2015 Kawasaki JET SKI Ultra LX Owners Manual

2015 Kawasaki JET SKI Ultra LX Manual

Get 2015 Kawasaki JET SKI Ultra LX PDF manuals and user guides View all 2015 Kawasaki JET SKI Ultra LX manuals

2015 Kawasaki JET SKI Ultra LX manual content summary:

  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 1
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 2
    people from injury.The first part of this manual, and the instructions under " DANGER" and " WARNING" in the instructions that follow these symbols to avoid accidents that could result in personal injury or death. ○NOTE indicates information that may help or guide you in the operation or service
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 3
    your JET SKI watercraft in a waterproof bag at all times so that you can refer to it whenever necessary. The information in this Owner's Manual may not completely match the actual product due to changes in the specifications. Please check your local boating laws and regulations before riding the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 4
    Quick Reference Guide This Quick Reference Guide will assist you in finding the information you're looking for. SAFETY INFORMATION PREVENT MAJOR DAMAGE GENERAL INFORMATION PRE-RIDE CHECK OPERATING INSTRUCTIONS TRANSPORTING AND STORAGE MAINTENANCE AND ADJUSTMENTS IN AN EMERGENCY APPENDIX j j j j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 5
    TABLE OF CONTENTS SAFETY INFORMATION ...Read Owner's Manual Thoroughly before Operation...Wear PFD, Protective Clothing Immobilizer Key Matching Indicator/"I9nI" Character/Warning Indicator Light...Communication Trouble Indicator/"Err" Character/Warning Indicator Light...Fuel ...Fuel Requirements ...
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 6
    , water skier, tuber, etc.) ...Towing a wakeboarder/water skier/tuber...Roles of the watercraft operator ...Roles of the observer ...Towing a personal watercraft...PRE-RIDE CHECK...OPERATING INSTRUCTIONS ... 50 52 52 53 54 55 55 56 56 57 57 57 57 58 59 59 60 61 63 64 64 65 65 66 67
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 7
    125 125 127 130 131 133 147 150 Bilge System Flushing...151 Jet Pump Bearings/Seals ...153 Fuses...153 IN AN EMERGENCY ...Troubleshooting Guide ...In the Case of Emergency ...Towing the JET SKI watercraft ...Jump Starting ...APPENDIX ...YOUR WARRANTY/OWNER SATISFACTION ...REPORTING SAFETY DEFECTS
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 8
    j Wear PFD, Protective Clothing and Gear • warning label on your JET SKI watercraft before operating. Be sure to observe these instructions. The owner's manual and the warning labels provide important safety information. Personal Flotation Device (PFD) All riders must wear a Coast Guard approved
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 9
    j 8 SAFETY INFORMATION j Important. Read this carefully. suit bottoms are made of a thick material • Wet (neoprene) that significantly retards the velocity Wet Suit Bottoms or Other Protective Clothing All riders must wear wet suit bottoms (neoprene shorts) or clothing that provides
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 10
    Important. Read this carefully. j SAFETY INFORMATION 9 Know Boating Laws Kawasaki recommends a minimum operator age of 16 years old. Know the operator age and training requirements for your state or region. A boating safety course is recommended and may be required in your state or region. Take a
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 11
    j 10 SAFETY INFORMATION j Important. Read this carefully. Attach Engine Shut-Off Cord (Lanyard) the engine shut-off cord (lanyard) to your • Attach wrist whenever operating this watercraft so that Ride within Your Limits within your limits and avoid aggressive ma• Ride neuvers to reduce the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 12
    Important. Read this carefully. j SAFETY INFORMATION 11 Do not Jump Wakes or Waves turns or jumping wakes or waves can in• Sharp crease the risk of back/spinal injury (paralysis), Never Ride after Consuming Drugs or Alcohol ride under the influence of or after consum• Never ing drugs or alcohol.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 13
    j 12 SAFETY INFORMATION j Important. Read this carefully. Do not Apply Throttle when Anyone is Behind Keep Away from Intake Grate away from the intake grate while the engine • Keep is on. - • Do not apply throttle when anyone is behind the JET SKI watercraft. - Turn the engine off or keep it
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 14
    Important. Read this carefully. j - SAFETY INFORMATION 13 Avoid Collision Collisions couse more injuries and deaths than any other type of personal watercraft accident. To avoid collisions, know the characteristics of your watercraft and observe all warnings. Scan constantly for people, objects,
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 15
    j 14 SAFETY INFORMATION j Important. Read this carefully. No Thrust = No Turn Ventilate Engine Compartment the engine compartment to ventilate it be• Open fore starting the engine. A concentration of gasoline fumes can cause a fire or explosion. Do not start the engine if there is a fuel leak
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 16
    / Modification Maintain your watercraft for safe operation by carrying out all maintenance items in the MAINTENANCE AND ADJUSTMENTS section of this owner's manual. Modifications to your watercraft may affect its stability or handling, and result in an unsafe riding condition or illegal condition for
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 17
    j 16 SAFETY INFORMATION j Follow Rules Important. Read this carefully. Never Operate after Dark not operate the watercraft after dark. It is not • Do designed for night use, and has no lighting equipment. all navigation rules and state and local laws • Follow that apply to PWCs.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 18
    Important. Read this carefully. This page intentionally left blank. j SAFETY INFORMATION 17 j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 19
    j 18 SAFETY INFORMATION j Important. Read this carefully. Label Location All warning labels on the vehicle are repeated here. Read the labels and understand them thoroughly. They contain information that is important for your safety and the safety of anyone else who may operate your vehicle.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 20
    Important. Read this carefully. (B) j SAFETY INFORMATION 19 j (C)
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 21
    j 20 (C) SAFETY INFORMATION j Important. Read this carefully.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 22
    Important. Read this carefully. (D) j SAFETY INFORMATION 21 j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 23
    j 22 SAFETY INFORMATION j (E) Important. Read this carefully. (F)
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 24
    Important. Read this carefully. (G) j SAFETY INFORMATION 23 (I) For detail explanation see APPENDIX (page 165) j (H)
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 25
    j 24 SAFETY INFORMATION j (K) Important. Read this carefully. (J)
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 26
    Important. Read this carefully. (L) j SAFETY INFORMATION 25 j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 27
    26 PREVENT MAJOR DAMAGE j NOTICE PREVENT MAJOR DAMAGE Certain conditions can cause major damage to your watercraft that is costly to repair. To avoid these conditions carefully read the following section and follow the recommendations to help prevent major damage to your watercraft. j Tilting
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 28
