Weber Genesis 1500 NG Owner Manual

Weber Genesis 1500 NG Manual

Get Weber Genesis 1500 NG PDF manuals and user guides View all Weber Genesis 1500 NG manuals
Add to My Manuals
Save this manual to your list of manuals

Weber Genesis 1500 NG manual content summary:

  • Weber Genesis 1500 NG | Owner Manual - Page 1
    any correspondence with the factory. GENESIS®1500 Natural Gas Barbecue Owner's Manual ® WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. NOTICE TO INSTALLER: These instructions must be left with the owner
  • Weber Genesis 1500 NG | Owner Manual - Page 2
    assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ƽ After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas leaks and away from LP tank. 2. Do not attempt to correct the problem yourself. 3. Call your fire department. 2
  • Weber Genesis 1500 NG | Owner Manual - Page 3
    and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of your date service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner's manual
  • Weber Genesis 1500 NG | Owner Manual - Page 4
    ; Perma-Mount, Gas Catcher, FlameCheck, Steam-N-Chips, Spider Stopper, and Warm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Genesis Gas Barbecues are covered under the following patent nos.: U.S.A. #4,677,964; 4,727,853; #4,777,927
  • Weber Genesis 1500 NG | Owner Manual - Page 5
    Instructions 6 Assembly 13-25 Operating Instructions Lighting 26-27 Cooking 28 After a Period of Nonuse 28 Cleaning 28 Troubleshooting & Maintenance Annual Maintenance 29 General Maintenance 30-32 Troubleshooting to help prevent flare-ups. e) Weber Warm-Up Basket for additional cooking or
  • Weber Genesis 1500 NG | Owner Manual - Page 6
    instructions will give you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before using your Weber from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system
  • Weber Genesis 1500 NG | Owner Manual - Page 7
    inches of water column pressure (.2526 psi). s A manual shut-off valve must be installed outdoors, immediately ahead of . s The stiffener should be assembled flush with the end of the tube and extend at least to the outside edge of the compression fitting. Contact Weber-Stephen Customer Service. 7
  • Weber Genesis 1500 NG | Owner Manual - Page 8
    barbecue Outside Accessible Locking Shut off Indoor Shut off Figure 1 Inside Gas Supply ƽCAUTION: Follow "General Specifications for Piping" in this manual. We recommend that this installation be done by a professional. ƽCAUTION: Combustible materials should never be within 24 inches of the top
  • Weber Genesis 1500 NG | Owner Manual - Page 9
    Recommended concrete pad requirements We recommend a pad a minimum of 40 inches left to right, 20 inches front to back and 4 inches deep (1.85 cubic feet). Figure 4. Note - Cubic feet is determined by multiplying length times width times depth and dividing by 1728. 20" 40" 4" Figure 4 If you use
  • Weber Genesis 1500 NG | Owner Manual - Page 10
    error may occur. If a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. Work table Gas supply line (with the flare
  • Weber Genesis 1500 NG | Owner Manual - Page 11
    Left frame Right frame Side frame (2) Accessory rack Warm-Up Basket Warming Rack Five long Flavorizer Bars Eight short Flavorizer Bars Side panel (2) Base panel Front Panel Cooking grate (2) Catch pan holder Catch Pan Drip pans (2) Thermometer Condiment basket 11
  • Weber Genesis 1500 NG | Owner Manual - Page 12
    Check contents of hardware packs Three burner control knobs Three tool holders Three tubing plugs Manifold bracket Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) One 1/4-20 x 2 inch bolts (actual size) Six 1/4-20 x 1/2 inch bolts (actual size)
  • Weber Genesis 1500 NG | Owner Manual - Page 13
    Step 2 Assemble the frame You will need: left frame, right frame, two nylon washers, two 1/4-20 x 1/2 inch bolts and a 7/16 inch wrench. Note - Work on carpeted area (on grass, or on one of the boxes) to protect the finish during frame assembly. Put the frame pieces so the leg tabs are up. Put the
  • Weber Genesis 1500 NG | Owner Manual - Page 14
    Step 4 Measure and drill holes You will need: Completed frame assembly, base panel, tape measure, and pencil. ƽCAUTION: Combustible materials should never be within 24 inches of the top, bottom, back or sides of the barbecue. Do not locate under overhead combustible construction. Note - With the lid
  • Weber Genesis 1500 NG | Owner Manual - Page 15
    Typical installation of the base for an existing concrete patio, new pad or wood deck (continued) Method 1 - Concrete A strike anchor, a minimum size of 3/8 inch x 3 1/2 inches long with a 3/8 inch flat washer and 3/8 inch nut. Figure 6. Note - Use a 3/8 inch diameter concrete drill bit for drilling
  • Weber Genesis 1500 NG | Owner Manual - Page 16
    for an existing concrete patio, new pad or wood deck (continued) Method 4 - Wood deck After assembling the base according to the assembly instructions, position the base assembly on your deck for anchoring. ƽCAUTION: Combustible materials should never be within 24 inches of the top, bottom, back
  • Weber Genesis 1500 NG | Owner Manual - Page 17
    tubes are under the frame brace. Figure 13. Note: Be careful when sliding the burner tubes through the side frame. Burner tubes Frame brace Your Weber NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use barbecue. Guide screw (a) Figure 13 Slide the cooking box
  • Weber Genesis 1500 NG | Owner Manual - Page 18
    Step 8 Connect barbecue gas supply line to the natural gas supply Note - We recommend that the connection between the barbecue gas supply line and the natural gas supply be flare to flare. A 3/8-inch flare fitting has been included with the barbecue gas supply line of your gas barbecue. The fitting
  • Weber Genesis 1500 NG | Owner Manual - Page 19
