Konica Minolta AccurioPress C14000 Watkiss PowerSquare 2-Knife Trimmer User Ma
Konica Minolta AccurioPress C14000 Manual
View all Konica Minolta AccurioPress C14000 manuals
Add to My Manuals
Save this manual to your list of manuals |
Konica Minolta AccurioPress C14000 manual content summary:
- Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 1
Watkiss P2T 2-Knife Trimmer User Manual English, Issue 1a, October 2016 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 2
© Watkiss Automation Limited 2016 All Rights Reserved. Reproduction, adaptation, or translation without prior written permission is prohibited, except as allowed under the copyright laws. Warranty The information contained in this document is subject to change without notice. Watkiss Automation - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 3
-fit the Side-Trimmer Book Supports 17 5. Error Conditions, Problems and Solutions 25 Side-Trimmer Error 25 Quality Problems 25 Side-Trimmer Message List 30 Paper Jams 33 Change the Fuses - Side-Trimmer 33 continued . . . User Manual for - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 4
6. Maintenance 35 Service Maintenance 35 Operator Maintenance 35 7. Specifications 37 8. Declaration of Conformity 39 ii Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 5
and Caution Messages The warning and caution messages used in this manual are shown below. WARNING: A WARNING message tells you that a procedure or operation can be dangerous. To prevent injury, you must follow the instructions. CAUTION: A CAUTION message tells you that a procedure or operation can - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 6
Installation Your Side-Trimmer must be installed by a Watkiss approved service engineer. Special knowledge is needed to install the machine. CAUTION: you have any questions or problems, refer to the problem solving section in this manual (see "Error Conditions, Problems and Solutions" on page 25 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 7
ON/OFF The mains power ON/OFF switch turns ON the switch Side-Trimmer or turns OFF the Side-Trimmer. Watkiss P2T 2-Knife Trimmer User Manual 3 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 8
the Side-Trimmer No. Component Function 8 Fuses The fuses make sure the operator and the machine are protected if there is an electrical problem or short circuit. 9 Rating and serial label The rating label displays the type of machine, serial number, power use and fuse information. 4 Watkiss - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 9
according to the PAGE SIZE. • To change the size and trim position, touch SIDE TRIM. See "Side-Trim" on page 8. Watkiss P2T 2-Knife Trimmer User Manual 5 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 10
Adjust the Stacker • If the side-trim size is 190mm or less, remove the book supports. See "Remove and re-fit the Side-Trimmer Book Supports" on page 46. Adjust the Stacker Adjust the stacker according to the size and thickness Side-Trim Bin" on page 13. 6 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 11
CHAPTER 3 The User Interface FIGURE 3. The booklet maker Touch Screen Side-Trimmer adjustment Watkiss P2T 2-Knife Trimmer User Manual 7 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 12
shows if the trim is offset from the centre-line. A red X shows that the side-trim function is not active. 8 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 13
line. The range is -40mm to +40mm, dependent on how much is to be trimmed. The default setting is 0mm. Watkiss P2T 2-Knife Trimmer User Manual 9 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 14
make changes to the configuration of the Some functions and buttons are only available at certain access levels. Refer to your booklet maker manual. Button Information Hidden Active Visible Operator Supervisor - SIDE TRIM (P2T) Touch SIDE TRIM (P2T) to switch off communication to the Side - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 15
changes to show the setting. The icon is the same orientation as the book delivery out of the Side-Trimmer. Watkiss P2T 2-Knife Trimmer User Manual 11 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 16
the default side-trim offset 1. Touch BASIC > SIDE TRIM and then touch AUTO. 2. Touch CLOSE to close the window. 12 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 17
-trim bin under the chute. Check the bin is positioned close to the machine. Magnets hold the bin in position. Watkiss P2T 2-Knife Trimmer User Manual 13 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 18
tray Set the collection table position according to the size of the book. Read the setting through the window. 14 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 19
to a folded position. Procedure - Lower the stacker 1. Push down on the top of the stacker until it clicks into position. Watkiss P2T 2-Knife Trimmer User Manual 15 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 20
and communication cables. When needed, rotate the Side-Trimmer back to the docked position, the latch will click closed. 16 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 21
) 1. Outer book support, left (marked LH OUT) 2. Inner book support, left (marked LH IN) 3. Centre book support 4. Inner book support, right (marked RH IN) 5. Outer book support, right (marked RH OUT) FIGURE 14. Side-Trimmer book supports Watkiss P2T 2-Knife Trimmer User Manual 17 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 22
4 - Standard Tasks - Remove and re-fit the Side-Trimmer Book Supports Top Cover Outfeed Guard FIGURE 15. The side-trimmer Pivot bearings FIGURE 16. View through the top cover. Pivot-bearings visible. FIGURE 17. View through - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 23
18 There is enough space to remove the book supports. • Open the top cover of the SideTrimmer. • Go to "Step 2 - remove the centre book support". If the pivot-bearings are visible: See Figure . • Go to "Step 2 - remove the centre book support". Watkiss P2T 2-Knife Trimmer User Manual 19 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 24
