2015 Polaris Sportsman Touring 850 SP Owners Manual - Page 138
2015 Polaris Sportsman Touring 850 SP Manual
Page 138 highlights
TROUBLESHOOTING Engine Doesn't Turn Over Possible Cause Low battery voltage Loose battery connections Loose solenoid connections Solution Recharge the battery to 12.8 VDC Check all connections and tighten Check all connections and tighten Engine Turns Over, Fails to Start Possible Cause Out of fuel Water is present in fuel Old or non-recommended fuel Fouled or defective spark plug(s) No spark to spark plug Water or fuel in crankcase Low battery voltage Mechanical failure Solution Refuel, cycle key to ON position three times for 5 seconds each, then start Drain the fuel system and refuel Replace with fresh recommended fuel Inspect plugs and replace if necessary Inspect plugs, verify stop switch is on Immediately see your POLARIS dealer Recharge the battery to 12.8 VDC See your dealer Engine Backfires Possible Cause Weak spark from spark plug Incorrect spark plug gap or heat range Old or non-recommended fuel Incorrectly installed spark plug wires Incorrect ignition timing Mechanical failure Loose ignition connections Water present in fuel Leaking exhaust components Solution Inspect, clean and/or replace spark plug(s) Set gap to specs or replace plugs Replace with fresh recommended fuel See your dealer See your dealer See your dealer Check all connections and tighten Replace with fresh recommended fuel See your dealer 136