, other controls, or move the vehicle 2 CAUTION! Ignition Key Position NOTE: The power window switches, radio, power outlets, and front door will cancel this feature. An unlocked car is an invitation to thieves. Always remove key from the ignition and lock all doors when - 2007 Dodge Caravan | Owner's Manual - Page 14
ignition and the driver's door is opened. Locking Doors With The Key You can insert the key with either side up. To lock the door, turn the key rearward, to unlock the door, turn the key forward. See Section 7 of this manual for door lock lubrication. STEERING WHEEL LOCK - IF EQUIPPED Your vehicle - 2007 Dodge Caravan | Owner's Manual - Page 15
the bulb check, it indicates that there is a problem with the electronics. In addition, if the light begins to flash after the bulb check, it indicates that someone used an invalid key to start the engine. Either of these conditions will result in the engine being shut off after two (2) seconds. If - 2007 Dodge Caravan | Owner's Manual - Page 16
16 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE Shaft Lock Module (Vehicles Equipped with Premium Security System) - If Equipped The shaft lock module is located inside the steering column. The module works in conjunction with the Sentry Key to prevent the steering shaft from rotating if someone - 2007 Dodge Caravan | Owner's Manual - Page 17
Sentry Key Immobilizer System serviced, bring all vehicle keys Sentry Key Transponder blank(s) to match the ignition switch lock cylinder key code. 2. Insert the first valid key After ten seconds a chime will sound and the Theft Alarm Light will begin to flash. Turn the ignition switch OFF and remove - 2007 Dodge Caravan | Owner's Manual - Page 18
telltale will flash. The engine will run only if a condition and monitor the remaining doors and ignition. To Arm the System The alarm will set when you use the power door locks, or use the Keyless Entry transmitter to lock the doors. After all the doors are locked and closed the SECURITY light - 2007 Dodge Caravan | Owner's Manual - Page 19
Alert If the horn sounds 3 times when you unlock a front door using either a key or the Keyless Entry Transmitter, the alarm has been activated. Check the vehicle for tampering. Security System Manual Override The system will not arm if you lock the doors using the manual door lock plunger. 2 - 2007 Dodge Caravan | Owner's Manual - Page 20
is in the interior lights ON position (extreme top position). • The illuminated entry system will not operate if the dimmer control is in the "defeat" position (extreme downward position). REMOTE KEYLESS ENTRY - IF EQUIPPED This system allows you to lock or unlock the doors and liftgate, and - 2007 Dodge Caravan | Owner's Manual - Page 21
of the system allow you to turn ON/OFF the Sound Horn On Lock, Remote Unlock Driver's Door 1st, and Flash Lights On Lock/Unlock features. 2 Three Button Transmitter Six button transmitters will provide functions that allow the same basic operation as the three button, but may also be used to Open - 2007 Dodge Caravan | Owner's Manual - Page 22
the Electronic Vehicle Information Center (EVIC), Customer Programmable Features section on vehicles so equipped. To lock the doors and liftgate: Press and release the LOCK button on the transmitter to lock all doors and liftgate. The horn will chirp once to acknowledge the signal. If desired, the - 2007 Dodge Caravan | Owner's Manual - Page 23
and park lights will flash, the horn will pulse on and off and the interior lights will turn on to be closer to the vehicle due to the radio frequency noises of the system. To Program Transmitters: Refer the full open position. If the liftgate is locked and is not equipped with a powered liftgate, - 2007 Dodge Caravan | Owner's Manual - Page 24
is not equipped with a right power sliding door and the door is closed and locked, pressing the button twice will result in the right side doors becoming unlocked. To Turn Off "Flash Lights On Lock/Unlock" - If Equipped If desired, the "Flash Lights On Lock/Unlock" feature can be turned on and off - 2007 Dodge Caravan | Owner's Manual - Page 25
Entry transmitter fails to operate from a normal distance, check for these two conditions. 1. A weak battery in the transmitter. The expected life of the battery is a minimum of three years. 2. Closeness to a radio transmitter such as a radio station tower, airport transmitter, and some mobile or CB - 2007 Dodge Caravan | Owner's Manual - Page 26
STARTING YOUR VEHICLE Transmitter Battery Service The recommended replacement battery is one CR2032 battery. NOTE: Perchlorate Material - special handling may apply. See www.dtsc.ca.gov/hazardouswaste/ perchlorate NOTE: Do not touch the battery terminals that are on the back housing or the printed - 2007 Dodge Caravan | Owner's Manual - Page 27
. Skin oils may cause battery deterioration. If you touch a battery, clean it with rubbing alcohol. 3. To reassemble the transmitter case snap two halves together. Make sure there is an even "gap" between the two halves. Test transmitter operation. DOOR LOCKS Manual Door Locks Lock the doors by - 2007 Dodge Caravan | Owner's Manual - Page 28
down when you shut the door, the door will lock. Therefore, make sure the keys are not inside the vehicle before closing the door. Power Door Locks - If Equipped A power door lock switch is on each front door trim panel. Use this switch to lock or unlock the doors. WARNING! • For personal security - 2007 Dodge Caravan | Owner's Manual - Page 29
mph. Automatic Door Lock Programming This feature is enabled when your vehicle is shipped from the assembly plant and can be disabled by using the following procedure: • On electronic vehicle information center (EVIC) equipped vehicles refer to Personal Settings in the EVIC section of this manual - 2007 Dodge Caravan | Owner's Manual - Page 30
turn the feature back on by manual operation of the power door locks (Lock or Unlock). Auto Unlock On Exit Programming - If Equipped The doors will unlock automatically on vehicles with power door locks if: 1. Enter your vehicle and close all doors. 2. Fasten your seat belt (fastening the seat belt - 2007 Dodge Caravan | Owner's Manual - Page 31
's door lock switch in the UNLOCK direction. 6. A single chime will sound to indicate the feature has been changed. 7. Repeat the above steps to alternate the equipped. NOTE: Use the Auto Door Locks and Auto Unlock features in accordance with local laws. WINDOWS Manual Rear Vent Windows A lever - 2007 Dodge Caravan | Owner's Manual - Page 32
operate the two vent windows from the front seat. Power Windows - If Equipped You can control either front window using switches on the driver's door trim panel. There is a single switch on the passenger's door trim panel which operates the passenger door window. The switches will operate only when - 2007 Dodge Caravan | Owner's Manual - Page 33
Down Feature - If Equipped The driver's window switch has an auto down feature. Press the window switch past the detent, release, and the window will go down automatically. To open the window part way, press the window switch part way and release it when you want the window to stop. The power window - 2007 Dodge Caravan | Owner's Manual - Page 34
faster in the downhill direction. • There is a hold-open latch that is activated when the sliding door is fully opened. This latch will keep your sliding door open on any incline. To close the sliding door after the hold-open latch is activated, you must push the button on the inside grab handle - 2007 Dodge Caravan | Owner's Manual - Page 35
section on vehicles so equipped. Power Sliding Door - If Equipped NOTE: The power sliding door must be unlocked before the switches located on the trim panel, just in front of the power sliding door will operate. The power sliding door may be opened manually or by using the buttons on the remote - 2007 Dodge Caravan | Owner's Manual - Page 36
or pull out on the outside sliding door handle. There are power sliding door switches located on the trim panel just in front of the power sliding door for the rear seat passengers. Pressing the switch once will open the power sliding door, once the door is fully open pressing the switch a second - 2007 Dodge Caravan | Owner's Manual - Page 37
are used while the power sliding door is activated, the power sliding door feature will be canceled and the door must be opened or closed manually. To avoid unintentional operation of the power sliding doors from the rear seats, press the ON /OFF button located in the overhead console to disable - 2007 Dodge Caravan | Owner's Manual - Page 38
for small children riding in the rear seats, the sliding doors are equipped with a child protection door lock system. NOTE: When the child lock system is engaged, the door can be opened only by using the outside door handle even though the inside door lock is in the unlocked position. To Engage - 2007 Dodge Caravan | Owner's Manual - Page 39
inside door lock is in the unlocked position. • The power sliding door will operate from the switches located on the trim panel just in front of the power sliding door, regardless of the child lock lever position. To avoid unintentional operation of the power sliding door from the rear seats, press - 2007 Dodge Caravan | Owner's Manual - Page 40
the liftgate can also be unlocked using the remote keyless entry or by activating the power door lock switches located on the front doors. Once unlocked, on vehicles equipped with power locks, the liftgate can be opened or closed without using the key. To open the liftgate, depress the liftgate - 2007 Dodge Caravan | Owner's Manual - Page 41
locks, the liftgate can only be opened using the vehicle keys. The key must be held in the unlocked position for the liftgate to open. Power Liftgate - If Equipped The power liftgate may be opened manually . Liftgate Handle 2 If the liftgate is locked and is not equipped with a powered liftgate - 2007 Dodge Caravan | Owner's Manual - Page 42
be opened by pressing the button located on the overhead console. WARNING! or opening, the liftgate will automatically reverse to the closed or open lights will flash to signal that the liftgate is opening or closing. • There are also pinch sensors attached to the side of the liftgate opening. Light - 2007 Dodge Caravan | Owner's Manual - Page 43
encounters multiple obstructions within the same cycle, the system will automatically stop and must be opened or closed manually. 2 WARNING! • Driving with the liftgate open can allow windows are closed, and the climate control blower switch is set at high speed. DO NOT use the recirculation mode. - 2007 Dodge Caravan | Owner's Manual - Page 44
44 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE Gas props support the liftgate in the open position. However, because the gas pressure drops with temperature, it may be necessary to assist the props when opening the liftgate in cold weather. SEAT STORAGE BIN SAFETY WARNING CAUTION! The storage bin - 2007 Dodge Caravan | Owner's Manual - Page 45
inserting the loose end of the strap into the latch mechanism. 2 Storage Bin Cover Emergency Release Strap NOTE: In the event of an individual being locked inside the storage bin, the storage bin cover can be opened from inside of the bin by pulling on the glow-in-the-dark strap - 2007 Dodge Caravan | Owner's Manual - Page 46
adult-size seat belts, your seat belts or the LATCH feature (Lower Anchors and Tether for CHildren) also, can be used to hold infant and child restraint systems. NOTE: The front airbags have a multi stage inflator design. This allows the airbag to have different rates of inflation that are based on - 2007 Dodge Caravan | Owner's Manual - Page 47
outboard seats in your vehicle are equipped with Lap/Shoulder Belts. The belt webbing retractor is designed to lock during very sudden stops or collisions. This feature allows the shoulder part of the belt to move freely with you under normal conditions. But in a collision, the belt will lock and - 2007 Dodge Caravan | Owner's Manual - Page 48
is in a seat and using a seat belt properly. WARNING! • Wearing a seat belt incorrectly is dangerous. Seat belts are designed to go around the large bones of your body. These are the strongest parts of your body and can take the forces of a collision the best. • Wearing your belt in the wrong - 2007 Dodge Caravan | Owner's Manual - Page 49
TO KNOW BEFORE STARTING YOUR VEHICLE 49 Lap/Shoulder Belt Operating Instructions 1. Enter the vehicle and close the door. Sit back and adjust the seat. 2. The seat belt latch plate is near the seatback of the front seats and next to your arm in the rear seats. Grasp the latch plate and pull out the - 2007 Dodge Caravan | Owner's Manual - Page 50
move too far forward, increasing the possibility of injury. Wear your seat belt snugly. • A belt that is worn under your arm is very dangerous. Your body hit your head in a collision if you do not wear your shoulder belt. The lap and shoulder belt are meant to be used together. • A belt that is - 2007 Dodge Caravan | Owner's Manual - Page 51
it is too tight, tilt the latch plate and pull on the lap belt. A snug belt reduces the risk of sliding under the belt in a collision. WARNING! • A lap belt worn too high can increase the risk of internal injury in a collision. The belt forces won't be at the strong hip and pelvic bones, but across - 2007 Dodge Caravan | Owner's Manual - Page 52
in a collision and leave you with no protection. Inspect the belt system periodically, checking for cuts, frays, or loose parts. Damaged parts must be replaced immediately. Do not disassemble or modify the system. Seat belt assemblies must be replaced after a collision if they have been damaged - 2007 Dodge Caravan | Owner's Manual - Page 53
the latch plate into the buckle until you hear a "click". To lengthen the lap belt, tilt the latch plate and pull. To remove slack, pull the loose end of the webbing. Wear the lap belt snug against the hips. Sit back and erect in the seat, then adjust the belt as tightly as is comfortable. 2 - 2007 Dodge Caravan | Owner's Manual - Page 54
devices are not a substitute for proper seat belt placement by the occupant. The seat belt still must be worn snugly and positioned properly. The pretensioners are triggered by the front airbag control module (see Front Airbag Section). Like the front airbags, the pretensioners are single use items - 2007 Dodge Caravan | Owner's Manual - Page 55
Warning System (BeltAlert). 1. With all doors closed and the ignition switch in any position except On or Start, buckle the driver's seat belt. 2. Turn the ignition switch to the ON/RUN position (engine does not need to be running), and wait for the Seat Belt Warning Light to turn off. 3. Within 60 - 2007 Dodge Caravan | Owner's Manual - Page 56
or front passenger's seat belt remains unbuckled. Seat Belts and Pregnant Women We recommend that pregnant women use the seat belts throughout their pregnancies. Keeping the mother safe is the best way to keep the baby safe. Pregnant women should wear the lap part of the belt across the thighs and - 2007 Dodge Caravan | Owner's Manual - Page 57
Supplemental Restraint Systems (SRS) - Airbags This vehicle has airbags for both the driver and front passenger as a supplement to the seat belt restraint systems. The driver's front airbag is mounted in the center of the steering wheel. The passenger's front airbag is mounted in the instrument - 2007 Dodge Caravan | Owner's Manual - Page 58
are based on collision severity and occupant size. Also, the front passenger airbag is certified to the Federal regulations that define Occupant Classification (Refer to "Occupant Classification System" in this section). This vehicle may also be equipped with a driver inflatable knee blocker located - 2007 Dodge Caravan | Owner's Manual - Page 59
location of the window bag. The area where the window bag is located should remain free from any obstructions. • If your vehicle is equipped with window bags, do not have any accessory bags. Front airbags, along with the seat belts and front seat belt buckle pretensioners, work with the instrument - 2007 Dodge Caravan | Owner's Manual - Page 60
in collisions where the airbags inflate, you need the seat belts to keep you in the right position for the airbags to protect you belt behind them or under their arm. If a child from 1 to 12 years old must ride in the front passenger seat because the vehicle is crowded, move the seat as far back - 2007 Dodge Caravan | Owner's Manual - Page 61
In some collisions the airbags won't deploy at all. Always wear your seat belts even though you have airbags. • Being too close to the steering wheel or instrument panel during front airbag deployment could cause serious injury. Airbags need room to inflate. Sit back, comfortably extending your arms - 2007 Dodge Caravan | Owner's Manual - Page 62
: • Occupant Restraint Controller (ORC) • AIRBAG Light • Driver Airbag • Front Passenger Airbag • Supplemental Side Curtain Airbags (If Equipped) • Front Impact Sensors • Side Impact Sensors (If Equipped) • Steering Wheel and Column • Instrument Panel • Seat Belt Reminder Light • Knee Impact Bolster - 2007 Dodge Caravan | Owner's Manual - Page 63
different rates of airbag inflation. • The ORC may modify the rate of inflation based on the occupant size provided by the Occupant Classification Module. • The ORC will not detect side, roll over, or rear impacts. • The ORC monitors the readiness of the electronic parts of the system whenever - 2007 Dodge Caravan | Owner's Manual - Page 64
BEFORE STARTING YOUR VEHICLE • The Driver and Passenger Airbag/Inflator Units are located in the center of the steering wheel and the right side of the instrument panel. When the ORC and impact sensors detects a collision requiring the airbags, it signals the inflator units. A large quantity of - 2007 Dodge Caravan | Owner's Manual - Page 65
the best interaction with the front airbag. • If your vehicle contains a Passenger Airbag Disable indicator light, it will be equipped with the Occupant Classification System (OCS). The OCS system will classify an occupant into a size category based on sensor readings from within the seat cushion - 2007 Dodge Caravan | Owner's Manual - Page 66
threshold is placed on the seat, the light will remain OFF. (The PAD indicator light is an amber light located on the center of the instrument panel above the radio.) Passenger Airbag Disabled Light For almost all sizes of properly seated adults, the airbag will be enabled in the event - 2007 Dodge Caravan | Owner's Manual - Page 67
child restraint. • The Occupant Classification Module (OCM) - If Equipped is located beneath the front passenger seat. The OCM classifies the occupant into one of three size categories based on the input from the Bladder Assembly and Belt Tension Sensor. The size categories include empty, child - 2007 Dodge Caravan | Owner's Manual - Page 68
the OCS system detects an adult the PAD indicator light will be off, and the airbag will be enabled. • The Belt Tension Sensor (BTS) - If Equipped is located at the outboard passenger lap belt anchor. The BTS generates a signal based on outboard lap belt tension. This signal is sent to the OCM to - 2007 Dodge Caravan | Owner's Manual - Page 69
or replaced with any part except those which are approved by DaimlerChrysler/ Mopar. • For replacement of the bladder or seat cover assembly, always use the DaimlerChrysler service kit which includes the seat cover and bladder riveted together. If A Deployment Occurs The airbag system is designed to - 2007 Dodge Caravan | Owner's Manual - Page 70
the garment manufacturer's instructions for cleaning. • It is not advisable to drive your vehicle after the airbags have deployed. If you are involved in another collision, the airbags will not be in place to protect you. WARNING! Deployed airbags, front seat belt buckle pretensioners and driver - 2007 Dodge Caravan | Owner's Manual - Page 71
Response If the airbags and seat belt pretensioners deploy after an impact and the electrical system remains functional, vehicles equipped with power door locks will unlock automatically. In addition, approximately 10 seconds after the vehicle has stopped moving, the interior lights will illuminate - 2007 Dodge Caravan | Owner's Manual - Page 72
NOTE: If the speedometer, tachometer or any engine related gauges are not working, the airbag control module may also be disabled. The airbags may not be ready to inflate for your protection. Promptly check fuse block for blown fuses. Refer to the label located on the inside of the fuse block cover - 2007 Dodge Caravan | Owner's Manual - Page 73
vehicle data parameters (see list below) in an event data recorder prior to the moment of airbag deployment. Please note that such data are ONLY recorded if an airbag deploys, and are otherwise unavailable. In conjunction with other data gathered during a complete accident investigation, the - 2007 Dodge Caravan | Owner's Manual - Page 74
• Brake status (service and parking brakes) • Accelerator status (including vehicle speed) • Engine control status (including engine speed) • Cruise control status • Traction/stability control status DaimlerChrysler Corporation Integrated Child Seat - If Equipped Operating instructions for this seat - 2007 Dodge Caravan | Owner's Manual - Page 75
