2016 Polaris Ranger 570 EPS Owners Manual - Page 65

2016 Polaris Ranger 570 EPS Manual

Page 65 highlights

MAINTENANCE Periodic Maintenance Chart Item Ź Oil lines, fasteners Ź Engine oil and filter change D Front Gearcase oil (if equipped) Middle Gearcase oil (if equipped) Rear gearcase oil (if equipped) Transmission oil Fuel system (whichever comes first) Hours Calendar Miles (Km) 50 H 6M Inspect for leaks and loose fittings 100 H 6M 1000 (1600) Change oil and filter; (perform a breakin oil change at one month) 100 H 6M Inspect level; change yearly 100 H 6M Inspect level; change yearly 100 H 6M Inspect level; change yearly 100 H 12 M 1000 (1600) Change fluid 100 H 12 M 1000 (1600) Cycle key to pressurize fuel pump; check for leaks at fill cap, fuel lines/rail and fuel pump; replace lines every two years 100 H 12 M Inspect; clean external surfaces 100 H 12 M Inspect for leaks 100 H 12 M Inspect 100 H 12 M Inspect 100 H 12 M 1000 (1600) Remove and grease 100 H 12 M 1000 (1600) Inspect; replace as needed 100 H 12 M Inspect 100 H 12 M Inspect for wear, routing, security; apply dielectric grease to connectors subjected to water, mud, etc. 100 H 12 M 1000 (1600) Inspect; clean; replace worn parts 100 H 200 H 250 H 300 H 500 H 12 M 24 M 24 M 36 M 60 M 2000 (3200) 5000 (8000) Inspect; replace as needed Change every two years Inspect; replace if necessary Clean out Replace coolant Inspect; adjust as needed Adjust as needed Inspect periodically; adjust when parts are replaced Inspect daily; adjust as needed Adjust as needed Maintenance Interval Remarks Ź Radiator (if applicable) Ź Cooling Hoses Ź Engine mounts Exhaust muffler/pipe Drive shafts Ź Spark plug D Ignition timing Ź Wiring D Clutches Ź D Front wheel bearings D Brake fluid Suspension bushings Spark arrester Ź Coolant Valve clearance Idle speed D Toe adjustment D Auxiliary brake (if equipped) Ź Headlight aim Lubrication Recommendations Check and lubricate all components at the intervals outlined in the Periodic Maintenance Chart beginning on page 61, or more often under severe use, such as wet or dusty conditions. Items not listed in the chart should be lubricated at the general lubrication interval. Item Engine Oil Brake Fluid Main Gearcase Oil (Transmission) Demand Drive (Front Gearcase) Fluid Front Prop Shaft Yoke Lube PS-4 5W-50 4-Cycle Oil DOT 4 Brake Fluid AGL Gearcase Lubricant & Transmission Fluid Demand Drive Fluid U-Joint Grease Method See page 64 (570) or page 66 (ETX). See page 78. See page 68. See page 69. Locate fittings and grease (3 pumps maximum). 63

  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
  • 99
  • 100
  • 101
  • 102
  • 103
  • 104
  • 105
  • 106
  • 107
  • 108
  • 109

63
MAINTENANCE
Periodic Maintenance Chart
Lubrication Recommendations
Check and lubricate all components at the intervals outlined in the Periodic Maintenance
Chart beginning on page 61, or more often under severe use, such as wet or dusty conditions.
Items not listed in the chart should be lubricated at the general lubrication interval.
Item
Maintenance Interval
(whichever comes first)
Remarks
Hours
Calendar
Miles (Km)
Ź
Oil lines, fasteners
50 H
6 M
-
Inspect for leaks and loose fittings
Ź
Engine oil and filter change
100 H
6 M
1000 (1600)
Change oil and filter; (perform a break-
in oil change at one month)
Ź
Front Gearcase oil (if equipped)
100 H
6 M
-
Inspect level; change yearly
Ź
Middle Gearcase oil (if equipped)
100 H
6 M
-
Inspect level; change yearly
Ź
Rear gearcase oil (if equipped)
100 H
6 M
-
Inspect level; change yearly
Ź
Transmission oil
100 H
12 M
1000 (1600)
Change fluid
D
Fuel system
100 H
12 M
1000 (1600)
Cycle key to pressurize fuel pump;
check for leaks at fill cap, fuel lines/rail
and fuel pump; replace lines every two
years
Ź
Radiator (if applicable)
100 H
12 M
-
Inspect; clean external surfaces
Ź
Cooling Hoses
100 H
12 M
-
Inspect for leaks
Ź
Engine mounts
100 H
12 M
-
Inspect
Exhaust muffler/pipe
100 H
12 M
-
Inspect
Drive shafts
100 H
12 M
1000 (1600)
Remove and grease
Ź
Spark plug
100 H
12 M
1000 (1600)
Inspect; replace as needed
D
Ignition timing
100 H
12 M
-
Inspect
Ź
Wiring
100 H
12 M
-
Inspect for wear, routing, security; apply
dielectric grease to connectors sub-
jected to water, mud, etc.
D
Ź
Clutches
100 H
12 M
1000 (1600)
Inspect; clean; replace worn parts
D
Front wheel bearings
100 H
12 M
-
Inspect; replace as needed
D
Brake fluid
200 H
24 M
-
Change every two years
Suspension bushings
250 H
24 M
2000 (3200)
Inspect; replace if necessary
Spark arrester
300 H
36 M
-
Clean out
Ź
Coolant
-
60 M
-
Replace coolant
Valve clearance
500 H
-
5000 (8000)
Inspect; adjust as needed
Idle speed
-
Adjust as needed
D
Toe adjustment
-
Inspect periodically; adjust when parts
are replaced
D
Ź
Auxiliary brake (if equipped)
-
Inspect daily; adjust as needed
Headlight aim
-
Adjust as needed
Item
Lube
Method
Engine Oil
PS-4 5W-50 4-Cycle Oil
See page 64 (570) or page 66 (ETX).
Brake Fluid
DOT 4 Brake Fluid
See page 78.
Main Gearcase Oil
(Transmission)
AGL Gearcase Lubricant & Transmission
Fluid
See page 68.
Demand Drive (Front
Gearcase) Fluid
Demand Drive Fluid
See page 69.
Front Prop Shaft Yoke
U-Joint Grease
Locate fittings and grease (3 pumps
maximum).