Weber 1100 LP Owner Manual

Weber 1100 LP Manual

Get Weber 1100 LP PDF manuals and user guides View all Weber 1100 LP manuals
Add to My Manuals
Save this manual to your list of manuals

Weber 1100 LP manual content summary:

  • Weber 1100 LP | Owner Manual - Page 1
    1100 LP Gas Barbecue Owner's Manual Serial Number Please use this number in registering your warranty and any correspondence with the factory. WEBER WEBER ® NationalPROPANEGAS Association WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even
  • Weber 1100 LP | Owner Manual - Page 2
    a spare or disconnected LP tank under or near this barbecue. ƽ Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ƽ After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and burner obstructions before using
  • Weber 1100 LP | Owner Manual - Page 3
    to the ORIGINAL PURCHASER of this Weber Gas Barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, 10 years, Flavorizer Bars, 3 years, Cast Iron Cooking Grates, 5 years, All Remaining Parts, 5 years, when assembled and operated
  • Weber 1100 LP | Owner Manual - Page 4
    Weber. Weber, , Flavorizer and Crossover are registered U.S. trademarks; Perma-Mount, Gas Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Weber Gas Barbecues are covered under
  • Weber 1100 LP | Owner Manual - Page 5
    the grill. Flavorizer Bars heat just the right amount of drippings for flavoring, letting excess fat drip past to help prevent flare-ups. e) Weber Warm-Up Basket for additional cooking or warming space. f) Separate burners for temperature control. g) Crossover Ignition System with Gas Catcher
  • Weber 1100 LP | Owner Manual - Page 6
    General Instructions Your Weber Gas Barbecue is a portable outdoor cooking appliance. With the Weber Gas Barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce that "outdoor" flavor in
  • Weber 1100 LP | Owner Manual - Page 7
    . If a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. LP tank filler adapter Bottom tray Two cooking grates Control
  • Weber 1100 LP | Owner Manual - Page 8
    Wheel frame Caster frame Two frame connectors Work table Swing table assembly Left hand slide bar (assembly) Two Accessory trays Axle Warming rack Warm-Up Basket Five long Flavorizer Bars Eight short Flavorizer Bars Tank panel (assembly) Front panel Catch pan holder Catch pan Two drip pans Manifold
  • Weber 1100 LP | Owner Manual - Page 9
    WE B Two wheels ER Fuel scale assembly Two casters Check contents of hardware packs Three burner control knobs Three tool holders Five tubing plugs (two are spares) Swing table end bracket Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size)
  • Weber 1100 LP | Owner Manual - Page 10
    the block of wood (or other protected surface). Tap on one hubcap. Put one wheel on the axle, WEBER side toward the hubcap. Slide the axle through the frame. Add the other wheel, WEBER side out. Tap on the hubcap. Figure 1. ER WE B ER WE B Step 3 Assemble top frame You will need
  • Weber 1100 LP | Owner Manual - Page 11
    Step 4 Continue frame assembly You will need: caster frame, wheel frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wrench. Place the caster frame onto the tabs of the left frame with the dimple to the inside. Figure 3. Place the wheel frame onto the tabs of the right frame
  • Weber 1100 LP | Owner Manual - Page 12
    with the holes in the frame and insert the plastic buttons through the front panel and frame. Figure 6. Plastic buttons Figure 5 View from rear of barbecue Figure 6 12
  • Weber 1100 LP | Owner Manual - Page 13
    hose. Set the cooking box in the frame so the burner tubes are under the frame brace. Figure 7. Burner tubes Frame brace Your Weber Gas Barbecue burner burners are correctly aligned. If you answered NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use barbecue. Guide
  • Weber 1100 LP | Owner Manual - Page 14
    Step 9 Install manifold bracket You will need: manifold bracket Hook the bracket onto the manifold at the center burner valve. Place your hand underneath the bracket. Lift the manifold, bracket and cooking box slightly and hook the tab of the bracket onto the frame
  • Weber 1100 LP | Owner Manual - Page 15