YOUR VEHICLE 75 To obtain Integrated Child Seat replacement instructions: Use the order form at the back of this manual and specify publication number 81-016- large enough for an adult safety belt. Always check the child seat owner's manual to ensure you have the right seat for your child. Use the - 2007 Dodge Caravan | Owner's Manual - Page 76
• Rearward-facing child seats must NEVER be used in the front seat of a vehicle with a front passenger airbag. An airbag deployment could cause severe are older than one year. These child seats are also held in the vehicle by the lap/shoulder belt or the LATCH child restraint anchorage system. - 2007 Dodge Caravan | Owner's Manual - Page 77
back is against the seat back, they should use a belt-positioning booster seat. The child and booster seat are held in the vehicle by the lap/shoulder belt. Children Too Large For Booster Seats seat. A rearward facing child restraint in the front seat may be struck by a deploying passenger airbag - 2007 Dodge Caravan | Owner's Manual - Page 78
the label on the restraint for weight and height limits. • Carefully follow the instructions that come with the restraint. If you install the restraint improperly, it may not work when you need it. The passenger seat belts are equipped with cinching latch plates, which are designed to keep the lap - 2007 Dodge Caravan | Owner's Manual - Page 79
is not in use, secure it in the vehicle with the seat belt or remove it from the vehicle. Don't leave it loose in seats. Second-row seats also feature tether strap anchorages, located in the rear surface of the seatback. In addition, all 3-passenger bench seats and 3rd row fold-in-floor seats - 2007 Dodge Caravan | Owner's Manual - Page 80
that the strap is routed over the top of the seatback and under the head restraint between the head restraint posts. Except for bench seats with split seatbacks, when the tether anchorage is used in the center seating position, the strap should be positioned straight over the top of the seatback - 2007 Dodge Caravan | Owner's Manual - Page 81
increased head motion and possible injury to the child. Use only the anchor positions directly behind the child seat to seat is not LATCH compatible, install the restraint using the vehicle seat belts. Fleet vehicles equipped with the LATCH system on the 3-passenger bench seat must have the seat - 2007 Dodge Caravan | Owner's Manual - Page 82
all children in the vehicle that the seat belts are not toys and should not be played with, and never leave your child unattended in the vehicle. Installing the Child Restraint System If your fleet vehicle is equipped with LATCH anchorages on the 3-passenger bench seat, do not install three child - 2007 Dodge Caravan | Owner's Manual - Page 83
Airbags deploying in the front seat could harm your pet. An unrestrained pet could be thrown about and possibly injured, or injure a passenger during panic braking or in a collision. Pets should be restrained in the rear seat in pet harnesses or pet carriers that are secured by seat belts. REAR SEAT - 2007 Dodge Caravan | Owner's Manual - Page 84
deploying passenger air bag. This vehicle is equipped with a child restraint tether anchor located on the floor, behind the front passenger seat. Use this be secured in the passenger seat of a vehicle with a passenger airbag. In an accident a passenger airbag may deploy causing severe injury or - 2007 Dodge Caravan | Owner's Manual - Page 85
. Never allow children to slide the shoulder belt behind them or under their arm. Tether Installation For Commercial Vehicles With Rear Seat Delete To secure the child restraint upper tether strap to the vehicle, follow the instructions shown: 1. Locate the child restraint tether anchor on the - 2007 Dodge Caravan | Owner's Manual - Page 86
to the extended tether strap. 4. If necessary, raise the passenger seat head restraint to allow the tether strap to be routed under the head restraint. 5. Route the tether strap beneath the head restraint between the two head restraint posts. Ensure that the child restraint tether strap is centered - 2007 Dodge Caravan | Owner's Manual - Page 87
7. Following the child seat manufacturer's instructions, tighten the child restraint tether strap. 8. If necessary, reposition the seat head restraint. 9. Inspect the tether anchor strap for nicks, abrasions, discoloration, and loose threads. If these, or any other condition that might effect the - 2007 Dodge Caravan | Owner's Manual - Page 88
The engine oil installed in the engine at the factory is a high quality energy conserving type lubricant. Oil changes should be consistent with anticipated climate conditions under which vehicle operations will occur. The recommended viscosity and quality grades are shown in Section 7 of this manual - 2007 Dodge Caravan | Owner's Manual - Page 89
are closed, and the climate control blower switch is set at high speed. DO NOT use the recirculation mode. Safety Checks You Should Make Inside The Vehicle Seat Belts Inspect the belt system periodically, checking for cuts, frays and loose parts. Damaged parts must be replaced immediately. Do - 2007 Dodge Caravan | Owner's Manual - Page 90
Have someone observe the operation of exterior lights while you work the controls. Check turn signal and high beam indicator lights on the instrument panel. Fluid Leaks Check area under vehicle after overnight parking for fuel, engine coolant, oil or other fluid leaks. Also, if gasoline fumes are - 2007 Dodge Caravan | Owner's Manual - Page 91
UNDERSTANDING THE FEATURES OF YOUR VEHICLE CONTENTS Mirrors ...96 ▫ Inside Day/Night Mirror ...96 ▫ Automatic Dimming Mirror - If Equipped ...96 ▫ Driver's Side Outside Mirror Auto Dimmer - If Equipped ...97 ▫ Outside Mirrors ...97 ▫ Exterior Mirrors Folding Feature ...98 ▫ Power Folding Outside - 2007 Dodge Caravan | Owner's Manual - Page 92
Equipped ...124 ▫ 6-Way Passenger's Power Seat - If Equipped ...124 ▫ Adjustable Head Restraints - If Equipped ...125 ▫ Heated Seats - If Equipped ...126 ▫ Manual Reclining Seats - If Equipped ...127 ▫ Manual Lumbar - If Equipped ...128 ▫ Middle Rear Bench Seat Recline - If Equipped ...129 ▫ Stow - 2007 Dodge Caravan | Owner's Manual - Page 93
Lights ...150 ▫ Interior Lights ...151 ▫ Park Lights ...151 ▫ Headlights ...151 ▫ Automatic Headlights - If Equipped ...153 ▫ Daytime Running Lights (Canada/Fleet Vehicles Only) ...153 ▫ Lights-On Reminder ...153 ▫ Battery - If Equipped ...163 Electronic Speed Control - If Equipped ...164 ▫ To - 2007 Dodge Caravan | Owner's Manual - Page 94
Console - If Equipped ...167 ▫ Courtesy/Reading Lights ...168 ▫ Sunglass Storage ...168 ▫ Compass Programmable Features - If Equipped ...173 Garage Door Opener - If Equipped ...177 ▫ Programming If Equipped ...185 ▫ Electrical Outlet Use With Engine Off ...186 Convenience Tray Drawer And Cup - 2007 Dodge Caravan | Owner's Manual - Page 95
Bins - If Equipped ...190 ▫ Overhead Rail System - If Equipped ...191 ▫ Removable Floor Console With Stow 'n Go Seating - If Equipped ...193 ▫ Removable Floor Console Without Stow 'n Go Seating - If Equipped ...194 ▫ Rear Compartment Storage Bins ...198 ▫ Cargo/Tub Net ...198 ▫ Coat Hooks ...198 - 2007 Dodge Caravan | Owner's Manual - Page 96
the small control under the mirror Automatic Dimming Mirror - If Equipped When using this feature the mirror will automatically adjust for annoying headlight glare from vehicles behind you. You can turn the feature on or off by pressing the button at the base of the mirror. A light - 2007 Dodge Caravan | Owner's Manual - Page 97
the mirror clean. Driver's Side Outside Mirror Auto Dimmer - If Equipped This mirror automatically adjusts for annoying headlight glare from vehicles behind you. You can turn this feature on or off by pressing the button at the base - 2007 Dodge Caravan | Owner's Manual - Page 98
down to the left or right to fold in the mirrors. Turn the knob back upward to the left mirror, right mirror, or off (center) position to the have to be in the ON position. Power Remote-Control Mirrors - If Equipped Use the mirror select switch, located on the instrument panel to the left of the - 2007 Dodge Caravan | Owner's Manual - Page 99
visor down and swing the mirror cover upward. The lights turn on automatically. Closing the mirror cover turns off the lights. Sun Visor Extension - If Equipped This feature has can be controlled by the optional Driver Memory Seat Feature. Refer to "Driver Memory Seat" in section 3 of this manual. - 2007 Dodge Caravan | Owner's Manual - Page 100
" "Mike" "Work or Dial" "248-555-1212 ). Your cellular phone's audio is transmitted through your vehicle's audio system; the system will automatically mute your radio when using the mirror contains the microphone for the system and the control buttons that will enable you to access the system. - 2007 Dodge Caravan | Owner's Manual - Page 101
The UConnect™ system is fully integrated with the vehicle's audio system. The volume of the UConnect™ system can be adjusted either from the radio volume control knob, or from the steering wheel radio control (right switch), if so equipped. The radio display will be used for visual prompts from the - 2007 Dodge Caravan | Owner's Manual - Page 102
part of the command, when you are asked for it. For example, you can use the combined form voice command Phonebook New Entry, or you can break the combined form command into two voice commands: Phonebook and New Entry. Please remember, the UConnect™ system works best you back to the previous menu. - 2007 Dodge Caravan | Owner's Manual - Page 103
0.96 or higher. See www.chrysler.com/uconnect for supported phones. To complete the pairing process, you will need to reference your cellular phone owner's manual. One of the following vehicle specific websites may also provide detailed instructions for pairing with the brand of phone that you have - 2007 Dodge Caravan | Owner's Manual - Page 104
can say 234-567-8901. • The UConnect™ system will confirm the phone number and then dial. The number will appear in the display of certain radios. Call/Dial by Saying a Name • Press the "Phone" button to begin. • After the Ready prompt and the following beep, say "Dial" or Call. • System will - 2007 Dodge Caravan | Owner's Manual - Page 105
of Bob. • When prompted, enter the number designation (e.g., Home, Work, Mobile, or Pager ). This will allow you to store multiple numbers dial the corresponding phone number, which may appear in the display of certain radios. Add Names to Your UConnect™ Phonebook NOTE: Adding names to phonebook - 2007 Dodge Caravan | Owner's Manual - Page 106
phonebook entry that you wish to edit. • Next, choose the number designation (home, work, mobile, or pager) that you wish to edit. • When prompted, recite the a mobile and a home number, but you can add John Doe's work number later using the Phonebook Edit feature. Delete Entries in the UConnect™ - 2007 Dodge Caravan | Owner's Manual - Page 107
the desired entry and say Delete. • After you enter the name, the UConnect™ system will ask you which designation you wish to delete, home, work, mobile, or pager. Say the designation you wish to delete. • Note that only the phonebook entry in the current language is deleted. After confirmation - 2007 Dodge Caravan | Owner's Manual - Page 108
the UConnect™ system. Check with your cellular service provider for the features that you have. Answer or Reject an Incoming Call - No Call Currently in Progress When you receive a call on your cellular phone, the UConnect™ system will interrupt the vehicle audio system, if on, and will ask if - 2007 Dodge Caravan | Owner's Manual - Page 109
call will be on hold while the second call is in progress. To go back to the first call, refer to Toggling Between Calls. To combine two calls, a single beep. This indicates that the call is on hold. To bring the call back from hold, press and hold the Phone' button until you hear a single beep. - 2007 Dodge Caravan | Owner's Manual - Page 110
on the UConnect™ system either until the call ends or until the vehicle battery condition dictates cessation of the call on the UConnect™ system and transfer of the call is automatically transferred from the UConnect™ system to the mobile phone. • An active call is automatically transferred to the - 2007 Dodge Caravan | Owner's Manual - Page 111
and the mobile phone is reachable: • Pick up the phone and manually dial the emergency number for your area. If the phone is not reachable instruct the paired cellular phone to call the emergency number. This feature is only supported in the USA. NOTE: The emergency number dialed is based - 2007 Dodge Caravan | Owner's Manual - Page 112
based on Working with Automated Systems This method is designed to be used in instances where one generally has to press numbers on the cellular phone keypad while navigating through an automated telephone system. You can use your UConnect™ system to access a voicemail system or an automated service - 2007 Dodge Caravan | Owner's Manual - Page 113
service center menu structure and to leave a number on a pager. Barge In - Overriding Prompts The 'Voice Recognition' button can be used when you wish to skip part Indicators If available on the radio and/or on a premium display such as the instrument panel cluster, and supported by your cell phone, - 2007 Dodge Caravan | Owner's Manual - Page 114
dialing via the cell phone keypad, the user must exercise caution and take precautionary safety measures). By dialing a number with your paired Bluetooth™ cellular phone, the audio will be played through your vehicle's audio system. The UConnect™ system will work the same as if you dial the number - 2007 Dodge Caravan | Owner's Manual - Page 115
YOUR VEHICLE 115 Information Service When using AT&T Wireless Service, dialing to phone number the UConnect™ system, then follow the instruction described in your cellular phone user's manual. List Paired Cellular Phone Names • Press for an alternate way to "select" or "delete" a paired phone. 3 - 2007 Dodge Caravan | Owner's Manual - Page 116
list is being played and then choose the phone you wish to delete. Things You Should Know About Your UConnect™ System Voice Training For users experiencing difficulty with the system recognizing their voice commands or numbers, the UConnect system Voice Training feature may be used. To enter this - 2007 Dodge Caravan | Owner's Manual - Page 117
From outside the UConnect mode (e.g. from radio mode), • Press and hold the ' best results, the Voice Training session should be completed when the vehicle is parked, engine running, all windows closed, and the blower fan switched off. This procedure may be repeated with a new user condition. 3 - 2007 Dodge Caravan | Owner's Manual - Page 118
dialing number combinations may not be supported. Far End Audio Performance • Audio quality is maximized under: • low-to-medium blower setting, • low-to-medium vehicle speed, • low road noise, • smooth road surface, • fully closed windows, and • dry weather condition. • Operation from driver seat. - 2007 Dodge Caravan | Owner's Manual - Page 119
rely on the phone and network, and not the UConnect™ system. • Echo at far end can sometime be reduced by lowering the in-vehicle audio volume. Bluetooth Communication Link Occasionally, Cellular phones have been found to lose connection to the UConnect™ system. When this happens, the connection can - 2007 Dodge Caravan | Owner's Manual - Page 120
120 UNDERSTANDING THE FEATURES OF YOUR VEHICLE - 2007 Dodge Caravan | Owner's Manual - Page 121
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 121 3 - 2007 Dodge Caravan | Owner's Manual - Page 122
122 UNDERSTANDING THE FEATURES OF YOUR VEHICLE - 2007 Dodge Caravan | Owner's Manual - Page 123
is subject to the following conditions: • This device may not cause harmful interference. • This device must accept any interference received, including interference that may cause undesired operation. SEATS Manual Front & Second Row Seat Adjuster The adjusting bar is located under the front of the - 2007 Dodge Caravan | Owner's Manual - Page 124
movement of the seat could cause you to lose control. The seat belt might not be properly adjusted and you could be injured. 8-Way Driver's Power Seat - If Equipped The driver's power seat switches are located on the outboard side of the seat. The front switch controls up/down, forward/rearward - 2007 Dodge Caravan | Owner's Manual - Page 125
or impede its ability to move as it may cause damage to the seat controls. Seat travel may become limited if movement is stopped by an obstruction in the seat's path. Adjustable Head Restraints - If Equipped Head restraints can reduce the risk of whiplash injury in the event of impact from the rear - 2007 Dodge Caravan | Owner's Manual - Page 126
- If Equipped This feature heats the front driver and passenger seats. The controls for the heated seats are located on the instrument panel above the radio. You may choose LOW, HIGH or No Heat. The switch position as well as an indicator light will show when the LOW or HIGH heat is ON. WARNING - 2007 Dodge Caravan | Owner's Manual - Page 127
slightly, lift the lever, then push back to the desired position and release the lever. Lean forward and lift the lever to return the seatback to its normal position. Using body pressure, lean forward and rearward on the seat to be sure the seatback has latched. 3 Manual Reclining Seat Control - 2007 Dodge Caravan | Owner's Manual - Page 128
collision you could slide under the seat belt and be seriously or fatally injured. Use the recliner only when the vehicle is parked. Manual Lumbar - If Equipped The lumbar adjustment handle is located inboard under the armrest. To increase the support, rotate the handle down. Manual Lumbar Control - 2007 Dodge Caravan | Owner's Manual - Page 129
THE FEATURES OF YOUR VEHICLE 129 Middle Rear Bench Seat Recline - If Equipped Pull up on the handle located on the side of the seat to release the seatback. This allows the seatback to be either reclined or folded forward. Stow 'n Go Seating - If Equipped On vehicles equipped with Stow 'n Go - 2007 Dodge Caravan | Owner's Manual - Page 130
Second Row Seats 1. Lower the head restraint and raise the armrests on the second row seat. 2. Slide storage bin locking mechanism to the Locked position and then pull up on the storage bin latch to open cover. Storage Bin Cover Lock Release 3. Pull up on the seatback recliner lever located on the - 2007 Dodge Caravan | Owner's Manual - Page 131
3 Second Row Seatback Release Lever Second Row Seat Release Strap NOTE: The cupholder must be in the closed position before the seat can be tumbled into the floor. 4. Pull rearward on the release strap located at the rear of the seat and tumble the seat forward into the storage bin. 5. Close the - 2007 Dodge Caravan | Owner's Manual - Page 132
locking mechanism to the Locked position and then pull up on the storage bin latch to open cover. 2. Pull up on the handle to lift the seat out of the storage bin and push the seat rearward to latch the seat anchors. Second Row Seat Release Handle 3. Pull up on the seatback recliner lever located - 2007 Dodge Caravan | Owner's Manual - Page 133
133 2. Pull release strap marked "1" located on the rear of the seat to lower the seatback. 3 Second Row Seatback Release Lever 4. Close the storage bin cover and adjust the head restraint to the desired position. To Fold Third Row Seats 1. Lower the head restraint to its full down position - 2007 Dodge Caravan | Owner's Manual - Page 134
Pull release strap marked "2" to release the anchors. Third Row Seat Release Strap 3 Third Row Seatback Release Strap 2 To Unfold Third Row Seats 1. Pull up on the assist strap to lift the seat out of the storage bin and push the seat forward until the anchors latch. 4. Pull release strap marked - 2007 Dodge Caravan | Owner's Manual - Page 135
FEATURES OF YOUR VEHICLE 135 3 Third Row Seatback Lift Assist Strap Third Row Seat Release Strap 3 2. Pull release strap marked "1" to unlock the recliner. 3. Pull release strap marked "3" to return the seatback to its full upright position. 4. Adjust the head restraint to the desired position. - 2007 Dodge Caravan | Owner's Manual - Page 136
THE FEATURES OF YOUR VEHICLE WARNING! In a collision, you or others in your vehicle could be injured if seats are not properly latched to their floor attachments. Always be sure the seats are fully latched. Tailgate Mode 1. Pull release strap "2", then pull release strap "3" to rotate the entire - 2007 Dodge Caravan | Owner's Manual - Page 137
forward for easy access to the third row seat or rear cargo area. To tilt the seat on vehicles equipped with quad seats, pull up on the release handle located on the outboard side of the seat and tilt the seat fully forward. To return the seat, lower the seat and ensure that it is fully latched - 2007 Dodge Caravan | Owner's Manual - Page 138
FEATURES OF YOUR VEHICLE To tilt the seat on vehicles equipped with Stow 'n Go seating, pull forward on the release strap located on the front of the seat between the seat back and seat cushion and tilt the seat fully forward. To return the seat, lower the seat and ensure that it is fully latched - 2007 Dodge Caravan | Owner's Manual - Page 139
