2012 Ford F550 Cab Diesel Supplement 3rd Printing - Page 39
2012 Ford F550 Cab Manual
Page 39 highlights
Maintenance and Specifications Draining the DFCM 1. Stop the vehicle and shut off the engine. WARNING: The vehicle must be stopped with the engine off when draining the DFCM. Fuel may ignite if the separator is drained while the engine is running or vehicle is moving. Note: Air will enter into the fuel system if the DFCM is drained while the system is running. The engine will not operate properly if air enters the system. 2. Locate the DFCM and place an appropriate container under the drain port (see illustration). 3. Rotate the drain counterclockwise until the O-ring is visible. Allow the DFCM to drain for approximately 25 seconds or until clean fuel is observed. Rotate the drain clockwise to tighten it. If no liquid drains, the drain may be clogged. Have the DFCM serviced by your authorized dealer. 4. Make sure that the drain valve is fully tightened, then remove the container from under the vehicle. Note: A loose drain valve can allow air to enter the fuel system and cause drivetrain issues. The engine will not operate properly. be sure that the drain valve is fully tightened. 5. Restart the engine. The WATER IN FUEL DRAIN FILTER or WATER IN FUEL DRAIN FILTER SEE MANUAL message and light should not be illuminated. If they continues to illuminate, have the fuel system checked and repaired. 39 2012 Diesel (67l) Supplement, 3rd Printing USA (fus)