Weber Genesis Silver C NG Owner Manual
Weber Genesis Silver C NG Manual
 |
View all Weber Genesis Silver C NG manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Genesis Silver C NG manual content summary:
- Weber Genesis Silver C NG | Owner Manual - Page 1
them for future use. THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONLY. ƽ WARNING: Do not try to light this appliance without reading the "Lighting" Instructions section of this manual YOU MUST READ THIS OWNERS GUIDE BEFORE OPERATING YOUR GAS GRILL A006.f B006.e C096.b D006.e 55022 03/28/01 - Weber Genesis Silver C NG | Owner Manual - Page 2
before use. See instructions in this manual for correct procedures. ƽ Do not operate the Weber gas barbecue if there under the barbecue. ƽ Your Weber Gas Barbecue should never be used by children. Accessible parts of the barbecue may be very problem yourself. 3. Call your fire department. A-2 - Weber Genesis Silver C NG | Owner Manual - Page 3
, they are defective. Before returning any parts, contact the Customer service representative in your region using the contact information sheet provided with your manual. If Weber confirms the defect and approves the claim, Weber will elect to replace such parts without charge. If you are required - Weber Genesis Silver C NG | Owner Manual - Page 4
Contents Danger & Warnings A-2 Warranty A-3 General Instructions A-5 Exploded View A-6 Parts List A-9 Assembly Instructions B-1 Installing Features C-1 Operating D-1 Lighting D-1 Manual Lighting D-2 Lighting the side Burner D-3 Cooking D-4 Storage and/or Nouse D-4 Cleaning D-4 Annual - Weber Genesis Silver C NG | Owner Manual - Page 5
instructions will give you the minimum requirements for assembling your Weber Gas Barbecue. Please read the instructions carefully before using your Weber isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping - Weber Genesis Silver C NG | Owner Manual - Page 6
1 Genesis Silver-C NG 032801 2 3 27 28 4 29 5 6 30 31 7 32 33 8 34 9 35 10 36 11 12 37 13 38 39 14 40 15 41 42 16 43 17 44 18 45 19 33 46 20 21 47 22 23 48 24 49 25 50 26 A-6 - Weber Genesis Silver C NG | Owner Manual - Page 7
Knobs 31. Control Panel 32. Ignitor Button 33. Control Panel Hardware 34. Side Burner 35. Crossover tube 36. Front and Back Burners 37. Center Burner 38. Manifold Hardware 39. Manifold 40. Manifold Support Bracket 41. Disposable Drip Pan 42. Back Panel 43. 1/4-20 x 1/2 inch bolts 44. Igniter 45 - Weber Genesis Silver C NG | Owner Manual - Page 8
-Stephen Products Co., Weber, the silhouette, and the kettle configuration are registered trademarks ® of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL, 60067-6266, U.S.A. This product is covered by one or more United States patents and patents in - Weber Genesis Silver C NG | Owner Manual - Page 9
Screwdriver Phillips screwdriver Hammer 7/16 open-end or an adjustable wrench Pliers Block of wood Lid - 1 ® ® Left Frame - 1 Right Frame - 1 Wheel Frame - 1 Caster Frame - 1 Frame Connectors - 2 Side Burner - 1 Cooking Box - 1 Left Trim Piece - 1 Right Trim Piece - 1 Work Surface - 1 Cooking - Weber Genesis Silver C NG | Owner Manual - Page 10
Warming Rack - 1 Warm-Up Basket - 1 Flavorizer Bars - 5 Front Panel - 1 Back Panel - 1 Bottom tray - 1 Catch Pan Holder - 1 Catch-Pan - 1 Disposable Drip Pans - 2 Thermometer - 1 Wheels - 2 Casters - 2 Burner Control Knobs - 3 Hinge Pins (1/4 x 1 1/2 inch clevis pin) - 2 2 inch bolts (1/4 x 20 x 2 - Weber Genesis Silver C NG | Owner Manual - Page 11
Assembly Instructions WE B Assemble wheel frame You will need: axle rod, two wheel hubcaps, two wheels, wheel frame, one hubcap onto the end of the axle rod. Slide one wheel onto the axle, WEBER name facing out. Next, slide the other end of the axle rod through the wheel frame. Add the other wheel - Weber Genesis Silver C NG | Owner Manual - Page 12
Continue frame assembly You will need: caster frame and wheel frame. Place the caster frame onto the tabs of the left frame, so that the swing table locking bracket (1) is to the rear. Place the wheel frame onto the tabs of the right frame, so that the swing table locking bracket is to the rear (2). - Weber Genesis Silver C NG | Owner Manual - Page 13
), 2 inch bolt, nylon washer, keps nut, pliers and a 7/16 inch or adjustable wrench. Place the cooking box (assembly) in the frame assembly so the burner tubes(1) are under the frame brace(2). (1) (2) B-3 - Weber Genesis Silver C NG | Owner Manual - Page 14
Your Weber Gas Grill the left rear and left front of the cooking box? The screws are only guides. Do not tighten. 2) Do the valves fit into the ends of the burners . Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. Do not use - Weber Genesis Silver C NG | Owner Manual - Page 15
grams of hydrogen sulfide per 100 cubic feet of gas. I Plastic tubing is suitable only for outdoor, underground use. I Gas piping in top of the igniter up through the large part of the keyhole in the frame brace. Slide the igniter into the small part of the keyhole. 3) Tighten the igniter lock - Weber Genesis Silver C NG | Owner Manual - Page 16
Check that all burner valves are off You will need: burner control knobs. Valves are shipped in the OFF position, but you should check to be sure that they are turned OFF. Put the knob on each valve. Check by pushing down and turning clockwise. If they do not turn, they are off. Proceed to the next - Weber Genesis Silver C NG | Owner Manual - Page 17
Install Lid You will need: lid, two hair pin cotters(1) and two hinge pins(2). Place lid on top of the cooking box. Align the hinges at the rear of the barbecue. Insert hinge pins through the hinges from the outside. Insert hair pin cotters into the small holes in the hinge pins. (1) (2) Install - Weber Genesis Silver C NG | Owner Manual - Page 18
