Home » Ford Manuals » 2007 Ford F350 » Manual Viewer

2007 Ford F350 Owner Guide 2nd Printing - Page 250

2007 Ford F350 Manual

Get 2007 Ford F350 PDF manuals and user guides

View all 2007 Ford F350 manuals

Page 250 highlights

Cleaning • Never wash or rinse the engine while it is running; water in the running engine may cause internal damage. • Cover the highlighted areas to prevent water damage when cleaning the engine. • 5.4L V8 gasoline engine • 6.8L V10 gasoline engine PLASTIC (NON-PAINTED) EXTERIOR PARTS Use only approved products to clean plastic parts. These products are available from your authorized dealer. 250 2007 F-250/350/450/550 (f23) Owners Guide (post-2002-fmt) USA (fus)

Section	Page
Table of Contents	1
Introduction	4
CONGRATULATIONS	4
SAFETY AND ENVIRONMENT PROTECTION	5
Warning symbols in this guide	5
Warning symbols on your vehicle	5
Protecting the environment	5
BREAKING-IN YOUR VEHICLE	5
SPECIAL NOTICES	6
New Vehicle Limited Warranty	6
Service Data Recording	6
Event Data Recording	6
Vehicle Modification Data Recording	6
Special instructions	7
Cell phone use	7
Notice to owners of diesel-powered vehicles	8
Notice to owners of pickup trucks and utility type vehicles	8
Using your vehicle with a snowplow	8
Using your vehicle as an ambulance	8
Using your vehicle as a stationary power source (PTO)	9
Middle East/North Africa vehicle specific information	9
Instrument Cluster	12
WARNING LIGHTS AND CHIMES	12
GAUGES	16
Entertainment Systems	21
AUDIO SYSTEMS	21
AM/FM stereo system (if equipped)	21
AM/FM stereo/single CD with satellite compatible sound system (if equipped)	23
Premium in-dash six CD/satellite compatible sound system (if equipped)	28
GENERAL AUDIO INFORMATION	32
Satellite radio information (if equipped)	34
Climate Controls	38
HEATER ONLY SYSTEM (IF EQUIPPED)	38
Operating tips	38
MANUAL HEATING AND AIR CONDITIONING SYSTEM (IF EQUIPPED)	39
Operating tips	40
AUTOMATIC TEMPERATURE CONTROL SYSTEM (IF EQUIPPED)	41
Operating tips	43
Lights	44
HEADLAMP CONTROL	44
Autolamp control (if equipped)	44
Foglamp control (if equipped)	45
Daytime running lamps (DRL) (if equipped)	45
High beams	46
Flash to pass	46
PANEL DIMMER CONTROL	46
AIMING THE HEADLAMPS	47
Vertical and horizontal aim adjustment (sealed beam headlamps)	47
Vertical aim adjustment (aerodynamic headlamps)	49
TURN SIGNAL CONTROL	50
COURTESY/READING LAMPS (IF EQUIPPED)	50
MAP LAMPS (IF EQUIPPED)	50
BULBS	51
Headlamp condensation	51
Replacing exterior bulbs	51
Replacing headlamp bulbs (aerodynamic)	52
Replacing park/turn and sidemarker lamp bulbs (aerodynamic)	53
Replacing headlamp bulbs (sealed beam)	54
Replacing park/turn/sidemarker bulbs (sealed beam)	55
Replacing brake/tail/turn/back-up lamp bulbs - F–250/F–350 only	56
Replacing brake/tail/turn/back-up lamp bulbs - F–450/F–550 only	56
Replacing cargo lamp and high-mount brakelamp bulbs	57
Front clearance and identification lamp bulbs	57
Replacing foglamp bulbs (if equipped)	57
Replacing license plate lamp bulbs	58
Driver Controls	59
MULTI-FUNCTION LEVER	59
TILT STEERING WHEEL (IF EQUIPPED)	59
TRANSMISSION CONTROL	60
ILLUMINATED VISOR MIRROR (IF EQUIPPED)	60
OVERHEAD CONSOLE (IF EQUIPPED)	60
Storage compartment (if equipped)	61
AUXILIARY POWER POINT (12VDC)	61
POWER WINDOWS (IF EQUIPPED)	62
One touch down	62
Window lock (if equipped)	63
Power rear slider window (if equipped)	63
Accessory delay (if equipped)	63
AUTOMATIC DIMMING INSIDE REAR VIEW MIRROR (IF EQUIPPED)	63
POWER SIDE VIEW MIRRORS (IF EQUIPPED)	64
Heated outside mirrors (if equipped)	64
Mirror mounted side turn signal indicator (if equipped)	65
Clearance lamps (if equipped)	65
Fold-away mirrors	65
POWER ADJUSTABLE FOOT PEDALS (IF EQUIPPED)	66
SPEED CONTROL (IF EQUIPPED)	66
Setting speed control	66
Resuming a set speed	67
Increasing speed while using speed control	67
