Lenovo ThinkPad R32 Hardware Maintenance Manual
Lenovo ThinkPad R32 Manual
 |
View all Lenovo ThinkPad R32 manuals
Add to My Manuals
Save this manual to your list of manuals |
Lenovo ThinkPad R32 manual content summary:
- Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 1
ThinkPad R32 Series Hardware Maintenance Manual - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 2
Before using this information and the product it supports, be sure to read the general information under "Introduction" your IBM Authorized Dealer or your IBM Marketing Representative. © Copyright International Business Machines Corporation 2002. All rights reserved. Note to US Government Users - - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 3
Preface About this manual This manual contains service and reference information for IBM ThinkPad R32 Series Hardware Maintenance Manual products. Use this manual along with the advanced diagnostic tests to troubleshoot problems effectively. The manual is divided into sections as follows: v The - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 4
iv ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 5
Contents Preface iii ThinkPad R32 Series Hardware Maintenance Manual 1 Introduction 1 Important Service Information 1 Drive and Diskette Compatibility Matrix . . . . . 2 Safety Notices (Multi-lingual Translations) . . . . 3 Safety Information 11 Laser Compliance Statement 16 General - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 6
ThinkPad R32 Series Part II 115 Product overview 116 FRU removals and replacements 122 Locations 158 Parts list 161 ThinkPad R32 Series Part III 175 Product overview 176 FRU removals and replacements 182 Locations 219 Parts list 222 Notices 241 Trademarks 242 vi ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 7
ThinkPad R32 Series Hardware Maintenance Manual Introduction Important Service Information Important Diskette fixes are customer-installable. The diskette fixes are posted on the IBM support site http://www.pc.ibm.com/support/ . Advise customers to contact the PC Company HelpCenter at 800-772-2227 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 8
low-level format before replacing a hard disk drive. Attention: The drive startup sequence in the computer you are servicing might have been drives. Diskette Capacity 1.0MB 2.0MB 4.0MB 1.44MB Drive Read/Write Read/Write Not Compatible 2.88MB Drive Read/Write Read/Write Read/Write 2 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 9
provided in English, French, German, Italian, and Spanish. Safety Notice 1 Before the computer is powered-on after FRU replacement, make sure all screws, springs, or other small parts are in place and are not ían. Las piezas metálicas pueden causar cortocircuitos eléctricos. MT 2658/2659/2677 3 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 10
Verkaufsstelle oder den IBM Kundendienst ausgetauscht werden. Sie darf nicht zerlegt, wiederaufgeladen, kurzgeschlossen, oder Feuer oder Wasser ausgesetzt werden. Die Batterie kann schwere Verbrennungen Der Einsatz falscher Batterien kann zu Entzündung oder Explosion führen. 4 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 11
(Continued) Alcune batterie di riserva contengono una piccola quantità di nichel e cadmio. Non smontarle, ricaricarle, gettarle nel fuoco o nell'acqua né cortocircuitarle. de piezas. La utilización de una batería no apropiada puede provocar la ignición o explosión de la misma. MT 2658/2659/2677 5 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 12
regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery. La batterie contient du nickel. Ne no apropiada puede provocar la ignición o explosión de la misma. 6 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 13
remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery l'incendio o l'esplosione della batteria stessa. MT 2658/2659/2677 7 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 14
encima de los 100°C (212°F), ni la incinere ni exponga el contenido de sus celdas al agua. Deséchela tal como dispone la normativa local. 8 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 15
inmediatamente las áreas afectadas con agua durante 15 minutos como mínimo. Obtenga atención medica si se presenta algún síntoma del fluido despues de lavarse. MT 2658/2659/2677 9 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 16
To avoid shock, do not remove the plastic cover that surrounds the lower portion of the inverter card. Afin d'éviter tout risque de ünden oder Verletzungen bei Personen hervorzurufen. Sebbene le batterie di alimentazione siano a basso voltaggio, una batteria in en el personal. 10 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 17
removing any FRU, power-off the computer, unplug all power cords from electrical outlets, remove the battery servicing an IBM mobile computer. General Safety Follow these rules to ensure general safety: v Observe good housekeeping in the area of the machines during and after maintenance removes - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 18
representatives and the customer's personnel are not in a hazardous position. v Place removed covers and other parts in a safe place, away from all personnel, while you are servicing the machine. v Keep your tool case away from walk areas so that other people will not trip over it. v Do not wear - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 19
before: - Performing a mechanical inspection - Working near power supplies - Removing or installing main units v Before you start to work on the machine, unplug the power cord. If you cannot unplug it, ask the customer to power-off the wall box that supplies power to the machine and to lock the wall - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 20
v Do not service the following parts with the power on when they are removed from their normal operating places in a machine: - Power supply units - Pumps - Blowers and fans - Motor generators and similar units. (This practice ensures correct grounding of the units.) v If an electrical accident - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 21
Remove the cover. 5. Check for any obvious non-IBM alterations. Use good judgment as to the safety of any non-IBM power-supply cover fasteners (screws or rivets) have not been removed charge. Notes: 1. Use product-specific insulative and retains a charge even when you are specific service requirement - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 22
working on a double-insulated or battery-operated system. - You can use drive is certified to conform to the requirements of the International Electrotechnical Commission (IEC) 825 and CENELEC EN 60 825 for Class 1 laser products. When a CD-ROM drive is installed, note the following. 16 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 23
di procedure diverse da quelle specificate possono provocare l'esposizione a El uso de controles o ajustes o la ejecución de procedimientos distintos de los aquí especificados puede provocar la exposición a radiaciones peligrosas. Opening the CD-ROM drive could result in exposure to hazardous - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 24
al fascio. Radiación láser al abrir. No mire fijamente ni examine con instrumental óptico el haz de luz. Evite la exposición directa al haz. 18 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 25
General Descriptions This chapter includes descriptions for any ThinkPad model that has the PC-Doctor DOS diagnostics program. Some descriptions might not apply to your particular computer. MT 2658/2659/2677 19 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 26
failure can occur for a variety of reasons that have nothing to do with a hardware defect, such as: cosmic radiation, electrostatic discharge, or software error. FRU replacement should be considered only when a recurring problem exists. In this case, clear the error log and run the test again. Do - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 27
or installation of an incompatible card. v Damage caused by foreign material in the FDD. v Diskette drive damage caused by pressing the diskette drive cover or inserting diskettes with multiple labels. v Damaged or bent diskette drive eject button. v CD-ROM/DVD-ROM drive damage caused by excessive - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 28
following when you service this machine: v Keep the screw kit (P/N 08K6560) in your tool bag. v Always use new screws if you are instructed. v Use a torque screwdriver if you have one. Loose screws can cause a reliability problem. The IBM ThinkPad computer addresses this problem with nylon-coated - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 29
LCD panel ID: 1. Install the ThinkPad Maintenance Diskette and restart the computer. 2. When the IBM logo is displayed, press the ″ESC″ key few times until BIOS copyright and diagnostics screen appears. 3. Select 1. LCD Panel ID Utility from the main menu. 4. Follow the instruction on screen to read - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 30