    boat clockwise so that the PORT side always faces downward. For details on righting, refer to Righting the Capsized Watercraft section in the OPERATING INSTRUCTIONS chapter. or debris from the bottom may be drawn into the jet pump and damage the pump and impeller, and possibly clog cooling lines
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 29
    28 PREVENT MAJOR DAMAGE j After daily riding JET SKI watercraft are not designed to be • Since docked in water for extended periods, prolonged Wave Jumping waves can overstress the watercraft hull • Jumping and cause it to crack. To prevent hull cracks, do not jump waves. j immersion will cause
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 30
    Periodic Maintenance • The jet pump bearings and seals require periodic service. Major engine damage can occur if the jet pump bearings every year, whichever comes first. The jet pump bearings should also be serviced before any prolonged storage to prevent any water that may be left in the pump
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 31
    30 GENERAL INFORMATION j A. Battery B. Rear View Mirror C. Front Storage Case D. Multifunction Meter E. Engine Start/Stop Button F. Throttle Lever G. Handlebars H. Center Storage Case I. Ignition Switch J. Engine Shut-off Lanyard K. Shift Lever L. Bow Eye GENERAL INFORMATION Parts Location j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 32
    jGENERAL INFORMATION 31 j A. Handrails B. Ski Tow Eye C. Seat Latch D. Rear Seat E. Front Seat F. Water Supply Inlet Fitting (inside hatch cover) G. Bypass Outlet H. Engine Compartment I. Hand Strap A. Stern Eyes B. Reboarding Step C. Reverse Bucket D. Exhaust Outlet E. Drain Screws F. Steering
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 33
    32 GENERAL INFORMATION j j A. Jet Pump Cover B. Water Intake C. Grate D. Drive Shaft E. Speed Sensor A. B. C. D. Air Box Exhaust Pipe Spark Plugs Fuel Injectors
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 34
    jGENERAL INFORMATION 33 Multifunction Meter Ahead of the handlebars is a multifunction meter. When the ignition switch is turned on, all displays on the panel are shown; the warning indicator light is on and buzzer will sound twice. After this self-check procedure, the meter display shows the normal
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 35
    34 GENERAL INFORMATION j j 1. "MODE" Button 2. "SET" Button 3. Multifunction Display Clock Time/Trip/Hour Meters Tachometer (Numerical Value) Maximum Speed & Engine rpm Water Temperature Outside Temperature Fuel Consumption 4. Engine Warning Indicator 5. Engine Cooling Water Temperature
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 36
    jGENERAL INFORMATION 35 Speedometer The speedometer shows the watercraft speed. During a sharp turn the speed shown can be slightly higher or lower than the actual speed by turning direction. Tachometer The tachometer shows the engine speed in revolutions per minute (rpm). On the right side of the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 37
    36 GENERAL INFORMATION j j Multifunction Displays The Clock, Time/Trip/Hour Meters, Tachometer, Maximum Speed & Engine rpm, Water Temperature, Outside Temperature and two Fuel Consumptions will be displayed under the speedometer. Pushing the "MODE" button, shifts the display. These modes will
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 38
    jGENERAL INFORMATION 37 ○Briefly pushing the "MODE" button advances the NOTE hours or minutes step by step. Holding the button down advances the hours or minutes continuously. ○The clock works normally from the back-up power while the ignition switch is turned off. ○When the battery is disconnected,
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 39
    38 GENERAL INFORMATION j Trip Meter The trip meter shows the distance traveled since it was last reset to zero. To reset the trip meter: 1. Push the "SET" button and hold it in. All the displays in this mode start blinking. 2. After two seconds the displays stop blinking and the trip meter turns to
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 40
    jGENERAL INFORMATION 39 Hour Meter The hour meter shows the total hours that the watercraft has been operated. This meter cannot be reset. j ○The data is maintained even if the battery is disconnected. ○When the figures reach 9999, they reset to 0000 and start counting upward again when the craft
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 41
    40 GENERAL INFORMATION j Maximum Speed & Engine rpm The maximum speed recorded since last reset and its corresponding engine rpm are shown. "rpm" symbol blinks in this mode. j Tachometer (Numerical Value) The tachometer shows the engine speed in revolutions per minute (rpm). To reset this record:
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 42
    jGENERAL INFORMATION 41 Water Temperature This shows the ambient water temperature in degrees Centigrade (or Fahrenheit) and the display is refreshed every 5 seconds. j Outside Temperature This shows the ambient (or outside) temperature in degrees Centigrade (or Fahrenheit) and the display is
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 43
    42 GENERAL INFORMATION j Fuel Level Gauge/"FUEL" Character/Warning Indicator Light The fuel level is shown in segments. All fuel segments are displayed when the fuel tank is full. As the fuel is consumed, the segments go out accordingly. When the last segment is reached, it begins blinking. The
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 44
    jGENERAL INFORMATION 43 Engine Oil Indicator/"OILP" Character/Warning Indicator Light The warning indicator light goes on, the engine oil indicator and "OILP" blink and a buzzer sounds whenever the oil pressure is dangerously low. The engine speed will automatically be limited to 3 000 rpm. Return
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 45
    be limited to 3 000 rpm. Return to shore immediately and check the cooling system for clogging (see the Special Procedures section in the Operating Instructions chapter). To stop the buzzer, press any button for more than a second. NOTICE To prevent engine damage, do not operate the craft until the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 46
    automatically be limited to 3 000 rpm. Return to shore immediately and have your authorized Kawasaki JET SKI watercraft dealer check your boat to determine the problem. To stop the buzzer, press any button for more than a second. j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 47
    is other than a clogged cooling system or low oil level, have your authorized Kawasaki JET SKI watercraft dealer check your PWC to determine the problem (see the TROUBLE SHOOTING for instances when the engine speed will automatically be limited to 3 000 rpm). To stop the buzzer, press any button for
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 48
    jGENERAL INFORMATION 47 Indicator/"Innb" Immobilizer Amplifier Character/Warning Indicator Light If the amplifier for the immobilizer system malfunctions, the warning indicator light, the immobilizer indicator and "Innb" blink and a buzzer sounds. Have your authorized Kawasaki JET SKI watercraft
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 49
    Fuel j Indicator/"Err" Communication Trouble Character/Warning Indicator Light If there is a communication problem between the multifunction meter and the Antiknock Index shown in the tabel. The Antiknock Index is posted on service station pumps in the U.S.A. The octane rating of a gasoline is a
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 50
    rating. Gasoline quality is important. Fuels of low quality or not meeting standard industry specifications may result in unsatisfactory performance. Operating problems that result from the use of poor quality or nonrecommended fuel may not be covered under your warranty. Fuels Containing Oxygenates
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 51