    Step 11 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter. This was done to factory test the ignition system. The igniter lock nut is on the igniter. Insert the top of the igniter up through the large part of the keyhole in the frame
  • Weber Genesis 1500 NG | Owner Manual - Page 20
    . Figure 22 (c). ƽWARNING: If there is a leak at connections b or c, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When leak checks are complete, turn gas supply OFF and rinse connections with water. (a) (b) Figure 21 ƽWARNING: Do not ignite burners while
  • Weber Genesis 1500 NG | Owner Manual - Page 21
    Step 14 Add base panel You will need: Base panel. Put the right side in and down, tilt and set the left side in place. Figure 23. Step 15 Install side panels You will need: two side panels, and eight plastic buttons. From the inside of the frame assembly, set the left side panel in place between
  • Weber Genesis 1500 NG | Owner Manual - Page 22
    Step 16 Install Flavorizer Bars and Cooking Grates You will need: five long Flavorizer Bars, eight short Flavorizer Bars and two cooking grates. Set the long Flavorizer Bars side to side in the lower position, then set the short Flavorizer Bars front to back in the upper position in the cooking box.
  • Weber Genesis 1500 NG | Owner Manual - Page 23
    Step 18 Install Lid You will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small holes in the hinge pins. Figure 30. Hair pin cotter Hinge pin Step 19 Add
  • Weber Genesis 1500 NG | Owner Manual - Page 24
    end bracket at an angle so the lower tab is inside the frame tube. Push the bracket into the frame. Figure 32 (b). Check to see that in any way cracked or damaged, do not use the condiment basket. Call our Customer Service Center to order a new part. Wire end (a) Step 21 Install the accessory rack
  • Weber Genesis 1500 NG | Owner Manual - Page 25
    Up Basket, warming rack, work table, three tubing plugs, thermometer and a hammer. Insert one end of the Weber Warm-Up Basket into the hole in the 34 (c). Insert the thermometer into its holder. Figure 34 (d). Insert the tubing plugs into the ends of the frame. To fully seat the plugs, you may
  • Weber Genesis 1500 NG | Owner Manual - Page 26
    Lighting Summary lighting instructions are on the control panel. ƽ DANGER Failure to open any way, do not use the barbecue. Replace using only Weber authorized replacement gas supply line. Order from WeberStephen Products Co., Customer Service Center. Crossover Ignition System 1 1) Open the lid.
  • Weber Genesis 1500 NG | Owner Manual - Page 27
    Manual Lighting ƽ DANGER Failure to open lid while igniting the barbecue, or not valve on. 4) Strike a match and put the flame into the matchlight hole in the front of the cooking box. Manual Lighting 1 ƽWARNING: If the burner does not light, turn the Front burner control knob to OFF and wait 5
  • Weber Genesis 1500 NG | Owner Manual - Page 28
    and BACK at medium). See your Weber cookbook for detailed cooking instructions. Note: The temperatures inside your your retailer or the Weber-Stephen Customer Service Center. Outside surfaces cooking box - Brush any debris off of burners tubes. DO NOT ENLARGE BURNER PORTS (OPENINGS). Wash inside
  • Weber Genesis 1500 NG | Owner Manual - Page 29
    gas supply connection. Figure 3 (c). ƽWARNING: If there is a leak at connections (b) or (c), turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When leak checks are complete, see steps "Add side panels" and "Add base panel" to reinstall. Turn gas supply OFF at the
  • Weber Genesis 1500 NG | Owner Manual - Page 30
    Tips occasionally yellowish Burner inside cooking box Light blue Air shutter Venturi fin Figure 4 The Weber Spider Stopper Guard is factory installed. It fits tightly around the air shutter section of the burner tube and the valve, thereby preventing spiders and other insects access to the burner
  • Weber Genesis 1500 NG | Owner Manual - Page 31
    guide screw and washer in the corners of the cooking box. Figure 11. Guide screw Figure 11 h) Lift and twist the burner assembly slightly, to separate the crossover tube not fit tightly, contact Weber-Stephen Customer Service. k) Reconnect gas supply line. See "Check for gas leaks". Figure 12
  • Weber Genesis 1500 NG | Owner Manual - Page 32
    loose in the frame. Tighten if necessary; see Step "Install igniter" for correct procedure. If the Crossover Ignition System still fails to light, See Section "Manual Lighting", and contact Weber-Stephen Customer Service. 32
  • Weber Genesis 1500 NG | Owner Manual - Page 33
    TROUBLESHOOTING Problem Burners burn with a yellow or orange flame, in conjunction with the smell of gas. Check Inspect Weber Spider Stopper Guards for possible obstructions. (Blockage of holes.) Cure Clean Weber run the whole length of the burner tube. Clean burners. (See Section "General
  • Weber Genesis 1500 NG | Owner Manual - Page 34
    1 2 3 4 5 6 7 8 9 10 11 12 13 14, 15 16 17 18 19 20 21 ® ® 22 23 25 24 16 26 34 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 51 43-47 9 48 49 50
  • Weber Genesis 1500 NG | Owner Manual - Page 35
    Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Hicks Control panel 34 Igniter button 35 Phillips screws/washers (2) 36 Crossover tube 37 Front and back burners (2) 38 Center burner 39 1/4-20
  • Weber Genesis 1500 NG | Owner Manual - Page 36
    problems with parts or assembly. Call our toll free number 1-800-446-1071. For quicker service, please have your owner's manual available for reference. We also welcome any comments or suggestions you might have regarding our products. We wish your family the best in outdoor cooking enjoyment. Weber
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
GENESIS
®
1500
Natural Gas Barbecue
Serial Number
Please use this number in registering your warranty
and any correspondence with the factory.
Owner’s Manual
98635
10/97
®
FOR YOUR SAFETY
Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.