the original serial number by doing the following: 1. Install the Maintenance Diskette and restart the computer. 2. When the IBM logo is displayed, press the ″ESC″ key few times until BIOS copyright and diagnostics screen appears. 3. Select 2.VPD Utility from the main menu. 24 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 31
: 1. Install the Maintenance Diskette and restart the computer. 2. When the IBM logo is displayed, press the ″ESC″ key few times until BIOS copyright and diagnostics screen appears. 3. Select 2.VPD Utility from the main menu. 4. Follow the instruction on the screen to update the system serial number - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 32
are posted on: Maintenance diskette: http://www.pc.ibm.com/partner/infotips System program service diskette: http://www.pc.ibm.com/us/files.html or http://www.pc.ibm.com/qtechinfo/TPAD-MATRIX.html Passwords When the power-on password (POP), hard disk password (HDP), and supervisor password (SVP) are - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 33
IBM BIOS Setup Utility and make changes to system configuration settings. Attention: If the SVP has been forgotten and cannot be made available to the servicer, there is no service procedure to reset the password. The system board must be replaced for a scheduled fee. Removing the power-on password - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 34
any services to reset the hard drive password nor recover data from the hard drive. The hard drive can be replaced for a scheduled fee. Power management features Power management modes are available in the computer system to reduce power consumption and to prolong battery life. 28 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 35
″ page of the ″Power Management Properties″ screen. v An embedded modem signals the modem ring indicator v The battery power is at a critical level RAM, VRAM, and setup data are stored on the hard disk. v The system is powered off. Events that cause the computer to enter hibernation mode: MT 2658 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 36
disk drive (the Service Partition) that is not displayed by Windows Explorer. Use the Recovery CD if it was provided with the computer. Note: The recovery process might take up to 2 hours. To use the Product Recovery program to restore the pre-installed software, do the following: 30 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 37
instructions on the screen. Creating the Service Partition To create Service Partition and install the preloaded system from Recovery CD, do the following; To create Service Partition [SP]: 1. Erase all partitions on the hard-disk drive using FDISK or similar application. 2. Boot with Recovery CD - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 38
save it for future use. To use the Recovery Repair diskette: 1. Shut down and turn off the computer. 2. Attach the external diskette drive to the computer. 3. Insert the Recovery Repair diskette into the drive; then turn on the computer. 4. Follow the on-screen instructions. 32 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 39
.DSK file to C:\SPSD Note: XXrepresents for the version of BIOS. 2. Boot the computer with SPSD. a. Insert the created floppy diskette into floppy diskette drive before you turn on the computer. b. Press the power button. 3. Follow the on-screen instructions after booting. MT 2658/2659/2677 33 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 40
. 2. Select Diagnostics with the arrow keys, and press Enter. A pull-down menu appears: Note: The pull-down menu differs depending on the model. 3. Run the applicable function test. 4. Follow the instructions on the screen. If there is a problem, PC-Doctor shows some messages. 34 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 41
v Mouse v Video Adapter v Joystick Test v Serial Port v Diskette Test v Parallel Port v System Load v Fixed Disks v CD-ROM/DVD v Diskette Drives v Stereo Speaker v Other Devices v Wireless network controller (802.11b) v Memory Test - Full v Memory Test - Quick v Audio Test Note: In - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 42
Log v Full Erase Hard Drive v Quick Erase Hard Drive Power systems checkout To verify the symptom of the power problem on the computer, do the following: 1. Power off the computer. 2. Remove the battery pack. 3. Connect the AC Adapter. 4. Check that power is supplied when you power on the computer - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 43
power remaining when installed in the computer. Perform operational charging. If the battery status indicator or icon does not turn on, remove the Battery ASM and let it return to room temperature. Reinstall the Battery ASM. If the charge indicator or icon still does not turn on, replace the Battery - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 44
, replace the battery. 4. If the voltage is more than 9V for LiION, measure the resistance between battery terminals 5 and 6. The resistance must be 4 to 30K . If the resistance is not correct, replace the Battery ASM. If the resistance is correct, replace the system board. 38 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 45
are available, use narrative symptoms. If the symptom, is not listed, go to "Undetermined Problems" on page 54. Note: For any IBM device not supported by the diagnostic codes in this ThinkPad computer, see the manual for that device. Numeric Error Codes and Messages Error Code 0176 Message System - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 46
Controller Run Falied test. May interactive require replacing tests of the keyboard controller. keyboard and the auxiliary input devices. Keyboard locked Unlock the system Unlock key switch to proceed. Run interactive tests of the keyboard and the auxiliary input devices. 40 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 47
memory not working or not configured properly at offset nnnn, 1. DIMM 2. System Board System battery is dead Replace and run SETUP The CMOS clock battery indicator shows the battery is dead. Replace the battery and run Setup to reconfigure the system. Replace the backup battery and run IBM BIOS - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 48
Error Code 0270 Message Real time clock error Meanings Comment or Action Real-Time Clock fails BIOS hardware test. May require board repair. 1. Replace the backup battery and run IBM BIOS Setup Utility to reset the time and date. 0271 0280 0281 02B0 2. System Board Check date and time - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 49
socket number for Multi-Processor error. ServerBIOS2 test error: Cannot write to EISA CMOS. 1. Load Setup Defaults in IBM BIOS Setup Utility. 2. Replace the backup battery 02F5: DMA Test Failed 02F6: Software NMI Failed 02F7: Fail-Safe Timer NMI Failed device Address Conflict 3. System Board - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 50
Problem with Configuration Data NVRAM (CMOS) data. 1. DIMM 2. System Board I/O device IRQ conflict I/O device IRQ conflict error. 1. Load Setup Defaults in IBM BIOS Setup Utility. 2. Backup battery 3. System Board PS/2 Mouse Boot PS/2 Mouse Summary Screen: installed nnnn kB Extended RAM - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 51
and is installed correctly. 2. Enter the IBM BIOS Setup Utility and see whether the hard-disk drive and the diskette drive are properly identified. 3. Reseat the hard-disk drive. 4. Reinstall the operating system. 5. Diskette drive. 6. Hard-disk drive. 7. System board. MT 2658/2659/2677 45 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 52
nnnn of the upper limit of Upper Memory Blocks, indicating released segments of the BIOS which can be reclaimed by a virtual memory manager. Video BIOS shadowed Video BIOS successfully copied to shadow RAM Bad CRC1, stop POST task EEPROM CRC1 is Replace not correct (block planar. #6). EAIA data - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 53
docking station is not supported by the product. Fan error Cooling fan is FAN failing. Do you want abort resume from hibernation? (Y/N)System memory removed, press F3 to power off system and restore memory chip, press F4 to normal boot DIMM is removed during hibernation state. 1. Restore - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 54
ID Usage Description 2 Low battery alarm pi (1250Hz) for 125ms no (yellow DC in/ out beep pi (1760Hz) for 125ms pi (1400Hz) for 125ms 7 Power off beep pi (1760Hz) for 250ms 8 Power off alarm pi (1760Hz) for 125ms no sound for 125ms pi (1760Hz) for 125ms ) for 125ms 48 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 55
(on all the time) is characteristic of TFT LCD technology, but excessive pixel problems can cause viewing concerns. The LCD should be replaced if the number of missing, discolored, or lighted dots in any background is: v LCD Inverter/LED board (13.3″/14.1″) v LCD v System board MT 2658/2659/2677 49 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 56