    system. Before storage it is recommended that you drain all fuel from the fuel tank and fuel system. See the Storage section in this manual. WARNING Gasoline is extremely flammable and can be explosive under certain conditions. To avoid a possible fire or explosion, pull the lanyard key off the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 52
    jGENERAL INFORMATION 51 When filling remove the seats and observe the fuel level in the fuel tank to avoid overfilling. Also observe the fuel level gauge on the meter for the segments to increase while filling. Fill the tank with the recommended octane rating gasoline. The use of a small diameter
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 53
    52 GENERAL INFORMATION j Ignition Switch The ignition switch is located in the center storage case. This watercraft is equipped with two kinds of ignition keys, one of that controls the watercraft speed for the unskilled (Smart Learning Operation Mode, (SLO)) and the other for normal operation (
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 54
    jGENERAL INFORMATION 53 Smart Learning Operation mode (SLO) This watercraft is equipped with SLO, which reduces the maximum watercraft speed by approximately 30 percent. SLO mode is displayed on the meter as SLO, whereas the non-restricted ordinary mode is displayed as FPO. In SLO mode, all the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 55
    54 GENERAL INFORMATION j ○Three minutes after the engine stops, the meter display disappears and the ignition switch is turned off. When turning on the ignition switch again, push the ignition key forward. j How to use the Immobilizer-function keys Insert either the SLO or FPO key into the key
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 56
    jGENERAL INFORMATION 55 NOTICE The keys can be damaged by excessive heat, magnetic fields, heavy objects, shocks and if the plastic cover is damaged. To prevent key damage, do not expose the keys to excessively high temperatures, place them close to magnets or under heavy items, and avoid damaging
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 57
    56 GENERAL INFORMATION j Tilt Lever The handlebar tilt can be adjusted to suit you. Push down the tilt lever and move the handlebars up or down. There are five different angles to choose from. Controls Handlebars j A. Handlebars The handlebars allow the rider to steer the watercraft. It will
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 58
    jGENERAL INFORMATION 57 Kawasaki Smart SteeringTM (KSSTM) Your JET SKI watercraft can turn under certain conditions when the throttle is released. There must be thrust at the jet nozzle to initiate and complete turns. This is a supplemental steering system which assists operators in learning to
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 59
    and the engine shut-off lanyard key must be pushed under the stop button. ○Refer to the Starting the Engine section in the Operating Instructions chapter. A. Stop Button B. Lanyard Key NOTE riding, remove the engine shut-off lanyard • After key from PWC to avoid unauthorized use by children or
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 60
    the watercraft to slow down before shifting from Forward to Reverse. Refer to the Operating the JET SKI Watercraft in Reverse section in the OPERATING INSTRUCTIONS chapter.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 61
    60 GENERAL INFORMATION j Seat Latches There are two individual seats that can be unlocked using the latch under the rear of each seat. Remove the rear seat first. The procedure to open and close is the same for both seats. To Open: Pull the latch handle and pull the seat up and to the rear. To
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 62
    jGENERAL INFORMATION 61 Storage Compartment The box type storage case is located in the bow. Store this Owner's Manual there in a plastic bag. To open the lid, pull the knob and raise the lid all the way up. To close the lid, push on
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 63
    62 GENERAL INFORMATION j A container for a fire extinguisher is attached to the storage case. (A fire extinguisher is not standard equipment with this watercraft.) j A. Battery (Fuse) Cover B. ECU Cover A. Front Storage Case B. Fire Extinguisher NOTICE Running the watercraft without the storage
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 64
    jGENERAL INFORMATION 63 Center and Rear Storage Cases There is a center storage case in front of the seat. The ignition switch is inside this case. To open the lid, pull the knob. To close the lid, push the knob until it latches. j A. Rear Storage Case B. Drain Plugs A. Center Storage Case B.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 65
    64 GENERAL INFORMATION j Bilge Systems This watercraft has a jet vacuum drainage system at the rear end of the engine compartment. This system utilizes the water jet for propulsion to drain the bilge in the engine compartment. This system only works when the engine is running on water. Tool Kit
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 66
    jGENERAL INFORMATION 65 Drain Screws There are two drain screws in the stern to drain water accumulated in the engine compartment. Open them only when the craft is out of the water. Handrail The handrail behind the seat is for boarding from deep water. Also, when towing a water skier, wakeboarder,
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 67
    water by using this step and the handrail behind the rear end of the seat (see the Safe Operation and Launching sections in the OPERATING INSTRUCTIONS chapter). This step is designed only for reboarding from deep water, do not use it for pulling other craft. not use the reboarding step while
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 68
    , make sure that it is not overloaded and that you have followed these instructions. Maximum load Maximum load: 225 kg (496 lb) the total weight of not interfere with its operation. Do not carry animals on your watercraft. Instruct any passengers before riding to hold on to the person in front of
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 69
    68 GENERAL INFORMATION j a cargo net (not standard equipment with this • Use watercraft) or other suitable tie-down straps to se- j • • cure cargo on the open storage area. The hook under the rear end of the seat and the stern eyes are also available. Do not overload the storage area, maximum
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 70
    jGENERAL INFORMATION 69 Towing (a wakeboarder, water skier, tuber, etc.) Towing a wakeboarder/water skier/tuber Towing a wakeboarder, water skier, or tuber is a three-person team sport involving the watercraft operator, the backward-facing observer and the wakeboarder/skier/tuber. Everyone must know
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 71
    after the tow rope to prevent it from entering the water intake. Towing a personal watercraft If your watercraft runs out of fuel, develops engine problems, or needs to be towed by another watercraft, or if your watercraft needs to tow another watercraft in similar situations, tie a tow rope to
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 72
    jGENERAL INFORMATION 71 towed boats. Towing must be slow, not exceeding 8 km/h. Be extra careful when towing; towing can affect the steering of your watercraft and create a hazardous situation. NOTICE When your watercraft is being towed by another watercraft, ensure that at least one person is on
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 73
    72 PRE-RIDE CHECK j PRE-RIDE CHECK Cables section in the MAINTENANCE AND ADJUSTMENTS chapter). □ THROTTLE CONTROL - Check the operation of the throttle for binding, rough spots or excessive play. Adjust the cable if needed (see the Control Cables section in the MAINTENANCE AND ADJUSTMENTS chapter).