Installing Features Install the right trim piece with tool holders You will need: Right trim piece with tool holders Push the Right trim piece into the frame as shown(1), making sure that the tabs on the underside of the trim piece are snapped into the slots in the frame.(2) (1) Install the left - Weber Genesis Silver C NG | Owner Manual - Page 19
3.) Insert one end of the swing-up work surface rod into the hole in the frame. 5.) Add a washer to each bolt and insert it through the hole in the frame and the hole in the trim piece on both sides. Tighten with a wrench. 4.) While holding swing-up work surface in position, insert the other end - Weber Genesis Silver C NG | Owner Manual - Page 20
Install the work surface You will need: work surface. Place the work surface, so that the front and back edges fit over the frame, in the area between the left trim piece and the cooking box as shown. Do not use the work surface as a cutting board. Set the side burner in place in the frame. The - Weber Genesis Silver C NG | Owner Manual - Page 21
in the cooking box with the rounded sides up. Installing the Warm-Up" Basket You will need: Warm-Up Basket Insert one end of the Weber Warm-Up Basket into the hole at the right side of the inside of the lid, and the other end into the slot at the - Weber Genesis Silver C NG | Owner Manual - Page 22
for gas leaks. The burners have been flame-tested. As a safety precaution however, you should recheck all fittings for leaks before using your Weber Gas Barbecue. Shipping and handling may loosen or damage a gas fitting. ƽ WARNING: Perform these leak checks even if your barbecue was dealer or - Weber Genesis Silver C NG | Owner Manual - Page 23
a leak at connections(2),(3),(4) or(5), turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. When leak checks are complete, turn gas supply OFF at the source and rinse connections with - Weber Genesis Silver C NG | Owner Manual - Page 24
Operating Lighting Summary lighting instructions are on the control panel. ƽ DANGER Failure the barbecue. Replace using only Weber authorized replacement hose. Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. 1 1) Open the lid - Weber Genesis Silver C NG | Owner Manual - Page 25
Manual Lighting ƽ DANGER Failure to open lid while igniting the barbecue's burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does - Weber Genesis Silver C NG | Owner Manual - Page 26
Lighting the Side Burner The side burner has a separate ignition system from the main cooking box. ƽ DANGER Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flame-up which can - Weber Genesis Silver C NG | Owner Manual - Page 27
(medium). Refer to your Weber cookbook for detailed cooking instructions. Note: The temperature inside Service Representative in your region using the contact information sheet provided with your manual cooking module - Brush any debris off of burner tubes. DO NOT ENLARGE BURNER PORTS (OPENINGS). Wash - Weber Genesis Silver C NG | Owner Manual - Page 28
the burner to get debris and dirt out of the burner tube. Once the spider/insect screens and burners are clean replace the burners. If the spider/insect screen becomes damaged or cannot be cleaned, call Weber-Stephen Products Customer Service for replacement parts. provided with your manual. D-5 - Weber Genesis Silver C NG | Owner Manual - Page 29
General Maintenance Weber Spider /Insect screens Your Weber Gas Barbecue, as well as any outdoor gas appliance with a stainless steel screen(1) to prevent spiders and other insects access to the burner tubes through the air shutter openings. (1) We recommend that you inspect the Spider/Insect screens - Weber Genesis Silver C NG | Owner Manual - Page 30
shown. 1) Burner tube 2) Tips occasionally flicker yellow 3) Light blue 4) Dark blue (1) (2) (3) (4) Replacing Main Burners 1) Your Weber Gas Barbecue must be a flashlight. (2) 5) Slide the burner assembly out from under the guide screw and washer(1) in the corners of the cooking box. (1) Clean - Weber Genesis Silver C NG | Owner Manual - Page 31
twist the burner assembly slightly, to separate the crossover tube(1) from the burners. Remove the burners from the cooking fails to light, Contact the Customer Service Representative in your region using the contact information sheet provided with your manual. ƽ WARNING: After reinstalling the gas - Weber Genesis Silver C NG | Owner Manual - Page 32
Troubleshooting Problem on HIGH. Flames do not run the whole length of the burner tube. Are burners clean? Clean burners. (See Section "General Maintenance".) "Cleaning".) If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your region - Weber Genesis Silver C NG | Owner Manual - Page 33
ƽ WARNING: Before attempting any troubleshooting steps, all gas controls and supply valves should be in the OFF position. Problem Side Burner does not light. Check Is gas supply off? Cure Turn supply on. Flame is low in HIGH position. Is the fuel hose bent
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
 |
 |
±
WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These
instructions must be left with the owner
and the owner should keep them for future
use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
±
WARNING: Do not try to light this
appliance without reading the “Lighting”
Instructions section of this manual
±
WARNING
1.
Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2.
Do not store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
55022 03/28/01
Natural Gas
±
DANGER
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flames.
3.
Open lid
4.
If odor continues, keep away from the
appliance and immediately call your
gas supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
A006.f
B006.e
C096.b
D006.e
W
E
B
E
R
W
E
B
E
R
Owners Guide
Y
OU
MUST
READ
THIS
O
WNERS
G
UIDE
BEFORE
OPERATING
YOUR
GAS
GRILL