    13. Step 12 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter. This was done to factory test the ignition Insert the top of the igniter up through the large part of the keyhole in the frame brace. Figure 14 (b). Loosen the igniter lock
  • Weber 1100 LP | Owner Manual - Page 16
    satisfaction, then call Weber-Stephen Products Co., Customer Service Center. To fill, take the LP tank to an RV center, or look up gas-propane in the phone book for other sources of LP gas. ƽWARNING: We recommend that your LP tank be filled at an authorized LP gas dealer by a qualified attendant
  • Weber 1100 LP | Owner Manual - Page 17
    Step 15 Check that all burner valves are off You will need: one burner control knob. Valves are LP tank onto the fuel scale. Loosen the tank lock wing nut. Swing the tank lock down. Tighten the wing nut. Figure 17. E Tank lock wing nut F Figure 17 (a) Male fitting Collar Hose Regulator
  • Weber 1100 LP | Owner Manual - Page 18
    water solution. If a leak persists after retightening the fitting, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. c) Valves to manifold connections. Figure 20 (c). d) The hose to regulator connection. Figure 20 (d). ƽWARNING: If there is a leak at connections
  • Weber 1100 LP | Owner Manual - Page 19
    Step 18 Install Flavorizer Bars and Cooking Grates You will need: five long Flavorizer Bars, eight short Flavorizer Bars and two cooking grates. Set the long Flavorizer Bars side to side in the lower position, then set the short Flavorizer Bars front to back in the upper position in the cooking box.
  • Weber 1100 LP | Owner Manual - Page 20
    cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small holes snug. Do not overtighten. Figure 27 (a). Push on the three burner control knobs. Figure 27 (b). Insert in frame brace (a) Crossover Ignition
  • Weber 1100 LP | Owner Manual - Page 21
    any way cracked or damaged, do not use swing table. Call our Customer Service Center to order a new part. ƽWARNING: The load limit for the swing table is 30 pounds. Hinge rod (a) (b) (c) (b) Support rod (a) Figure 28 View from rear of barbecue Slot in frame (view from below) (c) Figure 29 21
  • Weber 1100 LP | Owner Manual - Page 22
    and pliers. Figure 30. Notch to the front Slide bar View from front of barbecue Step 23 Complete accessory installation You will need: Warm-Up . (a) (b) (e) (c) (f) Slide Support rod View from rear of barbecue (d) Figure 32 ƽCAUTION: To keep the barbecue stationary, the tabs on the locking
  • Weber 1100 LP | Owner Manual - Page 23
    nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using only Weber authorized replacement manifold assembly. Order from WeberStephen Products Co., Customer Service Center or authorized dealer. Crossover Ignition System 1 3 8 6 4 72
  • Weber 1100 LP | Owner Manual - Page 24
    tank valve, the excess flow control will activate, limiting the flow of gas from the LP tank. If this should occur, turn OFF the LP tank valve and burner control knobs and start over. 1 Manual Lighting 3 8 5 7 2 4 6 Figure 2 ƽ DANGER When the excess flow control is activated, a small amount of
  • Weber 1100 LP | Owner Manual - Page 25
    the correct cooking temperatures. ƽCAUTION: Replace thermometer in lid when not in use. Do not leave thermometer in food while cooking. If burners go out during cooking, open lid, turn off all burners and wait 5 minutes before relighting. Preheating Your Weber Gas Barbecue is an energy efficient
  • Weber 1100 LP | Owner Manual - Page 26
    : Turn your Weber Gas Barbecue OFF and wait for it to cool before cleaning. ƽCAUTION: Do not clean your Flavorizer Bars or cooking grates in a self-cleaning oven. Replacement cooking grates and Flavorizer Bars are available through your retailer or the Weber-Stephen Customer Service Center. Outside
  • Weber 1100 LP | Owner Manual - Page 27
    Cast Iron Cooking Grates ƽWARNING: Follow all safety instructions provided with your barbecue. Do not drop cast iron grates, they will vegetable cooking spray and heat in grill or oven as indicated above. Maintenance - Clean grates by turning on the barbecue burner control knobs to HHH and wipe