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 74
    jPRE-RIDE CHECK 73 □ BATTERY TERMINALS - Check the battery terminal screws for tightness, and make sure terminal covers are in place. □ DRAIN BILGE - Drain any water out of the engine WARNING Loose battery cables can create sparks which can cause a fire or explosion resulting in injury or death.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 75
    74 PRE-RIDE CHECK j □ MULTIFUNCTION METER - Check the operation of the multifunction meter. See GENERAL INFORMATION chapter for details. □ STORAGE COMPARTMENT - Check that the lid is secure. □ RIDER PROTECTION - Always wear the proper flotation device and protective gear. j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 76
    jOPERATING INSTRUCTIONS 75 OPERATING INSTRUCTIONS Basic Knowledge for Operation Read "SAFETY INFORMATION" and "PREVENT MAJOR DAMAGE" without fail. Please be sure to conduct the PRE-RIDE CHECK before boarding. Operation
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 77
    76 OPERATING INSTRUCTIONS j passengers wear a vest-type PFD (type 1, 2 or 3) at all times. state regulations before operating. Kawasaki recommends that all operators complete an approved boating safety course.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 78
    jOPERATING INSTRUCTIONS 77 riders must wear a Coast Guard approved personal flotation device (PFD) that is suitable for • All personal watercraft (PWC) use. Kawasaki recommends a vest-type PFD.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 79
    78 OPERATING INSTRUCTIONS j Because the watercraft is an inboard boat less than 4.8 m (16 ft) in length, federal regulations require that a fire extinguisher rated "B-1" (minimum 1 kg or 2 pound capacity)
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 80
    jOPERATING INSTRUCTIONS 79 Standard equipment does not include a fire extinguisher. Many owners prefer to provide their own fire extinguishers. If you wish, your dealer can furnish you
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 81
    80 OPERATING INSTRUCTIONS j Basic Operating and Riding Posture on the Seats When riding the watercraft, sit astride the seat. abrupt movement of the boat causing possible injury to
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 82
    jOPERATING INSTRUCTIONS 81 • Sit astride the seat. Operator and Passengers the operator is balancing the craft, the pas• While sengers climb aboard from the rear of the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 83
    82 OPERATING INSTRUCTIONS j WARNING A JET SKI watercraft requires throttle (thrust) to steer Kawasaki JET SKI watercraft dealer after the first ten hours of operation for initial maintenance service. See the Periodic Maintenance Chart in the MAINTENANCE AND ADJUSTMENTS chapter. Stopping the Engine
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 84
    . If the throttle fails, do not operate the watercraft until the source of the problem is found and corrected. transporting or refueling and before starting • After the engine, open PRE-RIDE CHECK chapter in this manual and follow its instructions before putting the watercraft in the water. •
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 85
    84 OPERATING INSTRUCTIONS j ○This NOTE watercraft is equipped with two kinds of ignition keys, SLO and FPO. Choose an appropriate key depending on your skill. These keys are
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 86
    jOPERATING INSTRUCTIONS 85 the engine has started, allow it to warm up for • After about 1 indicates that cooling water is circulating. If there is none, shut off the engine and find the source of the problem. When the exhaust system is dry, it can take up to 15 seconds for water to appear at the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 87
    86 OPERATING INSTRUCTIONS j • the craft to swing, since the watercraft turns at the stern and not at the bow. Check that your path is clear and move the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 88
    jOPERATING INSTRUCTIONS 87 alert for other watercrafts, swimmers, or ob• Keep structions in your path. Stopping the JET SKI Watercraft Shallow Water Start • • WARNING This high-performance
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 89
    88 OPERATING INSTRUCTIONS j 3. Press the stop button or pull the lanyard key off the stop button to stop the engine. NOTICE When starting the engine or riding, the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 90
    jOPERATING INSTRUCTIONS 89 operating speed. Experienced operators can usually shorten stopping distance by using various riding techniques. Turning the boat sharply (using the throttle) while stopping is a
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 91
    90 OPERATING INSTRUCTIONS j Less thrust from the jet pump makes the boat turn less sharply. Using the throttle is another important part of turning maneuvers. Applying the throttle
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 92
    jOPERATING INSTRUCTIONS 91 If you release the throttle completely, there is little thrust from the jet pump. The boat turns slowly and steering ability is reduced. If
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 93
    92 OPERATING INSTRUCTIONS j WARNING Suddenly shifting into reverse at high speed can cause the bow to suddenly dive into the water, throwing the occupants forward which can cause
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 94
    jOPERATING INSTRUCTIONS 93 NOTICE When starting the engine or riding, the watercraft must be in water at least 0.8 m (2.5 ft) deep. Sand or debris from the bottom may
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 95
    94 OPERATING INSTRUCTIONS j NOTICE To prevent severe engine damage, immediately stop the engine if the craft capsizes. If it continues running whilst capsized, water can enter the throttle
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 96
    jOPERATING INSTRUCTIONS 95 rear, trying not to let more water into the engine compartment under the seats. After Submerging ○If you have a passenger, he or she may
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 97
    96 OPERATING INSTRUCTIONS Summary of the procedure j Details of the steps 1. 2. 3. Remove the craft from the water, and remove the seat. Remove the drain screws in the stern
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 98
    jOPERATING INSTRUCTIONS 97 ○If you see water in the drain caps, there is a strong possibility that water has entered the intake manifold. Take the watercraft to a Kawasaki dealer for service that requires removing some adjacent components for access. NOTE 9. 5. 6. Remove the drain plug of the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 99