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 139 3 Seatback Release Lever Seat Release Handle 4. Pull up on the release handle and tumble the seat fully forward. - 2007 Dodge Caravan | Owner's Manual - Page 140
THE FEATURES OF YOUR VEHICLE 5. Pull the release bar located at the bottom front edge of the seat to disengage the front attachments. To reinstall the seat, remove any obstructions from the floor in front of the seat and ensure the head restraint is in its full downward position. Align the - 2007 Dodge Caravan | Owner's Manual - Page 141
THE FEATURES OF YOUR VEHICLE 141 50/50 Fold & Tumble Rear Seat Removal 1. Lower the head restraint and pull up on release lever "1" to fold the seatback down. 2. Pull up on release lever "2" and tumble the seat fully forward. 3 50/50 Seat Release Lever 2 Location 50/50 Seat Release Lever - 2007 Dodge Caravan | Owner's Manual - Page 142
THE FEATURES OF YOUR VEHICLE 3. Pull the release strap "3" located at the bottom of the seat to disengage the front attachments. To reinstall the 50/50 rear seat, lower the head restraint to the full down position, tilt the seat forward and engage the front floor attachments, then tilt the - 2007 Dodge Caravan | Owner's Manual - Page 143
143 2 - Passenger and 3 - Passenger Bench Seats Release levers are located on the rear leg assemblies, near the floor. To remove the seat, squeeze each release handle and rotate downwards to deploy the wheels. A lock indicator button pops up when the seat is unlocked. The seat assembly can now be - 2007 Dodge Caravan | Owner's Manual - Page 144
will hold plastic grocery bag handles are built into the seatbacks of all rear seats and some front seats. The floor supports the partial weight of the bagged goods. Grocery Bag Holders Rear-Most Bench Seat The seat position can be adjusted fore and aft to any of three positions - normal (rearward - 2007 Dodge Caravan | Owner's Manual - Page 145
seat may be adjusted to any of 3 positions on its tracks while installed in the vehicle. The bench seat may also be moved to the second seating position or removed from the vehicle. Release Lever Location 3 The release lever is below the seat and is accessible from the front and back of the seat - 2007 Dodge Caravan | Owner's Manual - Page 146
146 UNDERSTANDING THE FEATURES OF YOUR VEHICLE 1. Normal Seating- The 2nd and 3rd row seats are installed. The 3rd row bench seat is in the full rear position on the tracks. 3. Additional Storage- The 2nd and 3rd row seats installed. The 3rd row bench seat is in the full forward position on the - 2007 Dodge Caravan | Owner's Manual - Page 147
either or both seatbacks. With one seatback folded forward, rear seating for another occupant is still provided. Either or both seats may Fold and Tumble forward for more storage space. For maximum storage, remove the head restraint and place on the seat cushion, then fold the seatback over the - 2007 Dodge Caravan | Owner's Manual - Page 148
located behind the seat on seating position. Either or both of the rear seats are removed from the vehicle. The same lever is used to return the seatback to the upright position. NOTE: The head restraints are removable, if needed. To remove them, press the release tab on the right side of the base - 2007 Dodge Caravan | Owner's Manual - Page 149
injured or killed. • Do not allow people to ride in any area of your vehicle that is not equipped with seats and seat belts. • Be sure everyone in your vehicle is in a seat and using a seat belt properly. TO OPEN AND CLOSE THE HOOD To open the hood, two latches must be released. First pull the - 2007 Dodge Caravan | Owner's Manual - Page 150
OF YOUR VEHICLE Next, push to the left the safety catch located under the front edge of the hood, near the center. Be sure all hood latches are fully latched before driving. LIGHTS All of the lights, except the hazard warning lights, are controlled by switches to the left of the steering column on - 2007 Dodge Caravan | Owner's Manual - Page 151
turns on all instrument panel lighting. Headlight Switch 3 Interior Lights Interior lights are turned on when a door or liftgate is opened, the keyless entry transmitter is activated, or when the dimmer control is moved to the extreme top. The interior lights will automatically turn off in about - 2007 Dodge Caravan | Owner's Manual - Page 152
the brightness of the instrument panel lights. Interior light Defeat (OFF) Rotate the dimmer control to the OFF position (extreme bottom). The interior lights will remain off when the doors or liftgate are open. Dome Light Position Rotate the dimmer control completely upward to the second detent - 2007 Dodge Caravan | Owner's Manual - Page 153
will sound when the driver's door is opened. Battery Protection This feature provides battery protection to avoid wearing down the battery if the headlights, park lights, or front fog lights are left on for extended periods of time when the ignition switch is in the LOCK position. After 3 minutes of - 2007 Dodge Caravan | Owner's Manual - Page 154
AUTO, the lights will turn off automatically until the next cycle of the ignition switch or headlight switch. The battery protection feature will be disabled if the ignition switch is turned to any other position other than LOCK If the headlights or park lights are turned back on or the ignition - 2007 Dodge Caravan | Owner's Manual - Page 155
Signals Move the Multifunction Lever up or down and the arrows on each side of the base instrument cluster or Information Center flash to indicate proper operation of the front and rear turn signal lights. You can signal a lane change by moving the lever partially up or down. If either indicator - 2007 Dodge Caravan | Owner's Manual - Page 156
wheel to switch the headlights between HIGH and LOW beam. Passing Light You can signal another vehicle with your headlights by lightly pulling the multifunction lever toward the steering wheel to the wiper motor may occur. Windshield Wiper/Washer Control To use the washer, press the end of the - 2007 Dodge Caravan | Owner's Manual - Page 157
OFF position, the wipers will operate for approximately two wipe cycles, then turn OFF. Intermittent Wiper System Use the intermittent wipers when weather conditions make a single wiping cycle, with a variable pause between cycles, desirable. Rotate the end of the lever to the first detent position - 2007 Dodge Caravan | Owner's Manual - Page 158
located behind the turn signal control, toward you and move the wheel up or down, as desired. Release the lever to lock the wheel locked before driving. TRACTION CONTROL SWITCH - IF EQUIPPED The TRAC indicator, located below the instrument cluster odometer, will light up when the Traction Control - 2007 Dodge Caravan | Owner's Manual - Page 159
you used the switch to turn the system OFF. • The Traction Control will make buzzing or clicking sounds when in operation. REAR PARK SENSE SYSTEM while it is backing up in addition to the use of inside rearview and outside mirrors. 3 Traction Control Switch To turn the system back ON, press the - 2007 Dodge Caravan | Owner's Manual - Page 160
160 UNDERSTANDING THE FEATURES OF YOUR VEHICLE When the driver selects Reverse the system scans for objects behind the vehicle using four sensors located in the rear bumper. Objects can be detected from up to 59 inches (150 cm). A warning display above the rear window provides both visible and - 2007 Dodge Caravan | Owner's Manual - Page 161
None None None None None at 12 in. (30 cm) Intermittent at 8 in. (20 cm) Continuous 3 NOTE: The Rear Park Sense System will MUTE the radio, if on, when the audible warning is activated. - 2007 Dodge Caravan | Owner's Manual - Page 162
or blind spots before backing up. You are responsible for the safety of your surroundings and must continue to pay attention while backing up. Failure to be temporarily detected or not detected at all. Obstacles located above or below the sensors will not be detected when they are in close proximity - 2007 Dodge Caravan | Owner's Manual - Page 163
allows both the brake and accelerator pedals to move toward or away from the driver to provide improved position with the steering wheel. The adjustable pedal system is designed to allow a greater range of driver comfort for steering wheel tilt and seat position. The switch is located on the right - 2007 Dodge Caravan | Owner's Manual - Page 164
(EVIC) if the pedals are attempted to be adjusted when the system is locked out ("Adjustable Pedal Disabled - Cruise Control Engaged" or "Adjustable Pedal Disabled - Vehicle In Reverse"). ELECTRONIC SPEED CONTROL - IF EQUIPPED When engaged, this device takes over the accelerator operation at speeds - 2007 Dodge Caravan | Owner's Manual - Page 165
once and the CRUISE indicator located below the instrument cluster odometer will illuminate showing the electronic speed control system is on. To turn tap on the brake pedal, pushing the "CANCEL" button or normal braking while slowing the vehicle will deactivate the speed control without erasing the - 2007 Dodge Caravan | Owner's Manual - Page 166
increase speed by 6 mph (10 km/h), etc. To decrease speed while speed control is set, press and hold the "COAST" button. Release the button when the released, the vehicle will return to the set speed. NOTE: The speed control system maintains speed up and down hills. A slight speed change on moderate - 2007 Dodge Caravan | Owner's Manual - Page 167
the conditions, and you could lose control. An accident could be the result. Don't use Speed Control in door switches and an optional power liftgate switch. 3 Overhead Console NOTE: To avoid unintentional operation of the power sliding doors from the rear seats, press the ON /OFF button located - 2007 Dodge Caravan | Owner's Manual - Page 168
console. This light is turned on when the headlight switch is on and will adjust in brightness when the dimmer control is rotated up or down. Sunglass Storage At the rear of the overhead console, a compartment is provided for the storage of two pair of sunglasses. Press the door latch to open - 2007 Dodge Caravan | Owner's Manual - Page 169
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 169 Automatic Compass Calibration This compass is self calibrating which eliminates the need to manually set the compass. When the vehicle is new, the compass may the vicinity of the compass. Do not use magnetic tools when servicing the overhead console. 3 - 2007 Dodge Caravan | Owner's Manual - Page 170
170 UNDERSTANDING THE FEATURES OF YOUR VEHICLE Compass Variance Compass Variance is the difference between magnetic North and Geographic North. In some areas of the country, the difference between magnetic and geographic North is great enough to cause the compass to give false readings. If this - 2007 Dodge Caravan | Owner's Manual - Page 171
button for approximately 5 seconds. On vehicles equipped with Compass/Temp press and hold the C/T and US/M buttons for 5 seconds. The "VAR" symbol will light and the last variance zone number will be displayed. Press the STEP button on vehicles equipped with a Compass/ Mini Trip Computer or the US - 2007 Dodge Caravan | Owner's Manual - Page 172
If Equipped The Electronic Vehicle Information Center, when the appropriate conditions exist, displays the following WARNING messages and symbols. Each message is accompanied by a single chime: • TURN SIGNALS ON (with graphic) • PERFORM SERVICE • DOOR AJAR (one or more, with graphic) • LIFTGATE AJAR - 2007 Dodge Caravan | Owner's Manual - Page 173
System" in the "Starting And Operating, Tire Section") • MEMORY SEAT DISABLED (Not in Park) - If Equipped • ADJUSTABLE GAGED PEDAL DISABLED feature is selected the system scans for objects behind the vehicle using four sensors located in the rear bumper. Objects can be detected from up to 59 inches - 2007 Dodge Caravan | Owner's Manual - Page 174
overhead console and climate control displays will be in the selected units. Service Interval When this feature is selected a service interval between 2,000 your own personal preferences. Auto Door Locks When this feature is selected, all doors and the liftgate lock automatically when the speed of - 2007 Dodge Caravan | Owner's Manual - Page 175
set positions. If this feature is not selected, the driver's seat, driver's mirror, adjustable pedals, and radio settings can only return to their memory set positions using the memory recall buttons (1 or 2) on the driver's door panel. Any transmitter linked to memory will remain linked, but will - 2007 Dodge Caravan | Owner's Manual - Page 176
with or without the sound horn on lock feature selected. Pressing the "STEP" button when in this display will select "Yes" or "No." Sliding Door Open Flash? When this feature is selected, and the sliding door(s) are opened, the left and right exterior hazard lights will flash for 12 seconds to alert - 2007 Dodge Caravan | Owner's Manual - Page 177
to three remote controls (hand held transmitters) that operate devices such as garage door openers, motorized gates, or home lighting. It triggers these devices at the push of a button. The Universal Transceiver operates off your vehicle's battery and charging system; no batteries are needed. NOTE - 2007 Dodge Caravan | Owner's Manual - Page 178
HomeLink NOTE: When programming a garage door opener, it is advised to park outside the garage. Some vehicles may require the ignition switch to be turned to the second (Accessory) position for programming and/or operation of HomeLink. It is also recommended that a new battery be placed in the hand - 2007 Dodge Caravan | Owner's Manual - Page 179
Step Four has been completed. NOTE: Some gate operators and garage door openers may require you to replace this Programming Step 3 with the just trained HomeLink button and observe the indicator light or the EVIC display. If the indicator light stays on constantly, programming is complete and your - 2007 Dodge Caravan | Owner's Manual - Page 180
system (rolling code system). If your garage door is the "rolling code" type, please proceed to the heading "Programming A Rolling Code System." Programming A Rolling Code System 1. At the garage door opener receiver (motor-head unit) in the garage, locate the learn or smart button. This can usually - 2007 Dodge Caravan | Owner's Manual - Page 181
YOUR VEHICLE 181 Canadian Programming/Gate Programming Canadian radio-frequency laws require transmitter signals to time-out now occur for the trained device (i.e. garage door opener, gate operator, security system, entry door lock, home/office lighting, etc.). For convenience, the hand-held - 2007 Dodge Caravan | Owner's Manual - Page 182
2. The indicator light will begin to instructions in this section. This device complies with part 15 of FCC rules and with RSS-210 of Industry Canada. Operation is subject to the following conditions user's authority to operate the equipment. HomeLink is a trademark owned by Johnson Controls, Inc. - 2007 Dodge Caravan | Owner's Manual - Page 183
or 1-800-355-3515. POWER SUNROOF - IF EQUIPPED The power sunroof control is located between the sun visors on the overhead console. Press and hold the the Express Open Feature, causing the sunroof to open automatically. Press and hold the button located to the right of the sunroof switch, to open - 2007 Dodge Caravan | Owner's Manual - Page 184
partial open condition until the switch is pushed forward again. The sunshade can be opened manually. It seat belt properly and make sure all passengers are properly secured too. Do not allow small children to operate the sunroof. Never allow fingers or other body parts controls, or move the vehicle - 2007 Dodge Caravan | Owner's Manual - Page 185
outlet is located on the driver's side, just to the rear of the sliding door and is also controlled by the battery symbol indicating the power source. The lower instrument panel outlet is powered directly from the battery, items plugged into this outlet may discharge the battery and/or prevent engine - 2007 Dodge Caravan | Owner's Manual - Page 186
, if plugged in long enough, the vehicle's battery will discharge sufficiently to degrade battery life and/or prevent engine starting. • Accessories that draw higher power (i.e. coolers, vacuum cleaners, lights, etc.), will degrade the battery even more quickly. Only use these intermittently and - 2007 Dodge Caravan | Owner's Manual - Page 187
OF YOUR VEHICLE 187 CONVENIENCE TRAY DRAWER AND CUP HOLDERS Instrument Panel Cup Holders The instrument panel cupholders are located in a pull out drawer just below the climate controls. When the drawer is pulled out firmly, the arms of the cupholders will spring out. Place the container to - 2007 Dodge Caravan | Owner's Manual - Page 188
are also dual underseat cupholders for the 2nd seat passengers. With a bench seat in the 2nd seat position these cupholders slide out from under the center of the seat. If your vehicle is equipped with quad seats in the 2nd seat position, these cupholders are located on the outboard side of the - 2007 Dodge Caravan | Owner's Manual - Page 189
place. • The floor mat must be in position for optimum cupholder operation. There are also two cupholders and a flat tray on the seat back of the quad seats. These can be used when the seat back is folded forward. 3 Quad Seat Cupholder NOTE: • The quad seat cupholders will remain upright if the - 2007 Dodge Caravan | Owner's Manual - Page 190
FEATURES OF YOUR VEHICLE STORAGE Front Seat Storage Bin - If Equipped The storage bin is located under the front passenger's seat. If equipped with a lock, it can be locked with the ignition key. Second Row Seat Storage bins - If Equipped The Seat Storage Bins are located on the floor in front of - 2007 Dodge Caravan | Owner's Manual - Page 191
to the Unlocked position to allow greater access to the storage bin. CAUTION! NOTE: The storage bin cover must be locked and flat to avoid damage from contact with the front seat tracks, which have minimal clearance to the cover. Overhead Rail System - If Equipped The overhead rail system contains - 2007 Dodge Caravan | Owner's Manual - Page 192
UNDERSTANDING THE FEATURES OF YOUR VEHICLE To Remove Storage Bins 1. Support the bin with one hand and pull the latch handles out. rail. To reinstall the storage bins, place the bin in the desired location on the overhead rail, push firmly upward on the bin with one hand, while pushing in on the - 2007 Dodge Caravan | Owner's Manual - Page 193
down to lock the storage bin in place. 1. Open the console lid and remove the storage tray. 2. Pull up on the release handle located inside the Console With Stow 'n Go Seating - If Equipped The removable floor console has a two power outlets, storage tray, light, removable cell phone holder, - 2007 Dodge Caravan | Owner's Manual - Page 194
either the front seats or middle seats. NOTE: When the console is located between the front seats the outlet is protected by an automatic circuit breaker and is powered directly from the battery, items plugged into this outlet may discharge the battery and/or prevent engine starting. WARNING! In - 2007 Dodge Caravan | Owner's Manual - Page 195
Handle To remove the console use the following procedure: 1. Open the rear lid and remove the storage tray. 2. Pull up on the release handle located inside the floor console to disengage the floor console, reinstall the storage tray and close the rear lid. 3. Using the front and rear grab handles - 2007 Dodge Caravan | Owner's Manual - Page 196
reinstall the console, remove the rubber mat and relocate to the alternate floor tray, slide the console forward to engage the front of is fully latched. NOTE: When the removable floor console is located between the middle seats, the power outlet only has power supplied to it when the ignition switch - 2007 Dodge Caravan | Owner's Manual - Page 197
, if plugged in long enough, the vehicle's battery will discharge sufficiently to degrade battery life and/or prevent engine starting. • Accessories that draw higher power (i.e. coolers, vacuum cleaners, lights, etc.), will degrade the battery even more quickly. Only use these intermittently and - 2007 Dodge Caravan | Owner's Manual - Page 198
row storage bin or the third row tub. The net is supported by hooks located in these areas. Refer to instructions provided in the net kit. Coat Hooks Coat hooks are located along the headliner for the second and third row seating positions. The coat hook load limit is 10 lbs (4.5 kg). Exceeding - 2007 Dodge Caravan | Owner's Manual - Page 199
UNDERSTANDING THE FEATURES OF YOUR VEHICLE 199 3 Rear Cargo Area Loading Limit Roof Rack ROOF LUGGAGE RACK - IF EQUIPPED The crossbars and siderails are designed to carry the weight on vehicles equipped with a luggage rack. The load must not exceed 68 kg (150 lbs), and should be uniformly - 2007 Dodge Caravan | Owner's Manual - Page 200
VEHICLE To move the cross bars, loosen the thumb screws located at the upper edge of each cross bar approximately six the thumb screws to lock the cross bar into position. Attempt to move the crossbar again to ensure that it has properly locked into position. NOTE: To help control wind noise when - 2007 Dodge Caravan | Owner's Manual - Page 201