Book Supports Step 2 - remove the centre book support The centre book support is secured with spring clips. Hold the centre book support with supports There are two inner book supports. Remove one at a time. Hold each end of the inner book support and lift upwards. Remove the inner book support - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 25
There is enough space to fit the book supports. • Open the top cover of the SideTrimmer. • Go to "Step 2 - fit the inner and outer book supports". If the pivot-bearings are visible: See Figure • Go to "Step 2 - fit the inner and outer book supports". Watkiss P2T 2-Knife Trimmer User Manual 21 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 26
on page 17. On each book support, there are semicircular cut outs at each end. Position the cut-outs over the fixing points. Press down on the book support so that it fits onto the fixing points. Fixing Repeat with the other book supports. Cut-out 22 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 27
the outfeed guard open with one hand and slide the centre book support in though the opening. Keep the book support central. See Figure 15 on page 18 The centre book support is secured with spring clips. Hold the centre book support with two hands. Lift and slide forwards until it clips onto the - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 28
4 - Standard Tasks - Remove and re-fit the Side-Trimmer Book Supports 24 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 29
screen. See "Side-Trimmer Message List" on page 30. Refer also to your booklet maker user manual. Quality Problems Fore-edge trim Side-Trim Side-Trim FIGURE 18. Fore-edge trimming and side-trimming Trimming problems can affect the fore-edge trim or the side-trim. Make sure you follow the correct - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 30
in the SIDE TRIM window? No Yes Set SIDE TRIM to AUTO. Does the problem continue? Yes No Further action is not needed. If you need to use a cover of the side-trimmer. Wait for the side-trimmer to reset. Does the problem continue? Yes No Further action is not needed. Turn off the Side-Trimmer at - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 31
Problems and Solutions - Quality Problems Side-Trimming problem Does the problem continue? problem continue? Yes No Further action is not needed. Call your service engineer. Side-Trimming problem - the book is only trimmed on one side This problem Does the problem continue? Does the problem continue? - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 32
-Trimmer Book Supports" on page 17. Does the problem continue? Yes No No further action is needed. Turn off the Side-Trimmer at the mains ON/OFF switch. Wait for 5 seconds and then turn on the Side-Trimmer. Does the problem continue? Yes No Further action is not needed. Call your service engineer - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 33
the Side-Trimmer Book Supports" on page 17. Call your service engineer if there are marks on the trimmed edge different to a normal witness mark or if the edge is badly trimmed. Side-Trimming problem - cannot enter settings and/or the amount of trim. Watkiss P2T 2-Knife Trimmer User Manual 29 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 34
at least 5 seconds and then turn the side-trimmer ON. If the problem continues, then call your service engineer. Open and then close the top cover of the side-trimmer. Then side-trimmer ON. If the problem continues, then call your service engineer. 30 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 35
at least 5 seconds and then turn the side-trimmer ON. If the problem continues, then call your service engineer. The side-trim axis is moving. This message clears when the adjustment -trimmer ON. If the problem continues, then call your service engineer. Watkiss P2T 2-Knife Trimmer User Manual 31 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 36
problem continues, then call your service engineer. SYSTEM ERROR 41.39 If the side-trimmer setting is 190mm or less, check that the book supports are removed. Otherwise, follow the instructions If the problem continues, then call your service engineer. 32 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 37
wait at least 5 seconds and then turn the side-trimmer ON. If the problem continues, then call your service engineer. Change the Fuses - Side-Trimmer Introduction The Side-Trimmer has two fuses fuse breaks again, then call your Watkiss service engineer. Watkiss P2T 2-Knife Trimmer User Manual 33 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 38
5 - Error Conditions, Problems and Solutions - Change the Fuses - Side-Trimmer 34 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 39
a Watkiss approved service engineer can service the Side-Trimmer. Contact your supplier for further information. Operator Maintenance We recommend that you clean the Side-Trimmer every week to remove surface dust. CAUTION: Only clean the machine with materials that are recommended in this manual. Do - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 40
6 - Maintenance - Operator Maintenance 36 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 41
Maximum trim width: 380mm (no trim); 378mm (trimmed) Maximum side trim: 40mm each side Minimum side trim: 1mm each side Watkiss P2T 2-Knife Trimmer User Manual 37 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 42
can radiate radio frequency energy and, if not installed and used in accordance with the instruction manual, may cause harmful interference to radio communications. Operation of this equipment in a residential area this product at any time without notice. 38 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 43
/EC and 2008/35/EC Reach: REGULATION (EC) No. 1907/2006 M C Watkiss Technical Director, Watkiss Automation Ltd. 30 September 2016 Watkiss P2T 2-Knife Trimmer User Manual 39 - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 44
8 - Declaration of Conformity - 40 Watkiss P2T 2-Knife Trimmer User Manual - Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 45
- Konica Minolta AccurioPress C14000 | Watkiss PowerSquare 2-Knife Trimmer User Ma - Page 46
Watkiss Automation Limited 1 Blaydon Road Middlefield Industrial Estate Sandy, Bedfordshire SG19 1RZ United Kingdom Tel: +44 (0)1767 685700 Fax: +44 (0)1767 689900
Watkiss P2T 2-Knife Trimmer
User Manual
English, Issue 1a, October 2016