't power on. v Go to "Power systems checkout" on page 36. v AC Adapter v Battery assembly v Keyboard v System board The system doesn't power off. v Go to "Power systems checkout" on page 36. v Hold and press the power switch for more than 4 seconds. v Keyboard v System board 50 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 57
in Sequence Battery can't be charged. v Go to "Power systems checkout" on page 36. v Battery assembly v System board Memory-Related Symptom Symptom/Error Memory count (size) appears different from the actual size. FRU/Action in Sequence v Go to "FRU tests" on page 60. v Enter BIOS Utility and - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 58
display does not v Both display mode, press Fn+F7. work correctly. v System board Printer problems. v Run printer self-test. v Printer driver v Printer cable v Ensure that ″Parallel Port″ in the ″Config sub-menu″ menu of the BIOS Utility is correctly set. v System board 52 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 59
system. v Diskette drive v Hard disk drive v System board Intermittent Problems Intermittent system hang problems can be caused by a variety of reasons that have nothing to do with a hardware defect, such as cosmic radiation, electronic discharge, or software errors. FRU replacement should only be - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 60
. If any problems are found, replace the FRU. 3. Remove or disconnect all of the following devices: v Non-IBM devices v Printer, external mouse & keyboard, and other external devices v Battery pack v Hard disk drive v CD-ROM drive/Diskette drive (optional) v PC Card (PCMCIA) 4. Power on the computer - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 61
ThinkPad R32 Series Part I This section applies to the following models: 2658-F2X, 2658-DBX, 2658-DDX, 2658-DEX, 2658-DSX, 2658-DTX, 2658-G4X, 2658-G5X, 2658-G6X, 2658-G7X, 2658-G8X, 2658-G9X, 2658-GAX, 2658-GBX, 2658-GCX, 2658-GDX, 2658-GEX, 2658-GFX, 2658-GGX, 2658-GHX, 2658-GJX, 2658-GKX, 2658- - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 62
overview of the system features. Feature Processor Chip set Bus architecture System memory CMOS RAM Video Video memory LCD(Bright Ctrl) Audio Floppy Diskette drive (By model) Hard disk driveUpgradable Ultrabay Plus Modem Ethernet IEEE 1394 (on planar) CDC Description Intel Pentium-4M-1.6GHz/1.7GHz - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 63
Mini-PCI Antenna (By Model) PC Card (PCMCIA) ThinkLight IR I/O ports Security chip support Power BIOS Description One Mini-PCI slot (802. 11b-Modem Combo) Yes T2x1 or T3x1 (Cardbus w/o ZV Port) Two Type I/II or oneType III Yes Yes External monitor Parallel CRT Two USB Headphone Mic-in Speaker-out - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 64
enabled. The Arrow keys can be used as screen-scroll function keys. The cursor cannot be moved with the Arrow keys. Not all application programs support this function. You enable or disable Scroll Lock mode by pressing the ScrLk key. 58 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 65
Color Green Blinking green Blinking orange Orange (2) Standby mode Green Meaning Enough battery power remains for operation. The battery power charges up to 80% full power The battery pack needs to be charged The battery pack is being charged. The computer is in standby mode MT 2658/2659/2677 59 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 66
. FRU System board Power LCD unit Modem Audio Applicable test 1. CPU/Coprocessor (Diagnostics) 2. System board (Diagnostics) Battery (Diagnostics) 1. Video Adapter (Diagnostics) 2. Video (Interactive Tests) 1. Make sure the modem set up correctly. 2. Replacing the modem jack and modem card one at - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 67
Fan Applicable test 1. If a DIMM is installed, remove it and run Memory Test-Quick (Diagnostics) 2. If the problem does not recur, replace the DIMM and run the test again. 3. If the test does not detect the error, run Memory Test-Full (Diagnostics) 1. Power on system and check the air turbulence at - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 68
or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery. 62 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 69
significant amount of time. Do not short the battery terminals. CAUTION: Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type recommended by the manufacturer. Dispose of used batteries according to the manufacturer's instructions. MT 2658/2659/2677 63 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 70
: The screw does not separate from the PCI cover. 3 3 4 Note: There are 2 cables on step 4 : The gray cable is the main antenna and the black cable is the auxiliarey antenna. There is no step 3 if the Mini-PCI card is not stalled, then this cable will be connected to the 64 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 71
CDC card. Note: When you install the PCI card, remember to insert it into its socket at 20°, press it down and ensure the connection is well. 1030 Memory cover and Memory card Disassembly v "1010 Battery Disassembly" on page 63 2 1 MT 2658/2659/2677 65 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 72
of the memory card toward the right side of the socket, insert the memory card, at an angle of approximately 20°, into the socket; then press it firmly. Pivot the memory card until it snaps into place. Side View 1040 Hard Disk Drive Disassembly v "1010 Battery Disassembly" on page 63 66 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 73
of data on the drive. Before removing the drive, have the user make a backup copy of all the information on the drive if possible. Never remove the drive while the system is operating or is in suspend mode. 1050 Hard Disk Drive Cover Disassembly v "1010 Battery Disassembly" on page 63 1 1060 CD-ROM - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 74
1 2 3 1070 Keyboard Disassembly v "1010 Battery Disassembly" on page 63 1a 1b Step 1 Size (Quantity) M2.5 x L10 (2) Color Black 68 ThinkPad R32 Series Torque 3.2 kgf-cm - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 75
2 4 3 Notes: 1. When replacing the keyboard, make sure that the cable is clean and insert it fragile and could be damaged. Be careful when pulling out the cable. 1080 Backup Battery Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 MT 2658/2659/2677 69 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 76
regulations. Use of an incorrect battery can result in ignition or explosion of the battery. Replacement batteries can be ordered from IBM or IBM Authorized Dealers. 1090 Safety Cover Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 70 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 77
1 1100 Middle Cover Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 1 2 MT 2658/2659/2677 71 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 78
Cover Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 1 Step 1 Size (Quantity) M2.5 x L5 (1) Color Silver Torque 2.5 kgf-cm 72 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 79
If the Thinkpad R32 products are equipped with the Mini-PCI card, then the CDC modem card will not be installed. The procedure of ″cdc-card″ referred above should be skipped. 1120 Modem Cable Disassembly (Without CDC Modem Card) v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 80
(With CDC Modem Card) v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1110 CDC Cover Disassembly" on page 72 1 Notes: 1. If the Thinkpad R32 products are equipped with the CDC modem card, the wireless LAN board will - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 81
the system. 1150 Auxiliary Antenna Reassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1110 CDC Cover Disassembly" on page 72 MT 2658/2659/2677 75 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 82
Cable and Inverter Cable Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1110 CDC Cover Disassembly" on page 72 1a 1b 76 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 83
antenna from the system. 1170 LCD Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1110 CDC Cover Disassembly" on page 72 MT 2658/2659/2677 77 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 84
v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1040 Hard Disk Drive Disassembly" on page 66 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1170 LCD Disassembly" on page 77 78 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 85
1 Step 1 Size (Quantity) M2.5 x L10 (7) Color Black Torque 3.2 kgf-cm MT 2658/2659/2677 79 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 86
keyboard bezel facing the palm rest to remove it. Be careful not to break the latches. 1190 VGA Heat Sink Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1040 Hard Disk Drive Disassembly" on page 66 v "1070 Keyboard Disassembly - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 87
1 Step 1 Size (Quantity) M2.5 x L5 (1) Color Silver Torque 2.5 kgf-cm 1200 PCMCIA Holder Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 v "1030 Memory cover and Memory card Disassembly" on page 65 1 MT 2658/2659/2677 81 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 88