    98 OPERATING INSTRUCTIONS j 15. If the oil looks milky, then change the oil and protect the environment, do not discard gasoline; always return it to an authorized recycling center. 18. Continued problems may require cleaning of the fuel line to drain water. 19. Reinstall the seats and secure them.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 100
    jOPERATING INSTRUCTIONS 99 any foreign matter (like salt) out through the exhaust. End of the Day Checklist ○If NOTE this procedure seems difficult and beyond your mechanical
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 101
    100 OPERATING INSTRUCTIONS j NOTICE Water can enter the engine through the airbox and cause severe engine damage, and shorts in electrical equipment. To prevent water damage, cover the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 102
    jOPERATING INSTRUCTIONS 101 WARNING The jet pump contains moving parts that can cause severe injury. To prevent injury, never attempt to clear the jet pump of debris
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 103
    102 OPERATING INSTRUCTIONS j NOTICE Engine cooling water is supplied by the jet pump, and any loss of pump performance may cause overheating resulting in severe engine damage. To
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 104
    jTRANSPORTING AND STORAGE 103 TRANSPORTING AND STORAGE Transporting transporting the watercraft on a trailer, ob• When serve the trailer laws and regulations in your area. sure the trailer matches with the craft's weight • Be and hull design. fasten the watercraft to prevent move• Securely ment
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 105
    so that when the time comes to use it again, it will be in top condition. See your Kawasaki JET SKI watercraft dealer for this service or do the following. NOTICE A. Bow Eye j NOTICE Only use the bow and stern eyes when fastening the watercraft to the trailer. Since JET SKI
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 106
    jTRANSPORTING AND STORAGE 105 storing the watercraft in an area where the • When temperature drops below freezing, perform the following. Discharging water in the exhaust system NOTICE Water remaining in the exhaust system during cold weather could freeze and damage the exhaust pipe. To prevent
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 107
    securely to the fitting. If you are not confident you can perform storage procedures, ask your Kawasaki JET SKI watercraft dealer for this service. A. Nuts B. Bolts C. Handrail Plate the bilge system (see the Bilge System • Clean Flushing section in the MAINTENANCE AND AD- JUSTMENTS chapter), and
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 108
    jTRANSPORTING AND STORAGE 107 WARNING Gasoline is extremely flammable and can be explosive under certain conditions. To avoid a possible fire or explosion, pull the lanyard key off the stop button. Do not smoke. Make sure the area is well ventilated and free from any source of flame or sparks; this
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 109
    108 TRANSPORTING AND STORAGE j fogging oil directly into each cylinder. • Spray the engine over several times with the start • Turn button to coat the cylinder walls. NOTICE To prevent overheating resulting in engine and exhaust system damage, do not run the engine with the watercraft out of the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 110
    or one year, whichever comes first; and then every 50 hours or every year, whichever comes first. The jet pump bearings should also be serviced before any prolonged storage to prevent any water that may be left in the pump from corroding the bearings and causing premature failure. Battery j the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 111
    from Storage The following procedure explains the steps necessary to put the watercraft back in service following a storage period. See your Kawasaki JET SKI watercraft dealer for this service, or do the following. See the MAINTENANCE AND ADJUSTMENTS chapter for detailed procedures. Carry out
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 112
    jTRANSPORTING AND STORAGE 111 them if necessary. Reinstall the cover, • Replace apply non-permanent locking agent to the bolts before tightening securely. Bolts Tightening Torque: 7.8 N·m (0.80 kgf·m, 69 in·lb) that the drain screws in the stern are se• Check curely tightened. the terminals of the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 113
    112 MAINTENANCE AND ADJUSTMENTS j MAINTENANCE AND ADJUSTMENTS The maintenance and adjustments outlined in this chapter must be carried out in accordance with the Periodic Maintenance Chart to keep the watercraft in good running condition. The initial maintenance is vitally important and must not
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 114
    the antiknock index is recommended. The antiknock index is posted on service station pumps in the U.S.A. Maintenance and Warranty Proper maintenance is the recommended maintenance is carried out according to the instructions in this Owner's Manual at your own expense. The Kawasaki Limited Emission
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 115
    114 MAINTENANCE AND ADJUSTMENTS j NOTE Periodic Maintenance Chart Complete the Pre-Ride Checklist before each outing. Frequency Initial 10 Description Inspect all hoses, hose clamps, nuts, bolts, and fasteners * Lube jet pump bearings and seals; inspect and replace bearings/seals if necessary
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 116
    jMAINTENANCE AND ADJUSTMENTS 115 Frequency Initial 10 Description Replace engine oil Replace engine oil filter * * Inspect/tighten engine mount bolts Inspect fuel vent check valve Inspect throttle control system Flush bilge line and filter Flush cooling system (after each use in salt water) * *
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 117
    116 MAINTENANCE AND ADJUSTMENTS j *: These items must be performed with the proper tools. See an authorized Kawasaki JET SKI watercraft dealer for service, unless you have the proper equipment and mechanical proficiency (refer to the Service Manual). ○: Emission Related j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 118
    jMAINTENANCE AND ADJUSTMENTS 117 Control Cables Throttle Cable Play Inspection There must be free play in the throttle mechanism. Measure the distance the throttle lever moves before the engine begins to pick up speed. Free play should be about 2 mm (0.08 in.). If there is improper play, adjust it.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 119
