Hayward Aqua Solar® Aqua Solar
Hayward Aqua Solar® Manual
 |
View all Hayward Aqua Solar® manuals
Add to My Manuals
Save this manual to your list of manuals |
Hayward Aqua Solar® manual content summary:
- Hayward Aqua Solar® | Aqua Solar - Page 1
1,720 0.73 40 26,100 3.61 80 9,297 2.41 120 3,758 1.37 160 1,688 0.72 620 Division St. Elizabeth, NJ 07207 092008F RevG Copyright © 2010 Hayward Inc. Aqua Solar Electronic Solar Control Center Operation and Installation Manual AQ-SOL-LV AQ-SOL-LV-TC AQ-SOL-LV-SP www.haywardnet.com - Hayward Aqua Solar® | Aqua Solar - Page 2
THESE INSTRUCTIONS 5-Year Limited Solar Warranty This Five Year Limited Warranty statement is only applicable to Solar controls and accessories sold and installed within the USA and Canada* and supersedes any warranty statements dated prior to November 1, 2010. Hayward warrants its Hayward solar - Hayward Aqua Solar® | Aqua Solar - Page 3
. If the sensor and wiring are both good, then the main circuit PCB may have a problem. Table of Contents SPECIFICATIONS Specifications 1 OPERATION Controls 2 Temperature Display 3 INSTALLATION Mounting 4 Wiring 4 Jumper Settings 9 TROUBLESHOOTING Troubleshooting 10 WARRANTY Warranty 12 11 - Hayward Aqua Solar® | Aqua Solar - Page 4
Aqua Solar Digital Solar Control System The Aqua Solar Digital Solar Control System is a differential temperature control for solar heating of pools, spas, and hot tubs. The Aqua Solar is available in 3 models; AQ-SOL-LV, AQ-SOL-LV-TC and AQ-SOL-LV-SP. These models provide differential temperature - Hayward Aqua Solar® | Aqua Solar - Page 5
(model AQ-SOL-LV-TC only) The "Heating" LED will show when the pool is being solar heated. If your pool has a pool sweep, the Aqua Solar will turn it off for approximately 6 minutes when solar heat is turned on. This will allow air to be purged from the system. Controls and Displays MAIN SWITCH ON - Hayward Aqua Solar® | Aqua Solar - Page 6
SOL-LV-TC: This relay is the primary control for the filter pump-there is no other timer. The Aqua Solar will operate the filter pump according to the "trippers" set on the built-in timeclock in addition to the optional "Solar Override" and "Recirculate Freeze" options. AQ-SOL-LV-SP HEATER INTERLOCK - Hayward Aqua Solar® | Aqua Solar - Page 7
Aqua Solar terminal block as a junction for pump power, the terminal block is not rated for high amps. Be sure to connect the earth ground to the green terminal. Fuse (2A, Slo-Blo) Relay Control Outputs Booster Pump Pool Sweep (heater interlock for -SP model) Filter Pump Rev Fwd } Valve Output - Hayward Aqua Solar® | Aqua Solar - Page 8
use). Ground the shields to the Aqua Solar's ground screw. High Voltage Relay Output Wiring A maximum of two high voltage relays (industry standard) may be added to the AQSOL-LV. The AQ-SOL-LV-TC model comes with one relay for the filter pump control already installed and one additional relay may be
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
 |
 |
Temperature/Resistance /Voltage
All Hayward controls use a 10K thermistor sensors.
When disconnected from the
control, the sensor will read 10K ohms at 25ºC/77ºF.
Refer to the chart below for
the resistance at other
temperatures.
For a given temperature, the resistance
reading should be accurate to
±1%.
For a given resistance reading, the tempera-
ture reading should be accurate to ±0.5ºF.
All voltage measurements (DC) must
be made with the sensor connected to the control and should be accurate to ± 2%.