removing and replacing the PCMCIA holder, make sure that the PCMCIA cards are removed and the eject levers are sticking out. 1210 Heat Sink Module Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 82 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 89
, CPU or System Board is replaced. Thermal Pad is stuck on the bottom side of Heat Sink Module with adhesive. Do not re-use the thermal pad. 1220 Fan Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 MT 2658 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 90
1b Step 1 Size (Quantity) M2.5 x L5 (3) Color Silver Torque 2.5 kgf-cm 1230 CPU Disassembly v "1010 Battery Disassembly" on page 63 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1210 Heat Sink Module Disassembly" on page 82 1 84 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 91
Module, CPU or System Board is replaced. Thermal Pad is stuck on the bottom side of Heat Sink Module with adhesive. Do not re-use the thermal pad. 1240 Speaker Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1040 Hard Disk Drive - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 92
(1) Color Silver Torque 2.5 kgf-cm 1250 System Board Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1040 Hard Disk Drive Disassembly" on page 66 v "1060 CD-ROM Disassembly" on page 67 v "1070 Keyboard Disassembly" on page 68 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 93
. Do not re-use the thermal pad. 1260 I/O Port Bracket Disassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1040 Hard Disk Drive Disassembly" on page 66 v "1060 CD-ROM Disassembly" on page 67 v "1070 Keyboard Disassembly" on page 68 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 94
1 2 Step 1 2 Size (Quantity) M2.5 x L6 M2 x L12 Color Silver Silver Torque 3.2 kgf-cm 1.6 kgf-cm 3 4 5 6 78 88 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 95
and attached beneath the one marked number 8. CAUTION: There are several types of system board FRU for the Thinkpad R32 series, as followed: v System board with IBM security chip a v System board without IBM security chip a Begin by checking the FRU number of the system board, and be sure to use - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 96
warranty. 1270 LCD Bezel Disassembly (14.1″) v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1170 LCD Disassembly" on page 77 1 90 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 97
latches; then remove the LCD bezel. Be careful not to break these latches. v Gently push the two LCD latches outward to remove the LCD bezel. 1280 LCD Inveter Disassembly(14.1″) v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 MT 2658/2659/2677 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 98
PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1170 LCD Disassembly" on page 77 v "1270 LCD Bezel Disassembly (14.1″)" on page 90 v "1280 LCD Inveter Disassembly(14.1″)" on page 91 1 92 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 99
2 Step 2 Size (Quantity) M2 x L4(2) Color Silver Torque 2.5 kgf-cm 3a 3b 4 Step 3 Size (Quantity) M2.5 x L6(2) Color Black Torque 2.5 kgf-cm MT 2658/2659/2677 93 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 100
main antenna cable is lifted gently. 5 6 1300 LCD Bracket Hinges Disassembly (14.1″) v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 94 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 101
Color Silver Torque 2.5 kgf-cm 1310 Main Antenna Disassembly(14.1″) v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1170 LCD Disassembly" on page 77 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 102
(1) Color Silver Torque 2.5 kgf-cm 1320 Main Antenna Cable Reassembly v "1010 Battery Disassembly" on page 63 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 64 v "1070 Keyboard Disassembly" on page 68 v "1100 Middle Cover Disassembly" on page 71 v "1170 LCD Disassembly" on page 77 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 103
MT 2658/2659/2677 97 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 104
Locations Front View System-status indicators Computer display TrackPoint Rear View Ultrabay Plus Power jack TV port Parallel port Modem connector USB connector Monitor connector Ethernet connector 98 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 105
Bottom View 1 4 3 2 1. Battery pack 2. Memory slot door 3. Mini-PCI Card slot door 4. Docking connector MT 2658/2659/2677 99 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 106
Switch Locations SW2 Pin1 10 Boot Block Disabled 10 Boot Block Enabled Pin2 10 10 Check Check Password Password Enabled Disabled 100 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 107
Parts list 1 2 3 4 6 5 22 23 7 20 21 19 18 9 11 10 12 8 8 17 14 16 13 15 Note: The parts marked with asterisk are CRUs (customer replaceable units.) MT 2658/2659/2677 101 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 108
1 CRUs are defined as those CRUs that meet the following criteria: 1. No tools required for removal or replacement. Exception: Coin, thumb screws are acceptable. 2. Minimal technical expertise required. 3. Minimal Problem Determination is required (less than 5 minutes). Tier 2 CRUs are defined as - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 109
ASM DDR- 512M 10K0033** 14 Combo 802.11b/Modem 12P3863 Actiontec Mini-PCI Wireless Card 26P8513 IBM High Rate Wireless Mini-PCI Adapter 26P8472 15 Mini-PCI / DIMM door kit 46L6524 16 Main Battery Assy. (Li-Ion) Sanyo-W/W Sanyo-Japan Panasonic-W/W Panasonic-Japan 02K7054* 02K7058 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 110
20 FAN asm 21 Heat Sink Asm. (w/ thermal pad) 22 I/O Bracket 23 CPU Intel Pentium-4M 1.7 GHz CPU Intel Pentium-4M 1.6 GHz CPU Intel Pentium-4M 1.8 GHz FRU No. 27L4297* 27L4359* 05K9283* 46L6527 46P2589 46L6526 46P2587 46L6507 46P2588 46P2590 26P8449 26P8345 26P8346 104 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 111
3 LCD Hinge/Bracket kit (13″ TFT) 26P9720 4 LCD Invertor / LED card 14/13″ TFT 26P8139 (P/N 26P8140) 5 LCD cable Asm. (13″TFT) 27L0721 6 Antenna Kit 13″/14″ LCD Antenna L (Main) 13″/14″ 27L0723 46L6323 7 LCD Rear Cover asm (13/14″ TFT)-Wireless 26P9709 MT 2658/2659/2677 105 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 112
FRU No. 1 LCD Bezel asm ″R32″ (14″ TFT) 46L6503 2 LCD Panel asm (14″ TFT) DBU LG/LW Samsung 05K9888 11P8283 11P8280 3 LCD Hinge/Bracket kit (14″ TFT) 26P9719 4 LCD Invertor / LED card 14/13″ TFT 26P8139 (P/N 26P8140) 5 LCD cable asm (14″ TFT) 27L0720 106 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 113
13″/14″ LCD Antenna L (Main) 13″/14″ 7 LCD Rear Cover asm (13/14″ TFT)-Wireless LCD Rear Cover asm (13/14″ TFT) FRU No. 27L0723 46L6323 26P9709 26P9707 Keyboard 08K4546** 08K4548** 08K4550** 08K4552** 08K4554** 08K4556** 08K4558** 08K4560** 08K4562** 08K4564** 08K4566** MT 2658/2659/2677 107 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 114
Wrap Plug PC Test Card Audio Wrap Cable USB Parallel Test Cable Screwdriver Kit 5mm Socket Wrench Screwdriver Wireless Antenna Connector Tool ThinkPad hardware maintenance diskette version 1.07 FRU No. 72X8546 35G4703 66G5180 05K2580 95F3598 05K4694 27L8126 08K7159 108 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 115
cords: IBM power cords for a specific country are usually available only in that country. For 2-pin power cords: IBM power cord part number 13H5264* 13H5273* 36L8870* 49P2095* Used in these countries or regions Canada, U.S.A. Japan Argentina Brazil For 3-pin power cords: MT 2658/2659/2677 109 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 116
, CHH: 2658-BPH, BQH, CFH, CGH, CHH, BDH, BJH, CVH 2677-CFM, CGM: 2659-BPM, BQM, CFM, CGM, CHM 2658-BPM, BQM, CFM, CGM, CHM, A5M, A9M, BCM, BUM, BLM, BVM, CPM, CTM 2677-CFJ, CGJ: 2659-BPJ, BQJ, CFJ, CGJ, CHJ: 2658-BPJ, BQJ, CFJ, CGJ, CHJ, BGJ, BRJ, BTJ 110 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 117
-XP Pro (FR) 32P7786 Recovery CD Win-XP Pro (FR) 32P7786 Recovery CD Win-XP Pro (GR) 32P7787 Recovery CD Win-XP Pro (SP) 32P7788 Recovery CD Win-XP Pro (SP) 32P7788 Recovery CD Win-XP Pro (SP) 32P7788 2677-CFG, CGG: 2659-BPG, BQG, CFG, CGF, CHG: 2658-BPG, BQG, CFG, CGG, CHG, BAG, BJG - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 118
(US/ CA/ AP) Recovery CD Win2000 (US/ CA/ AP) Recovery CD Win2000 (US/ CA/ AP) Recovery CD Win2000 (LA-BR) 32P7575 32P7575 32P7575 32P7575 32P7579 Recovery CD Win2000 (LA-BR) Recovery CD Win2000 (DK) 32P7579 32P7580 Recovery CD Win2000 (FR) 32P7581 112 ThinkPad R32 Series 2677-CFG, CGG: 2659 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 119
CA/ AP) Recovery CD Win XP Home (LA-BR) Recovery CD Win XP Home (LA-BR) Recovery CD Win XP Home (DK) Recovery CD Win XP Home (FR) Recovery CD Win XP Home (GR) Recovery CD Win XP Home(SP) 32P7678 32P7678 32P7678 32P7682 32P7682 32P7683 32P7684 32P7685 32P7686 2659-BMF, BNF: 2658-BMF, BNF, A2F, C4F - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 120