LOAD LEVELING SYSTEM The automatic load leveling system will provide a level riding vehicle under most passenger and cargo loading conditions. A hydraulic pump vehicles that are not equipped with Anti-Lock Brakes. Vehicles without Anti-Lock Brakes (ABS) have a height-sensing proportioning valve. - 2007 Dodge Caravan | Owner's Manual - Page 202
- 2007 Dodge Caravan | Owner's Manual - Page 203
...221 ▫ FM Reception ...221 Sales Code RAZ - AM/ FM Stereo Radio With Cassette Tape Player, CD Player And CD Changer Controls ...222 ▫ Operating Instructions - Radio ...222 ▫ Power Switch, Volume Control ...222 ▫ Seek Button (Radio Mode) ...222 ▫ Tuning ...223 ▫ Radio Data System (RDS) ...223 4 - 2007 Dodge Caravan | Owner's Manual - Page 204
Type) Button ...223 ▫ Balance ...225 ▫ Fade ...225 ▫ Tone Control ...225 ▫ AM/FM Selection ...225 ▫ Scan Button ...225 ▫ To Set The Radio Push-Button Memory ...226 ▫ To Change From Clock To Radio Mode ...226 ▫ Operating Instructions - Tape Player ...226 ▫ Seek Button ...226 ▫ Fast Forward (FF - 2007 Dodge Caravan | Owner's Manual - Page 205
With CD Player And CD/DVD Changer Controls ...232 ▫ Radio Operation ...233 ▫ CD Player Operation ...237 ▫ CD/DVD Changer Operation ...238 ▫ Notes On Playing MP3 Files ...239 ▫ Operation Instructions - (CD Mode For MP3 Audio Play) ...241 ▫ Operating Instructions - MP3 Player, Portable Walkman ...242 - 2007 Dodge Caravan | Owner's Manual - Page 206
...262 ▫ Remote Control Operating Instructions ...262 ▫ Operating Instructions - Video Screen ...266 ▫ Operating Instructions - Headphones ...268 ▫ Operating Instructions - MP3 Player, Portable Walkman ...270 ▫ Operating Instructions - Video Games/Camcorders ...270 Satellite Radio - If Equipped - 2007 Dodge Caravan | Owner's Manual - Page 207
CD/DVD Disc Maintenance ...277 Climate Controls ...278 ▫ Manual Air Conditioning And Heating System ...278 ▫ Front Mode Control ...280 ▫ Manual Air Conditioning Operation ...284 ▫ Manual Rear Zone Climate Control - If Equipped ...286 ▫ Automatic Temperature Control - If Equipped ...289 Rear Window - 2007 Dodge Caravan | Owner's Manual - Page 208
208 UNDERSTANDING YOUR INSTRUMENT PANEL INSTRUMENT PANELS AND CONTROLS - 2007 Dodge Caravan | Owner's Manual - Page 209
UNDERSTANDING YOUR INSTRUMENT PANEL 209 BASE INSTRUMENT CLUSTER 4 - 2007 Dodge Caravan | Owner's Manual - Page 210
210 UNDERSTANDING YOUR INSTRUMENT PANEL INSTRUMENT CLUSTER WITH TACH - 2007 Dodge Caravan | Owner's Manual - Page 211
UNDERSTANDING YOUR INSTRUMENT PANEL 211 INSTRUMENT CLUSTER DESCRIPTIONS 1. Fuel Gauge The pointer shows the level of fuel in the fuel tank when the ignition switch is in the ON position. 2. Tire Pressure Monitoring Telltale Lamp - If Equipped Each tire, including the spare (if provided), should be - 2007 Dodge Caravan | Owner's Manual - Page 212
the fault condition is removed and reset. 3. Low Fuel Light When the fuel level reaches approximately 3.0 gallons (11.0 liters) this light will turn sensor damage may result when using replacement equipment that is not of the same size, type, and / or style. Aftermarket wheels can cause sensor - 2007 Dodge Caravan | Owner's Manual - Page 213
during sharp cornering maneuvers which change fluid level conditions. The vehicle should have service performed. If brake failure is indicated, immediate repair is necessary. 4 WARNING! Driving a vehicle with the brake light on is dangerous. Part of the brake system may have failed. It will take - 2007 Dodge Caravan | Owner's Manual - Page 214
ON position and may stay on for as long as four seconds. If the ABS light remains on or turns on while driving, it indicates that the Anti-Lock portion of the brake system is not functioning and that service is required. However, the conventional brake system will continue to operate normally if the - 2007 Dodge Caravan | Owner's Manual - Page 215
should turn on momentarily as the engine is started. If the light stays on or turns on while driving, it indicates a problem with the charging system. Immediate service should be obtained. 13. Seat Belt Reminder Light When the ignition switch is first turned ON, this light will turn on for 5 to - 2007 Dodge Caravan | Owner's Manual - Page 216
and stop the vehicle. Idle the vehicle with the air conditioner turned off until the pointer drops back into the normal range. If the pointer remains on the "H", and you hear continuous chimes, turn the engine off immediately, and call for service. 16. Temperature Gauge The temperature gauge shows - 2007 Dodge Caravan | Owner's Manual - Page 217
display indicator shows the automatic transaxle gear selection. NOTE: You must apply the brakes before shifting from Park. 19. Oil Pressure Warning Light This light shows low engine oil pressure. The light should turn on momentarily when the engine is started. If the light turns on while driving - 2007 Dodge Caravan | Owner's Manual - Page 218
Light This light is part of an onboard diagnostic system called OBD that monitors engine and automatic transmission control systems. The light will illuminate when the key is in the ON position before engine start. If the bulb does not come when turning the key from OFF to ON, have the condition - 2007 Dodge Caravan | Owner's Manual - Page 219
system and is a normal condition. The system will remain disabled for about 4 minutes until the brakes have cooled. The system will automatically reactivate and turn off the TRAC and the OFF indicators. If your vehicle becomes stuck in mud, ice, or snow, turn the Traction Control System OFF before - 2007 Dodge Caravan | Owner's Manual - Page 220
time setting will increase each time you press a button. RADIO GENERAL INFORMATION Radio Broadcast Signals Your new radio will provide excellent reception under most operating conditions. Like any system, however, car radios have performance limitations, due to mobile operation and natural phenomena - 2007 Dodge Caravan | Owner's Manual - Page 221
. FM Reception Because FM transmission is based on frequency variations, interference that consists of amplitude variations can be filtered out, leaving the reception relatively clear, which is the major feature of FM radio. NOTE: The radio, steering wheel radio controls (if equipped), and 6 disc CD - 2007 Dodge Caravan | Owner's Manual - Page 222
WITH CASSETTE TAPE PLAYER, CD PLAYER AND CD CHANGER CONTROLS NOTE: The radio sales code is located on the lower left side of your radio faceplate. Operating Instructions - Radio NOTE: Power to operate the radio is controlled by the ignition switch. It must be in the ON or ACC position to operate - 2007 Dodge Caravan | Owner's Manual - Page 223
the button is pressed. Radio Data System (RDS) The Radio Data System allows radio broadcasting stations to send data signals on a subcarrier frequency which is added to the stereo signal. RDS was developed to give FM receivers user-friendly features, such as Program Service name (PS) and Program - 2007 Dodge Caravan | Owner's Manual - Page 224
name. The PTY function only operates when in the FM mode. The radio display will flash "SEEK" and the selected PTY program type when searching station. If no station is found with the selected PTY program type, the radio will return to the last preset station. If a preset button is activated while - 2007 Dodge Caravan | Owner's Manual - Page 225
out. Adjust the balance and push the button back in. The balance will be displayed and continuously updated while the button is turned. Fade The Fade control provides for balance between the front and rear speakers Pressing the AM/FM button continues the search in the alternate frequency band. 4 - 2007 Dodge Caravan | Owner's Manual - Page 226
locked into memory. You can recall the stations stored in SET 2 memory by pressing the pushbutton twice. To Change From Clock To Radio Mode Press the Time button to change the display between radio frequency and time. Operating Instructions Clean and demagnetize the tape heads at least twice a year. - 2007 Dodge Caravan | Owner's Manual - Page 227
the EJT Tape button and the cassette will disengage and eject from the radio. Scan Button Press this button to play 10 seconds of each selection. of tape travel (side being played), press the PTY button. The lighted arrow in the display window will show the new direction. Metal Tape Selection - 2007 Dodge Caravan | Owner's Manual - Page 228
insert the tape. The NR light in the display will go off when the Dolby System is off. The Dolby System is automatically reactivated each time a tape is Corporation. Operating Instructions - CD Player NOTE: The ignition switch must be in the ON or ACC position and the volume control ON before the - 2007 Dodge Caravan | Owner's Manual - Page 229
YOUR INSTRUMENT PANEL 229 If the volume control is ON, the unit will switch from radio to CD mode and begin to or ACC position to insert a disc with the radio OFF. • If you insert a disc with the ignition ON and the radio OFF, the CD will automatically be pulled into the CD Player and the display - 2007 Dodge Caravan | Owner's Manual - Page 230
begin to fast forward until FF is released. The RW (Reverse) button works in a similar manner. Program Button 4 (Random Play) Press this button while between the tape player, CD player, or satellite radio (if equipped). To select Satellite Radio (if equipped), press the MODE button until the word - 2007 Dodge Caravan | Owner's Manual - Page 231
Control Capability - If Equipped This radio is compatible with a remote mounted CD changer available through Mopar Accessories. The following instructions are for the radio controls . Press and hold the RW button for fast reverse. The audio output can be heard when fast forward and fast reverse are - 2007 Dodge Caravan | Owner's Manual - Page 232
. Skipping will not damage the disc or the player, and play will resume automatically. As a safeguard and to protect your CD player, one of the following REV - AM & FM STEREO RADIO WITH CD PLAYER AND CD/DVD CHANGER CONTROLS NOTE: The radio sales code is located on the lower left side of your - 2007 Dodge Caravan | Owner's Manual - Page 233
button to select the following format types: Program Type Adult Hits Classical Classic Rock College Radio Display Adult Hit Classical Classic Rock College Radio Operation Power/Volume Control Press the ON/VOL control to turn the radio on. Turn the volume control clockwise to increase the volume. - 2007 Dodge Caravan | Owner's Manual - Page 234
only operates when in the FM and Satellite (if equipped) modes. The radio display will flash "SEEK" and the selected PTY program type when searching station. If no station is found with the selected PTY program type, the radio will return to the last preset station. If a preset button is activated - 2007 Dodge Caravan | Owner's Manual - Page 235
press and hold the button, the radio will continue to tune until you release the button. The frequency will be displayed and continuously updated while the button is pressed. Balance The Balance control adjusts the left-to-right speaker balance. Press the AUDIO button, select BALANCE, then press - 2007 Dodge Caravan | Owner's Manual - Page 236
stations to be locked into memory. You can recall the stations stored in SET 2 memory by pressing the pushbutton twice. To Change From Clock To Radio Mode Press the TIME button to change the display between radio frequency and time. General Information This radio complies with Part 15 of FCC rules - 2007 Dodge Caravan | Owner's Manual - Page 237
PANEL 237 CD Player Operation NOTE: • The ignition switch must be in the ON or ACC position and the volume control ON before the CD player will operate. • This Radio is capable of playing compact discs (CD), recordable compact discs (CD-R), rewritable compact discs (CD-RW) compact discs with MP3 - 2007 Dodge Caravan | Owner's Manual - Page 238
will continue to appear. The disc can be ejected with the radio OFF. FF/TUNE/RW Press FF (Fast Forward) and the CD player will begin to fast forward until FF is released. The RW (Reverse) button works in a similar manner. RND - Random Play Press the RND button while the CD is - 2007 Dodge Caravan | Owner's Manual - Page 239
and a 3 character extension) • Level 2: 31 (including a separator . and a 3 character extension) Multisession disc formats are supported by the radio. Multisession discs may contain combinations of normal CD audio tracks and computer files (including MP3 files). Discs created with an option such as - 2007 Dodge Caravan | Owner's Manual - Page 240
problems. The radio is designed to recognize the file as an invalid MP3 and will not play the file. When using the MP3 encoder to compress audio are supported for version 1 ID3 tags. ID3 version 2 is not supported by the radios. Playlist files are not supported. MP3 Pro files are not supported. - 2007 Dodge Caravan | Owner's Manual - Page 241
the Disc at Once option before writing to the disc. Operation Instructions - (CD Mode For MP3 Audio Play) SEEK Button (CD Mode For MP3 Play) Pressing the side of the button to move back through the MP3 selection. AM/FM Button (CD Mode For MP3 Play) Switches back to Radio mode. RND Button (CD Mode - 2007 Dodge Caravan | Owner's Manual - Page 242
of the Owner's Manual. Operating Instructions - Satellite Radio Mode (If Equipped) Refer to the Satellite Radio section of the Owner's Manual. Operating Instructions - MP3 Player, Portable Walkman An MP3 player can be connected to the audio system. Connect the cables to the RCA jacks located on the - 2007 Dodge Caravan | Owner's Manual - Page 243
refer to the manufacture's instructions for the correct colors when connecting the RCA cables. SALES CODE RBQ - AM/FM STEREO RADIO WITH 6 - DISC CD CHANGER NOTE: The radio sales code is located on the lower left side of your radio faceplate. 1. Video in (yellow) 2. Left audio in (white) 3. Right - 2007 Dodge Caravan | Owner's Manual - Page 244
the button in will bypass stations without stopping until you release it. Tune Press the TUNE control up or down to increase or decrease the frequency. If the button is pressed and held, the radio will continue to tune until the button is released. The frequency will be displayed and continuously - 2007 Dodge Caravan | Owner's Manual - Page 245
12 FM stations to be locked into push-button memory. The stations stored in SET 2 memory can be selected by pressing the corresponding push-button twice. Every time a preset button is used, a corresponding button number will be displayed. Audio The audio button controls the BASS, TREBLE, BALANCE - 2007 Dodge Caravan | Owner's Manual - Page 246
Press the TIME button to change the display between radio frequency and time. General Information This radio complies with Part 15 of FCC rules and with RSS-210 of Industry Canada. Operation is subject to the following conditions: 1. This device may not cause harmful interference, 2. This device - 2007 Dodge Caravan | Owner's Manual - Page 247
and the button with the corresponding number where the CD was loaded and the disc will unload and move to the entrance for easy removal. Radio display will show "ejecting" when it is being ejected. If you have ejected a disc and have not removed it within 15 seconds, it will be - 2007 Dodge Caravan | Owner's Manual - Page 248
player will begin to fast forward until FF is released. The RW (Reverse) button works in a similar manner. Random Play - SET / RND Press the RND button seconds will allow the program format type to be selected. Many radio stations do not currently broadcast PTY information. Toggle the PTY button - 2007 Dodge Caravan | Owner's Manual - Page 249
name. The PTY function only operates when in the FM mode. The radio display will flash "SEEK" and the selected PTY program type when searching PTY station. If no station is found with the selected PTY program type, the radio will return to the last station. If a preset button is activated while in - 2007 Dodge Caravan | Owner's Manual - Page 250
the TIME button to change the display from elapsed CD playing time to time of day. Operating Instructions - Satellite Radio Mode (If Equipped) Refer to the Satellite Radio section of the Owner's Manual. CD Diagnostic Indicators When driving over a very rough road, the CD player may skip momentarily - 2007 Dodge Caravan | Owner's Manual - Page 251
CODE RBK - AM/ FM STEREO RADIO WITH CD PLAYER AND CD CHANGER CONTROLS NOTE: The radio sales code is located on the lower left side of your radio faceplate. Radio Operation Power/Volume Control Press the ON/VOL control to turn the radio on. Turn the volume control clockwise to increase the volume - 2007 Dodge Caravan | Owner's Manual - Page 252
is pressed. To Set The Radio Push-Button Memory When you are locked into push-button memory. The stations stored in SET 2 memory can be selected by pressing the push-button twice. Every time a preset button is used a corresponding button number will be displayed. Audio The audio button controls - 2007 Dodge Caravan | Owner's Manual - Page 253
Press the TIME button to change the display between radio frequency and time. General Information This radio complies with Part 15 of FCC rules and with RSS-210 of Industry Canada. Operation is subject to the following conditions: 1. This device may not cause harmful interference, 2. This device - 2007 Dodge Caravan | Owner's Manual - Page 254
You may either insert or eject a disc with the radio OFF. If you insert a disc with the ignition ON and the radio OFF, the display will show the time of day. entrance for easy removal. The unit will switch to the radio mode. If you do not remove the disc within 15 seconds, it will be reloaded. - 2007 Dodge Caravan | Owner's Manual - Page 255
fast forward until FF is released. The RW (Reverse) button works in a similar manner. Random Play - RND/Program Button Control Capability - If Equipped This radio is compatible with a remote mounted CD changer available through Mopar Accessories. The following instructions are for the radio controls - 2007 Dodge Caravan | Owner's Manual - Page 256
fast forward. Press and hold the RW button for fast reverse. The audio output can be heard when fast forward and fast reverse are activated. the changer. Operating Instructions - Satellite Radio Mode (If Equipped) Refer to the Satellite Radio section of the Owner's Manual. CD Diagnostic Indicators - 2007 Dodge Caravan | Owner's Manual - Page 257
down • Damaged disc • Water condensation on optics SALES CODE RB1 - AM/FM STEREO RADIO WITH DVD/GPS NAVIGATION SYSTEM 4 RB1 Radio The Navigation Radio with DVD/GPS provides maps, turn identification, selection menus, instructions for selecting a variety of destinations and routes, and AM/FM - 2007 Dodge Caravan | Owner's Manual - Page 258
and the CD Player simultaneously. Always remove the Navigation DVD before inserting another disc. Operating Instructions - Radio Refer to your "Navigation User's Manual" for detailed operating instructions. Clock Setting Procedure The GPS receiver used in this system is synchronized to the time - 2007 Dodge Caravan | Owner's Manual - Page 259
you location and manually radio speakers. A remote control is provided for functions such as changing tracks or DVD functions, as well as selecting discs loaded in the 6 disc CD/DVD changer while listening to the Rear Audio/Video System. The Rear Seat Audio/Video System may be available in a base - 2007 Dodge Caravan | Owner's Manual - Page 260
turn on automatically once a DVD base version is a single-disc player, and will only accept one disc. To insert disc(s) into the changer, follow the instructions shown: 1. On vehicles equipped with the premium version, select and press any numbered button without an illuminated light - 2007 Dodge Caravan | Owner's Manual - Page 261
and the light below the loading slot will turn off. On vehicles equipped with the premium version the light above the radio volume control is ON, the unit will switch from radio to CD/DVD mode and the video screen will turn on. If the DVD supports the autoplay feature, play will begin automatically - 2007 Dodge Caravan | Owner's Manual - Page 262
premium version multi-disc changer, first select the numbered button where the disc is located and then press the EJT button. Remote Control Operating Instructions NOTE: Aim the remote control at the radio located on the center of the instrument panel and press the desired button. Direct sunlight - 2007 Dodge Caravan | Owner's Manual - Page 263
Buttons 17. Enter 18. Light Headphone Transmitter Button (1) The headphone transmitter button on the remote control and the power button on the headphones must be turned ON before sound can be heard from the headphones. On some radios the headphone symbol will flash for approximately 5 seconds - 2007 Dodge Caravan | Owner's Manual - Page 264
after pressing the STOP button to access the set up menu. Use the right and left arrows to move between tabs for language, rating, mark, audio and aspect. Use the up and down arrows to move between options within each tab. To change an item highlighted in blue, press ENTER. This - 2007 Dodge Caravan | Owner's Manual - Page 265
will begin to fast forward until the FF button is released. The RW (Reverse) button works in a similar manner. ENTER Button (17) This button only functions in DVD video mode. through the menu screen options. Light Button (18) Pressing this button illuminates the buttons on the remote control. 4 - 2007 Dodge Caravan | Owner's Manual - Page 266