    118 MAINTENANCE AND ADJUSTMENTS j A. Handlebars A. Equal that the steering nozzle is at the same • Check distance from each side of the reverse bucket bracket. j it is not, adjust the steering cable. • If the locknut on the end of the steering ca• Loosen ble located to the right of the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 120
    jMAINTENANCE AND ADJUSTMENTS 119 A. B. C. D. Steering Nozzle Joint Bolt Locknut A. Joint B. Locknut the bolt and disconnect the cable joint • Remove from the steering nozzle. the handlebars in a straight ahead steering • Center position. • Turn the joint on the cable to adjust the steering. the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 121
    120 MAINTENANCE AND ADJUSTMENTS j Shift Cable Adjustment • Put the shift lever in the "F (Forward)" position. A. Equal Steering Cable Inspection j Steering cable inspection is best performed by an authorized Kawasaki JET SKI watercraft dealer. If the steering feels rough or "catchy", have your
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 122
    jMAINTENANCE AND ADJUSTMENTS 121 lower stopper on the bucket should • The against the rear edge of the pump cover. rest A. Reverse Bucket B. Steering Nozzle • Put the shift lever in the "R (Reverse)" position. A. Stopper B. Pump Cover End either position is incorrect, adjust the shift cable. •
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 123
    122 MAINTENANCE AND ADJUSTMENTS j A. Locknut B. Ball Joint C. Sleeve A. Hole B. Ball j back the outer sleeve and take the ball joint • Slide off the ball. the ball joint and reattach it so the lower edge • Turn of the bucket is held above the top of the nozzle allowing the bucket to have 2 ∼ 3
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 124
    jMAINTENANCE AND ADJUSTMENTS 123 Fuel System Throttle Adjustments Idle speed adjustment is best performed by your authorized Kawasaki JET SKI watercraft dealer. If the idle speed is unstable have your dealer inspect the throttle body. Idle Speed 1 300 ±100 rpm - in water 1 300 ±100 rpm - out of
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 125
    124 MAINTENANCE AND ADJUSTMENTS j Engine Oil In order for the engine to function properly, maintain the engine oil at the proper level, and change the oil and replace the oil filter in accordance with the Periodic Maintenance Chart. Not only do dirt and metal particles collect in the oil, but the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 126
    oil if necessary. Refer to the Pre-Ride Check List in Operating Instruction chapter. Whenever you check the oil level, keep your watercraft level side vehicle. Consistent use of these products meets or exceeds warranty and service requirements and can help to extend the life of your Kawasaki engine
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 127
    126 MAINTENANCE AND ADJUSTMENTS j A. Level Ground B. Side Bumper C. Parallel A. Dipstick B. Dipstick Tube C. Left side j the dipstick, wipe it dry and insert it back • Remove into the dipstick tube so that the finger grip is positioned toward the left side of the hull, and then remove it again
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 128
    jMAINTENANCE AND ADJUSTMENTS 127 the watercraft port to starboard as well as • Level fore to aft. a well-ventilated area, start the engine while • In flushing the cooling system. NOTICE The engine must be running before the water is turned on and the water must be turned off before the engine is
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 129
    128 MAINTENANCE AND ADJUSTMENTS j NOTICE Do not allow dirt or foreign materials to enter the engine as they can cause serious engine damage. the oil thoroughly from the dipstick tube us• Drain ing a commercially-available vacuum pump. WARNING Used engine oil is toxic and pollutes the environment.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 130
    oil level carefully as follows: ○This NOTE procedure requires mechanical skills and tools. If it is beyond your capability, ask your Kawasaki dealer for the service. j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 131
    130 MAINTENANCE AND ADJUSTMENTS NOTE j Valve Clearance Valve and valve seats wear decreasing valve clearances, and upsetting valve timing. ○Since the trim and list of the watercraft will signifi- cantly affect the oil level, be sure that the operator and/or cargo are not aboard the watercraft
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 132
    jMAINTENANCE AND ADJUSTMENTS 131 Spark Plugs Since the engine is water-cooled and is generally operated at a constant throttle opening, cylinder head temperature is relatively stable. For this reason, if the engine is in good condition and properly tuned, it should not be necessary to use a spark
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 133
    132 MAINTENANCE AND ADJUSTMENTS Spark Plug Inspection and Replacement j NOTICE Do not adjust the plug gap. If the plug gap is out of the specification, replace the spark plug. the spark plugs and inspect the ceramic • Remove insulators. The appearance of the insulators reflects the efficiency of
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 134
    jMAINTENANCE AND ADJUSTMENTS 133 Battery The battery is located in the front storage compartment. Remove the battery recess cover in the front storage compartment. • A. Spark Plug Caps the caps lightly to make sure they are firmly in • Pull place. j A. Front Storage Compartment B. Battery Recess
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 135
    a sealed type, and the sealing strip should not be removed at any time after the specified electrolyte has been installed in the battery for initial service. It is not necessary to check the battery electrolyte level or add distilled water.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 136
    jMAINTENANCE AND ADJUSTMENTS 135 acid generates hydrogen gas • Battery which is flammable and explosive under DANGER Battery Removal • certain conditions. It is present within a battery at all times, even in a discharged condition. Keep all flames and sparks (cigarettes) away from the battery.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 137
    136 MAINTENANCE AND ADJUSTMENTS (1) Slide the rubber cap. j (2) Negative cable removal disconnect the negative cable from the bat• First, tery. j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 138