32P7690 32P7691 2658-A4S, C6S, CCS, CDS 2658-A4X, C6X, CCX, CDX 2658-B2G, B3G 2658-B2G, B3G 2658-B2G, B3G 2658-B2G, B3G 2658-B2G, B3G Option Parts List Battery charges: Description Main Battery Li-Ion Option-W/W Main Battery Li-Ion Sanyo-W/W Main Battery Li-Ion Panasonic-W/W Main Battery Li-Ion - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 121
ThinkPad R32 Series Part II This section applies to the following models: 2677-BZX, 2659-CHX, 2659-BZX, 2658-CHX, 2658-BZX, 2658-DFX, 2658-G2X, 2658-G3X. MT 2658/2659/2677 115 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 122
overview of the system features. Feature Processor Chip set Bus architecture System memory CMOS RAM Video Video memory LCD(Bright Ctrl) Audio Floppy Diskette drive (By model) Hard disk driveUpgradable Ultrabay Plus Modem Ethernet IEEE 1394 (on planar) CDC Description Intel Pentium-4M-1.6GHz/1.7GHz - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 123
Card (PCMCIA) ThinkLight IR I/O ports Security chip support Power BIOS Description One Mini-PCI slot (802. 11b) Yes T2x1 or T3x1 (Cardbus w/o ZV Port) Two Type I/II or oneType III Yes Yes External monitor Parallel CRT Two USB Headphone Mic-in Speaker-out Telephone (RJ11) LAN (RJ45) TV-out (S-Video - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 124
enabled. The Arrow keys can be used as screen-scroll function keys. The cursor cannot be moved with the Arrow keys. Not all application programs support this function. You enable or disable Scroll Lock mode by pressing the ScrLk key. 118 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 125
Green Blinking green Blinking orange Orange (2) Standby mode Green Meaning Enough battery power remains for operation. The battery power charges up to 80% full power The battery pack needs to be charged The battery pack is being charged. The computer is in standby mode MT 2658/2659/2677 119 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 126
. FRU System board Power LCD unit Modem Audio Applicable test 1. CPU/Coprocessor (Diagnostics) 2. System board (Diagnostics) Battery (Diagnostics) 1. Video Adapter (Diagnostics) 2. Video (Interactive Tests) 1. Make sure the modem set up correctly. 2. Replacing the modem jack and modem card one at - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 127
Fan Applicable test 1. If a DIMM is installed, remove it and run Memory Test-Quick (Diagnostics) 2. If the problem does not recur, replace the DIMM and run the test again. 3. If the test does not detect the error, run Memory Test-Full (Diagnostics) 1. Power on system and check the air turbulence at - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 128
or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery. 122 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 129
amount of time. Do not short the battery terminals. CAUTION: Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type recommended by the manufacturer. Dispose of used batteries according to the manufacturer's instructions. MT 2658/2659/2677 123 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 130
: The screw does not separate from the PCI cover. 3 4 3 Note: There are 2 cables on step 4 : The gray cable is the main antenna and the black cable is the auxiliarey antenna. There is no step 3 if the Mini-PCI card is not stalled, then this cable will be connected to the 124 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 131
CDC card. Note: When you install the PCI card, remember to insert it into its socket at 20°, press it down and ensure the connection is well. 1030 Memory cover and Memory card Disassembly v "1010 Battery Disassembly" on page 123 2 1 MT 2658/2659/2677 125 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 132
the memory card toward the right side of the socket, insert the memory card, at an angle of approximately 20°, into the socket; then press it firmly. Pivot the memory card until it snaps into place. Side View 1040 Hard Disk Drive Disassembly v "1010 Battery Disassembly" on page 123 126 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 133
copy of all the information on the drive if possible. Never remove the drive while the system is operating or is in suspend mode. 1050 Hard Disk Drive Cover Disassembly v "1010 Battery Disassembly" on page 123 1 1060 CD-ROM Disassembly v "1010 Battery Disassembly" on page 123 MT 2658/2659/2677 127 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 134
1 2 3 1070 Keyboard Disassembly v "1010 Battery Disassembly" on page 123 1a 1b Step 1 Size (Quantity) M2.5 x L10 (2) Color Black 128 ThinkPad R32 Series Torque 3.2 kgf-cm - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 135
2 4 3 Notes: 1. When replacing the keyboard, make sure that the cable is clean and insert it fragile and could be damaged. Be careful when pulling out the cable. 1080 Backup Battery Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 MT 2658/2659/2677 129 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 136
. Use of an incorrect battery can result in ignition or explosion of the battery. Replacement batteries can be ordered from IBM or IBM Authorized Dealers. 1090 Safety Cover Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 130 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 137
1 1100 Middle Cover Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 1 2 MT 2658/2659/2677 131 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 138
v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 1 Step 1 Size (Quantity) M2.5 x L5 (1) Color Silver Torque 2.5 kgf-cm 132 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 139
CDC Modem Card) v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1110 CDC Cover Disassembly" on page 132 2 1 Notes: 1. If the Thinkpad R32 products are - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 140
(With CDC Modem Card) v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1110 CDC Cover Disassembly" on page 132 1 Notes: 1. If the Thinkpad R32 products are equipped with the CDC modem card, the wireless LAN board will - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 141
. 1150 Auxiliary Antenna Reassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1110 CDC Cover Disassembly" on page 132 MT 2658/2659/2677 135 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 142
and Inverter Cable Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1110 CDC Cover Disassembly" on page 132 1a 1b 136 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 143
from the system. 1170 LCD Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1110 CDC Cover Disassembly" on page 132 MT 2658/2659/2677 137 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 144
Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1040 Hard Disk Drive Disassembly" on page 126 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1170 LCD Disassembly" on page 137 138 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 145
1 Step 1 Size (Quantity) M2.5 x L10 (7) Color Black Torque 3.2 kgf-cm MT 2658/2659/2677 139 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 146
of the keyboard bezel facing the palm rest to remove it. Be careful not to break the latches. 1190 VGA Heat Sink Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1040 Hard Disk Drive Disassembly" on page 126 v "1070 Keyboard - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 147
1 Step 1 Size (Quantity) M2.5 x L5 (1) Color Silver Torque 2.5 kgf-cm 1200 PCMCIA Holder Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 v "1030 Memory cover and Memory card Disassembly" on page 125 1 MT 2658/2659/2677 141 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 148
and replacing the PCMCIA holder, make sure that the PCMCIA cards are removed and the eject levers are sticking out. 1210 Heat Sink Module Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 142 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 149
, CPU or System Board is replaced. Thermal Pad is stuck on the bottom side of Heat Sink Module with adhesive. Do not re-use the thermal pad. 1220 Fan Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 MT 2658 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 150
Step 1 Size (Quantity) M2.5 x L5 (3) Color Silver Torque 2.5 kgf-cm 1230 CPU Disassembly v "1010 Battery Disassembly" on page 123 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1210 Heat Sink Module Disassembly" on page 142 1 144 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 151
, CPU or System Board is replaced. Thermal Pad is stuck on the bottom side of Heat Sink Module with adhesive. Do not re-use the thermal pad. 1240 Speaker Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1040 Hard Disk Drive - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 152
Color Silver Torque 2.5 kgf-cm 1250 System Board Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1040 Hard Disk Drive Disassembly" on page 126 v "1060 CD-ROM Disassembly" on page 127 v "1070 Keyboard Disassembly" on page - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 153
not re-use the thermal pad. 1260 I/O Port Bracket Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1040 Hard Disk Drive Disassembly" on page 126 v "1060 CD-ROM Disassembly" on page 127 v "1070 Keyboard Disassembly" on page 128 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 154