°F
Ohms
Volts
°F
Ohms
Volts
°F
Ohms
Volts
°F
Ohms
Volts
1
82,719
4.46
41
25,391
3.59
81
9,076
2.38
121
3,679
1.34
2
80,142
4.45
42
24,704
3.56
82
8,861
2.35
122
3,602
1.32
3
77,656
4.43
43
24,037
3.53
83
8,651
2.32
123
3,527
1.30
4
75,255
4.41
44
23,391
3.50
84
8,447
2.29
124
3,454
1.28
5
72,937
4.40
45
22,764
3.47
85
8,249
2.26
125
3,382
1.26
6
70,698
4.38
46
22,156
3.45
86
8,056
2.23
126
3,312
1.24
7
68,535
4.36
47
21,566
3.42
87
7,867
2.20
127
3,244
1.22
8
66,447
4.35
48
20,993
3.39
88
7,684
2.17
128
3,177
1.21
9
64,428
4.33
49
20,438
3.36
89
7,506
2.14
129
3,112
1.19
10
62,479
4.31
50
19,900
3.33
90
7,333
2.12
130
3,049
1.17
11
60,595
4.29
51
19,377
3.30
91
7,164
2.09
131
2,987
1.15
12
58,774
4.27
52
18,870
3.27
92
6,999
2.06
132
2,926
1.13
13
57,014
4.25
53
18,377
3.24
93
6,839
2.03
133
2,867
1.11
14
55,313
4.23
54
17,899
3.21
94
6,683
2.00
134
2,809
1.10
15
53,669
4.21
55
17,435
3.18
95
6,530
1.98
135
2,752
1.08
16
52,078
4.19
56
16,985
3.15
96
6,382
1.95
136
2,697
1.06
17
50,541
4.17
57
16,548
3.12
97
6,238
1.92
137
2,643
1.05
18
49,054
4.15
58
16,123
3.09
98
6,097
1.89
138
2,591
1.03
19
47,616
4.13
59
15,711
3.06
99
5,960
1.87
139
2,539
1.01
20
46,225
4.11
60
15,310
3.02
100
5,827
1.84
140
2,489
1.00
21
44,879
4.09
61
14,921
2.99
101
5,697
1.81
141
2,440
0.98
22
43,577
4.07
62
14,543
2.96
102
5,570
1.79
142
2,392
0.97
23
42,318
4.04
63
14,176
2.93
103
5,446
1.76
143
2,345
0.95
24
41,099
4.02
64
13,820
2.90
104
5,326
1.74
144
2,299
0.93
25
39,919
4.00
65
13,473
2.87
105
5,208
1.71
145
2,254
0.92
26
38,777
3.97
66
13,136
2.84
106
5,094
1.69
146
2,210
0.90
27
37,671
3.95
67
12,809
2.81
107
4,982
1.66
147
2,167
0.89
28
36,601
3.93
68
12,491
2.78
108
4,873
1.64
148
2,125
0.88
29
35,565
3.90
69
12,182
2.75
109
4,767
1.61
149
2,084
0.86
30
34,561
3.88
70
11,882
2.72
110
4,664
1.59
150
2,044
0.85
31
33,590
3.85
71
11,589
2.68
111
4,563
1.57
151
2,005
0.84
32
32,648
3.83
72
11,305
2.65
112
4,464
1.54
152
1,966
0.82
33
31,737
3.80
73
11,029
2.62
113
4,368
1.52
153
1,929
0.81
34
30,853
3.78
74
10,761
2.59
114
4,274
1.50
154
1,892
0.80
35
29,998
3.75
75
10,500
2.56
115
4,183
1.47
155
1,856
0.78
36
29,169
3.72
76
10,246
2.53
116
4,094
1.45
156
1,821
0.77
37
28,365
3.70
77
9,999
2.50
117
4,007
1.43
157
1,787
0.76
38
27,587
3.67
78
9,758
2.47
118
3,922
1.41
158
1,753
0.75
39
26,832
3.64
79
9,525
2.44
119
3,839
1.39
159
1,720
0.73
40
26,100
3.61
80
9,297
2.41
120
3,758
1.37
160
1,688
0.72
Electronic Solar Control Center
Operation and Installation
Manual
AQ-SOL-LV
AQ-SOL-LV-TC
AQ-SOL-LV-SP
092008F RevG
Copyright © 2010 Hayward Inc.
www.haywardnet.com
620 Division St.
Elizabeth, NJ
07207
Aqua Solar