    jMAINTENANCE AND ADJUSTMENTS 137 (3) Positive cable removal Battery Removal disconnect the positive cable from the bat• Next, tery. the tags of the hold-down straps from the • Release hooks. j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 139
    138 MAINTENANCE AND ADJUSTMENTS Battery Inspection and Maintenance j (2) Battery terminal cracks, dents) damage (deformation, (1) Battery terminal oxidation/corrosion (coated with patina/white powder) j A. Oxidation/Corrosion A. Deformation B. Dents 1. 2. 3. Apply a penetrating
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 140
    jMAINTENANCE AND ADJUSTMENTS 139 Battery inspection (4) Hold-down strap inspection A. Loose B. Cracks C. Deformation the hold-down strap for deterioration such • Check as cutting, cracking, or looseness. • Check the battery for deformation or cracks. j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 141
    140 MAINTENANCE AND ADJUSTMENTS (5) Battery tray cleaning j Battery Installation 1. Battery installation and fixation • Inspect the battery tray and remove dust. j the battery with the straps and make sure • Secure that it is firmly fixed. • Connect the positive cable to the battery first. 2.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 142
    jMAINTENANCE AND ADJUSTMENTS 141 (1) Temporal Tightening (2) Tightening attention to the cable terminal direction and • Pay connect the cable so that the battery terminal and cable terminal are in close contact. NOTICE Reversing the battery connections will damage the electrical system. To prevent
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 143
    142 MAINTENANCE AND ADJUSTMENTS (3) Confirmation of battery cable fixation j (4) Anticorrosive treatment tightening both terminals securely, move the • After cable terminals from side to side and make sure that the cables are fixed and do not move. a grease or a penetrant lubricating spray to •
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 144
    jMAINTENANCE AND ADJUSTMENTS 143 (5) Rubber cap installation Precaution for connecting the cable (1) To prevent a loose cable connection, do not use a long bolt • Cover the terminal with the rubber cap completely. j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 145
    144 MAINTENANCE AND ADJUSTMENTS j (3) To prevent the terminals being deformed or damaged, do not hit the terminals with a hammer. (2) To prevent a loose electrical connection, do not use a wire. j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 146
    operation, do not use a one-touch coupler. should not be removed after the specified electrolyte has been added to the battery during initial service. However, in order to maximize battery life and ensure that it will provide the power needed to start your watercraft, you must properly maintain
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 147
    146 MAINTENANCE AND ADJUSTMENTS Current Drain j sulfate to crystallize in the cells, the battery plates become permanently damaged and will not hold a charge. Battery failure due to sulfation is not warrantable. Battery Maintenance It is the owner's responsibility to keep the battery fully charged.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 148
    craft, adequate lubrication and corrosion protection is an absolute necessity to provide long, reliable service. Refer to the Periodic Maintenance Chart and Pre-ride Checklist in the OPERATING INSTRUCTIONS chapter for the frequency of the following items: Lubricate the following with a penetrating
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 149
    148 MAINTENANCE AND ADJUSTMENTS Steering Nozzle/Reverse Bucket Pivots j Shift Link Ball Joint A. Steering Nozzle Pivot B. Reverse Bucket Pivot A. Shift Link Ball Joint j the following with a high quality water• Lubricate proof marine grease.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 150
    jMAINTENANCE AND ADJUSTMENTS 149 Steering Link Joint Throttle Cable Fitting at Throttle Case A. Steering Joint A. Apply grease. of the other link joints should be per• Lubrication formed by your Kawasaki JET SKI watercraft dealer. ○Disassemble NOTE and lubricate the handlebar pivot. This
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 151
    150 MAINTENANCE AND ADJUSTMENTS j To Flush the Engine Cooling System Remove the cap and connect a garden hose with a screw-in fitting on its end. Start the engine and allow it to idle before turning on the water. Cooling System Flushing To prevent sand or salt deposits from accumulating in the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 152
    jMAINTENANCE AND ADJUSTMENTS 151 the engine idle for several minutes with the • Let water running. off the water. Leave the engine idling. • Turn Rev the engine a few times to clear the water out • of the exhaust system. Bilge System Flushing To prevent clogging, the bilge system should be flushed
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 153
    152 MAINTENANCE AND ADJUSTMENTS j engine compartment will fill with water when the engine stops or idles. It may be necessary to remove the fitting. A. Bilge Hoses B. Breather Fittings j the bilge filter hose, which comes from • Connect the hull bottom, to the garden hose, turn the wa- • • ter
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 154
    use or one year, whichever comes first; and then every 50 hours or every year, whichever comes first. The jet pump bearings should also be serviced before any prolonged storage to prevent any water that may be left in the pump from corroding the bearings and causing premature failure. j A. Fuse
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 155
    154 MAINTENANCE AND ADJUSTMENTS j NOTICE Incorrect fuses can damage the electrical system and may lead to a fire. To prevent damage and fire, do not substitute fuses. Replace the blown fuse with a new one of the correct capacity, as specified on the electric case. j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 156
    j IN AN EMERGENCY Troubleshooting Guide IN AN EMERGENCY 155 If this procedure does not identify your problem, see your JET SKI watercraft dealer or refer to the Service Manual. j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 157
    156 IN AN EMERGENCY j j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 158
    j IN AN EMERGENCY 157 j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 159
    158 IN AN EMERGENCY j j WARNING Faulty steering can cause an accident resulting in serious injury or death. To help prevent an accident, have any steering problems examined by an authorized Kawasaki JET SKI watercraft dealer.