1 2 Step 1 2 Size (Quantity) M2.5 x L6 M2 x L12 Color Silver Silver Torque 3.2 kgf-cm 1.6 kgf-cm 3 4 5 6 78 148 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 155
and attached beneath the one marked number 8. CAUTION: There are several types of system board FRU for the Thinkpad R32 series, as followed: v System board with IBM security chip a v System board without IBM security chip a Begin by checking the FRU number of the system board, and be sure to use - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 156
. 1270 LCD Bezel Disassembly (14.1″) v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1170 LCD Disassembly" on page 137 1 150 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 157
to break these latches. v Gently push the two LCD latches outward to remove the LCD bezel. 1280 LCD Inveter Disassembly(14.1″) v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 MT 2658/2659/2677 151 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 158
PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1170 LCD Disassembly" on page 137 v "1270 LCD Bezel Disassembly (14.1″)" on page 150 v "1280 LCD Inveter Disassembly(14.1″)" on page 151 1 152 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 159
2 Step 2 Size (Quantity) M2 x L4(2) Color Silver Torque 2.5 kgf-cm 3a 3b 4 Step 3 Size (Quantity) M2.5 x L6(2) Color Black Torque 2.5 kgf-cm MT 2658/2659/2677 153 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 160
4 of removing the LED board, please make sure the main antenna cable is lifted gently. 5 6 1300 LCD Bracket Hinges Disassembly (14.1″) v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 154 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 161
Silver Torque 2.5 kgf-cm 1310 Main Antenna Disassembly(14.1″) v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1170 LCD Disassembly" on page 137 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 162
Color Silver Torque 2.5 kgf-cm 1320 Main Antenna Cable Reassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 v "1070 Keyboard Disassembly" on page 128 v "1100 Middle Cover Disassembly" on page 131 v "1170 LCD Disassembly" on page 137 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 163
1330 Mylar Assembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 124 2 1 MT 2658/2659/2677 157 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 164
Locations Front View System-status indicators Computer display TrackPoint Rear View Ultrabay Plus Power jack TV port Parallel port Modem connector USB connector Monitor connector Ethernet connector 158 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 165
Bottom View 1 4 3 2 1. Battery pack 2. Memory slot door 3. Mini-PCI Card slot door 4. Docking connector MT 2658/2659/2677 159 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 166
Switch Locations SW2 Pin1 10 Boot Block Disabled 10 Boot Block Enabled Pin2 10 10 Check Check Password Password Enabled Disabled 160 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 167
Parts list 1 2 3 4 6 5 22 23 7 20 21 19 18 9 11 10 12 8 8 17 14 16 13 15 Note: The parts marked with asterisk are CRUs (customer replaceable units.) MT 2658/2659/2677 161 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 168
1 CRUs are defined as those CRUs that meet the following criteria: 1. No tools required for removal or replacement. Exception: Coin, thumb screws are acceptable. 2. Minimal technical expertise required. 3. Minimal Problem Determination is required (less than 5 minutes). Tier 2 CRUs are defined as - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 169
08K9774** Dogwood/ 40GB 11 HDD Cover 46L6523 12 Lower Case w/ label W/W for WR 62P4051 Lower Case w/ label EMEA for WR 62P4052 Lower Case w/ label IIPC-Cisco wireless 62P4058 Lower Case w/ label Japan-Cisco wireless 62P4059 13 CARD ASM DDR- 128M 10K0029** CARD ASM DDR- 256M 10K0031 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 170
asm 21 Heat Sink Asm. (w/ thermal pad) 22 I/O Bracket 23 CPU Intel Pentium-4M 1.6 GHz CPU Intel Pentium-4M 1.7 GHz CPU Intel Pentium-4M 1.8 GHz FRU No. 27L4297* 27L4359* 05K9283* 46L6527 46P2589 46L6526 46P3133 46P2587 46L6507 46P2588 46P2590 26P8345 26P8449 26P8346 164 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 171
. Description FRU No. 4 LCD Invertor / LED card 14/13″ TFT 26P8139 (P/N 26P8140) 6 Antenna Kit for D-1.5 (w/ puller TABs) 08K4072 Antenna Kit 13″/14″ LCD for D-1.5 08K4073 7 LCD Rear Cover asm (13/14″ TFT)-Wireless 26P9709 LCD Rear Cover asm (13/14″ TFT) 26P9707 MT 2658/2659/2677 165 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 172
/ LED card 14/13″ TFT 26P8139 (P/N 26P8140) 5 LCD cable asm (14″ TFT) 27L0720 6 Antenna Kit for D-1.5 (w/ puller TABs) 08K4072 Antenna Kit 13″/14″ LCD for D-1.5 08K4073 7 LCD Rear Cover asm (13/14″ TFT)-Wireless 26P9709 LCD Rear Cover asm (13/14″ TFT) 26P9707 166 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 173
** 08K4536** 08K4538** 08K4540** 08K4542** 08K4544** 08K4546** 08K4548** 08K4550** 08K4552** 08K4554** 08K4556** 08K4558** 08K4560** 08K4562** 08K4564** 08K4566** 08K4568** 08K4570** 08K4572** 08K4574** 08K4576** 08K4578** 08K4580** 08K4582** MT 2658/2659/2677 167 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 174
** 08K4612** 08K4614** 08K4616** Common parts list Tools: Description Tri-Connector Wrap Plug PC Test Card Audio Wrap Cable USB Parallel Test Cable Screwdriver Kit 5mm Socket Wrench Screwdriver Wireless Antenna Connector Tool ThinkPad hardware maintenance diskette version 1.07 FRU No. 72X8546 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 175
Power cords: IBM power cords for a specific country are usually available only in that country. For 2-pin power cords: IBM power power cords: Note: The grounded adapter is required for full MPRII compliance. If a 3-pin power cord came with your computer, see "Safety Information" on page 11. MT 2658 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 176
: 2658-CHH, BZH 2677-BZM:2659-CHM, BZM: 2658-CHM,BZM 2677-BZA: 2659-BZA: 2658-BZA 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 170 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 177
01R5626 Turkey-WinXP PRO Recovery CD Greek-WXP PRO 01R5627 Recovery CD Hungary-WinXP PRO Recovery CD Russian-WinXP PRO Recovery CD Polish-WinXP PRO 01R5628 01R5629 01R5625 2677-BZX: 2659-BZX: 2658-BZX 2677-BZS: 2659-BZS: 2658-BZS 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2677-BZG: 2659-CHG, BZG - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 178
CD Denmark-WinXP HOME 01R5670 01R5670 01R5676 01R5676 01R5672 62P8909 01R5731 01R5730 01R5730 01R5741 01R5740 01R5739 01R5738 01R5736 01R5736 01R5736 01R5733 172 ThinkPad R32 Series 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2677-BZG: 2659-CHG, BZG: 2658-CHG, BZG 2658-L6U, L7U, N7U, N8U 2658-N6A 2658 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 179
01R5745 01R5744 01R5743 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-K4P, N9K, NGP, NHP 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G Option Parts List Battery charges: Description Main Battery Li-Ion Option-W/W Main Battery Li-Ion Sanyo - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 180
SuperDisk drive (LS240) ZIP-250 drive 2nd HDD adapter Ultrabay Plus device carrier Ultrabay Plus numeric keypad Ultrabay Plus cradle for WorkPad c500 series FRU No. 08K9644* 27L4351* 27L4355* 27L4301* 27L3436* 08K9606* 08K9607* 08K9615* 00N8254* 08K6067* 26P9388* 19K2056* 26P9389* 174 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 181
ThinkPad R32 Series Part III This section applies to the following models: 2677-J3X, 2677-N3X, 2677-N4X, 2659-J3X, 2659-N3X, 2659-N4X, 2659-N5X, 2658-J3X, 2658-N3X, 2658-N4X, 2658-N5X, 2658-H4X, 2658-H3X, 2658-HAX, 2658-HBX, 2658-K3X, 2658-K4X, 2658-K5X, 2658-K6X, 2658-K7X, 2658-K8X, 2658-K9X, 2658- - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 182
of the system features. Feature Processor Chip set Bus architecture System memory CMOS RAM Video Video memory LCD(Bright Ctrl) Audio Floppy Diskette drive (By model) Hard disk driveUpgradable Ultrabay Plus Modem Ethernet IEEE 1394 (on planar) Description Intel Pentium-4M- 1.7GHz/ 1.8GHz/ 2.0GHz - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 183
) PC Card (PCMCIA) ThinkLight IR I/O ports Security chip support Power BIOS Description One CDC slot (MDC) One Mini-PCI slot (802. 11b-Modem Combo) or Mini-PCI slot (802. 11b) Yes T2x1 or T3x1 (Cardbus w/o ZV Port) Two Type I/II or oneType III Yes Yes External monitor Parallel CRT Two USB Headphone - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 184
enabled. The Arrow keys can be used as screen-scroll function keys. The cursor cannot be moved with the Arrow keys. Not all application programs support this function. You enable or disable Scroll Lock mode by pressing the ScrLk key. 178 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 185
