Poulan DB24H48YT User Manual

Poulan DB24H48YT Manual

Get Poulan DB24H48YT PDF manuals and user guides View all Poulan DB24H48YT manuals
Add to My Manuals
Save this manual to your list of manuals

Poulan DB24H48YT manual content summary:

  • Poulan DB24H48YT | User Manual - Page 1
    Do Not Throw Away 02139 OPERATOR'S MANUAL MODEL: DB24H48YT LAWN TRACTOR WARNING: Read this Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 195032 10.28.04 TR
  • Poulan DB24H48YT | User Manual - Page 2
    percentage of riding mower-related injuries. These operators should evaluate their ability to operate the riding mower safely enough , understand, and follow all instructions on the machine and in the manual before starting. • Do not put hands or feet near rotating parts or under the machine. Keep
  • Poulan DB24H48YT | User Manual - Page 3
    and replace with manufacturer's recommended parts, when necessary. • Mower blades are sharp. Wrap the blade or wear gloves, and use extra caution when servicing them. • Check brake operation frequently. Adjust and service as required. • Maintain or replace safety and instruction labels, as necessary
  • Poulan DB24H48YT | User Manual - Page 4
    . Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor. Please read and retain this manual. The instructions will enable you to
  • Poulan DB24H48YT | User Manual - Page 5
    UNASSEMBLED PARTS Steering Wheel Seat Steering Wheel Adapter (1) Large Flat Washer Steering Wheel Insert Clevis Pins Nose Roller Brackets (2) Hex Bolts 5/16-18 x 1 (2) Locknuts 5/16-18 Mower (2) Retainer Springs (single loop) (5) Retainer Springs (double loop) (4) Shoulder Bolt Key (1)
  • Poulan DB24H48YT | User Manual - Page 6
    Utility knife When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). TO REMOVE TRACTOR FROM CARTON UNPACK CARTON • Remove all accessible loose parts and parts cartons from carton. • Cut along dotted lines on all four
  • Poulan DB24H48YT | User Manual - Page 7
    If this battery is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions). LABEL TO ROLL TRACTOR OFF SKID (See Operation section
  • Poulan DB24H48YT | User Manual - Page 8
    WHEELS" in the Operation section of this manual. RETAINER SPRING PIN SHOULDER BOLT ADJUSTING BAR GAUGE WHEEL 3/8 WASHER 3/8-16 CENTER LOCKNUT FIG. 5 INSTALL MOWER AND DRIVE BELT (See Figs. 6 and 7) Be sure tractor is on level surface and mower suspension arms are raised with attachment lift
  • Poulan DB24H48YT | User Manual - Page 9
    still secure and wires are properly clamped. CHECK FOR PROPER POSITION OF ALL BELTS See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual. Verify that the belts are routed correctly. ✓ Before driving tractor, be sure
  • Poulan DB24H48YT | User Manual - Page 10
    MOWER HEIGHT 15 MOWER LIFT 15 ATTACHMENT ATTACHMENT CLUTCH DISENGAGED CLUTCH ENGAGED DANGER, KEEP HANDS AND FEET AWAY KEEP AREA CLEAR SLOPE HAZARDS (SEE SAFETY RULES SECTION) FREE WHEEL (Automatic Models only) LIGHTS ON Failure to follow instructions in damage to the tractor and/or engine.
  • Poulan DB24H48YT | User Manual - Page 11
    TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual tractor with the engine off. HEIGHT ADJUSTMENT KNOB - Used to adjust the mower
  • Poulan DB24H48YT | User Manual - Page 12
    and remove key. Always remove key when leaving tractor to prevent unauthorized use. • Never use choke rate. • Full throttle offers the best bagging and mower perfor- mance. TO USE CHOKE CONTROL (See Fig during hot months. For healthier and better looking lawns, mow often and after moderate growth. •
  • Poulan DB24H48YT | User Manual - Page 13
    prevent scalping in most terrain conditions. NOTE:Adjust gauge wheels with tractor on a flat level surface. • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual). • Remove retainer spring and clevis pin which secure each gauge wheel
  • Poulan DB24H48YT | User Manual - Page 14
    this manual). • To change engine oil, see the Maintenance section in this manual. in storage. To avoid engine problems, the fuel system should be fuel next season. See Storage Instructions for additional information. Never use cations of the manufacturer of your tractor. Use common sense when towing.
  • Poulan DB24H48YT | User Manual - Page 15
    transmission should be warmed up as follows: • Be sure the tractor is on level ground. • Place the motion control lever in Mower should be properly leveled for best mowing performance. See "TO LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual. • The left hand side of mower
  • Poulan DB24H48YT | User Manual - Page 16
    as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tractor. At least once a season, check to see if you should make any of the adjustments described in the Service and Adjustments section of this manual. • At least once a year you should
  • Poulan DB24H48YT | User Manual - Page 17