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 160
    j In the Case of Emergency Towing the JET SKI watercraft Refer to the Towing (a wakeboarder, water skier, tuber, etc.) section in the GENERAL INFORMATION chapter. Jump Starting If your watercraft's battery is run down, it should be removed and charged. If this is not practical, a booster battery and
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 161
    160 IN AN EMERGENCY j DANGER Batteries contain sulfuric acid that can cause burns and produce hydrogen gas which is highly explosive. Do not make this last connection at the throttle body, injector or battery. Take care not to touch the positive and negative cables together, and do not lean over
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 162
    schedule shown in this owner's manual. You are responsible for taking your product to the dealer immediately if there is a problem, and you, as the the first scheduled service. You can have the required servicing done by your Kawasaki dealer (recommended) or an equally-qualified service facility. You
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 163
    the repairs at no cost to you if it is determined that the problem is covered by the warranty. Kawasaki will work with your dealer to resolve been inspected by a Kawasaki dealer. You may purchase a Kawasaki Service Manual and any necessary special tools directly from your Kawasaki dealer. You
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 164
    163 What if I am not Satisfied With My Warranty Service? If you aren't satisfied with your dealership's repair will contact the dealership and work with it in resolving your problem. Want to Contact Kawasaki? This owner's manual should answer most of your questions about your Kawasaki. Your Kawasaki
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 165
    and remedy campaign. However, the U.S.C.G. cannot become involved in individual problems between you, your dealer, or Kawasaki Motors Corporation, U.S.A. Please send 20593-0001 Please send your correspondence to:. Consumer Services Kawasaki Motors Corp., U.S.A. P.O. Box 25252 Santa Ana, CA 92799-5252
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 166
    jAPPENDIX 165 ENVIRONMENTAL PROTECTION Kawasaki subscribes to the guidelines of Tread Lightly! a program dedicated to protecting the great outdoors through education and fostering responsible enjoyment of public lands. When using your Kawasaki JET SKI watercraft, please follow these Tread Lightly!
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 167
    166 APPENDIX j Environmental Hang Tag j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 168
    jAPPENDIX 167 One Star - Low-Emission The one-star label identifies engines that meet the California Air Resources Board's 2001 exhaust emission standards. Engines meeting these standards have 75% lower emissions than conventional carbureted two-stroke engines. These engines are equivalent to the
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 169
    168 APPENDIX j SPECIFICATIONS JET SKI WATERCRAFT - MODELS JT1500K INBOARD BOAT LESS THAN 4.8 M (16 FEET) IN LENGTH Maximum Number of Riders and Load Limit: Maximum number of riders Load limit Engine: Type Displacement Bore and Stroke Compression Ratio Ignition System Lubrication System Fuel System
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 170
    jAPPENDIX 169 Gap Terminal Ignition Timing Idle Speed 0.7 ∼ 0.8 mm Threaded terminal 3° ATDC @1 300 r/min (rpm) ∼ 32° BTDC @3 000 r/min (rpm) 1 300 ±100 r/min (rpm) - in water 1 300 ±100 r/min (rpm) - out of water Drive System: Coupling Jet Pump: Steering Braking *Performance: Minimum Turning Radius
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 171
    170 APPENDIX Curb Mass Air Draft (1) j 423 kg 865 mm 353 mm 78 L API SG, SH, SJ, SL or SM with JASO MA, MA1 or MA2 SAE10W-40 5.0 L 12 V 18 Ah 5.3 qt (U.S.) 932.7 lb 34.06 in. 13.9 in. 20.6 gal (U.S.) Maximum Draft (2) Fuel Tank Capacity Engine Oil: Type Viscosity Oil Capacity Electrical Equipment:
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 172
    jAPPENDIX 171 Serial Numbers The hull and engine identification numbers are used to register the boat. They are the only means of identifying your particular machine from others of the same model. These serial numbers may be needed by your dealer when ordering parts. In the event of theft,
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 173
    172 APPENDIX j Registration Numbers The graphic design of your JET SKI watercraft provides a specific location on each side for the registration numbers and validation decals. A. Location for Registration Number B. Location for Validation Decal A. Location for Registration Number B. Location for
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 174
    jAPPENDIX 173 letters must be equal to the width of any letter except "I" or any number except "1." A = 3 inches (76.2 mm) minimum B=C D = 3 inches (76.2 mm) j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 175
    174 MAINTENANCE RECORD j MAINTENANCE RECORD Owner Name...Address ...Phone Number ...Hull Number ...Engine Number ...Selling Dealer Name ...Address ...Phone Number ...Warranty Start Date ...Note: Keep this information and a spare key in a secure location. Date Engine Hours Maintenance Performed
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 176
    jMAINTENANCE RECORD 175 Date Engine Hours Maintenance Performed Dealer Name Dealer Address j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 177
    176 MAINTENANCE RECORD Date Engine Hours j Maintenance Performed Dealer Name Dealer Address j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 178
    jMAINTENANCE RECORD 177 Date Engine Hours Maintenance Performed Dealer Name Dealer Address j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 179
    178 MAINTENANCE RECORD Date Engine Hours j Maintenance Performed Dealer Name Dealer Address j
  • 2015 Kawasaki JET SKI Ultra LX | Owners Manual - Page 180
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
  • 99
  • 100
  • 101
  • 102
  • 103
  • 104
  • 105
  • 106
  • 107
  • 108
  • 109
  • 110
  • 111
  • 112
  • 113
  • 114
  • 115
  • 116
  • 117
  • 118
  • 119
  • 120
  • 121
  • 122
  • 123
  • 124
  • 125
  • 126
  • 127
  • 128
  • 129
  • 130
  • 131
  • 132
  • 133
  • 134
  • 135
  • 136
  • 137
  • 138
  • 139
  • 140
  • 141
  • 142
  • 143
  • 144
  • 145
  • 146
  • 147
  • 148
  • 149
  • 150
  • 151
  • 152
  • 153
  • 154
  • 155
  • 156
  • 157
  • 158
  • 159
  • 160
  • 161
  • 162
  • 163
  • 164
  • 165
  • 166
  • 167
  • 168
  • 169
  • 170
  • 171
  • 172
  • 173
  • 174
  • 175
  • 176
  • 177
  • 178
  • 179
  • 180