Reducing speed while using speed control	68
Turning off speed control	68
Indicator light (if equipped)	68
STEERING WHEEL CONTROLS (IF EQUIPPED)	69
Radio control features	69
Climate control features	69
UPFITTER CONTROLS (IF EQUIPPED)	69
ONE-TOUCH MOON ROOF (IF EQUIPPED)	71
CENTER CONSOLE (IF EQUIPPED)	72
MINI-MESSAGE CENTER (IF EQUIPPED)	72
MESSAGE CENTER (IF EQUIPPED)	74
Selectable features	75
Reset	75
Info menu	75
Odometer/Trip odometer	75
Distance to empty (DTE)	75
Average fuel economy (AFE)	76
Compass display	76
Compass zone/calibration adjustment	77
Engine hour meter	78
Setup menu	78
System check	78
Units (English/Metric)	79
Autolocks	79
Autolamp delay	79
Language	79
System warnings	80
TAILGATE LOCK (IF EQUIPPED)	83
Tailgate removal	84
Locks and Security	85
KEYS	85
POWER DOOR LOCKS (IF EQUIPPED)	85
Smart locks (if equipped)	85
Autolock (if equipped)	85
Relock	86
To deactivate/reactivate the autolock feature using the keypad	86
To deactivate/reactivate the autolock feature using the power door unlock control	86
CHILDPROOF DOOR LOCKS (IF EQUIPPED)	87
REMOTE ENTRY SYSTEM (IF EQUIPPED)	87
Unlocking the doors	88
Locking the doors	88
Power door lock disable feature (if equipped)	89
Sounding a panic alarm	89
Replacing the battery	89
Replacing lost remote entry transmitters	90
How to reprogram your remote entry transmitters	90
Illuminated entry	91
KEYLESS ENTRY SYSTEM (IF EQUIPPED)	92
Programming a personal entry code	92
Erasing personal code	93
Anti-scan feature	93
Unlocking and locking the doors using keyless entry	93
Seating and Safety Restraints	94
SEATING	94
Adjustable head restraints (if equipped)	94
Full bench seat (if equipped)	95
Captain’s chair (if equipped)	97
Adjusting the front power seat (if equipped)	97
Using the manual lumbar support	99
Heated seats (if equipped)	99
REAR FOLDING SEAT SYSTEM WITH LOAD FLOOR (IF EQUIPPED)	100
SAFETY RESTRAINTS	101
Safety restraints precautions	101
Combination lap and shoulder belts	103
Vehicle sensitive mode	103
Automatic locking mode	104
When to use the automatic locking mode	104
How to use the automatic locking mode	104
How to disengage the automatic locking mode	104
Energy Management Feature	105
Front safety belt height adjustment	105
Lap belts	106
Adjusting the lap belt	106
Safety belt warning light and indicator chime	107
Conditions of operation	108
BeltMinder	108
One time disable	110
Deactivating/activating the BeltMinder feature	110
Safety belt extension assembly	112
Safety belt maintenance	112
AIRBAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS)	113
Important SRS precautions	113
Children and airbags	114
How does the airbag supplemental restraint system work?	115
Determining if the system is operational	116
Disposal of airbags and airbag equipped vehicles	117
Passenger airbag ON/OFF switch (if equipped)	117
Turning the passenger airbag off	117
Turning the passenger airbag back on	118
NHTSA deactivation criteria (excluding Canada)	119
Transport Canada deactivation criteria (Canada Only)	120
SAFETY RESTRAINTS FOR CHILDREN	121
Important child restraint precautions	121
Children and safety belts	122
Child booster seats	122
Types of booster seats	123
SAFETY SEATS FOR CHILDREN	125
Child and infant or child safety seats	125
Installing child safety seats with combination lap and shoulder belts	126
Attaching child safety seats with tether straps	129
Tether strap attachment (rear SuperCab only)	131
Tires, Wheels and Loading	133
NOTICE TO UTILITY VEHICLE AND TRUCK OWNERS	133
VEHICLE CHARACTERISTICS	133
How your vehicle differs from other vehicles	134
INFORMATION ABOUT UNIFORM TIRE QUALITY GRADING	135
Treadwear	135
Traction AA A B C	136
Temperature A B C	136
TIRES	136
Glossary of tire terminology	136
INFLATING YOUR TIRES	137
Tire inflation information	140
TIRE CARE	141
Inspecting your tires	141