    . (See "TO ADJUST BRAKE" in the Service and Adjustments section of this manual). CAUTION: Use only a replacement blade approved by the manufacturer of your tractor. Using a blade not approved by the manufacturer of your tractor is hazardous, could damage your tractor and void your warranty. TIRES
  • Poulan DB24H48YT | User Manual - Page 18
    battery from tractor. • Rinse the battery with plain water and dry. • Clean terminals and battery cable ends with wire brush until bright. • Coat terminals with grease or petroleum jelly. • Reinstall battery (See "REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). V-BELTS
  • Poulan DB24H48YT | User Manual - Page 19
    a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. 19
  • Poulan DB24H48YT | User Manual - Page 20
    WARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: • Depress clutch/brake pedal fully and all moving parts have completely stopped. • Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. TRACTOR TO REMOVE MOWER (See Fig
  • Poulan DB24H48YT | User Manual - Page 21
    suspension. • Raise deck to highest position. TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See "PRODUCT SPECIFICATIONS" section of this manual). If tires are over or underinflated, you will not properly adjust your
  • Poulan DB24H48YT | User Manual - Page 22
    SERVICE AND ADJUSTMENTS BOTH FRONT PLATE LINKS MUST BE EQUAL IN LENGTH 02516 NUT "D" 02517 FRONT PLATE ASSEMBLY NUT "C" TRUNNION FIG. 22 TO REPLACE MOWER DRIVE BELT MOWER DRIVE BELT REMOVAL (See Fig. 23) • Park tractor on a level surface. Engage parking brake. • Lower mower arm. MOWER DRIVE BELT
  • Poulan DB24H48YT | User Manual - Page 23
    SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE (SECONDARY) DRIVE BELT (See Fig. 24) Park the tractor on level surface. Engage parking brake. • Remove mower (See "TO REMOVE MOWER" in this section of manual). • Remove screws from R.H. and L.H. mandrel covers and remove covers. REMOVE MOWER DRIVE BELT
  • Poulan DB24H48YT | User Manual - Page 24
    mower (See "TO REMOVE MOWER" in this section of manual). NOTE: Observe entire motion drive belt and position of all belt guides and keepers. • Disconnect clutch wire adjustment bolt, move mower deck height to the lowest position. After above adjustment is made, if the tractor still creeps forward or
  • Poulan DB24H48YT | User Manual - Page 25
    instructions in the Assembly section of this manual. FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your tractor tires due to slow leaks, tire sealant may be purchased from your local parts dealer. Tire sealant also prevents tire dry rot and corrosion. TO START
  • Poulan DB24H48YT | User Manual - Page 26
    adjustment should not be necessary. If adjustment is necessary, see engne manual. TO ADJUST CARBURETOR Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment. 26
  • Poulan DB24H48YT | User Manual - Page 27
    enclosure. TRACTOR Remove mower from tractor for winter storage. When mower is tractor (See "CLEANING" in the Mainte- nance section of this manual). • Inspect and replace belts, if necessary (See belt re- placement instructions in the Service and Adjustments section of this manual SYSTEM PARTS SUCH
  • Poulan DB24H48YT | User Manual - Page 28
    TROUBLESHOOTING POINTS PROBLEM Will not start CAUSE 1. Out of fuel. 2. Engine not "CHOKED" properly. 3. Engine flooded. 4. Bad spark plug. 5. Dirty air filter. 6. Dirty fuel filter. 7. Water in fuel. 8. Loose or damaged wiring. 9. Carburetor out of adjustment. 10. Engine valves out of adjustment.
  • Poulan DB24H48YT | User Manual - Page 29
    TROUBLESHOOTING POINTS PROBLEM CAUSE Engine dies when tractor is shifted into reverse 1. Reverse operation system (ROS) is not "ON" while mower or other attachment is engaged. Engine continues to run when operator leaves seat with attachment clutch engaged 1. Faulty operator-safety presence
  • Poulan DB24H48YT | User Manual - Page 30
    parts or labor incurred in replacing parts, any part instructions furnished. Electrolux Home Products, Inc. Outdoor Products Customer Service Dept. 1030 Stevens Creek Road Augusta, GA 30907 USA In Canada contact: Electrolux Canada Corp. 7075 Ordan Drive Mississauga, Ontario L5T 1K6 giving the model
  • Poulan DB24H48YT | User Manual - Page 31
    31 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION TFHOISLDISAALO15NDGEDGORTETEESDLLOINPEE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than
  • Poulan DB24H48YT | User Manual - Page 32
    the following information: a. Model Number/Manufacturer's I.D. Number b. Description of part. For Techical Assistance: call 1-800-829-5886 For a Parts Manual, go to our website: www.poulan-pro.com/support.asp NOTE: Electrolux Home Products provides parts and service through its authorized
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
OPERATOR'S MANUAL
MODEL:
DB24H48YT
LAWN TRACTOR
ALWAYS WEAR EYE PROTECTION DURING OPERATION
Visit our website: www.poulan-pro.com
WARNING:
Read this Manual and follow all Warnings and
Safety Instructions.
Failure to do so can result
in serious
injury.
IMPORTANT MANUAL
Do Not Throw Away
195032
10.28.04
TR
Printed in U.S.A.
02139