266 UNDERSTANDING YOUR INSTRUMENT PANEL Remote Control Battery Service • To replace the batteries for the remote control slide the cover rearward. The replacement batteries for the remote control are two AAA batteries. Operating Instructions - Video Screen Push up on the release button to lower the - 2007 Dodge Caravan | Owner's Manual - Page 267
. 2. Enter Button This button will enter the selection from the on-screen menu. 4 3. Brightness Button Changes the brightness of the screen picture. Video Screen and Controls 1 2 3 4 Screen Width Button Enter Button Brightness Button Video Screen Latch - 2007 Dodge Caravan | Owner's Manual - Page 268
form the system or when the radio or rear audio/video system is turned off. Volume Control Rotate the volume control to adjust the volume to the desired listening level. Headphone Controls 1. Power Button 2. Volume Control 3. Power Indicator Headphone Battery Service • Press the button at the - 2007 Dodge Caravan | Owner's Manual - Page 269
conditions: 1. Rear Seat Audio/Video System and headphones are on. Press the headphone transmitter button (1) on the remote control and the power button on the headphones. An indicator light will illuminate on the headphone earpiece to indicate the headphones are ON. Headphone Battery Service - 2007 Dodge Caravan | Owner's Manual - Page 270
audio system. Connect the cables to the RCA jacks located on the front of the CD/DVD changer. NOTE: Follow the manufactures instructions audio in (white) 3. Right audio in (red) NOTE: MP3 player's, video game systems, camcorders connected to the RCA jacks and CD's or DVD's inserted into the radio - 2007 Dodge Caravan | Owner's Manual - Page 271
and broadcasting studios. System Activation To activate your Sirius Satellite Radio service, call the toll-free number 888-539-7474, or visit RAH and RBK Radios With the ignition switch in the ACCESSORY position and the radio OFF, press the Tape Eject or CD Eject (depending on the radio type) and - 2007 Dodge Caravan | Owner's Manual - Page 272
Radios With the ignition switch in the ACCESSORY position and the radio OFF, press the CD Eject and TIME buttons simultaneously for 3 seconds. All twelve ESN/SID numbers will be displayed. The radio in the radio while in the Satellite radio mode. radio to bypass channels until the button is released - 2007 Dodge Caravan | Owner's Manual - Page 273
or FM pre-set memory stations. Follow the memory pre-set procedures that apply to your radio. Using the PTY (Program Type) Button - If Equipped Follow the PTY button instructions that apply to your radio. PTY Button SCAN When the desired program type is obtained, press the SCAN button within five - 2007 Dodge Caravan | Owner's Manual - Page 274
antenna location or strap such as bikes should be placed audio mutes. • Driving under wide bridges or along tall buildings can cause intermittent reception. • Placing objects over or too close to the antenna can cause signal blockage. RADIO OPERATION AND CELLULAR PHONES Under certain conditions - 2007 Dodge Caravan | Owner's Manual - Page 275
CONTROLS - IF EQUIPPED The remote sound system controls are located on the rear surface of the steering wheel at the 3 and 9 O'clock positions. The right hand rocker switch has a push button in the center and controls of the radio from AM to FM to Tape or CD mode depending on which radio is in the - 2007 Dodge Caravan | Owner's Manual - Page 276
The button located in the center of the left hand switch will tune to the next pre-set station that you have programmed in the radio pre-set TAPE AND PLAYER MAINTENANCE To keep the cassette tapes and player in good condition, take the following precautions: 1. Do not use cassette tapes longer than - 2007 Dodge Caravan | Owner's Manual - Page 277
from direct sunlight, heat and magnetic fields such as the radio speakers. 4. Before inserting a tape, make sure that the condition is low or "muddy" sound from one or both channels, as if the treble tone control were turned all the way down. To prevent this, you should periodically clean the head - 2007 Dodge Caravan | Owner's Manual - Page 278
make you comfortable in all types of weather. Manual Air Conditioning and Heating System Manual Air Conditioning and Heating Controls Front Blower Control The Front Blower Control selects whether the Climate Control System is ON or OFF. When the blower control is set to the O (OFF) position the - 2007 Dodge Caravan | Owner's Manual - Page 279
. The fan speed increases as you move the control clockwise. 4 Dual Zone Temperature Control Dual Zone Temperature Control - If Equipped With the Dual Zone Temperature Control System, each front seat occupant can independently control the temperature of air coming from the outlets on their side of - 2007 Dodge Caravan | Owner's Manual - Page 280
280 UNDERSTANDING YOUR INSTRUMENT PANEL Front Mode Control The mode control allows you to choose from several patterns of air distribution. Panel Mode NOTE: To improve your selection choices, the system allows you to operate at intermediate positions between the major modes. These intermediate - 2007 Dodge Caravan | Owner's Manual - Page 281
the outlets in the instrument panel. Each of these outlets can be individually adjusted to direct the flow of air. Moving the air vane knob on the center outlets down, will close off the air flow from the center outlets. The thumbwheel next to the outboard outlets can be rotated to regulate or - 2007 Dodge Caravan | Owner's Manual - Page 282
many temperature lever positions, the bilevel mode is designed to provide cooler air out of the panel outlets and warmer air from the floor outlets. Floor Mode Floor Outlets Air comes from the floor outlets. A slight amount of air is directed through the defrost and side window demister outlets. - 2007 Dodge Caravan | Owner's Manual - Page 283
from the floor, defrost and side window demist outlets. This mode works best in cold or snowy conditions. It allows you to stay comfortable while keeping the windshield clear. Air comes from the windshield and side window demist outlets. Use this setting when necessary to defrost your windshield - 2007 Dodge Caravan | Owner's Manual - Page 284
Control. To turn off the air conditioning, press the A/C button a second time. The indicator light will turn off. NOTE: • The compressor will not engage until the engine has been running for a few seconds. • If your air conditioning performance seems lower than expected, check the A/C air filter - 2007 Dodge Caravan | Owner's Manual - Page 285
light in the recirculation button will flash 3 times indicating that recirculation is not allowed. A/C Recirculation Programming The recirculation control necessary, the recirculation mode can be programmed to not automatically reset to the outside mode by using the following procedures: • - 2007 Dodge Caravan | Owner's Manual - Page 286
can be changed back and forth by following the above mentioned procedure. Manual Rear Zone Climate Control - If Equipped The Manual Rear Zone Climate Control system has floor air outlets to the rear of the right side sliding door and overhead outlets at each outboard rear seating position. The unit - 2007 Dodge Caravan | Owner's Manual - Page 287
" position do the second seat occupants have control of the rear blower speed. The rear blower control, located in the headliner near the center of the vehicle has an OFF position and 3 blower speed positions. This allows the second seat occupants to control the volume of air circulated in the rear - 2007 Dodge Caravan | Owner's Manual - Page 288
YOUR INSTRUMENT PANEL CAUTION! Interior air enters the Manual Rear Zone Climate Control system through an intake grille located in the passenger side trim panel behind the third seat. The heater outlets are located in the passenger side trim panel just behind the sliding door. Do not block or place - 2007 Dodge Caravan | Owner's Manual - Page 289
driver and passenger. Based on the sensor input, the system automatically adjusts the air temperature, the air flow volume, and amount of outside air recirculation. This maintains a comfortable temperature even under changing conditions. 4 Three-Zone Automatic Temperature Control Operation of the - 2007 Dodge Caravan | Owner's Manual - Page 290
Programmable Features" in Section 3 of this manual. To provide you with maximum comfort in the automatic mode, during cold start-ups the blower blower control to any fixed blower speed. This feature may be disabled using the following procedure: • Press and hold the Heated Rear Window and Auto LO - 2007 Dodge Caravan | Owner's Manual - Page 291
. The "AUTO" symbol in the front ATC display will be turned off when the system is being used in the manual mode. NOTE: Each of these features operate independently from each other. If any one feature is controlled manually, the remaining features will continue to operate automatically. The left - 2007 Dodge Caravan | Owner's Manual - Page 292
the outlets in the instrument panel. Each of these outlets can be individually adjusted to direct the flow of air. Moving the air vane knob on the center outlets down, will close off the air flow from the center outlets. The thumbwheel next to the outboard outlets can be rotated to regulate or - 2007 Dodge Caravan | Owner's Manual - Page 293
panel outlets, floor outlets and defrost. A slight amount of air is also directed through the side window demister outlets. NOTE: In many temperature positions, the bi-level mode is designed to provide cooler air out of the panel outlets and warmer air from the floor outlets. 4 Bi-Level Outlets - 2007 Dodge Caravan | Owner's Manual - Page 294
comes from the floor outlets. A slight amount of air is directed through the defrost and side window demister outlets. Air comes from the floor, defrost and side window demist outlets. This mode works best in cold or snowy conditions. It allows you to stay comfortable while keeping the windshield - 2007 Dodge Caravan | Owner's Manual - Page 295
system. Note: While operating in auto hi or auto lo , the air conditioning system is always activated. If fog, or mist appears on the windshield or side glass, select defrost mode and increase blower speed. Recirculation Control When outside air contains smoke, odors, high humidity, or if - 2007 Dodge Caravan | Owner's Manual - Page 296
is on the front ATC control unit located on the instrument panel. Selecting the "AUTO" position for the Rear Automatic Temperature Control System from the front ATC control unit, illuminates a "LOCK" symbol in the rear display. The rear temperature and air source are controlled from the front ATC - 2007 Dodge Caravan | Owner's Manual - Page 297
Section 3 of this manual. 4 Rear Automatic Temperature Control Operation of the rear control knob on the front ATC control unit to the "REAR CONTROL" position, this illuminates an "UNLOCK" symbol in the rear display. Next, rotate the Rear Blower Control and the Rear Mode Control to the "AUTO - 2007 Dodge Caravan | Owner's Manual - Page 298
"AUTO" and a range of blower speeds. CAUTION! Interior air enters the Rear Automatic Temperature Control System through an intake grille located in the passenger side trim panel behind the third seat. The heater outlets are located in the passenger side trim panel just behind the sliding door. Do - 2007 Dodge Caravan | Owner's Manual - Page 299
conditioned vehicles must be protected with a high-quality antifreeze coolant to provide proper corrosion protection and to protect against engine overheating. A 50% solution of ethylene 4 Auto Mode The rear system automatically maintains the correct mode and comfort level desired by the rear seat - 2007 Dodge Caravan | Owner's Manual - Page 300
vehicle, or keep it out of service (i.e. vacation) for two weeks or more, run the air conditioning system at idle for about five minutes in the fresh air and high blower setting. This will insure adequate system lubrication to minimize the possibility of compressor damage when the system is started - 2007 Dodge Caravan | Owner's Manual - Page 301
and pollen from the air. Refer to section 7 "Air Conditioning" for filter replacement instructions. REAR WINDOW FEATURES Intermittent Rear Wiper Operation - Manual Temperature Control Only The controls are located on the Manual Temperature Control head above the front blower control. When the button - 2007 Dodge Caravan | Owner's Manual - Page 302
Washer Operation - Manual Temperature Control Only The controls are located on the Manual Temperature Control head above the front blower control. Press and with Automatic Temperature Control, the controls for these features are located in the middle of the instrument panel above the radio. Rear - 2007 Dodge Caravan | Owner's Manual - Page 303
as well as an indicator light will show that the wiper is ON. Intermittent Rear Wiper Operation - Automatic Temperature Control Only When this button is pressed rear window washer is shared. It is located in the front of the engine compartment on the passenger side and should be checked for - 2007 Dodge Caravan | Owner's Manual - Page 304
the reservoir with windshield washer solvent (not radiator antifreeze) and operate the system for a few seconds to flush out the residual water. The washer fluid reservoir will hold a full gallon of fluid when the Low Washer Fluid Light illuminates. Electric Rear Window Defroster - If Equipped - 2007 Dodge Caravan | Owner's Manual - Page 305
UNDERSTANDING YOUR INSTRUMENT PANEL 305 If your vehicle is equipped with Infrared Three-Zone Automatic Temperature Control the rear defroster symbol will show in the display screen when the rear window defroster is on. CAUTION! To avoid damaging the electrical conductors of - 2007 Dodge Caravan | Owner's Manual - Page 306
- 2007 Dodge Caravan | Owner's Manual - Page 307
Equipped ...315 Automatic Transmission ...315 ▫ Brake/Transmission Interlock System ...316 ▫ Automatic Transmission Ignition Interlock System ...316 ▫ Four Speed Automatic Transmission ...316 Parking Brake ...319 Brake System ...321 ▫ Anti-Lock Brake System - If Equipped ...321 Traction Control - If - 2007 Dodge Caravan | Owner's Manual - Page 308
...343 ▫ Replacement Tires ...343 ▫ Alignment And Balance ...344 Tire Chains ...345 Snow Tires ...346 Tire Rotation ...346 Tire Pressure Monitor System (TPMS) - If Equipped ...347 ▫ Base Tire Pressure Monitoring System Without Electronic Vehicle Information Center (EVIC) - If Equipped ...348 - 2007 Dodge Caravan | Owner's Manual - Page 309
Base Tire Pressure Monitoring System With Electronic Vehicle Information Center (EVIC) - If Equipped ...349 ▫ Service Tire System Soon ...351 ▫ Using Your Compact Spare - Basic ) ...361 ▫ Fuel Requirements ...361 ▫ Selection Of Engine Oil For Flexible Fuel Vehicles (E-85) And Gasoline Vehicles ...362 - 2007 Dodge Caravan | Owner's Manual - Page 310
310 STARTING AND OPERATING ▫ Replacement Parts ...363 ▫ Maintenance ...363 Vehicle Loading ...363 ▫ Vehicle Certification Label ...364 ▫ Gross Vehicle Weight Rating (GVWR) Motorhome, Etc.) . . 382 ▫ Towing This Vehicle Behind Another Vehicle (Flat Towing With All Four Wheels On The Ground) ...382 - 2007 Dodge Caravan | Owner's Manual - Page 311
adjust your seat, adjust both inside and outside mirrors, and fasten your seat belts. WARNING! • Be sure to turn off the engine if you want leave the keys in the ignition. A child could operate power windows, other controls, or move the vehicle • Do not leave children or animals inside parked - 2007 Dodge Caravan | Owner's Manual - Page 312
seconds, depress the accelerator lightly (while still cranking the engine). 4. If engine does not start after 15 seconds, turn the ignition key off. 5. Wait 10 to 15 seconds, and repeat steps 1 - 5. NOTE: This vehicle is equipped with a transmission shift interlocking system. The brake pedal must be - 2007 Dodge Caravan | Owner's Manual - Page 313
pedal all the way to the floor and hold it there while cranking the engine. This should clear any excess fuel in case the engine is flooded. WARNING! Never pour fuel or other flammable liquid into the throttle body air inlet opening in an attempt to start the vehicle. This could result in - 2007 Dodge Caravan | Owner's Manual - Page 314
may be used to obtain a start from a booster battery or the battery in another vehicle. This type of start can be dangerous if done improperly. See section 6 of this manual for the proper jump starting procedures and follow them carefully. If the engine has been flooded, it may start to run, but - 2007 Dodge Caravan | Owner's Manual - Page 315
110-115 volt AC electrical outlet with a grounded, three-wire extension cord. The engine block heater cord is routed under the hood on the driver side of the vehicle. It has a removable cap that is located on the driver side of the Integrated Power Module. AUTOMATIC TRANSMISSION CAUTION! Damage - 2007 Dodge Caravan | Owner's Manual - Page 316
you obtain service. Four Speed Automatic Transmission The electronically controlled transmission provides a precise shift schedule. The transmission electronics are self-calibrating; therefore, the first few shifts on a new vehicle, may be somewhat abrupt. This is a normal condition, and precision - 2007 Dodge Caravan | Owner's Manual - Page 317
if the problem could recur. If the transmission cannot be reset, dealer service is required. Gear Ranges DO NOT race the engine when shifting from PARK or NEUTRAL positions into another gear range. Transmission Gear Ranges 5 "P" Park Supplements the parking brake by locking the transmission - 2007 Dodge Caravan | Owner's Manual - Page 318
the "3" range while operating the vehicle under heavy operating conditions will improve performance and extend transmission life by reducing excessive shifting and heat build up. "L" Low This range should be used for engine braking when descending very steep grades. In this range, upshifts will - 2007 Dodge Caravan | Owner's Manual - Page 319
limits. This is done to prevent transmission damage due to overheating. PARKING BRAKE When the parking brake is applied with the ignition switch on, the brake light in the instrument cluster will turn on. NOTE: This light only shows that the parking brake is applied. It does not show the degree of - 2007 Dodge Caravan | Owner's Manual - Page 320
on the transmission locking mechanism may make it difficult to move the selector out of PARK. WARNING! • Always fully apply the parking brake when leaving your vehicle, or it may roll and cause damage or injury. Also be certain to leave an automatic transmission in Park, a manual transmission in - 2007 Dodge Caravan | Owner's Manual - Page 321
-Lock Brake System - If Equipped The Anti-Lock Brake System provides increased vehicle stability and brake performance under most braking conditions. The system automatically "pumps" the brakes during severe braking conditions to prevent wheel lock-up. 5 WARNING! Pumping of the Anti-Lock Brakes - 2007 Dodge Caravan | Owner's Manual - Page 322
jeopardize the user's safety or the safety of others. The ABS light monitors the Anti-Lock Brake System. The light will come BRAKE warning light is not on. If the ABS light is on, the brake system should be serviced as soon as possible to restore the benefits of Anti-Lock brakes. If the ABS light - 2007 Dodge Caravan | Owner's Manual - Page 323
check cycle to ensure that the ABS system is working properly. This self check occurs each time the vehicle is started and accelerated past approximately 7 mph (11 km/h). ABS is activated during braking under certain road or stopping conditions. ABS-inducing conditions can include ice, snow, gravel - 2007 Dodge Caravan | Owner's Manual - Page 324
apply the brake of the spinning wheel. This will allow more engine torque to be applied to the wheel that is not spinning. The Traction Control System reduces wheel slip and maintains traction at the driving (front) wheels. The system reduces wheel slip by engaging the brake on the wheel that is - 2007 Dodge Caravan | Owner's Manual - Page 325
Control may cause the system to deactivate and turn on the TRAC and the OFF indicators located in the instrument cluster. This is to prevent overheating of the brake system and is a normal condition the steering wheel travel are considered normal and do not indicate that there is a problem with the - 2007 Dodge Caravan | Owner's Manual - Page 326
on snow covered, wet, or other slippery surfaces may cause the front wheels to pull erratically to the right or left. This phenomenon occurs when . Unequal traction can cause sudden pulling of the front wheels. You could lose control of the vehicle and possibly have an accident. Accelerate slowly - 2007 Dodge Caravan | Owner's Manual - Page 327
as hydroplaning and may cause partial or complete loss of vehicle control and stopping ability. To reduce this possibility, the following precautions INFORMATION Tire Markings 5 NOTE: • P (Passenger)-Metric tire sizing is based on U.S. design standards. P-Metric tires have the letter "P" molded - 2007 Dodge Caravan | Owner's Manual - Page 328
the sidewall beginning with the section width. The letter P is absent from this tire size designation. Example: 215/65R15 96H • LT (Light Truck)-Metric tire sizing is based on U.S. design standards. The size designation for LT-Metric tires is the same as for P-Metric tires except for the letters "LT - 2007 Dodge Caravan | Owner's Manual - Page 329