Tire wear	142
Damage	142
U.S. DOT Tire Identification Number (TIN)	143
Tire replacement requirements	143
Safety practices	144
Highway hazards	145
Tire and wheel alignment	145
Tire rotation	145
INFORMATION CONTAINED ON THE TIRE SIDEWALL	147
Information on “P” type tires	148
Additional information contained on the tire sidewall for “LT” type tires	151
Information on “T” type tires	152
Location of the Tire Label or Safety Compliance Certification Label	152
SNOW TIRES AND CHAINS	153
VEHICLE LOADING – WITH AND WITHOUT A TRAILER	153
Special loading instructions for owners of pickup trucks and utility-type vehicles	159
TRAILER TOWING	160
Preparing to tow	161
Hitches	161
Integrated hitch rating	162
Weight distributing hitch	163
Safety chains	163
Trailer brakes	163
Integrated trailer brake controller (if equipped)	164
Trailer lamps	167
Using a step bumper (if equipped)	167
Driving while you tow	168
Servicing after towing	168
Trailer towing safety tips	168
General	168
Loading	169
Braking	169
Backing up	169
Tires	170
Launching or retrieving a boat	170
RECREATIONAL TOWING	170
Driving	172
STARTING	172
Positions of the ignition	172
Preparing to start your vehicle	172
Important safety precautions	173
Starting the engine	176
Guarding against exhaust fumes	176
Important ventilating information	177
USING THE ENGINE BLOCK HEATER (IF EQUIPPED)	177
BRAKES	177
Four-wheel anti-lock brake system (ABS)	178
ABS warning lamp	178
Using ABS	178
Parking brake	179
STEERING	180
TRACTION-LOK AXLE (IF EQUIPPED)	181
PREPARING TO DRIVE YOUR VEHICLE	181
AUTOMATIC TRANSMISSION OPERATION (IF EQUIPPED)	182
Brake-shift interlock	182
Understanding the shift positions of the 5–speed automatic transmission	183
If your vehicle gets stuck in mud or snow	185
MANUAL TRANSMISSION OPERATION (IF EQUIPPED)	185
Using the clutch	185
Recommended shift speeds	186
Reverse	187
Parking your vehicle	187
Removing the key	188
REVERSE SENSING SYSTEM (IF EQUIPPED)	188
FOUR-WHEEL DRIVE (4WD) OPERATION (IF EQUIPPED)	190
Manual Shift On Stop (MSOS) 4x4 system (if equipped)	190
Electronic Shift On the Fly (ESOF) 4x4 system (if equipped)	190
Using a Manual Shift On Stop (MSOS) 4WD system (if equipped)	192
Shifting from 2H (2WD High) to 4H (4WD High)	192
Shifting from 4H (4WD High) to 2H (2WD High)	193
Shifting from 4H (4WD High) to 4L (4WD Low)	193
Shifting from 4L (4WD Low) to 4H (4WD High) or 2H (2WD High)	193
Using the N (Neutral) position	194
Using the Electronic Shift On the Fly (ESOF) 4WD system (if equipped)	194
Positions of the electronic shift system	194
Shifting from 2WD (2WD High) to 4x4 HIGH (4WD High)	195
Shifting from 4x4 HIGH (4WD High) to 2WD (2WD High)	195
Shifting from 4x4 HIGH (4WD High) to 4x4 LOW (4WD Low)	195
Shifting from 4x4 LOW (4WD Low) to 4x4 HIGH (4WD High) or 2WD (2WD High)	196
Driving off-road with truck and utility vehicles	196
How your vehicle differs from other vehicles	196
Basic operating principles	197
If your vehicle goes off the edge of the pavement	197
If your vehicle gets stuck	198
Emergency maneuvers	198
Parking	199
Normal characteristics	200
Sand	200
Mud and water	200
Driving on hilly or sloping terrain	201
Driving on snow and ice	202
Maintenance and Modifications	203
VEHICLE USED AS A STATIONARY POWER SOURCE	203
DRIVING THROUGH WATER	204
SNOWPLOWING	204
Installing the snowplow	204
Operating the vehicle with the snowplow attached	205
Snowplowing with your airbag-equipped vehicle	205
Transmission operation while plowing	206
Removing the snowplow frame mount	207
Roadside Emergencies	208
ROADSIDE ASSISTANCE	208
Getting roadside assistance	208
Using roadside assistance	209
Roadside coverage beyond basic warranty	209
HAZARD FLASHER	210
FUEL PUMP SHUT-OFF SWITCH	210
FUSES AND RELAYS	211
Fuses	211
Standard fuse amperage rating and color	212
Passenger compartment fuse panel	212