Green Blinking green Blinking orange Orange (2) Standby mode Green Meaning Enough battery power remains for operation. The battery power charges up to 80% full power The battery pack needs to be charged The battery pack is being charged. The computer is in standby mode MT 2658/2659/2677 179 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 186
. FRU System board Power LCD unit Modem Audio Applicable test 1. CPU/Coprocessor (Diagnostics) 2. System board (Diagnostics) Battery (Diagnostics) 1. Video Adapter (Diagnostics) 2. Video (Interactive Tests) 1. Make sure the modem set up correctly. 2. Replacing the modem jack and modem card one at - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 187
Fan Applicable test 1. If a DIMM is installed, remove it and run Memory Test-Quick (Diagnostics) 2. If the problem does not recur, replace the DIMM and run the test again. 3. If the test does not detect the error, run Memory Test-Full (Diagnostics) 1. Power on system and check the air turbulence at - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 188
or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery. 182 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 189
amount of time. Do not short the battery terminals. CAUTION: Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type recommended by the manufacturer. Dispose of used batteries according to the manufacturer's instructions. MT 2658/2659/2677 183 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 190
: The screw does not separate from the PCI cover. 3 4 3 Note: There are 2 cables on step 4 : The gray cable is the main antenna and the black cable is the auxiliarey antenna. There is no step 3 if the Mini-PCI card is not stalled, then this cable will be connected to the 184 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 191
CDC card. Note: When you install the PCI card, remember to insert it into its socket at 20°, press it down and ensure the connection is well. 1030 Memory cover and Memory card Disassembly v "1010 Battery Disassembly" on page 183 2 1 MT 2658/2659/2677 185 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 192
the memory card toward the right side of the socket, insert the memory card, at an angle of approximately 20°, into the socket; then press it firmly. Pivot the memory card until it snaps into place. Side View 1040 Hard Disk Drive Disassembly v "1010 Battery Disassembly" on page 183 186 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 193
copy of all the information on the drive if possible. Never remove the drive while the system is operating or is in suspend mode. 1050 Hard Disk Drive Cover Disassembly v "1010 Battery Disassembly" on page 183 1 1060 CD-ROM Disassembly v "1010 Battery Disassembly" on page 183 MT 2658/2659/2677 187 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 194
1 2 3 1070 Keyboard Disassembly v "1010 Battery Disassembly" on page 183 1a 1b Step 1 Size (Quantity) M2.5 x L10 (2) Color Black 188 ThinkPad R32 Series Torque 3.2 kgf-cm - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 195
2 4 3 Notes: 1. When replacing the keyboard, make sure that the cable is clean and insert it fragile and could be damaged. Be careful when pulling out the cable. 1080 Backup Battery Disassembly v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 MT 2658/2659/2677 189 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 196
. Use of an incorrect battery can result in ignition or explosion of the battery. Replacement batteries can be ordered from IBM or IBM Authorized Dealers. 1090 Safety Cover Disassembly v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 190 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 197
1 1100 Middle Cover Disassembly v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 1 2 MT 2658/2659/2677 191 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 198
v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 1 Step 1 Size (Quantity) M2.5 x L5 (1) Color Silver Torque 2.5 kgf-cm 192 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 199
CDC Modem Card) v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1110 CDC Cover Disassembly" on page 192 2 1 Notes: 1. If the Thinkpad R32 products are - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 200
(With CDC Modem Card) v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1110 CDC Cover Disassembly" on page 192 1 Notes: 1. If the Thinkpad R32 products are equipped with the CDC modem card, the wireless LAN board will - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 201
. 1150 Auxiliary Antenna Reassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1110 CDC Cover Disassembly" on page 192 MT 2658/2659/2677 195 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 202
and Inverter Cable Disassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1110 CDC Cover Disassembly" on page 192 1a 1b 196 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 203
from the system. 1170 LCD Disassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1110 CDC Cover Disassembly" on page 192 MT 2658/2659/2677 197 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 204
Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1040 Hard Disk Drive Disassembly" on page 186 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1170 LCD Disassembly" on page 197 198 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 205
1 Step 1 Size (Quantity) M2.5 x L10 (7) Color Black Torque 3.2 kgf-cm MT 2658/2659/2677 199 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 206
of the keyboard bezel facing the palm rest to remove it. Be careful not to break the latches. 1190 VGA Heat Sink Disassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1040 Hard Disk Drive Disassembly" on page 186 v "1070 Keyboard - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 207
1 Step 1 Size (Quantity) M2.5 x L5 (1) Color Silver Torque 2.5 kgf-cm 1200 PCMCIA Holder Disassembly v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 v "1030 Memory cover and Memory card Disassembly" on page 185 1 MT 2658/2659/2677 201 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 208
and replacing the PCMCIA holder, make sure that the PCMCIA cards are removed and the eject levers are sticking out. 1210 Heat Sink Module Disassembly v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 202 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 209
, CPU or System Board is replaced. Thermal Pad is stuck on the bottom side of Heat Sink Module with adhesive. Do not re-use the thermal pad. 1220 Fan Disassembly v "1010 Battery Disassembly" on page 183 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 MT 2658 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 210
1 2 4 3c 3a 3b Step 3 Size (Quantity) M2.5 x L5 (3) Color Silver 204 ThinkPad R32 Series Torque 2.5 kgf-cm - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 211
202 1 2 Note: Thermal Pad must be replaced when either Heat Sink Module, CPU or System Board is replaced. Thermal Pad is stuck on the bottom side of Heat Sink Module with adhesive. Do not re-use the thermal pad. 1240 Speaker Disassembly v "1010 Battery Disassembly" on page 183 MT 2658/2659/2677 205 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 212
Color Silver Torque 2.5 kgf-cm 1250 System Board Disassembly v "1010 Battery Disassembly" on page 123 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1040 Hard Disk Drive Disassembly" on page 186 v "1060 CD-ROM Disassembly" on page 187 v "1070 Keyboard Disassembly" on page - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 213
1 Step 1 Size (Quantity) M2.5 x L5(2) Color Silver Torque 2.5 kgf-cm 3 2 Notes: 1. When removing the system board from the bottom cover, gently raise the side of the system board facing the rear I/O ports; then pull out the system board. MT 2658/2659/2677 207 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 214
not re-use the thermal pad. 1260 I/O Port Bracket Disassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1040 Hard Disk Drive Disassembly" on page 186 v "1060 CD-ROM Disassembly" on page 187 v "1070 Keyboard Disassembly" on page 188 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 215
one marked 5 should be installed above the one marked 6; the one marked number 7 should be aligned with and attached beneath the one marked number 8. MT 2658/2659/2677 209 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 216
CAUTION: There are several types of system board FRU for the Thinkpad R32 series, as followed: v System board with IBM security chip a v System board without IBM security chip a Begin by checking the FRU number of the system board, and be sure to use the correct system board FRU for the computer. - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 217
warranty. 1270 LCD Bezel Disassembly (14.1″) v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1170 LCD Disassembly" on page 197 1 MT 2658/2659/2677 211 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 218
to break these latches. v Gently push the two LCD latches outward to remove the LCD bezel. 1280 LCD Inveter Disassembly(14.1″) v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 212 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 219