in Inches (in) R = Construction Code - R means Radial Construction. - D means Diagonal or Bias Construction. 15 = Rim Diameter in Inches (in) Service Description: 95 = Load Index -A numerical code associated with the maximum load a tire can carry. H = Speed Symbol -A symbol indicating the range of - 2007 Dodge Caravan | Owner's Manual - Page 330
conditions, and posted speed limits). Load Identification: ...blank...= Absence of any text on sidewall of the tire indicates a Standard Load (SL) Tire Extra Load (XL) = Extra Load (or Reinforced) Tire Light Load = Light have the full TIN including date code located on the white sidewall side of the - 2007 Dodge Caravan | Owner's Manual - Page 331
with the U.S. Department of Transportation tire safety standards, and is approved for highway use. MA = Code representing the tire manufacturing location. (2 digits) L9 = Code representing the tire size. (2 digits) ABCD = Code used by tire manufacturer. (1 to 4 digits) 03 = Number representing the - 2007 Dodge Caravan | Owner's Manual - Page 332
332 STARTING AND OPERATING Tire Loading and Tire Pressure Tire Placard Location NOTE: The proper cold tire inflation pressure is listed on either the face of the driver's door or the driver's side "B" pillar. Tire and Loading Information Placard Tire and Loading Information Tire Placard Location - 2007 Dodge Caravan | Owner's Manual - Page 333
For further information on GAWR's, vehicle loading, and trailer towing, refer to the "Vehicle Loading" section of this manual. To determine the maximum loading conditions of your vehicle, locate the statement "The combined weight of occupants and cargo should never exceed XXX kg or XXX lbs." on the - 2007 Dodge Caravan | Owner's Manual - Page 334
load from your trailer will be transferred to your vehicle. Consult this manual to determine how this reduces the available cargo and luggage load capacity of cargo/luggage, and towing capacities of your vehicle with varying seating configurations and number and size of occupants. This table is for - 2007 Dodge Caravan | Owner's Manual - Page 335
STARTING AND OPERATING 335 5 - 2007 Dodge Caravan | Owner's Manual - Page 336
shock. Objects on the road and chuckholes can cause damage that result in tire failure. • Unequal tire pressures can cause steering problems. You could lose control of your vehicle. • Over inflated or under inflated tires can affect vehicle handling and can fail suddenly, resulting in loss of - 2007 Dodge Caravan | Owner's Manual - Page 337
's side "B" pillar. Some vehicles may have Supplemental Tire Pressure Information for vehicle loads that are less than the maximum loaded vehicle condition. These pressure conditions will be found in the "Supplemental Tire Pressure Information" section of this manual. 5 Tire Placard Location - 2007 Dodge Caravan | Owner's Manual - Page 338
of outdoor temperatures, as tire pressures vary with temperature changes. Tire pressures change by approximately 1 psi (7 kPa) per 12 °F (7 °C) of air temperature change. Keep this in mind when checking tire pressure inside a garage, especially in the winter. CAUTION! After inspecting or adjusting - 2007 Dodge Caravan | Owner's Manual - Page 339
3 psi (21 kPa), which equals 1 psi (7 kPa) for every 12 °F (7 °C) for this outside temperature condition. Tire pressure may increase from 2 to 6 psi (13 to 40 kPa) during operation. DO NOT reduce this four (or 6, in case of trucks with dual rear wheels). Never combine them with other types of tires. - 2007 Dodge Caravan | Owner's Manual - Page 340
The compact spare is for temporary emergency use with radial tires. It is engineered to be used on your style vehicle only. Since this tire has loss of vehicle control. Do not install a wheel cover or attempt to mount a conventional tire on the compact spare wheel, since the wheel is designed - 2007 Dodge Caravan | Owner's Manual - Page 341
take your vehicle through an automatic car wash with the compact use spare tire warning label located on the limited use spare tire and wheel assembly. This tire may look of vehicle control. Tire Spinning When stuck in mud, sand, snow, or ice conditions, do not spin your vehicle's wheels above 30 - 2007 Dodge Caravan | Owner's Manual - Page 342
faster than 30 mph (48 km/h) for more than 30 seconds continuously when you are stuck, and don't let anyone near a spinning wheel, no matter what the speed. Tread Wear Indicators Tread wear indicators are in the original equipment tires to help you in determining when your tires - 2007 Dodge Caravan | Owner's Manual - Page 343
of Tire The service life of a tire is dependent upon varying factors including but not limited to: • Driving style • Tire pressure • Distance driven Keep dismounted tires in a cool, dry place with as little exposure to light as possible. Protect tires from contact with oil, grease, and gasoline - 2007 Dodge Caravan | Owner's Manual - Page 344
braking of your vehicle. This can cause unpredictable handling and stress to steering and suspension components. You could lose control and have an accident resulting in serious injury or death. Use only the tire and wheel will not correct this condition. See your dealer for proper diagnosis. - 2007 Dodge Caravan | Owner's Manual - Page 345
that only chains in good condition are used. Broken chains can cause serious damage. Stop the vehicle immediately if noise occurs that could indicate chain breakage. Remove the damaged parts of the chain before further use. • Install chains on the front wheels as tightly as possible and then - 2007 Dodge Caravan | Owner's Manual - Page 346
Observe the tire chain manufacturer's instructions on method of installation, operating speed, and conditions for usage. Always use the of vehicles operate at different loads and perform different steering, driving, and braking functions. For these reasons, they wear at unequal rates, and tend - 2007 Dodge Caravan | Owner's Manual - Page 347
STARTING AND OPERATING 347 Section of this manual. More frequent rotation is permissible if System (TPMS) will warn the driver of a low tire pressure based on the vehicle recommended cold placard pressure (the placard is located on the drivers side "B" Pillar • The tire pressure will vary with - 2007 Dodge Caravan | Owner's Manual - Page 348
as long as the condition exists, and will not The system will automatically update and the wheel rim mounted electronic sensors to monitor tire pressure levels (EXCLUDING THE SPARE TIRE). Sensors, mounted to each wheel as part of the valve stem, transmit tire pressure readings to the Receiver Module - 2007 Dodge Caravan | Owner's Manual - Page 349
for each low tire condition that it detects. Should system will automatically update and wheel rim mounted electronic sensors to monitor tire pressure levels (EXCLUDING THE SPARE TIRE). Sensors, mounted to each wheel as part of the valve stem, transmit tire pressure readings to the Receiver Module - 2007 Dodge Caravan | Owner's Manual - Page 350
Receiver Module • 4 Tire Pressure Monitoring Sensors • will sound once every ignition cycle for each low tire condition that it detects. In addition, the Electronic Vehicle Information the vehicle tire pressure placard. The system will automatically update, the Tire Pressure Monitor System (TPMS - 2007 Dodge Caravan | Owner's Manual - Page 351
each condition that it detects. NOTE: If a temporary spare tire is in use and none of the remaining 3 active road tire pressures are low, a "SERVICE TIRE sensor damage may result when using replacement equipment that is not of the same size, type, and/or style. After-market wheels can cause sensor - 2007 Dodge Caravan | Owner's Manual - Page 352
of the Tire Pressure Monitoring Telltale Lamp. Using Your Compact Spare - Basic Tire Pressure Monitoring System Only Your vehicle is equipped with a compact spare wheel and tire assembly that does not have a tire pressure monitoring sensor. Therefore, it will not be monitored by the Tire Pressure - 2007 Dodge Caravan | Owner's Manual - Page 353
back on the vehicle in place of the compact spare tire. General Information This device complies with part 15 of the FCC rules and RSS 210 of Industry Canada. Operation is subject to the following conditions performance. Light spark knock at low engine speeds is not harmful to your engine. However, - 2007 Dodge Caravan | Owner's Manual - Page 354
cause problems such as hard starting, stalling and hesitations. If you experience these symptoms, try another brand of "regular" gasoline before considering service for blended to reduce vehicle emissions and improve air quality. The manufacturer supports the use of reformulated gasolines. Properly - 2007 Dodge Caravan | Owner's Manual - Page 355
these blends may result in starting and driveability problems and may damage critical fuel system components. Problems that result from using methanol/gasoline or detergents or other additives are not needed under normal conditions and would result in additional cost. Therefore you should not have to - 2007 Dodge Caravan | Owner's Manual - Page 356
the emission control system. • An out-of-tune engine, or certain fuel or ignition malfunctions, can cause the catalytic converter to overheat. If you notice a pungent burning odor or some light smoke, your engine may be out of tune or malfunctioning and may require immediate service. Contact your - 2007 Dodge Caravan | Owner's Manual - Page 357
air into the vehicle. • Guard against carbon monoxide with proper maintenance. Have the exhaust system inspected every time the vehicle is raised. Have any abnormal conditions FUEL Fuel Filler Cap (Gas Cap) The gas cap is located behind the fuel filler door on the left side of the vehicle. If the gas - 2007 Dodge Caravan | Owner's Manual - Page 358
fuel filler door is located on, is located in the instrument cluster, just below the Fuel Gage. The fuel tank filler tube has a restricting door about 2 long enough to force open the restricting door. CAUTION! Damage to the fuel system or emission control system could result from using an improper - 2007 Dodge Caravan | Owner's Manual - Page 359
vehicle when the gas cap is removed or the tank filled. • Never add fuel when the engine is running. This is in violation of most state and federal fire regulations and will cause the malfunction indicator light to turn on. NOTE: • Tighten the fuel filler cap until you hear a "clicking" sound. This - 2007 Dodge Caravan | Owner's Manual - Page 360
AND OPERATING • If the problem continues, the message will appear the next time the vehicle is started. See Section 7 of this manual for more information. Make only. These vehicles can be identified by the unique fuel filler door label that states Ethanol (E-85) or Unleaded Gasoline Only. This - 2007 Dodge Caravan | Owner's Manual - Page 361
STARTING AND OPERATING 361 ETHANOL FUEL (E-85) E-85 is a mixture of approximately 85% fuel ethanol and 15% unleaded gasoline. WARNING! Ethanol vapors are extremely flammable and could cause serious personal injury. Never have any smoking materials lit in or near the vehicle when removing the fuel - 2007 Dodge Caravan | Owner's Manual - Page 362
362 STARTING AND OPERATING For best results, a refueling pattern that alternates between E-85 and unleaded gasoline should gasoline the engine oil requirements are the same. Refer to the "Maintenance Procedures" section of this manual for the proper quality and viscosity engine oil. Starting The - 2007 Dodge Caravan | Owner's Manual - Page 363
serviced with correct ethanol compatible parts. Maintenance If you operate the vehicle using E-85 fuel, follow Schedule B in the maintenance schedule section of this manual a certification label affixed to the driver's side door or pillar. If seats are removed for carrying cargo, do not exceed the - 2007 Dodge Caravan | Owner's Manual - Page 364
certification label attached to the driver's door pillar. The label contains the following wheels drive and steer the vehicle, it is important that you do not exceed the maximum front or rear GAWR. A dangerous driving condition can result if either rating is exceeded. You could lose control - 2007 Dodge Caravan | Owner's Manual - Page 365
This is the cold tire inflation pressure for your vehicle for all loading conditions up to full GAWR. Curb Weight The curb weight of a vehicle is , tires, wheels, etc.) of your vehicle will provide satisfactory service as long as you do not exceed the GVWR and front and rear GAWR. The best way to - 2007 Dodge Caravan | Owner's Manual - Page 366
way the brakes operate. CAUTION! Do not load your vehicle any heavier than the GVWR or the maximum front and rear GAWR. If you do, parts on your vehicle can break, or it can change the way your vehicle handles. This could cause you to lose control. Also overloading can - 2007 Dodge Caravan | Owner's Manual - Page 367
STARTING AND OPERATING 367 A loaded vehicle is shown in the illustration. Note that neither the GVWR or the GAWR capacities have been exceeded. Front Rear Axle Axle Empty Weight 2,140 lbs 1,470 lbs (971 kg) (667 kg) Load (Including driver, pas360 lbs 980 lbs sengers and cargo) (163 kg) (445 kg) - 2007 Dodge Caravan | Owner's Manual - Page 368
and recommendations in this manual concerning vehicles used for on the trailer in its loaded and ready for operation condition. The recommended way to measure GTW is to put your vehicle scale. The entire weight of the trailer must be supported by the scale. Gross Combination Weight Rating (GCWR) The - 2007 Dodge Caravan | Owner's Manual - Page 369
condition can result if either rating is exceeded. You could lose control part of the load on your vehicle. Frontal Area The maximum height and maximum width of the front of a trailer. Trailer Sway Control The trailer sway control supports the trailer tongue weight, just as if it were luggage located - 2007 Dodge Caravan | Owner's Manual - Page 370
contributes positively to tow vehicle and trailer stability. Trailer sway control and a weight distributing (load equalizing) hitch are recommended for adjusted Weight Distributing Hitch system may reduce handling, stability, braking performance, and could result in an accident. Weight Distributing - 2007 Dodge Caravan | Owner's Manual - Page 371
assist you in selecting the correct trailer hitch for your intended towing condition. Refer to the Trailer Towing Weights (Maximum Trailer Weight Ratings) chart . Trailer Hitch Classification Class Max. GTW (Gross Trailer Wt.) Class I - Light Duty 2,000 lbs (907 kg) Class II - Medium 3,500 lbs (1 587 - 2007 Dodge Caravan | Owner's Manual - Page 372
- Extra 10,000 lbs (4 540 kg) Heavy Duty All trailer hitches should be professionally installed on your vehicle. Engine/Transmission GCWR (Gross Combined Wt. Rating) 2.4L Automatic 5,200 lbs (2358 kg) Trailer Towing Weights (Maximum Trailer Weight Ratings) The following chart provides the maximum - 2007 Dodge Caravan | Owner's Manual - Page 373
STARTING AND OPERATING 373 Engine/Transmission GCWR (Gross Combined Wt. Rating) 3.3L & 3.8L Auto6,600 lbs (2993 kg) matic 6,600 lbs (2993 kg) Frontal Area 40 SQ. FT. (3.72 square - 2007 Dodge Caravan | Owner's Manual - Page 374
Engine * For vehicles equipped with Fold-in-Floor seating, the Gross Trailer Weight must be reduced Refer weight must be considered as part of the combined weight of Safety Information Section in this manual. Trailer and Tongue Weight wheels or heavier in the rear can cause the trailer to sway - 2007 Dodge Caravan | Owner's Manual - Page 375
AND OPERATING 375 which will cause loss of control of the vehicle and trailer. Failure to load vehicle. Also, additional factory-installed options, or dealer-installed options, must be considered as part of the total load on your vehicle. Refer to the Tire and Loading Information placard in - 2007 Dodge Caravan | Owner's Manual - Page 376
secured, dynamic load shifts can occur that may be difficult for the driver to control. You could lose control of your vehicle and have an accident. CAUTION! • Avoid towing a trailer for maintenance listed in Section 8 of this manual. When towing a trailer, never exceed the GAWR, or GCWR, ratings. - 2007 Dodge Caravan | Owner's Manual - Page 377
. Overloading can cause a loss of control, poor performance or damage to brakes, axle, engine, transmission, steering, suspension, chassis structure apply the parking brake on the tow vehicle. Put the tow vehicle automatic transmission in P for Park. Always, block or chock the trailer wheels. • GCWR - 2007 Dodge Caravan | Owner's Manual - Page 378
Information section of this manual on Replacement Tires for proper brake controller is required when towing a trailer with electronically actuated brakes. When towing a trailer equipped with a hydraulic surge actuated brake system, an electronic brake controller is not required. − Trailer brakes - 2007 Dodge Caravan | Owner's Manual - Page 379
of adequate capacity. Failure to do this could lead to accelerated brake lining wear, higher brake pedal effort, and longer stopping distances. WARNING! Do not connect trailer brakes to your vehicle's hydraulic brake lines. It can overload your brake system and cause it to fail. You might not have - 2007 Dodge Caravan | Owner's Manual - Page 380
& Wiring Whenever you pull a trailer, regardless of the trailer size, stop lights and turn signals on the trailer are required for motoring safety. The Trailer Tow Package may include a 4 and 7 pin wiring harness. Use a factory approved trailer - 2007 Dodge Caravan | Owner's Manual - Page 381
while operating the vehicle under heavy operating conditions will improve performance and extend transmission life by reducing excessive shifting and heat build up. This action will also provide better engine braking. The automatic transmission fluid and filter should be changed if you REGULARLY tow - 2007 Dodge Caravan | Owner's Manual - Page 382
than 10 mph (16 km/h), disengage until you can get back to cruising speed. − Use speed control in flat terrain and with light loads to maximize fuel efficiency. Towing Tips - Cooling System To reduce potential for engine and transmission overheating, take the following actions: − City Driving When - 2007 Dodge Caravan | Owner's Manual - Page 383
TO DO IN EMERGENCIES CONTENTS Hazard Warning Flasher ...384 If Your Engine Overheats ...385 Jacking And Tire Changing ...386 ▫ Jacking Instructions - Stow 'n Go Seating ...387 ▫ Jacking Instructions - Non Stow 'n Go Seating ...399 Jump-Starting Procedure ...405 Freeing A Stuck Vehicle ...407 Towing - 2007 Dodge Caravan | Owner's Manual - Page 384
HAZARD WARNING FLASHER The hazard flasher switch is located in the center of the instrument panel above the radio. flash on and off to warn oncoming With extended use, the Hazard Warning Flashers may wear down your battery. Hazard Flasher Switch To engage the Hazard Warning Flashers, depress the - 2007 Dodge Caravan | Owner's Manual - Page 385
to slow down an impending overheat condition. If your air conditioner is on, turn it off. The air conditioning system adds heat to the engine cooling system and turning off the A/C removes this heat. You can also turn the Temperature control to maximum heat, the Mode control to floor, and the fan - 2007 Dodge Caravan | Owner's Manual - Page 386
WARNING! A hot engine cooling system is dangerous. You or others could be badly burned by steam or boiling coolant. You may want to call a service center if your vehicle overheats. If you decide to look under the hood yourself, see Section 7, Maintenance, of this manual. Follow the warnings - 2007 Dodge Caravan | Owner's Manual - Page 387
wheel to be raised. • Apply the parking brake firmly before jacking. • Never start the engine with the vehicle on a jack. • Do not let anyone sit in the vehicle when it is on a jack. • Do not get under the vehicle when it is on a jack. • Only use the jack in the positions indicated. • If working - 2007 Dodge Caravan | Owner's Manual - Page 388
388 WHAT TO DO IN EMERGENCIES Jack Location - Stow 'n Go Seating The jack, jack handle and winch handle tools are stowed behind the rear left side trim panel the left. Also remove the tool pouch containing the spare tire winch handle tools, which is located next to the jack and jack handle. Jack - 2007 Dodge Caravan | Owner's Manual - Page 389
under the center of the vehicle by means of a cable winch mechanism. The "spare tire drive" nut is located on the floor, under a plastic cap between the front seats. The tool pouch contains three pieces and can be assembled into a Spare Tire Hook to remove the compact spare tire/cover assembly - 2007 Dodge Caravan | Owner's Manual - Page 390
390 WHAT TO DO IN EMERGENCIES Jacking Instructions - Stow 'n Go Seating 1. Loosen (but do not remove) the wheel lug nuts by turning them to the left one turn while the wheel is still on the ground. 2. To remove the compact spare tire/cover assembly, assemble the winch handle extensions to form a - 2007 Dodge Caravan | Owner's Manual - Page 391
winch "T" handle only. Use of an air wrench or other power tools is not from under the vehicle. Refer to jack engagement locations in the following steps for proper jack placement. part of your body under a vehicle that is on a jack. If you need to get under a raised vehicle, take it to a service - 2007 Dodge Caravan | Owner's Manual - Page 392
