Hayward Aqua Solar GL-235 Model: GL-235
Hayward Aqua Solar GL-235 Manual
 |
View all Hayward Aqua Solar GL-235 manuals
Add to My Manuals
Save this manual to your list of manuals |
Hayward Aqua Solar GL-235 manual content summary:
- Hayward Aqua Solar GL-235 | Model: GL-235 - Page 1
parts, etc.) or installed for more than the warranty period are not eligible for warranty repair replacement. 620 Division St. Elizabeth, NJ 07207 092007G RevH Copyright © 2010 Hayward Inc. Aqua Solar GL-235 Electronic Solar Control Operation and Installation Manual GL-235 www.haywardnet.com - Hayward Aqua Solar GL-235 | Model: GL-235 - Page 2
. In general, a separate ground conductor must be run to the ground terminal on the pool service panel. Low Voltage (LV) output: Solar Valve The GL-235 controls a single valve. In most applications this is the solar valve, which diverts water through the collector panels or through the normal - Hayward Aqua Solar GL-235 | Model: GL-235 - Page 3
the control circuitry is operating properly by disconnecting the solar sensor from the terminal block. The "Heating" LED should go off and the "CHECK SENSOR" LED should begin to blink. If "Heating" remains on, there is an internal circuit failure and the GL-235 will have to be returned for repair - Hayward Aqua Solar GL-235 | Model: GL-235 - Page 4
to drain. Alternatively, the GL235 control can provide recirculate freeze protection. If enabled, when the GL-235 senses a freeze condition at the collector sensor, it will allow circulation of relatively warm water from the pool to the collector panels. The GL-235 will allow recirculation when the - Hayward Aqua Solar GL-235 | Model: GL-235 - Page 5
the instructions in section marked "Low Voltage (LV) : Solar Valve" to correct. WARNING: If recirculate freeze protection is being used, do NOT leave the switch in the "MANUAL OFF" position during cold weather. Also note that the switch does NOT turn power off to the GL235. GL-235 high voltage - Hayward Aqua Solar GL-235 | Model: GL-235 - Page 6
Basic Installation of GL-235 Figure 2 6 GL-235 high voltage output used for Timer Override Figure 3 7
-
1 -
2 -
3 -
4 -
5 -
6
 |
 |
092007GRevH
Copyright © 2010 Hayward Inc.
www.haywardnet.com
620 Division St.
Elizabeth, NJ
07207
Aqua Solar
GL-235
5-Year Limited Solar Warranty
This Five Year Limited Warranty statement is only applicable to
Solar controls and accessories
sold and installed within the USA and Canada* and supersedes any warranty statements dated
prior to November 1, 2010.
Hayward warrants its Hayward solar products to be free from defects in material or workmanship,
under normal use and service for 5 years from date of manufacture, providing it is installed
according to the installation instructions and specifications. The datecode stamped on the
outside of the product and also coded on the printed circuit board will be the sole determination
of manufacturing date.
To obtain warranty service or repair, please contact the place of purchase or the nearest Hayward
authorized warranty service center. For more information, please contact the Hayward
Technical Service Support Center or visit us on the web at www.haywardnet.com.
Hayward will
not assume any of the cost incurred in removal or reinstallation of the product. One year outside
the USA and Canada.
The express warranty above constitutes the entire warranty of Hayward Pool Products with
respect to its solar products and IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED
OR IMPLIED, INCLUDING A WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE.
IN NO EVENT SHALL HAYWARD BE RESPONSIBLE OR ANY CONSEQUENTIAL OR
INCIDENTAL DAMAGES OF ANY NATURE WHATSOEVER.
No wholesaler, agent, dealer, contractor, or other person is authorized to give any warranty on
behalf of Hayward. This warranty is void if the product has been altered in any way after leaving
the factory.
Charges
Years 1-3:
no charge
Years 4-5
60% of current list price plus $5.00 shipping and handling
Unless a copy of the original purchase invoice is enclosed, the manufacturing datecode on the
product will be used to determine the repair charges. Hayward reserves the right to charge a
nominal fee to cover inspection, test, and return freight for all controls where no faults or
problems are detected. All charges will be COD (COD charge will be included) unless you
already have an open account in good standing with Hayward. If the product returned can not
be repaired, Hayward will offer and equivalent credit towards the purchase of any new
Hayward product. Products that exhibit evidence of abuse, misuse, field damage (water/fire
damage, line voltage applied to low voltage terminals, missing parts, etc.) or installed for
more than the warranty period are not eligible for warranty repair replacement.
Electronic Solar Control
Operation and Installation
Manual
GL-235