Power distribution box	217
Relays	220
CHANGING A FLAT TIRE	220
Dissimilar spare tire/wheel information	220
T-type/Mini-spare tire information (Harley-Davidson only)	222
Location of the spare tire and tools	223
Removing the spare tire (with spare tire carrier only)	223
Tire change procedure	225
Stowing the flat/spare tire	231
WHEEL LUG NUT TORQUE SPECIFICATIONS	232
JUMP STARTING YOUR VEHICLE	233
Preparing your vehicle	233
Connecting the jumper cables	234
Jump starting	235
Removing the jumper cables	236
WRECKER TOWING	238
Customer Assistance	240
GETTING THE SERVICES YOU NEED	240
At home	240
Away from home	240
Additional Assistance	241
IN CALIFORNIA (U.S. ONLY)	242
THE BETTER BUSINESS BUREAU (BBB) AUTO LINE PROGRAM (U.S. ONLY)	243
UTILIZING THE MEDIATION/ARBITRATION PROGRAM (CANADA ONLY)	244
FORD EXTENDED SERVICE PLAN	244
GETTING ASSISTANCE OUTSIDE THE U.S. AND CANADA	245
ORDERING ADDITIONAL OWNER’S LITERATURE	246
Obtaining a French owner’s guide	246
REPORTING SAFETY DEFECTS (U.S. ONLY)	246
REPORTING SAFETY DEFECTS (CANADA ONLY)	247
Cleaning	248
WASHING THE EXTERIOR	248
WAXING	248
PAINT CHIPS	249
ALUMINUM WHEELS AND WHEEL COVERS	249
ENGINE	249
PLASTIC (NON-PAINTED) EXTERIOR PARTS	250
WINDOWS AND WIPER BLADES	251
INSTRUMENT PANEL AND CLUSTER LENS	251
INTERIOR TRIM	252
INTERIOR	252
LEATHER SEATS (IF EQUIPPED, EXCEPT FOR THE KING RANCH F–250 AND F–350 CREWCAB)	252
LEATHER SEATS FOR THE KING RANCH F-250 AND F-350 CREWCAB ONLY (IF EQUIPPED)	253
UNDERBODY	254
FORD, LINCOLN AND MERCURY CAR CARE PRODUCTS	254
Maintenance and Specifications	256
SERVICE RECOMMENDATIONS	256
PRECAUTIONS WHEN SERVICING YOUR VEHICLE	256
Working with the engine off	256
Working with the engine on	256
OPENING THE HOOD	257
IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT	258
WINDSHIELD WASHER FLUID	260
CHANGING THE WIPER BLADES	260
ENGINE OIL	261
Checking the engine oil	261
Adding engine oil	263
Engine oil and filter recommendations	264
Use SAE 5W-20 engine oil	264
BATTERY	265
ENGINE COOLANT	267
Checking engine coolant	267
Adding engine coolant	268
Recycled engine coolant	270
Coolant refill capacity	271
Severe climates	271
What you should know about fail-safe cooling (if equipped)	272
How fail-safe cooling works	272
When fail-safe mode is activated	272
FUEL FILTER	273
WHAT YOU SHOULD KNOW ABOUT AUTOMOTIVE FUELS	273
Important safety precautions	273
Refueling	275
Fuel filler cap	275
Choosing the right fuel	276
Octane recommendations	277
Fuel quality	277
Cleaner air	277
Running out of fuel	278
ESSENTIALS OF GOOD FUEL ECONOMY	278
Measuring techniques	278
Filling the tank	278
Calculating fuel economy	279
Driving style — good driving and fuel economy habits	279
Habits	280
Maintenance	280
Conditions	280
EPA window sticker	281
EMISSION CONTROL SYSTEM	281
On board diagnostics (OBD-II)	282
Readiness for Inspection/Maintenance (I/M) testing	283
POWER STEERING FLUID	283
BRAKE FLUID	285
CLUTCH FLUID (IF EQUIPPED)	285
TRANSMISSION FLUID	286
Checking automatic transmission fluid (if equipped)	286
Low fluid level	287
Correct fluid level	287
High fluid level	287
Adjusting automatic transmission fluid levels	287
Automatic transmission fluid filter (if equipped)	288
Checking and adding manual transmission fluid (if equipped)	289
TRANSFER CASE FLUID (IF EQUIPPED)	290
DRIVELINE UNIVERSAL JOINT AND SLIP YOKE	290
AIR FILTER MAINTENANCE	290
Changing the air filter element	291
MOTORCRAFT PART NUMBERS	293
MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIES	294
ENGINE DATA	298
Drivebelt routing	298
IDENTIFYING YOUR VEHICLE	299
Safety Compliance Certification Label	299
Vehicle identification number (VIN)	299
TRANSMISSION/TRANSAXLE CODE DESIGNATIONS	300
Accessories	301
GENUINE FORD ACCESSORIES FOR YOUR VEHICLE	301
Exterior style	301
Interior style	302
Lifestyle	302
Peace of mind	302