  • Weber 1100 LP | Owner Manual - Page 28
    tanks are not compatible with your barbecue connection. Scale setting wing nut Tank lock wing nut Connecting the filled LP tank ƽWARNING: Make sure that the LP tank valve is closed. Close by turning clockwise. ƽ DANGER Do not use an open flame to check for gas leaks. Be sure there are no sparks or
  • Weber 1100 LP | Owner Manual - Page 29
    fitting If leak does not stop, turn off the gas and contact Weber-Stephen Customer Service. Do not use the barbecue. g) When leak checks are complete, turn gas supply OFF and rinse connections with water. LP Tank The LP tank manufacturer is responsible for the materials, workmanship and performance
  • Weber 1100 LP | Owner Manual - Page 30
    , bugs etc. Liquid Propane (LP) Tank(s) s The LP tank and connections supplied with your Weber Gas Barbecue have been designed and tested to meet government, American Gas Association and Underwriters Laboratories requirements. s Replacement LP tanks supplied by Weber satisfy the requirements. Check
  • Weber 1100 LP | Owner Manual - Page 31
    , abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using only Weber authorized replacement manifold assembly. Order from WeberStephen Products Co., Customer Service Center or authorized dealer. s Inspect the burners for correct flame pattern. Clean
  • Weber 1100 LP | Owner Manual - Page 32
    ports are fully open. Figure 13 ƽCAUTION: Do not enlarge the burner ports when cleaning. Replacing Main Burners a) Your Weber Gas Barbecue must be OFF and cool. b) Turn gas OFF at source. c) Remove control panel: take off the burner control knobs. Remove the screws holding the control panel in place
  • Weber 1100 LP | Owner Manual - Page 33
    separate the crossover tube from the burners. Figure 17. Remove the burners from the cooking box. Crossover tube Venturi fin Check fit around valve Check fit around burner Figure 19 ƽCAUTION: If the Spider Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. Figure 17 33
  • Weber 1100 LP | Owner Manual - Page 34
    the Crossover Ignition System fails to ignite the Front burner, light the Front burner with a match. If the Front burner lights with a match, then check the Crossover Ignition Crossover Ignition System still fails to light, contact Weber-Stephen Customer Service. White wire Black wire Figure 20 34
  • Weber 1100 LP | Owner Manual - Page 35
    check the Crossover Ignition System. Experiencing flare-ups: Are you preheating barbecue in the All burners on high for 10 to 15 prescribed manner? minutes for preheating. Are the cooking grates and Flavorizer Bars heavily coated with burned-on grease? Clean thoroughly. (See Section "Periodic
  • Weber 1100 LP | Owner Manual - Page 36
    1 2 3 4 5 6 7 8 9 10 11 12 13-14 15 16 17 18-19, 11 10-14 20 21 22 23 24 ® ® E BE R W E BE R W 31 25 26 27 28 29 30 32 33 36 34 35 36 38 37 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 66 56-60 61 62-63 64 65
  • Weber 1100 LP | Owner Manual - Page 37
    manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Hicks Road Palatine, IL 60067-6241 USA (800) 446-1071 1 Lid (assembly) 2 Lid handle 3 Warm-Up Basket 4 Warming rack 5 Short Flavorizer bars (8) 6 Long Flavorizer bars
  • Weber 1100 LP | Owner Manual - Page 38
  • Weber 1100 LP | Owner Manual - Page 39
  • Weber 1100 LP | Owner Manual - Page 40
    a Weber Barbecue. Our family here at Weber has worked hard to produce the highest quality products for your satisfaction. While we give much attention to our products, an occasional error may occur. Our knowledgeable Customer Service staff is prepared to help you with any problems with parts or
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
W
E
B
E
R
W
E
B
E
R
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.
FOR YOUR SAFETY
1.
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
2.
An LP tank not connected for use shall
not be stored in the vicinity of this or
any other appliance.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
1100 LP
Gas Barbecue
Serial Number
Please use this number in registering your warranty and
any correspondence with the factory.
Owner’s Manual
National
Association
PROPANE
GAS
®
98652
10/97