Color Black Torque 2.5 kgf-cm 1290 LCD Board Disassembly(14.1″) v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1170 LCD Disassembly" on page 197 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 220
2 Step 2 Size (Quantity) M2 x L4(2) Color Silver Torque 2.5 kgf-cm 3a 3b 4 Step 3 Size (Quantity) M2.5 x L6(2) Color Black Torque 2.5 kgf-cm 214 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 221
4 of removing the LED board, please make sure the main antenna cable is lifted gently. 5 6 1300 LCD Bracket Hinges Disassembly (14.1″) v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 MT 2658/2659 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 222
Silver Torque 2.5 kgf-cm 1310 Main Antenna Disassembly(14.1″) v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1170 LCD Disassembly" on page 197 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 223
Color Silver Torque 2.5 kgf-cm 1320 Main Antenna Cable Reassembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 v "1070 Keyboard Disassembly" on page 188 v "1100 Middle Cover Disassembly" on page 191 v "1170 LCD Disassembly" on page 197 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 224
1330 Mylar Assembly v "1010 Battery Disassembly" on page 183 v "1020 Mini-PCI cover and Mini-PCI card Disassembly" on page 184 2 1 218 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 225
Locations Front View System-status indicators Computer display TrackPoint Rear View Ultrabay Plus Power jack TV port Parallel port Modem connector USB connector Monitor connector Ethernet connector MT 2658/2659/2677 219 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 226
Bottom View 1 4 3 2 1. Battery pack 2. Memory slot door 3. Mini-PCI Card slot door 4. Docking connector 220 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 227
Switch Locations SW2 Pin1 10 Boot Block Disabled 10 Boot Block Enabled Pin2 10 10 Check Check Password Password Enabled Disabled MT 2658/2659/2677 221 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 228
Parts list 1 2 3 4 6 5 22 23 7 20 21 19 18 9 11 10 12 8 8 17 14 16 13 15 Note: The parts marked with asterisk are CRUs (customer replaceable units.) 222 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 229
1 CRUs are defined as those CRUs that meet the following criteria: 1. No tools required for removal or replacement. Exception: Coin, thumb screws are acceptable. 2. Minimal technical expertise required. 3. Minimal Problem Determination is required (less than 5 minutes). Tier 2 CRUs are defined as - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 230
Aironet Wireless 802.11b Mini-PCI for Japan 26P8369 IBM High Rate Wireless Mini-PCI Adapter 26P8472 15 Mini-PCI / DIMM door kit for D-2 62P4164 16 Main Battery Assy. (Li-Ion) Sanyo-W/W Sanyo-Japan Panasonic-W/W Panasonic-Japan 02K7054* 02K7058* 02K6928* 02K7060* 224 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 231
Base cover Misc parts kit 46P2587 20 FAN asm 46L6507 21 Heat Sink/ FAN Asm. (w/ thermal pad) 62P4162 for D-2 22 I/O Bracket 46P2590 23 CPU Intel Pentium-4M 1.7 GHz 26P8449 CPU Intel Pentium-4M 1.8 GHz 26P8346 CPU Intel Pentium-4M 2.0 GHz 26P8473 CPU Celeron 1.5GHz 26P8469 MT 2658 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 232
Description FRU No. 4 LCD Invertor / LED card 14/13″ TFT 26P8139 (P/N 26P8140) 6 Antenna Kit for D-1.5 (w/ puller TABs) 08K4072 Antenna Kit 13″/14″ LCD for D-1.5 08K4073 7 LCD Rear Cover asm (13/14″ TFT)-Wireless 26P9709 LCD Rear Cover asm (13/14″ TFT) 26P9707 226 ThinkPad R32 Series - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 233
/ LED card 14/13″ TFT 26P8139 (P/N 26P8140) 5 LCD cable asm (14″ TFT) 27L0720 6 Antenna Kit for D-1.5 (w/ puller TABs) 08K4072 Antenna Kit 13″/14″ LCD for D-1.5 08K4073 7 LCD Rear Cover asm (13/14″ TFT)-Wireless 26P9709 LCD Rear Cover asm (13/14″ TFT) 26P9707 MT 2658/2659/2677 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 234
English KBD ASM French KBD ASM Dutch KBD ASM Swedish/Finnish KBD ASM Norwegian KBD ASM Danish KBD ASM Italian KBD ASM European Spanish 228 ThinkPad R32 Series Vendor NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB NMB - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 235
** 08K4612** 08K4614** 08K4616** Common parts list Tools: Description Tri-Connector Wrap Plug PC Test Card Audio Wrap Cable USB Parallel Test Cable Screwdriver Kit 5mm Socket Wrench Screwdriver Wireless Antenna Connector Tool ThinkPad hardware maintenance diskette version 1.07 FRU No. 72X8546 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 236
(Delta) AC ADAPTER, 72W 2-pinS (ASTEC) FRU No. 02K6751* 02K6754* 02K6756* 02K6753* Power cords: IBM power cords for a specific country are usually available only in that country. For 2-pin power cords: IBM power cord part number 13H5264* 13H5273* 36L8870* 46P2095* Used in these countries or - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 237
IBM power cord part number 76H3514* 76H3516* 76H3530* 76H3520* CD 01R6093 English-WinXP PRO (US) Revoery CD 01R6093 English-WinXP PRO (US) Revoery CD 01R6093 English-WinXP PRO (US) MODELS 2677- L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G 2659 L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G, H2G 2658 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 238
PRO (US) Revoery CD 01R6093 English-WinXP PRO (US) Recovery CD 01R6104 Norway-WinXP PRO Recovery CD 01R6104 Norway-WinXP PRO Recovery CD 01R6104 Norway-WinXP PRO Recovery CD Netherland-WinXP PRO Recovery CD Netherland-WinXP PRO 01R6103 01R6103 232 ThinkPad R32 Series 2677-L2H, L3H - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 239
-WinXP PRO Recovery CD Italy-WinXP PRO Recovery CD Italy-WinXP PRO 01R6101 01R6101 Recovery CD Italy-WinXP PRO 01R6101 Recovery CD Spanish-WinXP PRO 01R6099 Recovery CD Spanish-WinXP PRO 01R6099 Recovery CD Spanish-WinXP PRO 01R6099 Recovery CD Spanish-WinXP PRO 01R6099 2658- L2G, L3G - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 240
-WinXP PRO 01R6100 01R6100 01R6100 Recovery CD 01R6097 French-WinXP PRO Recovery CD 01R6097 French-WinXP PRO Recovery CD 01R6097 French-WinXP PRO Recovery CD 01R6097 French-WinXP PRO Recovery CD 01R6097 French-WinXP PRO 234 ThinkPad R32 Series 2677- L2G, L3G, L4G, L5G, N2G, N3G - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 241
Recovery Portuguese-WinXP PRO 01R6095 Recovery CD 62P4777 Japan-WinXP PRO Recovery CD 62P4777 Japan-WinXP PRO Recovery CD Hong Kong-TC-WinXP PRO 67P4980 Recovery CD Hong Kong-TC-WinXP PRO 67P4980 Recovery CD Traditional Chinese-WinXP PRO 67P4974 2658- L2F, L3F, L4F, L5F, N2F, N3F - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 242
-WXP PRO 01R6110 Recovery CD Greek-WXP PRO 01R6110 Recovery CD Greek-WXP PRO 01R6110 Recovery CD Hungary-WinXP PRO Recovery CD Hungary-WinXP PRO Recovery CD Hungary-WinXP PRO 01R6111 01R6111 01R6111 Recovery CD Russian-WinXP PRO 01R6112 236 ThinkPad R32 Series 2658- L2T, L3T, L4T, N2T - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 243
01R6107 Hebrew-WinXP PRO Recovery CD CZ-WinXP PRO Recovery CD CZ-WinXP PRO 01R6106 01R6106 Recovery CD CZ-WinXP PRO 01R6106 Recovery CD English-Win2000 (US) Recovery CD English-Win2000 (US) 01R5670 01R5670 2659- L2G, L3G, L4G, L5G, N2G, N3G, N4G, N5G, H2G 2658- L2G, L3G, L4G, L5G, N2G, N3G - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 244
HOME Recovery CD German-WinXP HOME 01R5735 238 ThinkPad R32 Series 2658-L6X, L7X, N7X, N8X 2658-L6S, L7S, N7S, N8S 2658-L6P, L7P, N7P, N8P 2658-MJJ 2658-L8G, L9G 2658- K3U, K4U, LCU, N9U, NGU, NHU 2658-K4A, K5A: 2658-N9M: 2658-LAH, NEH, NFH 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 245
-K4P, N9P, NGP, NHP 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-L8G, L9G 2658-LAB 2658-K6T, NAT, NBT, NCT, NET, LAT, LBT, LDT, LFT 2658-LAC Option Parts List Battery charges: Description Main Battery Li-Ion Option-W/W Main Battery Li-Ion Sanyo-W/W Main - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 246
-250 drive 2nd HDD adapter Ultrabay Plus device carrier Ultrabay Plus numeric keypad Ultrabay Plus cradle for WorkPad c500 series FRU No. 08K9785* 08K9818* 08K9820* 08K9644* 27L4351* 27L4355* 27L4301* 27L3436* 08K9606* 08K9607* 08K9615* 00N8254* 08K6067* 26P9388* 19K2056* 26P9389* 240 ThinkPad R32 - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 247
be used instead of the IBM product, program, or service. The evaluation and verification of operation in conjunction with other products, except those expressly designated by IBM, are the responsibility of the user. IBM may have patents or pending patent applications covering subject matter in this - Lenovo ThinkPad R32 | Hardware Maintenance Manual - Page 248
service marks of IBM Corporation in the United States and other countries: IBM USB ThinkPad TrackPoint TrackPoint IV The following terms are trademarks or service and Company Watergate Software, Inc. Personal Computer Memory Card Interface Association Intel Corporation 242 ThinkPad R32 Series
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
 |
 |
ThinkPad R32 Series Hardware
Maintenance Manual
±²³