spare tire/cover assembly is clear of the vehicle, stand the tire/cover assembly upright and remove the wheel spacer by squeezing the two retaining tabs together. 5. There are two jack engagement locations on each side of the body, refer to the following illustration. Squeezing Winch Retainer Tabs - 2007 Dodge Caravan | Owner's Manual - Page 393
WHAT TO DO IN EMERGENCIES 393 6 Jack Engagement Locations - 2007 Dodge Caravan | Owner's Manual - Page 394
the flange, between the pair of tabs closest to the wheel to be changed. Place the wrench on the jack screw and turn to the right until the jack head is properly engaged in the described location. Do not raise the vehicle until you are sure the jack is securely engaged. WARNING! Raising - 2007 Dodge Caravan | Owner's Manual - Page 395
nuts. Push down on the wrench while tightening for increased leverage. Alternate lug nuts until each nut has been tightened twice. Correct wheel nut tightness is 130 N·m (95 ft. lbs). If in doubt the occupants of the vehicle. Always stow the jack parts and the spare tire in the places provided. 6 - 2007 Dodge Caravan | Owner's Manual - Page 396
To stow the compact spare tire/cover assembly on vehicles equipped with Stow 'n Go seating, assemble the winch handle extensions to form a "T' and fit the winch "T" enough slack in the cable to allow you to pull the wheel spacer out from under the vehicle. Jack Removal/Installation 16. Check - 2007 Dodge Caravan | Owner's Manual - Page 397
cover assembly in the place provided. CAUTION! Spare Tire Removal The winch mechanism is designed for use with the winch "T" handle only. Use of an air wrench or other power tools is not recommended and can damage the winch. 6 - 2007 Dodge Caravan | Owner's Manual - Page 398
been properly extended through the center of the wheel and spare tire cover assembly. Failure to properly engage both retainer tabs could result in loss of the spare tire & cover assembly, which will cause vehicle damage and may cause loss of control of the vehicle. 4. Using the winch "T" handle - 2007 Dodge Caravan | Owner's Manual - Page 399
Instructions - Non Stow 'n Go Seating Preparations For Jacking Park the vehicle on a firm level surface, avoid ice or slippery areas, set the parking brake jack or changing the wheel. • Turn on the Hazard Warning Flasher. • Block both the front and rear of the wheel diagonally opposite the jacking - 2007 Dodge Caravan | Owner's Manual - Page 400
400 WHAT TO DO IN EMERGENCIES Jack Location - Non Stow 'n Go Seating The jack, jack handle are stowed behind the rear left side trim panel in the rear cargo area. Pull up on the lever to release the cover. Remove the spare wheel, scissors jack and jack handle from stowage by rotating the wing - 2007 Dodge Caravan | Owner's Manual - Page 401
is designed for use with the jack handle only. Use of an air wrench or other power tools is not recommended and can damage the winch. Lowering Spare Tire 6 Jacking Instructions - Non Stow 'n Go Seating 1. Loosen (but do not remove) the wheel lug nuts by turning them to the left one turn while the - 2007 Dodge Caravan | Owner's Manual - Page 402
402 WHAT TO DO IN EMERGENCIES Jack Engagement Locations - 2007 Dodge Caravan | Owner's Manual - Page 403
the flange, between the pair of tabs closest to the wheel to be changed. Place the wrench on the jack screw and turn to the right until the jack head is properly engaged in the described location. Do not raise the vehicle until you are sure the jack is securely engaged. 6. Raise the - 2007 Dodge Caravan | Owner's Manual - Page 404
the wrench while tightening for increased leverage. Alternate lug nuts until each nut has been tightened twice. Correct wheel nut tightness is 130 N·m (95 ft stop could endanger the occupants of the vehicle. Always stow the jack parts and the spare tire in the places provided. 12. Secure the flat - 2007 Dodge Caravan | Owner's Manual - Page 405
drive nut to the right until the wheel is drawn into place against the underside automatic transmission cannot be started this way. Unburned fuel could enter the catalytic converter and once the engine has started, ignite and damage the converter and vehicle. If the vehicle has a discharged battery - 2007 Dodge Caravan | Owner's Manual - Page 406
the parking brake, place the automatic transmission in PARK and turn the ignition switch to the OFF position for both vehicles. 3. Turn off the heater, radio and all unnecessary electrical loads. 4. Connect one end of a jumper cable to the positive terminal of the discharged battery. Connect the - 2007 Dodge Caravan | Owner's Manual - Page 407
battery, let the engine idle a few minutes, then start the engine in the vehicle with the discharged battery. 7. When removing the jumper cables, reverse the above sequence exactly. Be careful of the moving belts wheel right and left to clear the area around the front wheels. Then shift back - 2007 Dodge Caravan | Owner's Manual - Page 408
a spinning wheel, no matter what the speed. TOWING A DISABLED VEHICLE With Ignition Key Your vehicle may be towed under the following conditions: The gear must be towed with the front wheels off the ground. CAUTION! Racing the engine or spinning the wheels too fast may lead to transmission - 2007 Dodge Caravan | Owner's Manual - Page 409
towing equipment. Damage to the front fascia will result. • Always use wheel lift equipment when towing from the front. The only other approved method of in the OFF position, not in the LOCK or ACCESSORY positions. If it is necessary to use the accessories while being towed (wipers, defrosters, etc - 2007 Dodge Caravan | Owner's Manual - Page 410
410 WHAT TO DO IN EMERGENCIES TOWING THIS VEHICLE BEHIND ANOTHER VEHICLE (Flat towing with all four wheels on the ground) Flat towing of vehicles equipped with an automatic transmission, is only permitted within the limitations described in this section. TOWING THIS VEHICLE BEHIND ANOTHER VEHICLE - 2007 Dodge Caravan | Owner's Manual - Page 411
Parts ...418 Dealer Service ...419 Maintenance Procedures ...419 ▫ Engine Oil ...420 ▫ Engine Oil Filter ...423 ▫ Drive Belts - Check Condition And Tension . . 423 ▫ Spark Plugs ...424 ▫ Engine Air Cleaner Filter ...424 ▫ Catalytic Converter ...425 ▫ Maintenance-Free Battery ...427 ▫ Air Conditioner - 2007 Dodge Caravan | Owner's Manual - Page 412
Hoses ...442 ▫ Automatic Transmission ...442 ▫ Front And Rear Wheel Bearings ...446 ▫ Appearance Care And Protection From Corrosion ...446 ▫ Cleaning The Instrument Panel And Underseat Cup Holders ...450 Fuses - Integrated Power Module ...452 Vehicle Storage ...455 Replacement Light Bulbs ...455 - 2007 Dodge Caravan | Owner's Manual - Page 413
MAINTAINING YOUR VEHICLE 413 ▫ Rear Tail, Stop, Turn Signal, Side Marker And Back-Up Lights ...459 ▫ Center High Mounted Stop Light (CHMSL) ...460 ▫ License Light ...461 Fluids And Capacities ...461 Fluids, Lubricants And Genuine Parts ...462 ▫ Engine ...462 ▫ Chassis ...463 7 - 2007 Dodge Caravan | Owner's Manual - Page 414
414 MAINTAINING YOUR VEHICLE 2.4L ENGINE Engine Compartment 2.4L Engine - 2007 Dodge Caravan | Owner's Manual - Page 415
MAINTAINING YOUR VEHICLE 415 3.3L/3.8L ENGINES 7 Engine Compartment 3.3L/3.8L Engines - 2007 Dodge Caravan | Owner's Manual - Page 416
of the emissions, engine, and automatic transmission control systems. When these systems control system. It could also affect fuel economy and driveability. The vehicle must be serviced before any emissions tests can be performed. • If the "Malfunction Indicator Light" is flashing while the engine - 2007 Dodge Caravan | Owner's Manual - Page 417
Light) is functioning and is not on when the engine is running, and that the OBD (On Board Diagnostic) system is ready for testing. Normally, the OBD system will be ready. The OBD system may not be ready if your vehicle was recently serviced, if you recently had a dead battery, or a battery - 2007 Dodge Caravan | Owner's Manual - Page 418
or repair facility. If your vehicle was recently serviced or had a battery failure or replacement, you may need to do serviced before going to the I/M station. The I/M station can fail your vehicle because the MIL symbol is on with the engine running. REPLACEMENT PARTS Use of genuine Mopar parts - 2007 Dodge Caravan | Owner's Manual - Page 419
to these manuals before attempting any procedure yourself. NOTE: Intentional tampering with emissions control systems can result in civil penalties being assessed against you. MAINTENANCE PROCEDURES The pages that follow contain the required maintenance services determined by the engineers who - 2007 Dodge Caravan | Owner's Manual - Page 420
420 MAINTAINING YOUR VEHICLE Engine Oil Checking Oil Level To assure proper engine lubrication, the engine oil must be maintained at the correct level. Check the oil level at regular intervals, such as every fuel stop. The best time to check the engine oil level is about 5 minutes after a fully - 2007 Dodge Caravan | Owner's Manual - Page 421
of this manual NOTE: Under no circumstances should oil change intervals exceed 6000 miles (10 000 km) or 6 months whichever comes first. Engine Oil Selection For best performance and maximum protection under all types of operating conditions, the manufacturer only recommends engine oils that are - 2007 Dodge Caravan | Owner's Manual - Page 422
low temperature starting and vehicle fuel economy. Refer to your engine oil filler cap for the recommended engine oil viscosity for your vehicle. For information on engine oil filler cap location, refer to the Engine Compartment illustration in this section. Lubricants which do not have both - 2007 Dodge Caravan | Owner's Manual - Page 423
type for replacement. The quality of replacement filters varies considerably. Only high quality filters should be used to assure most efficient service. Mopar Engine Oil Filters are a high quality oil filter and are recommended. Drive Belts - Check Condition and Tension At the mileage indicated in - 2007 Dodge Caravan | Owner's Manual - Page 424
converter. For proper type of replacement spark plugs, refer to the "Vehicle Emission Control Information" label in the engine compartment. Engine Air Cleaner Filter Under normal driving conditions, replace the air filter at the intervals shown on Schedule "A". If, however, you drive the vehicle - 2007 Dodge Caravan | Owner's Manual - Page 425
can result if your vehicle is not kept in proper operating condition. In the event of engine malfunction, particularly involving engine misfire or other apparent loss of performance, have your vehicle serviced promptly. Continued operation of your vehicle with a severe malfunction could cause - 2007 Dodge Caravan | Owner's Manual - Page 426
MAINTAINING YOUR VEHICLE NOTE: Intentional tampering with emissions control systems can result in civil penalties being assessed occurs, the vehicle should be stopped, the engine shut off and the vehicle allowed to cool. Thereafter, service, including a tune-up to manufacturer's specifications - 2007 Dodge Caravan | Owner's Manual - Page 427
427 • Do not idle the engine with any spark plug wires disconnected or removed, such as when diagnostic testing, or for prolonged periods during very rough idling or malfunctioning operating conditions. Maintenance-Free Battery The top of the MAINTENANCE-FREE battery is permanently sealed. You will - 2007 Dodge Caravan | Owner's Manual - Page 428
is in vehicle, disconnect both vehicle battery cables before connecting the charger to battery. Do not use a "fast charger" to provide starting voltage. Air Conditioner Maintenance For best possible performance, your air conditioner should be checked and serviced by an Authorized Dealer at the - 2007 Dodge Caravan | Owner's Manual - Page 429
, Stop Leak Products, Seal Conditioners, Compressor Oil, or Refrigerants. A/C Air Filter - If Equipped The A/C Air Filter - if so equipped, is found behind the filter access door located under the instrument panel on the passenger side. To replace the filter slide the lock toward the rear of the - 2007 Dodge Caravan | Owner's Manual - Page 430
this manual for the recommended air conditioning filter replacement intervals. Power Steering - Fluid Check Checking the power steering fluid level at a defined service interval on a level surface and with the engine off to prevent injury from moving parts and to insure accurate fluid level reading. - 2007 Dodge Caravan | Owner's Manual - Page 431
Lubrication Locks and all body pivot points, including such items as seat tracks, doors, liftgate, sliding doors and hood hinges, should be lubricated periodically to assure quiet, easy operation and to protect against rust and wear. Prior to the application of any lubricant, the parts concerned - 2007 Dodge Caravan | Owner's Manual - Page 432
the blade rubber out of contact with petroleum products such as engine oil, gasoline, etc. Windshield and Rear Window Washers The fluid reservoir for the windshield washers and the rear window washer is shared. It is located in the engine compartment and should be checked for fluid level at regular - 2007 Dodge Caravan | Owner's Manual - Page 433
for broken, damaged, deteriorated, or mispositioned parts. Open seams or loose connections could permit oil change. Replace as required. WARNING! Washer Fluid Bottle Exhaust System The best protection against carbon monoxide entry into the vehicle body is a properly maintained engine manual. 7 - 2007 Dodge Caravan | Owner's Manual - Page 434
working near the radiator cooling fan, disconnect the fan motor lead or turn the ignition switch to the OFF position. The fan is temperature controlled pressure cap when the radiator is hot. Engine Coolant Checks Check the engine coolant (antifreeze) protection every 12 months (before the onset - 2007 Dodge Caravan | Owner's Manual - Page 435
Genuine Parts for correct coolant type. CAUTION! Mixing of coolants other than specified HOAT engine coolants, may result in engine damage as possible. Do not use plain water alone or alcohol base engine coolant (antifreeze) products. Do not use additional rust inhibitors or antirust products, - 2007 Dodge Caravan | Owner's Manual - Page 436
When adding coolant, a minimum solution of 50% recommended Mopar Antifreeze/ Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Organic operated. NOTE: Mixing coolant types will decrease the life of the engine coolant and will require more frequent coolant changes. Cooling System Pressure Cap - 2007 Dodge Caravan | Owner's Manual - Page 437
your local authorities to determine the disposal rules for your community. To prevent ingestion by animals or children do not store ethylene glycol based engine coolant in open containers or allow it to remain in puddles on the ground. If ingested by a child, contact a physician immediately. Clean - 2007 Dodge Caravan | Owner's Manual - Page 438
freeze point or replacing coolant. Advise your service attendant of this. As long as the engine operating temperature is satisfactory, the coolant bottle point in the radiator and in the coolant recovery bottle. If antifreeze needs to be added, contents of coolant recovery bottle must also be - 2007 Dodge Caravan | Owner's Manual - Page 439
the front of the radiator clean. If your vehicle is equipped with air conditioning, keep the front of the condenser clean, also. • Do not change failure. Brakes In order to assure brake system performance, all brake system components should be inspected periodically. Suggested service intervals can - 2007 Dodge Caravan | Owner's Manual - Page 440
pressure (during vehicle operation), should be noted before hose is replaced based on leakage. NOTE: Inspection of brake hoses should be performed whenever the brake system is serviced and every engine oil change. Inspect hydraulic brake hoses for surface cracking, scuffing, or worn spots. If there - 2007 Dodge Caravan | Owner's Manual - Page 441
recommended brake fluid, refer to Fluids, Lubricants and Genuine Parts for correct fluid type. WARNING! Worn brake hoses can burst and cause brake failure should be checked when performing underhood services, or immediately if the brake system warning light indicates system failure. Clean the top - 2007 Dodge Caravan | Owner's Manual - Page 442
the brake fluid reservoir can result in spilling brake fluid on hot engine parts and the brake fluid catching fire. Use only brake fluid that during service. Care should be taken in installing new clamps to insure they are properly torqued. Automatic Transmission The automatic transmission - 2007 Dodge Caravan | Owner's Manual - Page 443
in transmission shift quality and/or torque converter shudder. Using a transmission fluid other than the manufacturers recommended fluid will result in more frequent fluid and filter changes. Refer to Fluids, Lubricants and Genuine Parts for correct fluid type. 7 - 2007 Dodge Caravan | Owner's Manual - Page 444
automatic transmission fluid level, the following procedure must be used: 1. The vehicle must be on level ground. 2. The engine should be running at curb idle speed for a minimum of 60 seconds. 3. Fully apply parking brake the dipstick clean and reinsert until seated. Remove dipstick and note reading - 2007 Dodge Caravan | Owner's Manual - Page 445
that the dipstick cap is reseated properly. Fluid and Filter Changes Automatic transmission fluid should be changed on all transmissions as follows Section 8 of this manual for Maintenance Schedules. If the transmission is disassembled for any reason, the fluid and filter should be changed. Special - 2007 Dodge Caravan | Owner's Manual - Page 446
wheel bearings are permanently sealed. No regular maintenance is required for these components. Appearance Care and Protection from Corrosion Protection of Body and Paint from Corrosion Vehicle body care requirements vary according to geographic locations and other extreme conditions will have an - 2007 Dodge Caravan | Owner's Manual - Page 447
drive near the ocean, hose off the undercarriage at least once a month. • It is important that the drain holes in the lower edges of the doors, rocker panels and trunk be kept clear and open. • If you detect any stone chips or scratches in the paint, touch them up immediately. The - 2007 Dodge Caravan | Owner's Manual - Page 448
to prevent corrosion. To remove heavy soil and/or excessive brake dust, use Mopar Wheel Cleaner (05066247AB) or equivalent or select a nonabrasive, non- use oven cleaner. Avoid automatic car washes that use acidic solutions or harsh brushes that may damage the wheels' protective finish. Interior - 2007 Dodge Caravan | Owner's Manual - Page 449
best oils, cleaning fluids, solvents, detergents, or ammonia based cleaners to clean your leather upholstery. Application of a leather conditioner is not required to maintain the original condition. Cleaning High Gloss Front Door door applique. Rub the applique with a firm pressure then buff lightly - 2007 Dodge Caravan | Owner's Manual - Page 450
radio . Seat Belt Maintenance Do not bleach, dye or clean the belts with work properly. Cleaning The Instrument Panel and Underseat Cup Holders Removal Remove the ash receiver from the convenience tray if there is a smoker's package in your vehicle. With your index finger, locate the stop tab located - 2007 Dodge Caravan | Owner's Manual - Page 451
MAINTAINING YOUR VEHICLE 451 hour. After one hour pull the drawer from the water and dip it back into the water about six times. This will loosen any remaining debris. Rinse the drawer thoroughly under warm running water. Shake the excess water from - 2007 Dodge Caravan | Owner's Manual - Page 452
Power module (IPM) Cartridge Fuse 30 Amp Pink 40 Amp Green 40 Amp Green 40 Amp Green 40 Amp Green 30 Amp Pink 30 Amp Pink 40 Amp Green Description Front Wipers Anti-Lock Brake System (ABS) Pump Front Blower Electronic Back Light (EBL) Body Control Module (BCM) Feed 1 Central Amplifier Seats - 2007 Dodge Caravan | Owner's Manual - Page 453
Only) Power Sliding Door Power Liftgate F11 F12 F14 Cavity F1 F2 F3 F5 Description Fog Lights Left Park/Tail Light Right Park/Tail Light RDO/IP Ignition F15 Battery Horn EWD/ Rear Wiper Rear Blower Ignition Off Draw (IOD) Electronic Automatic Transaxle (EATX) Battery ASD Fuel Pump A/C Clutch 7 - 2007 Dodge Caravan | Owner's Manual - Page 454
Amp Yellow 15 Amp Blue 20 Amp Yellow Description Anti-Lock Brake System (ABS) Module Ignition Switch Hazard Stop Lamp Front/Rear Washer Spare (IOD) CAUTION! • When installing overload. If a properly rated fuse continues to blow, it indicates a problem in the circuit that must be corrected. - 2007 Dodge Caravan | Owner's Manual - Page 455
20 Amp mini fuse in the Integrated Power Module labeled Ignition-Off Draw (IOD). • Or, disconnect the negative cable from the battery. • Anytime you store your vehicle, or keep it out of service (i.e. vacation) for two weeks or more, run the air conditioning system at idle for about five minutes in - 2007 Dodge Caravan | Owner's Manual - Page 456
YOUR VEHICLE NOTE: For lighted switches, see your dealer for replacement instructions. All of the interior bulbs are glass wedge base or glass cartridge types. Aluminum base bulbs are not approved and should not be used for replacement. LIGHT BULBS - Exterior Bulb Number Back-up, Tail, Stop, Turn - 2007 Dodge Caravan | Owner's Manual - Page 457
On some vehicles it may be necessary to slide the red release lock rearward and push forward on the connector while depressing the release tab. CAUTION ! Do not touch the new bulb with your fingers. Oil contamination will severely shorten bulb life. If the bulb comes in contact - 2007 Dodge Caravan | Owner's Manual - Page 458
MAINTAINING YOUR VEHICLE Front Park/Turn Signal and Sidemarker Lights 1. Remove the three screws securing the headlight module. 3. Replace bulb, reinstall socket and then reinstall the headlight module. 2. Twist the turn signal socket to remove from the headlight module and pull bulb from socket. - 2007 Dodge Caravan | Owner's Manual - Page 459
Back-up Lights 1. Raise the liftgate. 2. Remove the two tail light assembly push-in type fasteners, by prying under the fastener head with a large flat screwdriver. CAUTION! Do not touch the new bulb with your fingers. Oil - 2007 Dodge Caravan | Owner's Manual - Page 460
tabs to remove it from the housing. Center High Mounted Stop Light (CHMSL) 1. Remove the two screws securing the CHMSL. 4. Pull the bulb to remove it from the socket. 5. Replace the bulb, reinstall the socket, and reattach the light assembly. 2. Twist the bulb socket to remove from the CHMSL - 2007 Dodge Caravan | Owner's Manual - Page 461
the CHMSL. License Light 1. Remove the two lens assembly mounting screws. FLUIDS AND CAPACITIES Fuel Engine Oil-with filter 2. Pull the 2.4 Liter Engines (SAE 5W-30, API Certified) 3.3 & 3.8 Liter Engines (SAE 5W-20, API Certified) Cooling System * 2.4 Liter Engines (Mopar Antifreeze/Coolant 5 - 2007 Dodge Caravan | Owner's Manual - Page 462
YOUR VEHICLE FLUIDS, LUBRICANTS AND GENUINE PARTS Engine Component Engine Coolant 2.4 Liter Engine Oil 3.3/3.8 Liter Engine Oil Oil Filter 2.4 liter engines Oil Filter 3.3/3.8 liter engines Spark Plugs Fuel Selection Fluids, Lubricants and Genuine Parts Mopar Antifreeze/Coolant 5 Year/100,000 Mile - 2007 Dodge Caravan | Owner's Manual - Page 463
MAINTAINING YOUR VEHICLE 463 Chassis Component Automatic Transmission Brake Master Cylinder Fluids, Lubricants and Genuine Parts. Mopar ATF+4 Automatic Transmission Fluid. Mopar DOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake fluid is not available, then DOT 4 is acceptable. Use only - 2007 Dodge Caravan | Owner's Manual - Page 464
- 2007 Dodge Caravan | Owner's Manual - Page 465
MAINTENANCE SCHEDULES CONTENTS Emission Control System Maintenance ...466 Maintenance Schedules ...466 ▫ Schedule "B" ...469 M A I N T E N A N C E S ▫ Schedule "A" ...478 C H E D U L E S 8 - 2007 Dodge Caravan | Owner's Manual - Page 466
proper functioning of the emission control system. These, and all other maintenance services included in this manual, should be done to provide best vehicle performance and reliability. More frequent mainS tenance may be needed for vehicles in severe operating C conditions such as dusty areas and - 2007 Dodge Caravan | Owner's Manual - Page 467
Use the schedule that best describes your driving conditions. Where time and mileage are listed, follow the interval that occurs first. CAUTION! Failure to perform the required maintenance items may result in damage to the vehicle. At Each Stop for Fuel • Check the engine oil level about 5 minutes - 2007 Dodge Caravan | Owner's Manual - Page 468
add as needed. • Check all lights and all other electrical items for correct operation. At Each Oil Change • Change the engine oil filter. • Inspect the exhaust system. • Inspect the brake hoses. • Inspect the CV joints and front suspension components. • Check the automatic transmission fluid level - 2007 Dodge Caravan | Owner's Manual - Page 469
. Change the automatic transmission fluid and filter every 96 000 km (60,000 miles) if the vehicle is usually operated under one or more of the conditions marked with an . • Day or night temperatures are below 0° C (32° F). • Stop and go driving. • Extensive engine idling. • Driving in dusty - 2007 Dodge Caravan | Owner's Manual - Page 470
M 470 SCHEDULE "B" A I N Miles T (Kilometers) E N Change engine oil and engine oil filter. A Rotate Tires N C Inspect the brake linings. E Inspect the engine air cleaner filter, replace if S C H E D U L E S 3, 000 (5 000 ) X 6, 000 (10 000 ) X X X 9, 000 (15 000) X X X 12, 000 (20 000) X X X 15 - 2007 Dodge Caravan | Owner's Manual - Page 471
oil and engine oil filter. Rotate Tires Inspect the brake linings. Inspect the engine air cleaner filter, replace if necessary. Replace the engine air cleaner filter. Replace the spark plugs 2.4 liter engines. Inspect the tie rod ends and boot seals. Inspect and adjust the power steering pump belt - 2007 Dodge Caravan | Owner's Manual - Page 472
M 472 SCHEDULE "B" A I N Miles T (Kilometers) E N Change engine oil and engine oil filter. A Rotate Tires N C Inspect the brake linings. E Inspect the engine air cleaner filter, replace if S C H E D U L E S 39, 000 (65 000) X 42, 000 (70 000) X X X 45, 000 (75 000) X X 48, 000 (80 000) X X X 51 - 2007 Dodge Caravan | Owner's Manual - Page 473
the generator belt on 2.4 liter engines, replace if necessary. Inspect the PCV valve and replace if necessary. Inspect the serpentine drive belt on 3.3 liter and 3.8 liter engines, replace if necessary. ‡ Change the automatic transmission fluid and filter. Replace the air conditioning filter. 8 X - 2007 Dodge Caravan | Owner's Manual - Page 474
M 474 SCHEDULE "B" A I N Miles T (Kilometers) E Change engine oil and engine oil filter. N A Rotate Tires N Inspect the brake linings. C Inspect the engine air cleaner filter, replace if E necessary. S C H E D U L E S 75, 000 78, 000 81, 000 84, 000 87, 000 (125 000) (130 000) (135 000) (140 000) ( - 2007 Dodge Caravan | Owner's Manual - Page 475
engine oil and engine oil filter. Rotate Tires Inspect the brake linings. Inspect the engine air cleaner filter, replace if necessary. Replace the engine air cleaner filter Inspect and adjust the power steering pump belt tension on 2.4 liter engines. Inspect the generator belt on 2.4 liter engines - 2007 Dodge Caravan | Owner's Manual - Page 476
M 476 SCHEDULE "B" A I N Miles T (Kilometers) E N Change engine oil and engine oil filter. A Rotate Tires N C Inspect the brake linings. E Inspect the engine air cleaner filter, replace if S C H E D U L E S 108, 000 (180 000) X X X X 111, 000 (185 000) X 114, 000 (190 000) X X X 117, 000 (195 - 2007 Dodge Caravan | Owner's Manual - Page 477
SCHEDULE "B" 477 M Miles (Kilometers) Inspect the serpentine drive belt on 3.3 liter and 3.8 liter engines, replace if necessary. ‡ Change the automatic transmission fluid and filter. Replace the air conditioning filter. 108, 000 (180 000) 111, 000 (185 000) 114, 000 (190 000) 117, 000 (195 000 - 2007 Dodge Caravan | Owner's Manual - Page 478
engine oil and engine oil filter. E Rotate Tires S C H E D U L E S 6, 000 (10 000) [6] X X X 12, 000 (20 000) [12] X X X 8 Inspect the brake linings. Inspect the engine air cleaner filter, replace if necessary. Replace the engine air cleaner filter. Replace the spark plugs 2.4 liter engines - 2007 Dodge Caravan | Owner's Manual - Page 479
M Miles (Kilometers) [Months] Change engine oil and engine oil filter. Rotate Tires Inspect the brake linings. Inspect the engine air cleaner filter, replace if necessary. Replace the engine air cleaner filter. Replace the spark plugs & ignition cables on 2.4 liter engines. Inspect the tie rod ends - 2007 Dodge Caravan | Owner's Manual - Page 480
and replace the engine coolant at 60 S C H E D U L E S 42, 000 (70 000) [42] 48, 000 (80 000) [48] 54, 000 (90 000) [54] 60, 000 66, 000 72, 000 (100 000) (110 000) (120 000) [60] [66] [72] X X months or 102,000 miles, whichever comes first. Replace the air conditioning filter. X X X 8 - 2007 Dodge Caravan | Owner's Manual - Page 481
SCHEDULE "A" 481 M Miles (Kilometers) [Months] Change engine oil and engine oil filter. Rotate Tires Inspect the brake linings. Inspect the engine air cleaner filter, replace if necessary. Replace the engine air cleaner filter. Inspect the tie rod ends and boot seals. Check and replace the PCV - 2007 Dodge Caravan | Owner's Manual - Page 482
I N Miles T (Kilometers) E N [Months] A Change engine oil and engine oil filter. N C Rotate Tires E Inspect the brake linings. S C H E D U L E S 102, 000 (170 000) [102] X X X 8 Inspect the engine air cleaner filter, replace if necessary. Replace the engine air cleaner filter. Inspect the tie rod - 2007 Dodge Caravan | Owner's Manual - Page 483
the serpentine drive belt on 3.3 liter and 3.8 liter engines, replace if necessary. ‡ Flush and replace the engine coolant at 120 months, if not done at 102,000 miles. Replace the air conditioning filter. ‡ This maintenance is not required if previously replaced. Inspection and service should also - 2007 Dodge Caravan | Owner's Manual - Page 484
- 2007 Dodge Caravan | Owner's Manual - Page 485
ASSISTANCE CONTENTS Suggestions For Obtaining Service For Your Vehicle ...486 ▫ Prepare For The Appointment ...486 ▫ Prepare A List ...486 ▫ Be Reasonable With Requests ...486 If You Need Assistance ...486 Warranty Information (U.S. Vehicles Only) ...489 Mopar Parts ...489 Reporting Safety Defects - 2007 Dodge Caravan | Owner's Manual - Page 486
This can often provide a clue to the current problem. Prepare A List Make a written list of your vehicle's problems or the specific work you want done. If you've had an accident, or work done that is not on your maintenance log, let the service advisor know. Be Reasonable With Requests If you list - 2007 Dodge Caravan | Owner's Manual - Page 487
, and the latest information to assure your vehicle is fixed correctly and in a timely manner. This is why you should always talk to your dealer's service manager first. Most matters can be resolved with this process. • If for some reason you are still not satisfied, talk to the general manager or - 2007 Dodge Caravan | Owner's Manual - Page 488
to a TDD or a conventional teletypewriter (TTY) in the United States can communicate with the manufacturer by dialing 1-800-380-CHRY. Service Contract You may have purchased a service contract for your vehicle to help protect you from the high cost of unexpected repairs after your manufacturer's new - 2007 Dodge Caravan | Owner's Manual - Page 489
PARTS Mopar fluids, lubricants, parts, and accessories are available from your dealer. They will help you keep your vehicle operating at its best recall and remedy campaign. However, NHTSA cannot become involved in individual problems contact the Customer Service Department immediately. Canadian customers - 2007 Dodge Caravan | Owner's Manual - Page 490
manuals. (No P.O. Boxes). • Service Manuals. These comprehensive service manuals provide the information that students and professional technicians need in diagnosing/troubleshooting, problem solving, maintaining, servicing, and repairing DaimlerChrysler Corporation vehicles. A complete working - 2007 Dodge Caravan | Owner's Manual - Page 491
491 • Owner's Manuals. These manuals have been prepared with the assistance of service and engineering specialists to acquaint Treadwear The treadwear grade is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For - 2007 Dodge Caravan | Owner's Manual - Page 492
controlled conditions on specified government test surfaces of asphalt and concrete. A tire marked C may have poor traction performance. WARNING! The traction grade assigned to this tire is based on straight-ahead braking under controlled conditions on a specified indoor laboratory test wheel. - 2007 Dodge Caravan | Owner's Manual - Page 493
IF YOU NEED CONSUMER ASSISTANCE 493 WARNING! The temperature grade for this tire is established for a tire that is properly inflated and not overloaded. Excessive speed, under inflation, or excessive loading, either separately or in combination, can cause heat buildup and possible tire failure. 9 - 2007 Dodge Caravan | Owner's Manual - Page 494
- 2007 Dodge Caravan | Owner's Manual - Page 495
INDEX 10 - 2007 Dodge Caravan | Owner's Manual - Page 496
, Satellite Radio ...274 Antifreeze (Engine Coolant) ...435,436,461 Disposal ...437 Anti-Lock Brake System (ABS) ...321 Anti-Lock Warning Light ...214 Anti-Theft System ...18 Appearance Care ...446 Ashtray ...188 Auto Down Power Windows ...33 Automatic Dimming Mirror ...96 Automatic Door Locks ...29 - 2007 Dodge Caravan | Owner's Manual - Page 497
...Belts, Drive ...430 ...427 ...427 ...405 ...26 ...153 ...446 ...423 Body Mechanism Lubrication ...431 B-Pillar Location ...332 Brake Fluid ...463 Brake, Parking ...319 Brake System ...321,439 Anti-Lock (ABS) ...321 Fluid Check ...441 Hoses ...440 Warning Light ...213 Brakes ...321,439 Brake - 2007 Dodge Caravan | Owner's Manual - Page 498
386 Chart, Tire Sizing ...328 Check Engine Light (Malfunction Indicator Light) ...218,417 Child Restraint ...75,76,77 Child Restraint Tether Anchors ...79 Child Safety Locks ...38 Child Seat ...74,82 Clean Air Gasoline ...354 Cleaning Wheels ...448 Climate Control ...278 Clock ...220,258 Coat Hook - 2007 Dodge Caravan | Owner's Manual - Page 499
Service ...419 Defroster, Rear Window ...304 Defroster, Windshield ...90,283,295 Diagnostic System, Onboard ...416 Digital Video Disc (DVD) Player ...259 Dimmer Control ...152 Dipsticks Automatic Transmission ...444 Oil (Engine) ...420 Disabled Vehicle Towing ...408 Disposal Antifreeze (Engine - 2007 Dodge Caravan | Owner's Manual - Page 500
Starting ...405 Overheating ...385 Emission Control System Maintenance ...417,466 Engine ...414,415 Air Cleaner ...425 Air Cleaner Filter ...424 Block Heater ...315 Break-In Recommendations ...88 Checking Oil Level ...420 Compartment ...414,415 Coolant (Antifreeze) ...462 Cooling ...434 Exhaust Gas - 2007 Dodge Caravan | Owner's Manual - Page 501
Exhaust Gas Caution ...43,89,356,433 Exhaust System ...433 Extender, Seat Belt ...56 Exterior Folding Mirrors ...98 Filters Air Cleaner ...424 Air Conditioning ...301,429 Automatic Transaxle ...445 Engine Oil ...423,462 Engine Oil Disposal ...423 Flashers Hazard Warning ...384 Turn Signal ...212,458 - 2007 Dodge Caravan | Owner's Manual - Page 502
502 INDEX Fold in Floor (Stow n Go) Seating ...129 Freeing A Stuck Vehicle ...407 Fuel ...353 Adding ...357 Additives ...355 Clean Air ...354 Filler Cap (Gas Cap) ...357 Gasoline ...353 Gauge ...211 Hoses ...442 Light ...212 Octane Rating ...353,462 Requirements ...353,461 Tank Capacity ...461 Fuel - 2007 Dodge Caravan | Owner's Manual - Page 503
Mirror ...96 Instrument Cluster ...209,210,211 Instrument Panel and Controls ...208 Instrument Panel Lens Cleaning ...450 Integrated Child Seat ...74 Integrated Power Module (Fuses) ...452 Interior Appearance Care ...448 Interior Lights ...151,152 Intermittent Wipers (Delay Wipers) ...157,301,303 - 2007 Dodge Caravan | Owner's Manual - Page 504
...40 Lights ...90,150 Airbag ...62,72,90,214 Alarm ...216 Anti-Lock ...214 Automatic Headlights ...153 Back-Up ...459 Battery Saver ...153 Brake Warning ...213 Bulb Replacement ...455,456 Center Mounted Stop ...460 Cruise ...219 Dimmer Switch, Headlight ...152 Door Ajar ...213 Engine Temperature - 2007 Dodge Caravan | Owner's Manual - Page 505
Lights On Reminder ...153 Low Fuel ...212 Malfunction Indicator (Check Engine) ...218 Oil Pressure ...217 Park ...151,458 Passing ...156 Reading ...168 Rear Servicing ...459 Rear Tail ...459 Seat Belt 366 Capacities ...366 Tires ...332 Locks Door ...27 Steering Wheel ...14 Lower Anchors and Tether - 2007 Dodge Caravan | Owner's Manual - Page 506
Free Battery ...427 Maintenance Procedures ...419 Maintenance Schedule ...466 Light Duty Schedule "B" ...469 Schedule "A" ...478 Schedule "B" ...469 Maintenance, Sunroof ...185 Malfunction Indicator Light (Check Engine) . . 218,417 Manual, Service ...490 Map/Reading Lights ...168 Memory Seat ...99 - 2007 Dodge Caravan | Owner's Manual - Page 507
(UConnect™) ...100 Placard, Tire and Loading Information ...332 Power Brakes ...321 Distribution Center (Fuses) ...452 Door Locks ...28 Lift Gate ...41 Mirrors ...98 Outlet (Auxiliary Electrical Outlet) ...185 Seats ...124 Sliding Door ...35 Steering ...325 Steering, Checking ...430 Sunroof ...183 - 2007 Dodge Caravan | Owner's Manual - Page 508
Signals ...220 Radio, Navigation ...257 Radio Operation ...251,274 Radio Remote Controls ...262,275 Radio, Satellite ...271 Radio (Sound Systems) ...222,232,243,251 Rear Air Conditioning ...286,296 Rear Cup Holder ...188 Rear Heater ...286 Rear Park Sense System ...159 Rear Seat Removal ...141 - 2007 Dodge Caravan | Owner's Manual - Page 509
Safety Information, Tire ...327 Safety Tips ...89 Satellite Radio ...271 Satellite Radio Antenna ...274 Schedule, Maintenance ...466 Seat Belt Maintenance ...450 Seat Belt Reminder ...54,55 Seat Belts ...46 Adjustable Shoulder Belt ...52 Adjustable Upper Shoulder Anchorage ...52 And Pregnant Women - 2007 Dodge Caravan | Owner's Manual - Page 510
Selection of Coolant (Antifreeze) ...435,462 Sentry Key (Immobilizer) ...15 Sentry Key Programming ...17 Service Assistance ...486 Service Contract ...488 Service Engine Soon Light (Malfunction Indicator) ...218 Service Manuals ...490 Setting the Clock ...220,258 Shoulder Belts ...47 Signals, Turn - 2007 Dodge Caravan | Owner's Manual - Page 511
Go (Fold in Floor) Seats ...129 Sun Roof ...183 Sun Visor Extension ...99 Sunglasses Storage ...168 Sunroof Maintenance ...185 Supplemental Restraint System - Airbag ...57 Synthetic Engine Oil ...423 System, Navigation ...257 Tachometer ...215 Temperature Control, Automatic (ATC) ...289 Temperature - 2007 Dodge Caravan | Owner's Manual - Page 512
...408 Guide ...372 Recreational ...382,410 Weight ...372 Traction Control ...158,218,324 Traction Control Switch Guide ...372 Trailer Weight ...372 Transaxle ...315 Automatic ...12,315 Operation ...315 Overdrive ...318 Selection of Lubricant ...443,463 Transmission ...442 Automatic ...442 Filter - 2007 Dodge Caravan | Owner's Manual - Page 513
INDEX 513 Transmitter Battery Service (Remote Keyless Entry) ...26 Transmitter, Garage Door Opener (HomeLink ) . Unleaded Gasoline ...353 Untwisting Procedure, Seat Belt ...53 Vanity Mirrors ...99 Variance (Rear Seat Video System) ...259 Warning Flasher, Hazard ...384 Warning Lights (Instrument - 2007 Dodge Caravan | Owner's Manual - Page 514
...448 Wheel Bearings ...446 Wind Buffeting ...33,184 Window Fogging ...300 Windows ...31 Power ...32 Rear Vent ...31,32 Windshield Washers ...156,432 Windshield Wiper Blades ...432 Windshield Wipers ...156 Wiper Blade Replacement ...432 Wiper, Rear ...303 Wipers, Intermittent ...157 Zone Control - 2007 Dodge Caravan | Owner's Manual - Page 515
NOTES - 2007 Dodge Caravan | Owner's Manual - Page 516
NOTES - 2007 Dodge Caravan | Owner's Manual - Page 517
NOTES - 2007 Dodge Caravan | Owner's Manual - Page 518
NOTES - 2007 Dodge Caravan | Owner's Manual - Page 519
NOTES - 2007 Dodge Caravan | Owner's Manual - Page 520
NOTES
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
-
249
-
250
-
251
-
252
-
253
-
254
-
255
-
256
-
257
-
258
-
259
-
260
-
261
-
262
-
263
-
264
-
265
-
266
-
267
-
268
-
269
-
270
-
271
-
272
-
273
-
274
-
275
-
276
-
277
-
278
-
279
-
280
-
281
-
282
-
283
-
284
-
285
-
286
-
287
-
288
-
289
-
290
-
291
-
292
-
293
-
294
-
295
-
296
-
297
-
298
-
299
-
300
-
301
-
302
-
303
-
304
-
305
-
306
-
307
-
308
-
309
-
310
-
311
-
312
-
313
-
314
-
315
-
316
-
317
-
318
-
319
-
320
-
321
-
322
-
323
-
324
-
325
-
326
-
327
-
328
-
329
-
330
-
331
-
332
-
333
-
334
-
335
-
336
-
337
-
338
-
339
-
340
-
341
-
342
-
343
-
344
-
345
-
346
-
347
-
348
-
349
-
350
-
351
-
352
-
353
-
354
-
355
-
356
-
357
-
358
-
359
-
360
-
361
-
362
-
363
-
364
-
365
-
366
-
367
-
368
-
369
-
370
-
371
-
372
-
373
-
374
-
375
-
376
-
377
-
378
-
379
-
380
-
381
-
382
-
383
-
384
-
385
-
386
-
387
-
388
-
389
-
390
-
391
-
392
-
393
-
394
-
395
-
396
-
397
-
398
-
399
-
400
-
401
-
402
-
403
-
404
-
405
-
406
-
407
-
408
-
409
-
410
-
411
-
412
-
413
-
414
-
415
-
416
-
417
-
418
-
419
-
420
-
421
-
422
-
423
-
424
-
425
-
426
-
427
-
428
-
429
-
430
-
431
-
432
-
433
-
434
-
435
-
436
-
437
-
438
-
439
-
440
-
441
-
442
-
443
-
444
-
445
-
446
-
447
-
448
-
449
-
450
-
451
-
452
-
453
-
454
-
455
-
456
-
457
-
458
-
459
-
460
-
461
-
462
-
463
-
464
-
465
-
466
-
467
-
468
-
469
-
470
-
471
-
472
-
473
-
474
-
475
-
476
-
477
-
478
-
479
-
480
-
481
-
482
-
483
-
484
-
485
-
486
-
487
-
488
-
489
-
490
-
491
-
492
-
493
-
494
-
495
-
496
-
497
-
498
-
499
-
500
-
501
-
502
-
503
-
504
-
505
-
506
-
507
-
508
-
509
-
510
-
511
-
512
-
513
-
514
-
515
-
516
-
517
-
518
-
519
-
520
 |
 |
TABLE OF CONTENTS
SECTION
PAGE
1
INTRODUCTION
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
3
2
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
9
3
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
91
4
UNDERSTANDING YOUR INSTRUMENT PANEL
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
203
5
STARTING AND OPERATING
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
307
6
WHAT TO DO IN EMERGENCIES
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
383
7
MAINTAINING YOUR VEHICLE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
411
8
MAINTENANCE SCHEDULES
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
465
9
IF YOU NEED CONSUMER ASSISTANCE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
485
10
INDEX
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
495
1
2
3
4
5
6
7
8
9
10